Page 1
SCHEMATIC DIAGRAMS
18
CD RECEIVER
KD-A65J KD-R50E KD-R50EN
KD-R50EY KD-R60J KD-R80BTJ
KD-R80BTU KD-R80BTUN
(No.MA525<Rev.001>)1/
Page 2
■ PRECAUTIONS ON SCHEMATIC DIAGRAMS
z Due to the improvement in performance, some part numbers shown in the circuit diagrams
may not agree with those indicated in the Parts List.
z The parts numbers, values and rated voltage etc. in the Schematic Diagrams are for
reference only.
z Since the circuit diagrams are standard ones, the circuits and circuit constants may be
subject to change for improvement without any notice.
■ PRECAUTIONS ON PARTS LIST
z
The parts identified by the symbol are critical for safety. Whenever replacing these parts, be sure to
use specified ones to secure the safety.
z
The parts not indicated in this Parts List and those which are filled with lines --- in the Parts No.
columns will not be supplied.
z
P.W. BOARD Ass'y will not be supplied, but those which are filled with the Parts No. in the Parts No.
columns will be supplied.
z
When ordering chips, screws etc., place bulk orders (unit of tens) whenever possible to improve
shipping efficiency.
z
There are cases where the actual implemented parts in the sets and the service parts are different.
When ordering parts, make sure to refer to the Parts List.
■
PRECAUTIONS ON SERVICE
Certain parts of the power circuits and the GNDs differ according to the models. Care must be
taken for the following points as the differences are indicated separately in the LIVE GND ( ) and
the ISOLATED (NEUTRAL) GND ( ).
1. Do not touch the LIVE GND, or do not touch the LIVE GND and the ISOLATED (NEUTRAL)
GND at the same time. It may cause an electric shock.
Before pulling out the chassis or other parts, make sure to pull out the power cord from the
wall outlet first.
2. Do not short circuit between the LIVE GND and ISOLATED (NEUTRAL) GND, or never
measure the LIVE GND and ISOLATED (NEUTRAL) GND at the same time using measuring
instruments (oscilloscope, etc.). It may blow fuses or damage other parts.
■ DEVIATION TOLERANCE RANGE
DEVIATION TOLERANCE RANGE
F G J K M N R H Z P
± 1% ± 2% ± 5% ±10% ±20% ±30%
+30%
-10%
+50%
-10%
+80%
-20%
+100%
-0%
18
(No.MA525<Rev.001>)2/
Page 3
IC953
USB5V-R
HSP SW
IC943
DC/DC
USB5V-F
CONVERTOR
IC931
5V DC/DC
CONVERTER
IC921
3.3V LDO
REGULATOR
IC902
3.3V
LDO
IC901
REGULATOR
IC
IC801
JVC
BUS
IC771
EEPROM
IC701
MICON
IC681
REMOCON
IC661
PANEL MICON
IC602
RESET
IC601
D/A
CONVERTOR
IC601
RGB
CONTROL
IC581
CD
L.P.F.
IC541
CD
DSP
IC501
BTL
DRIVER
IC491
1.8V
REGULATOR
IC481
iPod IC
IC471
USB/CD
MCLK SW
IC442
SDRAM
IC441
FLASH ROM
IC402
EEPROM
IC401
TELECHIPS
USB DSP
IC301
POWER
AMP
IC161
ELECTRICAL
VOLUME
IC90
MIC AMP
IC1
TUNER IC
(BUILT IN
RDS)
J1
LINE OUT REAR
REAR L
REAR R
LINE OUT FRONT
FRONT L
FRONT R
SUBWOOFER
3.3V
3.3V
SUBWOOFER
XA0-21
AOUT L/R
AOUT L/R
5.0V
DAO1
1.8V XD0-15
CDMCLK
GND
LRCLK1
SW5V
MICON PS2
BCLK1
MUTE
MCLK
/DACMS
LOAD
BLKCK RST
DACMC
UH1+UH1-
MSW NRST
EN1
DACMD
SDA/SCL
MIC
BCK P.IC MUTE
UH0+/UH0-
LRCK
CLK SW/MCLK1
SRDATA
LOAD/MSW
TRST/MUTE CTL/UART TX/UART RX
ADIN0
USBH1D+/USBH1D-
USBH0D+/USBH0D-
USB5V-F
SW1/SW2/SW3/PSW
EN0
MLD/BLKCK/NRST/MDATA/MCLK/STAT/BCK/LRCK/SRDATA
EPSDA/EPSCL
CDON
CDMCLK
CD-L
AOUT L/R
CD-R
FRONT LEFT(+)
SPINDLE+
VDD5V
FRONT LEFT(-)
SPINDLE-
AUXL
CH-L FRONT RIGHT(+)
CD PLAYER UNIT
FEED+
AUXG CH-R
FRONT RIGHT(-)
FEED-
SD_SEL
AUXR
REAR LEFT(+)
FEED+
TRACKING+
MDATA
REAR LEFT(-)
FEED-
TRACKING-
MCLK REAR RIGHT(+)
FOCUS+
STAT
VDD3.3V ILL 10V
REAR RIGHT(-)
FOCUS-
MLD
SW5V
VDD5V
VOL DA
PSW VOLCK
AUTO ANT, AMP REMOTE
MICON
PS2
SPINDLE+
SPINDLE-
STEERING REMOTE
VF1.VF2
SW1
VT1.VT2
CDON
SW2
MD.LD
PS1
DIMMER INPUT
SW3 RESET
POWER
VF1/VF2 CTRL1
VT1/VT2
TRACKING+
FOCUS+
EN1
CTRL2
LD/MD
TRACKING-
FOCUS-
EN0
ILM TU.L
TU.R
BEEP
ANT JACK
R,G.B
TU/RDSCL
TU/RDSDA
SW1
SDA,SCL REMOCON
UH0+
DISPRST
J-DATA
BUSINT
RESET
UH0- 3.3V
J-CLK BUSSCK
D0-D7
/BUSI/O
LCDCL/CS/RST BUSSI
THERMAL
ILL 10V
BUSSO
EEPROM-DI
LCDWR/RD
DISPCE
EEPROM-DO
VDD
DISPDATA
VDD3.3V
EEPROM-CLK
DISPCLK
DISPRST
REMOCON
KEY0
KEYDATA
DISPCE
KEY1
ILL 10V
DISPDATA
USB5V F
USB5V R
VOL1
DISPCLK
VOL2
KEYDATA
GND GND
UHO+
UH1+
OPEN SWITCH OPEN
CH.L
UHO-
UH1-
S702 CH.R
MIC
M+
DETACH SWITCH DETACH
M-
S701
AUX-R
RESET SWITCH RESET GND
S703
AUX-L
OE Connector
To MIC & AUX
Cable
SW3
SW1
J2
LINE OUT
REAR & FRONT
SUBWOOFER
TRST
SWITCH UNIT
EACH BLOCK
MUTE
SW2
MUTE CTL
UART TX
UART RX
To SPK,
BATTERY, GND
To USB Cable
ELECTRIC UNIT
(USB1 & USB2)
J version only
USB5V-R
OUTFL
OUTFR
USB UNIT
PSW
OUTRF
OUTRR
S601 TO
S612
KEY
BUTTON
CN601
PICK UP
LOAD&FEED
MOTOR
POSITION SET
SWITCH
SPINDLE
MOTOR
SW1,SW2,SW3
JS686
ROTARY
ENCODER
CN101
J801
RGB LEDs
PS2
BATT
DETECT
MUTING
CIRCUIT
& MUTING
TRANSISTORS
CIRCUIT
CN441&CN442&CN444
CN441&CN442&CN444
To CD CHANGER
CN901
DOT LCD
CN102
DISPRESET
CN472
CN103
CN100
CN502
BLOCK DIAGRAM
created date:2012-03-14No.MA525
18
(No.MA525<Rev.001>)3/
Page 4
CONDITION
---FM MODE. ( )CD MODE.AM MODE.
*
*
*
*
*
*
*
*
NI / 270KNI / 270K0 / 1.5M0 / 1.5M
*
0V
5.2V
0.8V
4.9V
3.3V
5.2V
3.0V
14.4V
1.1V
0V
9.8V
1.6V
1.0V
1.1V
1.6V
1.0V
3.0V
14.4V
0V
9.8V
5.2V
3.3V
0V
3.3V
0.2V
4.2V
0V
3.3V0V
3.3V
0V
0.6V
0V
2.7V
0V
0V
3.3V
3.3V
3.3V
3.3V
3.3V
3.3V
3.3V
3.3V
3.3V
3.3V
3.3V
*(11.4)V
*(5.7V)
*(5.7V)
*(5.7V)
*(5.7V)
*(5.7V)
*(5.7V)
*(5.7V)
3.3V
3.3V
4.0V
4.0V
4.0V
4.0V
4.0V
4.0V
3.3V
8.3V
4.0V
3.3V
3.3V
NI / 270K
SX
EN
BST
IN
FB
VC
GND
OUT
SX
EN
BST
IN
FB
VC
GND
OUT
0 / 1.5M
R170 / R904
*
NC
NC
*
*
*
FOR TDA7720 E-VOL
FOR TDA7718 E-VOL
FOR TDA7720 E-VOL
47K47K
47K
47K
47K
47K
R747, R742, R748, R749
10K / NI10K / NI
10K / 5.1K
10K / 10K
NI / 10K
10 & 4.7K
10 & 4.7K 10 & 4.7K
750 & 360K
750 & 360K
750 & 360K
USED/NOT USED
USED/NOT USED
USED/NOT USED
NOT USED/USED
NOT USED/USED
NOT USED/USEDE-VOL SUPPLY SWITCH = R163 / R173, L181
BUZZER VOLTAGE LEVEL = R309 & R310
NOT USED/USED
NOT USED/USED
USED/NOT USED
USED/NOT USEDUSED/NOT USEDUSED/NOT USED
USED
USED
USED
NOT USED
NOT USED
NOT USED
NOT USED
NOT USED
NOT USED
NOT USED
NOT USED
NOT USED
NOT USED
NOT USED
NOT USED
NOT USED
NOT USED
NOT USED
Q480, Q481, D480, D481
SD CONNECTOR CIRCUIT = C480 TO C484, R480 TO R489
SD SWITCH CIRCUIT = R490 TO R499, R479, C479
USED
NOT USED
NOT USED
NOT USED
NOT USED
NOT USED
SD CONNECTOR AND SWITCH IC = J480, IC490
NOT USED
USED
USED
USED
USED
USED
SD AND CD SWITCH CIRCUIT = R471 TO R474
USED/NOT USED
NOT USED
NOT USED
NOT USED
NOT USEDNOT USED
USED
NOT USED
NOT USED
NOT USED
NOT USED
NOT USED
NOT USED
NOT USED
NOT USED
USED
USED
USED
USED
JVC BUS CIRCUIT = R801 TO R814, C801, C802
NOT USED
NOT USED
NOT USED
NOT USED
USED
USED
0
0
5.1K
5.1K
6.8K6.8K
0
5.1K
SPR-OUT D-RESISTOR = R335, R336, R337, R338
NOT USED
NOT USED
NOT USED
6.8K
TDA7718B-XTDA7718B-X
TDA7720-X
TDA7720-XTDA7720-X
USED/NOT USED
USED/NOT USED
QAM1343-001
QAM1343-001
QAM1331-001
2.5V
KD-R80BTU
CONVERTER
DC-DC
HSP SWITCH
USB5V-R
DC-DC
USB5V-F
*
2.5V
2.5V
KD-SD80BTE
KD-R50E
USB5V-F
OPEN
DETACH
EJECT
CD
SLOT
EJECT
LED
LED
GND
FB
NC
NC
NC
EN
VCC
OUT
OE_LEARNING2
TU-SCL
TU-SDA
REMOCON
( )
0V
0V
0V
*
*
*
*
**
*
*
*
0V
3.3V
14.2V
5.1V
4.9V
4.9V
4.9V
4.4V
2.2V
14.2V
1.6(3.3)
8.3V
1.2V
7.9V
1.25V
9.9V
R1/R2
22K/22K
R1/R2
22K/22K
R1/R2
10K/10K
R1/R2
R2
R1
R2
R1
RT1P241C-X
RT1N241C-X
RT1N141C-X
10K/10K
RT1P141C-X
*
NOT USED FOR ALL
*
QAM1332-001
QAM1331-001
QAM1331-001
NI / 10K
C335-C338: NCB21CK-474X-A
MUTING
NOT USED/USED
USED/NOT USED
USED/NOT USED
L10 (NQR0269-026X/NRSA63J-0R0X)
*
TELMUTE
OE REMOTE
FRONT RIGHT(+)
FRONT RIGHT(-)
FRONT LEFT(-)
FRONT LEFT(+)
REAR LEFT(+)
REAR LEFT(-)
REAR RIGHT(-)
REAR RIGHT(+)
REAR-SW JUMPERS = R164,R174 / R165,R175
*
*
TDA7718B-X
CHANGER CONNECTOR AND JVC BUS IC = J801, IC801
4.8V
4.8V
4.8V
KD-R60J
*
*
*
*
CIRCT
RST
MICON
DISP.
*
*
*
*
ONLY
SERIES
KD-R820
FOR
VDD3.3V
KEYDATA
DISPDA
DISPCE
DISPCLK
DISPRST
PW.IC MUTE
SW5V
VDD3.3
RESET
PS2
MUTING CIRCUIT
BATT DETECT PS2
ILM.10V
ILM.ADJ
CD8V
9V-ADJ9VCTRL2
MEM-IN
CTRL1
GND
ACC.IN
ACC5V
VDD5V
SW5V
ANTOUT
*
*
0V
0V
0V
0V
0V
0V
0V
0V
0V0V
0V
0V
0V
3.2V
3.2V
0V
0V
0V
0V
3.2V
2.6V
3.2V
3.3V
0V
0V
0V
4.9V
4.3V
0V
0V
3.2V
3.2V
3.2V
0V
0V
0.2V
3.2V
0V
0V
0V
0V
0V
(1/4W)
(1/10W)
*
Ω
0V
FLG1
FLG0
NC
NC
NC
NC
RGBCLK
NCOPEN
NC
NC
RXM
NCNCNC
EN0
SD_OE
EN1
SDPWR
NC
NC
PSW
NC
NC
D710~D713:
10V
3.3V
0V
4.9V 4.9V
*
VOUT
VIN
GND
CTRL
*
*
*
*
JVC BUS CIRCUIT: R759, R762, R763,R764, R765, C163, C173
AUTO ANTENNA CIRCUIT, R724, D851, D852, C851, C852
KD-R80BTJ
KD-A65J
9V
USB3.3
GND
USB5V-R
MUTE.CTL
TRST
USBRX
USBTX
*
MEMORY
ACC
REMOTE
AUTO ANTENNA
GND
ILLUMINATION
KD-R80BTJ
USED FOR
KD-A65J
MAIN PWB:GEB10334A
SPR-OUT D-RESISTOR = R325, R326, R327, R328
CIRCUIT
SUBWOOFER
*
FOR U VERSION ONLY
E.VOLUME
REMOTE
STEERING
UNLESS OTHERWISE SPECIFIED.
NOTES
2.
1. VOLTAGES ARE DC-MEASURED WITH A DIGITAL VOLT METER WITHOUT INPUT SIGNAL
ALL RESISTANCE VALUES ARE IN OHM.
ALL E.CAPACITORS ARE SHOWN IN THE FORM OF CAPACITANCE(uF)/RATED VOLTAGE(V)
3.
ALL CAPACITORS ARE 50V OR 25V CERAMIC CAPACITOR.
ALL CAPACITANCE VALUES ARE IN uF(P=pF)
ALL RESISTORS ARE 1/16W 5% METAL GLAZE RESISTOR.
COMPONENTS IN ' NI ' INDICATE NOT USE.
DSPRST
KEYDATA
4.2v
-
-
+
+
GND
4.2V
0v
4.2v
4.2v
4.2v
CIRCUIT
MIC PREAMP
VCC
8.3v
4.2v
VOL2
EEPROM-DI VOLMUTE
DC_ERR
QD3R
QD3G
QD3L
OFFSET/TAB
TAB/NC
POWER CORD ASS'Y
0V
0V
0V
0V
0V
4.9V
4.9V
0V
0V
0V
0V
0V
0V
3.2V
Vdd
GND
2.2V
4.8V
2.0V
1.8V
4.2V
2.9V
7.8V
7.8V
0V
2.3V
3.8V
5.7V
0V
7.8V
6.3V
3.9V
3.2V
0.2V
0V5.4V
5.4V
3.7V
3.6V
0.4V
3.8V
3.2V
2.4V
0V
0V
0V
0V0V0V0V3.3V
1.6V
3.2V
0V
0V
3.8V
3.2V
7.8V
3.1V
3.2V
0V
0V
0V
0V
0V
3.1V
3.2V
0V
0V
0V
0V
3.2V
0V
0V
1.1V
1.4V
0V
0V
2.4V
1.0V
1.4V
3.2V
3.2V
3.2V
3.0V
0V(3.2V)
0V
0V
0V
3.2V
3.2V
3.3V
3.2V
0V
0V
0V
3.2V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
1.4V
0V
0V
AMSELOUT2
AMSELOUT1
AMIFAGC1
AMSELIN2
AMSELIN1
PLL2
PLLREF
PLL1
VCO
GNDRF
VCC
VREG
VREF
SDA
SCL
DGNDXTAL
TEST
RSSI
MPXOUT
MPXIN
AMIFAGC2
AGND
ROUT
LOUT
AMRFAGC
VCC
GNDRF
FMRFIN1
FMRFIN2
AMRFIN
AMRFDEC
4.1V
1.5V
1.5V
3.0V
6.0V
6.0V
3.7V
3.8V
3.8V
3.2V
3.2V
0V
0V
0V
3.3V
0V
3.3V
3.3V
0V
0V
0V
0V
3.2V
0V
0V
3.2V
0V
14.2V
0V
6.8V
6.8V
5.2V
6.8V
6.8V
0V
6.9V
6.8V
6.8V
6.8V
0V
6.8V
6.8V
6.9V
6.8V
0V
5.2V
6.8V
0V
0V
0V
3.2V
3.2V
3.2V
3.2V
0V
MUTING
(1/8W)
A0
A1
A2
WPIN
MUTING
GND
NC
VOL-CLK
VOL-DA
CD-0N
PS1
PS2
STEERING REMOTE
ANT CONT
OFFSET2
14.2V
ANTENNA
USBRX
USBTX
BUS-INT
EEPROM-D0
POWER CORD
REGULATOR
LINE OUTPUT
REMOCON
S-GND
USB RESET
LINE OUT
CD/OFFSET
R750 (L)/R751 (H)MICON STAGE SETTING =
CPU
*
* REMARKS
(1/10W)
(1/10W)
6.8V
0V
0V
USBMUTE CONT
JVC BUS
POWER AMP.
TUNER
FM/AM
(1/10W)
E-VOLUME IC = IC161
A-GND
BUS-I/0
OUTFL-
EEPROM
GND
INFL
OUTFL+
OUTRL+
OUTRL-
MUTE
INRL
SVR
GND
OUTFR-
GND
OUTFR+
INFR
INRR
OUTRR-
GND
VCC3/4
GND
TAB/NC
OUTRR+
VCC1/2
AC-GND
STBY
MEMORY.IN
BUS-SO
BUS-SI
Vdd
SCL
BUS-SCK
DISPCE
DIMMER INPUT
/BUS-I/O
CHANGER CONTROL
STAGE1
SDA
DETACH
EJECT
DIM
SWREG
SUBMUTE
KEY2
BUZZER
KEY1
KEY0
AUTO
GND
VDD
VOL1
DIMMER IN
AVREF0
REGC
EEPROM-CLK
OE_LEARNING1
DISPCK
DISPDATA
EVDDO
FLMDOX1EVSSO
VSSX2VDD
XT1
XT2
RESET
DEBUG-DA
DEBUG-CLK
RDS DA NA
NC
VDD
T.M
SW1
SUBWOOFER OUTPUT
&
SW3.3V
AMPKILL
*
ILM
POWER
MMRY
GND
OELRN1
OELRN2
AGND
TUSDA
TUSCL
TUSCL
VOLDA
VOLCK
AUX_R
AUX_L
EN0
EN1
SWREG
OFFSET2
FR+
FL-
OUTFR
OUTSPRR
OUTSPRL
OUTFL
USB5V_R
SWREG
OPEN
DETACH
RL0
FL0
FR0
RR0
SUB_L
SUB_R
PVCC
DISPDA
EJECT
KEYDATA
DISPCK
OPEN
EEPROMDI
EJECT
DETACH
REMOCON
DISPCE
AUX_G
SD_PWR
CD.L
CD.R
TU.L
TU.R
MUTE
AMPKILL
OELRN2
OELRN1
AUX.L
AUX.G
OE
SD_OE
SD_OE
SD_PWR
EN1
SD_OE
EN0
10V
DC_ERR
DC_ERR
OUTSPRL
OUTFL
OUTFR
OUTSPRR
E_MUTE
OFFSET2
OFFSET
E_MUTE
OUTRL
OUTRR
OFFSET
CH.L
CH.R
AUXR
AUXG
AUXL
REMOCON
ACCO
RESET
CH.R
CH.L
EXT
J-CLK
J-DATA
BUSSO
OE
BUZZER
MUTE
SWREG
BUS-I/O
TUSDA
RESET
PS2
AMPKILL
HC2-DET
CTRL
HC2-DET
HC2-DET
OE-REMOTE
ACC5V
KEYDATA
DSPRST
ANTENA
POWER
SBMUTE
SBMUTE
CD8V
/BUS-I/O
BUSSI
TU.L
TU.R
EEPROMDI
AUX.G
BUSSCK
CD.R
CD.R
CD.L
CD.L
AUX.L
REMO
FL+
SW1
AUXR
AUXL
AUX.R
SW1
TRVP
PSW
PSW
BUZZER
MIC
MUTE.CTL
PS2
TUSCL
AUXG
DSPRST
DISPCK
AUX.R
RL-
RL+
FL-
FL+
FR+
FR-
RR+
RR-
BUSINT
PS1
MUTE.CTL
TRST
RR+
FR-
PS2
USBRX
USBTX
ANT
VOLCK
VOLDA
RR-
RL-
TRST
BUS-I/O
BUSSO
BUSSI
RL+
BUSSCK
/BUS-I/O
BUSINT
DISPDA
DISPCE
OUTFR
OUTFL
OUTRR
USBTX
USBRX
OUTRL
MEMORY
USB3.3V
UTX
USB5V_R
SD_OE
GND
AGND
HC2-DET
SD_PWR
URX
TRST
MUTE.CTL
USB5V-F
9V
MIC
GND
CD8V
SW1
PSW
TRVP
CD.R
CD.L
sure to use the specified one.
When replacing those parts make
Parts are safety assurance parts.!
!
!
!
!
!
!
!
!
!
!
1 2 3
X701
NAX0647-001X
X11
QAX0952-001Z
X702
QAX0401-001
FLMDO
VSS
RESET
X1
VDD
TOOL0
DEBUGCLK
E-CK
E-DA
T.M
TXM RXM
T-DA
T-CK
MIC+
MIC-
4
32
1
QSW0451-001
S702
4
32
1
QSW0451-001
S701
3214
NSW0246-001X
S704
6 5
4 3
21
S703
QSW0648-001Z
R738
NI
R112
560
R310
4.7k
R90
10k
R14
3.3k
R108
1K
R756
47K
R776
47K
R777
1K
R10410
R931
91k
R97
8.2K
R321
1k
R109
1.2k
R92
8.2k
R103
0
R926
1.5k
R925
4.7k
R988
180k
R110
47k
R111
47k
NI
R91
R955
1K
R956
1K
R914
6.8K
R785
0
R935
47K
R958
270
R927
0
R100
10k
R93
1.2k
R180
NI
R770
470k
R937
200k
R277
1k
R279
1k
R758
10K
R954
100
R981 3.3k
R746
47K
R334 22k
R950
10k
R344 22k
R273
330
R272
22k
R325 NI
R326 NI
R327 NI
R328 NI
R338
0
R337
0
R335
0
R336
0
R308
NI
R303 0
R306 NI
R307 0
R173
0
R163
NI
R170
0
R354 22k
R747
47K
R749
47K
R162
2.2K
R702
10M
R161
10K
R160
0
R94
1.2k
C991NIR994
0
R276
180
R782 330
R703
0
R772
270
R851
NI
R771
270
R922
0
R923
0
R718 NI
R904
1.5M
NI
R3
R734
1.2K
R882
47K
R765
1K
R996
NI
R995
NI
R990
NI
R987
NI
R928
2.7k
R881
27K
R731
10k
R936
200k
R907
0
R719
47k
R784
NI
R701
47k
R748
47K
R712
0
R767
1K
R953
91k
R811
100K
R965
100
R768
12K
R979
0
R913
6.8K
R902 5.6K
R715
47k
R714
47k
R952
24k
R189
2.2K
R713
47k
R195
2.2K
R15
3.3k
R959
270
R728
47k
R392 0
R766
10K
R787 NI
R757
1K
R760
22k
R934
100
R921
0
R924
0
R783
10K
R786
0
R309
10
R733
NI
R315
NI
R313
270
R314
1K
R710
150
R774
2.2K
R720
NI
R717
NI
R729
22k
R808
47K
R391 0
R750
10K
R101
8.2k
R932
24k
R190
NI
R933
10k
R323
180
R333
180
R709
150
R102
0
R99
120k
R98
10k
R331
1k
R322
330
R332
330
R773
NI
R803
6.8K
R324 22k
R278
180
R11
0
R2
680K
R1
680K
R343
180
R311
1K
R791
10k
R790
100k
R814
0
R708
NI
R95
120k
R165
NI
R164
0
R175
NI
R174
0
R742
47K
R716
NI
R744
NI
R312
1K
R176
47k
R769
100k
R302
1K
R972
10k
R971
10k
R301
1K
R96
33K
R973 20k
R974
47k
R711
4.7k
R353
180
R724
2.2k
R905
4.7k
R906
27k
R723
2.2k
R166
47k
R810
100K
R351 1k
R725
39K
R304
4.7K
1/10W
R5
47
R781 47K
R341 1k
R735
3.9K
R342
330
R352
330
R736
3.9K
R754
100
R764
4.7k
R4
4.7K
R6
220
R7
220
R761
3.9K
R801
3.9K
R806
100K
R275
330
R274
22k
R807
100
R809
6.8K
R704
NI
R741
NI
R743
NI
R753
1K
R752
47K
R751
10K
R901
10K
R812
3.9K
R804
100
R805
47K
R977
47k
R305
47K
R727
2.2k
R722
2.2k
R759
1K
NI
R17
NI
R16
R726
22K
R976
68k
1/10W R8
47
R763
4.7k
R762
0
R975
47k
R721
100
R755
100
R737
NI
R167
470
R178
0
R168
0
Q881
DRC2114E-X
DRC2114E-X
Q301
Q785
DRC2124E-X
Q781
NI
Q782
DRA2114E-X
Q786
DRA2124E-X
Q970
2SC1623A/5-6/-X
2SC1623A/5-6/-X
Q702
Q971
2SC1623A/5-6/-X
Q701
2SA812A/5-6/-X
L702
4.7
L701
4.7
L7
4.7
L901
QQR1884-001
L703
4.7
L6
560
NQR0269-026X
L10
NQL79GM-101X
L902
QQL92AK-220Z
L941
22
QQL92AK-220Z
L931
22
NQL79GM-4R7X
L191
4.7
L8
4.7
L5
560
L9
0.47
L12
1.8
L11
0.47
L182
NI
L903
NI
L3
0.27
NQL79GM-4R7X
L181
4.7
NQLH25M-4R7X
K932
K706
NQR0022-005X
K708
NQR0022-005X
K707
NQR0022-005X
NQLH25M-4R7X
K941
15 14
13
12 11 10 9
8 7 6 5
4 3 2 1
QNZ0095-001
J801
100
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25242322212019181716151413121110987654321
UPD78F1167AGC
IC701
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16
17181920212223242526272829303132
IC1
TEF6614TV1S4-X
SE1L1SE1R2SE2L3SE2R4SE3L5SE3R6QD1L7QD1G8QD1R9QD2L10QD2G11QD2G_QP2R12QD2R_DSEL13CREF
14
GND
15
SWR
16
SWL
17
OUTFR
18
OUTRR
19
OUTRL
20
OUTFL
21
WINTC
22
MUTE
23
VDD
24
SCL
25
SDA
26
DC_ERR
27
WIN_IN
28
IC161
123456789101112131415161718192021222324252627
TDA7851A
IC301
151413121110987654321
LV5680P
IC901
1234567
8 9 10 11 12 13 14
IC801
74AHCT126PW-X
9
8765
4 3 2 1
BD9673EFJ-X
IC943
9
8765
4 3 2 1
BD9673EFJ-X
IC931
9
8 7 6 5
4321
BD00GA3WEFJ-X
IC921
1234
5 6 7 8
IC771
BR24T02FJ-W-X
1 2 3 4
8 7 6 5
NJM4565E-X
IC90
654
3 2 1
IMX9-W
Q322
654
3 2 1
IMX9-W
Q271
654
3 2 1
IMX9-W
Q332
VIN
5
EN4OC
3
GND
2
VOUT
1
RT9715EGB-X
IC953
43
2 1
IC902
XC6213B332NG-X
8 7
6 4
321
QQR1872-001
L4
FUSE
QMFZ064-100-J1
D782
BAW56-TP-X
3
2
1
D785
BAW56-TP-X
BAW56-TP-X
D722
D781
NI
D331
BAW56-TP-X
D321
BAW56-TP-X
D271
BAW56-TP-X
MC2838-X
D721
D735
SML-D12V8W-X
D734
D733
SML-D12V8W-X
D971
RKZ6.8B2KG-X
RKZ5.6B2KG-X
D730
D702
6.2V
D710
D704
6.2V
D110
NI
D111
NI
D705
6.2V
D706
6.2V
D171
NI
D161
NI
D712
RKZ6.2B2KG-X
D703
6.2V
D970
RKZ6.8B2KG-X
D713
D714
RKZ6.2B2KG-X
D711
D982
MBRX130-TP-X
D783
RKS801KF-X
D931
RB051L
D851
NI
D1
NI
D852
NI
1N5401-BPC04
D901
D932
RB051L
D2
NI
D786
RKS801KF-X
D981
MBRX130-TP-X
C922
100/6.3
C955
150/6.3
C365
10/25
C385
10/25
C942
150/6.3
4.7/35
QTE1V67-475Z
C172
QTE1V67-475Z
C162
4.7/35
C366
10/25
C179
100/16
C386
10/25
C169
10/16
NI
C851
C914
NI
C92
4.7/50
C908
220/10
C910
10/25
C905
47/16
C909
330/6.3
C917
220/6.3
C103
22/16
C881
22/16
QTE1C57-476Z
C317
47/16
C733
10/16
C96
22/16
C93
4.7/50
C316
4.7/50
C903
47/16
C306
10/16
C278
10/25
C928
100/16
C95
4.7/50
C904
100/16
C902
2.2/50
C276
10/25
C26
100/16
C907
100/16
QEKJ1HM-105Z-S
C161
1/50
1/50
QEKJ1HM-105Z-S
C171
C723
330/6.3
C901
2700
QTE1C66-474Z
C311
N
QTE1C66-474Z
C302N
QTE1C66-474Z
C301
N
QTE1C66-474Z
C312
N
C97
330p
C334
NI
C332
NI
C333
NI
C331
NI
C916
0.0033
NI
C912
C982
0.1
C4
0.22
C6
27p
C14
0.22
C7
470p
NI
C780
0.47
C335
C13
1
C25
0.01
C168
0.22
C707
NI
0.47
C336
0.47
C337
0.47
C338
1
C318
NI
C985
NI
C90
C932
10
NI
C91
C938
0.01
10
C931
NI
C936
C937
6800p
C921
1
C105
NI
C784
2.2
C976
10
10
C977
C983
0.01
NI
C786
0.1
C975
10
C974
C178
0.22
C709 0.1
C785
1
C929
2.7k
C98
0.033
C327
0.022
C326
0.022
C708
22p
C36
NAF0029-001X
C183
1
C961
470P
C963
470P
C962
470P
C964
470P
C965
470P
C966
470P
C967
470P
C968
470P
C181
1
C1921C1821C191
1
C163
1
C973
10
C979
6800p
C933
10
10
C934
0.1
C935
C173
1
NI
C193
C35
NI
C111
NI
C34
NI
C110
NI
C920
1
NI
C980
C15
0.1
C175
1
NI
C164
C177
680p
NI
C174
C167
680p
C176
0.47
C196
NI
C194
NI
C165
1
C307
NI
C308
NI
C305
82P
C166
1
C303
56p
C304
56p
C313
56p
C314
56p
C944
1
C946
0.47
C953
100p
C952
10
C315
1.0
C185NIC184
NI
C186NIC187
NI
C930
0.1
C100
0.027
C992
1000P
C101
22p
C726
10
C195
NI
C94
330p
NI
C927
NI
C926
C732
0.047
C731
0.047
C713
47p
C104
0.1
C102
0.033
C711
47p
C99
0.027
C712
NI
C325
NI
C180
0.0047
NI
C720
NI
C852
C918
0.01
C715 0.1
C31
NI
C8
2p
C319
0.022
NI
C990
C716
1
NI
C28
C701
22P
C10
1
C702
27P
C703 NI
NI
C29
C704 NI
C714
100P
C771
0.047
C310
82P
C324
NI
C5
15p
C911
0.1
NI
C802
C9
5.6p
C3
0.001
C22
12p
C1
0.001
C23
0.1
NI
C981
C721
0.047
C2
7p
C19
0.1
C925 10
C16
0.01
C718
0.1
C18
0.01
C727
0.047
C12
0.01
C11
0.01
C717
0.047
C906
0.1
C915
0.1
C17
0.1
C24
0.01
C801
NI
NI
C782
C722
0.01
C320
0.022
C322
NI
NI
C783
C323
NI
QNB0190-001
J1
984
SUBWOOFER_L5FRONT_L6REAR_L7SUBWOOFER_R1FRONT_R2REAR_R
3
J2
123456789
101112131415161718
CN901
QNZ0607-001
181716151413121110
987654321
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
QNZ0605-002
CN102
5
4
3
2
1
QGA2001F1-05
CN472
3
2
1
QGA2501C1-03
CN100
ELECTRIC UNIT-1
To ELECTRIC UNIT-2
CN601
To SWITCH UNIT
BATTERY, GND
To SPK,
To ELECTRIC UNIT-2
Cable
To MIC & AUX
OE Connector
created date:2012-03-14No.MA525
18
(No.MA525<Rev.001>)4/
Page 5
CONDITION
---FM MODE. ( )CD MODE.AM MODE.
*
SD CONNECTOR CKT
*
*
*
USB0.EN
FWD
USB1.EN
REV
CD16M
CDON
USB3.3V
GND
MIC
PSW
DAC_L
SW3
DAC_R
SW2
A_GND
SW1
B.MUTE
A9V
D+
UO+
UO-
USB 1
D-
USB 2
USB5V-1
USB5V_2
2.5V
3.3V
3.2V
0V
3.3V
0V
3.2V
3.2V
0V
3.2V
0V
0V
0V
1.3V
0V
2.2V
2.2V
3.3V
0V
0V
3.2V
3.2V
BLKCK
USBGND
A_MUTE
U1-
RESET
U1+
URX
UTX
U0-
U0+
D_BCLK
D_LRCLK
NRST
D_SDATA
STAT
MLD
MDATA
MCLK
WRITE PROTECT
CARD DETECT
SD_CS
PLACE D480, D481 CLOSE TO THE SD CARD CONNECTOR
* NOTE: C480 IS NOT REQUIRED IF Q480 COLLECTOR IS CLOSE TO PIN 4 AND C481
GND
SD_DO
SD_DET
USB3.3V
SD_CLK
SD_DI
SD_PWR
USB5V-F
SD/CD BUS SWITCH
H: HC2
L: HC1
HC2-DET
CD.L
A.GND
CD.R
SW1
9V
CD8V
PSW
TRVP
MIC
CDON
SW3
GND
NOT USED
1/10W
1/10W
2.5V
3.1V
1.9V
7.1V
0V
0V
0.6V
0V
3.4V
3.1V
3.2V
3.2V
0V
3.3V
3.1V
3.2V
3.3V
6.3V
7.1V
1.7V
1.7V
1.7V
0V
4.8V
3.2V
3.2V
1.7V
1.7V
1.7V
1.3V
4.8V
0V
1.7V
1.7V
1.7V
1.7V
1.7V
4.8V
5.4V
3.3V
1.7V
1.7V
1.7V
1.6V
1.6V
1.6V
1.7V
0V
0V
3.3V
1.7V
1.7V
1.5V
0V
0V
2.4V
3.2V
0V
3.2V
1.6V
0V
1.5V
0V
3.3V
0.1V
1.7V
1.7V
0V
3.3V
3.3V
1.6V
1.7V
0V
3.3V
0V
1.5V
0V
0V
0V
0V
0V
0.7V
3.2V
0V
3.3V
0V
1.1V
1.4V
1.4V
1.7V
0.8V
0V
1.7V
1.3V
1.2V
1.1V
1.1V
1.7V
1.7V
1.9V
3.4V
2.4V
0.2V
1.9V
1.9V
1.9V
1.9V
2.0V
2.0V
0V
GND
GND
USB5V-R
MUTE.CTL
TRST
USBRX
USBTX
3.3V
4.2V
8.3V
4.2V0V4.2V
-
+
4.2V
+
-
GND
Vcc
4.2V
4.2V
USB.GND
BLKCK
PSW
USBGND
U1-
U1+
USB3.3V
U0-
U0+
USB0.EN
USB1.EN
A_MUTE
RESET
URX
UTX
MIC
DAC_L
DAC_R
A_GND
A9V
GND
GND
CD16M
D_BCLK
D_LRCLK
NRST
D_SDATA
STAT
MLD
MDATA
MCLK
SW2
SW1
REV
B.MUTE
FWD
5-CH BTL DRIVER
* CSEL: L(R544)-16.9344MHz
SERVO DSP
HOT!
HOT!
H(R545)-33.8688MHz
GND
GND
NOTES
ALL E.CAPACITORS ARE SHOWN IN THE FORM OF CAPACITANCE(uF)/RATED VOLTAGE(V)
UNLESS OTHERWISE SPECIFIED.
1. VOLTAGES ARE DC-MEASURED WITH A DIGITAL VOLT METER WITHOUT INPUT SIGNAL
2.
COMPONENTS IN ( ) INDICATE NOT USE.3.
ALL CAPACITANCE VALUES ARE IN uF(P=pF)
ALL RESISTANCE VALUES ARE IN OHM.
ALL CAPACITORS ARE 50V OR 25V CERAMIC CAPACITOR.
ALL RESISTORS ARE 1/16W 5% METAL GLAZE RESISTOR.
MAIN PWB: GEB10334A
GND
VCC
SW1
SW2
SW3
PSW
CLK16M
REV
FWD
SD_DET
B_MUTE
CBCLK
STAT
SRDATA
NRST
MLD
MDATA
MCLK
CLRCK
BLKCK
MDATA
MCLK
MLD
STAT
SD_DI
SD_CS
CD_MCLK
CD_MDATA
TRK+
FOCUS+
CD_MLD
CD_STAT
TRVP
CD_MCLK
HC2-DET
HC2-DET
FOCUS-
TRK-
SW3
FEED+
FEED-
SW2
FOCUS-
FOCUS+
VREF
B_MUTE
SRDATA
SW1
PSW
VF2
VT2
VT1
VF1
LD
MD
SP-
SP+
TRK+
TRK-
LOAD-
LOAD+
VF1
VT1
VT2
VF2
BLKCK
NRST
TRP
MD
FOP
TRP
LOAD+
SP+
FEED+
CD_MDATA
SP-
FEED-
CD_MLD
SPOUT
CD_STAT
CLRCK
CBCLK
FWD
REV
TRVP
FOP
LOAD-
CLK16M
SPOUT
CD.R
TRVP
CD.L
PSW
SD_OE
MIC
SD_PWR
GND
HC2-DET
GND
AGND
USB3.3V
MUTE.CTL
TRST
URX
UTX
USB5V_R
SW1
9V
CD8V
USB5V-F
!
!
sure to use the specified one.
When replacing those parts make
Parts are safety assurance parts.!
123
X521
QAX0714-001Z
FLAG
DQSY
EXT2
OSCIN
PCMK
SMON0
SMON1
MONON
SMCK
TX
VREF
EXT3
ARF
EXT0
EXT4
EXT1
100R492
100
R494
R520 10
100
R493
47kR495
R588
27k
100R490
100
R496
100R491
100
R498
100
R497
100
R499
100
R479
0R471 0R472
0
R4730R474
R516 10k
R551
1k
R549 10k
100
R483
R572 33
R509 8.2k
100R487
R553
1M
47kR488
100
R489
47k
R482
NQR0360-004X
R561
47k
R486
22R547
R503
33k
R546 22
47k
R484
10R564
R518 8.2k
R552
220
R566
0
100
R485
10R563
47k
R480
0R556
R510
8.2k
1KR481
R524
68k
0
R562
8.2kR558
R504
8.2k
R475 NI
82k
R542
R476 NI
R523
33k
R705
NI
R581
NI
R517
6.8k
R577 NQR0022-005X
R576 NQR0022-005X
R575 NQR0022-005X
R574 33
R573 33
R512 15k
R571 33
R502 6.8k
R545 NI
R507 2.2k
R570 NI
R569 NI
R568 NI
R501
NI
R511
5.6k
R603
0
NI
R526
R550 1k
NIR555
R541 2.7k
R730
NI
R585
8.2k
47kR565
R587
27k
R594
10k
R593
10k
R591
10k
R521
8.2k
R592
10k
R505
8.2k
R515
5.6k
R586
8.2k
R508
10k
R506
NI
R519 33k
R514
8.2k
0R548
R513
15k
R540
820
R554 1k
R478
NI
NQR0360-004XR560
NIR908 NIR909
NI
R910
R477
NI
R522
5.1k
NIR543
R584
24k
R583
24k
8.2kR559
NI
R911
0R557
R544 0
Q481
RT1N141M-X
2SB1424/R/-WQ501
2SB1689-X
Q480
2SA2188/F/-X
Q540
1
4 3
2
LF473
3
2 1
4
LF472
NQR0682-001X
1.8L521
K581
NQR0022-005X
DQSY 80
(BCLK) GIO2 79
(LRCK) GIO1 78
(SRDATA) GIO0 77
NSRVMONON 76
IOVDD2 75
X1 74
X2 73
DVSS2 72
NRST 71
BLKCK 70
STAT 69
MLD 68
MDATA 67
MCLK 66
TX 65
FLAG 64
TEST 63
NTEST2 62
DVDD2 61
CSEL60EXT059(CD16M) EXT1
58
EXT257EXT356EXT455LSPWM54AVDD153OUTR52NC51AVSS150OUTL49RFVDD248VCOF47PLLFO246PLLFO45PLLF44IREF43DSLF42NC
41
RFVSS2
40
NC39
ARFIN38
ARFFB37
ARFOUT36
ARFDC35
RFIN34
RFOUT
33
RFENV32
CENV
31
RFVDD1
30
LD29
PD
28
A
27
C
26
B25
D
24
F
23
E
22
RFVSS1
21
CTRCRS
20
VREF
19
OSCIN
18
FOP
17
TRP
16
TRVP2
15
TRVP
14
SPOUT
13PC12FG11
DVSS1
10
DVDD1
9
IOVDD1
8NC7NC6NC5
SRVMON14SRVMON0
3
PMCK2SMCK
1
MN6627553PA
IC541
38
GND
37
GND
36
S-GND
35
VCONT
34
MUTE1
33
MUTE234
32
VIN4-
31
VIN4
30
VREF-IN
29
VREF-OUT
28
REG-OUT
27
REG-IN
26
VIN+OP
25
VIN-OP
24
VO-OP
23
VIN3
22
VIN3-
21
VIN2
20
VIN2-
19
VIN2+
18
VIN117VIN1-16VIN1+15VCCS14VCCP113VO1+12VO1-11VO2-10VO2+
9
VO3-8VO3+7VO4-6VO4+5VLO+4VLO-3VCC22REV1FWD
LA6565-X
IC501
S
1
1B1
2
1B2
3
1A
4
2B1
5
2B2
6
2A
7
GND
8
3A
9
3B2
10
3B1
11
4A
12
4B2
13
4B1
14
/OE
15
VDD
16
TC7MBL3257AFK-X
IC490
1234
8765
NJM4565E-X
IC581
VCC
5Y4
GND3IN2NC
1
NI
IC540
NI
D481
NAF0029-001X
D477 NI
NAF0029-001X
D709
NI
NI
D480
NAF0029-001X
D708 NI
NAF0029-001X
D478
NI
GS1J-LTP-X
D502
GS1J-LTP-X
D501
47/6.3
C558
47/6.3
C545
47/6.3
C550
47/6.3C559
C515
100/6.3
C586
4.7/50
C585
4.7/50
C590
47/6.3
C591
100/10
C571
10/25
C576
10/25
C579
10/25
C541
10/25
C543
10/25
C924
NI
C511
100/16
C513
47/16
C503
0.0056
C566 0.082
560P
C548
C560
NI
0.33
C554
0.1
C570
C502 NI
C507
6800p
3300pC553
C578 0.1
C506 NI
C505
2200p
0.1C573
C510
NI
0.015C563
0.1C551
0.1
C546
C562
0.1
2700p
C549
C577 0.1
C574 0.1
C508 NI
C512
0.1/16
C504
NI
0.33
C569
C572 NI
4.7C555
C509
68p
C584
820p
C592
0.1
C581
NI
C588
150p
C514 NI
C582
NI
0.1
C542
C587
150p
C583
820p
C561
0.1
C519
470P
0.1C556
C520
470P
C517
1000p
C589
C516 0.1
C565
1000p
C989
NI
82P
C538
0.15/16
C547
C476 NI
C568 1000p
C475 NI
0.1
C479
NIC484
0.022C552
0.1
C480
0.1C481
NI
C483
0.1
C544
NI
C482
C539
NI
NI
C485
C522 NI
C521
NI
C705 22P
C725
100p
C706
22P
C501
0.0022
680pC557
C575
0.1
C115
NI
C540
NI
0.1C564
NIC567
C114
NI
C477 22P
C518
NI
C478 22P
FOCUS+
1
FOCUS-
2
TRK+
3
TRK-
4
GND
5
LD
6
GND
7
FEED-
8
FEED+
9
SPINDLE-
10
SPINDLE+
11
LOAD+
12
LOAD-
13
HC2-DET
14
GND
15
MD
16
VREF
17
VT1
18
PSW
19
VT2
20
SW1
21
VF2
22
SW2
23
D3.3V
24
SW3
25
VF1
26
CN502
QGF1049F1-26X
181716151413121110
987654321
NI
CN442
181716151413121110
987654321
NI
CN448
181716151413121110
987654321
NI
CN441
181716151413121110
987654321
NI
CN447
10
9
8
7
6
5
4
3
2
1
QGA2001C1-10
CN103
2
1
NICN444
2
1
NI
CN445
11
5
3
10
13
9
4
8
12
NNZ0256-001X
J480
16
6
2
15
14
1
7
ELECTRIC UNIT-2
To ELECTRIC UNIT-1
CN444
To USB UNIT
CN442
To USB UNIT
CN441
To USB UNIT
CN101
To CD PLAYER UNIT
To ELECTRIC UNIT-1
To USB Cable
created date:2012-03-14No.MA525
18
(No.MA525<Rev.001>)5/
Page 6
10V
KD-A65
1.5K//10K
680
330
330
2.2K//2.2K
820
820
1.5K//8.2K
1K
1K
680
330
330
1.5K//NI
560
270
270
2.2K//3.3K
1K
1K
1.5K/NI
1.2K
1.2K
820
430
430R607
R608
R609
R610
R611
R612/R631
R613
R614
R615/R634
R618
R619
R620
R648/R649
KD-SD80BT
NOT USED USED
10V11.5V
NOT USEDUSED
KD-R50 KD-R60
KD-R80BTU/BTJ
*ILLUMINATION SUPPLY
9V LDO (IC610 C612 C613)
B610
* REMARKS
***
*
***
**
***
*
*
*
*
*
9V LDO
DISPLAY
USB
NEVI
ENCODER
ENCODER
( )
0
*ILLUMINATION SUPPLY
*
*
0V3.3V
GND VDD
3.3V
OUT
REMOCON
0V
5V
0V
0V
0V
0V
0V
5V
5V 5V
0V
0V
0.1V
0V
0V
0V
0.2V
0V
0V
0V
0V
0V
1
4.7
4.7K
GEB10328A2
10K
0.047
RKZ3.9B2KG-X
7p
7p
10/16
RKZ3.9B2KG-X
RKZ3.9B2KG-X
RKZ3.9B2KG-X
RKZ3.9B2KG-X
0.022
0.022
RPT/PHONE
5.6V
10V
5.0V
NCB31CK-105X
RGB DRIVER
DISPCLK
DISPCE
DISPDA
0V
NBE21CM-106X
T3-8
T3-7
T3-6
T3-5
T3-4
T3-3
NCB20JK-475X
3.27V
3.27V
3.28V
3.28V
3.27V
3.27V
1.25V
3.22V
3.18V
3.18V
3.17V
3.17V
3.16V
3.17V
3.21V
3.17V
3.23V
3.28V
0V
3.27V
3.27V
3.28V
0V
3.26V
3.26V
3.28V
1.6V
1.62V
3.26V
3.28V
0V
3.28V
0V
0V0V0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V0V0V
3.26V
3.26V
3.28V
3.28V
SWITCH PWB : GEB10328A1
T3-2
LED
0V
0V
0V
0V
3.3V
3.3V
3.3V
3.25V
MICON IC661
FOR PROGRAMMING
3.25V
3.3V
B
A
SELECT
EQ
MENU
PWR/SRC
ENCODER
T3-1
COLOR/RND/
KEY MATRIX
DOWN
UP
BACK/TP
DISP
B-SKIPF-SKIP
NBE20JM-106X
NCB20JK-106X
RED
GND
GREEN
BLUE
VLED
DISPRST
DISPRST
VDD3.3V
DISPDATA
DISPCE
KEY1
LCDDA
LCDCLK
LCDCD
LCDRST
LCDCS
LCDCD
LCDDA
LCDCLK
PTTX
PTCK
KEYDATA
KEYDATA
DISPCLK
REMOCON
10V
RESET_DISP
KEYIN
KEY0
KEY1
SCL
SDA
VOL2
VOL1
KEY0
LCDCS
PTRX
E8_BUSY
CNVSS
R
G
B
KEYIN
KEYDATA
DISPDATA
DISPCLK
E8_BUSY
PTCK
PTRX
PTTX
DISPRST
VOL1
VOL2
CNVSS
RGB
LCDRST
DISPCE
SCL
SDA
1
2
3
X661
NAX0613-001X
PTRX
RST
PTCK
CNVSS
E8-BUSY
PTTX
VDD
GND
T2-2
T2-1
T2-3
T2-4
T1-1
T1-3
T1-2
T1-4
NAD0028-103X
TH601
4
3
2
1
NSW0246-001X
S667
4
3
2
1
NSW0246-001X
S665
4
3
2
1
NSW0246-001X
S661
4
3
2
1
NSW0246-001X
S662
4
3
2
1
NSW0246-001X
S663
4
3
2
1
NSW0246-001X
S664
4
3
2
1
NSW0246-001X
S671
4
3
2
1
NSW0246-001X
S668
4
3
2
1
NSW0246-001X
S669
4
3
2
1
NSW0246-001X
S670
5
6
7
8
4
3
2
1
RA663
NI
567
8
432
1
RA662
NI
R612 1K
R646
47K
R668 15k
R648
NI
R649
1.8K
R630
2.7K
R644
1K
R685
1K
R686
NI
R681
0
R697
470K
R683
330
R624
1.8K
R658
47K
R666 10K
R675
330
R663
1M
B606
NI
R659
NI
R698
330
R610 680
R660 150K
R696 47k
R700 NI
R627
820
R680 10K
R692 4.7K
R689
10K
R657
47K
R674
47K
R615
1.8K
R613
1K
R614
1K
R695 47k
R650 4.7K
R628
1.2K
R664 10K
B610
ni
R653
680
R633 680
R632 680
R631 680
R621
820
R634
10k
R642 47K
R602 100
R601 100
R643 NI
R604
1K
R606 NI
R669 10k
R655 1K
R690 10K
R691 4.7K
R641 47K
R645
100
R687
1K
R626
820
R665 330
R693 10K
R652 680
R623
1.2K
R611 680
R622
820
R605
0
R647
2.2K
R603 1K
R607 430
R608 430
R609 820
R656 10K
R618 270
R661 2.2K
R654 1K
R679
10K
R670 10k
R625
2.7K
R629
1.8K
R651 4.7K
R662
0
R637
10M
R671 10K
R667
1K
R620 560
R619 270
Q601
2SC1623A/5-6/-X
Q603
2SA812A/5-6/-X
Q602
2SA812A/5-6/-X
L661 47
L603
47
NQR0022-005X
L604
3 4
12
5
QSW1231-002
EN601
NC100
NC99
RY/BY98
AVCC97
VREF96
NC95
AVSS94
KEY093
KEY192
KEY291
THERMAL90
ANA89
NC88
MEMRST87
D086
D185
D284
D383
D482
D581
D680
D779
P1078
P1177
P1276
P1375P1474P1573P1672P17
71A070A169A268A367A466A565A664A763
VSS
62A861
VCC2
60A959
A1058A1157A1256A1355A1454A1553A1652A17
51
A18 50
A19 49
FLASHCS 48
LCDCS 47
LCKCL 46
LCDDA 45
/CE 44
LCDWR 43
LCDRD 42
NC 41
NC 40
E8_EPM 39
NC 38
NC 37
NC 36
DISPCLK 35
DISPDATA 34
KEYDATA 33
E8_BUSY 32
PTCK 31
PTRX 30
PTTX 29
NC 28
NC 27
NC 26
NC25NC24NC23NC22NC21/OE20LCDRST19KEY_IN18DISPCE17NC16NMI15VCC114XIN13VSS12XOUT11RESET10XCOUT9XCIN8CNVSS7BYTE6VOL15VOL24SCL3SDA2NC
1
R5F3650KDFB
IC661
VSS
1
A0
2
A1
3
A2
4
A3
5
A4
6
VSS
7
LED0
8
LED1
9
LED2
10
LED3
11
VSS12VSS
13
LED4
14
LED5
15
LED6
16
LED7
17
VSS
18
/OE
19
A5
20
A6
21
SCL
22
SDA
23
VDD
24
PCA9624PW-X
IC601
VOUT
5
CE4NC
3
VSS
2
VIN
1
XC6216B902MR-X
IC610
GND2NC
1
VDD
4
RST
3
IC602
XC6120N242NG-X
321
IC681
KSM-2003TN5B
1
2
456
3
NSSM065T-X
D605
1
2
456
3
NSSM065T-X
D604
1
245
6
3
NSSM065T-X
D609
1
245
6
3
NSSM065T-X
D610
1
2
456
3
NSSM065T-X
D601
1
2
456
3
NSSM065T-X
D602
1
3
2
D630
MC2838-X
Display
D620
SML-D12V8W-X
D615NID613NID614NID612NID611
NI
D618
RKZ5.6B2KG-X
D682
RKZ3.3B2KG-X
D651
RKS801KF-X
C667
10/6.3
C681
C604 10/16
C603 NI
C620
NI
C668
NI
C699
NI
C602
1
C601
0.1
C662 10
C609
NI
C682
0.1
C623
NI
C605 0.01
C606 0.1
C608
4.7
C607
4.7
C650
1
C610
NI
C611
NI
C612
0.1
C613
1
C614
0.1
C698
NI
C665
NI
C642 4.7
C671
0.047
C664
NI
C663 0.047
C621
NI
C622
NI
C641 0.01
C669
0.047
C661 0.047
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
NNZ0085-001
CN601
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
QGF0534F5-15X
CN602
SWITCH UNIT
CN102
To ELECTRIC UNIT-1
To LCD
created date:2012-03-14No.MA525
18
(No.MA525<Rev.001>)6/
Page 7
2.8V
NQR0286-007X
R601, R602, R603:
0V0V3.2V
3.2V
3.2V
3.2V
3.2V
R2
R1
=
RT1N441C-X
R2 = 47k
R1 = 47k
L409,L410:
NQR0682-001X
R406:
NQR0022-005X
R407,K445:
NQR0286-007X
NQR0286-007X
K447,K448,K454:
K442,K443,K444,
3.2V
3.2V
3.2V
3.2V
3.2V
3.2V
3.2V
0V
3.2V
1.6V
3.2V
CONDITION -- REAR USB MODE
2.4V
0V
0V
0V1.8V
3.2V3.2V
3.2V
3.2V
3.2V
0V
0V0V0V
0V
3.2V
3.2V
1.6V
1.6V
0V
0V
1.6V
1.6V
1.6V
0V
3.2V
3.2V
3.2V 2.5V
2.6V
2.6V
5.2V
0V
0V
0V
0V
0V
0.2V
0.2V
0.2V
0V
0.1V
0.2V
0V
0.2V
0V
2.6V
0.7V
0.8V
0.9V
2.4V
0.6V
0V
2.6V
0.9V
2.0V
0V
0.9V
0V
0V
3.2V
3.0V
0V
0V
0.2V
0.2V
0.3V
0.2V
0.2V
0.2V
0.1V
0.2V
3.0V
3.2V
3.2V
0V
3.2V
3.2V
3.3V
3.2V
3.2V
0V
3.2V
0.1V
0.2V
0.2V
0.2V
0.3V
0.2V
0.2V
0.2V
0V
0.2V
0V
0.2V
0.2V
0.2V
0.1V
0.2V
0.2V
0.1V
0.2V
0.2V
0.2V
0V
2.6V
2.0V
0.9V
2.6V
0.9V
2.4V
0.6V
0.6V
0.9V
2.4V
0.9V
2.6V
2.0V
2.8V
2.8V
2.8V
2.8V
2.8V
2.8V
2.8V
2.8V
0V
3.2V3.0V
0.9V
3.0V
0.9V
0V
0V
0V
0.7V
0.8V
0V
2.6V
0.7V
0.8V
3.3V
1.1V
1.6V
0.9V
0.9V
3.0V
1.6V
0.2V
0.3V
0.2V
0.2V
0.2V
0.1V
0.2V
0.2V
0.2V
0V
0V
3.2V
1.6V
1.6V
1.6V
3.2V
0V
3.0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V0V0V
1.8V
1.8V
1.8V
1.8V
1.8V
1.8V
1.8V
1.8V
1.8V
0V
3.2V
3.2V
3.2V
3.2V
3.2V
3.2V
3.2V
3.2V
3.2V
3.2V
3.2V
3.2V
3.2V
3.2V
3.2V
3.2V
3.2V
3.2V
3.2V
0V
0V
0V0V0V
0V
0V
0V
3.2V
3.2V
3.2V
3.2V
3.2V
3.2V
0V
3.2V
3.2V
3.2V
3.2V
3.2V
3.2V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
3.2V
3.3V
NQR0286-007X
NQR0286-007X
R451 - R454, R521:
NQR0022-005X
L404,L405,L407
RESET
= 1.406V (rms)
= 3.978V (p-p)
VOUT(p-p) = 0.78 x VCC
* DAC 0dB OUTPUT LEVEL:
PWB NO.: GEB10288A
2.
1.
ALL 0.1uF C.CAP ARE 16V OR 10V RATING.
3.
L(R420)-NOR FLASH
BM2:H(R423)-J.T.A.G.
* BOOT MODE:
SDRAMNOR FLASH
BURR BROWN 24-BIT DAC
IPOD A.IC
1.8V REGULATOR
DEBUGGER
J.T.A.G.
T --- TANTALUM CAPACITOR.
NOTES
ALL E.CAPACITORS ARE SHOWN IN THE FORM OF CAPACITANCE(uF)/RATED VOLTAGE(V)
ALL CAPACITANCE VALUES ARE IN uF(p=pF)
ALL RESISTANCE VALUES ARE IN OHM.
ALL CAPACITORS ARE 50V OR 25V OR 16V CERAMIC CAPACITOR.
UNLESS OTHERWISE SPECIFIED:
VOLTAGES ARE DC-MEASURED WITH A DIGITAL VOLT METER WITHOUT INPUT SIGNAL
NI INDICATES NOT INSERTED.
ALL RESISTORS ARE 1/16W +5% METAL GLAZE RESISTOR.
USB.GND
USB.GND
USB3.3V
U0-
U0+
SCLK
MIC
U1-
U1+
SW3
ESDA
ESCL
ESDA
ESCL
SW3
SW2
SW2
OE
XA20
SW1
URX
UTX
SW1
PSW
MIC
FWD
REV
B.MUTE
RESET
A.MUTE
USB1.EN
A.MUTE
RESET
USB0.EN
NOR_CS
WE
A_GND
NRST
D_BCLK
D_LRCLK
D_SDATA
USB1.EN
USB0.EN
D_RESET
RESET
PSW
DACMS
DACMD
CD16M
MLD
A9V
DAC_R
DAC_L
CD16M
BLKCK
STAT
MCLK
MDATA
MCLK
MLD
STAT
BLKCK
MDATA
DACMC
DAO
BCLK
LRCLK
REV
MODE0
MODE0
XA0
DAO
CLKSW
XA12
XA11
XA10
XA9
XA8
XA7
XA6
XA5
XA4
XA3
XA2
XA1
XA0
XD4
XD5
XD6
XD7
XD8
XD9
XD10
XD11
XD12
XD13
XD14
XD15
NRST
XD3
XD2
XD1
XD0
D_BCLK
D_LRCLK
D_SDATA
DACMD
DACMC
DACMS
CLKSW
SCLK
LRCLK
BCLK
U1+
U1-
U0+
U0-
UTX
URX
B.MUTE
FWD
NOR_CS
OE
SDCS
SDCKE
SDCLK
XA21
XA20
XA19
XA18
XA17
XA16
XA15
XA14
XA13
XA16
XA15
XA14
XA13
XA12
XA11
XA10
XA9
XA8
XA19
WE
D_RESET
XA18
XA17
XA7
XA6
XA5
XA4
XA3
XA2
XA1
XD0
XD8
XD1
XD9
XD2
XD10
XD3
XD11
XD4
XD12
XD5
XD13
XD6
XD14
XD7
XD15
XA3
XA2
XA1
XA0
XA10
XA14
XA13
SDCS
XA16
XA15
WE
XA21
XD0
XD1
XD2
XD3
XD4
XD5
XD6
XD7
XA4
XA5
XA6
XA7
XA8
XA9
XA11
SDCKE
SDCLK
XA20
XD15
XD14
XD13
XD12
XD11
XD10
XD9
XD8
!
!
!
sure to use the specified one.
When replacing those parts make
Parts are safety assurance parts.!
12MHz
NAX1168-001X
X401
TMS
TCK
TRST
GND
BM2
TDO
UIRX
U1TX
TDI
NI
R471
R417
270
R462 0
R463 0
R610
NI
22k
R409
R602
NI
R434
R481
47k
2.2k
R421
R416
270
22k
R408
4.7k
R423
4.7k
R415
R605
22
R425
1k
R604
22
R606
22
1/8W
R608 180
R607
22
R603
R601
R426
4.7k
R427
4.7k
R428
100
R420 4.7k
R441
0
R419 4.7k
R457 33
R456 33
R455 33
R418 4.7k
R414 33
NI
R442
R443 4.7k
R405 1M
R429
4.7k
R413 33
R412 33
R411 33
2.2k
R422
R410
4.7k
R458 0
R430 100
NI
R465
R403
47
R404
150
NI
R464
R407
R450 NI
NI
R468
0
R469
R431 100
NI
R470
R402
47
10k
R435
R436
10k
1/8W
R609 180
R521
R454
R453
R452
R451
R406
R449 NI
R448 NI
R447 NI
R401
47
R432
1k
R446 4.7k
R445
4.7k
NI
R459
R444 47k
LTC044EUB-X
Q401
LF409
LF410
0.12L402
0.12L401
L407
L491
4.7
L404
L406
150
1/10W
L403
0
L601 47
L405
K443
K442
NI
K450
K444
K447
K445
NI
K449
NQR0286-007X
K446
K441 NQR0502-001X
NIK454
K448
NQR0286-007X
K452
NQR0286-007X
K453
NQR0022-005X
K451
XD3128
XD2127
XD1126
XD0125
VDDI124
GPIOA15/EXINT3123
GPIOA14/EXINT2122
GPIOA13/EXINT1121
GPIOA12/EXINT0120
VDDIO119
VSS118
GPIOA11/SCL117
GPIOA10/SDA116
GPIOA9/SCL115
GPIOA8/SDA114
GPIOA7/SDI1113
GPIOA6/FRM1112
GPIOA5/SCK1111
VDDI110
GPIOA4/SDO1109
GPIOA3/CDAI108
GPIOA2/CLRCK107
GPIOA1/CBCLK106
GPIOA0/SPDIFTX105
nTRST_JTAG104
TDO103
TCK102
TMS101
TDI100
GPIOD2199
GPIOD2098
VSS97
UART1RX
96
UART1TX
95
GPIOD17
94
GPIOD16
93
GPIOD15/UART1CTSn
92
VDDI
91
GPIOB25/DAI
90
GPIOB24/DAO/BM2
89
GPIOB23/MCLK
88
GPIOB22/LRCK/BM1
87
GPIOB21/BCLK/BM0
86
VDDIO
85
VDDUSB
84
USB1D+
83
USB1D-
82
VSS
81
USB0D+
80
USB0D-
79
MODE1
78
nRESET
77
VSSPLL
76
XFILT
75
VDDPLL
74
VDDPLL1
73
XFILT1
72
VSSPLL1
71
VSSADC
70
VDDADC
69
ADIN0
68
ADIN2
67
ADIN4
66
VDDIO
65
READY/MODE0 64
CTRL/UART0RX/GPIOB9 63
FLAG/UART0TX/GPIOB8 62
ND_nWE/GPIOB7 61
GPIOB6/IIDE_nCS 60
VSS 59
VDDI 58
XTIN 57
XTOUT 56
XIN 55
XOUT 54
nCS3/ND_NOE3/GPIOB5 53
nCS2/ND_NOE2/GPIOB4 52
nCS1/ND_NOE1/GPIOB3 51
nCS0/ND_NOE0/GPIOB2 50
nOE 49
nWE 48
SD_nCS/GPIOB1 47
SD_CKE/GPIOB0 46
VSS 45
SDCLK 44
VDDIO 43
XA21/DQM0 42
XA20/DQM1 41
VDDI 40
XA19/DQM1 39
XA18/DQM0 38
XA17/ND_CLE 37
XA16/SD_nRAS/ND_ALE 36
XA15/SD_nCAS 35
XA14/BA1 34
XA13/BA0 33
XA12
32
XA11
31
XA10
30
XA9
29
XA8
28
XA7
27
VDDIO
26
VSS
25
VDDI
24
XA6
23
XA5
22
XA4
21
XA3
20
XA2
19
XA1
18
XA0
17
XD15
16
XD14
15
XD13
14
XD12
13
XD11
12
XD10
11
XD9
10
VDDIO
9
VSS
8
VDDI
7
XD8
6
XD7
5
XD6
4
XD5
3
XD4
2
VSS
1
TCC8600
IC401
VSS
54
DQ15
53
VDD
1
DQ0
2
VDDQ
3
DQ1
4
DQ2
5
VSSQ
6
DQ3
7
DQ4
8
VDDQ
9
DQ5
10
DQ6
11
VSSQ
12
DQ7
13
VDD
14
LDQM
15
/WE
16
/CAS
17
/RAS
18
/CS
19
BA0
20
BA1
21
A10/AP
22
A0
23
A1
24
A2
25
A3
26
VSSQ
52
DQ14
51
DQ13
50
VDDQ
49
DQ12
48
DQ11
47
VSSQ
46
DQ10
45
DQ9
44
VDDQ
43
DQ8
42
VSS
41
NC/RFU
40
UDQM
39
CLK
38
CKE
37
NC
36
A11
35
A9
34
A8
33
A7
32
A6
31
A5
30
A4
29
VSS
28
VDD
27
IC442
A3V28S40FTP-G6
A15
1
A14
2
A13
3
A12
4
A11
5
A10
6
A9
7
A8
8
A19
9
A20
10
/WE
11
RST
12
NC
13
WP/ACC
14
R//B
15
A18
16
A17
17
A7
18
A6
19
A5
20
A4
21
A3
22
A2
23
A1
24
A0
25
/CE
26
VSS
27
/OE
28
D0
29
D8
30
D1
31
D9
32
D2
33
D10
34
D3
35
D11
36
VCC
37
D4
38
D12
39
D5
40
D13
41
D6
42
D14
43
D7
44
D15
45
VSS
46
/BYTE
47
A16
48
IC441
EN29LV320BT70TI
NC
20
NC
19
NC
18
NC
17
NC
16
NC
15
MODE0
14
I2C_SDA
13
I2C_SCL
12
VSS
11
NC
10
NC
9
NC
8
NC
7
NC
6
VCC5nRESET4NC3MODE12NC
1
IC481
MFI341S2162-X
ZEROL
1
/MS
2
MC
3
MD
4
SCK
5
DATA
6
BCK
7
LRCK
8
NC
9
NC
10
VCC
11
AGND
12
VCOM
13
OUTR
14
OUTL
15
ZEROR
16
IC601
PCM1780-X
A01A12A23GND
4
SDA
5
SCL
6WP7
VDD
8
R1EX24512ASAS-X
IC402
S
6
VCC
5
A
4
CD16M
3
GND
2
SCLK
1
74LVC1G3157GW-X
IC471
VIN
4
VOUT3GND
2
STBY
1
IC491
NJM2878F4-18-X
D601
5.1V
NQR0450-001XC430
T
C442
22/6.3
T
C443
22/6.3
T
C491
47/10
T
C604
47/10
T
C495
22/6.3
T
C601
47/10
560p
C410
C418
0.15/16
C416
10
C417
330p
C415
1200p
0.1
C414
0.1/16
C471
C605
100p
C401
560p
0.1/16
C425
C606
100p
C426
20p
0.1
C409
560p
C405
470p
C406
C402
560p
C408
27P
C407
27P
C403
560p
C453
470p
C452
470p
C451
470p
C456
NI
C404
560p
0.1
C441
NI
C457
C419
560p
560p
C448
560p
C447
560p
C446
560p
C445
560p
C444
560p
C449
560p
C450
C455
15k
C454
15k
0.1/16
C424
0.1/16
C423
0.1
C422
C497
330p
NI
C496NIC498
NI
C429
NI
C428
NI
C427
C420
560p
C421
0.1
0.1
C482
0.1
C481
C494 0.1/16
C492
10/6.3
C493
0.1
NIC411
C603
0.1
C602
0.012/16
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
QGG2011M1-18X
CN441
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
QGG2011M1-18X
CN442
2
1
QGG2504M5-02
CN444
USB UNIT
CN441
To ELECTRIC UNIT-2
CN442
To ELECTRIC UNIT-2
CN444
To ELECTRIC UNIT-2
created date:2012-03-14No.MA525
18
(No.MA525<Rev.001>)7/
Page 8
LVB11141-A2
SW GND
LD
SW3
FOCUS-
LD
VR
MD
VT2
TRACKING+
Vc
VF2
VT1
GND
Vcc
TRACKING-
VF1
FOCUS+
GND
VT1
GND
VF1
FOCUS+
Vc
VF2
Vcc
TRACKING-
GND
FOCUS-
LD
VT2
VR
TRACKING+
MD
109876
5 4 3 2 1
HDU-120
0.1
1k
0.1
1
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
PICKUP A'SSY
OPTIMA-750B1
FOCUSING COIL TRACKING COIL
SPINDLE+
MD
PSW/REST
SW2
FEED+
SPINDLE-
TRACKING-
SW1
FOCUS-
VT1
Vcc
LVB11141-A1
MOTOR
MOTOR
MOTOR
LOAD
FEED
SPINDLE
LOADING-
LOADING+
GND
FEED-
TRACKING+
FOCUS+
GND
VREF(Vc)
VF1
VT2
VF2
SW GND
REST SW
SW2
TR-
LD
LD
SW1
SW2
SW3
VT2
VCC
LO-
VT1
VC
MD
VF2
REST
VF1
LO+
FO+
SP-
FO-
FE+
FE-
TR+
SP+
SW1
SW3
TR-
TR+
FO+
FO-
MD
VF1
VC
VT1
VT2
VCC
VF2
LO+
LO-
FE-
FE+
REST
SP-
SP+
MGND
FE+
FE-
LO+
SP-
SP+
LO-
REST
SL1
SL2
NSW0291-001X
SW2
NSW0291-001X
SW4
NSW0291-001X
SW3
13
NSW0291-001X
SW1
R1 130
B1
0
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
QGF1044F2-26X
CN101
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
QGF0522F3-15W
CN102
CD PLAYER UNIT
CN502
To ELECTRIC UNIT-2
created date:2012-03-14No.MA525
18
(No.MA525<Rev.001>)8/
Page 9
ELECTRIC UNIT
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
F1A
S1A
SPACER
SPACER
SPACER
SPACER
SPACER
A
A
1
1
1
1
1
1
1
1
1
1
1
1
GEA10334- A
R111
R110
R728
C920
R926R925
IC921
C187
C186
C185
C184
LF473
C955
R954
B910
R953 R952
C979
C980
R950
C983
CN448
B905
B904
CN447
R776
R777
B903
R108
R109
R112
C196
C195
D733
D735
D734
C194
S704
CN102
CN445
B105
B902
R474
R473
R472
R471
R913
J2
PP4
B103
B908
S702
S701
MARK
UL
PbF
CN103
B102
B101
C485
R481
R480
C480
Q480
R482
D481
C484
D480
C482
C483
C481
R485
R484
R486
R489
R488
R487
R483
J480
R479
R499
R497
R498
R491
R496
R490
IC490
R495
R493
C479
R494
R492
C475
R475
C476
R476
C538
R574
R573
R572
R571
C520
C519
R570
R569
R568
CN502
R911
R910
R909
R908
R988
C586
C583
C585
R585
C587
R587
C590
C582
C588
R586
R588
C581
C592
C591
C478
CN444
R478
D478
D477
C477
R477
LF472
CN472
CN442
C584
R584
R583
CN441
X521
IC541
C543
C541
C579
C576
C555
C571
IC581
C572
C512
C508
C549
C546
C551
R555
C550
C573
C505
R501
R502
R517
L521
C578
C553
C507
C554
C559
R564
C560
R561
R549
C503
C558
C513
R516
R553
C548
R503
C570
C502
R563
R524
Q501
C506
R511
C510
Q540
C562
R508
C577
C574
R506
R514
C504
R548
R554
C545
R515
C514
R505
C542
C561
R507
C556
R545
R512
C516
IC540
R523
C547
R504
R509
C552
R518
R510
R558
C544
R513
R557
C511
C515
C501
C557
C575
R547
R544
R559
R560
CN100
C942
L181
R277
R279
D271
Q271
C278
R273
R272
R325
R326
R327
R337
R335
R336
R308
R303
R306
R307
R173
R163
R170
C191
C182
C192
R162
C181R161
R160
IC161
L191
C967
C964
C963
R748
C183
R928
C928
C929
L903
R907
C785
R784
D786
L182
R955
K706
K708
K707
R902
C902
L4
S703
J1
J801
R766
R787
C784
R934
R921
R924
R783
D785
Q786
Q785
R315
R313
R314
Q301
R774
R720
R717
Q481
B901
R935
C938
PP3
PP2
R914
L902
C161
C171
C311
N
C312
N
C302
N
C301
N
R791
R790
C780
R165
R164
R175
R174
R742
R716
R744
D781
D783
D782
Q782
R972
R971
Q971
Q970
R973
R974
D970
D971
C982
R810
C331
C333
C332
C334
R781
C4
C14
C25
L6
C168
D708
C706
C276
R275
R274
C786
C709
R704
R741
R743
R751
C95
C98
C163
C173
R305
C316
C35
C34
R17
R16
C15
C175
D171
D161
C164
C177
C174
C167
C176 R167
R178
R168
C165 C166
C162
C172
R733
C922
R190
R180
R937
R730
R705
R276
R310
C917
C927
IC902
C926
C733
R768
C731
R770 D721
D722
L703
R769
Q701
Q702
Q332
Q322
R278
R786
R195
R189
R746
IC90
R758
C711
C97
C102
C104
R979
R93
C93
C96
R94
R99
C103
R96
C94
R95
R97
C101
C92
IC901
R756
R754
C705
C315
R309
R785
D331
D321
R710
R709
C314
C313
C304
C303
R311
R312
R302
R301
IC301
X701
X702
X11
R755
R975
R762
R763
R8
R976
C115
R726
R759
R722
R727
R977
R804
R812
R901
R809
R807
R806
R801
R761
R7
R6
R4
R764
R736
R735
R341
R5
R304
R725
R351
R166
R723
R724
R711
R176
R814
R14
C114
R803
R331
R321
R981
R750
R808
R729
R760
R757
R15
R713
R714
R715
R811
R767
R712
R719
R731
R881
R765
R882
R734
R718
R923
R922
R851
R703
R782
R749
R747
Q881
Q781
L701
L7
L702
L901
L3
R738
R737
L5
IC701
IC1
IC801
D713
D714
D711
D712
D709
D710
D851
D901
D982
D852
D981
CN901
C365
C385
C366
C179
C386
C169
C851
C914
L941
C908
C910
C905
C909
C881
C317
C903
C306
C904
C924
L931
C26
C907
C901
C723
C180
C852
C918
C715
C31
C990
C716
C28
C10
C703
C29
C704
C714
C23
C981
C19
C925
C16
C718
C18
C12
C11
C717
C17
C24
C801
C782
C783
created date:2012-03-14No.MA525
18
(No.MA525<Rev.001>)9/
Page 10
P1A1T1A
1
1
1
GEB10334A
L12
L11
L13
C111C110
D111D110
D730
B913
B912
C955
IC953
B911
C977
C976
IC943
C973
C974
C975
K941
K932
B905
B904
B909
C522
B903
CN102
CN445
B902
D932
J2
PP4
B908
R999
F100
S702
S701
R998
R959
R958
R997
CN103
C989
C985
R581
R577
R576
R575
R603
C993
R526
D502
C586
C585
R594
R593
R591
C590
R592
C591
CN444
CN472
CN442
K581
CN441
R566
B907
C726
X521
ARF
VREF
SMCK
MONON
SMON1
SMON0
OSCIN
DQSY
PCMK
FLAG
TX
EXT3
EXT4
EXT1
EXT2
EXT0
C543
C541
C579
C576
C571
C569
C563
C550
R556
C559
IC501
C566
R551
C558
C513
R552
R550
R546
D501
R540
C509
R543
R519
C545
R565
R541
C517
C565
R542
C568
R520
C539
R522
C511
R521
C515
R562
C540
C564
C567
C518
CN100
C986
R927
C946
C944
R986
R985
C942
R984
IC931
C935
C934
C933
R993
C278
R328
R338
C991
R994
C968
C966
C965
C962
C961
C36
C708
C326
C327
R956
R996
R995
R990
R987
C928
C521
C178
T.M
TXM
RXM
T-CK
T-DA
E-CK
C992
R965
E-DA
C902
L4
S703
J1
J801
C921
C937
B901
C936
R992
A-GND
R932
R933
C931
D931
PP3
C932
PP2
R931
C161
C171
C318
C338
C337
C336
C311
C312
C302
C301
C335
C7
L10
C996
R905
R906
C912
C916
C6
C13
L6
C707
C995
C90
C91
C105
C276
R753R752
B906
C95
C193
C316
C162
C172
R936
C922
C725
C953
C994
C952
VDD
X1
RESET
VSS
FLMDO
TOOL0
DEBUGCLK
MIC+
MIC-
C917
C733
C732
C713
C99
R90
R100
R92
C93
C96
R104
C103
R103
C92
R91
C100
R101
R102
R98
IC901
D702
C305
C308 C307
IC301
X702
X11
R721
R805
R352
R342
R353
R708
R343
R1
R2
R11
R324
R773
R332
R322
R333
R323
R701
R3
R904
R771
R772
R702
R354
R344
R334
L901
L3
L9
L5
L8
IC771
R392
D703
D706
R391
D705
D704
D2
D1
D901
CN901
C365
C385
C366
C179
C386
C169
C851
C914
L941
C908
C910
C905
C909
C881
C317
C903
C306
C904
C924
L931
C26
C907
C901
C723
C712
C325
C720
C8
C319
C701
C702
C771
C310
C324
C930
C5
C911
C802
C9
C3
C22
C1
C721
C2
C727
C906
C915
C722
C320
C322 C323
ELECTRIC UNIT
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
created date:2012-03-14No.MA525
18
(No.MA525<Rev.001>)10/
Page 11
SWITCH UNIT-1
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
F1A
S1A
A1GEA10328-
1
C614
B610
C612
C613
R700
D604
R679
TH601
IC610
D620
IC681
EN601
RA663
D602
D605
R643
S671
S670
S669
S668
S667
S665
S664
S663
S662
S661
D601
IC661
X661
RA662
R651
R662
R661
R656
R665
R657 R660
R659
R663
R666
R658
R655
R654
R652
R645
R653
R664
R650
R695
R696
R697
R630
R646R647
Q603
Q602
IC602
D630
D615D613
D611
D614
D612
D651
C665
C642
C671
C664
C641
C661
created date:2012-03-14No.MA525
18
(No.MA525<Rev.001>)11/
Page 12
P1AT1A
GEB10328A1
1
R634
R633
R632
R631
C699
C698
B606
C610
C611
MARK
UL
PbF
CN601
R610
R611
R612
C650
C607
C608
C606
C605
R687
CN602
R641
R642
R689
C620
C623
R648
R649
R644
R685
R686
R681
D682
R683
C681
C682
IC681
EN601
C609
L604
R698
C662
R615
R613
R614
T2-4
T2-3
T2-1
T2-2
GND
VDD
PTTX
E8-BUSY
CNVSS
PTCK
RST
PTRX
R602
R601
R604
D618
C603
Q601
C601
C602
R605
C668
R603
R607
R608
R609
IC601
R670
R625
R629
R637
R671
R667
R620
R619
R618
R626
R690
R628
R674
R680
R627
R675
R622
R623
R669
R606
R621
R624
R693
R691
R668
R692
L661
L603
C604
C667
C663
C621
C622
C669
SWITCH UNIT-1
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
created date:2012-03-14No.MA525
18
(No.MA525<Rev.001>)12/
Page 13
SWITCH UNIT-2
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
F1A
S1A
GEA10328A2
D610
D609
created date:2012-03-14No.MA525
18
(No.MA525<Rev.001>)13/
Page 14
P1A
T1A
GEB10328A2
MARK
UL
PbF
SWITCH UNIT-2
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
created date:2012-03-14No.MA525
18
(No.MA525<Rev.001>)14/
Page 15
USB UNIT
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
1P3A
S3A
B
A
5:TRST
4:TDO
2:TMS
3:TCK1:TDI
A
GEA10288-
4
5
6:TX
7:RX
6 7
GND
A
B
2
1
3
C454
C455
C456
C457
R457
R456
R455
K448
K447
K446
K445
K444
K443
K442
RST
C498
C497
C496
R454
R453
R452
R451
C426
R450
R449
R448
R447
R446
R445
PbF
R423
R444
L407
C605
C604
R432
R431
R430
C471
C401
C402
C403
C404
R429
R436
Q401
R434
L491
C495
C494
C492
C493
C491
IC491
C410
R415
R420
R419
R418
L406
L405
L404
C421
C420
C419
L403
C416
C417
C415
C414
R407
R406
R402
L402
L401
R401
C409
C405
C406
R404
C408
C407
R405
X401
R443
R442
R441
C442
C441
K441
C443
IC441
C424
C423
C422
IC401
MARK
UL
R521
R607
BM2
R606
R469
R468
R610
R604
R605
R422
K453
L601
K454
IC601
IC471
K452
C601
C430
C429
C603
C602
CN444
C606
K451
created date:2012-03-14No.MA525
18
(No.MA525<Rev.001>)15/
Page 16
4P3A
T3A
CN444
GEB10288A
R458
K450
K449
C453
C452
C451
R435
R609
CN442
CN441
C425
IC402
R428
R481
C482
C481
R427
R426
R425
R408
C411
R409
R417
R416
R414
R413
R412
R411
R410
C418
R403
C448
C447
C446
C445
C444
C449
C450
IC442
R601
R471
R603
R608
R470
R465
R463
R462
R464
IC481
R421
R602
D601
LF410
C428
C427
R459
CN444
LF409
USB UNIT
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
created date:2012-03-14No.MA525
18
(No.MA525<Rev.001>)16/
Page 17
CN101
A1
SW1
B1
PbF
SW2
SW3
WHT
LO+
YEL
LO-
REST
ORG
ORG
MGND
SL1
WHT
FE-
SP-
SP+
RED
BLK
YEL
FE+
CN102
R1
LVA11141-
P2A
MARK
UL
SW1
SW3
SW2
C
N
1
0
2
B1
R1
CN101
CD PLAYER UNIT-1
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
created date:2012-03-14No.MA525
18
(No.MA525<Rev.001>)17/
Page 18
PbF
P2A
LVA11141-A2
SW4
SW4
CD PLAYER UNIT-2
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
created date:2012-03-14No.MA525
18
(No.MA525<Rev.001>)18/
Loading...