Page 1
Nokia 5330 / 5330 Mobile TV Edition
RM-615
Service Manual Level 1&2
SERVICE MANUAL
Level 1&2
RM-615
Transceiver characteristics
Band:
Quad Band GSM 850/900/1800/1900
Tri Band WCDMA 850/1700/2100, 3GPP Rel. 5
Display:
2.4” 240x320 16M colours TFT QVGA display
Camera:
3.2 Mpix
Operating System:
S40 6th edition
Connections:
3.5 mm AV connector
2.0 mm DC charger connector
MicroUSB 2.0 (with Mass Storage support)
DVB-H (Mobile TV Edition only)
Bluetooth: 2.1 + EDR
Transceiver with BL-4U battery pack
Talk time Standby
GSM:
Up to 5.3 hours
WCDMA:
Up to 4.0 hours
Mobile TV playing time 6 hours
GSM:
Up to 408 hours
WCDMA:
Up to 408 hours
Note:
Talk times are dependant on network parameters and
phone settings
1 Confidential Copyright © 2010 NOKIA All rights reserved Version 1.0 ISSUE 1
Page 2
Nokia 5330 / 5330 Mobile TV Edition
RM-615
Service Manual Level 1&2
Table of contents
1. Change history ........................................................................................................................................................................... 3
2. Copyright ..................................................................................................................................................................................... 4
3. Warnings and cautions ........................................................................................................................................................... 5
3.1 Warnings ............................................................................................................................................................................ 5
3.2 Cautions .............................................................................................................................................................................. 5
4. ESD protection ........................................................................................................................................................................... 6
5. Care and maintenance ............................................................................................................................................................ 7
6. Battery information ................................................................................................................................................................. 8
7. Exploded view ........................................................................................................................................................................... 9
8. Service devices ........................................................................................................................................................................ 10
9. SW-update ................................................................................................................................................................................ 11
10. Disassembly instructions ................................................................................................................................................. 12
11. Assembly hints .................................................................................................................................................................... 18
12. Nokia 5530 Solder components .................................................................................................................................... 19
13. Nokia 5530 Mobile TV edition Solder components ................................................................................................. 20
2 Confidential Copyright © 2010 NOKIA All rights reserved Version 1.0 ISSUE 1
Page 3
Nokia 5330 / 5330 Mobile TV Edition
RM-615
Service Manual Level 1&2
1. CHANGE HISTORY
Status Version No. Date Comments
Approved 1.0 12.01.2010 First approved version
The purpose of this document is to help NOKIA service levels 1 and 2 workshop technicians to
carry out service to NOKIA products. This Service Manual is to be used only by authorized NOKIA
service suppliers, and the content of it is confidential. Please note that NOKIA provides also other
guidance documents (e.g. Service Bulletins) for service suppliers, follow these regularly and
comply with the given instructions.
While every endeavor has been made to ensure the accuracy of this document, some errors may
exist. If you find any errors or if you have further suggestions, please notify NOKIA using the
address below:
Nokia Care Academy
mailto:Service.Manuals@nokia.com
Please keep in mind also that this documentation is continuously being updated and modified,
so watch always out for the newest version.
3 Confidential Copyright © 2010 NOKIA All rights reserved Version 1.0 ISSUE 1
Page 4
2. COPYRIGHT
Copyright © 2009 Nokia. All rights reserved.
Reproduction, transfer, distribution or storage of part or all of the contents in this document in
any form without the prior written permission of Nokia is prohibited.
Nokia, Nokia Connecting People, and Nokia X and Y are trademarks or registered trademarks of
Nokia Corporation. Other product and company names mentioned herein may be trademarks or
tradenames of their respective owners.
Nokia operates a policy of continuous development. Nokia reserves the right to make changes
and improvements to any of the products described in this document without prior notice.
Under no circumstances shall Nokia be responsible for any loss of data or income or any special,
incidental, consequential or indirect damages howsoever caused.
The contents of this document are provided “as is”. Except as required by applicable law, no
warranties of any kind, either express or implied, including, but not limited to, the implied
warranties of merchantability and fitness for a particular purpose, are made in relation to the
accuracy, reliability or contents of this document. Nokia reserves the right to revise this
document or withdraw it at any time without prior notice.
The availability of particular products may vary by region.
IMPORTANT
This document is intended for use by qualified service personnel only.
Nokia 5330 / 5330 Mobile TV Edition
RM-615
Service Manual Level 1&2
4 Confidential Copyright © 2010 NOKIA All rights reserved Version 1.0 ISSUE 1
Page 5
3. WARNINGS AND CAUTIONS
Please refer to the phone’s user guide for instructions relating to operation, care and
maintenance including important safety information. Note also the following:
3.1 Warnings
1. CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH ELECTRONIC ENGINE
MANAGEMENT SYSTEMS AND ANTI–SKID BRAKING SYSTEMS. UNDER CERTAIN FAULT CONDITIONS,
EMITTED RF ENERGY CAN AFFECT THEIR OPERATION. IF NECESSARY, CONSULT THE VEHICLE
DEALER/MANUFACTURER TO DETERMINE THE IMMUNITY OF VEHICLE ELECTRONIC SYSTEMS TO RF
ENERGY.
2. THE HANDPORTABLE TELEPHONE MUST NOT BE OPERATED IN AREAS LIKELY TO CONTAIN
POTENTIALLY EXPLOSIVE ATMOSPHERES, EG PETROL STATIONS (SERVICE STATIONS), BLASTING
AREAS ETC.
Nokia 5330 / 5330 Mobile TV Edition
RM-615
Service Manual Level 1&2
3. OPERATION OF ANY RADIO TRANSMITTING EQUIPMENT, INCLUDING CELLULAR TELEPHONES, MAY
3.2 Cautions
1. Servicing and alignment must be undertaken by qualified personnel only.
2. Ensure all work is carried out at an anti–static workstation and that an anti–static wrist
3. Use only approved components as specified in the parts list.
4. Ensure all components, modules screws and insulators are correctly re–fitted after servicing
5. Ensure all cables and wires are repositioned correctly
INTERFERE WITH THE FUNCTIONALITY OF INADEQUATELY PROTECTED MEDICAL DEVICES. CONSULT
A PHYSICIAN OR THE MANUFACTURER OF THE MEDICAL DEVICE IF YOU HAVE ANY QUESTIONS.
OTHER ELECTRONIC EQUIPMENT MAY ALSO BE SUBJECT TO INTERFERENCE.
strap is worn.
and alignment.
5 Confidential Copyright © 2010 NOKIA All rights reserved Version 1.0 ISSUE 1
Page 6
4. ESD PROTECTION
Nokia 5330 / 5330 Mobile TV Edition
RM-615
Service Manual Level 1&2
Nokia requires that service points have sufficient ESD protection (against static
electricity) when servicing the phone.
Any product of which the covers are removed must be handled with ESD
protection. The SIM card can be replaced without ESD protection if the product
is otherwise ready for use.
To replace the covers ESD protection must be applied.
All electronic parts of the product are susceptible to ESD. Resistors, too, can be
damaged by static electricity discharge.
All ESD sensitive parts must be packed in metallized protective bags during
shipping and handling outside any ESD Protected Area (EPA).
Every repair action involving opening the product or handling the product
components must be done under ESD protection.
ESD protected spare part packages MUST NOT be opened/closed out of an ESD
Protected Area.
For more information and local requirements about ESD protection and ESD
Protected Area, contact your local Nokia After Market Services representative.
6 Confidential Copyright © 2010 NOKIA All rights reserved Version 1.0 ISSUE 1
Page 7
5. CARE AND MAINTENANCE
This product is of superior design and craftsmanship and should be treated with care. The
suggestions below will help you to fulfil any warranty obligations and to enjoy this product for
many years.
Keep the phone and all its parts and accessories out of the reach of small children.
Keep the phone dry. Precipitation, humidity and all types of liquids or moisture can
contain minerals that will corrode electronic circuits.
Do not use or store the phone in dusty, dirty areas. Its moving parts can be
damaged.
Do not store the phone in hot areas. High temperatures can shorten the life of
electronic devices, damage batteries, and warp or melt certain plastics.
Nokia 5330 / 5330 Mobile TV Edition
RM-615
Service Manual Level 1&2
Do not store the phone in cold areas. When it warms up (to its normal temperature),
moisture can form inside, which may damage electronic circuit boards.
Do not drop, knock or shake the phone. Rough handling can break internal circuit
boards.
Do not use harsh chemicals, cleaning solvents, or strong detergents to clean the
phone.
Do not paint the phone. Paint can clog the moving parts and prevent proper
operation.
Use only the supplied or an approved replacement antenna. Unauthorised antennas,
modifications or attachments could damage the phone and may violate regulations
governing radio devices.
All of the above suggestions apply equally to the product, battery, charger or any accessory.
7 Confidential Copyright © 2010 NOKIA All rights reserved Version 1.0 ISSUE 1
Page 8
6. BATTERY INFORMATION
Note: A new battery’s full performance is achieved only after two or three complete charge and
discharge cycles! The battery can be charged and discharged hundreds of times but it will
eventually wear out.
When the operating time (talk-time and standby time) is noticeably shorter than normal, it is
time to buy a new battery. Use only batteries approved by the phone manufacturer and
recharge the battery only with the chargers approved by the manufacturer.
Unplug the charger when not in use. Do not leave the battery connected to a charger for longer
than a week, since overcharging may shorten its lifetime.
If left unused a fully charged battery will discharge itself over time Temperature extremes can
affect the ability of your battery to charge.
For good operation times with Ni-Cd/NiMh batteries, discharge the battery from time to time by
leaving the product switched on until it turns itself off (or by using the battery discharge facility
of any approved accessory available for the product).
Do not attempt to discharge the battery by any other means Use the battery only for its
intended purpose.
Never use any charger or battery which is damaged.
Do not short-circuit the battery. Accidental short-circuiting can occur when a metallic object
(coin, clip or pen) causes direct connection of the + and - terminals of the battery (metal strips
on the battery) for example when you carry a spare battery in your pocket or purse.
Shortcircuiting the terminals may damage the battery or the connecting object.
Leaving the battery in hot or cold places, such as in a closed car in summer or winter conditions,
will reduce the capacity and lifetime of the battery. Always try to keep the battery between 15°C
and 25°C (59°F and 77°F).
A phone with a hot or cold battery may temporarily not work, even when the battery is fully
charged. Batteries’ performance is particularly limited in temperatures well below freezing.
Do not dispose batteries in a fire! Dispose of batteries according to local regulations (e.g.
recycling).
Do not dispose as household waste.
Nokia 5330 / 5330 Mobile TV Edition
RM-615
Service Manual Level 1&2
8 Confidential Copyright © 2010 NOKIA All rights reserved Version 1.0 ISSUE 1
Page 9
7. EXPLODED VIEW
A-COVER MODULE
A1
(I0001 - I0002)
Nokia 5330 / 5330 Mobile TV Edition
RM-615
Service Manual Level 1&2
A-COVER
I0001
EARPIECE M STOUT
LCD AM 240x320 Brixton
I0002
I0004
CARE SLIDE MODULE ASSY
A2
(I0101 - I0102)
SCREW
I0005
3CU Engine Module
A3
(I0202 - I0205)
PWB
I0203
DOCKING FLEX MOD FOR CARE
DECOPLATE ASSEMBLY
I0206
I0208
D-COVER ASSY
A5
(I0211 - I0213)
CAMERA MODULE
I0207
FUNCTION KEYPAD
I0003
UI FLEX MODULE ASSY
I0101
SLIDEMODULEASSY
I0102
NUMERIC KEYPAD
I0201
DOME SHEET NUMERIC
I0202
BB-SHIELD LID
I0204
TYPE LABEL
I0205
ANTENNA MODULE ASSY
A4
(I0209 - I0210)
IHF SPEAKER
I0210
ANTENNA MODULE
I0209
VOLUME KEY PWB ASSY
Ver. 1.0
9 Confidential Copyright © 2010 NOKIA All rights reserved Version 1.0 ISSUE 1
I0212
DC JACK
I0211
SCREW
I0214
Only available as
assembly
D-COVER
I0213
F-COVER ASSY
I0215
These parts can not be
reused after removal
Page 10
8. SERVICE DEVICES
Nokia 5330 / 5330 Mobile TV Edition
RM-615
Service Manual Level 1&2
FLS-5 Flash Device
CA-101 Service Cable
AC-8 Travel Charger
BL-4U Battery
SS-88 Camera removal tool
NMP standard toolkit (v2)
For more information, refer to the
Service Bulletin (SB-011) on NOKIA
Online. Supplier or manufacturer
contacts for tool re-order can be
found in “Recommended service
equipment” document on NOKIA
Online.
10 Confidential Copyright © 2010 NOKIA All rights reserved Version 1.0 ISSUE 1
Page 11
9. SW-UPDATE
Flash concept- (Point of Sales)
To use the FLS-5 Flash Dongle, follow the user guide inside the sales package.
Please check always for the latest version of flash software, wich is available on Nokia Online.
Nokia 5330 / 5330 Mobile TV Edition
RM-615
Service Manual Level 1&2
11 Confidential Copyright © 2010 NOKIA All rights reserved Version 1.0 ISSUE 1
Page 12
10. DISASSEMBLY INSTRUCTIONS
Nokia 5330 / 5330 Mobile TV Edition
RM-615
Service Manual Level 1&2
1) Nokia 5530 and 5330 Mobile TV Edition
disassembly.
3) To remove the F-COVER ASSY first release the two
clips on the top side of the cover.
2) You must use the Nokia Standard Toolkit version
2. You will also need the SS-88 camera removal tool
and the 2 mm charger plug.
4) Remove the F-COVER ASSY.
5) Open the USB door. 6) Unscrew the six TORX + size 6 screws in the order
shown. Do not use them again.
12 Confidential Copyright © 2010 NOKIA All rights reserved Version 1.0 ISSUE 1
Page 13
Nokia 5330 / 5330 Mobile TV Edition
RM-615
Service Manual Level 1&2
7) Use the SS-93 to detach the snaps of DECOPLATE
ASSEMBLY on back side. Remove the DECOPLATE
8) Push the ANTENNA MODULE ASSY slightly towards
the engine board and detach the D-COVER ASSY.
ASSEMBLY.
9) Remove the D-COVER ASSY. 10) Use a DC plug to lift up the DC JACK.
11) Remove ANTENNA MODULE ASSY. 12) Carefully turn over the DOCKING FLEX MODULE to
gain acces to the connector underneath.
13 Confidential Copyright © 2010 NOKIA All rights reserved Version 1.0 ISSUE 1
Page 14
Nokia 5330 / 5330 Mobile TV Edition
RM-615
Service Manual Level 1&2
13) Open the DOCKING FLEX MODULE connector with
the SS-93.
Be careful not to damage the connector or the
components nearby!
15) Open the UI FLEX connector with the SS-93.
Be careful not to damage the connector or the
components nearby!
14) Use the camera removal tool SS-88, to detach
the CAMERA. Lift up the SS-88 and remove the
camera.
16) Move the slide to the opposite position.
17) Use the SS-93 to release the four clips holding
the NUMERIC KEYPAD.
18) The NUMERIC KEYPAD is glued to the engine
board. While removing the keypad be careful not to
damage the components on the engine board! The
NUMERIC KEYPAD has always to be renewed.
14 Confidential Copyright © 2010 NOKIA All rights reserved Version 1.0 ISSUE 1
Page 15
Nokia 5330 / 5330 Mobile TV Edition
Service Manual Level 1&2
19) Remove the engine board. 20) Unscrew the two TORX + size 4 screws in the
order shown. Do not use them again.
RM-615
21) Move the slide to the opposite position. 22) Start detaching the A-COVER MODULE from the
middle of the device. Slide the SRT-6 along the edge
to release the clips holding the A-COVER MODULE.
23) Release also the clips on the other side of the
device.
24) While removing the A-COVER MODULE, take care
of the clips on bottom side.
15 Confidential Copyright © 2010 NOKIA All rights reserved Version 1.0 ISSUE 1
Page 16
Nokia 5330 / 5330 Mobile TV Edition
RM-615
Service Manual Level 1&2
25) Use the SS-93 to open the LCD connector. Be
careful not to damage the connector!
27) Slide the SS-93 to direction shown to detach the
bottom end of the LCD.
26) Carefully start to detach the LCD from the shown
place with the SS-93.
28) Carefully push the SS-93 under the LCD to detach
the LCD completely. Lift up the LCD as shown. Be
careful not to damage the UI FLEX underneath the
LCD!
29) Remove the LCD. The LCD cannot be used again.
Discard it.
30) Separate the FUNCTION KEYPAD from the ACOVER MODULE by pressing the keypad slightly
through the A-COVER MODULE. The FUNCTION KEYPAD
must always be renewed.
16 Confidential Copyright © 2010 NOKIA All rights reserved Version 1.0 ISSUE 1
Page 17
Nokia 5330 / 5330 Mobile TV Edition
RM-615
Service Manual Level 1&2
31) Use the dental tool to lift up the EARPIECE.
Be aware of the sharp point of the dental tool - be
careful not to injure yourself.
33) Use the dental tool to release the EARPIECE
ADHESIVE.
32) Remove the EARPIECE with the tweezers. The
EARPIECE cannot be used again.
34) Remove the EARPIECE ADHESIVE with the
tweezers. The EARPIECE ADHESIVE cannot be used
again.
35) Nokia 5330 Mobile TV Edition disassembly is
now complete.
-END OF DISASSEMBLY-
17 Confidential Copyright © 2010 NOKIA All rights reserved Version 1.0 ISSUE 1
Page 18
11. ASSEMBLY HINTS
Nokia 5330 / 5330 Mobile TV Edition
RM-615
Service Manual Level 1&2
1) Tighten the six TORX + size 6 screws to the
torque of 20 Ncm in the order shown.
2) Tighten the six TORX + size 6 screws to the
torque of 20 Ncm in the order shown.
18 Confidential Copyright © 2010 NOKIA All rights reserved Version 1.0 ISSUE 1
Page 19
12. NOKIA 5530 SOLDER COMPONENTS
TOP
Nokia 5330 / 5330 Mobile TV Edition
Service Manual Level 1&2
V2492
V2496
RM-615
V2494
F2050 X2500
X2491
X3200
BOTTOM
V2491
V2497
V2495
S2500
Ver. 1.0
19 Confidential Copyright © 2010 NOKIA All rights reserved Version 1.0 ISSUE 1
Page 20
13. NOKIA 5530 MOBILE TV EDITION SOLDER COMPONENTS
TOP
Nokia 5330 / 5330 Mobile TV Edition
Service Manual Level 1&2
V2492
V2496
RM-615
V2494
F2050 X2500
X2491
X3200
BOTTOM
V2491
V2497
V2495
F2001
Ver. 1.0
20 Confidential Copyright © 2010 NOKIA All rights reserved Version 1.0 ISSUE 1
S2500
Loading...