ORDER No. AED0501035
PANASONIC AUTOMOTIVE SYSTEMS COMPANY
Volkswagen
CQ-EV1571GC
AM/FM MPX ELECTRONIC TUNING
RADIO with 6-Disc CD Changer (MP3)
PART No. C30 035 195 A
VEHICLE : Golf 5, Passat 6
DESTINATION : Europe
PRODUCED AFTER : Aug., 2005
Note: CQ-EV1571GC supports MP3 but CQ-
EV1570GC does not.
Specifications*
General
Power Supply 12V DC (9V - 17V)
Test voltage 14.4V
Negative ground
Current Consumption 2A at 0.5W
Maximum Power Output 20W x 4ch; Standby typ. 500uA
Loudspeaker Impedance 4 ohms
FM Stereo Radio
Frequency Range 87.5 - 108.0 MHz
AM Radio
Frequency Range 531 - 1602 kHz
CD Changer (YGFD13311)
Frequency Response 40 - 20,000Hz (+/- 3dB)
Signal to Noise Ratio More than 74dB
Channel Separation More than 60dB
Dimensions** 246(W)x128(H)x193.3(D)mm
Weight** 2830g
* Specifications and the design are subject to possible modification
without notice due to improvements.
** Dimensions and Weight shown are approximate.
© 2005 Matsushita Electric Industrial Co., Ltd. All
rights reserved. Unauthorized copying and
distribution is a violation of law.
Volkswagen / CQ-EV1571GC
CONTENTS
Page Page
1 FEATURES 2
2 SYSTEM BLOCK DIAGRAM
3 VIEW AND CONNECTORS
4 WIRING CONNECTION
5 TERMINALS DESCRIPTION
6 IC BLOCK DIAGRAM
7 REPLACEMENT PARTS LIST 9
2
8 EXPLODED VIEW (Unit)
9 WIRING DIAGRAM
3
4
10 SCHEMATIC DIAGRAM
11 BLOCK DIAGRAM
5
6
1 FEATURES
•
• PLL (Phase Locked Loop) synthesized tuning.
• •
•
• 12-FM, 12-AM presets with preset scan.
• •
•
• Treble/Middle/Bass/Balance/Fader Control.
• •
•
• GALA (Speed-dependent volume control)
• •
•
• RDS REG (Automatic frequency for regional stations)
• •
•
• TIM (Traffic Information Messages)
• •
•
• TP (Speed-dependent volume control)
• •
•
• MIX Mode
• •
•
• IDC2 CD changer deck.
• •
•
• External CD Changer control.
• •
•
• MP3 Playback from CD-R/RW.
• •
•
• 8cm CDs unsupported.
• •
•
• Anti-Theft Coding.
• •
16
17
21
23
2 SYSTEM BLOCK DIAGRAM
2
3 VIEW AND CONNECTORS
Volkswagen / CQ-EV1571GC
3
Volkswagen / CQ-EV1571GC
4 WIRING CONNECTION
4
5 TERMINALS DESCRIPTION
Volkswagen / CQ-EV1571GC
5.1. Main Block
Pin
No.
1 CONTRAST voltage output for contrast level
2 BATT SENSE - I 3.6 3.6 3.6
3 CDC REMO async. Data out O 3.6 3.6 3.6
4 CDC DATA sync.Data input from Master I 3.5 3.5 3.5
5 CDC CLK sync.Clk input from Master I 3.5 3.5 3.5
6 NC - - 3.5 3.5 3.5
7 CNVSS pull down - 0 0 0
8 XCin - O 3.6 3.6 3.6
9 XCout - O 0 0 0
10 RESET reset - 3.6 3.6 3.6
11 X OUT crystal - 1.9 1.9 1.9
12 VSS ground - 0 0 0
13 XIN crystal - 1.6 1.6 1.6
14 VCC v osc - 3.6 3.6 3.6
15 NMI - I 3.6 3.6 3.6
16 T MUT - I 0 0 0
17 6.1V DET ext. IRQ signal for 6.1V
18 TUNER IRQ - I 3.4 3.4 3.4
19 CAN ENA - O 0 0 0
20 LCD ILL PWM output line for display
21 CAN RX CAN-receive pin (in PWR-down
22 CAN TX CAN-transmit pin O 3.6 3.6 3.6
23 CAN ERR - I 3.6 3.6 3.6
24 DC/DC OSC DC/DC external Clock (600-
25 NC - O 3.6 3.6 3.6
26 KEY ILL PWM output line for key
27 I2C2 - I 0 0 0
28 I2C2 - O 0 0 0
29 DATA T send data to LCD or
30 DATA R receive data
31 CLK Clock-line for LCD/EEPROM
32 BUSY - O 3.6 3.6 3.6
33 IDC SIM sync.serial output O 0 0 0
34 IDC SOM sync.serial input I 0.8 0.8 0.8
35 IDC SCKM serial clock O 3.1 3.1 3.1
36 IDC ON enable signal for serial
37 IDC MUTE analog-mute for IDC-Audio I 0 0 0
38 CD CD CONT could be switchd by P.ON O 3.7 3.7 3.7
39 IDC 5V ON switch 5V for indash CD deck O 3.7 3.7 3.7
40 NC - O 3.7 3.7 3.7
41 P.TIM - O 3.7 3.7 3.7
42 P.ON main power supply ON O 3.7 3.7 3.7
43 NC - O 3.7 3.7 3.7
44 FLASH
45 E2CS EEPROM Chip select line O 0 0 0
46 IDC 8V ON switch 8V for indash CD deck O 3.7 3.7 3.7
47 WDT
48 EXT.RADIO.
49 CAN.STB - O 3.7 3.7 3.7
50 NC - O 3.7 3.7 3.7
Port Description I/O FM
CSCCE
SERVICE
ON
IC601 : MC32C/83
(V)AM(V)CD(V)
O 2.0 2.0 2.0
setting (DA-converter output)
I 3.6 3.6 3.6
detection
O 0.7 0.7 0.7
illumination
I 1.8 1.8 1.8
ext IRQ)
O 2.1 2.1 2.1
650kHz)
O 3.1 3.1 3.1
illumination
O 0 3.6 0
EEPROM(Flash)
I 0 0 0
fromEEPROM(Flash)
O 3.6 3.6 3.6
SPI(Flash)
O 3.6 3.6 3.6
communication
Flash chip select I 3.7 3.7 3.7
- O 1.9 1.9 1.9
- O 3.7 3.7 3.7
Pin
No.
51 NC - O 3.5 3.7 3.5
52 NC - O 3.5 3.7 3.5
53 NC - O 3.5 3.7 3.5
54 LCD CS LCD Chip select line(please use
55 LCD A0 LCD -control-pin for order/data
56 LCD RESET reset line for LCD-display O 3.5 3.6 3.5
57-59NC - I 3.5 3.6 3.5
60 VCC v osc - 3.5 3.6 3.5
61 B M CONT ON/OFF-control for +B monitor O 3.5 3.6 3.5
62 VSS ground - 0 0 0
63 LCD TM - I 1 1 1
64 +B DET analog+B-detection I 2.5 2.5 2.5
65-69NC - I 1.9 1.9 1.9
70 V2 MDNI - I 0.9 0.9 0.9
71 EXP IRQ key matrix IRQ I 3.5 3.5 3.5
72 DSP RESET
73 TIMER IRQ external wakeup timer for WDT-
74 NC - O 3.5 3.5 3.5
75 NC - O 0 0 0
76 NC - O 0 0 0
77 TUN2 READY Tuner2 message ready signal I 3.5 3.5 3.5
78 TUN1READY Tuner1 message ready signal I 3.5 3.5 3.5
79 TUNER
80 NC - I 3.5 3.5 3.5
81 AGC BUF1 - I 0.6 0.6 0.6
82 AGC BUF2 - I 0.6 0.6 0.6
83 ANT2 OPEN AD-port to check antenna2
84 ANT2
85 ANT1 OPEN AD-port to check antenna1
86 ANT1
87 PSW power switch I 3.6 3.6 3.6
88 LOAD - I 3.6 3.6 3.6
89 EJECT - I 3.6 3.6 3.6
90 ANT1 CONT switching Antenna-+B on/off O 3.6 3.6 3.6
91 ANT2 CONT switching Antenna-+B on/off O 3.6 3.6 3.6
92 NC - O 3.6 3.6 3.6
93 NC - O 3.6 3.6 3.6
94 AVSS GND - 0 0 0
95 CLIP IN clip in I 3.6 3.6 3.6
96 V REF connect to P.ON 3.3V(P.ON <=
97 AVCC connect to Vdd - 3.6 3.6 3.6
98 I2C SCL I2C-bus clock line O 3.3 3.3 3.3
99 I2C SDA I2C-bus data line O 3.3 3.3 3.3
100 DSP RESET - O 3.6 3.6 3.6
Port Description I/O FM
/CS1 as chips select signal not
CS2)
desision
MON
QUAL
SHORT
SHORT
service
voltage
AD-port to check antenna2
voltage
voltage
AD-port to check antenna1
voltage
Vdd)
- I 3.3 3.3 3.3
- I 3.5 3.5 3.5
(V)AM(V)CD(V)
O 3.5 3.7 3.5
O 0 0 0
I 0 0 0
I 0 0 0
I 0.6 0.6 0.6
I 0 0 0
I 0.6 0.6 0.6
- 3.6 3.6 3.6
5
Volkswagen / CQ-EV1571GC
6 IC BLOCK DIAGRAM
6.1. Main Block
IC201 : C1EA00000035
IC603 : C1EB00000097
6
IC602 : C3EBFG000022
Volkswagen / CQ-EV1571GC
IC607 : C0JBAZ001229
IC604 : C0EBF0000351
IC605 : C0JBAZ001652
IC608 : C0CBADE00064
IC609 : C0CBABD00058
IC606, 623 : YEAMC14584BE
IC611 : C0CBABA00018
7
Volkswagen / CQ-EV1571GC
IC612 : C0ABBA000022
IC617 : C0DBFHZ00002
IC613 : C0CBCGE00001
IC614 : C0EBJ0000235
IC619 : C0EBB0000136
6.2. Display Block
IC401 : C1ZBZ0002116
IC616 : C0ABCA000088
IC404, 405, 407, 408 : C0DBABZ00002
8
7 REPLACEMENT PARTS
LIST
Notes :
1. Be sure to make your orders of replacement parts
according to this list.
2. Important safety notice: Components, identified by
have special characteristics important for safety. When
replacing any of these components, use only
manufacturer´s specified parts.
3. Location keys in the remarks column indicates the general
location of the parts shown in the exploded drawing, as in a
road map.
4. The marking (RTL) indicates that Retention Time is limited
for this item. After the discontinuation of assembly in
production, the item will continue to be available for a
specific period of time. The retention period of availability is
dependent on the type of assembly, and in accordance with
the laws governing part and product retention. After the end
of this period, the assembly will no longer be available.
5. “E” marks in remarks column are indicated supply parts of
Panasonic Automotive Systems Europe GmbH (PASE).
Ref.
No.
[MGCAP00044] Main Block
IC´s and TRANSISTORs
IC201 C1EA00000035 IC
IC601 MC32C/83 IC
IC602 C3EBFG000022 IC E
IC603 C1EB00000097 IC
IC604 C0EBF0000351 IC
IC605 C0JBAZ001652 IC
IC606 YEAMC14584BE IC
IC607 C0JBAZ001229 IC
IC608 C0CBADE00064 IC E
IC609 C0CBABD00058 IC
IC610 C0DBAHA00022 IC E
IC611 C0CBABA00018 IC
IC612 C0ABBA000022 IC
IC613 C0CBCGE00001 IC
IC614 C0EBJ0000235 IC
IC615 C2HBCJ000007 IC E
IC616 C0ABCA000088 IC E
IC617 C0DBFHZ00002 IC
IC619 C0EBB0000136 IC
IC623 YEAMC14584BE IC
IC625 C1BB00000877 IC E
PAC1 J3CCAC000002 Tuner Pack E
Q602 B1GDGFEJ0001 Transistor
Q603 B1ABCD000006 Transistor
Q604 2SB1073TX Transistor
Q605 B1ABCD000006 Transistor
Q606 2SB1073TX Transistor
Q609 B1DFAD000001 Transistor
Q610 B1DFAD000001 Transistor
Q612 B1ADKD000008 Transistor
Q613 B1ABCD000006 Transistor
Q614 2SB1073TX Transistor
Q615 B1ABCD000006 Transistor
Q616 2SB1073TX Transistor
Q617 B1ABCD000006 Transistor
Q618 2SD1259AJL Transistor
Q619 2SD1259AJL Transistor
Q620 B1GDCFEN0007 Transistor
Q621 B1ABCD000006 Transistor
Q622 B1ABCD000006 Transistor
Q623 2SB1073TX Transistor
Q624 B1ABCD000006 Transistor
Part No. Part Name & Description Remarks
mark
Volkswagen / CQ-EV1571GC
Ref.
No.
Q625 B1GDGFEJ0001 Transistor
Q626 B1GDGFEJ0001 Transistor
Q630 B1ADKD000008 Transistor
Q631 B1ABCD000006 Transistor
Q634 B1DHEC000010 Transistor E
DIODEs
D601 YEADDSM3MA2T Diode
D602 B0ACCJ000020 Diode
D609 B0ACCJ000020 Diode
D612 B0JCDD000007 Diode
D613 B0ACCJ000020 Diode
D615 YEADEC10DS1 Diode
D621 MAZ81800ML Diode
D623 B0JCDD000007 Diode
D624 B0JCDD000007 Diode
D650 MAZ80330HL Diode
D651 MAZ80470HL Diode E
D652 MAZ80330HL Diode
D653 MAZ80470HL Diode E
D654 B0JCDD000007 Diode
D671 MAZ822000L Diode
D673 MA3J142E0L Diode
D674 B0ACCJ000020 Diode
D675 B0JCDD000007 Diode
D676 B0JCDD000007 Diode
D678 MAZ81500LL Diode E
D679 MAZ81500LL Diode E
D702 MA8056LMHTX Diode
D711 B0ACCJ000020 Diode
D712 B0ACCJ000020 Diode
D713 B0JCDD000007 Diode
CAPACITORs
C105 F1H1H101A231 100PF 50WV
C106 F1H1H101A231 100PF 50WV
C107 ECA1VM101I 100µF 35WV
C108 ECA1VM101I 100µF 35WV
C120 YECUS1E104ZF 0.1µF 25WV
C121 YECUS1E104ZF 0.1µF 25WV
C122 YECUS1E104ZF 0.1µF 25WV
C123 YECUS1E104ZF 0.1µF 25WV
C132 F1G1H102A537 0.001µF 50WV
C133 F1G1H102A537 0.001µF 50WV
C134 F1G1H102A537 0.001µF 50WV
C135 F1G1H102A537 0.001µF 50WV
C136 F1G1H102A537 0.001µF 50WV
C137 F1G1H102A537 0.001µF 50WV
C138 YECUZ1H331JM 330PF 50WV
C139 YECUZ1H331JM 330PF 50WV
C140 YECUZ1H331JM 330PF 50WV
C141 YECUZ1H331JM 330PF 50WV
C202 YECUS1E104ZF 0.1µF 25WV
C203 ECA1CM470I 47µF 16WV
C204 ECA1HM010I 1µF 50WV
C205 YECUS1E104ZF 0.1µF 25WV
C253 YECUS1C224KX 0.22µF 16WV
C255 F1H1H104A854 0.1µF 50WV
C257 YECUS1C224KX 0.22µF 16WV
C259 F1H1H104A854 0.1µF 50WV
C262 F1H0J1050010 1µF 6.3WV
C263 F1H0J1050010 1µF 6.3WV
C264 F1G1H122A401 1200PF 50WV
C265 F1H0J1050010 1µF 6.3WV
C266 F1G1E181A043 180PF 25WV
C269 F1G1H680A565 68PF 50WV E
C271 F1J1H221A665 220PF 50WV
C272 F1J1H221A665 220PF 50WV
C273 F1J1H221A665 220PF 50WV
C274 F1J1H221A665 220PF 50WV
C304 F1G1H471A537 470PF 50WV E
Part No. Part Name & Description Remarks
9
Volkswagen / CQ-EV1571GC
Ref.
No.
C310 F1G1H680A565 68PF 50WV E
C353 YECUS1C224KX 0.22µF 16WV
C355 F1H1H104A854 0.1µF 50WV
C357 YECUS1C224KX 0.22µF 16WV
C359 F1H1H104A854 0.1µF 50WV
C362 F1H0J1050010 1µF 6.3WV
C363 F1H0J1050010 1µF 6.3WV
C364 F1G1H122A401 1200PF 50WV
C365 F1H0J1050010 1µF 6.3WV
C366 F1G1E181A043 180PF 25WV
C368 F1H0J2250007 2.2µF 6.3WV
C369 F1H0J2250007 2.2µF 6.3WV
C371 F1J1H221A665 220PF 50WV
C372 F1J1H221A665 220PF 50WV
C373 F1J1H221A665 220PF 50WV
C374 F1J1H221A665 220PF 50WV
C601 ECA1EM102B 1000µF 25WV
C602 ECA1EM102B 1000µF 25WV
C603 ECA1EM102B 1000µF 25WV
C604 ECA1EM102B 1000µF 25WV
C605 F1J1H221A665 220PF 50WV
C606 F1H1H681A189 680PF 50WV
C607 F1H1H681A189 680PF 50WV
C608 F1H1H681A189 680PF 50WV
C609 F1H1H681A189 680PF 50WV
C611 F1J1H221A665 220PF 50WV
C612 F1J1H221A665 220PF 50WV
C613 F1J1H221A665 220PF 50WV
C614 F1J1H221A665 220PF 50WV
C615 F1J1H101A672 100PF 50WV
C616 F1J1H101A672 100PF 50WV
C617 F1J1H101A672 100PF 50WV
C618 F1J1H103A513 0.01µF 50WV
C619 F1J1H221A665 220PF 50WV
C620 F1H1H103A221 0.01µF 50WV
C621 F1J1H221A665 220PF 50WV
C622 F1G1A104A031 0.1µF 10WV
C623 F1J1H6800005 68PF 50WV
C624 F1G1A104A031 0.1µF 10WV
C625 F1G1A104A031 0.1µF 10WV
C626 F1G1A104A031 0.1µF 10WV
C627 F1G1C103A067 0.01µF 16WV
C628 F4D554730017 0.047µF 5.5WV
C629 F1J1H6800005 68PF 50WV
C630 F1G1C103A067 0.01µF 16WV
C631 F1G1A104A031 0.1µF 10WV
C633 F1G1C103A067 0.01µF 16WV
C634 F1G1C103A067 0.01µF 16WV
C635 ECA1VM101I 100µF 35WV
C636 F1H1H104A854 0.1µF 50WV
C637 EEUFC1C820 82µF 16WV
C638 YECUZ1A224KX 0.22µF 10WV
C639 F1H1C104A041 0.1µF 16WV
C640 EEUFC1C820 82µF 16WV
C641 YECUZ1A224KX 0.22µF 10WV
C642 ECEA1EKA220I 22µF 25WV
C643 F1H1H104A854 0.1µF 50WV
C644 GRM32RR61E47 4.7µF 25WV
C645 GRM32RR61E47 4.7µF 25WV
C646 F1H1A105A036 1µF 10WV
C647 F1H1C104A041 0.1µF 16WV
C648 F1H1C104A041 0.1µF 16WV
C649 F1H1H222A190 0.0022µF 50WV
C650 F1H1C104A041 0.1µF 16WV
C653 F1G1H102A537 0.001µF 50WV
C654 F1G1H102A537 0.001µF 50WV
C658 F1G1C103A067 0.01µF 16WV
C660 F1G1H102A537 0.001µF 50WV
C662 F1G1H102A537 0.001µF 50WV
C663 F1G1C103A067 0.01µF 16WV
C664 F1G1H102A537 0.001µF 50WV
C665 F1G1H102A537 0.001µF 50WV
C666 F1G1H102A537 0.001µF 50WV
Part No. Part Name & Description Remarks
Ref.
No.
C667 F1G1H332A537 0.0033µF 50WV
C669 F1G1H102A537 0.001µF 50WV
C670 F1L1A226A017 22µF 10WV
C671 EEUFC1C820 82µF 16WV
C672 YECUZ1A224KX 0.22µF 10WV
C673 F1L1A226A017 22µF 10WV
C674 EEUFC1C820 82µF 16WV
C675 YECUZ1A224KX 0.22µF 10WV
C676 ECA1AM221I 220µF 10WV
C677 YECUZ1A224KX 0.22µF 10WV
C678 EEUFC1C820 82µF 16WV
C679 YECUZ1A224KX 0.22µF 10WV
C680 F1G1C103A067 0.01µF 16WV
C681 ECA1CM100I 10µF 16WV
C682 F1G1C103A067 0.01µF 16WV
C684 F1G1C103A067 0.01µF 16WV
C685 ECA1CM221 220µF 16WV
C686 F1G1H102A537 0.001µF 50WV
C687 F1G1H151A598 150PF 50WV E
C692 F4D554730017 0.047µF 5.5WV
C693 F4D554730017 0.047µF 5.5WV
C694 F1H1H180A231 18PF 50WV
C695 F1H1H180A231 18PF 50WV
C698 F1H1E223A031 0.022µF 25WV
C699 F1H1A154A007 0.15µF 10WV
C707 ECA1HM100I 10µF 50WV
C708 ECA1HM100I 10µF 50WV
C709 ECA1AM221I 220µF 10WV
C710 ECA1CM101I 100µF 16WV
C711 ECA1VM101I 100µF 16WV
C712 F1H1H104A854 0.1µF 50WV
C713 YECUZ1A224KX 0.22µF 10WV
C714 EEUFC1C820 82µF 16WV
C715 F1G1E103A083 0.01µF 25WV
C716 F1G1C103A067 0.01µF 16WV
C717 F1G1H101A540 100PF 50WV
C718 F1G1H101A540 100PF 50WV
C719 F1G1C103A067 0.01µF 16WV
C720 F1G1H101A540 100PF 50WV
C721 F1G1H101A540 100PF 50WV
C722 F1G1C103A067 0.01µF 16WV
C723 F1G1H101A540 100PF 50WV
C724 F1G1H101A540 100PF 50WV
C725 F1G1C103A067 0.01µF 16WV
C726 F1G1H101A540 100PF 50WV
C727 F1G1H101A540 100PF 50WV
C728 F1G1H270A518 27PF 50WV
C729 F1G1A104A031 0.1µF 10WV
C730 F1G1H270A518 27PF 50WV
C733 F1G1H471A537 470PF 50WV E
C749 F1G1H101A540 100PF 50WV
C750 F1G1H101A540 100PF 50WV
C757 F1K1C106A073 10µF 16WV
C758 ECA0JM471I 470µF 6.3WV
C759 F1G1H101A540 100PF 50WV
C761 F1G1C103A067 0.01µF 16WV
C762 F1G1H101A540 100PF 50WV
C763 ECA1CM221 220µF 16WV
C764 F1J1H103A513 0.01µF 50WV
C765 ECA1AM221I 220µF 10WV
C766 ECA1CM101I 100µF 16WV
C767 F1H1A4740009 0.47µF 10WV
C768 F1H1A4740009 0.47µF 10WV
C769 YECUZ1A224KX 0.22µF 10WV
C770 F1G1E472A041 0.0047µF 25WV
C771 F1G1A104A031 0.1µF 10WV
C772 ECA1HM4R7B 4.7µF 50WV E
C773 ECA1HM4R7B 4.7µF 50WV E
C774 F1G1A104A031 0.1µF 10WV
C775 F1G1E181A043 180PF 25WV
C776 F1G1H180A059 18PF 50WV
C777 F1H1H180A231 18PF 50WV
C778 F1G1C103A067 0.01µF 16WV
Part No. Part Name & Description Remarks
10
Ref.
No.
C779 F1G1H222A401 0.0022µF 50WV
C780 F1G1H222A401 0.0022µF 50WV
C781 F1J1H332A742 0.0033µF 50WV E
C782 F1J1H332A742 0.0033µF 50WV E
C783 F1J1H332A742 0.0033µF 50WV E
C784 F1J1H332A742 0.0033µF 50WV E
C785 ECA0JM221I 220µF 6.3WV
C786 F1G1A104A031 0.1µF 10WV
C787 F1G1H101A540 100PF 50WV
C788 ECA1HM4R7B 4.7µF 50WV E
C789 F1G1A104A031 0.1µF 10WV
C790 ECA1HM4R7B 4.7µF 50WV E
C791 F1G1A104A031 0.1µF 10WV
C792 ECA1CM101I 100µF 16WV
C794 F1G1A333A034 0.033µF 10WV E
C795 ECA1CAD100XI 10µF 16WV
C796 F1G1C223A088 0.022µF 16WV E
C797 F1G1C223A088 0.022µF 16WV E
C798 F1G1C223A088 0.022µF 16WV E
C799 F1G1C223A088 0.022µF 16WV E
C800 F1G1A473A002 0.047µF 10WV
C801 F1G1A473A002 0.047µF 10WV
C802 ECA1CM220I 22µF 16WV
C803 F1G1A104A031 0.1µF 10WV
C804 F1G1A104A031 0.1µF 10WV
C805 F1J1E475A200 4.7µF 25WV E
C806 F1H0J1050010 1µF 6.3WV
C807 F1G1A104A031 0.1µF 10WV
C808 F1J1E475A200 4.7µF 25WV E
C809 F1G1H332A538 0.0033µF 50WV
C813 F1G1E103A083 0.01µF 25WV
C814 F1G1A104A031 0.1µF 10WV
C815 F1G1A104A031 0.1µF 10WV
C816 F1G1C103A067 0.01µF 16WV
C818 F1G1C103A067 0.01µF 16WV
C820 ECA1CM101I 100µF 16WV
C821 ECA1CM101I 100µF 16WV
C822 ECA1CM470I 47µF 16WV
C823 ECA1VM101I 100µF 35WV
C824 F1G1H102A537 0.001µF 50WV
C825 F1G1H222A401 0.0022µF 50WV
C834 F1G1H152A538 0.0015µF 50WV E
C835 F1G1H152A538 0.0015µF 50WV E
C836 F1G1H221A571 220PF 50WV E
C837 F1H1H104A854 0.1µF 50WV
RESISTORs
C260 ERJ2GE0R00X 0ΩΩΩΩ 1/16W
C267 ERJ2GE0R00X 0ΩΩΩΩ 1/16W
C268 ERJ3GEY0R00V 0ΩΩΩΩ 1/16W
C305 ERJ3GEY0R00V 0ΩΩΩΩ 1/16W
C360 ERJ2GE0R00X 0ΩΩΩΩ 1/16W
C367 ERJ2GE0R00X 0ΩΩΩΩ 1/16W
R115 ERJ2GEJ273X 27kΩΩΩΩ 1/16W
R117 ERJ2GEJ273X 27kΩΩΩΩ 1/16W
R119 ERJ2GEJ273X 27kΩΩΩΩ 1/16W
R120 ERJ2GEJ273X 27kΩΩΩΩ 1/16W
R121 ERJ2GEJ273X 27kΩΩΩΩ 1/16W
R122 ERJ2GEJ273X 27kΩΩΩΩ 1/16W
R132 ERJ2GEJ101X 100ΩΩΩΩ 1/16W
R133 ERJ2GEJ101X 100ΩΩΩΩ 1/16W
R134 ERJ2GEJ101X 100ΩΩΩΩ 1/16W
R135 ERJ2GEJ101X 100ΩΩΩΩ 1/16W
R136 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R137 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R138 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R139 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R140 ERJ3GEYJ1R0V 1ΩΩΩΩ 1/16W
R253 ERJ3GEYJ223V 22kΩΩΩΩ 1/16W
R254 ERJ3GEYJ223V 22kΩΩΩΩ 1/16W
R257 ERJ3GEYJ223V 22kΩΩΩΩ 1/16W
R258 ERJ3GEYJ223V 22kΩΩΩΩ 1/16W
Part No. Part Name & Description Remarks
Volkswagen / CQ-EV1571GC
Ref.
No.
R259 ERJ3GEYJ153V 15kΩΩΩΩ 1/16W
R260 ERJ2GEJ105X 1MΩΩΩΩ 1/16W
R261 ERJ3GEYJ133V 13kΩΩΩΩ 1/16W
R262 ERJ2GEJ472X 4.7kΩΩΩΩ 1/16W
R263 ERJ3GEYJ134V 130kΩΩΩΩ 1/16W E
R264 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R353 ERJ3GEYJ223V 22kΩΩΩΩ 1/16W
R354 ERJ3GEYJ223V 22kΩΩΩΩ 1/16W
R357 ERJ3GEYJ223V 22kΩΩΩΩ 1/16W
R358 ERJ3GEYJ223V 22kΩΩΩΩ 1/16W
R359 ERJ3GEYJ153V 15kΩΩΩΩ 1/16W
R360 ERJ2GEJ622X 6.2kΩΩΩΩ 1/16W E
R361 ERJ3GEYJ133V 13kΩΩΩΩ 1/16W
R362 ERJ2GEJ472X 4.7kΩΩΩΩ 1/16W
R363 ERJ3GEYJ134V 130kΩΩΩΩ 1/16W E
R364 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R365 ERJ2GEJ101X 100ΩΩΩΩ 1/16W
R366 ERJ2GEJ101X 100ΩΩΩΩ 1/16W
R601 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R602 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R603 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R604 ERJ2GEJ101X 100ΩΩΩΩ 1/16W
R605 ERJ2GEJ101X 100ΩΩΩΩ 1/16W
R606 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R607 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R608 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R609 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R610 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R611 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R612 ERJ2GEJ561X 560ΩΩΩΩ 1/16W
R613 ERJ2GEJ561X 560ΩΩΩΩ 1/16W
R614 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R615 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R616 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R617 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R618 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R619 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R620 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R621 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R622 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R624 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R625 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R628 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R629 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R630 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R631 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R632 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R633 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R634 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R635 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R636 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R637 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R638 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R639 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R640 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R641 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R642 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R643 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R644 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R645 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R646 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R647 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R648 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R649 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R650 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R653 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R654 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R655 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R656 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R657 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R658 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R659 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R660 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
Part No. Part Name & Description Remarks
11
Volkswagen / CQ-EV1571GC
Ref.
No.
R661 ERJ2GEJ220X 22ΩΩΩΩ 1/16W
R666 ERJ12NF5600U 560ΩΩΩΩ 1/2W
R667 ERJ12NF5600U 560ΩΩΩΩ 1/2W
R670 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R671 ERJ2RKF105X 1MΩΩΩΩ 1/16W
R672 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R673 ERJ2GEJ104X 100kΩΩΩΩ 1/16W
R675 ERJ2GEJ104X 100kΩΩΩΩ 1/16W
R676 ERJ2GEJ104X 100kΩΩΩΩ 1/16W
R677 ERJ2GEJ223X 22kΩΩΩΩ 1/16W
R678 ERJ2GEJ333X 33kΩΩΩΩ 1/16W
R679 ERJ2GEJ223X 22kΩΩΩΩ 1/16W
R680 ERJ2GEJ333X 33kΩΩΩΩ 1/16W
R681 ERJ2GEJ222X 2.2kΩΩΩΩ 1/16W
R682 ERJ2GEJ222X 2.2kΩΩΩΩ 1/16W
R683 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R684 ERJ2GEJ510X 51ΩΩΩΩ 1/16W
R686 ERJ3GEYJ100V 10ΩΩΩΩ 1/16W
R687 ERJ3GEYJ100V 10ΩΩΩΩ 1/16W
R688 ERJ3GEYJ100V 10ΩΩΩΩ 1/16W
R689 ERJ2GEJ104X 100kΩΩΩΩ 1/16W
R690 ERJ2RHD123X 12kΩΩΩΩ 1/16W
R691 ERJ2RHD393X 39kΩΩΩΩ 1/16W E
R692 ERJ2RHD472X 4.7kΩΩΩΩ 1/16W
R693 ERJ2RHD472X 4.7kΩΩΩΩ 1/16W
R694 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R695 ERJ2GEJ303X 30kΩΩΩΩ 1/16W
R696 ERJ2GEJ153X 15kΩΩΩΩ 1/16W
R698 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R699 ERJ2GEJ682X 6.8kΩΩΩΩ 1/16W
R701 ERJ2GE0R00X 0ΩΩΩΩ 1/16W
R702 D0HA103ZA001 10kΩΩΩΩ 1/16W
R703 D0HA103ZA001 10kΩΩΩΩ 1/16W
R704 ERJ2RHD823X 82kΩΩΩΩ 1/16W E
R705 ERJL12UF27MU 0.027ΩΩΩΩ
R706 ERJL12UF27MU 0.027ΩΩΩΩ
R711 ERJ2GEJ223X 22kΩΩΩΩ 1/16W
R712 ERJ8GEYJ151V 150ΩΩΩΩ 1/8W
R714 ERJ2GEJ223X 22kΩΩΩΩ 1/16W
R715 ERJ8GEYJ271V 270ΩΩΩΩ 1/8W
R716 ERJ2GE0R00X 0ΩΩΩΩ 1/16W
R717 ERJ2GE0R00X 0ΩΩΩΩ 1/16W
R720 ERJ2GEJ101X 100ΩΩΩΩ 1/16W
R721 ERJ2GEJ101X 100ΩΩΩΩ 1/16W
R722 ERJ2GEJ123X 12kΩΩΩΩ 1/16W
R723 ERJ2GEJ100X 10ΩΩΩΩ 1/16W
R724 ERJ2GEJ100X 10ΩΩΩΩ 1/16W
R725 ERJ2GEJ100X 10ΩΩΩΩ 1/16W
R726 ERJ2GEJ100X 10ΩΩΩΩ 1/16W
R727 ERJ2GEJ100X 10ΩΩΩΩ 1/16W
R728 ERJ2GEJ100X 10ΩΩΩΩ 1/16W
R729 ERJ2GEJ101X 100ΩΩΩΩ 1/16W
R730 ERJ2GEJ101X 100ΩΩΩΩ 1/16W
R731 ERJ2RKF822X 8.2kΩΩΩΩ 1/16W E
R732 ERJ2RKF153X 15kΩΩΩΩ 1/16W E
R733 ERJ2RKF822X 8.2kΩΩΩΩ 1/16W E
R734 ERJ2RKF153X 15kΩΩΩΩ 1/16W E
R735 ERJ2GEJ223X 22kΩΩΩΩ 1/16W
R736 ERJ12YJ561H 560ΩΩΩΩ 1/2W
R737 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R738 ERJ2GEJ104X 100kΩΩΩΩ 1/16W
R739 ERJ2GEJ105X 1MΩΩΩΩ 1/16W
R740 ERJ2GEJ223X 22kΩΩΩΩ 1/16W
R741 ERJ8GEYJ681V 680ΩΩΩΩ 1/8W
R742 D4DAB5R60002 5.6ΩΩΩΩ
R743 ERJ2GEJ223X 22kΩΩΩΩ 1/16W
R744 ERJ12YJ561H 560ΩΩΩΩ 1/2W
R745 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R750 D4DAB5R60002 5.6ΩΩΩΩ
R751 ERJ2GEJ104X 100kΩΩΩΩ 1/16W
R752 ERJ2GEJ104X 100kΩΩΩΩ 1/16W
R753 ERJ2RKF104X 100kΩΩΩΩ 1/16W
R754 ERJ2RKF474X 470kΩΩΩΩ 1/16W E
Part No. Part Name & Description Remarks
Ref.
No.
R755 ERJ2RKF474X 470kΩΩΩΩ 1/16W E
R756 ERJ8ENF8200V 820ΩΩΩΩ 1/8W E
R757 ERJ2RKF104X 100kΩΩΩΩ 1/16W
R758 ERJ2RKF105X 1MΩΩΩΩ 1/16W
R759 ERJ2RKF105X 1MΩΩΩΩ 1/16W
R760 ERJ2GEJ392X 3.9kΩΩΩΩ 1/16W
R761 ERJ2RKF104X 100kΩΩΩΩ 1/16W
R762 ERJ2RKF104X 100kΩΩΩΩ 1/16W
R763 ERJ2RKF104X 100kΩΩΩΩ 1/16W
R764 ERJ2RKF105X 1MΩΩΩΩ 1/16W
R765 ERJ2RKF105X 1MΩΩΩΩ 1/16W
R766 ERJ2GEJ392X 3.9kΩΩΩΩ 1/16W
R767 ERJ2RKF104X 100kΩΩΩΩ 1/16W
R768 ERJ2RKF474X 470kΩΩΩΩ 1/16W E
R769 ERJ2RKF474X 470kΩΩΩΩ 1/16W E
R770 ERJ8ENF8200V 820ΩΩΩΩ 1/8W E
R771 ERJ2RKF104X 100kΩΩΩΩ 1/16W
R772 ERJ2RKF104X 100kΩΩΩΩ 1/16W
R775 ERJ2GEJ562X 5.6kΩΩΩΩ 1/16W
R776 ERJ2GEJ472X 4.7kΩΩΩΩ 1/16W
R777 ERJ2GEJ101X 100ΩΩΩΩ 1/16W
R778 ERJ2GEJ101X 100ΩΩΩΩ 1/16W
R779 ERJ6GEY0R00V 0ΩΩΩΩ 1/10W
R785 ERJ3GEYJ470V 47ΩΩΩΩ 1/16W
R786 ERJ3EKF6803V 680kΩΩΩΩ 1/16W
R787 ERJ6GEYJ102 1kΩΩΩΩ 1/10W
R788 D4DA53R90001 3.9ΩΩΩΩ
R789 ERJ6GEYJ102 1kΩΩΩΩ 1/10W
R790 ERJ6GEYJ102 1kΩΩΩΩ 1/10W
R791 ERJ2RKF332X 3.3kΩΩΩΩ 1/16W
R792 D4DA53R90001 3.9ΩΩΩΩ
R793 ERJ2GEJ104X 100kΩΩΩΩ 1/16W
R794 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R795 ERJ2RKF470X 47ΩΩΩΩ 1/16W
R796 ERJ2GEJ682X 6.8kΩΩΩΩ 1/16W
R797 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R798 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R799 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R801 ERJ2GE0R00X 0ΩΩΩΩ 1/16W
R802 ERJ2GE0R00X 0ΩΩΩΩ 1/16W
R804 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R805 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R806 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R807 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R808 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R809 ERJ2GEJ682X 6.8kΩΩΩΩ 1/16W
R810 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R811 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R812 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R813 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R814 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R815 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R816 ERJ2GE0R00X 0ΩΩΩΩ 1/16W
R817 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R818 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R820 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R821 ERJ2GE0R00X 0ΩΩΩΩ 1/16W
R822 ERJ2GE0R00X 0ΩΩΩΩ 1/16W
R823 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R824 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R825 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R826 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R827 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R828 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R829 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R830 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R831 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R832 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R833 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R834 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R835 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R836 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R837 ERJ2GE0R00X 0ΩΩΩΩ 1/16W
Part No. Part Name & Description Remarks
12
Ref.
No.
R838 ERJ2GE0R00X 0ΩΩΩΩ 1/16W
R839 ERJ2GE0R00X 0ΩΩΩΩ 1/16W
R840 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R841 ERJ2GEJ471X 470ΩΩΩΩ 1/16W
R842 ERJ2GEJ471X 470ΩΩΩΩ 1/16W
R843 ERJ2RKF681X 680ΩΩΩΩ 1/16W
R844 ERJ8GEYJ681V 680ΩΩΩΩ 1/8W
R868 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R869 ERJ2GEJ333X 33kΩΩΩΩ 1/16W
R870 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R876 ERJ2GEJ104X 100kΩΩΩΩ 1/16W
R877 ERJ2GEJ104X 100kΩΩΩΩ 1/16W
R878 ERJ2GEJ104X 100kΩΩΩΩ 1/16W
R883 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R884 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R885 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R886 ERJ8GEYJ102 1kΩΩΩΩ 1/8W
R891 ERJ2GEJ101X 100ΩΩΩΩ 1/16W
R892 ERJ2GEJ223X 22kΩΩΩΩ 1/16W
R893 ERJ12YJ561H 560ΩΩΩΩ 1/2W
R898 ERJ2GEJ334X 330kΩΩΩΩ 1/16W
R899 ERJ2GEJ224X 220kΩΩΩΩ 1/16W
R900 ERJ2GEJ334X 330kΩΩΩΩ 1/16W
R903 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R904 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R912 ERJ2GEJ223X 22kΩΩΩΩ 1/16W
R913 ERJ3GEYJ101V 100ΩΩΩΩ 1/16W
R915 ERJ2GEJ223X 22kΩΩΩΩ 1/16W
R916 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R917 ERJ2GEJ101X 100ΩΩΩΩ 1/16W
R918 ERJ2GEJ101X 100ΩΩΩΩ 1/16W
R920 ERJ8ENF4700V 47ΩΩΩΩ 1/8W
R929 ERJ2GEJ562X 5.6kΩΩΩΩ 1/16W
R930 ERJ2GEJ562X 5.6kΩΩΩΩ 1/16W
R931 ERJ2GEJ105X 1MΩΩΩΩ 1/16W
R932 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R934 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R936 ERJ2GE0R00X 0ΩΩΩΩ 1/16W
R938 ERJ2GE0R00X 0ΩΩΩΩ 1/16W
R939 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R940 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R941 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R942 ERJ2GEJ102X 1kΩΩΩΩ 1/16W
R943 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R944 ERJ2GEJ103X 10kΩΩΩΩ 1/16W
R945 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R946 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R948 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R949 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R950 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R951 ERJ2GEJ100X 10ΩΩΩΩ 1/16W
R952 ERJ2GEJ100X 10ΩΩΩΩ 1/16W
R953 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R955 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R956 ERJ2GEJ473X 47kΩΩΩΩ 1/16W
R957 ERJ2GEJ223X 22kΩΩΩΩ 1/16W
R958 ERJ2GEJ223X 22kΩΩΩΩ 1/16W
R959 ERJ2GEJ223X 22kΩΩΩΩ 1/16W
CONNECTORs
CN601 K1FA140B0006 Connector, 40P E
CN603 K1MN14A00024 Connector, 14P
CN604 K1KA12B00105 Connector, 12P
CN605 K1KA12B00105 Connector, 12P
COILs
L101 G0ZZ00001907 Coil
L102 YELT45N4R7KT Coil
L104 YELT45N4R7KT Coil
L105 J0JCC0000159 Coil E
L106 J0JCC0000159 Coil E
Part No. Part Name & Description Remarks
Volkswagen / CQ-EV1571GC
Ref.
No.
L107 J0JCC0000159 Coil E
L108 J0JCC0000159 Coil E
L601 YETQ026X163 Coil
L602 G0A111J00003 Coil
L603 J0JCC0000012 Coil
L604 J0JCC0000012 Coil
L605 J0JCC0000012 Coil
L606 J0JCC0000012 Coil
L609 G1C100M00021 Coil
L610 G1C100M00021 Coil
L619 G1B510D00001 Coil
L623 J0JHC0000075 Coil
L624 J0JHC0000075 Coil
L625 J0JHC0000075 Coil
L626 J0JCC0000159 Coil E
L627 YELT03N2R2KT Coil
L629 J0JCC0000159 Coil E
L630 J0JCC0000159 Coil E
L631 J0JCC0000159 Coil E
L632 J0JGC0000016 Coil
L633 J0JCC0000159 Coil E
L637 J0JCC0000159 Coil E
L701 J0JCC0000159 Coil E
CRYSTALs
XL601 H2D160500014 Crystal
XL604 H0J416500003 Crystal
NEON TUBE
Z101 YEAL02012T Neon tube
FILTERs
CS602 F1L1H2040003 Filter
CS603 F1L1H2040003 Filter
[MGCAP00045] Display Block
IC´s and TRANSISTORs
IC401 C1ZBZ0002116 IC
IC402 C0ABJA000015 IC
IC403 C1ZBZ0002380 IC
IC404 C0DBABZ00002 IC
IC405 C0DBABZ00002 IC
IC407 C0DBABZ00002 IC
IC408 C0DBABZ00002 IC
Q402 B1GBCFJA0023 Transistor
Q403 B1GDGFEJ0001 Transistor
Q406 B1ABCD000006 Transistor
Q407 B1GDGFEJ0001 Transistor
Q408 B1ABCD000006 Transistor
DIODEs
D411 B3AAB0000210 Diode E
D412 B3AAB0000210 Diode E
D413 B3AAB0000210 Diode E
D414 B3AAB0000210 Diode E
D415 B3AAB0000210 Diode E
D416 B3AAB0000210 Diode E
D417 B3AAB0000210 Diode E
D418 B3AAB0000210 Diode E
D419 B3AAB0000210 Diode E
D420 B3AAB0000210 Diode E
D421 B3AAB0000210 Diode E
D422 B3AAB0000210 Diode E
D423 B3AAB0000210 Diode E
D424 B3AAB0000210 Diode E
D425 B3AAB0000210 Diode E
D426 B3AAB0000210 Diode E
Part No. Part Name & Description Remarks
13
Volkswagen / CQ-EV1571GC
Ref.
No.
D427 B3AAB0000210 Diode E
D428 B3AAB0000210 Diode E
D429 B3AAB0000210 Diode E
D430 B3AAB0000210 Diode E
D431 B3AAB0000210 Diode E
D432 B3AAB0000210 Diode E
D433 B3AAB0000210 Diode E
D434 B3AAB0000210 Diode E
D435 B3AAB0000210 Diode E
D436 B3AAB0000210 Diode E
D454 B3AAB0000210 Diode E
D455 B3AAB0000210 Diode E
D461 B3AEB0000063 Diode E
D462 B3AEB0000063 Diode E
D463 B3AEB0000063 Diode E
D464 B3AEB0000063 Diode E
D465 B3AEB0000063 Diode E
D466 B3AEB0000063 Diode E
D467 B3AEB0000063 Diode E
D468 B3AEB0000063 Diode E
D469 B3AEB0000063 Diode E
D470 B3AEB0000063 Diode E
CAPACITORs
C401 F1J1H101A672 100PF 50WV
C402 F1J1H101A672 100PF 50WV
C403 F1J1H101A672 100PF 50WV
C404 F1J1H101A672 100PF 50WV
C406 F1J1C1050029 1µF 16WV
C407 F1J1C1050029 1µF 16WV
C408 F1J1C1050029 1µF 16WV
C409 F1J1C1050029 1µF 16WV
C410 F1J1C1050029 1µF 16WV
C411 F1J1H101A672 100PF 50WV
C412 YECUS1C104KX 0.1µF 16WV
C413 F1J1H103A513 0.01µF 50WV
C414 F1J1C1050029 1µF 16WV
C415 F1J1H103A513 0.01µF 50WV
C416 F1J1C1050029 1µF 16WV
C417 F1J1H101A672 100PF 50WV
C418 F1J1H103A513 0.01µF 50WV
C419 F1J1H224A736 0.22µF 50WV
C422 F1K1C106A073 10µF 16WV
C423 F1K1C106A073 10µF 16WV
C424 F1K1C106A073 10µF 16WV
C425 F1K1C106A073 10µF 16WV
C426 F1K1C106A073 10µF 16WV
C427 F1K1C106A073 10µF 16WV
C428 F1K1C106A073 10µF 16WV
C429 F1K1C106A073 10µF 16WV
RESISTORs
R401 ERJ6GEYJ473 47kΩΩΩΩ 1/10W
R402 ERJ6GEYJ473 47kΩΩΩΩ 1/10W
R403 ERJ6GEYJ473 47kΩΩΩΩ 1/10W
R404 ERJ6GEYJ473 47kΩΩΩΩ 1/10W
R405 ERJ3EKF1002V 10kΩΩΩΩ 1/16W
R406 ERJ3EKF1002V 10kΩΩΩΩ 1/16W
R407 ERJ3EKF1003V 100kΩΩΩΩ 1/16W
R408 ERJ3EKF1003V 100kΩΩΩΩ 1/16W
R409 ERJ3EKF1002V 10kΩΩΩΩ 1/16W
R410 ERJ3EKF1002V 10kΩΩΩΩ 1/16W
R417 ERJ6GEYJ105 1MΩΩΩΩ 1/10W
R418 ERJ6GEYJ105 1MΩΩΩΩ 1/10W
R419 ERJ6GEYJ105 1MΩΩΩΩ 1/10W
R420 ERJ6GEYJ105 1MΩΩΩΩ 1/10W
R424 ERJ3GEYJ473V 47kΩΩΩΩ 1/16W
R425 ERJ3GEYJ473V 47kΩΩΩΩ 1/16W
R427 ERJ3GEYJ473V 47kΩΩΩΩ 1/16W
R429 ERJ6GEYJ104 100kΩΩΩΩ 1/10W
Part No. Part Name & Description Remarks
Ref.
No.
R431 ERJ8GEYJ222V 2.2kΩΩΩΩ 1/8W
R432 ERJ8GEYJ182V 1.8kΩΩΩΩ 1/8W
R433 ERJ8GEYJ182V 1.8kΩΩΩΩ 1/8W
R434 ERJ8GEYJ182V 1.8kΩΩΩΩ 1/8W
R435 ERJ8GEYJ182V 1.8kΩΩΩΩ 1/8W
R436 ERJ8GEYJ182V 1.8kΩΩΩΩ 1/8W
R437 ERJ8GEYJ272V 2.7kΩΩΩΩ 1/8W
R438 ERJ8GEYJ272V 2.7kΩΩΩΩ 1/8W
R439 ERJ8GEYJ331V 330ΩΩΩΩ 1/8W
R440 ERJ8GEYJ331V 330ΩΩΩΩ 1/8W
R441 ERJ8GEYJ331V 330ΩΩΩΩ 1/8W
R442 ERJ8GEYJ331V 330ΩΩΩΩ 1/8W
R443 ERJ8GEYJ272V 2.7kΩΩΩΩ 1/8W
R454 ERJ8GEYJ392V 3.9kΩΩΩΩ 1/8W
R461 ERJ8GEYJ471V 470ΩΩΩΩ 1/8W
R462 ERJ8GEYJ471V 470ΩΩΩΩ 1/8W
R463 ERJ8GEYJ471V 470ΩΩΩΩ 1/8W
R464 ERJ8GEYJ471V 470ΩΩΩΩ 1/8W
R465 ERJ8GEYJ471V 470ΩΩΩΩ 1/8W
R466 ERJ8GEYJ471V 470ΩΩΩΩ 1/8W
R467 ERJ8GEYJ471V 470ΩΩΩΩ 1/8W
R468 ERJ8GEYJ471V 470ΩΩΩΩ 1/8W
R469 ERJ8GEYJ471V 470ΩΩΩΩ 1/8W
R470 ERJ8GEYJ471V 470ΩΩΩΩ 1/8W
R483 ERJ3GEYJ6R8V 6.8kΩΩΩΩ 1/16W
R484 ERJ12YJ6R8H 6.8kΩΩΩΩ 1/2W
R486 ERJ3GEYJ823V 82kΩΩΩΩ 1/16W
CONNECTORs
CP401 K1KB12A00096 Connector, 12p E
CP402 K1KB12A00096 Connector, 12p E
LCD
LCD401 L5DZAME00002 LCD E
COIL
L401 ERJ6GEY0R00V Coil
VARIABLE RESISTORs
VR402 EVEV21PP008B Variable Resistor
VR401 EVEV21PP016B Variable Resistor
Mechanical Parts
AE001 MGCAE00044 Flat wire, 14P
AE601-
604
ANT1 K1U204B00005 Antenna Receplacle
1 YEFM031083 Denger seal
2 MGCFA00082A Chassis E
3 MGCFA00094 Front panel E
4 MGCFA00083 Upper cover
5 MGCFF00010 Heat sink
6 YEP0PT0045A0 Display PCB w/Compnent RTL, E
7 MGCFR00006 Rubber switch C E
8 MGCFR00004 Rubber switch A E
9 GGCFC00115 ESC Ass´y E
10 MGCFC00123 Volume knob Ass´y E
11 MGCFR00005 Rubber switch B E
12 MGCFV00029A Insulator Sheet
13 YEP0PT0044A0 Main PCB w/Compnent RTL, E
14 MGCFX00094 Fixture power IC
15 MGCFV00005 Acetat pad E
16 MGCFA00084 Bottom cover
17 XTB2+6JFX Tapping Screw M2x6mm E
18 XTB3+5FFJ Tapping Screw M3x5mm
19 XTB3+85FFJ Tapping Screw M3x8mm E
20 YEJT03015A Screw
Part No. Part Name & Description Remarks
K4CD08000002 Ground terminal
14
Ref.
No.
21 YEJT03289 Screw
Part No. Part Name & Description Remarks
Volkswagen / CQ-EV1571GC
15
Volkswagen / CQ-EV1571GC
8 EXPLODED VIEW (Unit)
16
9 WIRING DIAGRAM
9.1. Main Block (Top View)
Volkswagen / CQ-EV1571GC
17
Volkswagen / CQ-EV1571GC
9.2. Main Block (Bottom View)
18
9.3. Display Block (Top View)
Volkswagen / CQ-EV1571GC
19
Volkswagen / CQ-EV1571GC
9.4. Display Block (Bottom View)
20
10 SCHEMATIC DIAGRAM
10.1. Main Block
Volkswagen / CQ-EV1571GC
3.9
C1EB00000097
R
Q624
B1ABCD000006
L
B0ACCJ000020
MA8056LMHTX
C0JBAZ001652
2SB1073TX
B0ACCJ000020
D675,676
B0JCDD000007
B0JCDD000007
B1DHEC000010
C1EA00000035
MGCAP00044
C1BB00000877
3.3V
L
R
C2HBCJ000007
5V
5V
Q613
B1ABCD000006
YEAMC14584BE
Q612
B1ADKD000008
2SB1073TX
220u10V
C709
Q614
B1ABCD000006
5V
5V
C0CBCGE00001
8.5V
Q630
B1ADKD000008
Q616
2SB1073TX
Q617
B1ABCD000006
D678
C0ABCA000088
3.4V
D679
100K
100K
Q631
B1ABCD000006
2V/DIV,5µs/DIV
5V
C765
220u10V
5V
8.5V
5V
8.5V
D612
B0JCDD000007
3.4V
B0JCDD000007
2V/DIV,0.5µs/DIV
2V/DIV,0.1ms/DIV
2V/DIV,5ms/DIV
MC32C/83
2V/DIV,5ms/DIV
3.3V 3.3V
C0JBAZ001229
5V
R956
2V/DIV,0.2s/DIV
C0DBFHZ00002
The following symbols are
shown on the schematic diagram.
+B
8.5V
8.5V
8V
8V
5V
5V
3V
3V
3.4V
3.4V
3.3V
3.3V
CD(L,R)
AUDIO(L,R)
B0ACCJ000020
Q603
B1ABCD000006
YEADEC10DS1
B1GDGFEJ0001B1GDGFEJ0001
Voltage values ware unavailable
but could be on the updated version.
3.3V
C0EBT0000235
C0CBABD00058C0CBADE00064
C0CBABA00018
5V 5V5V
3.3V
5V
8V
0.027
B1DFAD000001
5V
B1DFAD000001
0.027
D624
B0JCDD000007
B0JCDD000007
Q621
5V
3.3V
C0EBF0000351
D623
C0DBAHA00022
5V
B0ACCJ000020
B0ACCJ000020
Q604
Q606
2SB1073TX
2SB1073TX
8V
5V
Q622
Q605
B1ABCD000006
YEAMC14584BE
To
CN401
E-9482A
IC612
C0ABBA000022
8V 8V
B1ABCD000006
3.4V
3.4V
3.3V
3.4V
C3EBFG000022
3.3V
MGCAP00045 CP401To
B1GDGFEJ0001
B0ACCJ000020
MGCAP00045 CP402To
D674
B1ABCD000006
B1GDCFEN0007
C0EBB0000136
CQ-EV1571GC MAIN
21
Volkswagen / CQ-EV1571GC
10.2. Display Block
MGCAP00045
C0DBABZ00002
IC402
3.3V
C0DBABZ00002
8V
8V
C0ABJA000015
3.3V
L5DZAME00002
3.3V
3.3V
B1GDGFEJ0001
C1ZBZ0002380
3.3V
8V
6.8K
3.3V
C1ZBZ0002116
B1GBCFJA0023
8V
C0DBABZ00002
C0DBABZ00002
3.3V
8V
8V
3.3V
The following symbols are
shown on the schematic diagram.
8V
8V
3.3V
3.3V
D411–436,454,455
B3AAB0000210
D461–470
B3AEB0000063
3.3V
8V
B1GDGFEJ0001
Q406
B1ABCD000006
6.8K
B1ABCD000006
8V
8V 8V
3.3V
CQ-EV1571GC DISPLAY
MGCAP00044 CN604To
MGCAP00044 CN605To
22
11 BLOCK DIAGRAM
11.1. Main-1/Display Block
Volkswagen / CQ-EV1571GC
Main-1
ESC - Board
SW403-418
Keyboard
VR401,402
Encoder/
Switch
IC403
TEMP
SENSOR
SW401,402
CDC Switch
LCD401
LCD
CN601(1/2)
Quadlock connector
+ Battery
ext. CDC analog Audio
- Vdd
Fuse
BATTERY SENSE
DAB L,R
8KeyIn/Out
P.SW
LCD T.M
LOAD
EJ
V1-5
LCD.DATA
LCD.CLK
LCD.AO
LCD.RST
LCD.CS
CDC.BATT
DAB.BATT
CAN
CDC.CONT
TEL MUTE
CDC L/R
Telephone +/ -
8
SCAN.SW
VOL.a/b
TN.a/b
Q402,
403
NEG.IN
V2 MONI
LCD
Q406,407
ILL
LED
DRIVE
MGCAP00045
Q620,621
+B
+B
MON
+B
CAN_H/L
Q623,624
CDC-REMO
CDC.DATA
CDC.CLK
IC401
2
I
C IO
expander
Button
LED
DRIVE
IC402,404,405,407,408
D461-470
CDC.CONT
SW
T.MUTE
IC623(2/2)
P.ON VDD3.3V
SCL
SDA
Exp.IRQ
KEY ILL
Q408
D411-436
454,455
LCD Voltage
neg. Voltage
+B.MON
+B.M.CONT
P.ON 5V
IC606
Level
Shift
P.ON8V
P.ON8V
MGCAP00044 (1/2)
Filter
1
12
P.ON
VDD3.3V
P.ON
8V
IC603
CAN_H/L
filtered
Audio
CP401
CP402
ESC "Bus line"
+B VDD+5
CAN TRAN.
BATT.SENSE
CN604
CN605
1
12
IC607
(1/3)
ENA
STB
TxD
NER
RxD
IC605
NER
RxD
P.ON VDD3.3V
P.ON 8V
+ switched Battery
IC612
NEG.IN
IC602
VDD+5
Level
Shift
VDD+3.3
Level
Shift
LCD
neg.
voltage
VDD+ 3.3
E2Prom
IC617
6.1Det
6.1V
Det
P.ON
P.TIM
SDA
SCL
CONT.RAST
E2P.CS
E2P.CLK
E2P.DATA.OUT
E2P.DATA.IN
+B
SDA
6.1Det
CDC.REMO
CDC.Data
CDC.CLK
CAN.ENA
CAN.STB
CAN.ERR
CAN.TX/RX
P.ON
CDC.CONT
P.TIM
+B.MON
+B.M.CONT
BATT.SENSE
T.MUTE
Exp.IRQ
LCD.ILL
KEY.ILL
CONT.RAST
LCD.E2P.DATA.OUT
LCD.E2P.CLK
LCD.AO
LCD.RST
LCD.CS
E2P.DATA.IN
E2P.CS
V2.MONI
LCD.T.M
P Sw
Load
EJ
CAN AD
CAN u-com AD
CAN AD
CAN
2
IRQ
DA I
DA n
DA t
IO e IRQ
IO r
IO f
IO a
IO c I
IO e D
IO C
AD t
AD o
IRQ
IRQ E
IRQ S
WDT.
SCL
SERVICE
C
16MHz
XL601
IC619
Q626
Watchdog
VDD+3.3
Reset
RTH
TIMER
IRQ
OSC
IC504
Reset
ResetVddWDS
AD
AD
AD
2
C Bus
I
IC623(1/2)
IC601
ANT1.CONT
ANT2.CONT
ANT1.SHORT
ANT2.SHORT
ANT1.OPEN
ANT2.OPEN
AGC_BUF1
AGC_BUF2
DSP.RESET
DSP.RESET.MON
TUNER.QUAL
RDS.READY1
RDS.READY2
Tuner IRQ
DC/DC OSC
IDC.MUTE
IDC.SCKM
IDC.SOM
IDC.SIM
IDC.ON
IDC.RESET
IDC. 5VON
IDC.8VONn
+B
Q614-619
ANT
CONT
+5V.TIM P.ON 8V
2
Vdd Switch
Q604-606,622
1
+ switched Battery
DSP.RESET
DSP.RESET.MON
2
I
C Bus
IF.AGC 1/2
KAGC 1/2
AF.SAM1/2
AF.HOLD1/2
IF 1/2
Telephone+/DAB L,R
CDC L,R
TUNER.QUAL
RDS.READY1
RDS.READY2
for
IDC
MUTE
CD.SCKM
CD.SOM
CD.SIM
CD.ON
/RESET
SDA
SDA
SCL
IDC.5V
IDC.8V
ANT1.CONT
ANT2.CONT
ANT1.SHORT
ANT2.SHORT
ANT1.OPEN
ANT2.OPEN
AGC_BUF1
IF.AGC1
KAGC1
AF.SAM1
AF.HOLD1
IF1
SDA_DICE
SCL_DICE
AGC_BUF2
IF.AGC2
KAGC2
AF.SAM2
AF.HOLD2
IF2
SCL
2
C Bus_DICE
I
2
C Bus
I
DSP
41.6MHz
XL604
VDD+3.3
Power IDC
all Connections
via Connector
IC616
Vdd
Antenna
Detection/DC
connected
short
open
+5V.TIM
PAC1
SUB TUNER FM
2
I
C Bus_DICE
MAIN TUNER FM/AM
P.ON5V P.ON8.5V
IC614
reset
Audio
out
VDD_3.3
VDD_1.8
14
+5V.TIM
IC615
Q634
IDC.SPDIF
CN609
IDC.SPDIF
Reset
int. reg 1.8V
ANT2
+8.5V.TIM
IC201
FL/FR/
RL/RR
4
C.D
PMOS
TIM_PLAY(L)
TIM_REC(SUB W)
SDA
SCL
SDA
SCL
CQ-EV1571GC Main-1/Display
Sub-Antenna Main - Antenna
FM FM+AM
FM
FM/AM
CN601(2/2)
quadlock
+B
connector
FL+/FL-/FR+/FR-/
8 RL+/RL-/RR+/RR-
Vdd
POWER AMP
4
3.3V.TIM
3.3V.TIM
IC625
3.3V
TIM ENC/DEC
ANT1
23
Volkswagen / CQ-EV1571GC
11.2. Main-2 Block
Main-2
P.ON
P.TIM
IC607(2/3)
LEVEL
SHIFT
IC607(3/3)
LEVEL
SHIFT
DC/DC.OSC
IC610(1/2)
Q610
DC/DC
IC610(1/2)
Q609
DC/DC
+B
+B
+B
P.ON8V
+5V.TIM
IC611
LIN REG
MGCAP00044 (2/2)
P.ON8V
+5V.TIM
+5V.TIM
+3.3V.TIM
P.ON
P.ON 5V
SWITCH
P.ON 5V
P.ON
IC608
LIN REG
IC613
LIN REG
Q602
SWITCH
+B
+B
RADIO
8.5V
Reg.
+B
VDD.5V
+8.5V.TIM
+B
VDD+5
+8.5V.TIM
P.ON
+switched Battery
IC609
LIN REG
Q630,631
SWITCH
8.5V
main tuner
VDD+3.3
VDD+3.3
P.ON 8.5V
P.ON
Q625
ESC
SWITCH
P.ON VDD3.3V
CQ-EV1571GC Main-2
Printed in Japan 2005.8 (K) (Recycled Paper)
24
CONTENTS
Page Page
1 FEATURES 2
2 LASER PRODUCTS
3 WIRING CONNECTION (CD Deck)
4 BLOCK DIAGRAM (CD Deck)
5 TERMINALS DESCRIPTION (CD Deck)
6 IC BLOCK DIAGRAM (CD Deck)
7 CD CHANGER PARTS LIST 7
2
8 EXPLODED VIEW (CD Deck-1)
9 EXPLODED VIEW (CD Deck-2)
2
3
10 EXPLODED VIEW (CD Deck-3)
11 WIRING DIAGRAM (CD Deck)
4
5
12 SCHEMATIC DIAGRAM (CD Deck)
10
11
12
13
15
1 FEATURES
•
• The specifications are based on the main unit.
• •
2 LASER PRODUCTS
3 WIRING CONNECTION (CD Deck)
2
4 BLOCK DIAGRAM (CD Deck)
3
5 TERMINALS DESCRIPTION (CD Deck)
IC301 : MNBC67DWBUC
Pin
No.
10 VREF+ Reference power supply for AD
11 VDD Power supply(+3.3V) 12 OSC2 Microcomputer system clock output(7.37MHz) O
13 OSC1 Microcomputer system clock input(7.37MHz) I
14 VSS Ground 15 XI Ground I
16 NC No Connection 17 MMOD Memory mode switch terminal(GND fixation) I
18 NC No Connection 19 NC No Connection 20 NC No Connection 21 MDATA Microcomputer command data signal O
22 STAT Servo LSI status signal I
23 MCLK Microcomputer command clock signal O
24 MLD Microcomputer command loading signal O
25 /RST Microcomputer reset input I
26 NC No Connection 27 NC No Connection 28 NC No Connection 29 TEST1 Monitor 1 for test O
30 TEST2 Monitor 2 for test O
31 BLKCK Subcode block clock signal I
32 DQSY CD-TEXT/SUBQ Synchronous Idle I
33 FG Spindle motor FG signal I
34 CDON Operation mode signal I
35 PORT Servo LSI general-purpose port(MN6627941) I
36 NC No Connection 37 TXTD CD-TEXT data signal I
38 TXTCK CD-TEXT clock signals O
39 NC No Connection 40 NC No Connection -
Port Descriptions I/O
1 VREF- Ground 2 SW3 TRAYH photo sensor I
3 SW4 DPSH photo sensor I
4 SW5 DISCS photo sensor I
5 SW6 LOAD photo sensor I
6 SW7 EJECT photo sensor I
7 SW13 EJECT2 photo sensor I
8 SW16+ SW16(OUTER3)/temperature sensor I
9 VPP* Power supply for flash rewriting(+5V) -
converter(+3.3V)
Pin
No.
41 SCKM Serial communications clock input I
42 SIM Serial communications input data I
43 NC No Connection 44 SOM Serial communications output data O
45 SIM Serial communications input data I
46 SCKM Serial communications clock input I
47 NC No Connection 48 NC No Connection 49 NC No Connection 50 NC No Connection -
-
51 /PRST Servo LSI reset signal O
52 NC No Connection 53 NC No Connection 54 NC No Connection 55 COMSEL Communication mode selection terminal
56 SW15 SW15(FEEDER) I
57 SW8 SW8(PLAY) I
58 SW9 SW9(CLUMP) I
59 SW10 SW10(SHUTER) I
60 SW11 SW11(HORIG) I
61 SW1 SW1(INNNER) I
62 SW2 SW2(TRAYG) I
63 SW12 SW12(OUTER2) I
64 SW14 SW14(OUTER) I
65 CS Chip select signal for EEPROM O
66 FR Spindle rotation detection terminal I
67 PS Spindle mute signal O
68 DI/DO Serial communications I/O data for EEPROM I
69 SK Serial communications clock output for
70 NC SW16(OUTER3) 71 NC No Connection 72 TRV2 Traverse motor control 2 I
73 MUTE1 Traverse mute O
74 TRV Traverse motor control I
75 VM- Elevator motor control - O
76 VM+ Elevator motor control + O
77 LOD- Loading motor control - O
78 LOD+ Loading motor control + O
79 HM- Horizontal motor control - O
80 HM+ Horizontal motor control + O
Port Descriptions I/O
I
L:Pana bus H:Hi Pana bus
O
EEPROM
4
6 IC BLOCK DIAGRAM (CD Deck)
IC302 : C3EBDG000058
IC201 : MNG7941FBUC
IC202 : C3ABMB000034
IC501 : C0GBH0000006
5
IC601 : C0GBY0000025
6
7 CD CHANGER PARTS
LIST
Notes :
1. Be sure to make your orders of replacement parts
according to this list.
2. Important safety notice: Components, identified by
have special characteristics important for safety. When
replacing any of these components, use only
manufacturer´s specified parts.
3. Location keys in the remarks column indicates the general
location of the parts shown in the exploded drawing, as in a
road map.
4. The marking (RTL) indicates that Retention Time is limited
for this item. After the discontinuation of assembly in
production, the item will continue to be available for a
specific period of time. The retention period of availability is
dependent on the type of assembly, and in accordance with
the laws governing part and product retention. After the end
of this period, the assembly will no longer be available.
Ref.
No.
[E9482] CD Servo Block
IC´s AND TRANSISTORs
IC201 MNG7941FBUC IC
IC202 C3ABMB000034 IC
IC301 MNBC67DWBUC IC
IC302 C3EBDG000058 IC
IC401 C0CBABF00024 IC
IC501 C0GBH0000006 IC
IC601 C0GBY0000025 IC
Q101 YEANA1036KTX Transistor
CAPACITORs
C101 YECUZ1C104KX Ceramic, 0.1µF 16WV
C102 YECUZ1C104KX Ceramic, 0.1µF 16WV
C103 F3G0J1070003 Tantalum, 100µF 6.3WV
C108 F1H1H4710003 Ceramic, 470PF 50WV
C109 F1H1H4710003 Ceramic, 470PF 50WV
C110 YECUZ1C104KX Ceramic, 0.1µF 16WV
C111 YECUZ1C104KX Ceramic, 0.1µF 16WV
C112 F1H1H333A783 Ceramic, 0.033µF 50WV
C113 F1H1A1050019 Ceramic, 1µF 10WV
C114 YECUZ1C104KX Ceramic, 0.1µF 16WV
C115 YECUZ1C104KX Ceramic, 0.1µF 16WV
C116 F1H1H8210003 Ceramic, 820PF 50WV
C117 F1J1A106A023 Ceramic, 10µF 10WV
C118 F1J1A106A023 Ceramic, 10µF 10WV
C119 YECUZ1E223KX Ceramic, 0.022µF 25WV
C120 YECUZ1C104KX Ceramic, 0.1µF 16WV
C121 YECUZ1H102KX Ceramic, 1000PF 50WV
C122 YECUZ1C104KX Ceramic, 0.1µF 16WV
C124 F1H1H1010006 Ceramic, 100PF 50WV
C201 F1J1A106A023 Ceramic, 10µF 10WV
C202 F1H1A1050019 Ceramic, 1µF 10WV
C203 F1H1H103A783 Ceramic, 0.01µF 50WV
C205 YECUZ1C104KX Ceramic, 0.1µF 16WV
C206 YECUZ1C104KX Ceramic, 0.1µF 16WV
C209 F1H1A1050019 Ceramic, 1µF 10WV
C210 F1H1A1050019 Ceramic, 1µF 10WV
C212 F1H1A1050019 Ceramic, 1µF 10WV
C302 F1H1H103A783 Ceramic, 0.01µF 50WV
C304 F1H1A1050019 Ceramic, 1µF 10WV
C306 YECUZ1C104KX Ceramic, 0.1µF 16WV
C401 ECEA1AKS101 Electrolytic, 100µF 10WV
C406 F1H1H820A231 Ceramic, 82PF 50WV
C407 F1H1H820A231 Ceramic, 82PF 50WV
Part No. Part Name & Description Remarks
mark
Ref.
No.
C408 F1H1H820A231 Ceramic, 82PF 50WV
C409 F1H1A1050019 Ceramic, 1µF 10WV
C411 F1J1A106A023 Ceramic, 10µF 10WV
C501 YECUZ1C104KX Ceramic, 0.1µF 16WV
C502 YECUZ1C104KX Ceramic, 0.1µF 16WV
C503 YECUZ1C104KX Ceramic, 0.1µF 16WV
C504 YECUZ1C104KX Ceramic, 0.1µF 16WV
C601 F1H1H8210003 Ceramic, 820PF 50WV
C602 F1H1H8210003 Ceramic, 820PF 50WV
C603 F1H1A4740008 Ceramic, 0.47µF 10WV
C604 F1H1H333A783 Ceramic, 0.033µF 50WV
C605 YECUZ1C104KX Ceramic, 0.1µF 16WV
C606 F1H1A1050019 Ceramic, 1µF 10WV
C607 ECEA1AKS101 Electrolytic, 100µF 10WV
C608 F1J1A106A023 Ceramic, 10µF 10WV
C609 YECUV1C225KX Ceramic, 2.2µF 16WV
RESISTORs
R101 ERJ6GEYJ1R0V Chip, 1ΩΩΩΩ 1/10W
R102 ERJ3GEYJ152V Chip, 1.5kΩΩΩΩ 1/16W
R103 ERJ3GEYJ152V Chip, 1.5kΩΩΩΩ 1/16W
R104 ERJ3GEY0R00V Chip, 0ΩΩΩΩ 1/16W
R105 ERJ3GEY0R00V Chip, 0ΩΩΩΩ 1/16W
R106 ERJ3GEYJ333V Chip, 33kΩΩΩΩ 1/16W
R107 ERJ3GEYJ333V Chip, 33kΩΩΩΩ 1/16W
R108 ERJ3GEYJ102V Chip, 1kΩΩΩΩ 1/16W
R109 ERJ3GEYJ102V Chip, 1kΩΩΩΩ 1/16W
R110 ERJ3GEY0R00V Chip, 0ΩΩΩΩ 1/16W
R111 ERJ3GEY0R00V Chip, 0ΩΩΩΩ 1/16W
R112 ERJ3GEYJ561V Chip, 560ΩΩΩΩ 1/16W
R113 ERJ3GEYJ823V Chip, 82kΩΩΩΩ 1/16W
R114 ERJ3GEY0R00V Chip, 0ΩΩΩΩ 1/16W
R201 ERJ3GEY0R00V Chip, 0ΩΩΩΩ 1/16W
R202 ERJ3GEYJ121V Chip, 120ΩΩΩΩ 1/16W
R204 ERJ3GEYJ121V Chip, 120ΩΩΩΩ 1/16W
R206 ERJ3GEYJ332V Chip, 3.3kΩΩΩΩ 1/16W
R207 ERJ3GEYJ104V Chip, 100kΩΩΩΩ 1/16W
R210 ERJ3GEYJ105V Chip, 1MΩΩΩΩ 1/16W
R211 ERJ3GEYJ220V Chip, 22ΩΩΩΩ 1/16W
R212 ERJ3GEYJ121V Chip, 120ΩΩΩΩ 1/16W
R213 ERJ3GEYJ121V Chip, 120ΩΩΩΩ 1/16W
R214 ERJ3GEYJ121V Chip, 120ΩΩΩΩ 1/16W
R215 ERJ3GEYJ121V Chip, 120ΩΩΩΩ 1/16W
R216 ERJ3GEYJ121V Chip, 120ΩΩΩΩ 1/16W
R217 ERJ3GEYJ121V Chip, 120ΩΩΩΩ 1/16W
R218 ERJ3GEYJ121V Chip, 120ΩΩΩΩ 1/16W
R219 ERJ3GEYJ121V Chip, 120ΩΩΩΩ 1/16W
R223 ERJ3GEY0R00V Chip, 0ΩΩΩΩ 1/16W
R224 ERJ3GEY0R00V Chip, 0ΩΩΩΩ 1/16W
R301 ERJ3GEYJ221V Chip, 220ΩΩΩΩ 1/16W
R302 ERJ3GEYJ221V Chip, 220ΩΩΩΩ 1/16W
R303 ERJ3GEYJ221V Chip, 220ΩΩΩΩ 1/16W
R304 ERJ3GEYJ221V Chip, 220ΩΩΩΩ 1/16W
R305 ERJ3GEYJ752V Chip, 7.5kΩΩΩΩ 1/16W
R306 ERJ3GEYJ752V Chip, 7.5kΩΩΩΩ 1/16W
R307 ERJ3GEYJ752V Chip, 7.5kΩΩΩΩ 1/16W
R308 ERJ3GEYJ752V Chip, 7.5kΩΩΩΩ 1/16W
R309 ERJ3GEYJ563V Chip, 56kΩΩΩΩ 1/16W
R310 ERJ3GEYJ221V Chip, 220ΩΩΩΩ 1/16W
R311 ERJ3GEYJ563V Chip, 56kΩΩΩΩ 1/16W
R312 ERJ3GEYJ221V Chip, 220ΩΩΩΩ 1/16W
R313 ERJ3GEYJ563V Chip, 56kΩΩΩΩ 1/16W
R314 ERJ3GEYJ221V Chip, 220ΩΩΩΩ 1/16W
R315 ERJ3GEYJ563V Chip, 56kΩΩΩΩ 1/16W
R321 ERJ3GEYJ103V Chip, 10kΩΩΩΩ 1/16W
R322 ERJ3GEYJ332V Chip, 3.3kΩΩΩΩ 1/16W
R323 ERJ3GEYJ332V Chip, 3.3kΩΩΩΩ 1/16W
R324 ERJ3GEYJ332V Chip, 3.3kΩΩΩΩ 1/16W
R325 ERJ3GEYJ332V Chip, 3.3kΩΩΩΩ 1/16W
R326 ERJ3GEYJ332V Chip, 3.3kΩΩΩΩ 1/16W
R327 ERJ3GEYJ332V Chip, 3.3kΩΩΩΩ 1/16W
R328 ERJ3GEYJ332V Chip, 3.3kΩΩΩΩ 1/16W
Part No. Part Name & Description Remarks
7
Ref.
No.
R329 ERJ3GEYJ332V Chip, 3.3kΩΩΩΩ 1/16W
R330 ERJ3GEYJ332V Chip, 3.3kΩΩΩΩ 1/16W
R401 ERJ3GEYJ104V Chip, 100kΩΩΩΩ 1/16W
R404 ERJ3GEYJ473V Chip, 47kΩΩΩΩ 1/16W
R405 ERJ3GEYJ473V Chip, 47kΩΩΩΩ 1/16W
R406 ERJ3GEYJ473V Chip, 47kΩΩΩΩ 1/16W
R407 ERJ3GEYJ121V Chip, 120ΩΩΩΩ 1/16W
R408 ERJ3GEYJ121V Chip, 120ΩΩΩΩ 1/16W
R409 ERJ3GEYJ121V Chip, 120ΩΩΩΩ 1/16W
R410 ERJ3GEYJ121V Chip, 120ΩΩΩΩ 1/16W
R411 ERJ3GEYJ121V Chip, 120ΩΩΩΩ 1/16W
R412 ERJ3GEYJ121V Chip, 120ΩΩΩΩ 1/16W
R416 ERJ3GEYJ103V Chip, 10kΩΩΩΩ 1/16W
R417 ERJ3GEYJ121V Chip, 120ΩΩΩΩ 1/16W
R501 ERJ3GEYJ121V Chip, 120ΩΩΩΩ 1/16W
R502 ERJ8GEYJ1R0V Chip, 1ΩΩΩΩ 1/8W
R503 ERJ3GEYJ121V Chip, 120ΩΩΩΩ 1/16W
R504 ERJ3GEYJ183V Chip, 18kΩΩΩΩ 1/16W
R505 ERJ3GEYJ563V Chip, 56kΩΩΩΩ 1/16W
R601 ERJ3GEYJ103V Chip, 10kΩΩΩΩ 1/16W
R602 ERJ3GEYJ153V Chip, 15kΩΩΩΩ 1/16W
R603 ERJ3GEYJ103V Chip, 10kΩΩΩΩ 1/16W
R604 ERJ3GEYJ153V Chip, 15kΩΩΩΩ 1/16W
R605 ERJ3GEYJ332V Chip, 3.3kΩΩΩΩ 1/16W
R606 ERJ3GEYJ332V Chip, 3.3kΩΩΩΩ 1/16W
R607 ERJ3GEYJ223V Chip, 22kΩΩΩΩ 1/16W
R608 ERJ3GEYJ333V Chip, 33kΩΩΩΩ 1/16W
R609 ERJ3GEYJ473V Chip, 47kΩΩΩΩ 1/16W
R610 ERJ3GEYJ332V Chip, 3.3kΩΩΩΩ 1/16W
R611 ERJ3GEYJ103V Chip, 10kΩΩΩΩ 1/16W
R612 ERJ3GEYJ103V Chip, 10kΩΩΩΩ 1/16W
R613 ERJ3GEYJ332V Chip, 3.3kΩΩΩΩ 1/16W
R614 ERJ3GEYJ101V Chip, 100ΩΩΩΩ 1/16W
R615 ERJ3GEYJ563V Chip, 56kΩΩΩΩ 1/16W
R616 ERJ3GEYJ153V Chip, 15kΩΩΩΩ 1/16W
R617 ERJ3GEYJ103V Chip, 10kΩΩΩΩ 1/16W
R618 ERJ3GEYJ153V Chip, 15kΩΩΩΩ 1/16W
R619 ERJ3GEYJ103V Chip, 10kΩΩΩΩ 1/16W
R620 ERJ3GEYJ333V Chip, 33kΩΩΩΩ 1/16W
R621 ERJ3GEYJ563V Chip, 56kΩΩΩΩ 1/16W
R622 ERJ6GEYJ8R2V Chip, 8.2ΩΩΩΩ 1/10W
Part No. Part Name & Description Remarks
Ref.
No.
SWITCHes
SW1 K0L1BA000104 Switch
[E2916]
SWITCH
SW15 K0L1BA000104 Switch
[E2788]
DIODEs
D1 B3NAA0000065 LED
SWITCH
SW2 K0L1BA000104 Switch
[E2895]
IC´s AND TRANSISTORs
Q4 B3NAA0000065 LED
Q5 B3HB00000023 Transistor
Q6 B3HB00000023 Transistor
Q7 B3HB00000023 Transistor
Q13 B3HB00000023 Transistor
Q16 B3NAA0000065 LED
CONNECTORs
CN311 K1MN11B00062 Connector, 11P
SWITCHes
SW12 K0L1BA000104 Switch
SW14 K0L1BA000104 Switch
Part No. Part Name & Description Remarks
CONNECTORs
CN101 YEAESFW15R1E Connector, 15P
CN301 K1MN21B00072 Connector, 21P
CN302 K1MN06B00085 Connector, 6P
CN401 K1MN14B00080 Connector, 14P
CN501 YEAESFW15R1E Connector, 15P
CN601 YEAE5326102 Connector, 2P
COILs
FL201 J0JAC0000047 Coil
FL202 J0JAC0000047 Coil
SWITCHes
SW8 K0L1BA000104 Switch
SW9 K0L1BA000099 Switch
SW10 K0L1BA000099 Switch
SW11 K0L1BA000099 Switch
CRYSTALs
X201 H2D338500003 Ceramic Oscillator
X301 H2D737400003 Ceramic Oscillator
[E2828]
CONNECTORs
CNP1 K1MN11B00062 Connector, 11P
[E2786]
DIODEs
D5 B3EB00000014 Diode
D6 B3EB00000014 Diode
D7 B3EB00000014 Diode
D13 B3EB00000014 Diode
CONNECTORs
CN312 K1MN06A00016 Connector, 6P
Mechanical Parts
MISCELLANEOUS
AJ1 YGAJ071495 Motor Power Cord w/Plug, 2P
AT1 YEAT05014 Bracket, GND
1 YGFA012275 Upper Chassis Ass´y
2 YGFX018678A Side Bracket L
4 YEFW04159A Roller Shaft Collar
5 YGFX0052588 Outline Detection Spring
6 YGFX0052591 Feeder lock Lever Spring
7 YGFX0052723 Off Backlash Spring
8 YGFA011965C Side Chassis R
9 YGFX206150 Disc Guide U
10 YGFX249601 Feeder Arm Ass´y
11 YGFX018690 Loading Motor Bracket Ass´y
12 YGP0FX5775 Loading Motor Ass´y
13 YGFX2188402 Rubber Roller
8
Ref.
No.
14 YGFW05412 Disc Collar
16 YGAP2916 Loading Motor FPC
17 YGFW05414 Collar Shaft Ass´y
18 YGFX0031122 Loading Gear
19 YGFX206161 Feeder Piece
20 YGFX206159A Guide FL
21 YGFX206202 Slide Plate
22 YGFX0462168B Feeder Plate
23 YGFX219134A Guide F Base
24 YGFX0462182 Guide Cam F Plate Ass´y
25 YGFX218841 Disc Roller
26 YGFW062741 Shaft
27 YGFX0052602 Roller Plate Spring
28 YEFW04181 Guide Plate Collar
30 YGFX0052648 Push Lever Thrust Spring
31 YEFX218308 Roller
32 YGFX0463010 Push Lever
33 YGFX0052589B Push Spring
34 YGFX0052590 Feeder Spring
35 YGFX0052601B Spring
36 YGFX206160 Guide FU
37 YGFX0052712 Guide Spring F
39 YGFX0052594 Clamp Drive Spring
40 YGFA012283B Swing Base Ass´y
41 YGFX0461903B Guide Lever Ass´y B
42 YEFX018595 Guide B
43 YGFX0462172 Horizontal Rack
44 YESFX234004 Horizontal Cam
45 YGFX0032005B Horizontal Cam Gear
46 YGFX0031130 Horizontal Cam Gear
47 YEFX003931 Horizontal Gear 5
48 YGFX0031138 Horizontal Gear 4
49 YEFX014047 Snap Ring
50 YGFX0031125 Horizontal Gear 3
51 YESFX003085 Gear
52 YGFX0032007 Horizontal Gear 1
53 YEFX003884 Stocker Cam 3
54 YEFX003883B Stocker Cam 2
55 YGFX0052595 Stocker Thrust Spring
56 YEFX003875 Elevator Gear 4
57 YGFA012277 Suspension Chassis Ass´y
58 YGP0FX5773 Spindle Motor Ass´y
59 YGFS04745 Damper 2
60 YGFX206156 Disc Guide S
61 YGFX9995354 Nut Piece
62 YGFX218312 O-Ring
63 YGFX0052582A Damper Spring R
64 YEFX003872 Elevator Gear 1
65 YGFX0052593 Sus. Lock Spring
66 YGFX0463014 Lever
67 YEFX003873 Elevator Gear 2
68 YEFX003874 Elevator Gear 3
69 YGFX003882B Stocker Cam 1
70 YGFX0462173 Stocker Rack
71 YGP0FX5707 Optical Pick-up Ass´y
72 YGJT03363 Feed Screw Ass´y
73 YGFX0052586 Thrust Adjustment Spring
74 YEFW04161A Feed Screw Housing
75 YGFX0052650 Travers Guide
76 YGP0FX5774 Traverse Motor Ass´y
77 YGFX018816 Gear Bracket
78 YGFX0031119 TR Gear 2
79 YGFX0031120 TR Gear 3
80 YGFA012279 Suspension Chassis Bottom
81 YGFS04746 Damper 1
82 YGFX0052596 Stocker Spring
83 YGFX0052587 Unclamp Spring
84 YGFX0052583A Damper Spring
85 YGFX0052581A Damper Spring F
86 YGP0FX4761 Elevator Motor Ass´y
87 YGAP2788 Elevator Motor FPC
88 YGFX018600A Elevator Motor Bracket
Part No. Part Name & Description Remarks
Ass´y
Ref.
No.
89 YGFX0462174B Suspension Lock Plate
90 YGFX0053030A Stocker Spring
91 YGFX0462166 SW Cover
92 YGAP2828 Suspension FPC
93 YGFX233554 Disc Holder L
94 YEFX0031007 Disc Hold Gear
95 YGFA011976G Main Chassis Ass´y
96 YGFX0031128 Clamp Cam Gear
97 YGFV012474 Insulator
100 YGFX0462184 Guide Cam B Plate Ass´y
101 YGFX219135 Guide B Base Ass´y
102 YGFX206155A Guide BL
103 YGFX206136E Guide BU
104 YGFX0052662 Guide Spring B
105 YGFX0462185 Avoidance Lever 1 Ass´y
106 YGFX0031137 Pushout Cam Gear
110 YGFA012281 Stocker Top Coner Ass´y
111 YGFX233551 Stocker Tray Support
112 YGFX0463011 Pushout Lever
113 YGFX018691 Horizontal Motor Bracket
114 YGP0FX5772 Horizontal Motor Ass´y
115 YESFX003087 Pushout Gear 2
116 YESFX003086 Pushout Gear 1
117 YGFX233553 Disc Holder U
118 YGFX0052608 Push Lever Spring
119 YGFX0052584 Avoidance Lever Spring
120 YEFX0052291B Pushout Plate Spring
131 YGFX233552 Stocker Tray Housing L
132 YGFX9995641 Stocker Tray
150 XUC15V Retaining Ring
151 XUC2V E-Ring
152 YEJE01044 Retaining Ring
153 YGFW05389 Stocker Cam Ring
154 XQN2+A2FX Screw, M2x2mm
155 XQN2+C2FX Screw, M2x2mm
156 XSB2+3FJ Bind Screw, M2x3mm
157 XSB2+4FX Bind Screw, M2x4mm
158 XYN2+C4FX Screw w/Washer, M2x4mm
159 XYN2+C5FX Screw w/Washer, M2x5mm
160 XYN2+C6FX Screw w/Washer, M2x6mm
161 YEJS02037B Tapping Screw
162 YEJS06246 Thin Head Screw w/Washer
163 YGJS05051 Thin Head Screw w/Washer
164 YGJS05063 Screw w/Washer
165 YEJS06097A Screw
169 YEJS06244 Screw, M1.7x3mm
Part No. Part Name & Description Remarks
Ass´y
9
8 EXPLODED VIEW (CD Deck-1)
10
9 EXPLODED VIEW (CD Deck-2)
11
10 EXPLODED VIEW (CD Deck-3)
12
11 WIRING DIAGRAM (CD Deck)
11.1. CD Servo Block (Top View)
13
11.2. CD Servo Block (Bottom View)
14
12 SCHEMATIC DIAGRAM (CD Deck)
15
Printed in Japan 2005.6 (K)
Loading...