Members Mark Bq51009 Owner's Manual

Grill Guide

For Model BQ05041-28 (BQ51009)

LP Gas Barbecue Grill

FOR YOUR SAFETY:

TO THE INSTALLER OR PERSON ASSEMBLYING THIS GRILL:

TO THE CONSUMER: Retain this G

1. Read this Grill Guide before attempting to assemble or operate your grill.

2. Follow all safety instructions.

3. Check for leaks according to directions in this Grill Guide before operating your grill, even if purchasing an assembled grill.

4. Keep this Grill Guide for future reference.

5. Contact 1-800-933-0527 should you need assembly assistance or have any questions.

Leave this Grill Guide with the consumer.

ill Guide for future reference.

THIS GRILL IS FOR OUTDOOR USE ONLY.

If stored indoors, then detach and leave propane cylinder outside.

Safety Precautions

Always read and follow all DANGER, WARNING, AND FOR YOUR SAFETY notices in this Grill Guide. Failure to do may result in serious bodily injury or death, or in a fire or an explosion causing damage to property.

1. Grill installation must conform with local codes or, in the absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code, B149.2.

2. This gas grill, when installed, must be electrically grounded in accordance with local codes or , in the absence of local codes, with the National Electrical Code, ANSI/NFPA 70, or the Canadian Electrical Code, CSA C22.1. This applies if an external electrical source is utilized.

3. This gas grill shall be used only outdoors, and not be used in a building, garage, or any other enclosed area.

4. This gas grill is not intended to be installed in or on recreational vehicles and/or boats.

5. Never use any other type of fuel for this grill other than LP gas.

6. Only use the pressure regulator with a type 1 connector that is supplied with this gas grill.

7. Inspect the gas hose before each use. If it is evident there is excessive abrasion or wear, or the hose is cut, it must be replaced prior to the gas grill being put into operation. The replacement hose assembly shall be that specified by the manufacturer.

8. Always perform a Leak Test before operating your grill.

FOR YOUR SAFETY

1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open lid.

4. If odor continues, immediately call your gas supplier or your fire department.

FOR YOUR SAFETY

WARNING

Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, and other reproductive harm.

Table of Contents

Safety Precautions……….……………………………..……………...…………...…… 2

Table of Contents…………………….…………………………………..……….……...3

Warranty……………………………….………………………………………….…….. 4

Customer Support Center……………….………………………………………….…….4

Assembly Instructions...…………………………………………………………..…..5-16

General Information and Operation………………..………………………………..17-26

Trouble Shooting Guide……………………………………………….................……..27

Frequently Asked Questions……………………………….................………………...28

Write down here and keep for future reference

Date of Purchase: _________________

Serial Number: ___________________

The serial number may be found on the placard located on the back of the grill

SHOP: WWW.KMART.COM

BQ05041-28 (BQ51009)

Kmart Corporation

Hoffman Estates, IL 60179

1-866-562-7848

The manufacturer warrants to the original consumer-purchaser that this product shall be free from defects in workmanship and materials under normal and reasonable use when assembled and operated according to this Grill Guide from date of purchase as follows:

One year except as noted below: Stainless Steel Burners – 3 years

Cast Aluminum and Stainless Steel Cabinet

Parts and Control Panel – 5 years

The manufacturer will, at its option, refinish or replace any product or part found to be defective during the limited warranty period. There may be a shipping charge. The manufacturer may require you to return the part(s) claimed to be defective for its inspection, freight or postage

prepaid. Contact our Customer Support Center as shown below before returning any part(s).

Additional information can be obtained by writing:

Barbecue Grills Warranty Dept.

1375 Mitchell Blvd

Schaumburg, IL 60193

The manufacturer will require reasonable proof of purchase. We strongly recommend you keep your sales receipt and register your grill. You can attach your receipt to this guide.

Thanks for purchasing a BBQ Pro Gas Grill. We’re here to help you maximize your enjoyment an appreciation of your new grill. Please don’t hesitate to contact us should you have any questions regarding assembly, performance, warranty, or accessories. Please have your model number ready before you contact us.

We’re here to serve You!

• If you need assistance or to order parts: Call □ 1-800-933-0527 or send a FAX to □ 1-847-252-1001.

• Business hours: Monday through Friday; 8:30AM-5:00PM Central Time.

• Visit us on the web at: www.omahagrills.com

Customer Support Center

Limited Warranty

This limited warranty does not cover the cost of any inconvenience or property damage due to failure of the product and does not cover damage due to misuse, abuse, alteration, improper or failure to perform normal and routine maintenance, discoloration, scratches, rust, accident, damage arising out of transportation of the product, or normal wear and tear. This limited warranty will not apply to any grill used for commercial use.

This limited warranty is the sole warranty given by the manufacturer and is in lieu of all other warranties; express or implied, including implied warranty of merchantability or fitness for a particular purpose. Neither manufacturer dealers nor the retail establishment selling this product have any authority to make any warranties or to promise remedies in addition to or inconsistent with those stated above.

This limited warranty applies only to products sold at retail, and is not transferable.

The manufacturer's maximum liability, in any event, shall not exceed the purchase price of the product paid by the original consumer-purchaser. Some states do not allow the exclusion or limitation of incidental or consequential damages. Therefore, the above limitations or exclusions may not apply to you. This warranty gives you specific legal rights and may also have other rights, which vary from state to state.

Assembly Instructions

This page will give you an overview of information to assemble your grill. The following pages will show in step-by-step detail how to do so. We offer the following suggestions to make your grill assembly as easy as possible.

1.) Read through the entire Assembly Instructions before you begin.

2.) Choose an area large enough to comfortably lay out all the parts and hardware with enough maneuver.

3.) Have an area with a non-abrasive surface where you can lay parts without scratching them.

4.) Use 2 people to remove the Cabinet and Firebox Assembly from the carton.

5.) Lay all parts and hardware out and ensure you have everything listed on the Parts and Hardware page before you begin assembly. See the Customer Support Page for contact information should any parts be damaged or missing.

6.) A Phillips Head Screwdriver has been provided for assembly.

7.) Do not use a Power Screwdriver for assembly as you could strip the threads on the Nuts and Bolts.

8.) The propane tank for this grill is sold separately. See the LP Gas and Cylinder Information later in this guide.

room to easily

BQ05041-28 (BQ51009)

WARNING

Failure to follow all Danger, Warnings, and For Your Safety notices in this Grill Guide may result in serious bodily injury o death, or in a fire or an explosion causin

Perform the Leak Test explained later in this Grill Guide before operating your grill.

damage to property.

CAUTION

BQ05041-28 (BQ51009) Detail Parts List

1 Thermometer & Thermometer Seat

2 Hood – Outer

3 Silicon Stopper

4 Logo Plate

5 Hood – Inner

6 Hood Bolt

7 Hood Side Panel – Left

8 Hood Side Panel – Right

9 Handle Support

10 Handle

11 Firebox-Left Side

12 Firebox – Right Side

13 Firebox – Upper Back

14 Gas Hose

15 Regulator and Hose

16 Warming Rack

17 Firebox – Lower Back

18 Cooking Grate – Small

39 Side Burner Shelf Frame

40 Side Burner Back Bracket

41 Side Burner Electrode

42 Side Burner Cover

43 Side Burner Pan Support

44 Side Burner Inside Frame

45 Side Burner Valve

46 Side Burner

47 Side Burner Air Shutter

48 Side Burner Front Bracket

49 Side Burner Front Panel

50 Serving Tray

51 Side Shelf Frame

52 Side Shelf Back Bracket

53 Side Shelf Front Panel Frame

54 Side Shelf Front Panel

55 Side Shelf Front Panel Handle

56 Cabinet Back Panel

19 Cooking Grate – Large 57 Cabinet Right Side Panel

20 Griddle 58 Cabinet Left Side Panel

59 Cabinet Door – Left

60 Cabinet Door Hinge

61 Cabinet Center Drawer Support

62 Cabinet Door Handle

63 Handle Support

64 Drawer

65 Cabinet Drawer Handle

66 Cylinder Support Ring

67 Cabinet Crossbar

68 Cabinet Bottom Panel

69 Locking Caster

70 Non-Locking Caster

71 Swivel Locking Caster

72 Swivel Non-Locking Caster

73 Electric Igniter Cap

74 Side Burner Cover Bolts

21 Heat Diffuser – Large

22 Heat Diffuser – Small

23 Burner Support Rail

24 Electrode – Main Burners

25 “U” Burner

26 “I” Burner

27 Heat Shield – Firebox

28 Heat Shield – Grease Tray

29 Heat Shield - Control Panel Inner

30 Gas Manifold Assembly

31 Heat Shield - Control Panel Outer

32 Control Panel

33 Control Knob Seat

34 Electric Igniter

35 Control Knob

36 Grease Tray

37. Handle Support 75 Name Plate

38. Grease Tray Handle 76 Silicon Pad

BQ05041-28 (BQ51009) Detail Parts List

Cabinet and Firebox Assembly..1PC

Heat Diffuser (large)…2PCS

Heat Diffuser (small)…1PC

Griddle…1PC

DO NOT DISPOSE OF BATTERIES IN FIRE. BATTERIES MAY EXPLODE OR LEAK.

Phillips Head Bolt M6*3/8”L

Phillips Head Bolt M4*5/16”L

Lock Washer M6

Assembly Parts List

Side Burner Assembly…1PC Side Shelf Assembly…1PC

Warming Rack…1PC Cooking Grate (large)…2PCS

Serving Tray...1PC

Cooking Grate (small)…1PC

WARNING

Hardware List

14PCS D Control Knob 1PC

2PCS E

14PCS F

Battery Size AA 1PC

Phillips Head Screwdriver 1PC

STEP 1

Attach the Side Burner Front Panel to the Side Burner Front Bracket using 3 Phillips Head Bolts (A) and 3 Lock Washers (C).

STEP 2

Loosely screw 2 Phillips Head Bolts (A) and 2 Lock Washers (C) into the upper left and right corner holes in the left side of the Firebox as shown in the insert. Leave them loose so that you can fit the Side Burner Assembly between the Firebox side and the head of the bolt. Remove the Phillips Head Bolt from the lower side corner of the Control Panel (Fig 1) and hold for Step 4. Now fit the Side Burner Front and Back Brackets down over the heads of the 2 Phillips Head Bolts (A) as shown.

Fig 1

+ 21 hidden pages

Members Mark Bq51009 Owner's Manual

Specifications and Main Features

Frequently Asked Questions

User Manual