Members Mark Bq05046-6-a Owner's Manual

Grill Guide

For Model BQ05046-6-A

Professional Liquid Propane Gas Island Grill

SAM'S CLUB does not stock parts for this item at the Club, but our grill team is here to

Call us between 8:30 AM to 5:00 PM Central Time, Monday through Friday.

Missing a part? No need to go back to SAM'S CLUB!

help you. If you need parts, whether they are missing or damaged,

please call Toll Free Help Line

Stop!

1-800-933-0527

FOR YOUR SAFETY:

1. Read this Grill Guide before attempting to
assemble or operate your grill.

2. Follow all safety instructions.

3. Check for leaks according to directions in this
Grill Guide before operating your grill, even if
purchasing an assembled grill.

4. Keep this Grill Guide for future reference.

5. Contact
assembly assistance or have any questions.

1-800-933-0527 should you need

THIS GRILL IS FOR OUTDOOR USE ONLY.

If stored indoors, then detach and leave propane cylinder outside.

TO THE INSTALLER OR PERSON ASSEMBLYING THIS GRILL:

Leave this Grill Guide with the consumer.

TO THE CONSUMER:

Retain this Grill Guide for future reference.

Safety Precautions

Always read and follow all DANGER, WARNING, AND FOR YOUR SAFETY notices in this Grill
Guide. Failure to do may result in serious bodily injury or death, or in a fire or an explosion causing
damage to property.

1. Grill installation must conform with local codes, or in their absence, with either the National Fuel
Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and Propane Installation Code, CSA B149.1, or
Propane Storage and Handling Code, B149.2.

2. This gas grill, when installed, must be electrically grounded in accordance with local codes, or, in
the absence of local codes, with the National Electrical Code, ANSI/NFPA 70, or the Canadian
Electrical Code, CSA C22.1.

3. This gas grill shall be used outdoors only, and shall not be used in a building, garage, or any other
enclosed area.

4. This gas grill is not intended to be installed in or on recreational vehicles and/or boats.

5. Never use any other type of fuel for this grill other than that specified on the name plate attached to
the grill or the cover of this Grill Guide.

6. Only use the pressure regulator with a type 1 connector that is supplied with this gas grill.

7. Before each use, check the gas hose for excessive abrasion or wear, or cuts. Replace a hose
assembly showing those signs with the hose assembly specified in the parts list before using the
grill.

1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or
any other appliance.

2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other
appliance.

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open lid.

4. If odor continues, keep away from the appliance, and immediately call your gas supplier or
your fire department.

WARNING

DANGER

WARNING

Combustion by-products produced when using this product contain chemicals known to the
State of California to cause cancer, birth defects, and other reproductive harm.

Table of Contents

Safety Precautions……….……………………………..……………...…………...…… 2

Table of Contents…………………….…………………………………..……….……...3

Warranty……………………………….………………………………………….…….. 4

Customer Support Center……………….………………………………………….…….4

Assembly Instructions...…………………………………………………………..…..5-13

General Information and Operation………………..………………………………..14-24

Trouble Shooting Guide……………………………………………….................……..25

Frequently Asked Questions……………………………………………………………26

Write down here and keep for future
reference

Date of Purchase: _________________

Serial Number: ___________________

The serial number may be found on the placard located
on the back of the grill

Visit us at: www.samsclub.com

Retailer :

Address :

BQ05046-6-A

Sam’s Club

608 Southwest 8th Street

Bentonville, AR 72712

1-888-746-7726

3

Limited Warranty

The manufacturer warrants to the original
consumer-purchaser that this product shall be

free from defects in workmanship and materials
under normal and reasonable use when
assembled and operated according to this Grill
Guide from date of purchase as follows:

One year except as noted below:

Stainless Steel Burners – 3 years
Stainless Steel Parts except Burners, Grates,
Warming Rack, and Heat Diffusers - 5 years

The manufacturer will, at its option, refinish or
replace any product or part found to be defective
during the limited warranty period. There may be
a shipping charge. The manufacturer may require
you to return the part(s) claimed to be defective
for its inspection, freight or postage prepaid.
Contact our Customer Support Center as shown
below before returning any part(s).

Additional information can be obtained by
writing:

Barbecue Grills
Warranty Dept.

1375 Mitchell Blvd

Schaumburg, IL 60193

The manufacturer will require reasonable proof
of purchase. We strongly recommend you

keep your sales receipt

You can attach your receipt to this guide.

and register your grill.

This limited warranty does not cover the cost of
any inconvenience or property damage due to
failure of the product and does not cover damage
due to misuse, abuse, alteration, improper or
failure to perform normal and routine
maintenance, discoloration, scratches, rust,
accident, damage arising out of transportation of
the product, or normal wear and tear. This
limited warranty will not apply to any grill used
for commercial use.

This limited warranty is the sole warranty given
by the manufacturer and is in lieu of all other
warranties; express or implied, including implied
warranty of merchantability or fitness for a
particular purpose. Neither manufacturer dealers
nor the retail establishment selling this product
have any authority to make any warranties or to
promise remedies in addition to or inconsistent
with those stated above.

This limited warranty applies only to products
sold at retail, and is not transferable.

The manufacturer's maximum liability, in any
event, shall not exceed the purchase price of the
product paid by the original consumer-purchaser.
Some states do not allow the exclusion or
limitation of incidental or consequential damages.
Therefore, the above limitations or exclusions
may not apply to you. This warranty gives you
specific legal rights and may also have other
rights, which vary from state to state.

Customer Support Center

Thanks for purchasing a Member’s Mark Grill. We’re here to help you maximize your enjoyment and
appreciation of your new grill. Please don’t hesitate to contact us should you have any questions regarding
assembly, performance, warranty, or accessories. We have a full line of replacement parts available. Please
have your model number ready before you contact us. We’re here to serve You!

• If you need assistance or to order parts: Call

• Business hours: Monday through Friday; 8:30AM-5:00PM Central Time.

• Visit us on the web at: www.omahagrills.com

1-800-933-0527 or send a FAX to 1-847-252-1001.

4

r

Assembly Instructions

This page will give you an overview of information to assemble your grill. The following pages will show in
step-by-step detail how to do so. We offer the following suggestions to make your grill assembly as easy as
possible.

1.) Read through the entire Assembly Instructions before you begin.

2.) Choose an area large enough to comfortably lay out all the parts and hardware with enough
maneuver.

3.) Have an area with a non-abrasive surface where you can lay parts without scratching them.

4.) The Grill Island weighs in at close to 400 pounds. Use caution, and enough people, to remove the Grill
Island from the carton and steel pallet on the bottom.

5.) Lay all parts and hardware out and ensure you have everything listed on the Parts and Hardware page before
you begin assembly. See the Customer Support Page for contact information should any parts be damaged
or missing.

6.) A Philips head screwdriver has been provided if your gas grill requires one for assembly.

7.) Do not use a Power Screwdriver for assembly as you could strip the threads on the Nuts and Bolts.

8.) The propane tank for this grill is sold separately. See the LP Gas and Cylinder Information later in this
guide.

room to easily

BQ05046-6-A

WARNING

Failure to follow all Danger,
Warnings, and For Your Safety
notices in this Grill Guide may
result in serious bodily injury o
death, or in a fire or an explosion
causing damage to property.

CAUTION

Perform the Leak Test explained
later in this Grill Guide before
operating your grill.

5

1 Thermometer 36 Back Burner Fuel Line 77 Left Top Drawer

2 Hood 37 Infrared Back Burner 78 Drawer Glide Bracket –Right

3 Hood Bolt 38 Flame Sensor 79 Drawer Glide Bracket –Left

4 Silicon Stopper For Hood 39 Back Burner Electrode 80 Right-Top Drawer

5 Hood Handle 40 Warming Rack 81 Flip-up Door

6 Handle Connector-Left 41 Large & Small Cooking Grate 82 Cylinder Tray Glide Mounting

7 Handle Connector-Right 42 Firebox Back-Top Plate Bracket –Left

8 Firebox Rear Panel 43 Heat Shield 83 Cylinder Tray

9 Rotisserie Spit Support 44Granite Countertop Insert 84 Cylinder Tray Glide Mounting

10 Firebox-Left Side Panel 45 Grease Tray Bracket –Right

11 Rotisserie Spit Storage Support Left 46 Drawer Handle 85 Left Front Cabinet Support

12 Rotisserie Spit Storage Support Right 47 Silicon Stopper for Countertop 86 Ice Chest Handle

13 Bottom Heat Shield 48 Heat Diffuser 87 Ice Chest Exterior

14 Rotisserie Motor Support 49 “U” Main Burner 88 Ice Chest Lid

15 Firebox-Right Side Panel 50 Gas Manifold Assembly 89 Ice Chest Cover Handle

16 Back Burner Front Frame 51 Regulator and Hose 90 Cabinet Shelf

17 Heat Shield –Control Panel Inner 52 Smoker Drawer Cover 91 Right Front Cabinet Support

18 Electric Igniter 53 Smoker Drawer 92 Bottom Drawer Front Crossbar

19 Side Burner Lower Heat Shield 54Manual Igniter 93 Ice Chest Liner with Plug

20 Control Panel 55 Flip-up Door - Handle 94 Ice Chest Drawer Glide Mounting

21 Control Knob 56 Burner Support Rail Bracket -Right

22 Control Knob Seat 57 Firebox Back 95 Ice Chest Drawer

23 Side Burner Electrode 58 Firebox Front 96 Ice Chest Drawer Glide Mounting

24 Side Burner Air Shutter 59 Cabinet Right-Top –Back Panel Bracket -Left

25 Side Burner Stem 60 Cabinet Left – Top –Back Panel 97 Bottom Drawer

26 Side Burner Lower Heat Shield-Left Support 61 Firebox Support Right 98 Bottom Drawer Center Glide

27 Side Burner Head 62Cabinet Bottom Panel Slide Bracket

28 Side Burner Inside Frame 63 Cabinet Right Side Skirt 99 Right Bottom Door

29 Side Burner Grate 64 Cabinet Front Skirt 100 Cabinet Back Panel Bracket

30 Side Burner Top Frame 65 Countertop Frame 101 Cylinder Support Ring

31 Side Burner Cover 66 Firebox Support-Left 102 Flip-up Door Glide Rod

32 Rotisserie Motor 67 Cabinet Left Side Skirt 103 Electronic Ignition Button

33 Rotisserie Assembly 68 Cabinet Left Side Panel 104 Towel Bar Handle

A. Rotisserie Spit Handle 69 Caster 105 Towel Roller

B. Rotisserie Spit Washer 70 Locking Caster 106 Silicon Stopper for drawers

C. Rotisserie Counterweight 71 Swivel Caster 107 Ice Chest Drain Plug

D. Rotisserie Spit Bushing 72 Locking Swivel Caster

E. Rotisserie Fork 73Cabinet Right Side Panel

F. Rotisserie Spit 74 Cabinet Left –Back Panel

34 Back Burner Cover 75Cabinet Crossbar

35 Side Burner Clapboard 76 Cabinet Right –Back Panel

Detail Parts List

Detail Parts List - Not Shown In Diagram

108 Grill Cover 111 Control Knob Allen Screw

109 Main Burner Screw 112 Rotisserie Thumbscrew

110 Handle Bolt 113 Towel Bar Screw

114 Side Burner Cover Bolt and Nut
115 AA Battery

6

Detail Parts List

3

3

A

3

3

-

B

3

3

-

C

3

3

-

E

3

3

-

D

3

3

-

F

3

3

-

E

7

BQ05046-6-A Assembly Parts List

Heat Diffuser ---3 PCS

Rotisserie Spit with
Handle..…1PC

Small Cooking

Grate (9.5”)…..2PCS

Large Cooking
Grate (11.5”).….1PC

Meat Fork--- 2 PCS Counterweight--- 1 PC

Warming Rack --- 1 PC

Rotisserie Motor ---1PC

Towel Bar
Handle-----2 PCS

BQ05046-6-A Assembly Hardware List

A. “AA” Size Battery – 1 Pc B. Spit Washer – 2 Pcs

C. Spit Bushing – 1 Pc

8