Lab-Line 700, 100IDE, 100JPN, 100-5JPN, 101 User manual

5/04

COMPACT,

MODEL

a

NO.

OPERATION

MANUAL

LAB-LINEs

LOW

700,

COST

100IDE, 100-5JPN, 120,

120JPN,

INCUBATORS

100JPN,

101,

105,

120-5JPN,

NO

057-139-00

REV.

ECN

106,

K

19154

121, 150JPN,

3;

Barnstead|nternational

s

Boulevard

797

lewa

barnstead

Here

52001-0797

<

Var

tab

2555

Kerper

PO.

Box Dubuque. Phone: Fax.

563-589-0516 E-Mail: www

barnslnad.com

563-556-2241

mkt@

125,

152

U.S.A

or

800-553-0039

com

126,

150,

に

EAGLE

OF

CONTENTS

E

SECTION

‘4

TITLE

1

introduction

2

Description

3

Specifications

Installation

5

Operation

6

Maintenance

7

Replacement

Warranty

Parts

SECTION

INTRODUCTION

1

THANK

selecting

for

ease

and

Lab-Line

of

start-up,

PLEASE

«

Inspect immediately

e

Use been

e

Read location

unit

e

Insist

of

+

Be sure Instruments

IF

after

reading

operation

the

Accessory

received.

this

Operation

for

requirements,

that

every

this

manual.

to

this

instructions,

YOU

Instruments

PROCEED

carton

the

fill

within

if

damage

Do

unit:

operator

out the

manual

and

Checklist

not

Manual

you

as

well

Warranty

seven

you

please

contents

is

found.

when

discard

will

packing

thoroughly

want

as

user

of

this

(7)

days

should

cail:

equipment

your

for

AS

for

shipping

unpacking

materials

before

to

consider

convenience.

unit

becomes

Registration

after

have

Card

receiving

any

difficulties

needs.

For

FOLLOWS:

damage.

to

decicing

the

familiar

Notify

verify

until

all

availability

with

and

mail

the

unit.

with

that

the

is

accounted

upon

the

it

the

of

in

maximum

carrier

complete

an

appropriate

power

Operation

to

Lab-Line

installation

value

unit

for.

and

Section

other

or

has

Lab-Line

ALL

RIGHT

The

information

pro-

vided

Any

other

prior

written

(563)

RESERVED

soiely use

of

consent

Customer 556-2241

contained

to

this

in

enable

the

information,

of

the

manufacturer

Relations

or

(800)

this

manual

users

of

the

or

the

reproduction

is

Department

522-5463

is

the

exclusive

equipment

expressly

prohibited

propeily

described

or

transmission

of

hereir

©

2004.

Lab-Line

to

operate

of

all

or

1

ab-Line

Instruments,

and

maintain

any

portion

instruments,

of

Inc..

such

this

manual

Inc.

and

has

equipment.

been

without

The

Lab-Line bacteriological environment and

invertebrate

All open-wire activated. (2.5cm) chamber. units

temperature.

otherwise, 150JPN units purposes.

fibergiass

easy

Models

and

are

and

for

models

internal

Solid,

Powder to

clean

105,

provide

152

intended

compact.

hematological

growing

embryos.

have

specially

heaters. A pilot

corrosion

insulation

coated.

and

maintain. A bimetallic

106,

the

same

are

Educational

for

egg

DI

low

microorganisms,

resistant

help

durable,

125

and

performance

incubation

cost

incubators

studies.

designed

light

indicates

aluminum

to

distribute

heavy

126

have

Incubators

and

are

DESCRIPTION

are

useful

They

provide a controlled

as

well

as,

for

the

heaters

gauge

an

as

to

eliminate

when

chamber

heat

evenly

steel

thermostat

acrylic

the

with

not

outer

other

acrylic

to

be

the

walls

exteriors.

units.

outer

used

LEFT-SIDE

for

biochemical.

study

heaters

throughout

controls

door

for

of

the

hazards

are

with

1-inch

make

but.

Models

doors.

clinical

VIEW:

SECTION

chick

the

150,

These

2

of

«THERMOS

LISTED

‘AS

UPCOMING

ON

POWER

#440-359-00

SWITCH

REPLACEMENT

PARTS

STATUS

#360-235-00

#360-233-01

LIST

©

=

E

Е

©

=

H

|

n 로

u

o

E

LAMP

(LENS).

(LAMP

BASE)*

i

LJ

THERMOSTAT

#920-273-00

#560-230-00

©

|

(KNOB)*

T

LS

SECTION

3

SPECIFICATIONS

109,

OMIDE).

120.

100(IDE).

120,

POWER 100,

100IDE,

100JPN,

120JPN,

100JPN,

120JPN,

REQUIREMENTS:

100IDE,

101,

100JPN,

100-5JPN,

TEMPERATURE

100JPN,

120,

120JPN, 150,

100-5JPN,

INTERIOR

100-5JPN,

120-5JPN,

150,

EXTERIOR

100-5JPN,

120-5JPN,

150,

105,

120,

125: 150

150JPN:

106,

121,

126: 152:

120JPN:

120-5JPN:

RANGE:

101

105,

106:

125,

126:

150JPN,

120-5JPN:

DIMENSIONS:

101,

121, 125,

150JPN,

DIMENSIONS:

101,

121,

150JPN,

105,

125,

152:

106:

126:

152;

106:

126:

152:

120VAC, 120VAC.

100VAC, 240VAC, 240VAC,

100VAC,

From

12"W x 12"D x 8"H

(30 x 36 x 20

12"W x 12"D x 12"H

(30 x 30 x 30

13-7/16"W x 13-11/32"D x 12-11/16"H

(36 x 34 x 32

14-3/8"W x 13-11/32"D x 11-5/16"H (37 x 34 x 30

14-3/8"W x 13-11/32"D x 15-5/16"H (37 x 34 x 41

13-7/16"VY x 13-11/32"D x 15-5/16"H (37 x 54 x 41

50/60

50/60 50/60 50/60 50/60 50/60

slightly

slightly slightly

above

above above

cm)

Hz, Hz. Hz, Hz. Hz. Hz. Hz,

100

Watts,

150

Watts,

104

Watts,

100

Watts,

150

Watts,

70

Watts,

100

Watts,

ambient

ambient ambient

to

to to

0.8

Amps

1.3

Amps

1.0

Amps

0.4

Amps

0.6

Amps

0.7

Amps

1.0

Amps

40°C

60°C

45°C 65°C

t00(IDE?

120.

100(IDE),

120.

UNITS

*Refer

100JPN,

120JPN,

100JPN,

120JPN,

to

100-5JPN, 120-5JPN,

100-5JPN,

120-5JPN,

ENVIRONMENTAL

POLLUTION

INSTALLATION

VOLTAGE

IEC

664-1

CHAMBER

101,

121,

150,

150JPN,

SHIPPING

101, 105, 106:

121,125,

150,

150JPN,

CATEGORY":

ELECTRICAL

TOLERANCE:

TEMPERATURE:

PRODUCT

VOLUME:

105,

106:

125, 126:

152:

WEIGHT:

126:

152:

OPERATING

DEGREE*:

ALTITUDE:

HUMIDITY:

SUPPLY:

USAGE:

0.67

cubic

feet

1.00

cubic

feet

1.32

cubic

feet

15

ibs.

(7

kg)

27

lbs.

(12

kg)

33

Ibs.

(15

kg)

CONDITIONS:

2 H 2000

Meters

80%

maximum,

120VAC

+10%

15°C This only

or

of

normal

to

40°C

product

(19

liters)

(28

liters)

(37

liters)

MSL

(Mean

non-condensing

240VAC

rated

line

is

intended

Sea

for

Level)

use

indoors

SECTION

INSTALLATION

4

VSHIPPING

_

This examine the

delivering

copy

of

the

Open

for

before

found, promptly.

days damage:

LOCATION:

from source the

THERMOMETER

Place thermometer, thermometer into exposed.

promptly

IMPORTANT:

after

Place

drafts

that

unit

for

The

the

vent

CARTON:

should

for

any

delivery

the

packaging

receipt

you

and

matches free incubator

INSTALLATION:

tnermometer

grommet

on

be

shipping

carrier

receipt.

carton

report

of

shipment

must

call

the

unit

wide

variations

the

air

convection,

door

in

supplied

(including

top

of

inspected

damage

should

materials

Failure

on a level

the

both

carefully

it

to

the

carrier

to

absolves

for

a

damage

unit

nameplate

opens

holder

hole

at

with

the

bulb)

cabinet

upon

delivery.

before

specify

making

are

discarded—after

request

tabie

in

ambient

accessory

from

doubles

the top

unit,

extends

until

unpacking. and

certain

and

request

an

inspection

the

inspection

or

bench

temperature,

requirements.

attachment

the

left

as a vent

of

through

about

When

sign

that

a

carrier

the

from

promptly.

where

side.

fixture

thermometer

the

grommet

the

1/4-inch

received,

If

damage

for

the

damage

all

parts

unpacking, damage

of

damage

any

it

will

be

near a power

Allow

and

user

on

the

until

holder.

of

the

holder

carefully

is

discovered,

on

are

accounted

if

damage

inspection

within

liability

clearance

holder.

Push

for

operated,

suppiy

convenience

top

of

Push

3-inches

the

is

your

is

a

few

away

around

the

unit. the

of

the

holder

NOTE:

The

Turn

THERMOMETER

IT

MAY

THERMOMETER

thermometer

the

thermometer

THERMOMETER

HOLDER

THERMOMETER

BE

NECESSARY

GROMMET

HOLDER

VENT

(TOP

OF

HOLDER

buto

should

in

its

~

——

INCUBATOR)

TO

SQUEEZE

TO

INSTALL

extend

holder

for

THE 3 PRONGS

IT

MORE

about

easy

2-inches

reading.

OF

EASILY.

into

THE

the

chamber

o

SECTION

OPERATION

5

DANGER:

COMBUSTIBLE THE OR

WARNING: WHICH INJURY

START-UP.

1.

2.

3.

4

DO

PRESENCE

EXPLOSION

DO

WILL

MAY

When

use.

hand increase The

Allow

then

Repeat incubator

Load

apart

the

Turn

side

status

one

check

the

to

NOT

USE

IN

THE

MATERIALS

OF

PRESSURIZED

MAY

RESULT,

NOT

HEAT

CAUSE

RESULT.

the

Steps 1 and 2 until

is

incubator

allow

IT

cordset

the

power

of

incubator—rotate temperature,

lamp

is

hour

for

the

thermometer.

then

ready

for

proper

OR

ANY

TO

EMIT

is

plugged

switch

lit

when

the

temperature

to

so

that

air

CAUSING

SUBSTANCE

counterclockwise

the

be

items

PRESENCE

EXPLOSIVE

OR

SEALED

DEATH

TOXIC

into

ON.

loaded.

circulation.

FUMES—-DEATH

an

outlet,

Note

thermostat

the

thermostat

heaters

desired

or

are

inside

setting

specimens

OF

FLAMMABLE

GASES.

ABOVE A TEMPERATURE

the

energized

the

DO

CONTAINERS—FIRE

OR

SEVERE

incubator

knob

clockwise

to

lower

chamber

is

obtained.

are

spaced

OR

NOT

USE

INJURY.

OR

SEVERE

is

ready

on

lower

to

the

temperature.

to

stabilize:

The

far

enough

IN

for

right

LA

the

insofar possibility

as

possible,

of

chamber.

fungus

keep

the

growth

incubator

starting

from

door

clesed

airborne

in

order

organisms

to

reduce

entering

INSTALLATION:

com

SHELF

ELECTRICAL

INSTALLATION.

two

placed aluminum

supplied for

3-prong grounded it

is

required

type.

of

the unit conform

of

the unit conform

for

the

green

NOTE:

100

series

aluminum

on

top. shelves.

REQUIREMENTS:

120

VAC

with a 3-wire

plugs.

type.

that a qualified

240

VAC

variety

is

furnished

100

variety

is

furnished

If a plug

unit

ground

LEAVE

with

VAC

with

load

of

local

of

local

wire

UNIT

comes

sheives:

150

models

if

For

models

plug

with

code

models

piug

with

code

must

requirements

is

DISCONNECTED

with 1 fixed

one

series

require a 120

line

an

extension

an

outlet

require a 240 configurations the

plug and reguire a 100

configurations

the

plug

and

be

installed.

secured

shelf.

is

fixed

to

the

has

two

removable,

VAC,

cord.

It

should

cord

designed

electrician

VAC,

in

use

removed.

configuration

VAC,

in

use

removed.

configuration

use

only

and

matching

to

the

plug

WHEN

120

series

bottom

be

is

used,

to

accept

replace

|

worldwide

The

reguirements.

worldwide

The

requirements.

the

ground

NOT

of

nonadjustable,

50/60

plugged

it

also

2-prong

the

50/60

user

50/60

user

3-prong

the

power

terminal.

IN

USE.

units

the

chamber,

Hz

power into should

outlet

Hz

power

for

240

must

install a plug

Hz

power

for

100

must

install a plug

grounded

outlet.

are

supplied

the

perforated

source.

an

outlet

be

the

plugs

(ungrounded).

with a new

source. VAC

power.

source. VAC

power.

type,

Make

with

other

is

They

are

designed

3-wire

grounded

|

Because

the

to

Because

the

to

rated

sure

the

上 ~

SECTION

MAINTENANCE

6

BE

ADVISED:

NOTE: WARRANTY PERIOD, MAY

IF PLEASE OR DIRECTLY

CAUTION:

ATTEMPTING

ROUTINE

thorough shelves abrasives

cleaning

REPAIRS

accessible

upside bottom

and

MAKE

NO

BEFORE

SUCH

BE

TECHNICALLY

ASSISTANCE

CALL

THE

(800)

522-5463.

TO

LAB-LINE

DISCONNECT

CLEANING:

Clean

To

AND

Unplug

A

down

remove 2 nuts

up

cleaning

can

be

or

metallic

clean

solution SERVICING:

inside

heater

and

the

ATTEMPT

CONSULTATION

IS

NEEDED

LAB-LINE

NO

ANY

any

between

cleaned

the

can

the

unit

the

is

located

remove 4 screws

insulation

that

TO

CONSULTING

SOPHISTICATED

BEYOND

CUSTOMER

MERCHANDISE,

WITHOUT

MAINTENANCE

spills

immediately.

with a mild

scouring

viewing

be

used.

from

chamber.

under

covering

hold

SERVICE

IS

PRIOR

PLUG

YOUR

STILL

WHAT

HOWEVER,

FROM

OR

ADVISED,

OR

RELATIONS

OR

incubation

detergent

pads

on

door

use a soft

Avoid

its

outlet

the

scratching

before

the

flocr

from

the

heater

REPAIR A LAB-LINE

LAB-LINE

DIFFICULT.

THE

APPROVAL

DEALER.

ESPECIALLY

DISTRIBUTOR

DEPARTMENT

SHOULD

FROM

ELECTRICAL

REPAIR

Remove

periods.

any

part

damp

servicing.

of

the

bottom

heater.

to

the

OF

the

The

or

soap of

the

cloth. A

the

chamber.

Disconnect

floor

of

AFTER

WHEN

CAN

BE

RETURNED

LAB-LINE.

OUTLET

THIS

plug

from

chamber

and

water.

unit.

regular

acrylic

The

thermostat

Turn

of

the

cabinet.

the

chamber.

PRODUCT

THE

WARRANTY

THE

PROVIDE,

AT

(563)

BEFORE

UNIT.

its

outlet

interior

Do

window

plastic.

the

incubator Lift

heater

UNDER

REPAIR

556-2241

for

and

not

use

is

easily

out

leads

a

the

SECTION

7

Door,

Heater,

Temperature

Door,

Acrylic

Thermometer

100V/100W

Heater.

Shelf

(100,

Shelf,

Upper

Status

Acrylic

(Models

Door.

Acrylic

Heater,

(100-5JPN,

100/120V

Heater,

105,

Shelf,

(120,

Lamp

Power

Thermometer

DESCRIPTION

Control

(Models

125,

(Models

Door

Holder

Thermometer:

100/120V

Heater,

240V

Tension

Rubber

120.

Lower

Status

(150

125,

Lens

Switch-120V:

Switch-220V:

Wiring

Knob:

Cordset:

105,

106):

126,

150):

Handle:

Grommet:

units;

240V

units: 120-5JPN): units

(150):

units

(152): Catch: Hinge:

Feet

(4):

125

Series): Series):

150

Series):

Lamp

Thermostat:

Base:

(amber):

Holder:

Schematic:

PART

NUMBER

560-230-00

470-187-00

540-262-00 540-261-01

540-261-00

560-263-00

790-022-00

910-136-00

340-152-00 340-152-041 340-152-02 340-209-00 340-209-01 600-124-00 570-341-00 790-214-00

172-134-00 172-135-00 172-136-00

360-233-01

360-235-00

440-359-00

440-292-00 910-039-00

920-273-00 228-604-00

NEED CALL:

LAB-LINE

PART?

A

(563)

RESERVES

CALL

556-2241

RIGHT

THE

(800)

or

TO

CHANGE

LAB-LINE

522-5463;

SPECIFICATIONS

PARTS

FAX:

HOTLINE.

589-0516.

(563)

WITHOUT

PRIOR

NOTICE

10

WARRANTY

Page 1 of

2

LAB-LINE by

Lab-Line following (it}

the “Commencement

LAB-LINE RESPECT WARRANTIES, MERCHANTABILITY

An

authorized

the

event

obligation

defective

Lab-Lme's force Line

or

inconsistent

contamination.

or

third

not

an

IN

NO INDIRECT, ANY OR

OTHERWISE,

OR

PERFORMANCE

ON

CONTRACT,

LIABILITY

INSTRUMENTS,

shall

page

date

the

MAKES

TO

of a defect

and

exciusive

product.

warranty

o:

effect

'ts

party

authorized

EVENT

DAMAGES

if

duly

with

or

SPECIAL,

OR

from

product

THE

representative

authorized

overheating,

SHALL

REGULATORY

be

free

the

first

is

Date’).

NO

OTHER

PRODUCTS

INCLUDING

AND

covered

remedy,

provided

there

is

any

written

(iii)

dealer

RESULTING

TORT

operating

use

of

LAB-LINE

INCIDENTAL,

ARISING

OF

(INCLUDING

INC.

(“Lab-Line”)

of

defects

to

occur purchased Except

service

replacement

of

Lab-Line.

ANY

as

WARRANTY,

AND

BUT

NOT

FITNESS

of

Lab-Line

by

Lab-Line’s

provide

hereunder

(i)

repair

representative,

instructions

modification

BE

FROM

OUT

OF

PRODUCTS,

ACTION.

warrants

in

materials

of

(i)

by

the

expressiy

EXPRESSLY

LIMITED

FOR A PARTICULAR

must

free

shail

made

or

parts

LIABLE

OR

CONSEQUENTIAL

LOSS

OR

IN

NEGLIGENCE),

for a period

the

date

original

stated

EXPRESSED

TO,

perform

warranty.

replacement

be

null

to

the

product

(i)

for

the

alteration

that

are

TO

OF

USE

CONNECTION

WHETHER

the

ANY

that

the

of

product

retail

customer

above.

DISCLAIMS

WARRANTIES

all

warranty

Lab-Line

parts

and

void

by a party

misuse

product),

of

the

product

obtained

PARTY

OR

PROFITS,

SUCH

ANY

product

time

defined

is

sold

by

(the

OR

IMPLIED,

ANY

OF

PURPOSE.

inspections.

shall,

as

to

remedy

and

without

other

(including

mishandling,

from a party

FOR

DAMAGES,

WITH

CLAIM

THEORY

use

by

any

ANY

ANTICIPATED

THE

OF

manufactured

on

the

Lab-Line

WITH

AND

DESIGN,

its

sole

the

further

than

customer

who

DIRECT,

OR

SALE,

IS

BASED STRICT

or

ALL

In

Lab-

is

FOR

USE

The

name

800-522-5463.

of

your

nearest

authorized

"

iS:

Barnstead

vout

fal

Stats

Lab-Line

Here

dealer

may

>

be

obtained

by

calling

1-

11

WARRANTY

Page 2 of

12

24

2

MONTH

©

se

9 0

0

e

04.

4

¢ 0 0

è 0 o

e è

e

PARTS

All

Environmental

Low

Temperature Animal Controlled

Biological Refrigerators, Chromatography

Large compressor

Frame Saybolt

Timers, Saf-T-Shield, Alt Dual Reciprocating Rockers Low

Environ Titer Multi Water Slide Mixers, Thermal Blok Aquabaths,

Capacity

PARTS

Clamps,

Incubators & Ovens

Action

Cost

Plate

Wrist

Baths

Warmers

Heaters

Study

Viscosimeter Samplers,

and

Shakers

Blok

Stirrers,

Cyclers

WARRANTY:

Chambers

B.

Chamber

Environment

Work

Station

Freezers

Refrigerators

only}

WARRANTY:

Frame

Flasks

Safety

Open

Shakers

Rotators

Shaker

(excluding

lifetime

Tongs

Air

Hotplates

warranty

O.

D.

Incubators

Centers

and

Sets.

Lab

Shaker

(open

ai:

Aquabaths}.

on

(5

year

Freezers

Jacks

ang

water.

Ultrasonic

heaters

parts

(5

bath}

warranty

year

parts

Cleaners

on

compressor

warranty

only)

on

LIFETIME

Refrigerated

year

PARTS

All

ORBITAL

parts

WARRANTY:

Shakers

warranty

Orbital

warranty

on

the

drive

Shakers

on

the

(not

carrying a 24

mechanism

carry a lifetime

compressor,

and

month

and a 5

warranty

a 5

year

parts

warranty)

year

warranty

on

the

warranty

drive

on

offer a lifetime

on

all

other

mechanism, all

other

1-

parts.

12

Lab-Line 700, 100IDE, 100JPN, 100-5JPN, 101 User manual

Specifications and Main Features

Frequently Asked Questions

User Manual