Members Mark Cg2036001-mm Owner's Manual
Traditional Barrel BBQ Grill
Owner’s Manual
Assembly and Operating Instructions
Model # CG2036001-MM
Tools required for assembly: (Not Included)
Pliers, Philips & Flathead Screwdrivers, Adjustable Wrench.
Keep this manual for future reference.
CG2036001-MM Eng Page 1 of 24 20121008 V.1
WARNING
l Only use this grill on a hard, level, non-combustible, stable surface (concrete, ground, etc.) capable of
supporting the weight of the grill. Never use on wooden or other surfaces that could burn.
l DO NOT use grill without charcoal ash tray in place. DO NOT attempt to remove charcoal ash tray while coals
are hot.
l When grill is in use, keep clearance of 36” between the hot grill and any combustible materials, such as
bushes, trees, wooden decks, wooden fences, buildings, etc. Do not place hot grill under roof overhang or in
any other enclosed area.
l For outdoor use only. Do not operate grill indoors or in an enclosed area.
l For household use only. Do not use this grill for other than its intended purpose.
l We recommend the use of a Charcoal chimney starter to avoid the dangers associated with charcoal lighting
fluid. If you choose to use charcoal lighting fluid, only use lighting fluid approved for lighting charcoal. Carefully
read manufacturer’s warnings and instructions on the charcoal lighting fluid and charcoal prior to the use of
their product. Store charcoal lighting fluid safely away from grill.
l When using charcoal lighting fluid, allow charcoal to burn with grill lid and doors open until covered with a light
ash (approximately 20 minutes). This will allow charcoal lighting fluid to burn off. Failure to do this could trap
fumes from charcoal lighting fluid in grill and may result in a flash fire or explosion when lid is opened.
l Never use charcoal that has been pre-treated with lighting fluid. Use only a high grade plain charcoal or
charcoal / wood mixture.
l Do not use gasoline, kerosene or alcohol for lighting charcoal. Use of any of these or similar products could
cause an explosion possibly leading to severe bodily injury.
l Never add charcoal lighting fluid to hot or even warm coals as flashback may occur causing severe burns.
l Place grill in an area where children and pets cannot come into contact with unit. Close supervision is
necessary when grill is in use.
l Do not leave grill unattended when in use.
l When adding charcoal and / or wood, use extreme caution and follow instructions in “Adding Charcoal / Wood
During Cooking” section of this manual.
l Do not store or use grill near gasoline or other flammable liquids, gases or where flammable vapors may be
present.
l Do not store lighter fluid or other flammable liquids or materials under the grill.
l Use caution when adjusting charcoal grate height, use oven mitt. Handle will be hot when in use.
l Never raise or lower charcoal grate when water smoking as hot water may splash on to coals creating a burst
of hot steam and coals.
Grill is hot when in use. To avoid burns:
l DO NOT attempt to move the grill.
l Wear protective gloves or oven mitts.
l DO NOT touch any hot grill surfaces.
l
DO NOT wear loose clothing or allow hair to come in contact with grill.
!
!
CG2036001-MM Eng Page 2 of 24 20121008 V.1
WARNING
l When grilling, grease from meat may drip into the charcoal and cause a grease fire. If this should happen close
lid to suffocate the flame. Do not use water to extinguish grease fires.
l Use caution when opening the lid, keep hands, face and body a safe distance away. Flash flare ups may occur
when air comes into contact with fire or hot coals.
l Never place more than 6 pounds (2.7 kg) on side and front tables. Do not lean on the side tables. Always
ensure side tables are securely fastened.
l Do not allow charcoal and/or wood to rest on the walls of grill. Doing so will greatly reduce the life if the metal
and finish of your grill.
l Use caution during assembly and while operating your grill to avoid scrapes or cuts from sharp edges of metal
parts. Use caution when reaching into or under grill.
l When opening lid, be sure lid is fully opened and secure to prevent lid from closing unexpectedly.
l In windy weather, place grill in an outdoor area that is protected from the wind.
l Close lid to suffocate flame.
l Never leave coals and ashes in grill unattended, before grill can be left unattended, remaining coals and ashes
must be removed from grill. Use caution to protect yourself and property, carefully place remaining coals and
ashes in a non-combustible metal container and saturate completely with water, allow coals and water to
remain in metal container 24 hours prior to disposing.
l Extinguished coals and ashes should be placed a safe distance from all structure and combustible materials.
l With a garden hose completely wet the surface beneath and around grill to extinguish any ashes, coals or
embers which may have fallen during the cooking or cleaning process.
l After each use, clean the grill thoroughly and apply a light coat of vegetable oil to prevent rusting. Cover the
grill to protect it from excessive rusting.
l Use caution when lifting or moving grill to prevent strains and back injuries.
l We advise that a fire extinguisher be on hand. Refer to your local authority to determine proper size and type of
fire extinguisher.
l Store the grill out of reach of children and in a dry location when not in use.
l Do not attempt to services grill other than normal maintenance as explained in “After-Use Safety” and “Proper
Care & Maintenance” sections of this manual.
l Properly dispose of all packaging material
Use caution and common sense when operating your grill,
Failure to adhere to safety warning and guidelines in this manual could result in bodily injury or property damage.
Save this manual for future reference.
!
!
CG2036001-MM Eng Page 3 of 24 20121008 V.1
ASSEMBLY INSTRUCTIONS
THANK YOU FOR PURCHASING THIS BARREL GRILL
Read all safety warnings & assembly instructions carefully before assembling or operating your grill.
For missing parts, please call customer service at CustomerService@Rankam.com or at 888-837-1380 (U.S. only)
(Proof of purchase will be required.)
Inspect contents of the box to ensure all parts are included and undamaged.
We recommend two people for assembly of this grill.
The following tools are required for assembly and are not included:
l Pliers
l Philips & Flathead Screwdrivers
l Adjustable Wrench
CG2036001-MM Eng Page 4 of 24 20121008 V.1
Product Diagram
CG2036001-MM Eng Page 5 of 24 20121008 V.1
Component List
1. Left rear leg
2. Right rear leg
3. Right front leg
4. Left front leg
1 pc
1 pc
1 pc
1 pc
5. Grill Body
6. Wheel
7. Axle
8. Bottom rack
1 pc
2 pcs
1 pc
1 pc
9. Charcoal Grate Clip
10. Air Vent
11. Lower Hinge
12. Side Shelf
2 pcs
2 pcs
2 pcs
1 pc
13. Front table slate
14. Right front table
support
15. Left front table
support
16. Temperature Gauge
2 pcs
1 pc
1 pc
1 pc
CG2036001-MM Eng Page 6 of 24 20121008 V.1
CG2036001-MM Eng Page 7 of 24 20121008 V.1
17. Chimney
18. Chimney Cover
19. Lid
20. Lid Handle
1 pc
1 pc
1 pc
1 pc
21. Lid Hinge
22. Warming Rack
23. Grease cup holder
24. Charcoal Grate
2 pcs
1 pc
1 pc
1 pc
25. Charcoal Grate
Handle
26. Cooking Grid
1 pc
3 pcs
STOP!
For assembly assistance, missing or damaged parts, please contact customer service at
CustomerService@Rankam.com or at 1-888-837-1380.
DO NOT RETURN TO RETAILER.
Hardware List
A
Bolt (M8X15)
4 pcs
B
Bolt (M8X12)
8 pcs
C
Bolt (M6X30)
8 pcs
D
Bolt (M6X12)
30 pcs
E
Lock Nut (M10)
2 pcs
F
Nut (M8)
16 pcs
G
Cap Nut (M8)
1 pc
H
Nut (M6)
10 pcs
I
Lock Nut (M6)
10 pcs
J
Cap Nut (M6)
2 pcs
K
Cap Nut (M5)
2 pcs
L
Flange Nut (M6)
2 pcs
M
Hinge Pin
2 pcs
N
Cotter Pin
2 pcs
O
Lid Handle Insulation
Washer
2 pcs
P
Wheel Washer
2 pcs
Q
Charcoal Grate Handle
Insulation Washer
2 pcs
R
Spring
1 pc
CG2036001-MM Eng Page 8 of 24 20121008 V.1
Loading...