Page 1
P4450005
Deerfield™ Kitchen Sink
Installation and User Guide
MODEL NUMBERS
5815W
Important :- Please quote the above model number(s) when ordering spares.
IMPORTANT!
Installer: This manual is the property of the customer and must
be retained with the product for maintenance and operational
purposes.
1037045
Page 2
P4450
CONTENTS
DESCRIPTION ......................................................................... 3
SAFETY : WARNINGS ............................................................. 3
DIMENSIONS ........................................................................... 4
SPECIFICATION ...................................................................... 5
Plumbing Connections ..................................................... 5
INSTALLATION ......................................................................... 5
Before You Begin ............................................................. 5
Install the Kitchen Sink - Self Rimming ............................ 6
Install the Plumbing ......................................................... 9
USER MAINTENANCE ............................................................ 10
Cleaning ........................................................................... 10
SPARE PARTS ......................................................................... 11
CUSTOMER SERVICE ............................................................ 12
Guarantee of Quality ........................................................ 12
Commercial / Business Use ............................................. 12
Not Covered by this Guarantee ........................................ 12
To Contact Us .................................................................. 12
1037045
2
Page 3
P4450
DESCRIPTION
This guide covers the installation of the Deerfield™ cast iron kitchen sink.
SAFETY : WARNINGS
Kohler products are precision-engineered and should give continued
superior and safe performance, provided:
1. They are installed, commissioned, operated and maintained in
accordance with the recommendations given in this Manual.
2. Periodic attention is given, as necessary, to maintain the product in
good functional order. Recommended guidelines are given in the
MAINTENANCE section.
Carefully inspect the new fixture for any signs of damage.
When installing Kohler Products, manufacturers guidelines for power tool
safety should be followed.
1037045
3
Page 4
P4450
DIMENSIONS
P4450010
203
559
838
224
391
287
50
14
420
All Dimensions in mm
1037045
4
Page 5
P4450
SPECIFICATION
Plumbing Connections
Hot (H) and Cold (C) inlets must be connected to the correct inlet supplies.
INSTALLATION
Before You Begin
1. Turn off the water supply.
2. The plumbing installation must comply with Water Supply
Regulations/Bye-laws (Scotland), Building Regulations or any
particular regulations and practices, specified by the local water
company or water undertakers. The installation should be carried out
by a plumber or contractor who is registered with, or is a member
of an association such as:
Institute of Plumbing (IOP), throughout the UK.
National Association of Plumbing, Heating and Mechanical Services
Contractors (NAPH & MSC), England and Wales.
Scottish and Northern Ireland Plumbing Employers’ Federation
(SNIPEF), Scotland and Northern Ireland.
3. Before installation carefully inspect the new fixture for any signs of
damage.
1037045
5
Page 6
P4450
Install the Kitchen Sink - Self Rimm ing
1. Before installing the sink make sure there is adequate clearance
between the taps, the backsplash, the fixture and the cabinet.
2. Make sure that the countertop is clean and dry.
P4345020
Installation Template
3. Cut out the installation template.
4. Fix the installation template to the countertop and mark around the
template with a pencil.
5. Using a suitable power tool, carefully cut-out the opening.
6. Seal the cut edges with a moisture resistant sealer (e.g. yacht varnish).
1037045
6
Page 7
P4450
P4345040
Seal cut edges with a
moisture resistant sealer
Illustration may not be the same
as product being installed
Caution! Cast Iron sinks are very heavy, so make sure two people lift the
sink into position.
7. Fit the taps in accordance with the manufacturer’s instructions.
8. Install the drain in accordance with the manufacturer’s instructions.
9. Fit the sink into the counter top and check for position and alignment.
10. Apply a thin, continuous bead of silicone sealant around the edge of
the sink.
1037045
7
Page 8
P4450
P4345050
Silicone Sealant
11. Remove any excess silicone sealant and fill in any voids as required.
12. Allow the silicone sealant to cure before proceeding with the
installation.
1037045
8
Page 9
P4450
Install the Plumbing
P4345070
Nut
Nut
Gasket
Gasket
Caution! Make sure a watertight seal exists on all sink drain connections.
Caution! Provide access to the plumbing connections for future plumbing
maintenance.
1. Connect the drain to the waste pipe.
2. Connect the hot and cold water supplies.
3. Open the hot and cold water valves, and check the supply connections
for leaks.
4. Run water into the sink, and check the drain connections for leaks.
1037045
9
Page 10
P4450
USER MAINTENANCE
Cleaning
Caution! Risk of product damage. Many cleaners contain abrasive and
chemical substances, and should not be used for cleaning stainless steel,
enamel, plated or plastic fittings. These finishes should be cleaned using
a mild washing up detergent or soap solution, rinsed and then wiped dry
with a soft clean cloth.
Keep your cast iron product looking new by rinsing it out thoroughly after
each use. If the surface gets excessively dirty, use a general purpose
cleaner.
Do not use abrasive cleaners or solvents on cast iron products.
1037045
10
Page 11
P4450
SPARE PARTS
P4450020
5815W
1037045
11
Page 12
P4450
CUSTOMER SERVICE
Guarantee of Quality
Kohler UK guarantee products against any defect of materials or workmanship for the following periods
All Kitchen Sinks
Our co
nfidence in the quality and reliability of our superior products enables us to offer a comprehensive
guaran
tee for all products.
To regi
ster and fully benefit from this guarantee you must return the enclosed product registration card indicating the
Kohler i
temsyouhavepurchased.
Within
the guarantee period we will undertake to resolve any material defects, by providing replacement parts, modules
or compl
ete product, as we deem appropriate. To be free of charge, work must only be undertaken by Kohler UK
approved
personnel.
To e n su r e
that any problems can be promptly resolved you must contact Kohler UK directly.
Proofofp
urchasemustbeprovidedwithanyclaims.
This gua
rantee covers products in domestic use, installed, operated and maintained in accordance with the instructions. It
covers th
e purchaser only and is not transferable.
Commerci
al/BusinessUse
Any Kohle
r Bathroom product used within a commercial / business premise is guaranteed for 1Yearagainst any defect of
materials
or workmanship
Not Covere
dbythisGuarantee
Damage or d
efects arising from incorrect installation, improper use or lack of maintenance.
Installed
product damaged in transit Consequential loss, damage or product removal and installation costs.
General w
ear and tear.
This guar
antee is in addition to your statutory and other legal rights.
Applies t
o the UK only.
To Contac
tUs
Tel: 087
0 8505551
Fax: 087
0 8505552
email: i
nfo@kohleruk.com
Website
: www.kohleruk.com
Kohler Mira Ltd
Cromw
ell Road,
Cheltenham GL52 5EP.
The company reserves the right
to alter
product specifications
without notice.
© Kohler Mira Limited, July 2002
Loading...