Rinnai RL94IP, RL94IN Specifications

RL94i (VC2837FFUD-US)

0.0

1.0

2.0

3.0

4.0

5.0

6.0

7.0

8.0

9.0

10.0

0 25 50 75 100 125 150

Type of Appliance

Rinnai Model Number

Operation / Installation

Minimum/Maximum Gas Rate (Input)

Electrical

Electrical Consumption

Amperage

Ignition System

Hot Water Capacity

Temperature

Temperature (without remote)

Installation

Energy Factor

Service Connections

Isolation & Pressure Relief Valves Included

Water Flow Control

Minimum/Maximum Water Supply Pressure

 Temperature controlled, continuous flow, gas hot water system  Certified for installation in manufactured (mobile) homes  Forced combustion / Direct vent

REU-VC2837FFUD-US

Forced combustion; indoor only

10,300 - 199,000 BTU/h

Appliance: AC 120 Volts - 60 Hz Controller: DC 12 Volts

Normal: 97 w Standby: 2 w Anti-frost protection: 120 w

Max with pump: 8A Max without pump: 4A Fuse: 10A

Direct electronic ignition

Minimum flow rate: 0.26 GPM (1 l/min) Minimum activation flow rate: 0.4 GPM (1.5l /min) Maximum flow rate: 9.8 GPM (37.1 l/min)

98° - 120°F (37°- 49°C) (factory default) Maximum temperature is selectable at 120°F (49°C) or at 140°F (60°C) ; 98° - 185°F (37°- 85°C) available with the MCC-91-2 controller for commercial and hydronic applications

120°F (49°C) (factory default) or 140°F (60°C)

Indoor only

Natural Gas: 0.82 Propane: 0.82

Gas supply: 3/4 inch MNPT Cold water inlet: 3/4 inch MNPT Hot water outlet: 3/4 inch MNPT

Isolation Valves are certified to NSF/ANSI 61 for potable water

Water flow sensor, electronic water control device and by-pass

20 - 150 PSI (138-1035 KPa) (recommended 30-80 PSI (209 - 552 KPa) for optimal performance)

Rinnai is continually updating and improving products; therefore, specifications are subject to change without prior notice. Local, state, provincial and federal codes must be adhered to prior to installation.

FLOW TABLE

Water Flow gpm (l/min)

10.0 (37.9)

9.0 (34.1)

8.0 (30.3)

7.0 (26.5)

6.0 (22.7)

5.0 (19.0)

4.0 (15.1)

3.0 (11.4)

2.0 (7.6)

1.0 (3.8)

0.0 0

25(13.9) 50(27.8) 75(41.6) 100(55.6) 125(69.4)

delta T - Temperature Rise (ºF)

RL94i VC SP(01) 7/2015

Low Lead Content

NSF/ANSI 372

C U

150(83.3)

SANITATION

RL94i (VC2837FFUD-US)

External Recirculation Pump Control

Water Temperature Control

Controller

Controller Cable

Safety Devices

Clearances from Combustibles (suitable for closet, attic, and crawl space installations)

Clearances from Non-combustibles

Min. / Max. Gas Supply Pressure (sea level)

Manifold Gas Pressure (inches W.C.)

NOx

Rinnai Circ-Logic™(Included): Recirculation program cycles external pump

Simulation feed forward and feedback

MC-91-2US (part of the front panel) Deluxe controller: MC-100V-1US (optional) Bathroom controller: BC-100V-1US (optional) MCC-91-2US (optional; for hydronic and commercial applications) MC-195T-US (optional; for use with Circ-Logic

Non-polarized two-core cable, minimum 22 AWG

 Flame failure - Flame Rod  Boiling protection  Combustion fan rpm check  Over current - glass fuse

 Top of heater - 6 inches (152mm)  Front of heater - 6 inches (152mm)  Sides of heater - 2 inches (51mm)

 Top of heater - 2 inches (51mm)  Front of heater - 6 inches (152mm)  Sides of heater - 1/2 inch (13mm)

 Remaining flame (OHS)  Thermal fuse  Automatic frost protection

 Back of heater - 0 inches  Ground / bottom - 12 inches (305mm)  From vent pipe - 0 inches

Natural Gas: min 4” W.C. (10mbar) max 10.5” W.C. (26.1mbar) Propane Gas: min 8” W.C. (20mbar) max 13.5” W.C. (33.6mbar)

Natural Gas: high fire 2.9” W.C. (7.22mbar) low fire 0.61” W.C. (1.52mbar) Propane Gas: high fire 4.7” W.C. (11.71mbar) low fire 0.87” W.C. (2.17mbar)

Complies with South Coast Air Quality Management District 40 ng/J or 55 ppm NOx emission levels

Limited Warranty

DIMENSIONS

Heat exchanger: 12 years* for residential, 10 years for residential and space heating, and 5 years* for commercial; All other parts: 5 years*; Labor: 1 year; (* 3 years from date of purchase when used as a recirculating water heater within a hot water recirculation loop, where the water heater is in series with a recirculation system and all recirculating water flows through the water heater, and where an aquastat/thermostat, timer, or an on-demand recirculation system is not incorporated.) Refer to the manual for complete warranty information.

WEIGHT: 46.3 lb (21.0 kg)

14.04 (356.6)

9.27 (235.5)

5.05 (128.1)

0.4~1.8 (10~45) Variable

2.67 (67.8)

22.95 (583)

DIMEN-

SION

A (GAS)

A (COLD)

A (HOT)

Inches (mm)

1.31 (33.2)

1.93 (49)

1.35 (34.4)

4.21 (106.9)

1.17 (29.8)

DIMEN-

SION

Inches (mm)

4.33 (110)

2.89 (73.3)

1.85 (47)

3.44 (87.3)

Rinnai Corporation • 103 International Drive • Peachtree City, GA 30269 • Toll-Free: 1-800-621-9419 • Fax: 678-364-8643 • www.rinnai.us