JBL SCS-200, SCS-200.5 Service manual

Page 1

SCS200.5/SCS200.6/SCS260.5/SCS260.6 SERVICE MANUAL

PRO SOUND COMES HOME!™

JBL Consumer Products, Harman Consumer International, 2, Route de Tours, 72500 Château du Loir, France. Tel: + 33 (0)2 43 38 43 00, Fax: + 33 (0)2 43 44 93 83

www.jbl.com

Page 2

Advanced Product Informa tion

Provisional Specifications

SCS 260 Satellite

Frequency Response: 100Hz – 20kHz

Sensitivity( 2.83V@1m): 88dB

Nominal Impedance: 8 Ohm

Maximum Recommended Amplifier Power1: 100 Watt RMS

Power Handling (Continuous/Peak): 50W/200W

High Frequency Driver: ½” (13mm) Titanium laminate dome with JBL

Low Frequency Driver: Dual 3” (75mm) PolyPlas™

Magnetic Shielding: Yes

Dimensions*: 11½” x 4” x 3½”

Weight per Speaker: 1.36kg (3 lb)

*excludes shelf stand

SCS 260 Center

Frequency Response: 100Hz – 20kHz

Sensitivity( 2.83V@1m): 88dB

Nominal Impedance: 8 Ohm

Maximum Recommended Amplifier Power1: 100 Watt RMS

Power Handling (Continuous/Peak): 50W/200W

High Frequency Driver: ½” (13mm) Titanium laminate dome with JBL

Low Frequency Driver: Dual 3” (75mm) PolyPlas™

Magnetic Shielding: Yes

Dimensions*: 4” x 11½” x 3½”

Weight per Speaker: 1.36kg (3 lb)

*excludes shelf stand

SCS 260 Subwoofer

Low Frequency Cut -off: 35Hz

High Frequency Cut-off: 160Hz

Built-in Power Amplifier: 100 Watt RMS

Inputs: Line Level: LFE + Left and Right RCA Phono

Inputs: High Level: Left and Right speaker terminals

Outputs High Level: Left and Right speaker terminals

Auto-on Mode: Yes

Driver: 8” (200mm) Long Throw Cellulose Fiber

Port: FreeFlow™ flared

Magnetic Shielding: No

Dimensions*: 16¼” x 11” x 13¾”

Weight per Speaker: 12.7kg (28 lb)

*including feet

EOS™ waveguide

292mm x 101mm x 89mm

EOS™ waveguide

101mm x 292mm x 89mm

413mm x 280mm x 349mm

PRO SOUND COMES HOME!™

JBL Consumer Products, Harman Consumer International, 2, Route de Tours, 72500 Château du Loir, France. Tel: + 33 (0)2 43 38 43 00, Fax: + 33 (0)2 43 44 93 83

www.jbl.com

Page 3

Advanced Product Information

Provisional Specifications

SCS 200 Satellite

Frequency Response: 110Hz – 20kHz

Sensitivity( 2.83V@1m): 86dB

Nominal Impedance: 8 Ohm

Maximum Recommended Amplifier Power1: 75 Watt RMS

Power Handling (Continuous/Peak): 40W/160W

High Frequency Driver: ½” (13mm) Titanium laminate dome with JBL

Low Frequency Driver: 3” (75mm) PolyPlas™

Magnetic Shielding: Yes

Dimensions*: 7¼” x 4” 3½”

Weight per Speaker: 0.79kg (1.75 lb)

*excludes shelf stand

SCS 200 Center

Frequency Response: 100Hz – 20kHz

Sensitivity( 2.83V@1m): 88dB

Nominal Impedance: 8 Ohm

Maximum Recommended Amplifier Power1: 100 Watt RMS

Power Handling (Continuous/Peak): 50W/200W

High Frequency Driver: ½” (13mm) Titanium laminate dome with JBL Low Frequency Driver: Dual 3” (75mm) PolyPlas™

Magnetic Shielding: Yes

Dimensions*: 4” x 11½” x 3½”

Weight per Speaker: 1.36kg (3 lb)

*excludes shelf stand

SCS 200 Subwoofer

Low Frequency Cut -off: 35Hz

High Frequency Cut-off: 160Hz

Built-in Power Amplifier: 100 Watt RMS

Inputs: Line Level: LFE + Left and Right RCA Phono

Inputs: High Level: Left and Right speaker terminals

Outputs High Level: Left and Right speaker terminals

Auto-on Mode: Yes

Driver: 8” (200mm) Long Throw Cellulose Fiber

Port: FreeFlow™ flared

Magnetic Shielding: No

Dimensions*: 16¼ x 11” x 13¾”

Weight per Speaker: 12.7kg (28 lb)

*including feet

EOS™ waveguide

184mm x 101mm x 89mm

EOS™ waveguide

101mm x 292mm x 89mm

413mm x 280mm x 349mm

PRO SOUND COMES HOME!™

JBL Consumer Products, Harman Consumer International, 2, Route de Tours, 72500 Château du Loir, France. Tel: + 33 (0)2 43 38 43 00, Fax: + 33 (0)2 43 44 93 83

www.jbl.com

Page 4

SCS200SUB / SCS260SUB

Page 5

Page 6

SCS260 CENTER / SCS200 CENTER

Page 7

Model name: SCS 300/260 SAT

SAT200/260/300  Wall bracket 326-ABS-05010

Part number Description Q'ty

01 306-HIPS-00725 Plastic cover 287.89*97.2*86.4H black 1PC 02 28DM13NH-DT01 13mm DOME TWEETER 4 OHM 1PC 03 32PF55JZL-LW01 Woofer 3 1/4" 19mm 12ohm (2.3+2.1)oz 2PCS 04 351-KM04015A321 Screw 8PCS 05 354-HM04703 Screw 8PCS 06 352-FM04014D602 Screw 6PCS 07 013-7600-00827 Crossover of CEN 1PC 08 352-AM03008D035 Screw 2PCS 09 327-010-00118 10 215-000-00827 Terminal 1PC 11 352-CM03509D439 Screw 1PC 12 244-030-00306 Grille 255.99*92.78*19.88H black 1PC 13 336-EVA-00297 EVA 330*5.5*0.5T black 2PCS 14 424-000-05002 PO bag SCS200.7;300.7 1PC

Model name: SCS 200/300 CEN

Part number Description Q'ty

01 306-HIPS-00724 HIPS plastic cover 287.89*97.2*86.4H blac 1PC 02 28DM13NI-DT01 Tweeter 2PCS 03 32PF55JZL-LW01 Woofer 1PC 04 351-KM04015A321 Screw 8PCS 05 354-HM04703 Screw 8PCS 06 352-FM04014D602 Screw 6PCS 07 013-7600-00827 X-over 1PC 08 352-AM03008D035 Screw 2PCS 09 327-010-00118 Grille cup 6PCS 10 215-000-00827 Terminal 1PC 11 352-CM03509D439 Screw 1PC 12 244-030-00307 HIPS grille 255.99*92.78*19.88H black 1PC 13 336-EVA-00297 EVA 330*5.5*0.5T black 2PCS 14 424-000-05002 PO bag SCS200.7;300.7 1PC

Grille cup 10*φ11.2 black

6PCS

Model name: SCS 200 SAT No

01 306-HIPS-00726 02 19DM13NJ-DT01 Tweeter 1PC 03 32PF55JZF-FW01 Woofer 3 1/4" 1PC 04 351-KM04015A321 Screw 4PCS 05 354-HM04703 Screw 4PCS 06 352-FM04014D602 Screw 4PCS 07 013-7600-00828 X-over 1PC 08 352-AM03008D035 Screw 2PCS 09 327-010-00118 Grille cup 4PCS 10 215-000-00827 Terminal 1PC 11 352-CM03509D439 Screw 1PC 12 244-030-00305 HIPS grille 156.24*92.46*17.9H black 1PC 13 336-EVA-00295 EVA 220*5.5*0.5T black 1PC 14 424-000-05001 PO bag SCS200.7 SAT 1PC

Part number Description Q'ty

HIPS plastic cover 185.93*96.9*84.7H blac

1PC

Page 8

Model name: SCS200/260 6

352-AM03008D040

8PCS

352-AM03010D06

4PCS

350-EM04012D024

4PCS

No. Part number Description Reference Q'ty

051-A00374

351-AM03008A079 Screw M3*8 6PCS

351-BM03012A088 Screw M3*12 1PC

351-HM04016A218 Screw M4*16 4PCS

354-GM04002 Screw sheet M4 4PCS

05 06

150-e8604106 Transformer EI-86 230V/50Hz 1PC

152-v602026 Power wire SP-021A 6FT VDE 1PC

154-v12506t0 Fuse TSD 1.25A 250V VDE 1PC

155-520020 Fuse connector R3-11 1PC

162-10082007 WIRE RED 18AWG 80mm 1PC

162-a040d001 Speaker wire #1015 400mm 1PC

163-11009 Mini tighen wire 100mm 2PCS

176-wjce1 Terminal CE-1 1PC

180-prf1003s Power switch RF-1003-BB2-OH

193-2m1813 PiezoTO-220 18*13mm Q120,Q124 2PCS

306-ABS-00714

361-FE-00004 IC HOLDER 26.9*12*1.4T 1PC

323-AL-00019 HEAT SINK 117.5*60*25 1PC

311-ABS-00028 Plastic knob 46077-W P.V.C. 1PC

302-AL-00226-0BF Alu. Panel 215*270*2.5t SCS140 1PC

302-AL-00226-0BG Alu. Panel 215*270*2.5t SCS146 1PC

335-NYL-00002 Wire lock 4K-4 NO-BB 2PCS

333-EVA-00096 EVA gasket wide side 213*15*2.0mm 2PCS

333-EVA-00097 EVA gasket wide side 213*15*1.0t 2PCS

333-EVA-00132 EVA gasket long side 238*15*2.0mm 2PCS

333-EVA-00133 EVA gasket long side 238*15*1.0t 2PCS

333-EVA-00220 EVA gasket long side 225*15*1t UL 1PC

320-RUB-00033 Rubber gasket 25*21*4t 4PCS

413-000-00188 SPEAKER label 4 OHM 45*8mm 1PC

413-000-00540 Label, MADE IN CHINA 1PC

333-EVA-00188 EVA gasket 170x5x1t 1PC

362-FE-00013

PCB ASS'Y amp 1PC

Screw ￠3*8 Type B

Screw ￠3*10 Type P Screw 4￠*12

SW101 1PC

Plastic cover with metal spray 268*213*102 1PC

PCB Gasket L TYPE t=1.6mm S.P.C.C 89*9*1.6T 2PCS

Print on: 11/08/04 Page: 1/4 File: Part list -SCS140 & 146 (JBL) for service manual .xls

Page 9

Electric parts

195-10204hgw

D209

1PC

No. Part number Description Reference Q'ty

351-AM03014A094 Screw M3*14 1PC

352-AM03008D040

110-10821jk2 Resistor 820Ω 1W ±5% 10mm R132 1PC

110-122r2j15 Resistor 2.2Ω 1/2W ±5% 15mm R127 1PC

113-500r1j10 Cement resistor 0.1Ω 5W ±5% R121,R122 2PCS

114-03302m0 Semi-fixed resistor 3K 0.3W ±20% R138 1PC

115-h503a101 Variable resistor D16 50K/1

135-4478m35 Electrolytic cap 4700uF 35V ±20% C121,C122 2PCS

135-4478m50 Electrolytic cap 4700uF 50V ±20% C133,C134 2PCS

156-h010010 Tube 1ψ*10mm Q101,Q115 2PCS

162-10202001 Wire 26AWG 1007 200mm RED 1PC

171-udhss124d Relay 5A 24V UDH-SS124D RY101 1PC

174-0rcb202v Jack RCA JACK RCB-202V JK202 1PC

174-0rca108nb RCA JACK RCA108NB 1P JK203 1PC

174-2rsp108v Speaker terminal 8 PIN RSP-108

175-1c07v01

175-1d02v01

175-1d05v01

180-tms7210v SWITCH SLIDE 6PIN MS7210

190-06m4558d I.C. OPA 4558D U101,U203 2PCS

190-16tl074cn I.C TL074CN ST U201,U202 2PCS

192-021c1815g

192-991d669a TransistorHI-SINCERITY HSD669A Q106 1PC

192-021tip35

192-992b649t Transistor HSB649T Q105 1PC

192-022tip36

192-161tip41

192-162tip42c Transistor TIP42C PNP SGS Q120 1PC

192-201d882

192-202b772

193-3m2520

32 33

197-00kbl405

197-101n4002 Diode 1N4002 D104 1PC

197-101n5402 Diode 1N5402 D111,D112 2PCS

361-FE-00051 Transistor holder 14.2*8.0*5.2 t=1.6mm 1PC

323-AL-00020 HEAT SINK 65*32*31 1PC

361-NYL-00054 Transistor isolated sheet 2PCS

Screw ￠3*8 Type B

VR201 1PC

JK201 1PC

Connector 7PIN PITCH=2.5mm Connector 2PIN PITCH=3.96mm Connector 5PIN 3.96mm

P101 1PC P102 1PC P103 1PC SW201 1PC

Transistor 2SC1815GR Q101,Q115 2PCS

Transistor TIP35C Q107 1PC

Transistor TIP36C Q108 1PC Transistor TIP41C NPN SGS Q124 1PC

Transistor KSD882 Transistor KSB772 Piezo TO-3P 25x20mm

Q117 1PC Q119 1PC Q107,Q108 2PCS

LED 204HGW 3￠

Bridge rectifier 4A 500V KBL40

D110,D115 2PCS

4PCS

01 104-sub135e00 PCB OF SUB135E 1PC

02 110-14122j26 Resistor 1.2K 1/4W ±5% CF 26mm TAP R265 1PC

03 110-14472j26 Resistor 4.7K 1/4W ±5% CF 26mm TAP R201,R202 2PCS

04 110-14560j26 Resistor 56Ω 1/4W ±5% CF 26mm TAP R117 1PC

05 110-16101j26 Resistor 100Ω 1/6W ±5% CF 26mm TAP R120,R213,R214,R215 4PCS

06 110-16102j26 Resistor 1K 1/6W ±5% CF 26mm TAP R124,R166,R254,R264 4PCS

R133,R134,R209,R212,R216,R21 7,R220,R221,R222,R225,R226,R2 28,R229,R230,R232,R235,R240,R

07 110-16103j26 Resistor 10K 1/6W ±5% CF 26mm TAP

260 18PCS

08 110-16104j26 Resistor 100K 1/6W ±5% CF 26mm TAP R163,R164,R231 3PCS

09 110-16105j26 Resistor 1M 1/6W ±5% CF 26mm TAP R143,R259 2PCS

10 110-16123j26 Resistor 12K 1/6W ±5% CF 26mm TAP R135,R139,R165 3PCS

11 110-16124j26 Resistor 120K 1/6W ±5% CF 26mm TAP R233 1PC

12 110-16151j26 Resistor 150Ω 1/6W ±5% CF 26mm TAP R253 1PC

R103,R123,R136,R137,R141,R14

13 110-16152j26 Resistor 1.5K 1/6W ±5% CF 26mm TAP

2,R153 7PCS

14 110-16153j26 Resistor 15K 1/6W ±5% CF 26mm TAP R118,R145,R152,R154,R234 5PCS

15 110-16154j26 Resistor 150K 1/6W ±5% CF 26mm TAP R131,R252 2PCS

16 110-16181j26 Resistor 180Ω 1/6W ±5% CF 26mm TAP R111,R114 2PCS

Print on: 11/08/04 Page: 2/4 File: Part list -SCS140 & 146 (JBL) for service manual .xls

Page 10

Electric parts

No. Part number Description Reference Q'ty

17 110-16183j26 Resistor 18K 1/6W ±5% CF 26mm TAP R227 1PC

0,R237,R238,R255,R256,R262,R2

18 110-16223j26 Resistor 22K 1/6W ±5% CF 26mm TAP

19 110-16273j26 Resistor 27K 1/6W ±5% CF 26mm TAP R223 1PC

20 110-16205j26 Resistor 2M 1/6W ±5% CF 26mm TAP R257 1PC

21 110-16332j26 Resistor 3.3K 1/6W ±5% CF 26mm TAP R106,R107,R144,R236,R258 5PCS

22 110-16392j26 Resistor 3.9K 1/6W ±5% CF 26mm TAP R105,R108 2PCS

23 110-16393j26 Resistor 39K 1/6W ±5% CF 26mm TAP R126 1PC

24 110-16470j26 Resistor 47Ω 1/6W ±5% CF 26mm TAP R112,R113,R115,R116 4PCS

25 110-16471j26 Resistor 470Ω 1/6W ±5% CF 26mm TAP R140,R161,R162 3PCS

26 110-16472j26 Resistor 4.7K 1/6W ±5% CF 26mm TAP

27 110-16473j26 Resistor 47K 1/6W ±5% CF 26mm TAP R101,R219,R249,R250,R251 5PCS

28 110-16512j26 Resistor 5.1K 1/6W ±5% CF 26mm TAP R210,R211 2PCS

29 110-16513j26 Resistor 51K 1/6W ±5% CF 26mm TAP R224 1PC

30 110-16563j26 Resistor 56K 1/6W ±5% CF 26mm TAP R104 1PC

31 110-16681j26 Resistor 680Ω 1/6W ±5% CF 26mm TAP R148,R151 2PCS

32 110-16682j26 Resistor 6.8K 1/6W ±5% CF 26mm TAP R109 1PC

33 110-16913j26 Resistor 91K 1/6W ±5% CF 26mm TAP R203,R204,R205,R206 4PCS

34 130-sl101k503 Disc capacitor 100P 50V SL ±10% TAP 5PCS

35 130-2b102k503 Disc capacitor 1000P 50V ±10% TAP C116,C141,C203 3PCS

36 130-2b221k503 Disc capacitor 220P 50V ±10% TAP

37 130-2b681k503 Disc capacitor 680P 50V ±10% TAP C208 1PC

38 130-2f104z503 Disc capacitor 0.1U 50V +80/-20% TAP

39 130-3f473m503 Disc capacitor 0.047U 50V ±20% TAP C106,C209 2PCS

40 130-sl470k503 Disc capacitor 47P 50V ±10% TAP C229 1PC

41 132-103j503 Mylar capacitor 0.01U 50V ±5% TAP C223,C224 2PCS

42 132-104j503 Mylar capacitor 0.1U 50V ±5% TAP C107,C218,C221,C222 4PCS

43 132-223ja03 Mylar capacitor 0.022uF 100V ±5% TAP

44 132-473j503 Mylar capacitor 0.047U 50V ±5% TAP C216,C217 2PCS

45 135-3105m50 Electrolytic cap 1U 50V ±20% TAP C105,C112,C228 3PCS

46 135-3106m50 Electrolytic cap 10uF 50V ±20% TAP

47 135-3107m16 Electrolytic cap 100uF 16V ±20% TAP

48 135-3107m50 Electrolytic cap 100U 50V ±20% TAP C135,C136 2PCS

49 135-3226m50 Electrolytic cap 22U 50V ±20% TAP C114,C118,C225 3PCS

50 135-3227m10 Electrolytic cap 220U 10V ±20% TAP C129,C130 2PCS

51 135-3227m16 Electrolytic cap 220U 16V ±20% TAP C111,C233 2PCS

52 135-3476m25 Electrolytic cap 47U 25V ±20% TAP C103 1PC

53 192-027c1815gr Transistor 2SC1815GR TAP

54 192-027c2235y Transistor 2SC2235Y TAP Q121 1PC

55 192-028a1015gr Transistor 2SA1015GR TAP Q114,Q116,Q122,Q127 4PCS

56 192-028a965y Transistor 2SA965Y TAP Q125 1PC

57 192-1672n5551 Transistor 2N5551 TAP Q103,Q109 2PCS

58 192-1682n5401 Transistor 2N5401 AI-PNP 350V 500mA Q104,Q110 2PCS

63 12PCS

R110,R125,R130,R147,R150,R15 7,R159,R207,R208 9PCS

C204,C205,C210,C211,C212,C23 0 6PCS

C108,C113,C115,C119,C137,C13 8,C232,C235,C236,C237,C239,C2 40,C241 13PCS

C123,C124,C125,C126,C127,C12 8,C131,C132, C215 9PCS

C201,C202,C206,C213,C219,C23 1 6PCS

C109,C110,C117,C120,C234,C23 8,C242 7PCS

Q102,Q111,Q112,Q113,Q118,Q12 3,Q126,Q206,Q207,Q208 10PCS

Print on: 11/08/04 Page: 3/4 File: Part list -SCS140 & 146 (JBL) for service manual .xls

Page 11

Electric parts

,,,,,

No. Part number Description Reference Q'ty

59 197-131n4148 Diode 1N4148 26mm TAP

60 199-15000335

61 199-15000625 62 199-15001605

Zener Diode 3.3V 1/2W 52mm TAP

Zener Diode 6.2V 1/2W 52mm TAP Zener Diode 16V 1/2W 52mm TAP

4,D201,D202,D206,D207,D208,D2 19PCS

D102,D205 2PCS

D106,D107 2PCS D109 1PC

63 161-506520 JUMPER WIRE 26mm TAP 68PCS

No. Part number Description Reference Q'ty

051-A00014B

162-50129001 CABLE ASS'Y 120mm AWG28 WHT P302 1PC

175-9f40hr2 HR2*40 0.15PC

190-16tl074cn I.C TL074CN ST U301 1PC

162-10059001

02 110-16103j26 Resistor 10K 1/6W ±5% CF 26mm TAP

PCB ASS'Y OF SCS135 LIMITER 1PC

Single wire 50mm WHITE UL1007

1PC

4 6PCS

03 110-16223j26 Resistor 22K 1/6W ±5% CF 26mm TAP R310,R312 2PCS

04 110-16333j26 Resistor 33K 1/6W ±5% CF 26mm TAP R305 1PC

05 110-16474j26 Resistor 470K 1/6W ±5% CF 26mm TAP R307 1PC

06 110-16751j26 Resistor 750Ω 1/6W ±5% CF 26mm TAP R311,R313 2PCS

07 110-16755j26 Resistor 7.5M 1/6W ±5% CF 26mm TAP R306 1PC

08 130-2f104z503 Disc capacitor 0.1U 50V +80/-20% TAP C305,C306 2PCS

09 132-103j503 Mylar capacitor 0.01U 50V ±5% TAP C302,C303 2PCS

10 135-3226m50 Electrolytic cap 22U 50V ±20% TAP C301 1PC

11 135-3476m25 Electrolytic cap 47U 25V ±20% TAP C304 1PC

12 192-027c1815gr Transistor 2SC1815GR TAP Q301,Q302 2PCS

13 197-131n4148 Diode 1N4148 26mm TAP D301,D302 2PCS 14 161-506520 JUMPER WIRE 26mm TAP 6PCS 15 110-16153j26 Resistor 15K 1/6W ±5% CF 26mm TAP R302 1PC

Print on: 11/08/04 Page: 4/4 File: Part list -SCS140 & 146 (JBL) for service manual .xls

Page 12

SUB200/260 TRANSISTOR PINOUTS

PARTS NAME

1 2 3 TIP35C Emiter Collector base TIP36C Emiter Collector base

PARTS NAME

1 2 3 2SB649A Emiter Collector base 2SB772 Emiter Collector base 2SD669A Emiter Collector base 2SD882 Emiter Collector base

PINOUTS

PARTS NAME

1 2 3 2SA1015 Emiter Collector base 2N5401 Emiter base Collector 2SC1815 Emiter Collector base 2N5551 Emiter base Collector

PINOUTS

Page 13

TL07 4

TL074A - TL074B

LOW NOISE J-FET QUAD OPERATIONAL AMPLIFIERS

.WIDE COMMON-MODE (UP TO V

DIFFERENTIALVOLTAGERANGE

)AND

.LOW INPUT BIAS AND OFFSET CURRENT

.LOW NOISE e

=15nV/√Hz (typ)

.OUTPUTSHORT-CIRCUIT PROTECTION

.HIGH INPUT IMPEDANCE J–FET INPUT

STAGE

.LOW HARMONICDISTORTION : 0.01%(typ)

.INTERNAL FREQUENCYCOMPENSATION

.LATCHUPFREE OPERATION

.HIGHSLEWRATE : 13V/µs (typ)

DESC RIP TI ON

The TL074,TL074Aand TL074Barehighspeed J–FETinputquadoperation alamplifiers incorporating wellmatched,high voltageJ–FETand bipolartransistorsin amonolithicintegratedcircuit.

Thedevicesfeaturehighslewrates,lowinputbiasand offsetcurrents, andlow offsetvoltagetemperature coefficient .

(PlasticPackage)

(PlasticMicropackage)

ORDER CODES

Part Number

TL074M/AM/BM –55 TL074I/AI/BI –40 TL074C/AC/BC 0 Example : TL074IN

DIP14

SO14

Temperature

Range

C, +125oC ••

C, +105oC ••