Mitsubishi MBP15G, MBP30G, MBP20G, MBP40G, MBP20H Operator's Manual

GASOLINE WATER PUMP

IMPORTANT – Please make certain that
persons who are to use this equipment
thoroughly read and understand these
instructions and any additional instructions
provided prior to operation.

NOTE:
No refund or exchange once gasoline is placed
into the fuel tank.Warranty registration must be
complete within 30 days of purchase with proof
of purchase.

MBP15G
MBP20G
MBP30G
MBP40G
MBP20H
MBP30T

Operator’s Manual

TABLE OF CONTENTS

SAFTEY INSTRUCTIONS

● Warning Labels

2-3

3

FEATURES, ASSEMBLY AND ACCESSORIES 4

BEFORE OPERATION 5

OPERATING THE WATER PUMP 6

MAINTENANCE 7-8

STORAGE 8

TROUBLE SHOOTING 9

SPECIFICATIONS 10

PERFORMANCE CURVE 11

LIMITED WARRANTY 13

DANGER WARNING CAUTION

DANGER indicates a potenally
hazardous situaon which, if not
avoided, WILL result in death or
serious injury.

SAFETY INSTRUCTIONS

WARNING indicates a potenally
hazardous situaon which, if not
avoided, could result in death or
serious injury.

CAUTION indicates a potenally
hazardous situaon which, if not
avoided, may result in minor or
moderate personal injury, or
property damage.

WARNING

To reduce the risk of serious injury or even death,
read the following safety precauons and operang
instrucons before operang.

DANGER

Using a water pump indoors WILL KILL YOU IN MINUTES

Engine exhaust contains carbon monoxide.
This is a poison you cannot see or smell.
NEVER use inside a home or garage, even IF doors
and windows are open; only use OUTSIDE and far
away from windows, doors and vents.

DANGER

FUEL IS HIGHLY FLAMMABLE AND EXPLOSIVE

Always turn off the engine before adding fuel. Hot
engine parts, sparks or cigarees can ignite
gasoline. Store fuel away from water pump.
Never refuel while smoking or in the vicinity of an
open flame.
Take care not to spill any fuel on the engine or
muffler when refueling.
Before transporng the water pump in a vehicle,
drain all fuel to prevent leakage that may occur.
Store the water pump in a well venlated area
with the fuel tank empty.

WARNING

Starter and other rotang parts can entangle hands,
hair, clothing, or accessories.

Do not wear loose clothing, jewelry, or anything
that may be caught in the starter or other
rotang parts.
Tie up long hair when operang the water pump.

WARNING

KEEP CHILDREN AND PETS AWAY

Keep bystanders, especially children and pets, at
least 50 feet (15m) from the water pump. Do not let

15m

children touch the water pump. When not in use,
the water pump should be stored in a dry, locked
locaon, out of reach of children.

CAUTION

HEAVY LOAD

Use proper liing techniques when transporng the
water pump from site to site. Improper liing
techniques may result in personal injury.

WARNING

ENGINE AND MUFFLER MAY BE HOT

Contact with muffler area can result in serious burns.
Exhaust heat/gases can ignite combusbles,
structures or damage fuel tank causing a fire.

DO NOT touch hot parts and AVOID hot exhaust
gases. Allow equipment to cool before touching.

- 2 -

CAUTION

Improper treatment can damage the unit and shorten its life

Be sure pump chamber is filled with water before starng the
engine. NEVER run pump without priming.

• Use a non-collapsible hose on the sucon side of the pump.

• Use water pump only for intended uses.

• Not suitable for pumping sea water, beverages, acids, chemical
soluons, or any other liquid, other than clean water.

• DO NOT obstruct the sucon or discharge hose in any way.

• NEVER operate pump without strainer basket connected to end
of sucon hose.

• DO NOT exceed sucon head (see Specificaon). Use shortest
sucon head possible.

• NEVER allow vehicles to drive over hoses. If a hose must be
posioned across a roadway, use planking on each
side of hose to allow vehicles to pass over without obstrucng or
collapsing hose.

• Posion pump to avoid “walking” or equipment movement,
especially if located near a ditch or edge of open ravine. The
equipment could fall in.

• Keep equipment away from edge of river or lake where it could
cause the bank to collapse.

• DO NOT insert any objects through cooling slots.

NOTICE

Engine oil is hazardous to the environment

Be very careful when changing the oil to prevent spilling onto the
ground. Even if it is washed away, it will not mix with water and
will pollute the watershed—having a negave impact on the
plants and animals that it comes in contact with.
When disposing of engine oil:

1. While changing the engine oil, place a drip pan under the oil
plug to collect the waste.

2. Soak up any spills with sawdust, kiy lier, or sand. NEVER
dump down the drain or sewer.

3. Take the oil and filter to an oil recycling center.

Warning Labels

CAUTION

Fully prime the pump and check all
connections for leakage before starting
this engine.

WARNNING

Fuel is flammable and explosive.
NEVER fuel a running or hot engine.
Ensure there are no fuel leaks before
starting.
Keep sources of sparks and flames
away.
Clean up fuel spills immediately.
Aways keep a fire extinguisher nearby.

DANGER

Do not use the water pump in an
enclosed area, exhaust fumes can
KILL.

- 3 -