Philips HTS-3265-Mk1 Service Manual
1 - 1
HTS3265/75
©
Copyright 2008 Philips Consumer Electronics B.V. Eindhoven, The Netherlands
All rights reserved. No part of this publication may be reproduced, stored in a retrieval syst em or
transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise
without the prior permission of Philips.
Published b
y LM0815 Service Audio Printed in The Netherlands Subject to modification
DVD Home Theater System
Version 1.0
TABLE OF CONTENTS
Location of PCB Boards ............................................ 1-2
Versions Variation ...................................................... 1-2
Measurement Setup .................................................. 1-4
Specifications............................................................ 1-3
Service Aids.............................................................. 1-5
ESD & Safety Instruction .......................................... 1-6
Lead-free solding Information.................................... 1-7
Setting procedure & Repair Instructions........................ 2
Disassembly Instructions & Service positions .............. 3
Block & Wiring Diagram ................................................ 4
VFD+JACK+STANDBY Board......................................5
Main Board.................................................................... 6
Power Board.................................................................. 7
Service Manual
Service
Tfswjdf
Tfswjdf
Mechanical Exploded View & Part List .......................... 8
Revision List .................................................................. 9
3139 785 34000
GB
Chapter
LOCATION OF PCB BOARDS
MAIN PCB
POWER PCB
JACK PCB
VFD PCB
STANDBY PCB
1 - 2
VERSION VARIATION:
Type/Versions
Features
Output Power - 600W
Voltage (220V~240V)
MP3 Link
SERVICE SCNARIO MATRIX:
Type/Versions
HTS3265
/75
x
x
x
HTS3265
Board in used
Main Board
Power Board
VFD+JACK+STANDBY Board
*Bd = Board Level Repair
/75
Bd
Bd
Bd
SPECIFICATIONS
1 - 3
AMPLIFIER
Total output power :
- Home Theatre mode ................... ........................ ........ 600 W
Frequency Response ...... ......... .......... 180 Hz – 18 kHz / ±3 dB
Signal-to-Noise Ratio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . > 60 dB (A-weighted)
Input Sensitivity
- AUX 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 400 mV
- AUX 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 400 mV
- MP3 LINK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 400 mV
RADIO
Tuning Range . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FM 87.5-108 MHz
...............................................................................(50/100 kHz)
............................................................................26 dB Quieting
Sensitivity ............. ................ ....... ......... ................ .... FM 22 dBf,
IF Rejection Ratio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FM 60 dB
Signal-to-Noise Ratio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FM 50 dB
Harmonic Distortion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FM Mono 3%
............................................................................ FM Stereo 3%
Frequency Response ...... ......... ...... FM 180 Hz–10 kHz / ±6 dB
Stereo Separation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FM 26 dB (1 kHz)
Stereo Threshold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FM 29 dB
DISC
Laser Type . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Semiconductor
Disc Diametre . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12cm / 8cm
Video Decoding . .. . .. .. .. .. .. .. .. . .. .. .. .. .. .. .. . .. .. .. . MPEG-1 / MPEG-2 /
.................................................................... / DivX 3/4/5/6, Ultra
Video DAC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 Bits
Signal System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . PAL / NTSC
Video Format . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4:3 / 16:9
Video S/N .... ....... ....... ....... ....... ................................. ....... . 56 dB
Composite Video
Output . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1.0 Vp-p, 75Ω
Frequency Response ...... ......... ........... 4 Hz–20 kHz (44.1 kHz)
................................................................ 4 Hz–22 kHz (48 kHz)
................................................................ 4 Hz–44 kHz (96 kHz)
PCM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . IEC 60958
Dolby Digital ...... ......... .................... ....... IEC 60958, IEC 61937
DTS .... ....... ....... ....... ....... ....................... IEC 60958, IEC 61937
FRONT AND REAR SPEAKERS
System . . . . . . . . . . . . . . ............................................ Full range satellite
Impedance . . . . . . . . . . . . . . ..............................................................3 Ω
Speaker drivers ...... .................................. 3” full range speaker
Frequency response . . . . . . . . . . . . . . .......................... 150 Hz – 20 kHz
Dimensions . . . . . . . . . . . . . . ................................. 103 x 203 x 71 (mm)
...................................................................................(w x h x d)
Weight .... ....... ........................................................0.54 kg/each
CENTRE SPEAKER
System . . . . . . . . . . . . . . ............................................ Full range satellite
Impedance . . . . . . . . . . . . . . ..............................................................6 Ω
Speaker drivers ...... .................................. 3” full range speaker
Frequency response . . . . . . . . . . . . . . .......................... 150 Hz – 20 kHz
Dimensions . . . . . . . . . . . . . . ................................. 244 x 105 x 74 (mm)
...................................................................................(w x h x d)
Weight .... ....... .................................................................0.84 kg
SUBWOOFER
Impedance . . . . . . . . . . . . . . ..............................................................6 Ω
Speaker drivers ...... .................................. 165mm (6.5”) woofer
Frequency response . . . . . . . . . . . . . . ............................40 Hz – 150 Hz
Dimensions . . . . . . . . . . . . . . ............................... 163 x 363 x 369 (mm)
...................................................................................(w x h x d)
Weight .... ....... .................................................................5.08 kg
Speci cations subject to change without prior notice.
MAIN UNIT
Power Supply Rating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 220 - 240 V~;
.......................................................................................... 50 Hz
Power Consumption . .. .. .. ... .. ... .. .. .. ... .. ... .. .. .. ... .. .. .. ... .. ... .. .. 100 W
Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 360 x 58 x 332 (mm)
...................................................................................(w x h x d)
Weight .... ....... ....... ....... ....... ................................. ....... ......2.9 kg
1 - 4
LEVEL METER
e.g. Sennheiser UPM550
with FF-filter
S/N and distortion meter
e.g. Sound Technology ST1700B
L
R
DUT
CD
Use Audio Signal Disc
(replaces test disc 3)
SBC429 4822 397 30184
Bandpass
250Hz-15kHz
e.g. 7122 707 48001
LF Voltmeter
e.g. PM2534
DUT
RF Generator
e.g. PM5326
S/N and distortion meter
e.g. Sound Technology ST1700B
Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz).
Ri=50
Tuner FM
MEASUREMENT SETUP
Service Tools:
Universal Torx driver holder .................................4822 395 91019
Torx bit T10 150mm ...........................................4822 395 50456
Torx driver set T6-T20 .........................................4822 395 50145
Torx driver T10 extended .....................................4822 395 50423
Compact Disc:
SBC426/426A Test disc 5 + 5A ...........................4822 397 30096
SBC442 Audio Burn-in test disc 1kHz .................4822 397 30155
SBC429 Audio Signals disc .................................4822 397 30184
Dolby Pro-logic Test Disc ....................................4822 395 10216
SERVICE AIDS
HANDLING CHIP COMPONENTS
1 - 5
1 - 6
1 - 7
System , Region Code , etc. Setting Produre
2 - 12 - 1
1)System Reset
a) Press “OPTIONS“ button on R/C,TV will show setup menu
b) Select the menu using the and
c) Go preference page to do system reset
2)Region Code Change
a) In open model, press”9” “9“ “9“ “9“ on R/C,then input desired
number to change region code :
1 USA
2 EU
3 AP
4 Australia ,NZ , Latam
5 Russia , INDIA
6 CHINA
3)Version Control Change
a) In open model, press “1“ “5“ “9“ on R/C
b) Press “ok” button to con rm
c) TV will show message as below:
on R/C
7) Upgrading new sofeware
a) Copy “sofeware les” into a CD-R
b) Open the CD Door,then insert the CD-R program disc
c) Close the CD Door
d) VFD will show:
“Loading“
“Erase” -- erase the ash memory
“Writing” about 1 minute
“done “
* the system will switch off and on again automatically.
e) OSD will show:
upgrade le detected
Do you wish to continue with
the sofeware upgrade?
OK Cancel
Current model HTS3265/75
Ver00.06.02_80219_00 region : 4
Servo: 5B.62.00.00
8032: 05.00.04.06 RISC: FF.00.04.05
IF current model does not match you set use down arrow
key on the remote to change
OK
4)Password Change
a) Press “OPTIONS “ button on R/C,TV will show setup menu
b) Select the menu using the and on R/C
c) Go preference page select “password“ to change
* 000000 is default password supplied.
5)Check on the Sofeware Version
a) Open the CD Door
b) Press “INFO“ button on R/C
c) TV will show the version on screen
6)Trade model
a) Press “Open/Close “ button on R/C
b) Press “2” “5” “9” on R/C,VFD will display “TRA ON “ or “TRA
OFF“
f) Select “OK”, OSD will show:
upgrade in process...
V326X
please do not unplug or
switch off the device.
CAUTION!
This information is confi dential and may not be
distributed.Only a qualifi ed se rvice person should
reprogram the Region Code.
REPAIR INSTRUCTIONS (part one)
2 - 22 - 2
Loading...