Rinnai RHFE-559FTA-A-P, RHFE-559FTA-A-N User Manual

EX22C (RHFE-559FTA)

Type of Appliance

Rinnai Model Number Gas Rate Input (BTU/hour)

Gas Rate Output (BTU/hour)

AFUE Rating Minimum Gas Supply Pressure Maximum Gas Supply Pressure Electrical Connection Gas Connection Combustion System Ignition System Fan CFM Output Temperature Settings

Temperature Control

Direct vent wall furnace suitable for homes, apartments, and condominiums, residential or commercial setting; modular/mobile home approved; forced combustion, forced convection

RHFE-559FTA-A-N (Natural gas) RHFE-559FTA-A-P (Propane)

Low - 8,200 Low - 8,200 High - 21,500 High - 20,700

Low - 6,560 Low - 6,560 High - 17,200 High - 16,560

81% 82%

3.5 in (89 mm) W.C. 8 in (203 mm) W.C.

10.5 in (267 mm) W.C 13 in (330 mm) W.C. AC 120V, 60 Hz, 56 watts 1/2 inch NPT Stainless steel Bunsen burners Electronic spark ignition Low: 110.5 High: 162.7 Low (LO): minimum combustion

60° - 80° F in 2° increments High (HI): maximum combustion

• Electronic thermostat

• Temperature limiting program to comply with Inside Design

Temperature limits

Humidifier Tray Weight Clearance from Combustibles Noise Level Warm Air Outlet

FEATURES

Restart capability: Timer Settings: Seven-stage modulating gas valve: Negative coefficient thermistor: Variable speed inducer motor with

pressure switch: Self diagnostic electronics:

Quiet operation:

Enameled tray with capacity of 2.1 pints (1000 cc) Approximately 57 lbs (26 kg) Side: 2 inches (50 mm), Top: 0 inches (0 mm), Front: 40 inches (1 m) 33 - 42 dB(A) Bottom front louvers

restarts automatically when ignition or combustion fails starts and turns off the heater at 2 timer settings provides precise gas flow by operating from one to seven stages detects temperature change in 1/2 of a degree monitors and controls combustion fan and allows the appliance to

overcome winds of up to 40 mph continually monitors functions; provides auto shutdown codes; indicates

when air filter needs cleaning reduces noise through use of swept blades in convection fan; quiet

expansion / contraction of parts due to temperature changes

RHFE-559FTA SP 6/2010

EX22C (RHFE-559FTA)

Safety Devices

Venting Maximum Vent Length Wall Thickness and

Flue Manifold Kits

(the “A” vent kit is included with the appliance)

• Flame rod detects flame failure; results in auto shutdown to prevent escape of gas

• Bi-metal switch, thermal fuse, and thermistor detect overheat condition; results in auto shutdown

• 3 amp fuse protects against power surge; results in auto shutdown

• Abnormal spark at time of ignition results in auto shutdown

• Combustion fan purges any gas from the combustion chamber before

ignition

• Convection fan continues to run after burner shutdown to cool internal parts

• Child lock prevents inadvertent operation

• Appliance shuts down if room reaches 104° F (40° C)

concentric; 3 1/8 inch (80 mm) wall hole 13 feet (4 m) with a maximum of 2 bends; maximum 10 feet (3 m) vertically

Name Kit No. fits walls

S Vent Kit FOT-150 3 - 4 1/2 in (75 - 115 mm) A Vent Kit FOT-151 4 1/2 - 9 1/2 in (115 - 240 mm) B Vent Kit FOT-152 9 1/2 - 15 3/4 in (240 - 400mm) C Vent Kit FOT-153 15 3/4 - 23 5/ 8 in (400 - 600 mm) D Vent Kit FOT-154 23 5/8 - 31 1/ 2 in (600 - 800 mm)

Warranty Conversion Kit

Labor: 2 years; Parts: 5 years; Heat Exchanger: 10 years To natural gas: 204000036 To propane gas: 204000040

Rinnai is continually updating and improving products; therefore, specifications are subject to change without prior notice. Local, state, provincial and federal codes must be adhered to prior to installation.

DIMENSIONS

29.9 in (760 mm)

6.8 in

(172 mm)

22.9 in

(582 mm)

10.1 in (257 mm)

3.3 in

(85 mm)

Rinnai Corporation • 103 International Drive • Peachtree City, GA 30269 • Toll-Free: 1-800-621-9419 • Fax: 678-829-1666 • www.rinnai.us