Samsung S8000 Service Manual v1.1

GSM TELEPHONE

GT-S8000

GSM TELEPHONE

CONTENTS

Safety Precautions

1.

Specification

2.

Product Function

3.

Array course control

4.

Exploded View and Parts list

5.

MAIN Electrical Parts List

6.

Disassembly and Assembly

7. Instructions

Block Diagrams

8.

PCB Diagrams

9.

Chart of Troubleshooting

10.

Reference data

11.

Safety Precautions

1.

Repair Precaution

1-1.

Repair in Shield Box, during detailed tuning.

●

Take specially care of tuning or test,

because specipicty of cellular phone is sensitive for surrounding interference(RF noise).

Be careful to useakind of magnetic object or tool,

●

because performance of parts is damaged by the influence of manetic force.

Surely useastandard screwdriver when you disassemble this product,

●

otherwise screw will be worn away.

Useathicken twisted wire when you measure level.

●

thicken twisted wire has low resistance, therefore error of measurement is few.

A

Repair after separate Test Pack and Set because for short danger(for example an

●

overcurrent and furious flames of parts etc) when you repair board in condition of

connecting Test Pack and tuning on.

Take specially care of soldering, because Land of PCB is small and weak in heat.

●

Surely tune on/off while using AC power plug, becausearepair of battery charger is

●

dangerous when tuning ON/OFF PBA and Connector after disassembing charger.

Don't use as you pleases after change other material than replacement registered on SEC

●

System.

Otherwise engineer in charge isn't charged with problem that you don't keep this rules.

1-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Safety Precautions

ESD(Electrostatically Sensitive Devices) Precaution

1-2.

Several semiconductor may be damaged easilly by static electricity. Such parts are called by

ESD(Electrostatically Sensitive Devices), for example IC,BGA chip etc. Read Precaution below.

You can prevent from ESD damage by static electricity.

Remove static electricity remained your body before you touch semiconductor or parts with

●

semiconductor. There are ways that you touch an earthed place or wear static electricity

prevention string on wrist.

Use earthed soldering steel when you connect or disconnect ESD.

●

Use soldering removing tool to break static electricity.,otherwise ESD will be damaged by

●

static electricity.

Don't unpack until you set up ESD on product. Because most of ESD are packed by box

●

and aluminum plate to have conductive power,they are prevented from static electricity.

You must maintain electric contact between ESD and place due to be set up until ESD is

●

connected completely to the proper place oracircuit board.

1-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Specification

2.

GSM General Specification

2-1.

GSM850

Phase 1

Freq.

Band[MHz]

Uplink/Downlin

k

ARFCN range 128~251

Tx/Rx spacing 45MHz 45MHz 95MHz 80MHz 190MHz

Mod. Bit rate/

Bit Period

Time Slot

Period/Frame

Period

824~849 869~894

270.833kbps

3.692us

576.9us

4.615ms

EGSM 900

Phase 2

880~915 925~960

0~124 &

975~1023

270.833kbps

3.692us

576.9us

4.615ms

DCS1800

Phase 1

1710~1785 1805~1880

512~885 512~810

270.833kbps

3.692us

576.9us

4.615ms

PCS1900

1850~1910 1930~1990

270.833kbps

3.692us

576.9us

4.615ms

WCDMA2100

1922~1977 2112~2167

UL:9612~988 8DL:10562~1

0838

3.84Mcps

FrameLength:

10ms

Slotlength:

0.667ms

Modulation 0.3GMSK 0.3GMSK 0.3GMSK 0.3GMSK QPSKHQPSK

MS Power 33dBm~5dBm

Power Class 5pcl ~ 19pcl 5

Sensitivity -102dBm -102dBm -100dBm -100dBm -106.7dBm

TDMA Mux 8 8 8 8

Cell Radius 35Km 35Km 2Km 2Km 2Km

33dBm~5dB

m

pcl

~19

pcl

30dBm~0dBm 30dBm~0dBm

0

2-1

pcl

~15

pcl

0

~15

pcl

24dBm~-

50dBm

max+24dBm)

3(

8

Specification

GSM Tx Power Class

2-2.

TX Power

control

GSM850

level

533±2

631±2

729±2

827±2

925±2

10 23±2

11 21±2

12 19±2

dBm

TX Power

control

EGSM900

level

533±2

631±2

729±2

827±2

925±2

10 23±2

11 21±2

12 19±2

dBm

TX Power

control

DCS1800

level

030±3

128±3

226±3

324±3

422±3

520±3

618±3

716±3

dBm

TX Power

control

PCS1900

level

030±3

128±3

226±3

324±3

422±3

520±3

618±3

716±3

dBm

13 17±2

14 15±2

15 13±2

16 11±3

17 9±3

18 7±3

19 5±3

dBm

13 17±2

14 15±2

15 13±2

16 11±3

17 9±3

18 7±3

19 5±3

dBm

2-2

814±3

912±4

10 10±4

11 8±4

12 6±4

13 4±4

14 2±5

15 0±5

dBm

814±3

912±4

10 10±4

11 8±4

12 6±4

13 4±4

14 2±5

15 0±5

dBm

Product Function

3.

Main Function

Multimedia capability

―

Navigation

―

Video editor

―

Organiser-Alarms, Calculator,NotePad,Task Manager,Smart Converter,World Clock

―

Stopwatch

Active Sync

―

Bluetooth

―

Namecard recognition

―

Voice recorder

―

Games

―

Google Map

―

TV OUT

―

Auto Brightness Control

―

Acceleration Sensor

―

G-Sensor

―

Mega Pixel, Camcorder,Video Player

-5

,

3-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

4.

Test Jig(GH99

RF Test Cable(GH

-36900

39-00985

A)

Test Cable(GH

Adapter(GH

39-01290

99-38251A)

A)

4-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Software Downloading

Downloading Binary Files

4-1.

ㆍSix

4-2.

ㆍ ㆍS8000 ㆍ ㆍ

binary files for downloading S8000

-

Boot, Amss, Apps, Rsrc1, Rsrc2, Factory FS

Pre-requsite for Downloading

Downloader Program

(

Downloader V5.53

Mobile Phone Data Cable Binary files

)

4-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

S/W Downloader Program

4-3.

Load the binary download program by executing the

1.

"

Downloader V5.53

Array course control

"

4-3

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Select the

2.

"

LSI6410

.

"

as Control.

4-4

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Select the

3.

Array course control

Full Download.

4-5

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

4. Load the file of Boot, Amss, Apps, Rsrc 1. Rsrc2, Factory FS from the folder that you saved the binary files.

4-6

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Click the

.

5

Port Search

button

en the download cable is connected

wh

to PC.

cf. You have to set the phone as a download mode by pressing Volume down + Camera + End key simultaneously before

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

connect

ing to PC .

4-7

Array course control

Then the

down load

er can search the port.

4-8

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Click the

.

5

Download

button

wh

en the

Port searched.

It will start to download.

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

4-9

Array course control

When downloading is finished successfully, there is

6.

Confirm the downloaded version name and etc.

7.

*#197328640# ->

choose

'2'

→

choose

:

'1' ->

All

a"

choose

files complete

'2'

message.

"

4-10

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Exploded View and Parts List

5.

5-1.

Cellular phone Exploded View

QFR01

QLC01

QCK02

QCA02

QCA01

QME03

QKP01

QME01

QMI03

QLB01

QVK02

QAR01

QVK01 QSH01

QMP01

QSH02

QSH03

QCR05

QMP02

QRF06

QMO01

QSP01

QCR05

QVO01

QCK01

QRE01

QCR60

QBA00

5-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Exploded View and Parts List

5-2.

Cellular phone Parts list

Design LOC Description SEC CODE

QAR01 ASSY ETC-RCV+MIC+EAR JACK ASS'Y GH59-07377A

QBA00 ASSY COVER-BATT GH98-12808A

QCA01 CAMERA MODULE GH59-07335A

QCA02 ASSY CAMERA-VGA GT-S8000 GH96-03767A

QCK02 PMO KEY-HOLD GH72-53016A

QCR05 SCREW-MACHINE

QCR60 SCREW-MACHINE

6001-001478

6001-002005

QFR01 ASSY CASE-FRONT GH98-12377A

QKP01 ASSY KEYPAD-SND END(EU/BLACK) GH98-12397A

QLB01 ASSY BRACKET-LCD GH98-12398A

QLC01 ASSY LCD-3.1"WVGA GT-S8000 AMOLED ASSY GH96-03746A

QME01 KEY FPCB-TF KEY PBA GH59-07373A

QME03 TOUCH/PANEL-GT-S8000 TSP GH59-07332A

QMI03 RMO RUBBER-MIC HOLDER1 GH73-12994A

QMO01 MOTOR LINEAR VIBRATION-GTS8000 GH31-00475A

QMP01 A/S ASSY-PBA MAIN GT-S8000 SVC(EU) GH82-03706A

QMP02 ASSY PBA SUB-GT-S8000 GH92-05754A

QSH01 ICT SHIELD-CAN BOTOM GH70-05019A

QSH02 ICT SHIELD-CAN COVER GH70-05020A

QSH03 ASSY BRACKET-SHIELD CAN GH98-12400A

QSP01 MODULE-SPK/INTENNA(GT-S8000) GH59-07307A

QVK01 KEY FPCB-GT-S8000(V/K) GH59-07054A

QVK02 KEY FPCB-GT-S8000(H/K) GH59-07053A

QRE01 ASSY CASE-REAR GH98-12378A

QRF06 PMO COVER-USB GH72-52829A

QVO01 ASSY KEY-VOL GH98-12806A

QCK01 ASSY KEY-CAM GH98-12807A

5-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

MAIN Electrical Parts List

6.

SEC CODE Design LOC Description

0403-001547

0404-001172

0406-001223

0406-001254

0406-001267

0406-001288

0406-001305

0407-001002

0504-000168

0504-001138

0504-001151

0505-002088

0801-003139

0801-003200

0801-003265

0902-002441

1001-001408

1001-001461

1001-001481

1001-001488

1001-001546

1001-001580

D600 DIODE-ZENER

D300 DIODE-SCHOTTKY

ZD400 DIODE-TVS

ZD605 DIODE-TVS

ZD606 DIODE-TVS

ZD610 DIODE-TVS

ZD608 DIODE-TVS

ZD609 DIODE-TVS

V400 DIODE-TVS

V401 DIODE-TVS

ZD401 DIODE-TVS

ZD402 DIODE-TVS

ZD403 DIODE-TVS

D400 DIODE-TVS

D401 DIODE-TVS

U502 DIODE-TVS

D200 DIODE-ARRAY

D201 DIODE-ARRAY

Q601 TR-DIGITAL

Q600 TR-DIGITAL

U101 TR-DIGITAL

U102 TR-DIGITAL

Q300 FET-SILICON

Q700 FET-SILICON

U300 IC-CMOS LOGIC

U103 IC-CMOS LOGIC

U304 IC-CMOS LOGIC

U301 IC-CMOS LOGIC

UCP701 IC-MICROPROCESSOR

U404 IC-ANALOG SWITCH

U401 IC-ANALOG SWITCH

U607 IC-ANALOG SWITCH

U704 IC-ANALOG SWITCH

U402 IC-ANALOG SWITCH

U403 IC-ANALOG SWITCH

U600 IC-ANALOG MULTIPLEX

6-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Description

1003-002047

1003-002216

1201-002147

1201-002581

1201-002775

1201-002821

1201-002830

1202-001079

1203-002832

1203-004571

1203-004819

1203-005069

1203-005485

1203-005690

1203-005772

1203-005782

1203-005795

1204-003026

1205-003297

1205-003467

1205-003726

1205-003757

1404-001221

1405-001177

2007-000157

2007-003015

2007-003018

2007-007193

2007-007307

2007-007480

U601 IC-MOTOR DRIVER

U703 IC-LEVEL DRIVER

U603 IC-VIDEO AMP

F201 IC-RF AMP

PAM100 IC-POWER AMP

PAM102 IC-POWER AMP

U105 IC-POWER AMP

U405 IC-VOLTAGE COMP.

U406 IC-VOLTAGE COMP.

U604 IC-VOL. DETECTOR

U200 IC-MULTI REG.

U205 IC-POSI.FIXED REG.

U207 IC-POSI.FIXED REG.

U608 IC-POSI.FIXED REG.

U602 IC-POSI.FIXED REG.

U501 IC-DC/DC CONVERTER

U305 IC-VOL. DETECTOR

U204 IC-DC/DC CONVERTER

PMIC200 IC-DC/DC CONVERTER

U202 IC-TUNER

U100 IC-TRANSCEIVER

U303 IC-SWITCH

UCP300 IC-MODEM

U400 IC-CODEC

TH300 THERMISTOR-NTC

V300 VARISTOR

V301 VARISTOR

V402 VARISTOR

R515 R-CHIP

R514 R-CHIP

R747 R-CHIP

R105 R-CHIP

R106 R-CHIP

R340 R-CHIP

R341 R-CHIP

R606 R-CHIP

6-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Description

2007-007741

2007-007798

2007-007943

2007-008045

2007-008046

2007-008047

2007-008049

2007-008052

R208 R-CHIP

R217 R-CHIP

R218 R-CHIP

R219 R-CHIP

R520 R-CHIP

R603 R-CHIP

R102 R-CHIP

R122 R-CHIP

R301 R-CHIP

R333 R-CHIP

R334 R-CHIP

R407 R-CHIP

R412 R-CHIP

R413 R-CHIP

R416 R-CHIP

R417 R-CHIP

R418 R-CHIP

R609 R-CHIP

R730 R-CHIP

R731 R-CHIP

R732 R-CHIP

R764 R-CHIP

R113 R-CHIP

R114 R-CHIP

R118 R-CHIP

R119 R-CHIP

R111 R-CHIP

R112 R-CHIP

R306 R-CHIP

R342 R-CHIP

R343 R-CHIP

R713 R-CHIP

R714 R-CHIP

R733 R-CHIP

R734 R-CHIP

R737 R-CHIP

6-3

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Description

2007-008052

2007-008055

2007-008057

2007-008419

R738 R-CHIP

R745 R-CHIP

R746 R-CHIP

R762 R-CHIP

R763 R-CHIP

R120 R-CHIP

R212 R-CHIP

R213 R-CHIP

R215 R-CHIP

R216 R-CHIP

R234 R-CHIP

R330 R-CHIP

R410 R-CHIP

R500 R-CHIP

R607 R-CHIP

R619 R-CHIP

R620 R-CHIP

R715 R-CHIP

R716 R-CHIP

R717 R-CHIP

R718 R-CHIP

R719 R-CHIP

R720 R-CHIP

R721 R-CHIP

R722 R-CHIP

R723 R-CHIP

R726 R-CHIP

R752 R-CHIP

R757 R-CHIP

R760 R-CHIP

R761 R-CHIP

R769 R-CHIP

R770 R-CHIP

R604 R-CHIP

R123 R-CHIP

R124 R-CHIP

6-4

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Description

2007-008419

2007-008420

2007-008516

2007-008548

2007-008581

2007-008587

2007-008588

2007-008590

2007-008686

2007-008766

2007-008798

2007-008806

2007-008964

2007-009084

2007-009115

2007-009157

R125 R-CHIP

R126 R-CHIP

R402 R-CHIP

R405 R-CHIP

R331 R-CHIP

R303 R-CHIP

R304 R-CHIP

R305 R-CHIP

R600 R-CHIP

R727 R-CHIP

R728 R-CHIP

R729 R-CHIP

R403 R-CHIP

R404 R-CHIP

R232 R-CHIP

R231 R-CHIP

R400 R-CHIP

R108 R-CHIP

R401 R-CHIP

R605 R-CHIP

R329 R-CHIP

R743 R-CHIP

R744 R-CHIP

R109 R-CHIP

R117 R-CHIP

R121 R-CHIP

R519 R-CHIP

R742 R-CHIP

R313 R-CHIP

R406 R-CHIP

R414 R-CHIP

R419 R-CHIP

R748 R-CHIP

R749 R-CHIP

R310 R-CHIP

R311 R-CHIP

6-5

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Description

2007-009157

2007-009171

2007-009182

2007-009201

2007-009212

2007-009233

2007-009420

2007-009801

2007-009849

2203-000233

2203-000278

2203-000438

2203-000696

2203-000725

2203-000812

2203-002443

2203-002668

2203-002709

2203-005138

2203-005682

R314 R-CHIP

R201 R-CHIP

R202 R-CHIP

R203 R-CHIP

R204 R-CHIP

R205 R-CHIP

R504 R-CHIP

R110 R-CHIP

R104 R-CHIP

R420 R-CHIP

R101 R-CHIP

R408 R-CHIP

R409 R-CHIP

R623 R-CHIP

R415 R-CHIP

C212 C-CER,CHIP

C203 C-CER,CHIP

C179 C-CER,CHIP

C207 C-CER,CHIP

C312 C-CER,CHIP

C217 C-CER,CHIP

C608 C-CER,CHIP

C211 C-CER,CHIP

C623 C-CER,CHIP

C624 C-CER,CHIP

C175 C-CER,CHIP

C174 C-CER,CHIP

R206 C-CER,CHIP

C339 C-CER,CHIP

C726 C-CER,CHIP

C1006 C-CER,CHIP

C102 C-CER,CHIP

C109 C-CER,CHIP

C116 C-CER,CHIP

C117 C-CER,CHIP

C302 C-CER,CHIP

6-6

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Description

2203-005682

2203-005683

2203-005717

2203-005719

2203-005725

2203-005729

C414 C-CER,CHIP

C415 C-CER,CHIP

C525 C-CER,CHIP

C526 C-CER,CHIP

C527 C-CER,CHIP

C528 C-CER,CHIP

C602 C-CER,CHIP

C603 C-CER,CHIP

C605 C-CER,CHIP

C619 C-CER,CHIP

C620 C-CER,CHIP

C704 C-CER,CHIP

C707 C-CER,CHIP

C710 C-CER,CHIP

C715 C-CER,CHIP

C716 C-CER,CHIP

C184 C-CER,CHIP

C724 C-CER,CHIP

C725 C-CER,CHIP

C177 C-CER,CHIP

C110 C-CER,CHIP

C114 C-CER,CHIP

C120 C-CER,CHIP

C127 C-CER,CHIP

C130 C-CER,CHIP

C131 C-CER,CHIP

C133 C-CER,CHIP

C135 C-CER,CHIP

C139 C-CER,CHIP

C145 C-CER,CHIP

C147 C-CER,CHIP

C158 C-CER,CHIP

C160 C-CER,CHIP

C419 C-CER,CHIP

C420 C-CER,CHIP

C722 C-CER,CHIP

6-7

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Description

2203-005729

2203-005731

2203-005732

2203-005734

2203-005736

2203-005777

2203-005789

2203-005792

2203-005806

2203-006048

C723 C-CER,CHIP

L125 C-CER,CHIP

C264 C-CER,CHIP

C269 C-CER,CHIP

C406 C-CER,CHIP

C425 C-CER,CHIP

C426 C-CER,CHIP

C427 C-CER,CHIP

C100 C-CER,CHIP

C101 C-CER,CHIP

C403 C-CER,CHIP

C407 C-CER,CHIP

R107 C-CER,CHIP

C105 C-CER,CHIP

C107 C-CER,CHIP

C112 C-CER,CHIP

C115 C-CER,CHIP

C136 C-CER,CHIP

C143 C-CER,CHIP

C148 C-CER,CHIP

C152 C-CER,CHIP

C154 C-CER,CHIP

C162 C-CER,CHIP

C231 C-CER,CHIP

C188 C-CER,CHIP

C191 C-CER,CHIP

C215 C-CER,CHIP

L115 C-CER,CHIP

C178 C-CER,CHIP

C146 C-CER,CHIP

C151 C-CER,CHIP

C138 C-CER,CHIP

C142 C-CER,CHIP

C198 C-CER,CHIP

C202 C-CER,CHIP

C196 C-CER,CHIP

6-8

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Description

2203-006048

2203-006090

2203-006120

2203-006123

2203-006137

2203-006187

2203-006194

2203-006208

2203-006305

2203-006399

C401 C-CER,CHIP

C402 C-CER,CHIP

C221 C-CER,CHIP

C180 C-CER,CHIP

C128 C-CER,CHIP

C141 C-CER,CHIP

C267 C-CER,CHIP

C279 C-CER,CHIP

L127 C-CER,CHIP

L128 C-CER,CHIP

C119 C-CER,CHIP

C126 C-CER,CHIP

C258 C-CER,CHIP

C261 C-CER,CHIP

C266 C-CER,CHIP

C314 C-CER,CHIP

C315 C-CER,CHIP

C325 C-CER,CHIP

C328 C-CER,CHIP

C330 C-CER,CHIP

C515 C-CER,CHIP

C149 C-CER,CHIP

L124 C-CER,CHIP

C200 C-CER,CHIP

C201 C-CER,CHIP

C204 C-CER,CHIP

C208 C-CER,CHIP

C216 C-CER,CHIP

C239 C-CER,CHIP

C241 C-CER,CHIP

C242 C-CER,CHIP

C243 C-CER,CHIP

C244 C-CER,CHIP

C245 C-CER,CHIP

C246 C-CER,CHIP

C247 C-CER,CHIP

6-9

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization