Raypak X Pak 85 User Manual
ECONOPAK
TM
COMMERCIAL HOT WATER SYSTEM
FOR TODAY & TOMORROW
E CONOPAK Features
HOTEL / MOTEL
MULTI FAMILY
RESTAURANT
NURSING HOME
COMMERCIAL LAUNDRY
Proven Raypak Quality • Value • Serviceability • Efficiency
TYPE
WH
• All Non-ferrous Waterways
• Factory mounted and wired stainless steel
pump (Piping by others)
• High Efficiency - Up to 82% thermal efficiency
• Six models available:
90,000 to 399,000 BTU per Hour Input
• Super Fast Recovery - Consistent 140°F water
delivery, even during peak demand times
• Long Service Life (Four times longer than
average tank-type heaters)
• Compact - Fits in small equipment rooms
• Backed by a twenty-year limited warranty
ECONOPAK
TM
- COMMERCIAL HOT WATER SYSTEM
16
33
1
/
4
22
1
/
8
12
1
/
2
5
18
3
1
/
4
2
THERMOSTAT CONN
(ELECTRICAL CONN
ON OTHER SIDE)
GAS
CONN
3/4 NPT PIPE
TO DRAIN
A
11
7
/
8
6
INLET
OUTLET
3
1
/
8
MIN
19
26
1
/
4
1
/
2
K
L
G
FER
GWD
LEDOM
EZIS
TUPNI
)HUTBM(
-NI
ROOD
-TUO
ROOD
YREVOCER
Δ F°001=T
**)HPG(
HTDIW
A
THGIEH
C
SAG
.NNOC
G
RETAW
.NNOC
HJ
EULF
.AID
KL
-TOOF
TNIRP
X
GNIPPIHS
THGIEW
)SBL(
SLAIRETAMELBITSUBMOCMORFECNARAELCMUMINIM
ROOLFTNORF
RAERTHGIR
EDISTFEL
EDISTHGIR
ROODNI
POT
ROODTUO
POTTNEV
1
09-HW 09 •
0911-2/11-54/3574501
ELBITSUBMOCETONEES
661A/N6
531-HW 531 •
23181-2/14/11-64/164/105531
ELBITSUBMOCETONEES
661A/N6
591-HW 591 •
29181-2/14/11-74/164/105041
ELBITSUBMOCETONEES
661A/N6
2
062-HW 462 ••
2628/3228/7264/32/118/1117-35092
*ELBITSUBMOCETONEES
2193
DETCURTSBONU
6
033-HW 433 ••
2334/3524/3364/32/114/3018- 2/165093
*ELBITSUBMOCETONEES
2193
DETCURTSBONU
6
004-HW 993 ••
6934/1928/35612/112/1219-06504
*ELBITSUBMOCETONEES
2193
DETCURTSBONU
6
"RELIEF VALVE" LABEL
1" NPT COUPLING
8.00" DIAMETER
2" NPT
WATER
CONNECTION
3/4" NPT COUPLING
"THERMOMETER" LABEL
MAGNESIUM ANODE
(.840 O.D. X 53")
(2 PLACES)
24 7/16"
DIAMETER
"SCALD DANGER" LABEL
INSULATION
STEEL TANK JACKET
NAMEPLATE/RATING
DECAL
ASME IDENTIFICATION
PLATE WITH
SERIAL NUMBER
(ASME CODE TANKS ONLY)
SERIAL NUMBER
55 5/8"
2" NPT
WATER
CONNECTIONS
3 5/8"
1 1/2" DIAMETER
(3 PLACES)
DRAIN VALVE 3/4" NPT
"TO BOILER" LABEL
6 3/16"
13 3/16"
20 3/16"
"FROM BOILER"
LABEL
3/4" NPT COUPLING
"TANKSTAT" LABEL
EZISKNAT
)SNOLLAG(
EPYT
GNIPPIHS
)SBL(THGIEW
08 EDOC552
08 EDOC-NON891
Drawing 1
MODELS WH-90, WH-135, WH-195
Drawing 1A-Footprint
Drawing 2 Drawing 2A-Footprint
MODELS WH-260, WH-330, WH-400
80-GALLON TANK
Tank must be ordered seperately
Raypak, Inc. reserves the right to make product changes or improvements at any time without notice.
Catalog No.: 3000.11-I Effective: 05-15-10 Replaces: 03-01-08 Litho in U.S.A. ©1994-2010 Raypak, Inc.
Fig. 9287
Fig. 9286
RAYPAK,Inc.
2151 Eastman Avenue • Oxnard, CA 93030
805-278-5300 • Fax 800-872-9725 • www.raypak.com
* Installation on combustible floor requires optional shield. ** Based on manufacturer’s rating. Models available for use with either Natural Gas or Propane. A front clearance of at least 24 inches is recommended for adequate service of burner tray and controls. Ratings shown are for elevations up to 2,000 feet. Ratings should be reduced at the rate of 4% for each 1,000 feet above sea level.
All dimensions are in inches.
All dimensions are in inches.
PUMP
(OPTIONAL)
PUMP COVER
(OPTIONAL)
OUTDOOR
40"
STACKLESS
OUTDOOR
TOP
G GAS
CONNECTION
(C)
INDOOR
DRAFT
MODELS ONLY
38
26-1/2
3-7/8
10-1/4
3-7/8
21-1/4 ELECTRICAL CONNECTION
13-1/4 GAS CONNECTION
OUTLET
WATER
CONN.
INLET
H
8-1/2"
26-1/2"
TAN K
24 7/16
38 1/2
LOWER UPPER
HEATER
26 1/2
X
K
J
A
TAN K
24-7/16
38 1/2
UPPER
LOWER
6-1/4
A
HEATER
26-1/2
12
X
Loading...