Page 1
IMPORTANT:
Introduction
Service Schematics
nokia
Exploded view and component disposal
n610/n616
This document is intended for use by authorized NOKIA service centers only.
“Service Schematics” was created with focus on customer care.
The purpose of this document is to provide further technical repair information for
NOKIA mobile phones on Level 3/4 service activities.
It contains additional information such as e.g. “Component finder”,
“Frequency band table” or “Antenna switch table”.
The “Signal overview” page gives a good and fast overview about the most
important signals and voltages on board.
Saving process time and improving the repair quality is the aim of this document.
It is to be used additionally to the service manual and other training
or service information such as Service Bulletins.
All measurements were made using following equipment:
Nokia repair SW : Phoenix Service Software 2004.32.6.62
Oscilloscope : Fluke PM 3380A/B
Spectrum Analyzer : Advantest R3162 with an analog probe
RF-Generator / GSM Tester : Rhode & Schwarz CMU 200
Multimeter : Fluke 73 Series II
TFE-4/RV-1
Table of Contents PageTable of Contents Page
While every endeavour has been made to ensure the accuracy of this document, some
errors may exist. If the reader finds any errors, NOKIA should be notified in writing.
Please send E-Mail to: training.sace@nokia.comtraining.sace@nokia.com
Copyright © NOKIA
This material, including documentation and any related computer programs is protected
by copyright, controlled by NOKIA. All rights are reserved. Copying, including reproducing,
modifying, storing, adapting or translating any or all of this material requires the prior
written consent of NOKIA. This material also contains confidential information, which may
not be disclosed to others without the prior written consent of NOKIA.
Customer Care / Service & Support Readiness / Competence Transfer Team
Customer Care / Service & Support Readiness / Competence Transfer Team
Copyright © 2005 NOKIA Only for training and service purposes
Copyright © 2005 NOKIA Only for training and service purposes
Version: 2.0 Version: 2.0
FrontpageFrontpage
DCT-4 common basebandDCT-4 common baseband
System connectorSystem connector
UEME, SIMUEME, SIM
UPP, Combo memoryUPP, Combo memory
Bluetooth, Power connectorsBluetooth, Power connectors
RF partRF part
Signal overviewSignal overview
Component finder TF4_05Component finder TF4_05
Car Radio mute, Display, Handset Car Radio mute, Display, Handset
Power, MicrophonePower, Microphone
PowerPower
RS232 connection RS232 connection
Component finder TF5_06Component finder TF5_06
18.01.200518.01.2005
N610/N616 TFE-4/RV-1N610/N616 TFE-4/RV-1
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10
10
1111
1212
1313
1414
Board version: TF5_06 Board version: TF5_06
FrontpageFrontpage
Page 1(14)Page 1(14)
Page 2
SYS_CONN
Page 3
PWRONX
HEADINT
RFAUX(1:0)
XMIC(2:0)
XEAR(3:0)
SLOWAD(6:0)
ACCDIF(2:0)
CHARGER(4:0)
IACCDIF(5:0)
GENIO(52:0)
KEY_UI
Page 6
Page 3
HEADINT
XMIC(2:0)
XEAR(3:0)
LCDUI(2:0)
KEYB(10:0)
GENIO(52:0)
PWRONX
SLOWAD(6:0)
PUSL(3:0)
AUDIO
GENIO(52:0)
SLOWAD(6:0)
XAUDIO(17:0)
AUDUEMCTRL(5:0)
PUSL(3:0)
PWRONX
XAUDIO(17:0)
SLOWAD(6:0)
ACCDIF(2:0)
CHARGER(4:0)
POWER
dual_4.0
Page 4
RFCONV(9:0)
RFAUXCONV(2:0)
GENIO(52:0)
RFCONVCTRL(2:0)
RFCONVDA(5:0)
AUDIODATA(3:0)
AUDUEMCTRL(5:0)
IACCDIF(5:0)
PUSL(3:0)
SIMIF(3:0)
LCDUI(2:0)
KEYB(10:0)
GENIO(52:0)
RFCONVCTRL(2:0)
RFCONVDA(5:0)
AUDIODATA(3:0)
AUDUEMCTRL(5:0)
IACCDIF(5:0)
PUSL(3:0)
PUSL(3:0)
UPP
basic8m
Page 5
LPRF
AUDUEMCTRL(5:0)
GENIO(52:0)LPRFCLK
RFCLK
RFCLKGND
RFICCNTRL(2:0)
MEMADDA0(15:0)
MEMAD(24:16)
MEMCONT(15:0)
RF_BB
SLOWAD(6:0)
RFCONV(9:0) RFCONV_O(9:0)
RFAUXCONV(2:0)
LPRFCLK
RFCLK
RFCLKGND
RFAUX(1:0)
GENIO(52:0)
PUSL(3:0)
RFICCNTRL(2:0)
MEMADDA0(15:0)
MEMAD(24:16)
MEMCONT(15:0)
GENIO(52:0)
RFAUXCONV_O(2:0)
GENIO_O(52:0)
RFICCNTRL_O(2:0)
RFCLK_I
LPRFCLK_I
MEMORY
amd64mbit
Page 6
0
1
2
3
4
5
6
7
8
9
5
6
RXIINP
RXIINN
RXQINP
RXQINN
TXIOUTP
TXIOUTN
TXQOUTP
TXQOUTN
VREF1
TXP
RESET
0
RFBUSCLK
1
RFBUSDA
2
RFBUSEN1
RF
Schematics
Page 7
RXIINP
RXIINN
RXQINP
RXQINN
VREF1
RFBUSEN1
RFBUSCLK
RFBUSDA
RESET
AFC
2
TXC
0
TXC
TXP
TXIOUTP
TXIOUTN
TXQOUTP
TXQOUTN
RFCLK_I
LPRFCLK_I
SIMIF(3:0)
Customer Care / Service & Support Readiness / Competence Transfer Team
Customer Care / Service & Support Readiness / Competence Transfer Team
Copyright © 2005 NOKIA Only for training and service purposes
Copyright © 2005 NOKIA Only for training and service purposes
Version: 2.0 Version: 2.0
18.01.200518.01.2005
SIM
Page 4
SIMIF(3:0)
GENIO(52:0)
N610/N616 TFE-4/RV-1N610/N616 TFE-4/RV-1
Board version: TF5_06 Board version: TF5_06
DCT-4 common basebandDCT-4 common baseband
Page 2(14)Page 2(14)
Page 3
UEME
UEM
Page 5
Page 4
XAUDIO(17:0)
"HF"
1
"HFCM"
2
"MIC3P"
8
"MIC3N"
9
"MIC2P"
4
"MIC2N"
5
"HEADINT"
0
R165
47k
R154
10k
R182
47R
R182
47R
C165
100n
C165
100n
C164
100n
C164
100n
C166
2x33n
GND
GND
C151
27p
R166
10k
GND
GND
C151
27p
C166
2x33n
C154
100n
C154
100n
R167
1k0
R167
1k0
GND
C153
27p
GND
C167
R151
1k0
C159
GND
C156
10n
27p
C163
27p
R151
1k0
GND
R152
1k0
R152
1k0
C156
10n
C153
27p
GND
C172
1n0
1n0
GND
L150
EXC24CB102U
1
23
EXC24CB102U
1
23
L168
"HANDSFREEMICP"
4
"HANDSFREEMICN"
"HANDSETMICP"
4
"HANDSETMICN"
GND
C150
27p
GND
C150
27p
UEM
Page 4
Customer Care / Service & Support Readiness / Competence Transfer Team
Customer Care / Service & Support Readiness / Competence Transfer Team
Copyright © 2005 NOKIA Only for training and service purposes
Copyright © 2005 NOKIA Only for training and service purposes
PWRONX
X100/System connecror
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
GND
GND
R103
14V/50V
GND
B2B_XEARP
B2B_XEARN
GND
B2B_HDMICP
B2B_HDMICN
GND
B2B_HFMICP
B2B_HFMICN
GND
HF_MUTE
HD_DETECT
HD_MUTE
GND
UI_POWERON
POWERONX
POWEROFFX
IGNS
CRM
VWAKE
BTEMP
BSI
VFLASH
FBUSTX
FBUSRX
GND
MBUS
GND
2
R100
/2 47R
C104
27p
GND
1
R100
/2 47R
VFLASH
Version: 2.0 Version: 2.0
V101
RSA6.1EN
GND
V100
RSA6.1EN
GND
18.01.200518.01.2005
J105
BSI
BTEMP
C102
27p
GND
V103
C110
RB521S-30TE61
1n0
GND
V102
RSA6.1EN
GND
R112
47R
R104
47R
R101
47R
C107
27p
C106
27p
C105
27p
GND
GND
GND
R112
47R
R104
47R
R101
47R
N610/N616 TFE-4/RV-1N610/N616 TFE-4/RV-1
0
1
GND
R114
27k
R115
47k
~3V
VBACK
R102
220k
GND
Board version: TF5_06 Board version: TF5_06
R105
/2 47R
2
R106
2
/2 47R
R107
2
/2 47R
R108
2
/2 47R
R109
2
/2 47R
R110
2
/2 47R
R111
/2 47R
2
"FBUSTXO"
"FBUSRXO"
"MBUS"
1
C118
27p
GND
1
C119
27p
GND
1
C120
27p
GND
1
C121
27p
GND
1
C122
27p
GND
1
C109
27p
GND
1
C108
27p
GND
1
2
0
System connectorSystem connector
R105
/2 47R
R106
/2 47R
R107
/2 47R
R108
/2 47R
R109
/2 47R
R110
/2 47R
R111
/2 47R
"HF_MUTE <-"
"HD_MUTE <-"
"UI_POWER_ON <-"
"POWEROFFX <-"
"IGNS ->"
"CRM <-"
SLOWAD(6:0)
26
14
8
9
10
12
GENIO(52:0)
ACCDIF(2:0)
UEM
Page 4
UPP
Page 5
UEM
Page 4
Page 3(14)Page 3(14)
Page 4
~4V
VBATIN
Audio
Page 3
XAUDIO(17:0)
SLOWAD(6:0)
UPP
Page 5
CHARGER(4:0)
B200/32.768kHz
B200
32.768kHz
C209
5p6
GND
AUDIODATA(3:0)
BT
AUDUEMCTRL(5:0)
RFCONVCTRL(2:0)
C210
5p6
GENIO(52:0)
IACCDIF(5:0)
RFCONVDA(5:0)
2.8V
VFLASH1
VANA
2.8V
0
1
2
3
4
5
6
GND
PUSL(3:0)
1
VBACK
R202
4x100k
~3V
2.8V
VFLASH1
R305
100k
GND
~3V
VBACK
C239
100n
220k
0
1
4
3
2
1u0
R314
C220
VBAT
R200
AGND2
GND
GND
GND
GND
GND
IPA1
IPA2
GND
GND
0R22
GND
GND
C291
1u0
C236
100n
C237
100n
C282
1u0
AGND2
C238
100n
C299
1u0
C201
1u0
GND
GND
VANA
2.8V
J305
2
C284
1u0
GND
VANA
2.8V
GND
VANA
GND
2.8V
C200
100n
C290
1u0
GND
1u0 1u0
GND
GND
D200/UEM
UEM_V4.4_WDOGS_ENABLED
M9
VCHARIN1
P9
VCHARIN2
L6
VCHARINKL9VCHAROUTK
D5
TESTMODE
P8
VBATBB1
N9
VBATBB2
VBATBB3
VBATBB4
A1
VBATBB5
P7
PWRONX
P1
OSCIN
P2
OSCOUT
P3
VBACK
N3
VRTC
M4
OSCCAP
K4
VDAAUD1
H2
MICBCAP
H1
MICB1
J2
J1
MIC1N
H3
MICB2
J3
MIC2P
J4
MIC2N
K2
MIC3P
K1
MIC3N
K3
MICSUB
M3
VSAAUD1
N7
HOOKINT
C4
VDD28
A9
VDD18
PURX
SLEEPX
D9
SLEEPCLK
B6
EARDATA
A6
MICDATA
UEMINT
A8
CBUSCLK
B7
CBUSDA
C8
CBUSENX
B5
SIMIODAI
A5
SIMCLKI
C5
SIMIOCTRL
B8
IRTX
B9
IRRX
C6
MBUSTX
D6
MBUSRX
A7
FBUSTXI
C7
FBUSRXI
DBUSCLK
DBUSDA
DBUSENX
RFCONVCLK
RXID
RXQD
TXID
TXQD
AUXD
C9
VSS
C2
BSI
D3
BTEMP
D1
KEYB1
D2
KEYB2
C1
LS
E3
VCXOTEMP
D4
PATEMP
VBATVR1
VBATVR2
J14
VBATVR3
VBATVR4
VBATVR5
VBATVR6
VBATVR7
F6
GNDTH1
F7
GNDTH2
F8
GNDTH3
F9
GNDTH4
G6
GNDTH5
G7
GNDTH6
G8
GNDTH7
G9
GNDTH8
H6
GNDTH9
H7
GNDTH10
H8
GNDTH11
H9
GNDTH12
VCHAROUT1
VCHAROUT2
VBATREGS
GNDREGS
PWMO
PWM1C
CHDISX
VANA
VFLASH1
VFLASH2
VCORE
VIO
GNDFLASH1
VDAAUD2
EARP
EARN
XEAR
HEADINT
HFCM
VSAAUD2
VBATDRIV
BUZZO
VIBRA
CALLED1
DLIGHT
KLIGHT
CALLED2
VSADRIV1
VSADRIV2
VSIM
SIMIODAO
SIMCLKO
SIMRST
SIMCARDDET
VSIMGND
IRLEDC
IRRXN
MBUS
FBUSTXO
FBUSRXO
VDACONVRX
RXIINP
RXIINN
RXQINP
RXQINN
VSACONVRX
VDACONVTX
TXIOUTP
TXIOUTN
TXQOUTP
TXQOUTN
VSACONVTX
AUXOUT
TXPWRDET
AFCOUT
VREFRFO1
VREFRFO2
VREF25BB
VREF25RF
VREF278
CCP
CCN
VPUMP
GNDVR1
VR1A
VR1B
VR2
VR3
VR4
VR5
VR6
VR7
IPA1
IPA2
ISET
VBG
UEMRSTX
SMPSCLK
GNDTH13
GNDTH14
GNDTH15
GNDTH16
N10
P10
M10
L10
GND
M7
P4
M5
N8
M8
P11
M13
B1
L5
GND
N2
M2
M1
N1
N6
L1
HFMIC1P
L2
L3
F2
G2
G3
E1
F1
F3
E2
F4
G1
C3
B2
B3
A2
P6
A3
N4
L4
M6
N5
P5
B13
C13
B14
D12
C14
C12
F11
E11
D14
E14
E12
F12
E13
E4
D13
H13
H14
G14
G13
H12
P12
M11
N13
N12
P14
M12
L12
J12
K14
J11
L13
K12
F14
F13
G12
R422
27k
J13
A4
B4
J6
J7
J8
J9
GND
GNDGND
C241
VBATT1VBATT1
VBATT2VBATT2
PWRONX
AGND1
AGND1
GND
GND
C274
1u0
302931
GND
N11
N14
AGND2
C10
B11
210
A10
D10
A11
B10
A13
C11
A14
A12
B12
D11
P13
M14
K11
K13
L11
L14
VBATT3VBATT3
VBATT6VBATT6
X100
Page 3
C276C277
1u0
3456
C242
1n0
1n0
GND
R240
4k7
GND
C182
100n
C275
1u0
GND
VBATT4VBATT4
VBATT5VBATT5
VBATT1VBATT1
C182
100n
R220
4k7
600R/100MHz
L260
VANA
GND
2.8V
543210
0
1
10
AGND2
2
C260
1u0
C281
1u0
210
3
543210
GND
8
9
VIO
1.8V
C218
100n
GND
C240
10n
10n
~4V
C202
10n
GND
VCORE_LIN
C208
1u0
GND
VBAT
~4V
C390
100n
GND
C289
1u0 1u0
C296
1u0
GND
C207
VIO
2.8V
1u0
C283
1u0
GND
0
1
2
3
GND
C297C298
1u0
1.5V
0
1
2
3
4
5
6
7
C295 C294
GND
0
1
2
C293
GND
"SIMRST"
2
"SIMCLK"
1
"SIMIODAO"
0
"SIMCARDDET"
3
C287
GND
VFLASH1
2.8V
C279
1u0
0
1
2
C292
1u0
GND
1u01u0
VFLASH2
1u0
GND
9
8
C288
GND GND GND GND
1u01u0
GND
GND
GND
VR1A
VR2
VR3
VR4
VR5
VR6
VR7
EMIF03-SIM01
VANA
2.8V
C278C280
1u0
R388
R1
R2
R3
ACCDIF(2:0)
RFCONV(9:0)
RFAUXCONV(2:0)
C285C286
1u0
4.75V
2.8V
Audio
Page 3
Mjoelner
Page 7
Mjoelner
Page 7
R390
100k
VFLASH1
0
1
2
3V
X387/SIM
"VSIM"
1
"RST"
2
3
"CLK"
C707_10M006_527_2
TP390
2.8V
100R
R386
9
8
7
6
"VSIM"
5
R387
14V/50V
"I/O"
"GND"
GND
GND
GND
Customer Care / Service & Support Readiness / Competence Transfer Team
Customer Care / Service & Support Readiness / Competence Transfer Team
Copyright © 2005 NOKIA Only for training and service purposes
Copyright © 2005 NOKIA Only for training and service purposes
Version: 2.0 Version: 2.0
18.01.200518.01.2005
N610/N616 TFE-4/RV-1N610/N616 TFE-4/RV-1
Board version: TF5_06 Board version: TF5_06
UEME, SIMUEME, SIM
Page 4(14)Page 4(14)
Page 5
E451
E452
E453
E454
E455
E456
E457
E458
R485
GND
10k
1.8V
VIO
R487
10k
D450/FLASH
AM29N643GT70MVAI
FLASHM 4Mx16
4194303
1
NC
2
NC
3
NC
4
NC
5
NC
6
NC
7
NC
8
NC
ADDRESS/DATA I/O
B1,D8= VIO
1.8V
0
VIO
A
CLK
_AVD
_CE
_RESET
_OE
_WE
_WP
RDY
VIOA5=
VPPA7=
GNDA3,C1,B10,D3=
PS
NC
R484
10k
16
21
1.8V
VIO
R486
10k
R488
10k
B2
A9
B8
A8
B3
A2
A10
C10
R483
10k
A4
B4
B9
B6
A6
B7
A1
B5
D10
D9
C7
C6
D5
D4
C3
C2
C9
C8
D7
D6
C5
C4
D2
D1
GND
4
2
X480
1
"JTMS"
2
"JTRst"
3
4
5
6
7
8
9
10
11
12
13
14
"JTDI"
"JTDO"
"JTClk_ret"
"JTClk"
"EMU0"
"EMU1"
DSP_MCUTEST(2:0)
GENIO(52:0)
3
1
2
4
0
5
6
GND
0
1
2
3
4
5
6
0
1
2
0
1
2
3
A11
B11
A12
A13
B12
1.5V
VCORE
C402
23
16
17
18
19
20
21
22
23
6
5
7
9
1
0
8
3
4
0
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
R450
4k7
C454
100n
VPP
PRODTP6
J700
GND
GNDGND
C450 C451
10n
GND
0
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
C401C400
100n
10n
10
C403
10n
10n
GND
GND
1.8V
VIO
C404
10n
100n
GND
GND
9 0
0
1
2
3
4
5
6
7
8
J416
J419
J417
J420
C405
GND
10n
GND
M7
M9
M10
M11
K11
L12
K13
J12
H11
L8
L9
K8
K12
H12
K6
J418
23
24
K10
A4
C1
E1
D5
D4
F4
K1
J4
J1
N8
J13
A9
H4
K7
H10
D8
K9
G4
D7
G10
N10
H1
A6
F13
N5
N7
M8
L10
L11
M12
N13
L13
J11
N9
L7
L6
M6
N11
M13
N12
N6
H13
M1
J10
C4
A2
A3
A1
C5
C3
B3
B2
B4
B5
TESTMODE
JTCLK
JTRST
JTDI
JTMS
JTDO
EMU0
EMU1
GENTEST0
GENTEST1
GENTEST2
GENIO0
GENIO1
GENIO2
GENIO3
VDDDSP1
VDDDSP2
VDDDSP3
VSSDSP1
VSSDSP2
VSSDSP3
VDDMCU
VSSMCU
VDDCORE1
VDDCORE2
VDDPDRAM1
VDDPDRAM2
VSSCORE1
VSSCORE2
VSSPDRAM1
VSSPDRAM2
VSSIO1
VSSIO2
VSSIO3
VSSIO4
VDDIO1
VDDIO2
VDDIO3
VDDIO4
VDDA
0
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
FLSRSTX
EXTWRX
EXTRDX
FLS2CSX
FLSBAAX
FLSPS
FLSAVDX
FLSCLK
FLSCSX
FLSRDY
GENIO23
GENIO24
D400/UPP
UPP8M_V1.1_UBGA144
SLEEPX
SLEEPCLK
EARDATA
NC
MICDATA
UEMINT
CBUSCLK
CBUSDA
CBUSENX
GENIO31
GENIO30
GENIO29
GENIO26
MBUSTX
MBUSRX
FBUSTX
FBUSRX
DBUSCLK
DBUSDA
DBUSEN1X
RFCONVCLK
GENIO18
GENIO16
GENIO17
GENIO14
GENIO15
AUXDA
GENIO13
GENIO5
GENIO6
GENIO7
GENIO8
GENIO9
GENIO10
GENIO11
GENIO12
RFBUSCLK
RFBUSDA
RFBUSEN1X
GENIO25
RFCLK
GENIO28
GENIO4
LCDCAMCLK
LCDCAMTXDA
GENIO27
LCDCSX
GENIO19
GENIO20
GENIO21
GENIO22
PURX
IRTX
IRRX
RXID
RXQD
TXID
TXQD
VSSA
P00
P01
P02
P03
P04
P10
P11
P12
P13
P14
P15
D11
D12
D13
G11
G13
G12
C11
C13
C10
D10
E12
E10
E11
F10
F11
E13
F12
B13
C12
A10
B10
K2
L1
H3
E2
F2
J2
G1
G2
F3
D1
C2
D2
B1
H2
G3
E3
D3
F1
E4
K3
L3
J3
N3
K4
L4
M4
N4
K5
M2
N1
N2
M3
L2
M5
L5
D6
A7
C6
B6
A5
C7
D9
A8
B8
C8
B9
C9
B7
J402
GND
J404
J403
J405 J406
J409
J413
J421
J410
J424
J407
0
1
7
2
65
0
R420
100R
1
0
1
2
3
31
30
29
26
18
16
17
14
15
13
5
6
7
8
9
10
11
12
0
1
2
C420
12p
25
28
4
27
19
20
21
22
0
1
2
KEYB(10:0)
3
J408
J412
J411
9
8
J414
J422
1
2
3
4
5
6
7
8
9
10
J415
J423
0
1
2
3
4
5
0
1
2
0
1
2
3
4
5
R424
220k
GND
PUSL(3:0)
AUDIODATA(3:0)
AUDUEMCTRL(5:0)
IACCDIF(5:0)
RFCONVCTRL(2:0)
RFCONVDA(5:0)
RFICCNTRL(2:0)
RFCLK
LCDUI(2:0)
UEM
Page 4
UEM
BT
UEM
UEM
UEM
UEM
Mjoelner
Page 7
13 Mhz (from Mjoelner)
Page 7
Customer Care / Service & Support Readiness / Competence Transfer Team
Customer Care / Service & Support Readiness / Competence Transfer Team
Copyright © 2005 NOKIA Only for training and service purposes
Copyright © 2005 NOKIA Only for training and service purposes
Version: 2.0 Version: 2.0
18.01.200518.01.2005
N610/N616 TFE-4/RV-1N610/N616 TFE-4/RV-1
Board version: TF5_06 Board version: TF5_06
UPP, Combo memoryUPP, Combo memory
Page 5(14)Page 5(14)
Page 6
2.8V
VFLASH1
UPP
Page 5
UPP
Page 5
KEYB(10:0)
GENIO(52:0)
~4V
VBAT
L132
L133
600R/100MHz
C149
1u0
GND
C148
1u0
GND
GND
600R/100MHz
V130/Bluetooth
6
VREG
46
53
52
54
1
2
3
4
7
8
9
10
GND
11
13
14
15
19
24
29
33
39
43
47
51
56
16
17
32
41
45
"RI"
3
"DTR"
6
"CTS"
0
"RTS"
7
"DSR"
1
"DCD"
2
"TXD = GenIOUSARTRX"
1
"RXD = GenIOUSARTTX"
0
LRB2_0630271
VCCXTAL
VCC
OSCON
VCC
RESETX
VCC
SLEEPX
GND
VBBEN
GND
EN26MHZ
GND
SLPCLK
GND
GND5SYSCLK
GND
GND
GPP0
GND
GPP1
GND
GPP4
GND
GPP6
GND
GPP7
GND
GPP9
GND
GPP10
GND
GPP11
GND
CENX
GND
TRST
GND
GND
GND
GND
GND
GND
GND
VAPPL
VPP
VDD
TMS
TDO
TCK
WRX
ANT
TDI
J145
Ant
12
GND
31
44
48
49
18
26
50
38
37
40
28
27
30
36
35
34
20
21
22
23
25
42
55
NC
J144
J137
J138
J139
J140
J141
J143
J135
1.8V
VIO
"RI"
"DTR"
"CTS"
"RTS"
"DSR"
"DCD"
"TXD"
"RXD"
0RR132
R306
2 /2 47R
R306
/2 47R2
R307
/2 47R
2
R307
2
/2 47R
R311
/2 47R
2
R311
2
/2 47R
R310
2 /2 47R
R310
/2 47R2
J103
LPRFSync
LPRFInt
USARTRx
USARTTx
CBUSClk
CBUSDa
CBUSEnX
PURX
SleepX
21
22
19
20
SleepClk
1
2
3
2194
PUSL(3:0)
0
1
2
LPRFCLK
UPP
Page 5
Mjoelner
Page 7
GENIO(52:0)
UPP
Page 5
AUDUEMCTRL(5:0)
R308
/2 47R
1
C306
27p
GND
R308
/2 47R
1
C307
27p
GND
R312
/2 47R
1
C308
27p
GND
R313
/2 47R
1
C309
27p
GND
R309
/2 47R
1
C310
27p
GND
R309
/2 47R
1
C311
27p
GND
R312
/2 47R
1
C312
27p
GND
R313
/2 47R
1
C313
27p
GND
75683
UPP
Page 5
X101/Power connector
"EB_PWR"
"RI"
"DTR"
"CTS"
"TXD"
X102/Power connector
"EB_GND"
"RTS"
"RXD"
"DSR"
"DCD"
X101
MATE
X102
MATE
~4V~4V
VBATVBATTRF
J104
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
J106
Customer Care / Service & Support Readiness / Competence Transfer Team
Customer Care / Service & Support Readiness / Competence Transfer Team
Copyright © 2005 NOKIA Only for training and service purposes
Copyright © 2005 NOKIA Only for training and service purposes
Version: 2.0 Version: 2.0
18.01.200518.01.2005
N610/N616 TFE-4/RV-1N610/N616 TFE-4/RV-1
"DTR"
"TXD"
"RXD"
"DCD"
"RI"
"GND"
"RTS"
"DSR"
"CTS"
Board version: TF5_06 Board version: TF5_06
Bluetooth, Power connectorsBluetooth, Power connectors
GND
Page 6(14)Page 6(14)
Page 7
UEM
Band Channel
RX
VCO/RX
VC/RX
TX VCO/TX
VC/TX
EGSM 900 37
942.4MHz
3769.6MHz
~2.72V
897.4MHz 3589.6MHz
~1.98V
GSM 1800 700
1842.8MHz
3685.6MHz
~2.37V
1747.8MHz 3495.6MHz
~1.59V
Vcont1 Vcont2 Vcont3
GSM850/900 RX - - GSM850/900 TX - - 2.7V
GSM1800 RX - - GSM1800 TX 2.7V - -
Page 4
RXIINP
RXIINN
RXQINP
RXQINN
Bluetooth
Page 6
UPP
Page 5
LPRFCLK
RFCLK
RFBUSCLK
RFBUSEN1
RFBUSDA
RESET
X602
1
Z601/Antenna switch
V601
BC848W
R603
R601
1k5
15k
R602
C602
33k
3p9
R618
C605
100n
E601
Tx1--GSM
Tx2
R610
10R
PCN
ANTENNA SWIT CH
C603
1n0
560R
C606
27p
C701
15p
ANT
Z601
LM-T118S1E2
C607
3u3
R713
5k6
R713
R713
R713
R717 /2 2k2
2.8V
T701
LDB211G8005C-001
3
5
4
C721
1n0
27p
C733
B39901-B7715-C610
27p
C734
5k6
5k6
5k6
?
1
2
Z701
897.5MHz
13
J701
J702
/2 2k2?R717
11
L712
3n9H
L710
10nH
C722
15p
OUTIN
L711
15nH
L606
4.7V
VR1A
C629
27p
8n2H
C634
2p2
L607
8n2H
L603
3n9H
C631
L604
0p5
3n9H
N601/Mjoelner
MJOELNER_S2006F3A
C5
RXIP
C6
RXIM
B6
RXQP
A5
RXQM
C1
INPL
B1
INML
G1
INPM
F1
INMM
A8
XTALP
A7
XTALM
G2
MLP
F2
MLM
E2
HLP
D2
HLM
C2
1.8V
VIO
R611
10R
R623
100R
R629
5R6
R625
47R
R617
22R
R630
330R
C636
C628
C625
1u0
10n
10n
LLP
B2
LLM
B8
REFOUT
H9
VIO
NA
E9
RFBUSCLK
E7
RFBUSENX
F8
RFBUSDA
F7
RESETX
E8
SELADDR
A1
VDDRXF
B7
VDDRXBB
H6
VDDLO
J3
VDDTX
G7
VDDCP
F9
VDDPRE
G8
VDDPLL
A6
VDDXO
A9
VDDBBB
J9
NA
D7
VDDDIG
D8
VDDDL
A4
VBEXT
B5
RBEXT
R626
2k7
TXQP
TXQM
OUTHP
OUTHM
OUTLP
OUTLM
CPOUT
INPLO
INMLO
PLFB1
PLFB2
VPCH
VPCL
SENSE
VANTL
VANTM
VANTH
VTXBH
VTXBL
VTXLOL
VTXLOH
VBDET
VSSLNA
VSSXO
VSSCP
VSSTX
VSSLO
H3
TXIP
G3
TXIM
G4
H4
J1
H1
J2
H2
G9
J7
J8
D9
TXP
E3
TXC
J5
DET
J4
J6
H5
G5
F4
IMIR
C3
B9
C9
C8
B3
C4
A3
D3
B4
H8
NA
A2
C7
G6
F3
F6
F5
VSS1
D5
VSS2
D6
VSS3
E6
VSS4
E4
VSS5
D4
VSS6
H7
VSS7
L703
L702
L701
C706
C707 2n2
R706
33k
C709
180p
33nH
33nH
33nH
68p
C710
180p
C705
C704
15p
27p
R708
4k7
R707
15k
8k2
R711
C712
R710
180p
5k6
C711
3n9
C639
L608
33nH
V602
BAR63-04W-E6327
47p
IN
OUT
942.5MHz
IN
OUT
Z602
1842.5MHz
C703
1n0
3
Cont1
Cont2
Cont
Rx1-GSM
Rx2-DCS
B601/26MHz
2.8V
VR5
VR3
VR2
C627
C622
C626
10u
100n
5p6
VR6
VR4
C635
C632
C623
C871
1n0
100n
27p
C633
C620
C624
27p
27p
27p
27p
C715
68p
C716
68p
C718
C717
1n0
27p
VR2
R720
82R
L705
3n3H
R721
82R
R725
120R
L707
18nH
L706
15nH
L708
18nH
R726
120R
C731
27p
12
TXIOUTP
TXIOUTN
TXQOUTP
TXQOUTN
TXP
TXC
UEM
UPP
UEM
Page 4
Page 5
Page 4
UEM
Page 4
VREF1
R612
1k0
C615
10n
2.8V
VR7
R730
5R6
C610
C740
C741
3u3
100n
5p6
VCC
VC
G701
OUT
R731
292R
RESNET_3DB
T702
LDB213G7010C
3
1
5
4
2
292R
17R6
C803
27p
R801
4k7
V801
R802
100R
C804
C805
27p
27p
C812
1u0
C815
C807
27p
33u_16V
C825
100n
N801/Power amplifier
1
Ident
2
N/C
3
Pout_DCS
4
Vdd2
5
B1_OUT
B2_OUT
COUP
L801
B1_IN
B2_IN
TERM
R803
GND
47R
L808
5n6H
Vdd1
6
Pout_GSM
C823
1p0
PF08125B-02-TB
GND7,13=
C813
27p
Pin_DCS
Vapc_DCS
Vapc_GSM
Pin_GSM
L805
42R/100MHz
GND
C816
27p
12
11
10
9
8
R819
17R6
292R
292R
Battery
R821
100R
R820
1k0
R818
100R
R817
1k0
C818
L806
27p
10nH
C820
R805
27p
30R4
178R5
178R5
C821
1p8
V802
R823
180R
R822
3k9
C822
27p
C824
3p9
L807
5n6H
R806
17R6
292R
VBATTRF_
connector
Customer Care / Service & Support Readiness / Competence Transfer Team
Customer Care / Service & Support Readiness / Competence Transfer Team
Copyright © 2005 NOKIA Only for training and service purposes
Copyright © 2005 NOKIA Only for training and service purposes
Version: 2.0 Version: 2.0
C826
8p2
18.01.200518.01.2005
N610/N616 TFE-4/RV-1N610/N616 TFE-4/RV-1
Board version: TF5_06 Board version: TF5_06
RF partRF part
Page 7(14)Page 7(14)
Page 8
1) 32kHz at C210
2) 32kHz SLEEPCLK at J404
3) 26MHz RFCLK at C420
4) SLEEPX at J403
VR2 = 2,8V
VR6 = 2,8V
VR4 = 2,8V
VR7 = 2,8V
13
11
12
10
5) CBUSCLK at J406
9) DBUSDA at J414
13) TX I/Q at R713
6) CBUSDATA at J407
10) FLASHCLK at J419
7) CBUSENX at J408
11) TXP at J701
8) DBUSCLK at J413
12) TXC at J702
3
Vr5 = 2,8V
VR3 = 2,8V
VIO = 1,8V
VR1A = 4,8V
VCORE LIN = 1,5V
VANA = 2,8V
1
VBAT = 4V
6
7
4
VFLASH1 = 2,8V
VSIM = 3V
5
8
9
2
Customer Care / Service & Support Readiness / Competence Transfer Team
Customer Care / Service & Support Readiness / Competence Transfer Team
Copyright © 2005 NOKIA Only for training and service purposes
Copyright © 2005 NOKIA Only for training and service purposes
Version: 2.0 Version: 2.0
18.01.200518.01.2005
N610/N616 TFE-4/RV-1N610/N616 TFE-4/RV-1
Board version: TF5_06 Board version: TF5_06
Signal overviewSignal overview
Page 8(14)Page 8(14)
Page 9
Bottom
C281 P5 C704 K7 J405 S5 R105 W5 R711 L7
A800 D5 C282 O3 C705 K8 J406 R6 R106 W6 R713 L6
C283 P2 C706 J6 J407 R6 R107 W7 R717 L6
B200 P3 C284 P3 C707 J6 J408 Q6 R108 W7 R720 H6
B601 J8 C285 O6 C709 M7 J409 Q6 R109 Y7 R721 H6
C286 N6 C710 J6 J410 Q6 R110 Y6 R725 I6
C102 Y5 C287 N7 C711 L7 J411 R6 R111 Y5 R726 I6
C104 T5 C288 N7 C712 M7 J412 Q6 R112 Y4 R730 L9
C105 Y3 C289 O6 C715 L6 J413 S6 R114 T3 R731 K8
C106 X3 C290 P6 C716 L6 J414 S6 R115 T3 R801 D4
C107 Y4 C291 O6 C717 L6 J415 R6 R132 N7 R802 J5
C108 Y5 C292 P6 C718 L6 J416 T7 R151 U3 R803 C4
C109 Y6 C293 P7 C721 H5 J417 S7 R152 U2 R805 F4
C110 T2 C294 O7 C722 H5 J418 S7 R154 Q3 R806 H5
C118 V5 C295 N6 C731 I5 J419 S8 R165 Q4 R817 G5
C119 W6 C296 O7 C733 I5 J420 S6 R166 T4 R818 G4
C120 W6 C297 N6 C734 I5 J421 P8 R167 U3 R819 F6
C121 W7 C298 O7 C740 K8 J422 P8 R182 U4 R820 G5
C122 Y6 C299 N7 C741 M9 J423 P8 R200 Q5 R821 G5
C148 N2 C306 F1 C803 D3 J424 P8 R202 N3 R822 H5
C149 N2 C307 F1 C804 D3 J700 S5 R220 N3 R823 H5
C150 W5 C308 G1 C805 J5 J701 N8 R240 N3
C151 U4 C309 G9 C807 D6 J702 L6 R305 N3 T701 H6
C153 U3 C310 F9 C812 D6 R306 P7 T702 K7
C154 U3 C311 F9 C813 E4 L132 N2 R307 P8
C156 U3 C312 G1 C815 C6 L133 N2 R308 F1 V100 Y4
C159 U3 C313 G9 C816 F3 L150 V3 R309 F8 V101 W6
C163 U2 C390 U5 C818 H5 L168 V2 R310 P8 V102 Y6
C164 T4 C400 P7 C820 G4 L260 Q2 R311 P8 V103 T3
C165 U3 C401 Q5 C821 G5 L261 Q2 R312 G1 V130 J3
C166 U3 C402 R5 C822 H5 L262 R2 R313 G8 V601 L5
C167 V3 C403 Q5 C823 C5 L263 R2 R314 P4 V602 B6
C172 V3 C404 R5 C824 H5 L264 Q2 R386 P4 V801 D3
C182 P3 C405 R8 C825 E3 L265 R2 R387 Q4 V802 H5
C200 P5 C420 L5 C826 C5 L603 H6 R388 S4
C201 R5 C450 U6 C871 I8 L604 H6 R390 P4 X100 X5
C202 R5 C451 U6 L606 H7 R420 L5 X101 F2
C207 N3 C454 S5 D200 O4 L607 H7 R422 N6 X102 F7
C208 P5 C602 L5 D400 R7 L608 B5 R424 O9 X387 R5
C209 P2 C603 M6 D450 U7 L701 K7 R450 S5 X401 X7
C210 P3 C605 M5 L702 K8 R483 W5 X480 W3
C218 N3 C606 J8 G701 L8 L703 K7 R484 W5 X602 D2
C220 N3 C607 L6 L705 H6 R485 V5 X603 R5
C236 N6 C610 L9 J101 Y3 L706 I6 R486 W3 X604 J5
C237 N6 C615 I8 J102 Y5 L707 I6 R487 W2
C238 P5 C620 H8 J103 M3 L708 I6 R488 W2 Z601 B4
C239 O3 C622 J5 J104 E2 L710 G5 R601 L5 Z602 H6
C240 N3 C623 K6 J105 M9 L711 I5 R602 L5 Z604 H7
C241 O2 C624 J6 J106 E8 L712 G5 R603 L5 Z701 I5
C242 N3 C625 K6 J135 H4 L801 C4 R610 M5
C260 Q2 C626 J6 J137 J4 L805 E3 R611 J6
C261 Q2 C627 K5 J138 I4 L806 G5 R612 I8
C262 R2 C628 J7 J139 I4 L807 H5 R617 J8
C263 R2 C629 J6 J140 I4 L808 C5 R618 L5
C264 Q2 C631 H6 J141 H4 R623 J6
C265 R2 C632 I8 J143 H4 N601 I7 R625 J6
C274 O2 C633 J6 J144 H4 N801 E5 R626 J8
C275 P4 C634 H7 J145 O1 R629 J7
C276 P4 C635 J7 J305 O2 R100 T5 R630 J7
C277 O3 C636 J8 J396 U2 R101 Y3 R706 J6
C278 O3 C639 C5 J402 S5 R102 X3 R707 J5
C279 P5 C701 B5 J403 S5 R103 T5 R708 J5
C280 P7 C703 B3 J404 S5 R104 X3 R710 L7
Z
T
L
V
X
N
R
D
G
J
A
B
C
Customer Care / Service & Support Readiness / Competence Transfer Team
Customer Care / Service & Support Readiness / Competence Transfer Team
Copyright © 2005 NOKIA Only for training and service purposes
Copyright © 2005 NOKIA Only for training and service purposes
Top
Power amp
1
2
3
5
4
6
1
1
10
8
7
9
2
1
1
3
5
7
9
1
1
Version: 2.0 Version: 2.0
1
3
2
4
6
8
0
1
2
1
4
1
18.01.200518.01.2005
1
2
3
4
UPP
Flash
Mjoelner
UEM
1
2
3
4
2
Bluetooth
8
9
6
SIM Reader
N610/N616 TFE-4/RV-1N610/N616 TFE-4/RV-1
Board version: TF5_06 Board version: TF5_06
Component finder TF4_05 Component finder TF4_05
Page 9(14)Page 9(14)
Page 10
AUDIOV10
AUDIOV10
X104
Page 12
CRMX
BUK107-50DL
DTAB
GND
4
D
S
V124
RB491D-T146
V123
IN
Car Radio Mute
R116
1k0
R105
1k0
C161
10n
GND
3D2
G1
2
S11
R320
680k
C305
1u0
FDG6322C
V116
GND
VEBPWR
GND
POWERONX pulse
R313
680k
C314
100n
D301
TLC555ID
1
VDD
GND
2
TRIG
DSCH
3
THRES
OUT
4
RES5CONT
J310
R329
10k
VEBPWR
R109
4S2
5G2
100k
D1 6
VEBPWR
8
7
6
C304
100n
GND
R319
10k
VEBPWR
B2BHDMICP
B2BHDMICN
B2BHFMICP
B2BHFMICN
B2BPOWERONX
B2BIGNS
R416
47k
GND
GND
GND
VWAKE
B2BVFLASH
B2B Connector
X110
PTP423
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
PTP422
20
21
B2BBSI
22
23
24
25
26
27
28
GND
B2BXEARP
B2BXEARN
B2BHFMUTEX
B2BHDMUTEX
B2BUIPOWERON
B2BPOWEROFFX
B2BCRM
B2BFBUSRD
B2BFBUSDR
B2BMBUS
POWEROK
C254
100n
GND
UM6K1N-TN
V401
C255
10u
2
5
G
R219
R221
V306
UMH9N
R1
10k
V306
UMH9N
R1
10k
R412
47k
1k0
1k0
GND
R220
2k87
C226
1n5
VEBPWR
47kR2
47k
GND
D
S
UMH9N
R1
5
10k
GND
R321
10k
6
1
GND
3
VMICONX
Page 12
4
GND
C405
22p
V305
R322
R316
47k
2
3
47kR2
4
C220
1n5
GND
C222
10n
VEBPWR
C306
10n
10k
VMIC3
R201
5k6
C253
10n
R404
100R
GND
R408
100R
C408
22p
GND
R409
100R
C410
22p
GND
R410
100R
C412
220p
GND
V305
UMH9N
R1
10k
R2
GND
C404
22p
C409
22p
C411
22p
C249
1u0
R411
100R
C245 100n
C246
R314
6
1
33n
47k
R233
47k
J309
R234
47k
R315
10k
R229
22k
" 1% "
R230 22k
" 1% "
C250
330p
GND GND
V400
RSA6.1EN
GND
J308
13
12
C259
330p
GNDGND
C221
100n
C225
100n
C248
330p
N200
TS974ID
-
+
4= VMIC2
11= GND
Handsfree and handset downlink path
N201
TDA7391PD
R232
10k
R222
C247
15
14
4
8
9
17
C229
10u
47k
1u0
GND
C256
100n
1,10,11,20,21= GND
AUDIOV10
GND
R224
10k
IN+
OUT+
IN-
OUT-
ST-BY NC
MUTE
CD18NC
5,16=
N201 Pin 5+16
C257
C236
1u0
2
19
3
NC
6
7
NCSYNC
13
NC
AUDIOV10
GND12=
C258
100u
100n
1
SHUTDOWN
2
BYPASS
3
IN+
45
IN-
GND
Display Unit Connector
R406
R405
100R
100R
R407
GND
GND
X103
10
9
8
7
6
5
4
3
2
1
C415
22p
C414
22p
VWM16V
GND
GND
GND
L401
600R/100MHz
L402
600R/100MHz
R407
VWM16V
C407
22p
GND
R419
VWM16V
C406
10n
VDU
VWM16V
N202
LM4864M
6=
VEBPWR
GND7=
R226
10k
R419
L201
68R/100MHz
C223
220p
GND
C227
220p
GND
8
Vo2
Vo1
68R/100MHz
C231
100n
C234
100n
L202
C228
1n0
L203
600R/100MHz
R227
4R7
GND
L204
R228
4R7
GND
GND
GND
C224
1n0
C235
22p
GND
GND
R235
100R
R236
100R
X105
4
2
1
SMK ThruHole 3.5
FLASHIMEI
N101
Page 12
VDU
X107
1
2
3
GND
4
5
6
7
HDEARP
8
9
HDEARN
10
VWM16V
R420
R420
VWM16V
Customer Care / Service & Support Readiness / Competence Transfer Team
Customer Care / Service & Support Readiness / Competence Transfer Team
Copyright © 2005 NOKIA Only for training and service purposes
Copyright © 2005 NOKIA Only for training and service purposes
Version: 2.0 Version: 2.0
18.01.200518.01.2005
N610/N616 TFE-4/RV-1N610/N616 TFE-4/RV-1
Board version: TF5_06 Board version: TF5_06
GND
GND
Car Radio mute, Display, HandsetCar Radio mute, Display, Handset
Page 10(14)Page 10(14)
Page 11
SMK ThruHole 2.5
X106
VMIC
R200
330R
C200
10u
R202
GND
3
4
2
1
GND
GND
PTP200
C238
22p
L200
600R/100MHz
C239
R208
22p
GNDGND
1k8
1k0
C201
22p
GND
C213
1n0
GND
C210
220n
C135
1u0
GND
R209
6k8
+2V5BIAS
C212
22p
C219
GND
10n
L207
33nH
GND
C217
GND
9
10
22p
Handsfree microphone path
C203
220p
C205
R216
10k
22p
GND
GND
R205
120k
N200
TS974ID
-
+
4= VMIC2
11= GND
8
L208
33nH
R211
22k
C204
C215
22p
22p
C216
N200
TS974ID
2
1
3
+
VMIC24=
GND11=
GND
R212
22k
N200
TS974ID
GND
6
-
5
+
4= VMIC2
22p
11= GND
GND
22p
C209
GND
7
C218
22p
GND
C202
1u0
R206
10k
GND
C211
1u0
10k
R215
GND
C207
220p
C242
220p
GND
GND
R203
100R
R213
100R
GND
GND
C206
10n
C214
10n
R207
3k9
B2BHFMICP
B2BHFMICN
X110
Page 10
X110
Page 10
100n
C311C310
100n
C312
100n
X110
Page 10
VWAKE
C313
100n
GND
B2BPOWEROFFX
R317
10k
X104
Page 12
R325
100k
SENSE
VREF2V5
C302
100n
GND
close to PWRCON
4S2
5G2
D16
R328
10k
GND
C303
1u0
FDG6322C
V302
R328
1k0
Power control
"Threshold Level: 8V (22k, 10k)"
LMC7215IM5X
-
3
+
R308
10k
GND
POWEROK
3D2
G1
2
S1 1
GND
N302
2= VWAKE
5= GND
1
R326
2k87
R312
GND
VWAKE VCAR
Voltage supervisor
R300
120k
R305
120k
GND
R309
k
220
R310
GND
Antennaline
C300
39k
PTP301
12
13
9
10
R304
10k
D300
74AHC08D
&
VWAKE14=
GND7=
D300
74AHC08D
&
14= VWAKE
7= GND
11
8
R307
5k6
GND
V301
BAS70-07W
V301
BAS70-07W
PTP307
R311
GND
VREF2V5
IGNS5V
B2BIGNS
X110
Page 10
C301
1u0
Page 12
SMPSON
47k
Page 13
RS232POWEROFFX
10k
X209
GND GND
1u
VREF2V5
E210
GND
R301
220k
R306
120k
LMC7215IM5X
4
3
E211
LMC7215IM5X
4
3
N301
-
+
2= VWAKE
5= GND
N300
-
+
BAS70-07W
1
V300
VWAKE2=
GND5=
BAS70-07W
1
V300
w=2,55 mm; dist0,76mm
CPWG GND: layer 4
J302
C307
VWAKE
1n0
R302
GND
10k
POWEROK
GND
C252
10n
GND
VMIC3
L209
33nH
C208
VMIC2
22p
GND
GND
X210
GND
+2V5BIAS
C241
100n
C240
VMIC
L205
600R/100MHz
R217
22k
R218
1u0
22k
C251
1u0
Customer Care / Service & Support Readiness / Competence Transfer Team
Customer Care / Service & Support Readiness / Competence Transfer Team
Copyright © 2005 NOKIA Only for training and service purposes
Copyright © 2005 NOKIA Only for training and service purposes
Version: 2.0 Version: 2.0
18.01.200518.01.2005
N610/N616 TFE-4/RV-1N610/N616 TFE-4/RV-1
Board version: TF5_06 Board version: TF5_06
Power, MicrophonePower, Microphone
Page 11(14)Page 11(14)
Page 12
CAR_CONNECTOR
X104
1
+VB
2
IGNS
3
CRM
4
-VB
GND
DEFAULT
C159
22p
"Copper fuse "
C153
22p
R103
GND
PTP104
GND
C158
1u
L104
68R/100MHz
C108
22p
GND
PTP103
C130
68R/100MHz
GND
Power
R303
C156
100n1n0
L100
Page 11
22k
R102
1u
PTP106
GND
V100
MBRS340T3
V115
SMAJ30A
C164
220p
GND
GND
VCAR
C160
10n
V101
SMAJ30A
C155C154
Page 10
CRMX
C129
C109
220p
100n
GND
GND
SENSE
R110
10k
R145
10k
C122
100n
GND
"1%"
VCARSW
V104
V107
2SC5658QRS
J113
C151
220n
GND
C133
C134
100u_50V
10V LDO APAMP
N103
IN
4
LM2941S
ON/OFF
2
3
GND6GND
GND
AUDIOV10
R122
R126
1k0
GND
PTP114
C128
100n
6k8
OUT
5
ADJ
1
C143
100u_16V
J114
J117
GND
VCAR
VCAR switch
VWAKE
N100
IN
8
LM2936MX-5.0
C157
22p
1u
C107
100u
2367
Page 10
VMICONX
OUT
1
C140
C139
22p
100u
C126
100n
R120
100k
3k3
VMIC switch
S24
G25
D16
FDG6322C
V112
D2 3
G1
VMIC
J115
2
1S1
GND
C137
R125
10k
10n
X110
Page 10
B2BHFMUTEX
Page 11
SMPSON
C148
220n
2
J11
V105
C115
220n
BZX84C18
R106
220k
R113
1k0
VCARSW
C118
100u_50V
L101
33uH
C120
100n
4.3V SMPS VEBPWR
N101
IN
2
6
LM2676S-ADJ
ON/_OFF
C119
100u_50V
4
7G8
G
VDU
"VEBPWR (normal mode) 4.37V"
"VEBPWR (FLASHIMEI=HI) = 5.257V"
FB
SW_OUT
1
CBOOST
3
C117
10n
V117
MBRS340T3
V108
UM6K1N-TN
C141
L102
33uH
1n0
GND
R131
10R
R104
2k87
470u_6V3
R107
1k1
GND
R111
3k9
D
G
C123
100n
PTP108
C110
R115
47k
PTP109
470u_6V3
R114
47k
PTP110
C111
VEBPWR
C113
100n
X103
Page 10
FLASHIMEI
R132
R133
150k
X110
Page 10
B2BUIPOWERON
R134
0R1
R135
10k
R137
C146
GND
100R
100R
10n
AUDIOV10
V120
R1
2
10k
47kR2
C145
10n
3k3
GND
GND
R136
10k
LMC7211BIM5X
4
3
V122
BAS70-07W
R142
47k
6
1
N104
-
+
2= AUDIOV10
5= GND
R144
1k0
UMH9N
R1
5
10k
1
BAS70-07W
AUDIOV10
C147
100n
GND
V120
47kR2
V119
R139
3
4
C149
1u0
BAS70-07W
1k0
47k
V119
V118
R140
220k
R146
220k
G
D
S
R141
47k
V121
V401
UM6K1N-TN
C116
C162
10n
C165
220p
L103
2u2H
C142
100u_16V
GND
C163
220p
Customer Care / Service & Support Readiness / Competence Transfer Team
Customer Care / Service & Support Readiness / Competence Transfer Team
Copyright © 2005 NOKIA Only for training and service purposes
Copyright © 2005 NOKIA Only for training and service purposes
Version: 2.0 Version: 2.0
18.01.200518.01.2005
N610/N616 TFE-4/RV-1N610/N616 TFE-4/RV-1
GND
Board version: TF5_06 Board version: TF5_06
PowerPower
Page 12(14)Page 12(14)
Page 13
VEBPWR
"pwr B2B con. 540F035"
B2B connectors for Power & Rs232
X111
1
2
3
4
5
6
7
8
X112
1
2
3
4
5
6
7
8
"pwr B2B con. 540F035"
GND
VEBPWR
R507
RS232
47k
GND
47k
GND
47k
GND
47k
GND
47k
GND
10k
RS232
R508
10k
RS232
R509
10k
RS232
R510
47k
RS232
R512
10k
RS232
RS232
RS232
RS232
RS232
R511
10k
V503
3
UMH9N
5
R1
10k
4
RS232
R2
N500
MAX3238EEAI
24
T1IN
23
T2IN
22
T3IN
19
T4IN
17
T5IN
8
R1IN
9
R2IN
11
R3IN
1
RS232
C519
1u0
RS232POWEROFFX
Page 11
VEBPWR
RS232
100n
RS232
47k
C521
1u0
GND
RS232
RS232
R517
0R
GND
caps close
to pin 26
3
14
13
VRS232
RS232
C532
1u0
C2+
C2-
_FORCEOFF
FORCEON
26=
T1OUT
T2OUT
T3OUT
T4OUT
T5OUT
R1OUTB
R1OUT
R2OUT
R3OUT
_INVALID
GND2=
C1+
C1-
5
6
7
10
12
16
21
20
18
28
25
15
27
V+
4
V-
RS232
GND
C518
1u0
RS232
C517
220n
GND
RS232
C520
1u0
RS232
RS232
RS232
RS232
RS232
RS232
RS232
C524
220p
C525
220p
C526
220p
C527
220p
C528
C529
220p
C530
220p
C531
220p
GND
GND
GND
GND
GND
GND
GND
GND
L501
600R/100MHz
RS232
L502
600R/100MHz
L503
600R/100MHz
RS232
L504
600R/100MHz
RS232
L505
600R/100MHz
RS232
L506
600R/100MHz
L507
600R/100MHz
RS232
L508
600R/100MHz
C501
C503
C504
C505
C506
C507
C508
C509
R513
RS232
R515
RS232
R514
RS232
R516
RS232
R515
RS232
R516
RS232
R514
RS232
R513
GND
GND
GND
GND
GND
GND
GND
GND
RS232
RS232
RS232
RS232
RS232
RS232
RS232
E501
/2 VWM16V/2 VWM16V
1
GND
E502
/2 VWM16V
1
GND
E503
/2 VWM16V
1
GND
E504
/2 VWM16V
1
GND
E505
/2 VWM16V
2
GND
E506
/2 VWM16V
2
GND
E507
2
GND
E508
/2 VWM16V
2
GND
C502
220p
22p
GND
GND
RS232
C510
22p
220p
GND
GND
RS232
C511
220p
22p
GND
GND
RS232
C512
22p
220p
GND
GND
RS232
C513
220p
22p
GND
GND
RS232
C514
22p
220p
GND
GND
RS232
C515
220p
22p
GND
GND
RS232
C516
220p
22p
GND
GND
X102/RS232 Connector
"TXD"
"RXD"
"DTR"
"DCD"
"CTS"
"DSR"
"RI"
"RTS"
GND
220p
1
2
3
4
5
6
7
8
9
10
RS232
V501
6
UMH9N
"RI"
R1
"CTS"
"DCD"
"RXD"
"DSR"
2
1
3
5
4
6
2
1
6
2
1
3
5
4
10k
R
V501
UMH9N
R1
10k
R2
V502
UMH9N
R1
10k
R2
V503
UMH9N
R1
10k
R2
V502
UMH9N
R1
10k
R2
2
4
2
3
1
5
6
7
8
R501
RS232
"TXD"
"DTR"
"RTS"
Customer Care / Service & Support Readiness / Competence Transfer Team
Customer Care / Service & Support Readiness / Competence Transfer Team
Copyright © 2005 NOKIA Only for training and service purposes
Copyright © 2005 NOKIA Only for training and service purposes
5k6
R502
3k9
5k6
R504
3k9
R505
5k6
R506
3k9
RS232
GND
RS232
RS232
GND
RS232
RS232
GND
Version: 2.0 Version: 2.0
18.01.200518.01.2005
N610/N616 TFE-4/RV-1N610/N616 TFE-4/RV-1
Board version: TF5_06 Board version: TF5_06
RS232 connection RS232 connection
Page 13(14)Page 13(14)
Page 14
C216 H3 R142 L2 R329 M7
C107 F11 C217 H2 D300 P6 R143 N16 R404 E15
C108 C11 C218 H3 D301 M6 R144 N15 R405 E16
C109 D9 C219 H1 R145 F13 R406 E16
C110 Q17 C220 P4 E210 D22 R146 M16 R407 E16
C111 Q14 C221 H7 R200 C6 R408 E15
C113 Q10 C222 J1 L100 C10 R201 J3 R409 E14
C115 F13 C223 D8 L101 I10 R202 C6 R410 E14
C116 I16 C224 C8 L102 O9 R203 O4 R411 E14
C117 N11 C225 H7 L103 H16 R205 H2 R412 E14
C118 I12 C226 P4 L104 E13 R206 J3 R416 Q3
C119 I7 C227 H8 L200 C7 R207 O3 R419 D2
C120 M11 C228 C9 L201 D8 R208 C7 R420 D4
C122 F12 C229 D6 L202 D9 R209 H2
C123 L13 C230 E5 L203 E5 R211 H3 V100 D11
C126 J4 C231 F3 L204 E4 R212 H3 V101 F10
C128 H17 C234 G3 L205 J4 R213 N4 V104 H14
C129 D9 C235 E4 L207 I1 R215 H3 V105 F14
C130 E13 C236 F1 L208 I3 R216 G2 V107 F12
C133 G19 C238 C6 L209 I3 R217 J2 V108 L12
C134 G21 C239 C7 L401 E2 R218 J2 V112 J4
C135 D6 C240 J2 L402 E2 R219 P4 V115 C11
C137 J5 C241 J2 R220 P4 V116 L4
C139 L14 C242 N4 N100 J14 R221 P4 V117 O11
C140 K14 C245 J1 N101 M9 R222 D7 V118 L16
C141 O12 C246 I1 N103 I19 R224 G2 V119 N15
C142 F16 C247 G1 N104 O16 R226 G2 V120 L2
C143 L17 C248 I2 N200 I2 R227 F3 V121 K15
C145 O15 C249 J3 N201 F7 R228 G3 V122 N17
C146 O17 C250 I1 N202 F2 R229 I1 V123 K7
C147 O16 C251 I4 N300 R6 R230 I1 V124 K8
C148 F13 C252 I4 N301 K5 R231 I1 V300 Q4
C149 N16 C253 J3 N302 M7 R232 F1 V301 P5
C151 G18 C254 F2 R233 J3 V302 O5
C153 E13 C255 E2 R102 B10 R234 J3 V305 M4
C154 E12 C256 H7 R103 C12 R235 D5 V306 L1
C155 J13 C257 D7 R104 L11 R236 D4 V400 E15
C156 E12 C258 I5 R105 L4 R300 R6 V401 N15
C157 J14 C259 I2 R106 G14 R301 R4
C158 B11 C300 R5 R107 L11 R302 Q4 X103 B15
C159 B11 C301 K5 R109 K4 R303 B11 X104 A12
C160 B10 C302 N8 R110 F13 R304 M7 X105 B9
C161 L4 C303 N7 R111 L12 R305 R6 X106 A7
C162 H15 C304 L5 R113 F13 R306 Q5 X107 B4
C163 G17 C305 N6 R114 L13 R307 M8 X110 O2
C164 B10 C306 K1 R115 L13 R308 N7 X111 Q20
C165 H15 C307 Q4 R116 L4 R309 K6 X112 L20
C200 C6 C310 Q5 R120 J4 R310 K6 X209 B22
C201 C7 C311 K4 R122 G20 R311 P5 X210 Q23
C202 J3 C312 M7 R123 J4 R312 O5
C203 H2 C313 Q5 R125 J5 R313 N6
C204 I3 C314 N5 R126 G20 R314 M4
C205 H2 C404 E15 R131 O12 R315 M4
C206 O4 C405 E16 R132 O18 R316 M4
C207 O4 C406 E16 R133 N17 R317 Q6
C208 I3 C407 E16 R134 M17 R318 O4
C209 I3 C408 E15 R135 O15 R319 M5
C210 C7 C409 E15 R136 O17 R320 N6
C211 H3 C410 E15 R137 O15 R321 K1
C212 H2 C411 E14 R138 O15 R322 K1
C213 C6 C412 E14 R139 N17 R325 P4
C214 N4 C414 E2 R140 M16 R326 O4
C215 H3 C415 E2 R141 M15 R328 O4
C D
E
L
N
R
V
X
Customer Care / Service & Support Readiness / Competence Transfer Team
Customer Care / Service & Support Readiness / Competence Transfer Team
Copyright © 2005 NOKIA Only for training and service purposes
Copyright © 2005 NOKIA Only for training and service purposes
Version: 2.0 Version: 2.0
18.01.200518.01.2005
N610/N616 TFE-4/RV-1N610/N616 TFE-4/RV-1
Board version: TF5_06 Board version: TF5_06
Component finder TF5_06Component finder TF5_06
Page 14(14)Page 14(14)
Loading...