Rational SCCWE201E Parts Manual
Service part catalogue
SelfCookingCenter® whitefficiency®
SelfCooking Center 201 - 20 x 1/1 GastronormE
E21SH1110
2/15/2012
3 AC208V (240V) 60Hz UL
CD-Ges_101207
©Copyright by RATIONAL Technical Service
All Rights reserved
SelfCooking Center 201 - 20 x 1/1 GastronormE
E21SH1110
SelfCookingCenter® whitefficiency®
2
3 AC208V (240V) 60Hz UL
2/15/2012
SelfCooking Center 201 - 20 x 1/1 GastronormE
E21SH1110
SelfCookingCenter® whitefficiency®
Pos. Part No. Description Qty.
1 Control panel 1
2 Electrical installation 1
3 ClimaPlus 1
4 Steam generator 1
5 Hot air heating 1
6 Motor and fan wheel 1
7 Interior cabinet 1
8 Door 1
9 Exterior cabinet 1
10 Water 1
11 CleanJet + Care 1
13 Standard accessory 1
2/15/2012
3 AC208V (240V) 60Hz UL
3
SelfCooking Center 201 - 20 x 1/1 GastronormE
E21SH1110
Control panel
4
3 AC208V (240V) 60Hz UL
2/15/2012
SelfCooking Center 201 - 20 x 1/1 GastronormE
E21SH1110
Control panel
Pos. Part No. Description Qty.
1 87.01.005 Control panel insert with overlay *RAT* 1
2 42.00.112 Control pcb *TFT* 1
3 42.00.081 MMI pcb 1
4 40.03.467 Cable On-Off switch MMI 1
5 40.03.515 Cable MMI - TFT 1
6 40.03.516 Cable MMI - CPU 1
7 16.02.062 Dial f. pulse generator 1
9 40.00.404 Pulse generator 1
12 16.01.910 Cover f. control pcb w. gasket 1
13 16.01.908 Sealing f. panel insert 1
2/15/2012
3 AC208V (240V) 60Hz UL
5
SelfCooking Center 201 - 20 x 1/1 GastronormE
E21SH1110
Electrical installation
6
3 AC208V (240V) 60Hz UL
2/15/2012
SelfCooking Center 201 - 20 x 1/1 GastronormE
E21SH1110
Electrical installation
Pos. Part No. Description Qty.
1 40.00.453 Solid state relais 6
2 10.00.061 Pan head screw Torx T20 M4x12 12
3 10.00.061 Pan head screw Torx T20 M4x12 3
4 1204.0120 Tooth lock washer A4,3 3
5 40.03.932 Heat sink big 2 SSR 3
6 40.03.384 Mounting device heat sink SSR 1
7 10.00.507 Pan head screw Torx 5/16" T20 18
9 40.03.985 Cooling fan 1
11 40.03.425 Cooling fan 1
12 2005.0106 Protective grid for cooling fan 1
13 40.03.425 Cooling fan 1
14 40.03.425 Cooling fan 1
15 10.00.564 Pan head screw Torx T20 M4x45 6
16 42.00.080 Control pcb *Sicotronic* 1
17 42.00.128 SD-memory card 4GB 1
20 10.00.243 Spacer M4x8 1
21 1104.0121 Hex nut M4 self locking 1
22 40.03.756 Fixing clip f. pcb 1
23 40.03.533 Fixing clip f. pcb 4
24 40.03.999 Bus cable 1.5m 1
26 40.03.998 Bus cable 1.15m 1
30 40.03.984 Transformer f. cooling fan 1
35 40.03.989 Loudspeaker K 64 WPT 1
A Electrical installation 1
2/15/2012
3 AC208V (240V) 60Hz UL
7
SelfCooking Center 201 - 20 x 1/1 GastronormE
E21SH1110
Electrical installation
8
3 AC208V (240V) 60Hz UL
2/15/2012
SelfCooking Center 201 - 20 x 1/1 GastronormE
E21SH1110
Electrical installation
Pos. Part No. Description Qty.
1 40.02.696 Contactor assembly 1
2 40.03.982 Cable clock switch USA 1
5 40.03.979 Cable contactor-SSR 1
6 40.03.485 Cable control harness 1
8 40.01.329 Dry up protector 183° 1
9 3014.0302 Hex nut M10 for dry-up protector 1
10 40.01.482 Safety temperature limiter 365°C 1
11 3014.0327 Hex nut M10x1,0 1
12 40.03.666 Contactor B&J K3-74B00 190 R 1
13 40.02.641 Auxilliary contact B&J HN10 N/O 1
17 40.03.348 Control transformer T1 1
18 10.01.065 Hex nut M5 1
19 40.03.423 Mounting support transformer 1
20 10.00.709 Hex nut M6 w. locking 1
21 40.02.425 Varistor 1
25 4001.0224 Fuse 6.35x32mm 2
25 40.01.588 Fuse SC-8A 10x38 2
26 40.02.512 Fuse holder 2x6.3A 1
26 40.01.487 Fuse holder 2pol 1
29 10.00.364 Pan head screw Torx M3x12 2
33 40.03.524 Mounting support for fuse holder 1
35 10.00.061 Pan head screw Torx T20 M4x12 2
37 40.01.611 Terminal block grey WKN 70/U 3
39 40.01.610 Earth terminal 20 WKN 70SL/U 1
40 40.03.729 Terminal block grey WKN 35/U 3
44 4001.1203 End plate for mounting rail 5
45 4007.0620 Membrane DGC 29 3
46 4007.0621 Membrane DGC 36 2
54 40.04.122 Cover for Fuse *UL* 2
2/15/2012
3 AC208V (240V) 60Hz UL
9
SelfCooking Center 201 - 20 x 1/1 GastronormE
E21SH1110
ClimaPlus
10
2/15/2012
3 AC208V (240V) 60Hz UL
SelfCooking Center 201 - 20 x 1/1 GastronormE
E21SH1110
ClimaPlus
Pos. Part No. Description Qty.
1 22.00.882 Mounting device f. pressure sensor 2
2 3017.1011 Pressure sensor for humidity control Huba 401 1
3 22.00.908 Inner humidity meas. Piece 1
4 22.00.850 Outer humidity meas. Piece 1
5 22.00.881 Gasket f. hum. meas. Pipe 2
6 1104.0122 Hex combination nut M4 galv 6
7 22.00.525 Hose set f. humidity control 1
8 22.00.725 Humidity control cpl. 1
9 22.00.916 Air inlet pipe 1
10 22.00.958 Drain hose for humidity control 1
11 2066.0527 Hose clamp ø14mm 2
12 22.00.767 Vent cover 1
13 22.00.837 O-ring for humidity control 2
15 10.00.111 Cable clip long 2
2/15/2012
3 AC208V (240V) 60Hz UL
11
SelfCooking Center 201 - 20 x 1/1 GastronormE
E21SH1110
Steam generator
12
2/15/2012
3 AC208V (240V) 60Hz UL
SelfCooking Center 201 - 20 x 1/1 GastronormE
E21SH1110
Steam generator
Pos. Part No. Description Qty.
1 44.00.945 Steam generator insolated 1
2 10.00.709 Hex nut M6 w. locking 2
14 44.01.349 Heating element 1
15 44.01.349 Heating element 1
17 44.00.279 Gasket f. heating element 2
18 10.00.709 Hex nut M6 w. locking 18
19 2066.0519 Hose clamp 35,6mm 1
20 2066.0526 Hose clamp ø46mm 1
21 44.00.207 Emptying pump 1
22 1006.0762 Hex screw M6x10 2
23 1306.0222 Washer A6,4x15x1,5 2
24 44.00.232 Fixing device f. pump steam generator 1
25 10.00.709 Hex nut M6 w. locking 2
26 44.01.223 Drain hose steam generator 1
27 40.04.107 Thermocouple steam generator *B5* 1
29 10.00.414 Cable strap black 120° 1
30 1104.0122 Hex combination nut M4 galv 1
31 2112.1006 Steam hose 50x7mm 1
32 2066.0504 Hose clamp 40-60mm 2
34 44.00.280 Gasket f. heating element+Level elektrode insert 1
35 2920.1300 Level elektrode insert 1
36 10.00.709 Hex nut M6 w. locking 4
37 44.01.408 Filling level electrode 90 mm 1
38 44.01.168 Fixing angle steam generator 1
39 44.01.181 Fixing angle steam generator 1
43 2066.0518 Hose clamp 30mm 2
A 8354.1320 Pump connection spout cpl. 1
2/15/2012
3 AC208V (240V) 60Hz UL
13
SelfCooking Center 201 - 20 x 1/1 GastronormE
E21SH1110
Pump connection spout
14
2/15/2012
3 AC208V (240V) 60Hz UL
SelfCooking Center 201 - 20 x 1/1 GastronormE
E21SH1110
Pump connection spout
Pos. Part No. Description Qty.
1 2118.1000 Pump connection spout 1
2 2120.1259 Stop plug 10mm 1
3 2110.1008 Silicon hose ø10x2mm 1
4 2066.0527 Hose clamp ø14mm 2
5 2066.0530 Hose clamp ø16.4mm 1
6 2062.0331 Junction pressure hose GS 10 1
7 4005.0101 Tie rap 145 mm 1
2/15/2012
3 AC208V (240V) 60Hz UL
15
SelfCooking Center 201 - 20 x 1/1 GastronormE
E21SH1110
Hot air heating
16
2/15/2012
3 AC208V (240V) 60Hz UL
SelfCooking Center 201 - 20 x 1/1 GastronormE
E21SH1110
Hot air heating
Pos. Part No. Description Qty.
1 40.03.410 Mating flange f. heating assembly 2
2 40.03.655 Heating assembly 1
3 40.03.655 Heating assembly 1
4 10.00.109 Hex screw M5x23 12
5 10.01.076 Cap nut M5*A2 2
6 40.03.415 Gasket f. heating assembly 2
7 1107.0103 Star lock ø3 4
17 50.00.844 Nozzle f. moistening 2
18 50.00.846 Union nut M12x13.2 N 2
2/15/2012
3 AC208V (240V) 60Hz UL
17
SelfCooking Center 201 - 20 x 1/1 GastronormE
E21SH1110
Motor and fan wheel
18
2/15/2012
3 AC208V (240V) 60Hz UL
Loading...