Red Lion PMKCC User Manual

1

PMKCC1 & PMKCC2

These panel mount kits adapt 1/16 DIN meters to either a 50 mm x 50 mm or
a 68 mm x 68 mm panel cut-out. The kit consists of two metal panel adaptors,
one neoprene gasket and 2 3-48 x 1/2" screws. The adapter plates and gasket are
pinched between the front bezel of the meter and the mounting clip. The 1/2"
long screws may be necessary for thicker panel installations.

Note: If room permits, make the wiring connections after the unit is mounted. If

there is not enough room, pull the wires through before installing as

described below:

1. Pull the wires through the following items in order:

a) One panel adapter plate.

b) Through existing panel opening.

2. Slide the following items onto the counter.

a) Panel gasket

b) Adapter plate

c) Adapter gasket

3. Slide meter through panel cut-out from the front, and center in the panel

opening.

5. Install the mounting clip. Tighten the screws moderately to “pinch” the
gaskets and panels between the front bezel and the mounting clips.

INSTALLATION FOR 1/16 DIN PANEL MOUNT KITS

PMKCC1 PMKCC2 PMKCC3

Three panel mount kits for 1/16 DIN meters are available to replace many existing meters on the
market today. Kits come complete with adapter plates coated with a durable flat black polyurethane
finish, mounting hardware, and gaskets.

DIMENSIONS In inches (mm)

PMKCC1 PMKCC2 PMKCC3

Bulletin No. PMKCC-B
Drawing No. LP0090
Released 02/09

Tel [phone]
Fax [phone]
www.redlion.net

PMKCC3

For mounting proceed as follows:

1. Slide panel gasket over back of meter. (Gasket is supplied in accessory bag
with meter.)

2. Slide meter onto adapter plate.

3. Slide adapter gasket onto meter.

4. Attach meter to adapter plate with mounting clip.

5. Place complete assembly over existing cut-out, lining up the adapter plate
mounting holes with existing holes.

6. Use two mounting screws and nuts provided with Panel Adapter Kit to secure
panel to existing cut-out.

MODEL NO. DESCRIPTION PART NUMBER

PMKCC1

3-PIECE KIT permits mounting in existing

1.97" X 1.97" (50 mm x 50 mm) panel cut-outs
O.A. 2.27" x 2.27" (57.6 mm x 57.6 mm)

PMKCC100

PMKCC2 PMKCC200

PMKCC3 PMKCC300

3-PIECE KIT permits mounting in existing

2.68" x 2.68" (68 mm x 68 mm) panel cut-outs,
O.A. 3" x 3" (76 mm x 76 mm)

2-PIECE KIT permits mounting in existing

2.36" x 2.95" (60 mm x 75 mm) panel cut-outs
O.A. 2.36" x 2.96" (60 mm x 75 mm)
Hole Centers 2.48" (63 mm)

ORDERING INFORMATION

LIMITED WARRANTY

The Company warrants the products it manufactures against defects in materials and workmanship
for a period limited to two years from the date of shipment, provided the products have been stored,
handled, installed, and used under proper conditions. The Company’s liability under this limited
warranty shall extend only to the repair or replacement of a defective product, at The Company’s
option. The Company disclaims all liability for any affirmation, promise or representation with
respect to the products.

The customer agrees to hold Red Lion Controls harmless from, defend, and indemnify RLC against
damages, claims, and expenses arising out of subsequent sales of RLC products or products
containing components manufactured by RLC and based upon personal injuries, deaths, property
damage, lost profits, and other matters which Buyer, its employees, or sub-contractors are or may be
to any extent liable, including without limitation penalties imposed by the Consumer Product Safety
Act (P.L. 92-573) and liability imposed upon any person pursuant to the Magnuson-Moss Warranty
Act (P.L. 93-637), as now in effect or as amended hereafter.

No warranties expressed or implied are created with respect to The Company’s products except those
expressly contained herein. The Customer acknowledges the disclaimers and limitations contained
herein and relies on no other warranties or affirmations.

Red Lion Controls
Headquarters
20 Willow Springs Circle
York PA 17406
Tel [phone]
Fax [phone]

Red Lion Controls

China

Unit 101, XinAn Plaza

Building 13, No.99 Tianzhou Road

ShangHai, P.R. China 200223

Tel [phone]

Fax [phone]

Red Lion Controls

Europe

Printerweg 10

NL - 3821 AD Amersfoort

Tel [phone]

Fax [phone]

Red Lion Controls

India

54, Vishvas Tenement

GST Road, New Ranip,

Ahmedabad-382480 Gujarat, India

Tel [phone]

Fax [phone]