Philips HTS-3011-Mk2 Service Manual

1 - 1

HTS3011/98

All rights reserved. No part of this publication may be reproduced, stored in a retrieval syst em or transmitted, in any form or by any means, electronic, mechanical, photo copying, or otherwise without the prior permission of Philips.

Published b

y LM0832 Service Audio Printed in The Netherlands Subject to modification

DVD Home Theater System

Version 1.0

TABLE OF CONTENTS

Location of PCB Boards ............................................ 1-2

Versions Variation ...................................................... 1-2

Measurement Setup .................................................. 1-4

Specifications............................................................ 1-3

Service Aids.............................................................. 1-5

ESD & Safety Instruction .......................................... 1-6

Lead-free solding Information.................................... 1-7

Setting procedure & Repair Instructions........................2

Disassembly Instructions & Service positions .............. 3

Block & Wiring Diagram ................................................ 4

VFD+STANDBY+VOL+MP3+BRACKET Board............ 5

Main Board.................................................................... 6

Power Board.................................................................. 7

Service Manual

Service

Tfswjdf

Mechanical Exploded View & Part List .......................... 8

Revision List .................................................................. 9

3139 785 34480

Chapter

This service manual is for HTS3011/98 Second Generation model, which is different from the previous generation HTS3011/98 models.

For Second Generation model the serial number begin with MF2AXXXXXXXXXX. Refer to the rating label illustration at right.

Second Generation

LOCATION OF PCB BOARDS

1 - 2

VERSION VARIATION:

Type/Versions

Features

Output Power - 200W

Voltage (110V~240V)

Aux In

SERVICE SCNARIO MATRIX:

Type/Versions

HTS3011

/98

HTS3011

Board in used

Main Board

Power Board

VFD+STANDBY+VOL+MP3+BRACKETBoard

*C = Component Level Repair

/98

SPECIFICATIONS

1 - 3

AMPLIFIER

Total output power :

- Home Theatre mode ................... ............. ........... .......... 200 W

Frequency Response ...... ......... .......... 180 Hz – 18 kHz / ±3 dB

Signal-to-Noise Ratio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . > 60 dB (A-weighted)

Input Sensitivity

- AUX 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 400 mV

- AUX 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 400 mV

RADIO

Tuning Range . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FM 87.5-108 MHz

...............................................................................(50/100 kHz)

............................................................................26 dB Quieting

Sensitivity ............. ................ ................ ................ ..... FM 22 dBf

IF Rejection Ratio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FM 60 dB

Signal-to-Noise Ratio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FM 50 dB

AM Suppression Ratio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FM 30 db

Harmonic Distortion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FM Mono 3%

............................................................................ FM Stereo 3%

Frequency Response ...... ......... ...... FM 180 Hz–10 kHz / ±6 dB

Stereo Separation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FM 26 dB (1 kHz)

Stereo Threshold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FM 29 dB

DISC

Laser Type . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Semiconductor

Disc Diametre . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12cm / 8cm

Video Decoding . .. . .. .. .. .. .. .. .. . .. .. .. .. .. .. .. . .. .. .. . MPEG-1 / MPEG-2 /

.................................................................... / DivX 3/4/5/6, Ultra

Video DAC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 Bits

Signal System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . PAL / NTSC

Video Format . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4:3 / 16:9

Video S/N .... ....... ....... ....... ....... ....... ................................. . 56 dB

Composite Video

Output . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1.0 Vp-p, 75Ω

Frequency Response ...... ......... ........... 4 Hz–20 kHz (44.1 kHz)

................................................................ 4 Hz–22 kHz (48 kHz)

................................................................ 4 Hz–44 kHz (96 kHz)

PCM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . IEC 60958

Dolby Digital ...... .................... ......... ....... IEC 60958, IEC 61937

FRONT AND REAR SPEAKERS

System . . . . . . . . . . . . . . ............................................ Full range satellite

Impedance . . . . . . . . . . . . . . ..............................................................4 Ω

Speaker drivers ...... ...................................3” full range speaker

Frequency response . . . . . . . . . . . . . . .......................... 150 Hz – 20 kHz

Dimensions . . . . . . . . . . . . . . ............................. 100 x 95.5 x 83.5 (mm)

...................................................................................(w x h x d)

Weight .... ....... ........................................................0.47 kg/each

CENTRE SPEAKER

System . . . . . . . . . . . . . . ............................................ Full range satellite

Impedance . . . . . . . . . . . . . . ..............................................................8 Ω

Speaker drivers ...... ...................................3” full range speaker

Frequency response . . . . . . . . . . . . . . .......................... 150 Hz – 20 kHz

Dimensions . . . . . . . . . . . . . . ............................. 100 x 99.5 x 83.5 (mm)

...................................................................................(w x h x d)

Weight .... ....... .................................................................0.52 kg

SUBWOOFER

Impedance . . . . . . . . . . . . . . ..............................................................8 Ω

Speaker drivers ...... ................................. 165 mm (6.5”) woofer

Frequency response . . . . . . . . . . . . . . ............................40 Hz – 150 Hz

Dimensions . . . . . . . . . . . . . . ............................ 131 x 315.5 x 386 (mm)

...................................................................................(w x h x d)

Weight .... ....... ...................................................................3.6 kg

Speci cations subject to change without prior notice.

MAIN UNIT

Power Supply Rating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 110-240 V; 50-60 Hz

Power Consumption . .. .. .. ... .. ... .. .. .. ... .. ... .. .. .. ... .. ... .. .. .. ... .. ... . 40 W

Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 360 x 55 x 332 (mm)

...................................................................................(w x h x d)

Weight .... ....... ....... ....... ....... ................................. ....... ....2.58 kg

1 - 4

LEVEL METER

e.g. Sennheiser UPM550

with FF-filter

S/N and distortion meter

e.g. Sound Technology ST1700B

DUT

Use Audio Signal Disc (replaces test disc 3)

SBC429 4822 397 30184

Bandpass

250Hz-15kHz

e.g. 7122 707 48001

LF Voltmeter

e.g. PM2534

DUT

RF Generator

e.g. PM5326

S/N and distortion meter

e.g. Sound Technology ST1700B

Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz).

Ri=50

Tuner FM

MEASUREMENT SETUP

Service Tools:

Universal Torx driver holder .................................4822 395 91019

Torx bit T10 150mm ...........................................4822 395 50456

Torx driver set T6-T20 .........................................4822 395 50145

Torx driver T10 extended .....................................4822 395 50423

Compact Disc:

SBC426/426A Test disc 5 + 5A ...........................4822 397 30096

SBC442 Audio Burn-in test disc 1kHz .................4822 397 30155

SBC429 Audio Signals disc .................................4822 397 30184

Dolby Pro-logic Test Disc ....................................4822 395 10216

SERVICE AIDS

HANDLING CHIP COMPONENTS

1 - 5

1 - 6

1 - 7

System , Region Code , etc. Setting Produre

2 - 12 - 1

1)System Reset

a) Press “OPTIONS“ button on R/C,TV will show setup menu

b) Select the menu using the and

c) Go preference page to do system reset

2)Region Code Change

a) In open model, press”9” “9“ “9“ “9“ on R/C,then input desired

number to change region code :

1 USA

2 EU

3 AP

4 Australia ,NZ , Latam

5 Russia , INDIA

6 CHINA

3)Version Control Change

a) In open model, press “1“ “5“ “9“ on R/C

b) Press “ok” button to con rm

c) TV will show message as below:

on R/C

7) Upgrading new sofeware

a) copy “sofeware  les” into a CD-R

b) open the CD Door,then insert the CD-R program disc

c) close the CD Door

d) VFD will show:

“Loading“

“Erase” -- erase the  ash memory

“Writing” about 1 minute

“done “

* the system will switch off and on again automatically.

e) OSD will show:

upgrade  le detected

Do you wish to continue with

the sofeware upgrade?

OK Cancel

Current model HTS3011/98

Version: 00.00.07.01 region :3

Servo:5B.62.00.00

8032:05.00.04.06 RISC: FF.00.04.05

IF current model does not match you set use down arrow

key on the remote to change

4)Password Change

a) Press “OPTIONS “ button on R/C,TV will show setup menu

b) Select the menu using the and on R/C

c) Go preference page select “password“ to change

* 000000 is default password supplied.

5)Check on the Sofeware Version

a) Open the CD Door

b) Press “INFO“ button on R/C

c) TV will show the version on screen

6)Trade model

a) Press “Open/Close “ button on R/C

b) Press “2” “5” “9” on R/C,VFD will display “TRA ON “ or “TRA

OFF“

f) select “OK”, OSD will show:

upgrade in process...

V3011

please do not unplug or

switch off the device.

CAUTION!

This information is conﬁ dential and may not be distributed.Only a qualiﬁ ed se rvice person should reprogram the Region Code.

REPAIR INSTRUCTIONS

Ok or No

Chang F901

Check D902/903/904/908 D909/911/912

OK or No

CHANG D902/903/904/908 D909/911/912

Check Repair IC901/IC902/IC903 /Q902 or output circuit

2 - 22 - 2

+ 19 hidden pages