Grill Guide
For Model BQ05046-6
Professional Liquid Propane Gas Grill Island
STOP!
Missing A Part? No Need
Back To The Store!
The store where you made the purchase does not stock parts for this item. If you need parts, whether they are
missing or damaged, please call Toll Free Help Line 1-800-933-0527. Call us between 8:30 AM and 5:00 PM Central Time, Monday through Friday.
FOR YOUR SAFETY:
1.Read this Grill Guide before attempting to assemble or operate your grill.
2.Follow all safety instructions.
3.Check for leaks according to directions in this Grill Guide before operating your grill, even if purchasing an assembled grill.
4.Keep this Grill Guide for future reference.
5.Contact 1-800-933-0527 should you need assembly assistance or have any questions.
THIS GRILL IS FOR OUTDOOR USE ONLY.
If stored indoors, then detach and leave propane cylinder outside.
TO THE INSTALLER OR PERSON ASSEMBLYING THIS GRILL:
Leave this Grill Guide with the consumer.
TO THE CONSUMER:
Retain this Grill Guide for future reference.
Safety Precautions
Always read and follow all DANGER, WARNING, AND FOR YOUR SAFETY notices in this Grill Guide. Failure to do may result in serious bodily injury or death, or in a fire or an explosion causing damage to property.
1.Grill installation must conform with local codes, or in their absence, with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code, B149.2.
2.This gas grill, when installed, must be electrically grounded in accordance with local codes, or, in the absence of local codes, with the National Electrical Code, ANSI/NFPA 70, or the Canadian Electrical Code, CSA C22.1.
3.This gas grill shall be used outdoors only, and shall not be used in a building, garage, or any other enclosed area.
4.This gas grill is not intended to be installed in or on recreational vehicles and/or boats.
5.Never use any other type of fuel for this grill other than LP gas.
6.Only use the pressure regulator with a type 1 connector that is supplied with this gas grill.
7.Before each use, check the gas hose for excessive abrasion or wear, or cuts. Replace a hose assembly showing those signs with the hose assembly specified in the parts list before using the grill.
!WARNING
1.Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
2.An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.
!DANGER
If you smell gas:
1.Shut off gas to the appliance.
2.Extinguish any open flame.
3.Open lid.
4.If odor continues, keep away from the appliance, and immediately call your gas supplier or your fire department.
!WARNING
Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, and other reproductive harm.
Table of Contents
Safety Precautions……….……………………………..……………...…………...…… 2
Table of Contents…………………….…………………………………..……….……...3
Warranty……………………………….………………………………………….…….. 4
Customer Support Center……………….………………………………………….…….4
Assembly Instructions...…………………………………………………………..…..5-12
General Information and Operation………………..………………………………..13-23
Trouble Shooting Guide……………………………………………….................……..24
Frequently Asked Questions……………………………………………………………25
Write down here and keep for future reference
Date of Purchase: _________________
Serial Number: ___________________
The serial number may be found on the placard located on the back of the grill
BQ05046-6
Sam’s Club
608 Southwest 8th Street
Bentonville, AR 72712
1-888-746-7726
Visit us at: www.samsclub.com
3
Limited Warranty
The manufacturer warrants to the original consumer-purchaser that this product shall be free from defects in workmanship and materials under normal and reasonable use when assembled and operated according to this Grill Guide from date of purchase as follows:
One year except as noted below: Stainless Steel Burners – 3 years
Stainless Steel Parts except Burners, Grates, Warming Rack, and Heat Diffusers - 5 years
The manufacturer will, at its option, refinish or replace any product or part found to be defective during the limited warranty period. There may be a shipping charge. The manufacturer may require you to return the part(s) claimed to be defective for its inspection, freight or postage prepaid. Contact our Customer Support Center as shown below before returning any part(s).
Additional information can be obtained by writing:
Barbecue Grills
Warranty Dept.
1375 Mitchell Blvd
Schaumburg, IL 60193
The manufacturer will require reasonable proof of purchase. We strongly recommend you keep your sales receipt and register your grill. You can attach your receipt to this guide.
This limited warranty does not cover the cost of any inconvenience or property damage due to failure of the product and does not cover damage due to misuse, abuse, alteration, improper or failure to perform normal and routine maintenance, discoloration, scratches, rust, accident, damage arising out of transportation of the product, or normal wear and tear. This limited warranty will not apply to any grill used for commercial use.
This limited warranty is the sole warranty given by the manufacturer and is in lieu of all other warranties; express or implied, including implied warranty of merchantability or fitness for a particular purpose. Neither manufacturer dealers nor the retail establishment selling this product have any authority to make any warranties or to promise remedies in addition to or inconsistent with those stated above.
This limited warranty applies only to products sold at retail, and is not transferable.
The manufacturer's maximum liability, in any event, shall not exceed the purchase price of the product paid by the original consumer-purchaser. Some states do not allow the exclusion or limitation of incidental or consequential damages. Therefore, the above limitations or exclusions may not apply to you. This warranty gives you specific legal rights and may also have other rights, which vary from state to state.
Customer Support Center
Thanks for purchasing a Member’s Mark Grill. We’re here to help you maximize your enjoyment and appreciation of your new grill. Please don’t hesitate to contact us should you have any questions regarding assembly, performance, warranty, or accessories. We have a full line of replacement parts available. Please have your model number ready before you contact us. We’re here to serve You!
•If you need assistance or to order parts: Call 1-800-933-0527 or send a FAX to 1-847-252-1001.
•Business hours: Monday through Friday; 8:30AM-5:00PM Central Time.
•Visit us on the web at: www.omahagrills.com
4
Assembly Instructions
This page will give you an overview of information to assemble your grill. The following pages will show in step-by-step detail how to do so. We offer the following suggestions to make your grill assembly as easy as possible.
1.) Read through the entire Assembly Instructions before you begin.
2.) Choose an area large enough to comfortably lay out all the parts and hardware with enough room to easily maneuver.
3.) Have an area with a non-abrasive surface where you can lay parts without scratching them.
4.) The Grill Island weighs in at close to 400 pounds. Use caution, and enough people, to remove the Grill Island from the carton and steel pallet on the bottom.
5.) Lay all parts and hardware out and ensure you have everything listed on the Parts and Hardware page before you begin assembly. See the Customer Support Page for contact information should any parts be damaged or missing.
6.) A Phillips Head Screwdriver has been provided for assembly. You should not need any additional tools.
7.) Do not use a Power Screwdriver for assembly as you could strip the threads on the Nuts and Bolts.
8.) The propane tank for this grill is sold separately. See the LP Gas and Cylinder Information later in this guide.
BQ05046-6
! WARNING
Failure to follow all Danger, Warnings, and For Your Safety notices in this Grill Guide may result in serious bodily injury or death, or in a fire or an explosion causing damage to property.
! CAUTION
Perform the Leak Test explained later in this Grill Guide before operating your grill.
5
BQ05046-6 Detail Parts List |
|
|
1. Thermometer |
55. Smoker Drawer Handle |
|
2. Stainless Steel Hood |
56. Burner Support Rail |
|
3. Hood Bolt |
57. Firebox – Back |
|
4. Silicon Stopper for Hood |
58. Heat Shield - Control Panel Outer |
|
5. Hood Handle |
59. Cabinet Right-Top-Back Panel |
|
6. Handle Connector - Left |
60. Cabinet Left-Top-Back Panel |
|
7. Handle Connector - Right |
61. Firebox Support – Right |
|
8. Firebox Rear Panel |
62. Cabinet Bottom Panel |
|
9. Rotisserie Spit Bracket |
63. Cabinet Right Side Skirt |
|
10. Firebox - Left Side Panel |
64. Glide Support |
|
11. Rotisserie Spit Support - Right |
65. Countertop Frame |
|
12. Rotisserie Spit Support - Left |
66. Firebox Support - Left |
|
13. Bottom Heat Shield |
67. Cabinet Left Side Skirt |
|
14. Rotisserie Motor Support |
68. Cabinet – Left Side Panel |
|
15. Firebox - Right Side Panel |
69. Caster |
|
16. Back Burner – Front Frame |
70. Locking Caster |
|
17. Heat Shield - Control Panel Inner |
71. Swivel Caster |
|
18. Electric Igniter |
72. Locking Swivel Caster |
|
19. Side Burner Lower Heat Shield |
73. Cabinet – Right Side Panel |
|
20. Control Panel |
74. Cabinet Left - Back Panel |
|
21. Control Knob |
75. Glide |
|
22. Control Knob Seat |
76. Cabinet Right - Back Panel |
|
23. Side Burner Electrode |
77. Right-Top Drawer |
|
24. Side Burner Air Shutter |
78. Glide Mounting Bracket - Right |
|
25. Side Burner Stem |
79. Glide Mounting Bracket - Left |
|
26. Side Burner Lower Heat Shield - Left Support |
80. Cylinder Tray |
|
27. Side Burner |
81. Cylinder Tray Handle |
|
28. Side Burner Inside Frame |
82. Right Front Cabinet Support |
|
29. Side Burner Grate |
83. Drawer Front Crossbar |
|
30. Side Burner Shelf Frame |
84. Center Front Cabinet Support |
|
31. Side Burner Cover |
85. Left Front Cabinet Support |
|
32. Rotisserie Motor |
86. Cabinet Crossbar |
|
33. Rotisserie Spit w/ Forks and Counterweight |
87. Right Control Panel Support |
|
34. Back Burner Cover |
88. Left Control Panel Support |
|
35. Side Burner Clapboard |
89. Left Top Drawer |
|
36. Back Burner Stem |
90. Ice Chest Handle |
|
37. Infrared Back Burner |
91. Ice Chest Exterior |
|
38. Flame Sensor |
92. Ice Chest Drawer |
|
39. Back Burner Electrode |
93. Ice Chest Liner |
|
40. Warming Rack |
94. Ice Chest Front Cover |
|
41. Cooking Grate |
95. Ice Chest Front Cover Handle |
|
42. Firebox Back-Top Plate |
96. Ice Chest Back Cover |
|
43. Heat Shield |
97. Left Bottom Door |
|
44. Granite Countertop Insert |
98. Bottom Drawer |
|
45. Grease Tray |
99. Right Bottom Door |
|
46. Grease Tray Handle |
100. Cabinet Back Panel Bracket |
|
47. Silicon Stopper for Countertop with Granite |
101. Cylinder Support Ring |
|
48. Heat Diffuser |
102. Manual Igniter |
|
49. "U" Main Burner |
103. Cabinet Shelf |
|
50. Gas Manifold Assembly |
104. Ice Chest Drain Plug |
|
51. Regulator and Hose |
105. Cabinet Front Skirt |
|
52. Smoker Drawer Cover |
106. Cabinet Shelf Support |
|
53. Smoker Drawer |
107. Cylinder Tray Stopper |
|
54. Smoker Drawer Front |
108. Electronic Igniter Button |
|
|
109. Paper Towel Roller |
6 |
Detail Parts List
7
BQ05046-6 Assembly Parts List
Heat Diffuser ---3 Pcs |
Cooking Grate ---3 Pcs |
Warming Rack --- 1 Pc |
||
Spit--- 1 Pc |
Meat Fork--- 2 Pcs |
Counterweight--- 1 Pc |
Rotisserie Motor ---1Pc |
|
|
BQ05046-6 Assembly Hardware List |
|
A. “AA” Size Battery – 1 Pc
C. Spit Handle – 1 Pc
B. Spit Washer – 2 Pcs
D. Spit Bushing – 1 Pc
8