Orion VCL-MX System Manual

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

1

O

O

RRIIOONN

T

T

EELLEECCOOM

M

N

N

EETTW

WOORRKKSS

I

I

NNCC..

VCL-MX Version 6

80 E1, 160Mbps Voice & Data Multiplexer

System Guide

Orion Telecom Networks Inc.

16810, Avenue of Fountains,

Suite # 108, Fountain Hills,

AZ 85268 USA

PH: ([phone],

FAX: [phone]

E-mail: [e-mail]

Web Site: http://www.oriontelecom.com

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

2

Warranty

This Orion product is warranted against defects in material and workmanship for a period of one year
from the date of shipment. During the warranty period, Orion will, at its discretion, either repair or
replace products, which prove to be defective. For warranty service or repair, this product must be
returned to a service facility designated by Orion. The buyer shall prepay shipping charges to Orion and
the company shall pay shipping charges to return the product to the buyer. However, the buyer shall
pay all the shipping charges, duties and taxes for products returned to Orion from another country.

Limitation of Warranty

The foregoing warranty shall not apply to defects resulting from improper or inadequate maintenance by
the buyer. The buyer-supplied firmware or interfacing, unauthorized modification or misuse, operation
outside of the environmental specifications for the product or improper site preparation or maintenance.

Exclusive Remedies

The remedies provided herein are the buyer's sole and exclusive remedies. Orion shall not be liable for
any direct, indirect, special, incidental or consequential damages, whether based on contract or any
legal theory.

Notice

This manual contains information that is proprietary to Orion Telecom Networks Inc. No part of this
publication may be reproduced in any form whatsoever without prior written approval by Orion Telecom
Networks Inc.

Safety Warnings

The exclamation point within a triangle is intended to warn the operator or service
personnel of operation and maintenance factors relating to the product and its operating
environment, which could pose a safety hazard.

Always observe standard safety precautions during installation, operation and maintenance of this
product. Only qualified and authorized service personnel should carry out adjustment, maintenance or
repairs to this instrument. No adjustment, maintenance or repairs should be performed by either the
operator or the user.

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

3

Index

S. No. Particulars Page No.

1 Foreword 4

2 Product Overview 5

3 Key Features 6

4 Additional Features 6

5 Highlights 7

6 Security and Password Features 7

7 Transmission Mediums 7

8 Multi-service platform 8

9 Configuration and Flexibility 8

10 Synchronization 8

11 Application of VCL-MX 9

12 System Overview and Architectural Details 9

13 Safety: Laser protection 9

14 Front View 10

15 Back View 11

16 Voice Interfaces 11

17 Data Interfaces 12

18 Chassis / System Backplane 12

19 System Management 12

20 Technical Specifications 13

21 Protection 21

22 Management Interfaces 21

23 Power Supply 21

24 Power Consumption 22

25 Environmental 22

26 Dimensions 23

27 Application Diagrams 23

28 Ordering Information 30

29 Support 35

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

4

Foreword

The VCL-MX Version 6 - 80 E1, 160Mbps Multiplexer is a compact, carrier class and cost-effective
bandwidth provisioning equipment designed to manage and deliver services from the optical core to the
access.

This system guide presents the technical specifications along with the functions and features of the
product. It gives a brief description of the hardware and software associated with the VCL-MX Version 6

- 80 E1, 160Mbps Multiplexer. This user guide also gives an overview of the various applications in
which VCL-MX Version 6 - 80 E1, 160Mbps Multiplexer can be used. These are explained with the use
of application diagrams. These application diagrams are useful for the Network planning and design
engineers.

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

5

Product Overview

VCL-MX Version 6 – 80 E1 Multiplexer may be
used for inter-connecting legacy voice and
data networks, provisioning and managing
bandwidth on a E1 channelized level as well
as 64Kbps and sub-rate multiplexing at DS-0
time-slot level and as a digital-access cross­connect equipment. Due to the changing traffic
patterns, there is a need to support multiple
services from the same equipment like
integrated data transport, better network
management etc. This necessitated evolution
to next generation E1 Multiplexer.

Redundant control card and power supply options make it an ideal chose for network service providers
seeking to integrate and provide legacy and the next generation services from a single platform.

Next generation E1 Multiplexer has emerged as one of the most economical and technologically viable
solutions for transmitting both voice and data over carrier networks. This technology offers savings on
investments/power and space to service providers.

Orion Telecom Networks, Inc., USA provides efficient solutions in this field using the E1 Multiplexer
series products. E1 Multiplexer provides a full range of solutions in this evolving field of next generation
telecom solutions. E1 Multiplexer family provides the unique advantage of carrying both data and voice
over PDH. In addition to being affordable, these products have built-in modularity, which allow easy
upgradeability. This upgradeability feature allows the customer to evolve in a “build-as-you-grow”
concept. Along with the Orion Telecom as Network Management solution the E1 Multiplexer family
provides the following features:

• Easy network manageability

• Lower cost per line

• Easy upgradeability

• Carrying both data and voice over PDH

• Easy integration to SDH network

• Higher reliability

Key Features

VCL-MX Version 6 – 80 E1, 160Mbps Multiplexer provides the advanced features and capabilities,
listed below:

• 160Mbps, 80 E1 fully non-blocking cross-connect at 64Kbps (DS-0) level (2480 DS-0 – any to any
time-slot cross-connect)

• 8Kbps cross-connect granularity is supported for sub-rate multiplexing to provide up to 4
asynchronous data channels in a single 64Kbps time-slot.

• Multi-service platform – may be used to provide a wide variety of voice and data services from
single chassis

• 1+1 E1 Link Protection / E1 Port Redundancy

• 1+1 Control Card Processor Redundancy

• 1+1 Cross-Connect Redundancy

• 1+1 Timing (Synchronization Clock) Redundancy. User selectable synchronization priority.

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

6

• 1+1 48V DC Power Supply Redundancy (Dual Power Input – allows the equipment to be powered
from two separate sources

• Optional - 1+1 Channel Protection - allows the user to protect 64 Kbps voice & data channels

• 144 FXO or 144 FXS channels per unit.

• 72 E&M 2-wire / 4-wire channels per unit

• Any “mix” of data and voice channels in a single unit

• Universal Slots – slot independent system so that any type of interface card may be inserted and

used in any card slot.

• Supports R2 CAS, ITU-T Q.421 and ITU-T Q.422 signaling

• Supports CAS Custom / User Programmable ABCD Signaling

• Bit Error Rate (BER) monitoring – BER thresholds to generate BER alarms automatically whenever

alarm limits are exceeded.

• Supports Long Loops of up to 1200 Ohms

• Supports 75 VRMS and 90 VRSM Ring Voltage Options

• Supports A-law and Mu-law voice coding.

• Supports sinusoidal un-balanced ring output

• Provides a ring of ≥75 volts RMS into a load of 5 R.E.N. on each channel with a 0.30 Erlang traffic

pattern (5 R.E.N. load = 5 parallel phone load on each line).

• May be used in a Point-to-Point, Point-to-Multi point, Add-Drop (drop-insert), Tree and Star topology

• Telnet

• SSH for secured access

• SNMP traps

• Maintains Access Security Log

• In-band and Out-of-band management

• GUI (Graphical User Interface)

Additional Features

• Voice and Digital Data services

• Any combination ("mix-n-match") of Voice and Digital Data services deployed from a single

VCL-MX "Smart Shelf” - 4, 8, 12, 16 channels per card

• Integrated IEEE C37.94 Teleprotection Interface

• Digital Data option may be used for internet access or video conferencing application

• Wireless applications including Cellular Networks

• Digital Microwave Radio

• SCADA applications

• ATM/Frame Relay circuit termination

• Powerful Network Management System for monitoring and network control

• Compliance with all relevant ITU-T (CCITT) recommendations

• 19-inch, 6U high construction.

Highlights

• Field upgradable to provide voice, data or both services

• Flexibility on use of transmission medium-copper, fiber or wireless

• Choice of Interfaces for Voice and Data Applications

• USB and RS232, Interface for local connection through the serial interface to the "Network

Control and Management Software”

• In-band and Out-of-band system configuration and management interface.

• Channel assignment independent of slot position in the sub-rack

• Extensive set of alarms

• User Selectable Internal, External and Loop-timed clock synchronization priority options

• Universal slots - any interface card can plug in at any interface slot.

• OAM Card

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

7

Security and Password Features:

System Access, Control and Management Options:

• Telnet

• SSH

• CLI Control Interface (HyperTerminal or VT100)

• SNMP V2 Traps (MIB File provided).

OAM: Operation And Management Ports

• RS232 Serial Port

• USB COM Port

• 10/100BaseT Ethernet for remote access.

Security and Protection

• Secured Access via SSH V2

• Password Protection: Password Protection in compliance with the mandatory clauses of the

• GR-815-CORE-2 specifications for secured access control.

• Logging: Maintains a log of all successful and un-successful attempts. Logged information

includes the ID and the IP address of the accessing entities. Alerts the administrator if the un­successful logging attempts exceed 3.

• Security Audit: All access logs for up to 30 days are maintained for security audit purposes.

• Security log entry of any request or activity including that user-ID (including IP address, if

applicable), to establish user accountability

• Report Generation / Audit Trail

• Security Administration.

Transmission Mediums

The VCL-MX offers an excellent flexibility on the choice of transmission medium over which it may be
deployed. The transmission medium can be either of the following:

• Copper

• Optical Fiber

• Wireless.

Multi-service platform

VCL-MX Version 6 - E1 160Mbps Multiplexer supports both data and voice traffic.

For voice traffic, it supports the following interfaces:

• FXO

• FXS

• E&M (2Wire / 4Wire)

• Hot-Line (Ring-Down)

• 18 x five-way / 30 x three-way voice conferencing

• Ring Generator (75V RMS)

• GEN GEN / Magneto Interface Card

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

8

For data traffic, it supports the following interfaces:

• Channelized E1 / Fractional E1 data

• RS-232 asynchronous data

• Sub-rate multiplexing to provide 4 asynchronous data channels in a single 64Kbps time-slot

• V.24 synchronous data / asynchronous data

• G.703, @ 64 Kbps, co-directional

• V.35, V.36, X.21, V.11, RS530, RS449 synchronous, “n”x64Kbps data

• Relay I/O Card (Dry Contact)

• Universal DCE / DTE synchronous “n”x64Kbps data interface

• BRI ISDN “U” Interface

• IEEE C37.94 Teleprotection Interface

• 8E1 plus 100Mbps Ethernet fiber optical transport interface along with the following:

• EOW (Engineering Order Wire) channel for end to end installation and maintenance

• Local and remote loop back test for diagnostics

• 1+1 Fiber Path protection

• ALS (Auto Laser Shutdown) facility for eye safety

• 10/100M Ethernet Port - 100 Mbps Ethernet data transmission rate complies with IEEE8 02.3

Configuration and Flexibility

VCL-MX Version 6 - E1 160Mbps Multiplexer can be configured as an Add-Drop Multiplexer (ADM) and
Terminal Multiplexer (TMUX). It can support diverse topologies like point-to-point, ring, star and tree.

It can be configured in various topologies supporting both electrical and optical interfaces. It can take
modular cards, which would enable the customers to start small and grow as traffic demands scale.

Synchronization

Timing Options

Internal Clock, Loop-Timed Clock, External Clock. User selectable
synchronization priority

Synchronization Sources

Internal Clock, span clock timing derived from incoming HDB3 links
(Loop-Timed), External Clock, 75 Ohms (TTL), 2.048 Mbits and
120 Ohms (Bits clock)

Default Option Internal Clock (Stratum 3)

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

9

Application of VCL-MX

POTS (voice), digital data or real-time video conferencing services (V.35, V.36, X.21) high-speed digital
data interface options allow point-to-point network solutions for providing a video conferencing channel
of up to 1920 Kbps).

• Junction Mux - for digital interconnection of analog exchanges

• Point-to-Point, Point-to-Multi point, Add-Drop (drop-insert), Tree and Star topology applications

• Wireless network applications

• High-speed data ports for digital communication links providing Leased Lines access to Internet

Service Providers (ISPs) with speeds ranging from 64Kbps up to 1920 Kbps digital data
interface options

• Micro-Cellular infrastructure applications for providing cell-switch connectivity

• Wide area networking

• Internet access over POTS lines - All POTS interfaces operate @ 64Kbps and support V.34

(33.6Kbps) dial-up modems.

• Up to 80 E1 Digital Access Cross-Connect. Large, completely non-blocking cross-connect for

up to 64Kbps 2480 time-slots - any” time-slot to “any” time-slot.

System Overview and Architectural Details

The VCL-MX Version 6 – 80 E1, 160Mbps Multiplexer provides full range of POTS (voice) and digital
data services to subscribers located at different locations, requiring to interconnect and establish a
voice and data network over an E1 Link. The VCL-MX is a simple, yet powerful E1 Channel Bank for
connecting and integrating analog communication equipment with digital E1 services.

The VCL-MX Version 6 – 80 E1 160Mbps Multiplexer provides cross connect, voice telephony and
digital data services for applications, which may include:

E1 Multiplexer platform has been envisaged to address the growing demand for an ultra-compact Add­Drop Multiplexer (ADM) and provide Ethernet-over-PDH mapping functions. It can be configured in
various topologies such as linear, star, ring and bus.

VCL-MX Version 6 – 80 E1, 160Mbps Multiplexer has a multi-slot chassis with TDM backplane. In the
chassis, there are ten (10) traffic slots meant for tributary cards (line cards). The line cards can support
various type of interface cards, which include E1, Voice and very wide variety of Data interfaces.

Two slots are reserved for 1+1 redundant system / control cards, which include the redundant cross
connect, processor and aggregate interface functions. One dedicated slot exists for an OAM card, one
for ring generation and two slots for 1+1 redundant power supply.

Safety: Laser protection

The optical interfaces of the VCL-MX Version 6 - E1 160Mbps Multiplexer come with Class 1, Small
Form-factor Pluggable (SFP)-based optical line interfaces with digital diagnostics capability for SFPs on
the optical interface cards.

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

10

Front View

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

11

Back View

The Multiplexer may be used in Terminal or Drop-Insert configuration to provide:

• Toll Quality Voice Services

• Interconnect LAN (Campus Network)

• Interconnect computer terminals various types of data terminals

• Provide LAN-WAN Interconnectivity.

Voice Interfaces

For voice traffic, it supports the following interfaces:

• FXO

• FXS

• E&M (2-wire and 4-wire)

• Hot-Line (Ring-Down)

• 18 x five-way / 30 x three-way voice conferencing

• Ring Generator (75V RMS)

• GEN GEN / Magneto Interface Card

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

12

Data Interfaces

For data traffic, it supports the following interfaces:

• Channelized E1 / Fractional E1 data with full cross-connect capability at 64Kbps, DS-0 level

• RS-232 asynchronous data

• Sub-rate multiplexing to provide 4 asynchronous data channels in a single 64Kbps time-slot

• V.24 synchronous data / asynchronous data

• G.703, @ 64 Kbps, co-directional

• V.35, V.36, X.21, V.11, RS530, RS449 synchronous, “n”x64Kbps data

• BRI ISDN “U” Interface

• Relay I/O Card (Dry Contact)

• IEEE C37.94 Teleprotection Interface

• Universal DCE/DTE synchronous “n”x64Kbps data interface

• 8E1 plus 100Mbps Ethernet fiber optical (1+1) protected transport interface

Chassis / System Backplane

All connections are made at the rear of the chassis, providing interconnections between the various
plug-in cards and to the network. VCL-MX Version 6 - E1 160Mbps Multiplexer and supports high­density PDH cards. The line cards terminate a combination of Voice, Data and E1 Interfaces.

The VCL-MX E1 Multiplexer has a 160 MBits/sec backplane and provides a host of features including,
channel drop and insert facility over a network of VCL-MX E1 Multiplexers, for voice and data
applications.

An extensive set of alarms, for easy maintenance are provided in the system.

System Management

VCL-MX Version # 6 - Voice and Data Drop-Insert Multiplexer offer a variety of management options,
The VCL-MX E1 multiplexer management software can be configured using CLI (English text)
commands and GUI (Graphical User Interface). The management and configuration commands may be
executed from a VT100 terminal, Windows HyperTerminal, any DOS based system, Linux or UNIX
based system, or Telnet (remote management).

The equipment provides a wide choice of access ports for connecting to and executing management
and configuration commands through its OAM Card

The OAM card provides:

a) COM Port (RS232 Serial Port).
b) USB Port
c) 10/100BaseT Ethernet Port (each multiplexer may be assigned an IP address and connected to

a LAN / IP network for remote access and management through the 10/100BaseT Ethernet Port

for out-of-band configuration, management and access).
d) Telnet
e) SSH
f) SNMP, V2
g) Additionally, a Windows based GUI (Graphical User Interface) for easy configuration,

management and access.

The VCL-MX has an effective, CLI (text) and GUI based "Network Management Interface", which may
be used for configuring and monitoring multiple systems from a single central location.

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

13

Technical Specifications:

E1 Interface: (Part No. VCL-MX-1520-E1-5.0)

Maximum number of interface cards
(in a single chassis)

As per requirement and upto 10
Used to map with Voice and Data Interface

Number of interfaces per E1 Interface
Card

8 E1 Interfaces

Conformity (electrical) G.703

Frame structure As per ITU (CCITT) G.704

Signaling Channel Associated Signaling

PCM Sampling Rate 8000 Samples / sec

Bit rate 2048 Kbps ± 50 ppm

Code HDB3, 50 % Duty Cycle

Nominal Impedance

120Ω balanced / 75Ω unbalanced

Peak voltage of a mark
For 120 Ω Balanced interface
75 Ω Unbalanced interface

3.0 V ± 0.3 V

2.37 V ± 0.237 V
Peak voltage of a space
For 120 Ω Balanced interface
75 Ω Unbalanced interface

0 V ± 0.3 V
0 V ± 0.237 V

Nominal pulse width 244 ns

Pulse mask As per ITU (CCITT) Rec. G.703

Output jitter <0.05 UI (in the frequency range of 20Hz to 100 KHz)

Permissible Attenuation 6 dB at 1 MHz

Return loss at:

51.2 KHz to 102.4 KHz

102.4 KHz to 2048 KHz
2048 KHz to 3072 KHz

> 12dB
> 18dB
> 14dB

Jitter tolerance As per ITU (CCITT) G.823

Frame alignment As per ITU (CCITT) G.732

Loss and recovery of frame alignment As per clause 3 of ITU (CCITT) G.732

Loss and recovery of multi-frame
alignment

As per clause 5.2 of ITU (CCITT) G.732

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

14

FXS, Voice Frequency Interface: (Part No. VCL-MX-1525-16-5.0)

Maximum number of interface cards 9
Number of channels per card 16

Interface type

FXS,
A-law, 8 bit/sample, A=87.6 / 87.7, 13 segment coding

Maximum number of channels

(In a single chassis)

144

Transmission performance Fully compliant to ITU (CCITT) G.712 specification
Line impedance

600 Ω (900 Ω optional)

Voice channel frequency 300Hz-3400Hz

Insertion loss / gain

-2.0 dB Nominal (user adjustable)

Adjustable range –30 dB to +3 dB in steps of 0.5dB
User selectable range for gain /
insertion loss

0 dB to 18 dB

Idle channel noise

≤ - 65 dB

Return loss

300Hz – 600Hz - ≥ 12 dB

600Hz – 3400Hz - ≥ 15 dB
Longitudinal balance ≥ 46 dB between 300Hz to 3400Hz
Ring frequency 16 Hz, 20 Hz, 25 Hz, 50 Hz

Ring voltage

≥ 75 volts RMS into a load of 5 R.E.N. with a 0.30 Erlang

traffic pattern
Subscriber loop current ≥ 30mA into a subscriber loop of 1200 Ohms
Overload level +3.14 dBm ± 0.5 dBm

Battery reversal All channels
Dial pulse speed 50 pps – Pulse Dialing ≤ ± 2 ms / DTMF Dialing
Protection As per ITU-T Rec. K.20

FXO, Voice Frequency Interface: (Part No. VCL-MX-1530-16-5.0)

Maximum number of interface cards 9
Number of channels per card 16

Interface type

FXO

A-law, 8 bit/sample, A=87.6 / 87.7, 13 segment coding

Maximum number of channels

(In a single chassis)

144

Transmission performance Fully compliant to ITU (CCITT) G.712 specification

Line impedance

600Ω (900Ω optional)

Voice channel frequency 300Hz-3400Hz

Insertion Loss / Gain

-2.0 dB Nominal (user adjustable)

Adjustable range –30 dB to +3 dB in steps of 0.5 dB
User selectable range for gain /

insertion loss

0 dB to 18 dB

Idle Channel Noise

≤ -65dB

Return loss

300Hz – 600Hz - ≥ 12 dB

600Hz – 3400Hz - ≥ 15 dB
Longitudinal balance ≥ 46 dB between 300Hz to 3400Hz

Overload Level +3.14 dBm ± 0.5 dBm

Battery reversal All channels
Dial pulse speed 50 pps – Pulse Dialing ≤ ± 2 ms / DTMF Dialing

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

15

Hot-Line Interface Card: (Part No. VCL-MX-1525HTL-16-5.0)

Number of channels per card 16

Maximum number of interface cards 9

Maximum number of channels 144

Interface type

Hot-Line

A-law, 8 bit/sample, A=87.6 / 87.7, 13 segment coding
Transmission performance Fully compliant to ITU (CCITT) G.712 specification

Line Impedance

600Ω (900Ω optional)

Loop resistance Upto 2000 Ohms

Voice channel frequency 300Hz-3400Hz

Insertion loss / gain

-2.0 dB Nominal (user adjustable)

Adjustable range –30 dB to +3 dB in steps of 0.5 dB
User selectable range for gain /

insertion loss

0 dB to 18 dB

Idle channel noise

≤ -65 dB

Return loss

300Hz – 600Hz - ≥ 12 dB

600Hz – 3400Hz - ≥ 15 dB
Longitudinal balance ≥ 46 dB between 300Hz to 3400Hz

Ring frequency 16 Hz, 20 Hz , 25 Hz, 50 Hz

Ring voltage

≥ 75 volts RMS into a load of 5 R.E.N. with a 0.30 Erlang

traffic pattern

Subscriber loop current ≥ 30mA into a subscriber loop of 1200 Ohms

Overload level +3.14 dBm ± 0.5 dBm

Dialing Ring-down

E&M 2 Wire / 4 Wire Voice Frequency Interface (Part No. VCL-MX-1535-08-5.0)

Number of channels per card 8

Maximum number of interface cards 9

Maximum number of channels 72

Interface type

2W / 4W E&M, Type II and Type V

A-law, 8 bit/sample, A=87.6 / 87.7, 13 segment coding
Transmission performance Fully compliant to ITU (CCITT) G.712 specifications

Line impedance

600Ω (900Ω optional)

Voice channel frequency 300Hz-3400Hz

Insertion loss / gain

-2.0 dB Nominal (user adjustable)

Adjustable range –30 dB to +7.5 dB in steps of 0.5 dB
User selectable range for gain /

insertion loss

0 dB to 18 dB

Idle channel noise < 65 dB

Return loss

300Hz – 600Hz - ≥ 12 dB

600Hz – 3400Hz - ≥ 15 dB
Longitudinal balance ≥ 46 dB between 300Hz to 3400Hz

Dial pulse speed 50 pps – Pulse Dialing ≤ ± 2 ms / DTMF Dialing

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

16

Maximum M-Lead resistance 1200 Ohms

Maximum M-Lead current drain < 5 mA

Maximum E-Lead current < 100mA

Conference Interface Card: (Part No. VCL-MX-1590)

Number of Channels per Card 5

Conference capability

18 five-way / 30 three-way multi port voice conference

capability
Interface Type 4 Wire E&M

Maximum Number of Channels 90
Transmission performance Fully compliant to ITU G.712
Line Impedance

600 Ω
Voice Channel Frequency 300Hz-3400Hz
Idle Channel Noise

≤ -65 dB

Return Loss

300Hz - 600Hz - ≥ 12 dB

600Hz - 3400Hz - ≥ 15 dB
Longitudinal Balance ≥ 46 dB between 300Hz to 3400Hz

Low Speed Data Interface Asynchronous RS232 (Part No. VCL-MX-1559-08-5.0)

Number of interfaces per card 8
Maximum number of interface cards 9
Mode Asynchronous, RS232 (V.24/V.28 line drivers) - DCE
Bit rate 50 bps to 19.2 Kbps
Character length 5 / 6 / 7 / 8 (auto-select)
Stop bits 1 / 1.5 / 2 (auto-select)

Parity Even / Odd / 0’s / 1’s / none (auto-select)

GEN GEN / Magneto / Local Battery Interface Card: (Part No. VCL-MX-1587)

Number of channels per card 16

Interface type

Magneto, 2-wire (GEN-GEN)

A-law, 8 bit/sample, A=87.6 / 87.7, 13 segment coding

Line impedance 600Ω
Voice channel frequency 300Hz-3400Hz
Maximum number of channels 144
Transmission performance Fully Compliant to ITU (CCITT) G.712 specification
Voice channel frequency 300Hz-3400Hz

Insertion loss / gain

-2.0 dB Nominal (user adjustable)

Adjustable range -30dB to +3 dB
User selectable range for gain /

insertion loss

0 dB to 18 dB

Idle channel noise

≤ -65 dB

Return loss

300Hz - 600Hz - ≥ 12dB

600Hz - 3400Hz - ≥ 15dB

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

17

Longitudinal balance ≥ 46 dB between 300Hz to 3400Hz
Overload level +3.14 dBm ± 0.5 dBm

High Speed Data Interface Asynchronous 50bps to 115.2Kbps Asynchronous Data Interface (Part
No. VCL-MX-1558-04-48AHS)

Interface RS232, RS485, V.24

Number of interfaces per card 4
Maximum number of interface cards 9
Bit Rate 50bps to 115.2Kbps -user selectable
Character length 5 / 6 / 7 / 8 (auto-select)
Stop bits 1 / 1.5 / 2 (auto-select)

Parity Even / Odd / 0’s / 1’s / none (auto-select)

Mode DCE or DTE, User selectable

64Kbps Universal Data Interface (Part No. VCL-MX-1545-04-48)

Number of interfaces per card 4
Maximum number of interface cards 9
Mode – Synchronous - Interface V.35 / V.36 / X.21 / RS530 / V.24 / V.11 / V.28 - DCE
Mode - Asynchronous - Interface RS232 / RS485 / V.24 / V.11 / V.28 - DCE

Mode - Sub Rate Multiplexing ­Interface

RS232 / RS485 / V.24 / V.11 / V.28 - 4 Asynchronous data

channels multiplexed into one single 64 Kbps timeslot - DCE

Conformity EIA and ITU-T

Synchronous Bit rate

V.35 / V.36 / X.21 / RS530 / V.11 @ 64 Kbps

V.24 @ 300, 600, 1200, 2400, 4800, 9600, 19200 bps
Asynchronous Bit rate 50 bps to 19200 bps

G.703 @ 64kbps, Synchronous Data Interface: (Part No. VCL-MX-1560-08-5.0)

Interface G.703 @ 64 Kbps

Number of interfaces per card 8

Maximum number of interface cards 9

Conformity To (CCITT) Rec. G.703

Mode Synchronous, Co-directional

Bit rate 64Kbps

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

18

BRI ISDN, 2B+D Interface Card: (Part # VCL-MX-1550-04-5.0)

BRI ISDN Interface "U" Interface

Compliance Meets ANSI T1.601-1992 requirements

Bit Rate 160 Kbits/s

Frame Format 2B+D as per ITU-T (CCITT) Rec.1.430

Line Code 2B1Q as per ITU-T (CCITT) Rec.G.961

Accepted Line Attenuation 42dB at 40 KHz

Pulse Shape As per ITU-T (CCITT) Rec.G.961

Impedance 135 Ohms at 40KHz

Maximum distance: 5 km (4 miles) on 0.5 mm twisted Pan. Distance may vary with cable gauge.

For distance using various cable gauges please refer chart below.

Distance in kms. (Miles)

Wire Gauge (AWG/mm)

Line Rate

(Kbps)

144

19 (.9mm)

17.4 (10.8)

22 (.6mm)

11.6 (7.2)

24 (.5mm)

8.1 (5.0)

26 (.4mm)

5.5 (3.4)

Relay I/O Interface Card: (Part No. VCL-MX-1547-16-48)

Description: This interface card provides 16 Relay I/Os that may be used to extend either Dry Relay
Contacts (Relay Normally-Open or Relay Normally-Close) or operate switches remotely (using Dry
Relay Contacts rated 2A @ 60Volts DC) between any two Multiplexers using a 64 Kbps time-slot.

Maximum number of channels 144

Maximum number of interface cards 9

Relay Specifications (Drivers)

Maximum Number of Dry Contact Sensors 16

Maximum switching power 60 W (approximately)

Maximum switching voltage / current

60V DC, 2 A
250V AC, 2 A

Isolation 2.5 KVA Minimum

Typical number of operations > 1 million

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

19

Dry Contacts Sensors

Maximum number of dry contact sensors 16

Maximum current 50 mA

Typical current 20 mA

Reference source voltage 3.3 Volts

Universal Data Interface: High Speed Synchronous “n x 64” Data Interface Type - User
Configurable DCE-DTE: (Part No. VCL-MX-1558-04-48)

Interface

V.35 (DTE/DCE)
V.36 (DTE/DCE)
X.21 (DTE/DCE)
V.11 (DTE/DCE)
RS422 (DTE/DCE)
RS530 (DTE/DCE)

Number of interfaces per card

4, (“N” x 64KBits/sec. per card)

Maximum number of interface cards 9

Bandwidth

(“N” x 64 Kbits/sec. interface
maximum value of “N” =30)-user selectable

Conformity Universal user-configurable as above
Mode Synchronous
Bit rate 64 Kbps to 1920 Kbps

User interface DCE/DTE (User programmable for DTE/DCE mode)

High Speed “n x 64” Data Interface Type: 10/100BaseT Ethernet with Electrical Ethernet:
(Part No. VCL-MX-1595-04-5.0)

Interface 10/100BaseT (Electrical)

Number of interfaces per card 4 Ports (4 x 10/100BaseT Electrical)

Maximum number of interface cards 9

Application Point to point

Bandwidth

(“N” x 64 Kbits/sec. interface
minimum value of “N” =1
maximum value of “N” =30) - user selectable

Aggregate bandwidth

1920Kbps – maximum, user programmable in steps of
64Kbps from 64 Kbps to 1920Kbps.

Conformity 10/100BaseT Ethernet Electrical

User interface 10/100BaseT

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

20

8 E1 Plus 100Mbps Ethernet Fiber Optical Transport Interface
(Part No. VCL-MX-1551-5.0-WLWL-DKM)

Optical

Number of optical ports 1+1 redundant, automatic link protection

Channel capacity 8E1 Plus 100Mbps Ethernet

Jitter character ITU-T G.742, G.823 complaint

Type of transmitter Class 1 Laser

Transmitter power

-11 dBm to +3 dBm - as ordered
20 km, 40 km, 80 km, 120 km reach – as ordered

Receive sensitivity - 34 dBm

Bit rate 155 Mbps

Wavelength

850 nm multimode / 1310nm singlemode / 1550nm
singlemode (optional)

Optical connector LC (MSA Complaint SFP Module)

Fully compliant with ITU-T G.957, G.958 Specification

Class 1 Laser Product, Compliant with IEC 60825-1

Compliant with Telcordia (Bellcore) GR-468-CORE

Safety

Class 1 Laser

Auto Laser Shut Down in the event of fiber break.

Ethernet Interface - 10/100BaseT

Number of interfaces 4

Interface RJ-45 Ethernet 10BaseT or 100BaseT-TX (auto sensing)

Compliance

Ethernet Version 2.0 IEEE802.3
10Base-T & 100Base-TX Activity, Full/half duplex.

Interface rate 100 Mbps Ethernet data transmission rate

Order Wire Interface

Phone set Standard 2-wire phone set

Bandwidth and coding 64 Kb/s PCM Channel, A-Law Coding

Integrated IEEE C37.94 Teleprotection Interface (Part No. VCL-MX-1552-SM)

Number of interfaces per card 4

Maximum number of interface cards 9

Maximum number of channels 36

Standards IEEE C37.94

Optical 1310nm Single Mode (40KM / 80KM / 120KM)

Optical connector FC-PC / ST-PC / LC

Safety Class 1 Laser

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

21

Integrated IEEE C37.94 Teleprotection Interface (Part No. VCL-MX-1552-MM)

Number of ports 4

Standards IEEE C37.94

Optical

850nm Multi Mode (2KM)
1310nm Multi Mode (2KM)

Optical connector FC-PC / ST-PC / LC

Protection

Remote / FXS (subscriber side) interface is protected against power surges and transients occurring
from lightning and electric induction as per ITU-T Rec. K.20 towards line side.

Management Interface

• COM Port (RS232 Serial Port)

• USB Port

• 10/100BaseT Ethernet Port - Each multiplexer may be assigned an IP address and connected to

a LAN / IP network for remote access and management through the 10BaseT Ethernet Port for
out-of-band configuration, management and access

• Telnet

• SSH

• SNMP, V2

• Windows based GUI (Graphical User Interface) for easy configuration, management and access.

Power Supply

Input DC Voltage -48V DC (nominal)

Range of Input -36V to -72V DC

Output Voltage 5V filtered -48V (for terminal cards)

Full Load Current 4A at 48V DC

Input Voltage Reversal Protection Provided in the Card

Over Current Protection 6A at 48V DC

Short Circuit Protection Current limit – 6A. Recovers on removal of short

Efficiency at Full Load >91%

Ripple at Full Load <5mVrms

Spike at Full Load <50mV

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

22

Power Consumption

Power Consumption 50 to 200 watts depending upon configuration

EMI, EMC, Surge Withstand and other Compliances

EN 50081-2 EN 50082-2 IEC 60068-2-29

IEC 61000-4-6 (Conducted Immunity). IEC 60068-2-6 IEC 60068-2-2

IEC 60068-2-78 IEC 60068-2-1 IEC 60068-2-14

CISPR 22 / EN55022 Class B (Conducted Emission and Radiated Emission)

IS 9000 (Part II Sec. 1-4, Part III Sec. 1-5, Part IV, Part 14 Sec. 1-3)

IEC 60870-2-1 IEC 61000-4-5 IEC 61000-4-12

IEC 61000-4-3 (Radiated Immunity) IEC 61000-4-8 IEC 61000-4-16

IEC 61000-4-2 IEC 61000-4-10

IEC 61000-4-4 IEC 61000-4-11

Telcordia GR-1089 Surge and
Power Contact

• ESD, Voltage and Surge Withstand: Meets and exceeds IEC 61000-4-2, IEC 61000-4-4,
IEC 61000-4-5, Level 4 specifications.

• Immunity to Voltage Dips, Short Power Supply Interruptions and Voltage Variations meets and
exceeds IEC 61000-4-11, Level 1 specifications.

Other Regulatory Compliances:

• Meets CE requirements

• Complies with FCC Part 68 and EMC FCC Part 15

Environmental

Operating Temperature -200C to +600C

Maximum Operating Humidity 95% R.H., Non-Condensing

Maximum Operating Altitude Up to 3,000 meters above sea level

Operation Complies with ETS 300 019 Class 3.2

Storage Temperature -400C to +700C

Storage Complies with ETS 300 019 Class 1.2

Maximum Storage Humidity 98% R.H., Non-Condensing

Maximum Storage Altitude Up to 3,000 meters above sea level

Transportation Complies with ETS 300 019 Class 2.3

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

23

Dimensions and Appearance

Height 266 mm (19” 6U high)
Width 482 mm
Depth 270 mm
Weight 12 Kgs.
Chassis Color Matte Black - Powder coated

Applications

The VCL-MX Version 6 - E1 160Mbps Multiplexer can be configured in Linear and Bus architectures.
It can be used in the core of the network to provide high-speed backbone network.

The VCL-MX Version 6 - E1 160Mbps Multiplexer could provide the core for cellular or mobile networks
between Mobile Switching Centers with subtended.

VCL-MX Version 6 - E1 160Mbps Multiplexer could also be used to provide versatile cross-connect
functionality to connect telephone exchanges in VCL-MX Version 6 - E1 Multiplexer in dense metro
areas.

Telco Networks Providing Voice and Data Services

VCL-MX Version 6 - E1 160Mbps Multiplexer is an ideal platform to provide high-end data and voice
requirement of clients. VCL-MX Version 6 - E1 160Mbps Multiplexer can be installed at the regional and
gateway Points of Presence (POP) locations in order to cater to the ever-growing data requirements of
the customers while supporting legacy services at the same time.

The advantage that the VCL-MX Version 6 - E1 160Mbps Multiplexer provides the Telecom Service
provider is as follows:

• The VCL-MX Version 6 - E1 160Mbps Multiplexer enables network simplifications by collapsing
networks, nodes and services into a single multi service device. A smaller number of higher­density nodes and node types enable cost savings as a result of a smaller, more homogenous
network to manage.

• The flexible architecture of the VCL-MX Version 6 - E1 160Mbps Multiplexer series ensures that
the network is future proof, and the service provider has the flexibility of choosing a technology
he thinks useful at any time in the future with minimal investment.

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

24

Application Diagram

Application 1: Providing Voice and Data Services on Microwave Radio Links

VCL-MX E1, 160Mbps Voice & Data Multiplexers
Connecting over Digital Microwave Radio Links

Application 2: Providing Voice and Data Services on Optical Fiber

VCL-MX E1, 160Mbps Voice & Data Multiplexers

Connecting over Optical Fiber Links

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

25

Application 3: Transporting E & M Channels

VCL-MX E1, 160Mbps Voice & Data Multiplexer

Connecting at the Central Office/Switch - E & M Interfaces

Application 4

VCL-MX E1, 160Mbps Voice & Data Multiplexer

Using in a Subscriber Loop Point to Point or Drop/Insert Application

FXO/JNC 2 wire exchange loop interface card
FXS/SLC 2 wire subscriber loop interface card

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

26

Application 5: Providing Synchronous “n x 64” Kbps Data Interfaces

VCL-MX E1, 160Mbps Voice & Data Multiplexer

Providing Synchronous (V.11, X.21, V.35, V.36, RS422, RS530)

“n x 64” Kbps Data Interfaces

DCE- Remote DCE Configuration

Data Interface Card (Application A)

DCE- Remote DTE Configuration

Data Interface Card (Application B)

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

27

Application 6: Providing Voice and Synchronous “n x 64” Kbps Data Interfaces

VCL-MX E1, 160Mbps Voice & Data Multiplexer

Providing Voice and Synchronous (V.11, X.21, V.35, V.36, RS422, RS530)

“n x 64” Kbps Data Interfaces

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

28

Application 7: For providing Hybrid Voice and Data Services

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

29

Application 8:

VCL-MX E1, 160Mbps Voice & Data Multiplexer

used in Add-Drop, Tree and Star Configuration

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

30

Ordering Information

VCL-MX E1 Core System (Common Equipment)

S. No. Part # Product Description

1. VCL-MX-1500

E1 Control Card
Central processor, cross-connect and system control Card
may be used in a 1 + 1 redundant Configuration
Note: Please order 2 numbers for 1 + 1 redundancy

2. VCL-MX-1510

(-) 48V DC Input Power Supply Card
may be used in a 1 + 1 redundant Configuration
Note: Please order 2 numbers for 1 + 1 redundancy

3. VCL-OAM-2104-5.0

Management Card
[SNMP, Telnet (RJ45 Port) and Serial Port (USB and DB-9
COM Port)], OAM - Operations and Management Card for
connecting the multiplexer to be managed in a LAN - allows the
USER to assign a unique IP address to each multiplexer
connected in a LAN to be managed from a single point. Telnet,
SNMP (V2)

4. VCL-MX-1506

19" Shelf 6U High (Sub-Rack) fitted with 75Ω / 120Ω
DB25 (F) Connectorised Backplane
Max. Ten (10) traffic slots meant for tributary cards (line cards)

VCL-MX Version 6 [User Configurable Interfaces]

S. No. Part # Product Description

1. VCL-MX-1520-E1-5.0

8 E1 Interface Card
Full capability to cross connect at DS-0, 64Kbps time-slot level
as well as to inter-connect to voice and digital data services
between 80 incoming E1 Ports (i.e., 80 separate E1 Links,
2480 DS-0 – any to any time-slot cross-connect).
(For 8E1 Redundancy please order 2 Cards each Chassis)

2. VCL-MX-1525-16-5.0

16 Port VF, RT (FXS) Line Interface Card
64Kbps/Sec. VF Channels per Remote Terminal Line Card.
(Programmable Tx and Rx settings / VF range -30 dB to +3dB
in steps of 0.5dB).
(9 Cards / 144 Ports (Max) per Chassis)

3. VCL-MX-1525HTL-16-5.0

16 Port VF, Hot-Line (FXS-Ring-Down) Line Interface Card: ,
64Kbps/Sec. Hot-Line Channels per Card. (Programmable Tx
and Rx settings / VF range -30 dB to +3dB in steps of 0.5 dB)
(9 Cards / 144 Ports (Max) per Chassis)

4. VCL-MX-1530-16-5.0

16 Port VF, CO (FXO) Line Interface Card
64Kbps/Sec. VF Channels per Central Office Line Card.
(Programmable Tx and Rx settings / VF range -30 dB to +3dB in
steps of 0.5 dB)
(9 Cards / 144 Ports (Max) per Chassis)

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

31

5. VCL-MX-1535-08-5.0

8 Port, VF, E&M 2 Wire / 4 Wire Interface Card
64Kbps/Sec. (Programmable Tx and Rx settings / VF range -30
dB to +7dB in steps of 0.5 dB)
(09 cards / 72 Ports (Max) per Chassis)

6. VCL-MX-1540-15

Ring Generator Card (15 Watt)
Central Office Ring Generator (75 volts RMS).
[Supports up to 4 x 16 Port VF, FXS Cards]
(To be ordered with FXS card (s) - one card per Chassis)

7. VCL-MX-1540-30

Ring Generator Card (30 Watt)
Central Office Ring Generator Card (75 volts RMS).
[Supports up to 9 x 16 Port VF, FXS Cards]
(To be ordered with FXS card (s) - one card per Chassis)

8. VCL-MX-1526-15R

1+1 Redundant Ring Generator Card (15 Watt x 2)
Central Office Ring Generator (75 volts RMS).
[Supports up to 4 x 16 Port VF, FXS Cards]
(To be ordered with FXS card(s) - one Ringer card per Chassis)

9. VCL-MX-1526-30R

1+1 Redundant Ring Generator Card (30 Watt x 2)
Central Office Ring Generator (75 volts RMS).
[Supports up to 9 x 16 Port VF, FXS Cards]
(To be ordered with FXS card(s) - one Ringer card per Chassis)

10. VCL-MX-1545-04-48

4 Port, 64Kbps DCE [V.35,V.36, X.21, RS530, V.24, V.11, V.28]
Synchronous OR [RS232 or RS485] Asynchronous Data
Interface Card with Sub Rate Multiplexing
(9 Cards / 36 Ports (Max) per Chassis)

11. VCL-MX-1547-16-48

16 Port, Relay I/O Interface Card (RIO)
[Extend either Dry Relay Contacts (Relay Normally-Open or
Relay Normally-Close) or operate switches remotely (using Dry
Relay Contacts rated 2A @ 30Volts DC) between any two
Multiplexers using a 64 Kbps time-slot]
(9 Cards / 72 Ports (Max) per Chassis)

12. VCL-MX-1550-04-5.0

4 Port: 2B+D, Basic Rate ISDN Interface Card, 2B1Q Line
Coding, U Interface (4 Ports BRI ISDN Interfaces per card).
09 cards / 36 ports (Max) per Chassis.

13. VCL-MX-1551-5.0

8 E1 Plus 4 Ethernet [100Mbps, Electrical RJ45 (F)] over Fiber
Optical Transport Interface Card [2 x SFP based / without SFPs]
(without SFPs - SFPs must be ordered separately)
(9 Cards / 72 Ports (Max) per Chassis)

14. VCL-MX-1558-04-48

4 Port, “n x 64” High Speed 64 Kbps to 1920 Kbps (User
Configurable) DCE/DTE Synchronous Universal Data Interface
Card [DCE/DTE (User programmable for DTE/DCE mode)]
[V.35, V.36, X.21, V.11, RS442, RS530]
(9 Cards / 36 Ports (Max) per Chassis)

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

32

15. VCL-MX-1558-04-48AHS

4 Port, High Speed RS232, RS485, V.24 (V.24/V.28 Line
Drivers) 50bps to 115.2Kbps, DTE / DCE Asynchronous Data
Interface Card (9 Cards / 72 Ports (Max) per Chassis)

16. VCL-MX-1559-08-5.0

8 Port, RS232 (V.24/V.28 Line Drivers) 50bps to 19.2Kbps DCE
Asynchronous Data Interface Card
(9 Cards / 72 Ports (Max) per Chassis)

17. VCL-MX-1560-08-5.0

8 Port G.703 @ 64Kbps, Synchronous Codirectional Data
Interface Card
(9 Cards / 72 Ports (Max) per Chassis)

18. VCL-MX-1561-02-5.0

Dual Link O/E Ethernet {Electrical [RJ45 (F)] + Optical [SFP
based / without SFP]} Card [for Point-to-Multi Point applications]
User configurable from 64Kbps to 2Mbps. User Selectable Data
Transfer Rate
(Max. bandwidth per card 2Mbps.)
(9 Cards / 36 Ports (Max) per Chassis)

19. VCL-MX-1587-16

16 Port Magneto (GEN-GEN) Line Interface Card.
(9 Cards / 144 Ports (Max) per Chassis)

20. VCL-MX-1595-04-5.0

4 Port Ethernet [10/100BaseT, Electrical] Card [for Point-to-Point
applications]
User configurable from 64Kbps to 2Mbps. User Selectable Data
Transfer Rate (Max. bandwidth per card 2Mbps.)
(9 Cards / 36 Ports (Max) per Chassis)

VCL-MX [Cables and Accessories]

S. No. Part # Product Description

1.

VCL-1505-TER­DB37F-RJ45F-16PP

16xE1/T1, DB37 [2 x DB37F] to RJ45 [16 x RJ45F] Termination Panel
19" Metal case 1U High Rack Mount Version with Hardware Set
[RJ45 cables not included]

2.

VCL-1505-TER­DB37F-RJ45F-32PP

32xE1/T1, DB37 [4 x DB37F] to RJ45 [32 x RJ45F] Termination Panel
19" Metal case 1U High Rack Mount Version with Hardware Set
[RJ45 cables not included]

3.

VCL-1505-TER­DB37F-RJ45F-48PP

48xE1/T1, DB37 [6 x DB37F] to RJ45 [48 x RJ45F] Termination Panel
19" Metal case 1U High Rack Mount Version with Hardware Set
[RJ45 cables not included]

4.

VCL-1514_1513­TER-DB37F-BNCF­16PP

16xE1, DB37 [2 x DB37F] to BNC [32 x BNCF] Termination Panel
19" Metal case 1U High Rack Mount Version with Hardware Set
[BNC cables not included]

5.

VCL-HRNS 1264­4E1O

E1/T1 4 Port Connectorized Cable [DB25M-Open]
[1 cable each 4 Port E1/T1 card]

6.

VCL-HRNS 1268­8E1Y37M

E1/T1 8 Port Y Connectorized Cable [2xDB25M-DB37M]
[1 cable each 8 Port VCL-1505-TER-DB37F-RJ45F]

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

33

7.

VCL-HRNS 1247­03M

75 Ohms Connectorized Cable (BNCM-BNCM, 3m)

8.

VCL-HRNS 1247­05M

75 Ohms Connectorized Cable [BNCM-BNCM, 5 meter]

9.

VCL-HRNS 1247­10M

75 Ohms Connectorized Cable [BNCM-BNCM, 10 meter]

10.

VCL-HRNS
1264FXO

FXS/FXO/HTL 8 Port Connectorized Cable [DB25M-Open]
[1 cable each 8 Port FXS/FXO card]

11.

VCL-HRNS
1264ENO

E&M 2 Port Connectorized Cable [DB25M-Open]
[1 cable each 2 Port E&M card]

12.

VCL-HRNS
1264RS2V2ORev1

RS232/V.28 1 Port 64Kbps Connectorized Cable [DB25M-Open]
[1 cable each 1 Port RS232/V.28 64Kbps card]

13.

VCL-HRNS
1264IOOD

RIO 8 Port Drive Connectorized Cable [DB25M-Open]
[1 cable each 8 Port RIO card]

14.

VCL-HRNS
1264IOOS

RIO 8 Port Sense Connectorized Cable [DB25M-Open]
[1 cable each 8 Port RIO card]

15.

VCL-HRNS
1073V35F

V.35 1 Port 64Kbps Connectorized Cable [DB25M-Winchester F]
[1 cable each 1 Port V.35 64Kbps card] OR

16.

VCL-HRNS
1075V35M

V.35 1 Port 64Kbps Connectorized Cable [DB25M-Winchester M]
[1 cable each 1 Port V.35 64Kbps card]

17.

VCL-HRNS
1083V36F

V.36 1 Port Connectorized Cable [DB25M-DB37F]
[1 cable each 1 Port V.36 64Kbps card] OR

18.

VCL-HRNS
1083V36M

V.36 1 Port Connectorized Cable [DB25M-DB37M]
[1 cable each 1 Port V.36 64Kbps card]

19.

VCL-HRNS
1084X21F

X.21 1 Port Connectorized Cable [DB25M-DB25F]
[1 cable each 1 Port X.21 64Kbps card] OR

20.

VCL-HRNS
1084X21M

X.21 1 Port Connectorized Cable [DB25M-DB25M]
[1 cable each 1 Port X.21 64Kbps card]

21.

VCL-HRNS
1082RS5V1O

RS530/V.11 1 Port Connectorized Cable [DB25M-Open]
[1 cable each 1 Port RS530/V.11 64Kbps card]

22.

VCL-HRNS
1082RS5V1F

RS530/V.11 1 Port Connectorized Cable [DB25M-DB25F]
[1 cable each 1 Port RS530/V.11 64Kbps card]

23.

VCL-HRNS
1264RSO

RS232 2 Port Connectorized Cable [DB25M-Open]
[1 cable each 2 Port RS232 card] OR

24.

VCL-HRNS
1264RS9F

RS232 2 Port Connectorized Cable [DB25M-2xDB9F]
[1 cable each 2 Port RS232 card] OR

25.

VCL-HRNS
1264RS9M

RS232 2 Port Connectorized Cable [DB25M-2xDB9M]
[1 cable each 2 Port RS232 card]

26.

VCL-HRNS
1264G7O

G.703 4 Port Connectorized Cable [DB25M-Open]
[1 cable each 4 Port G.703 card]

27. UMIKitMXV6

System Core Cables, Blank Space Blocking Plates, Installation
Accessories, Documentation, System User Manual / Disk, etc [Set]

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

34

VCL-MX Version 6, TeleProtection (User Configurable Interfaces)

S. No. Part # Product Description

1 VCL-MX-1552-SM-FC

4 Port, Integrated IEEE C37.94 Optical Interface, Duplex FC,
20KM, 1310nm, Single-Mode (SM) Teleprotection Interface Card
used to connect upto 4, VCL-TP Teleprotection Terminals.
(9 Cards / 36 Ports (Max) per Chassis)
NOTE: This interface card is to be used a plug-in card option
with the VCL-MX, Version 6 Multiplexers.

2 VCL-MX-1552-SM-ST

4 Port, Integrated IEEE C37.94 Optical Interface, Duplex ST,
20KM, 1310nm, Single-Mode (SM) Teleprotection Interface Card
used to connect upto 4, VCL-TP Teleprotection Terminals.
(9 Cards / 36 Ports (Max) per Chassis)
NOTE: This interface card is to be used a plug-in card option
with the VCL-MX, Version 6 Multiplexers.

3

VCL-MX-1552-0850MM­FC

4 Port, Integrated IEEE C37.94 Optical Interface, Duplex FC,

0.5KM, 850nm, Multi-Mode (MM) Teleprotection Interface Card
used to connect upto 4, VCL-TP Teleprotection Terminals.
(9 Cards / 36 Ports (Max) per Chassis)
NOTE: This interface card is to be used a plug-in card option
with the VCL-MX, Version 6 Multiplexers.

4

VCL-MX-1552-0850MM­ST

4 Port, Integrated IEEE C37.94 Optical Interface, Duplex ST,

0.5KM, 850nm, Multi-Mode (MM) Teleprotection Interface Card
used to connect upto 4, VCL-TP Teleprotection Terminals.
(9 Cards / 36 Ports (Max) per Chassis)
NOTE: This interface card is to be used a plug-in card option
with the VCL-MX, Version 6 Multiplexers.

5 VCL-MX-1552-MM-FC

4 Port, Integrated IEEE C37.94 Optical Interface, Duplex FC,
2KM, 1310nm, Multi-Mode (MM) Teleprotection Interface Card
used to connect upto 4, VCL-TP Teleprotection Terminals.
(9 Cards / 36 Ports (Max) per Chassis)
NOTE: This interface card is to be used a plug-in card option
with the VCL-MX, Version 6 Multiplexers.

6 VCL-MX-1552-MM-ST

4 Port, Integrated IEEE C37.94 Optical Interface, Duplex ST,
2KM, 1310nm, Multi-Mode (MM) Teleprotection Interface Card
used to connect upto 4, VCL-TP Teleprotection Terminals.
(9 Cards / 36 Ports (Max) per Chassis)
NOTE: This interface card is to be used a plug-in card option
with the VCL-MX, Version 6 Multiplexers.

7 VCL-MX-1554-04

4 Port, Integrated IEEE C37.94 Optical, SFP based
Teleprotection Interface Card, used to connect upto 4,
VCL-TP Teleprotection Terminals.
(without SFPs - SFPs must be ordered separately)
(9 Cards / 36 Ports (Max) per Chassis)
NOTE: This interface card is to be used a plug-in card option
with the VCL-MX, Version 6 Multiplexers.

VCL-MX Version 6 - E1 160Mbps Voice & Data Multiplexer

Orion Telecom Networks Inc. – 2013-2014

35

Notes:

Technical specifications are subjects to changes without notice.
Revision 4.8 – June 10, 2014.

Orion Telecom Networks Inc.

16810, Avenue of Fountains,

Suite # 108, Fountain Hills,

AZ 85268 USA

PH: ([phone]

FAX: [phone]

E-mail: [e-mail]

Website: http://www.oriontelecom.com