Samsung S8300 Service Manual

GSM TELEPHONE

GT-S8300

GSM TELEPHONE

CONTENTS

Safety Precautions

Specification

Product Function

Array course control

Exploded View and Parts list

MAIN Electrical Parts List

Disassembly and Assembly

7. Instructions

Block Diagrams

PCB Diagrams

Chart of Troubleshooting

10.

Reference data

11.

Safety Precautions

Repair Precaution

1-1.

Repair in Shield Box, during detailed tuning.

●

Take specially care of tuning or test,

because specipicty of cellular phone is sensitive for surrounding interference(RF noise).

Be careful to useakind of magnetic object or tool,

●

because performance of parts is damaged by the influence of manetic force.

Surely useastandard screwdriver when you disassemble this product,

●

otherwise screw will be worn away.

Useathicken twisted wire when you measure level.

●

thicken twisted wire has low resistance, therefore error of measurement is few.

Repair after separate Test Pack and Set because for short danger(for example an

●

overcurrent and furious flames of parts etc) when you repair board in condition of

connecting Test Pack and tuning on.

Take specially care of soldering, because Land of PCB is small and weak in heat.

●

Surely tune on/off while using AC power plug, becausearepair of battery charger is

●

dangerous when tuning ON/OFF PBA and Connector after disassembing charger.

Don't use as you pleases after change other material than replacement registered on SEC

●

System.

Otherwise engineer in charge isn't charged with problem that you don't keep this rules.

1-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Safety Precautions

ESD(Electrostatically Sensitive Devices) Precaution

1-2.

Several semiconductor may be damaged easilly by static electricity. Such parts are called by

ESD(Electrostatically Sensitive Devices), for example IC,BGA chip etc. Read Precaution below.

You can prevent from ESD damage by static electricity.

Remove static electricity remained your body before you touch semiconductor or parts with

●

semiconductor. There are ways that you touch an earthed place or wear static electricity

prevention string on wrist.

Use earthed soldering steel when you connect or disconnect ESD.

●

Use soldering removing tool to break static electricity.,otherwise ESD will be damaged by

●

static electricity.

Don't unpack until you set up ESD on product. Because most of ESD are packed by box

●

and aluminum plate to have conductive power,they are prevented from static electricity.

You must maintain electric contact between ESD and place due to be set up until ESD is

●

connected completely to the proper place oracircuit board.

1-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Specification

GSM

2-1.

Freq.

Band(MHZ)

Uplink/Downli

ARFCN

range

Tx/Rx

spacing

Mod. Bit rate/

Bit Period

Time slot

Period/Frame

Period

850&900/

GSM

824~849 869~894

128~251

270.833

3.692

576.9

4.615

DCS1800/PCS1900 General Specification

850

MHz

kbps us

EGSM

Phase

880~915 925~960

0~124 &

975~1023

MHz

270.833

3.692

576.9

4.615

900

kbps us

DCS1800

Phase

1710~1785 1805~1880

512~885 512~810

270.833

3.692

576.9

4.615

MHz

kbps us

PCS

1850~1910 1930~1990

270.833

3.692

576.9

4.615

1900

MHz

kbps us

WCDMA

2100

1920 ~ 1980 2110 ~ 2170

:9612~ 9888

: 10562 ~ 10838

MHz

190

Mcps

3.84

WCDMA

900

880 ~ 915 925 ~ 960

:2712~ 2863

:2937~ 3088

MHz

Mcps

3.84

Modulation

MS Power

Power Class Class

Sensitivity

TDMA Mux

Cell Radius

GMSK

0.3

dBm

-102

8888- -

dBm

GMSK

0.3

Class

-102

dBm dBm

dBm

GMSK

0.3

dBm~0dBm30dBm~0dBm

Class

dBm

-102

GMSK

0.3

Class

-102

---

dBm

UL:BPSK DL:QPSK

Max

:24

Min

:-50

Class

-106.7

dBm

dBm dBm

UL:BPSK DL:QPSK

Max

:24

Min

:-50

Class

-103.7

dBm

dBm dBm

2-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Specification

GSM TX power class

2-2.

TX POWER

LEVEL CONTOL

533±2

631±2

729±2

827±2

925±2

10 23±2

11 21±2

12 19±2

EGSM

850/900

dBm

TX POWER

LEVEL CONTOL

030±3

128±3

226±3

324±3

422±3

520±3

618±3

716±3

DCS

1800

dBm

TX POWER

LEVEL CONTOL

030±3

128±3

226±3

324±3

422±3

520±3

618±3

716±3

PCS

1900

dBm

13 17±2

14 15±2

15 13±2

16 11±3

17 9±3

18 7±3

19 5±3

dBm

814±3

912±3

10 10±4

11 8±4

12 6±4

13 4±4

14 2±5

15 0±5

dBm

814±3

912±3

10 10±4

11 8±4

12 6±4

13 4±4

14 2±5

15 0±5

dBm

2-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Product Function

Main Function

Innovative Clean-back Slider Design Slider

Hybrid User interface(full touch

Accelerometer(Auto Rotate Display)

Mega Pixel AF Camera with Wide Preview&Capture

-8

-2.8

inch SMS/MMS(OMA GPS Navigation(On-board, Off-board), Google Map E-mail(POP3/IMAP4/SMTP, SSL) WAP MP3/AAC/AAC+/eAAC+/WMA/AMR/MIDI/SP-MIDI/i-melody/WAV/MMF MPEG4/H.263/H.264/WMV JPEG/GIF/A-GIF/PNG/WBMP/Flash/SVG-T/TIFF GSM Phase Quad Band(EGSM850/900/DCS/PCS), UMTS MicroSD Card Support USB v2.0 High Speed, Bluetooth v2.1 FMRadiowithRDS(BT+FM One chip) SyncML DS v.1.1 Local/Net. Sync. MS Outlook(Express) Exchangeable

2.0

240

Full HTML Browser(NF3.5), HTTP, OTA provisioning supported

2+/

WQVGA

400

v1.2),

Class

Video Messaging(H.263+AMR), Unified inbox(SMS/MMS)

EDGE,3GPP Rel.

12,

X4 keypad)

WQVGA AMOLED

16M

Cat.6 HSDPA

900/2100

7.2

MHz+GPS

Mbps

1.575

GHz

Dictionary(English-Regional Language), Mobile Blog(Samsung)

Mobile Printing BPP, OPP, PictBridge(USB printing)

3-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array Course Control

Software Adjustments

4-1.

Test Jig(GH99

RF Test Cable(GH

-36900

39-00985

Test Cable(GH

Adapter(GH

39-01160

99-38251

4-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array Course Control

Software Downloading

4-2.

4-2-1.

4-2-2.

■

Pre-requsite for Download

Downloader Program(

•

GT-S8300 Mobile Phone

•

Micro USB Data Link Cable

•

Binary file

•

Multiloader V5.44.exe

)

S/W Download Process

Load the binary download program by executing the

Execute the download SW, Multiloader.exe.

Boot the S8300 by pressing

if you do properly, you can see the'DOWMLOAD' in the middle of the screen.

'#9'+'

Power ON Key'at the same time.

Connect the Micro USB data cable to the S8300.

Press'Port Search', then'Port' is activated.

“Multiloader V5.44.exe”

4-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array Course Control

Choose MSM6275/MSM6280 and check'Full Download', then All buttons will be

activate exept Apps button.

4-3

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array Course Control

Click the'Boot', then the dialogue box is opened. Select the wanted directory, and

press'OK'.

4-4

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Click'Amss','Rsrc1','Rsrc2','Factory FS' each, and select wanted files.

Array Course Control

4-5

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array Course Control

Click'Download', then downloading is executed successively.If the download

is completed, S/W downloading is finished.

Download time:about4minutes

(

)

4-6

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Exploded View and Parts List

5-1.

QFU01

QME03

QLC01

QSP01

QCA01

QCA02

Cellular phone Exploded View

QSH04

QKP02

QSH01

QSC01

QPC01

QCR72

QSC02

QMP01

QMI03

QCR72

QAN02

QBK01

QFL04

QCR72

QFR01

QHI01

QFL01

QFR02

QVO01

QRF06

QCK01

QRE01

QCR60

QBA00

5-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Exploded View and Parts List

5-2.

Cellular phone Parts list

Design LOC Description SEC CODE

QAN02 INTENNA-GT_S8300 MAIN GH42-01913A

QBA00 PMO CASE-BATT GH72-51431A

QBK01 ASSY COVER-BACK GH98-11251A

QCA01 CAMERA MODULE-GT_S8300

GH59-06746A

QCA02 CAMERA MODULE-GT_S8300 CIF GH59-07028A

QCR60 SCREW-MACHINE

QCR72 SCREW-MACHINE

6001-002005

6001-002051

QFL04 PMO CASE-LOWER DUMMY GH72-51429A

QFU01 ASSY CASE-UPPER GH98-11240A

QKP02 ASSY KEYPAD-SUB(ZK/XEU) GH98-11250A

QLC01 ASSY LCD-GT_S8300 GH96-03549A

QME03 TOUCH/PANEL GH59-06720A

QMI03 RUBBER HOLDER-MIC GH73-12452A

QMP01 A/S ASSY-GT_S8300 PBA MAIN GH82-03495A

QPC01 ASSY ETC-GT_S8300 SLIDE FPCB GH59-06883A

QSC01 TAPE-SCREW SHEET

QSC02 TAPE-SCREW SHEET

GH74-43174A

GH74-43175A

QSH01 IPR COVER-SHIELD GH70-04613A

QSH04 ASSY COVER-SHIELD FRONT GH98-11719A

QSP01 MODULE-GT_S8300 SPK+MOT GH59-06903A

QFR01 ASSY CASE-FRONT LOWER GH98-11242A

QFR02 ASSY CASE-FRONT GH98-11243A

QFL01 ASSY CASE-LOWER GH98-11247A

QHI01 ASSY HINGE-ACTUATOR BODY GH98-11248A

QRE01 ASSY CASE-REAR GH98-11241A

QRF06 PMO COVER-MICRO USB GH72-51432A

QVO01 PMO KEY-VOLUME GH72-51453A

QCK01 ASSY KEY-CAM GH98-11253A

5-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

MAIN Electrical Parts List

SEC CODE Design LOC Discription 0403-001547 0406-001190 0406-001267 0406-001267 0406-001267 0406-001267 0406-001267 0406-001286 0406-001286 0406-001286 0406-001286 0406-001286 0406-001286 0406-001293 0406-001293 0406-001293 0406-001324 0406-001330 0504-001151 0504-001151 0801-003013 0801-003065 1001-001394 1001-001394 1001-001481 1001-001488 1001-001546 1001-001586 1003-002047 1009-001035 1108-000237 1201-002581 1201-002736 1201-002775 1201-002821 1201-002830

D600 DIODE-ZENER ZD700 DIODE-TVS ZD200 DIODE-TVS ZD300 DIODE-TVS ZD400 DIODE-TVS ZD600 DIODE-TVS ZD601 DIODE-TVS ZD701 DIODE-TVS ZD702 DIODE-TVS ZD703 DIODE-TVS ZD704 DIODE-TVS ZD705 DIODE-TVS ZD706 DIODE-TVS ZD707 DIODE-TVS ZD708 DIODE-TVS ZD709 DIODE-TVS

D601 DIODE-TVS

U601 DIODE-TVS

U200 TR-DIGITAL

U201 TR-DIGITAL

U300 IC-CMOS LOGIC

U401 IC-CMOS LOGIC

U502 IC-ANALOG SWITCH

U607 IC-ANALOG SWITCH

U600 IC-ANALOG SWITCH

U603 IC-ANALOG SWITCH

U501 IC-ANALOG SWITCH

U602 IC-ANALOG MULTIPLEX

U604 IC-MOTOR DRIVER

U700 IC-HALL EFFECT S/W

UME300 IC-MCP

F206 IC-RF AMP

U500 IC-AUDIO AMP

PAM201 IC-POWER AMP PAM200 IC-POWER AMP PAM100 IC-POWER AMP

6-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Discription 1203-005367 1203-005448 1203-005690 1204-002924 1205-003297 1205-003498 1205-003517 1205-003611 1209-001831 1404-001224 1405-001221 2007-000138 2007-000144 2007-000162 2007-000162 2007-000170 2007-000566 2007-001285 2007-001285 2007-001290 2007-001308 2007-003010 2007-003010 2007-007310 2007-007488 2007-007741 2007-008045 2007-008045 2007-008045 2007-008045 2007-008046 2007-008046 2007-008046 2007-008047 2007-008047 2007-008049

U605 IC-POSI.FIXED REG. U400 IC-POWER SUPERVISOR U402 IC-DC/DC CONVERTER U100 IC-TUNER U202 IC-TRANSCEIVER

UCP301 IC-MODEM

U101 IC-BLUETOOTH U606 IC-SWITCH

U701 IC-SENSOR VR300 THERMISTOR-NTC VR400 VARISTOR

R600 R-CHIP

R416 R-CHIP

R507 R-CHIP

R611 R-CHIP

R518 R-CHIP

R615 R-CHIP

R211 R-CHIP

R213 R-CHIP

R520 R-CHIP

R401 R-CHIP

R509 R-CHIP

R513 R-CHIP

R510 R-CHIP

R413 R-CHIP

R309 R-CHIP

R315 R-CHIP

R429 R-CHIP

R500 R-CHIP

R613 R-CHIP

R117 R-CHIP

R119 R-CHIP

R210 R-CHIP

R112 R-CHIP

R114 R-CHIP

R100 R-CHIP

6-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

SEC CODE Design LOC Discription 2007-008049 2007-008049 2007-008050 2007-008052 2007-008052 2007-008052 2007-008052 2007-008052 2007-008052 2007-008055 2007-008055 2007-008055 2007-008055 2007-008055 2007-008055 2007-008055 2007-008056 2007-008056 2007-008057 2007-008135 2007-008419 2007-008419 2007-008419 2007-008419 2007-008419 2007-008419 2007-008420 2007-008420 2007-008420 2007-008477 2007-008478 2007-008478 2007-008478 2007-008483 2007-008483 2007-008483

R101 R-CHIP R303 R-CHIP R209 R-CHIP R103 R-CHIP R104 R-CHIP R601 R-CHIP R602 R-CHIP R700 R-CHIP R701 R-CHIP R505 R-CHIP R511 R-CHIP R514 R-CHIP R607 R-CHIP R608 R-CHIP R612 R-CHIP R711 R-CHIP R703 R-CHIP R705 R-CHIP R704 R-CHIP R412 R-CHIP R105 R-CHIP R106 R-CHIP R107 R-CHIP R108 R-CHIP R212 R-CHIP R712 R-CHIP R113 R-CHIP R501 R-CHIP R502 R-CHIP R308 R-CHIP R409 R-CHIP R410 R-CHIP R517 R-CHIP R115 R-CHIP R421 R-CHIP R515 R-CHIP

Main Electrical Parts List

6-3

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Discription 2007-008486 2007-008486 2007-008486 2007-008516 2007-008516 2007-008516 2007-008516 2007-008516 2007-008516 2007-008516 2007-008516 2007-008516 2007-008531 2007-008531 2007-008542 2007-008544 2007-008587 2007-008588 2007-008588 2007-008588 2007-008588 2007-008588 2007-008588 2007-008774 2007-008774 2007-008806 2007-008806 2007-008806 2007-008806 2007-009084 2007-009111 2007-009115 2007-009115 2007-009155 2007-009157 2007-009157

R400 R-CHIP R414 R-CHIP R423 R-CHIP R301 R-CHIP R302 R-CHIP R304 R-CHIP R424 R-CHIP R425 R-CHIP R426 R-CHIP R427 R-CHIP R428 R-CHIP R702 R-CHIP R208 R-CHIP R310 R-CHIP R204 R-CHIP R516 R-CHIP R102 R-CHIP R120 R-CHIP R203 R-CHIP R503 R-CHIP R504 R-CHIP R709 R-CHIP R710 R-CHIP R109 R-CHIP R207 R-CHIP R118 R-CHIP R314 R-CHIP R407 R-CHIP R616 R-CHIP R312 R-CHIP R506 R-CHIP R402 R-CHIP R403 R-CHIP R405 R-CHIP R417 R-CHIP R418 R-CHIP

6-4

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

SEC CODE Design LOC Discription 2007-009157 2007-009157 2007-009201 2007-009420 2007-009801 2007-009838 2203-000233 2203-000278 2203-000278 2203-000278 2203-000330 2203-000330 2203-000386 2203-000425 2203-000679 2203-000679 2203-000696 2203-000696 2203-000725 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-000854 2203-001017 2203-001383 2203-001385 2203-002709 2203-005050 2203-005050 2203-005234

R419 R-CHIP R420 R-CHIP R305 R-CHIP R206 R-CHIP R508 R-CHIP R415 R-CHIP C104 C-CER,CHIP C200 C-CER,CHIP C533 C-CER,CHIP C534 C-CER,CHIP C407 C-CER,CHIP C408 C-CER,CHIP C226 C-CER,CHIP C542 C-CER,CHIP C274 C-CER,CHIP C288 C-CER,CHIP C207 C-CER,CHIP C297 C-CER,CHIP C603 C-CER,CHIP C205 C-CER,CHIP C210 C-CER,CHIP C225 C-CER,CHIP C282 C-CER,CHIP C283 C-CER,CHIP C530 C-CER,CHIP C541 C-CER,CHIP C705 C-CER,CHIP C706 C-CER,CHIP C529 C-CER,CHIP C134 C-CER,CHIP C121 C-CER,CHIP C119 C-CER,CHIP C711 C-CER,CHIP C204 C-CER,CHIP C209 C-CER,CHIP C101 C-CER,CHIP

Main Electrical Parts List

6-5

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Discription 2203-005446 2203-005482 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 2203-005682 2203-005719 2203-005719 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005725 2203-005727 2203-005727 2203-005727 2203-005729 2203-005729 2203-005731 2203-005732 2203-005732

C208 C-CER,CHIP C540 C-CER,CHIP C103 C-CER,CHIP C108 C-CER,CHIP C216 C-CER,CHIP C248 C-CER,CHIP C262 C-CER,CHIP C281 C-CER,CHIP C308 C-CER,CHIP C409 C-CER,CHIP C437 C-CER,CHIP C445 C-CER,CHIP C133 C-CER,CHIP C446 C-CER,CHIP C241 C-CER,CHIP C251 C-CER,CHIP C253 C-CER,CHIP C260 C-CER,CHIP C261 C-CER,CHIP C263 C-CER,CHIP C264 C-CER,CHIP C266 C-CER,CHIP C267 C-CER,CHIP C268 C-CER,CHIP C273 C-CER,CHIP C285 C-CER,CHIP C292 C-CER,CHIP C294 C-CER,CHIP C132 C-CER,CHIP C700 C-CER,CHIP C702 C-CER,CHIP C123 C-CER,CHIP C227 C-CER,CHIP C129 C-CER,CHIP C231 C-CER,CHIP C232 C-CER,CHIP

6-6

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

SEC CODE Design LOC Discription 2203-005736 2203-005736 2203-005736 2203-005736 2203-005736 2203-005736 2203-005736 2203-005736 2203-005736 2203-005736 2203-005736 2203-005736 2203-005736 2203-005736 2203-005740 2203-005740 2203-005777 2203-005779 2203-005789 2203-005789 2203-005792 2203-005792 2203-005792 2203-005806 2203-005806 2203-005806 2203-005806 2203-005806 2203-005806 2203-005806 2203-005806 2203-005806 2203-005806 2203-005806 2203-005806 2203-005806

C237 C-CER,CHIP C239 C-CER,CHIP C240 C-CER,CHIP C242 C-CER,CHIP C250 C-CER,CHIP C252 C-CER,CHIP C259 C-CER,CHIP C269 C-CER,CHIP C284 C-CER,CHIP C286 C-CER,CHIP C299 C-CER,CHIP C410 C-CER,CHIP C427 C-CER,CHIP C432 C-CER,CHIP C115 C-CER,CHIP C116 C-CER,CHIP C228 C-CER,CHIP C271 C-CER,CHIP C120 C-CER,CHIP C230 C-CER,CHIP C105 C-CER,CHIP C109 C-CER,CHIP C127 C-CER,CHIP C201 C-CER,CHIP C206 C-CER,CHIP C215 C-CER,CHIP C223 C-CER,CHIP C236 C-CER,CHIP C246 C-CER,CHIP C257 C-CER,CHIP C303 C-CER,CHIP C317 C-CER,CHIP C318 C-CER,CHIP C326 C-CER,CHIP C327 C-CER,CHIP C328 C-CER,CHIP

Main Electrical Parts List

6-7

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Discription 2203-005806 2203-005806 2203-005806 2203-006048 2203-006048 2203-006123 2203-006194 2203-006194 2203-006194 2203-006194 2203-006194 2203-006194 2203-006194 2203-006194 2203-006194 2203-006194 2203-006194 2203-006194 2203-006194 2203-006194 2203-006194 2203-006194 2203-006260 2203-006260 2203-006348 2203-006399 2203-006399 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423

C332 C-CER,CHIP C335 C-CER,CHIP C346 C-CER,CHIP C531 C-CER,CHIP C601 C-CER,CHIP C130 C-CER,CHIP C131 C-CER,CHIP C211 C-CER,CHIP C214 C-CER,CHIP C304 C-CER,CHIP C319 C-CER,CHIP C320 C-CER,CHIP C321 C-CER,CHIP C322 C-CER,CHIP C323 C-CER,CHIP C324 C-CER,CHIP C329 C-CER,CHIP C330 C-CER,CHIP C333 C-CER,CHIP C334 C-CER,CHIP C338 C-CER,CHIP C340 C-CER,CHIP C106 C-CER,CHIP C107 C-CER,CHIP C433 C-CER,CHIP C447 C-CER,CHIP C543 C-CER,CHIP C102 C-CER,CHIP C213 C-CER,CHIP C233 C-CER,CHIP C234 C-CER,CHIP C244 C-CER,CHIP C245 C-CER,CHIP C247 C-CER,CHIP C255 C-CER,CHIP C256 C-CER,CHIP

6-8

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

SEC CODE Design LOC Discription 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-006462 2203-006462 2203-006556 2203-006562 2203-006562

C258 C-CER,CHIP C265 C-CER,CHIP C270 C-CER,CHIP C272 C-CER,CHIP C276 C-CER,CHIP C278 C-CER,CHIP C279 C-CER,CHIP C290 C-CER,CHIP C293 C-CER,CHIP C302 C-CER,CHIP C305 C-CER,CHIP C307 C-CER,CHIP C310 C-CER,CHIP C311 C-CER,CHIP C312 C-CER,CHIP C313 C-CER,CHIP C314 C-CER,CHIP C315 C-CER,CHIP C316 C-CER,CHIP C325 C-CER,CHIP C331 C-CER,CHIP C336 C-CER,CHIP C337 C-CER,CHIP C339 C-CER,CHIP C341 C-CER,CHIP C342 C-CER,CHIP C343 C-CER,CHIP C400 C-CER,CHIP C401 C-CER,CHIP C528 C-CER,CHIP C532 C-CER,CHIP C203 C-CER,CHIP C309 C-CER,CHIP C345 C-CER,CHIP C406 C-CER,CHIP C412 C-CER,CHIP

Main Electrical Parts List

6-9

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Discription 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006562 2203-006665 2203-006665 2203-006665 2203-006665 2203-006665 2203-006668 2203-006668 2203-006668 2203-006681 2203-006712 2203-006712 2203-006824 2203-006825 2203-006825 2203-006838 2203-006838 2203-006838 2203-006839 2203-006839 2203-006839 2203-006839 2203-006839 2203-006839

C413 C-CER,CHIP C414 C-CER,CHIP C415 C-CER,CHIP C416 C-CER,CHIP C417 C-CER,CHIP C418 C-CER,CHIP C419 C-CER,CHIP C420 C-CER,CHIP C422 C-CER,CHIP C525 C-CER,CHIP C526 C-CER,CHIP C704 C-CER,CHIP C707 C-CER,CHIP C110 C-CER,CHIP C114 C-CER,CHIP C117 C-CER,CHIP C118 C-CER,CHIP C124 C-CER,CHIP C219 C-CER,CHIP C220 C-CER,CHIP C306 C-CER,CHIP C523 C-CER,CHIP C218 C-CER,CHIP C243 C-CER,CHIP C221 C-CER,CHIP C520 C-CER,CHIP

TA500 C-CER,CHIP

C300 C-CER,CHIP C301 C-CER,CHIP C515 C-CER,CHIP C111 C-CER,CHIP C112 C-CER,CHIP C122 C-CER,CHIP C402 C-CER,CHIP C425 C-CER,CHIP C426 C-CER,CHIP

6-10

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

SEC CODE Design LOC Discription 2203-006839 2203-006839 2203-006839 2203-006839 2203-006839 2203-006839 2203-006839 2203-006839 2203-006839 2203-006839 2203-006839 2203-006839 2203-006839 2203-006839 2203-006839 2203-006839 2203-006839 2203-006839 2203-006839 2203-006839 2203-006839 2203-006841 2203-006841 2203-006841 2203-006841 2203-006841 2203-006841 2203-006841 2203-006841 2203-006841 2203-006841 2203-006841 2203-006841 2203-006841 2203-006841 2203-006872

C436 C-CER,CHIP C501 C-CER,CHIP C502 C-CER,CHIP C503 C-CER,CHIP C505 C-CER,CHIP C506 C-CER,CHIP C508 C-CER,CHIP C510 C-CER,CHIP C511 C-CER,CHIP C512 C-CER,CHIP C513 C-CER,CHIP C516 C-CER,CHIP C518 C-CER,CHIP C519 C-CER,CHIP C527 C-CER,CHIP C535 C-CER,CHIP C536 C-CER,CHIP C537 C-CER,CHIP C609 C-CER,CHIP C712 C-CER,CHIP

TA402 C-CER,CHIP

C438 C-CER,CHIP C439 C-CER,CHIP C440 C-CER,CHIP C441 C-CER,CHIP C442 C-CER,CHIP C507 C-CER,CHIP C509 C-CER,CHIP C514 C-CER,CHIP C600 C-CER,CHIP C604 C-CER,CHIP C605 C-CER,CHIP C606 C-CER,CHIP C608 C-CER,CHIP

TA401 C-CER,CHIP

C423 C-CER,CHIP

Main Electrical Parts List

6-11

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Discription 2203-006872 2203-006872 2203-006872 2203-006872 2203-006872 2203-006872 2203-006872 2203-006979 2203-006979 2203-007210 2203-007235 2203-007270 2203-007270 2203-007270 2203-007270 2203-007270 2203-007270 2203-007271 2203-007271 2203-007271 2203-007271 2203-007271 2203-007317 2203-007317 2203-007317 2203-007317 2203-007317 2203-007317 2203-007317 2404-001225 2404-001377 2404-001381 2404-001381 2404-001381 2404-001474 2404-001474

C424 C-CER,CHIP C431 C-CER,CHIP C500 C-CER,CHIP C517 C-CER,CHIP C524 C-CER,CHIP C710 C-CER,CHIP C713 C-CER,CHIP C254 C-CER,CHIP C287 C-CER,CHIP C421 C-CER,CHIP C411 C-CER,CHIP C249 C-CER,CHIP C344 C-CER,CHIP C403 C-CER,CHIP C404 C-CER,CHIP C435 C-CER,CHIP C443 C-CER,CHIP C113 C-CER,CHIP C126 C-CER,CHIP C128 C-CER,CHIP C405 C-CER,CHIP C434 C-CER,CHIP C275 C-CER,CHIP C277 C-CER,CHIP C298 C-CER,CHIP C428 C-CER,CHIP C429 C-CER,CHIP C430 C-CER,CHIP

C504 C-CER,CHIP TA501 C-TA,CHIP TA503 C-TA,CHIP TA400 C-TA,CHIP TA502 C-TA,CHIP TA600 C-TA,CHIP TA100 C-TA,CHIP TA601 C-TA,CHIP

6-12

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

SEC CODE Design LOC Discription 2703-001733 2703-001747 2703-002176 2703-002198 2703-002203 2703-002203 2703-002203 2703-002205 2703-002207 2703-002207 2703-002208 2703-002368 2703-002794 2703-002794 2703-002795 2703-002795 2703-002795 2703-002798 2703-002798 2703-002798 2703-002858 2703-002903 2703-002903 2703-002906 2703-002917 2703-002917 2703-002953 2703-003001 2703-003004 2703-003009 2703-003260 2703-003260 2703-003335 2703-003502 2703-003534 2801-004339

L201 INDUCTOR-SMD L204 INDUCTOR-SMD L212 INDUCTOR-SMD L115 INDUCTOR-SMD L203 INDUCTOR-SMD L217 INDUCTOR-SMD L223 INDUCTOR-SMD L113 INDUCTOR-SMD L101 INDUCTOR-SMD L218 INDUCTOR-SMD L208 INDUCTOR-SMD L112 INDUCTOR-SMD L214 INDUCTOR-SMD L216 INDUCTOR-SMD L104 INDUCTOR-SMD L107 INDUCTOR-SMD L116 INDUCTOR-SMD L202 INDUCTOR-SMD L205 INDUCTOR-SMD L211 INDUCTOR-SMD L109 INDUCTOR-SMD L207 INDUCTOR-SMD L222 INDUCTOR-SMD L206 INDUCTOR-SMD L215 INDUCTOR-SMD L221 INDUCTOR-SMD L105 INDUCTOR-SMD L403 INDUCTOR-SMD L102 INDUCTOR-SMD L225 INDUCTOR-SMD L401 INDUCTOR-SMD L402 INDUCTOR-SMD L111 INDUCTOR-SMD L400 INDUCTOR-SMD L602 INDUCTOR-SMD

OSC400 CRYSTAL-SMD

Main Electrical Parts List

6-13

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Discription 2801-004573 2801-004589 2809-001277 2901-001499 2901-001499 2904-001759 2904-001785 2904-001789 2904-001864 2909-001283 2910-000034 2910-000058 2911-000128 3003-001136 3301-001342 3301-001812 3301-001812 3301-001812 3301-001895 3301-001895 3301-001895 3301-001895 3301-001895 3301-001895 3301-001895 3301-001895 3301-001912 3404-001152 3404-001152 3404-001152 3705-001503 3708-002283 3709-001456 3709-001539 3711-007004 3711-007021

OSC500 CRYSTAL-SMD OSC100 CRYSTAL-SMD

TCX200 OSCILLATOR-VCTCXO

F700 FILTER-EMI/ESD F701 FILTER-EMI/ESD F204 FILTER-SAW F201 FILTER-SAW F203 FILTER-SAW F205 FILTER-SAW F100 FILTER-LC F202 DUPLEXER-SAW F200 DUPLEXER-SAW

DUF100 DUPLEXER-FEM

AU500 MIC MEMS

L703 BEAD-SMD L500 BEAD-SMD L600 BEAD-SMD L601 BEAD-SMD L711 BEAD-SMD L712 BEAD-SMD L713 BEAD-SMD L714 BEAD-SMD L715 BEAD-SMD L716 BEAD-SMD L717 BEAD-SMD L718 BEAD-SMD

L103 BEAD-SMD TAC700 SWITCH-TACT TAC701 SWITCH-TACT TAC702 SWITCH-TACT RFS101 CONNECTOR-COAXIAL

CN700 CONNECTOR-FPC/FFC/PIC

SIM400 CONNECTOR-CARD EDGE

CN400 CONNECTOR-CARD EDGE

BTC400 HEADER-BATTERY

HDC700 HEADER-BOARD TO BOARD

6-14

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

SEC CODE Design LOC Discription 3722-002871 4302-001180 4709-001713

IFC600 JACK-MINI USB BAT400 BATTERY-LI(2ND) CPL200 COUPLER-DIRECTION

GH13-00066A U503 IC ASIC-SGH_G900 GH70-03349A SC100 IPR SHIELD-CAN CLIP GH70-03349A SC101 IPR SHIELD-CAN CLIP GH70-03349A SC102 IPR SHIELD-CAN CLIP GH70-03349A SC103 IPR SHIELD-CAN CLIP GH70-03349A SC104 IPR SHIELD-CAN CLIP GH70-03349A SC106 IPR SHIELD-CAN CLIP GH70-03349A SC107 IPR SHIELD-CAN CLIP GH71-08426A ANT100 NPR CONTACT-ANTENNA GH71-08426A ANT101 NPR CONTACT-ANTENNA GH71-08426A ANT102 NPR CONTACT-ANTENNA GH71-08426A ANT200 NPR CONTACT-ANTENNA GH71-08863A SC108 NPR S HIELD-FRAME

Main Electrical Parts List

Please consult the GSPN website(Samsung Portal) for the most recent version of the product's part list.

6-15

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Disassembly and Assembly Instructions

Disassembly

7-1.

※

Be care of scratch and molding damage.

Unscrew the4points.

Separate the REAR from the FRONT ass'y

Caution

Unscrew the3points.

Disassemble the key FPCB from connector.

①

②

Caution

※

Be care of damage to KEY F-CPB.

※

Caution

Disassemble the slide F-CPB with the

conenctor.

Seprete PBA from the slide ass'y.

Be care of damage to slide F-CPB

Caution

※

Be care of scratch and molding damage.

Detach Screw Cap2EA

Unscrew the2points.

7-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

+ 67 hidden pages