Page 1
CCS Technical Documentation
RH-27 Series Transceivers
Assembly
Issue 1 11/2003 Confidential ©2003 Nokia Corporation
Page 2
RH-27
Assembly CCS Technical Documentation
Step-by-Step Assembly Instructions
Alway use ESD protection
Assembly Instructions
Step-by-Step Assembly Instructions (Model 6225)
1. Press the Release Key down into its correct position. 2. Put the Release Spring into its place.
3. Put the DC Jack into its place. 4. Put the Vibra into its place.
Note! Avoid touching the spring contacts.
Page 2 ©2003 Nokia Corporation Confidential Issue 1 11/2003
Page 3
RH-27
CCS Technical Documentation Assembly
Step-by-Step Assembly Instructions (Model 6225)
5. Put the Volume Key into its place. 6. Put the Power Key into its place.
7. Put the Antenna into its place.
Note! Do not touch the inside of the Antenna plate.
9. Place the LCD into the UI frame. Note! Do not press the LCD as it may get damaged.
8. Put the UI Board into its place.
10. Fit the Display Shield into its place. Make sure the shield is properly locked on both sides to
the frame.
Issue 1 11/2003 Confidential ©2003 Nokia Corporation Page 3
Page 4
RH-27
Assembly CCS Technical Documentation
Step-by-Step Assembly Instructions (Model 6225)
11. Put the Speaker into the frame so that the guiding
pin goes into its place.
13. Place the UI Module and the engine together by
closing the Display connector.
12. Put the Microphone into the frame.
Note! Do not touch the spring contacts.
1.
3.
5.
2.
4.
6.
14. Put the unit into the C-cover. 15. Tighten the six screws in the order indicated above.
Note! Set 20Ncm/650rpm to your Torque driver before
tightening.
16. Place the B-cover into its place. Make sure the
17. Place the Keymat into its place.
snaps on both sides are locked to the module.
Page 4 ©2003 Nokia Corporation Confidential Issue 1 11/2003
Page 5
RH-27
CCS Technical Documentation Assembly
Step-by-Step Assembly Instructions (Model 6225)
18. Place the A-cover into its place. 19. Slide the Battery cover into its place until the
Release Key locks it.
Assembly complete!
Issue 1 11/2003 Confidential ©2003 Nokia Corporation Page 5
Page 6
RH-27
Assembly CCS Technical Documentation
Page 6 ©2003 Nokia Corporation Confidential Issue 1 11/2003
Loading...