JBL ESC-360 Service manual
ESC 360
Service Manual
SPECIFICATIONS:
Audio Section
Surround Formats: Dolby Digital - DTS - Dolby Pro Logic
•
Frequency Response at 1W (+0dB, -3dB): 55Hz - 20 kHz
•
Signal-to-Noise Ratio (IHF-A): 80 dB
•
Satellite Section
Frequency Response (-6db): 120 Hz-20 kHz
•
Sensitivity (2.83V @ 1m): 84 dB
•
Nominal Impedance: 4 Ohms
•
Recommended Amplifier Power: 25 Watts RMS (in sub)
•
Titanium Laminate HF: 12 mm
•
Paper Cone Midrange : 75 mm
•
Dimensions (H x W x D): 111 x 81 x 92 mm
•
Weight: 0.5 kg
•
Finish: silvergray
•
Center Section
Frequency Response (-6db): 120 Hz-20 kHz
•
Sensitivity (2.83V @ 1m): 86 dB
•
Nominal Impedance: 4 Ohms
•
Recommended Amplifier Power: 25 Watts RMS (in sub)
•
Titanium Laminate HF: 12 mm
•
Paper Cone Midrange : dual 75 mm
•
Dimensions (H x W x D): 83 x 194 x 95 mm
•
Weight: 0.8 kg
•
Finish: silvergray
•
Subwoofer Section
Low Frequency Cut-off: 40 Hz
•
High Frequency Cut-off: 160 Hz
•
Built-in Power Amplifier (RMS): 25 Watts x 5 + 60 Watts
•
Paper Cone Long Throw Driver : 165 mm
•
Dimensions (H x W x D): 315 x 300 x 310
•
Weight: 7.2 kg
•
Finish: silvergray
•
General Section
Power Requirement: 230V/50-60Hz
•
Power Consumption: 80 Watts
•
BPL40003-0102
GSP400008-0101
HSP140071-3160
FSA213012-1801
HSP140054-1080
BRF400006-0001
BRF400005-0001
BPF405006-01011
BPA400007-01011
FSA243010-1801
APE200080-0001
TWEETER
IVM110001-0001
YLB1060003-0002
ESC 360 CENTER SPEAKER : AFK200003-0001
ESC360 SATELLITE : AFK200002-0001
BPL400003-0102
GSP400002-0102
FSA213012-1401
BPF405003-0101
BPA400004-0101
BRF400005-0001
BRF400006-0001
IVM000002-0004
TWEETER
FSA243010-1801
APE200040-0001
EXPLODED VIEW JBL ESC 360
K
N
N
ESC360 PART LIST
ITEM PART NUMBER MATERIAL DESCRIPTION
1 EVM200002-0001 WOOD BOX W300xH300xD300mm
2 BPR000020-0001 PORT EDGE ABS W/SPRAY MA4810
3 BPR000042-0BA0 PORT (F) ABS MA4810
4 BPF005056-0AY1 CNTL PANEL METALIC LIGHT GREY SILVER
5 BFP211001-0001 PVC PLATE
6 BPL000013-0001 LOGO PLATE 22.5xW18mm JBL
7 BPK005031-0000 CONTROL KNOB W/SPRAY MA4810
8 APE200140-4001 CNTL PCB ASSY (HI)
9 IVE200001-0001 SPONGE OD165xID143xT1.0mm
10 FSA226061-1401 SPK DRIVER 6.5" 4OHM 60W
11 BPE000005-0002 FOOT D25xL25 LIGHT GREY W/MA4810 SPRAY
12 BRF200001-0001 RUBBER FOOT NR3 BLACK 13.5xT2.0mm W/ADHE
13 IVE200002-0001 SPONGE L268xW268xT2.0mm
14 APE200065-4001 LED INTERFACE PCB ASSY HI
15 GSE200008-0001 REAR PANEL SECC T=2.0mm CEDCOATTING BLK
16 ICH209001-0001 SPONGE FIBER T0.5mm 268x120mm
17 GAL200004-0001 HEAT SINK L AL W/ANODIZING BLK
18 APE200063-5001 DC PCB ASSY CHASSIS
19 GSE200010-0001 PCB BKT R SECC T=1.0mm
20 GSE200011-0001 PCB BKT L SECC T=1.0mm
21 CFC021001-1001 FUSE HOLDR FUSE HOLDER FH-B02
22 BRB200001-0001 RUBBER BUSHING BLACK W/UL
23
DBU001002-0011 BUSHING AC LINE BUSHING HEAVY POWER 4K-4
24 MSW008004-0010 SW ROCKER 5A AC 250V TV-5
25 TTK223001-0001 PWR TRANS EI-96 230V
26 APE200064-5001 SPK JACK ASSY CHASSIS
27 IVE200010-0001 SPONGE A EVA
28 APE004710-4004 DECODER PCB ASSY AC3 DTS/DSP HI
29 GSE200020-0001 PCB BKT L SECC T=1.0mm
30 GSE200021-0001 PCB BKT R SECC T=1.0mm
31 BPC200001-0001 PCB COVER A ABS LIGHT GREY
32 IVE200004-0001 SPONGE B EVA
33 IVE200003-0001 SPONGE A EVA
34 APE200061-5001 MAIN PCB ASSY CHASSIS
35 BPC210001-0001 PCB COVER B ABS LIGHT GREY
36 GAL200003-0001 HEAT SINK AL W238xH32mm W/ANODIZING BLK
37 GSE200009-0001 PCB BKT L T=1.0mm
38 APE200062-5001 AMP. PCB ASSY CHASSIS
39 GSE200012-0001 PCB BKT Z SECC T=1.0mm
S1 HSP140054-3080 SCREW T3.0xL8xP1.06mm BLACK OXIDE
S2 HST140054-3100 SCREW T3.0xL10xP1.06mm BLACK OXIDE
S3 HSD143103-3200 SCREW M4.0xP0.7xL20 mm C
S4 HSP143083-3140 SCREW ;M3.0xP0.5xL14mm PAN HEAD BLAC
S5 HST140051-3220 SCREW T3xL22xP1.06mm BLACK OXIDE
S6 HSP140091-3200 SCREW T4xL20xP1.59mm BLACK OXIDE
S7 HST140054-3060 SCREW T3xL6xP1.06mm BLACK OXIDE
S8 HSP140074-3080 SCREW T3.5xL8xP1.41mm BLACK OXIDE
S9 HSP140054-3100 SCREW T3.0xL10xP1.06mm BLACK OXIDE
S10 HSP140091-3160 SCREW T4.0x1.59PxL16mm BLACK PAN HEAD
S11 HST140071-3140 SCREW T3.5xP1.41x14mm BLACK OXIDE
S12 HSP140054-3060 SCREW T3.0xL6xP1.06mm BLACK OXIDE
1 HNT140700-1300 NUT M4.0xOD7.0xT3.0mm NICKEL
2 HOT002006-0003 CU-SPACER M3.0xP0.5xL20mm HEXAGO
Main
Installation Point Qty. Description Material No.
1 MAIN PCB ASSY HI APE200061-4001
IC302 1 IC 14 PIN TL074CD RCI000740-0001
IC621 IC622 IC623 IC701 4 IC 8 PIN TL072CD RCI000720-0001
IC620 1 IC 42 PIN M62446FP MITSUBISHI RCI062446-0001
IC301 1 IC 16 PIN TC4052BFN CHIP RCI004052-0001
IC201 1 IC 44 PIN TC9819 U-CON V2 MASK RCI870047-0082
Q101 Q102 Q103 Q104 Q301 Q302 Q505 7 XISTR NPN SMT (2SC945) RCN200945-0001
Q506 1 XISTR PNP 2SA812 hfe:200~400 RCP200733-0001
ZD601 ZD602 2 DIODE ZENR 6.9-7.2V 0.5W RAZ005007-0020
D201 D202 D203 D303 11 CHIP DIODE LL4148 TELEFUNKEN RCD104148-0010
D304 D305 D306 D307 D308 D601 D208
D650 1 DIODE;RECTIFIER 1N4002 RAD114001-0010
ZD301 1 DIODE ZENR 2.3-2.5V 0.5W RAZ005002-0020
ZD201 1 DIODE ZENR 5.6-5.9V 0.5W RAZ005006-0020
R832 JP01 R738 3 CHIP RES. 0 OHM JUMP WIRE QCF015020-0000
R383 R384 2 CHIP RES. 10 OHM 1/10W 5% QCF015020-1000
R880 R317 R318 R835 9 CHIP RES. 100 OHM 1/10W 5% QCF015020-1010
R876 R877 R878 R879 R881
R309 R310 R313 R314 14 CHIP RES. 1K OHM 1/10W 5% QCF015020-1020
R331 R373 R374 R846
R864 R865 R868 R869 R875 R336
R101 R103 R106 R108 23 CHIP RES. 10K OHM 1/10W 5% QCF015020-1030
R113 R214 R311 R312
R319 R320 R325 R326
R330 R333 R335 R337
R529 R542 R821 R101A R118 R119 R120
R380 R527 2 CHIP RES. 100K OHM 1/10W 5% QCF015020-1040
R107 R321 R322 R378 R379 5 CHIP RES. 1M OHM 1/10W 5% QCF015020-1050
R104 R109 R110 R327 R327A 5 CHIP RES. 150 OHM 1/10W 5% QCF015020-1510
R211 1 CHIP RES. 1.8K OHM 1/10W 5% QCF015020-1820
R833 R834 2 CHIP RES. 2.4K OHM 1/10W 5% QCF015020-2420
R332 1 CHIP RES. 22K OHM 1/10W 5% QCF015020-2230
R329 R334 R801 R803 R804 R805 R816 8 CHIP RES. 220K OHM 1/10W 5% QCF015020-2240
R802
R301 R302 R303 R304 9 CHIP RES. 24K OHM 1/10W 5% QCF015020-2430
R305 R306 R307 R308 R377
R862 R863 R866 R867 R873 R874 6 CHIP RES. 2.7K OHM 1/10W 5% QCF015020-2720
R210 R315 R316 3 CHIP RES. 3.3K OHM 1/10W 5% QCF015020-3320
R817 R818 R819 R828 R829 5 CHIP RES 3.6K OHM 1/10W 5% QCF015020-3620
R381 R382 2 CHIP RES. 470 OHM 1/10W 5% QCF015020-4710
R212 R213 R226 R236 15 CHIP RES. 4.7K OHM 1/10W 5% QCF015020-4720
R323 R324 R215 R216 R217 R218 R220
R221 R223 R224 R219
R105 R112 R225 R526 R528 5 CHIP RES. 47K OHM 1/10W 5% QCF015020-4730
R885 R886 2 RESISTOR 150 OHM 1W 5% MF HI QHM105000-1510
R375 R376 2 CHIP RES. 680 OHM 1/10W 5% QCF015020-6810
R830 R822 R827 R836 R837 R842 R843 9 CHIP RES. 8.2K OHM 1/10W 5% QCF015020-8220
R844 R845
R102 1 CHIP RES. 5.1K OHM 1/10W 5% QCF015020-5120
R372 1 RESISTOR 4.7K OHM 1/6W 5% CF QAF065000-4720
R810 R811 R812 3 RESISTOR 22K OHM 1/6W 5% CF QAF065000-2230
L301 1 CHOKE 10 uH 10% SAN001600-1000
R232 1 RESISTOR 100 OHM 1/6W 5% CF QAF065000-1010
C202 C203 2 CHIP CAP 18 pF 50V 5% PYL410370-1800
C317 C318 2 CHIP CAP 22 pF 50V 5% PYL410370-2200
C303 C304 C309 C310 18 CHIP CAP 47 pF 50V 5% PYL410370-4700
C328 C331 C363 C364
C769 C773 C777 C780
C781 C782 C358 C359 C360 C361
C301 C302 C307 C308 4 CHIP CAP 100 pF 50V 5% PYL410370-1010
C102 C106 C110 C111 13 CHIP CAP 0.1 uF 50V 5% PYL456370-1040
C206 C211 C325 C326 C703 C704 C321A
C322A C110A
C101 C105 2 CHIP CAP 0.01 uF 50V 5% PYL456370-1030
C208 C362 2 CHIP CAP 0.022 uF 50V 5% PYL456370-2230
C702A C752 C753 C755 11 COND ELECT 47uF 10V 20% PRE039530-4700
C766 C767 C783 C784 C786 C787 C788
C207 1 COND ELECT 47uF 16V 20% PRE039540-4700
C109 C305 C306 C311 10 COND ELECT 47uF 25V 20% PRE039550-4700
C312 C315 C316 C319 C320 C327
C209 C527 C330 3 COND ELECT 10 uF 50V 20% PRE039570-1000
C104 C108 C201 C323 C324 5 COND ELECT 1uF 50V 20% PRE039570-1090
C765 C785 2 COND ELECT 100uF 10V 20% PRE039530-1010
C768 1 COND ELECT 100uF 16V 20% PRE039540-1010
C789 C795 C809 C811 8 COND ELECT 100uF 25V 20% PRE039550-1010
c810 c812 c815 c816
C313 C314 C321 C322 4 COND ELECT 220uF 25V 20% PRE039550-2210
C526 1 COND ELECT 2.2 uF 50V 20% PRE039570-2290
C204 1 COND ELECT 0.47 uF 50V 20% PRE039570-4780
C701A C703A C704A C705A C706A 5 COND ELECT 4.7 uF 50V 20% PRE039570-4790
C813 C814 2 COND ELECT 3.3 uF 50V 20% PRE039570-3390
C770 C776 2 COND METAL 0.82uF 63V 5% MINI SIZE PRN126380-8240
C772 C774 2 COND MYLAR 0.0047 uF 100V 5% PRM0373A0-4720
C771 C775 2 COND MYLAR 0.0056 uF 100V 5% PRM0373A0-5620
C205 C650 2 COND ELECT 2200 uF 10V 20% 85`C PVE039530-2220
JP400~JP466 L604 L605 JP467 JP468 71 WIRE BARE 22 GA TINNED XJP220000-0001
JP469(NEAR L604)
CN206 1 CONNECTOR 10 PIN PITCH=2.0mm CCN200000-0110
CON2 1 CONNECTOR B2B-XH-A 2 PIN CCN250000-0102
JK201 1 PHONE JACK D3.5 3 PIN BLK CJM035001-3010
CR201 1 CRYSTAL 4.194304 MHZ HC-49/U JQC013100-4151
CN8A 1 CONNECTOR 15 PIN TO2-3100-1150 CCH100060-0215
CN5A 1 CONNECTOR 9 PIN P1.25x2.5mm 180' FPC CCH125060-0209
CN6A 1 FPC CONNECTOR 15PIN P1.25x2.5mm 180' CCH125060-0215
JK301 1 RCA JACK 4P RED-RED/WHT-WHT CJR004101-0020
JK303 1 OPTICAL RECEIVER DLR1111 CJT200001-0005
JK302 1 RCA JACK 1P GREEN RJ-1081-05-0300A CJR001101-0030
CN601A 1 CON/WIRE 11P 250mm 2547&1007 A=2mm VWA200047-0005
RB1 1 CHIELD CABLE 3P L=70mm 2547#26 A=2.5mm VSW323122-0070
RB3 1 SHIELD CABLE 2P 120mm 1533#26 A=2.5mm VSW223122-0120
RB102B 1 CON/WIRE 7P 120mm 2547&1007 A=2mm VWA200047-0006
RB9A 1 CON/WIRE 2P 60mm A=2.5mm B=2512V VWA010091-0001
RB100 1 CON/WIRE 4P 290mm 1007#26 AWG FLAT A=2mm VWA200097-0001
RB906 1 FLAT WIRE 9P 380mm 1007#26 A=2.5mm VWA010091-0002
CN6A 1 FFC CABLE 15P 50mm 2896 P=1.25mm VFC150530-0500
CN5A 1 FFC CABLE 9P L=50mm 2896 P=1.25mm A=2.5 VFC090530-0500
CN8A 1 FFC CABLE 15P L=50mm 2896 P=1.0mm VFC150520-0500
RB102 1 CON/WIRE 3P 350mm 1007#26 FLAT VWA010090-0002
Amplifier
Installation Point Qty. Description Material No.
1 AMP. PCB ASSY (HI) APE200062-4001
IC421 IC501 IC502 3 IC 11 PIN TDA7265 SGS THOMSON RHI007265-0001
IC703 1 IC 11 PIN LM3886T RHI003886-0001
IC800 IC626 2 IC 8 PIN TL072CD RCI000720-0001
IC303 IC304 IC401 IC601 IC602 IC702 6 IC 14 PIN TL074CD RCI000740-0001
Q508 Q509 2 XISTR NPN 2SC2001L NEC RAN202001-0001
Q401 Q501 Q502 Q601 Q701 Q602 6 XISTR NPN 2SC2878-A (TE2,.M) RAN202878-0001
Q800 Q801 Q402 3 XISTR NPN 2SC945P RAN200945-0001
Q510 1 XISTR PNP 2SA733Q,P NEC RAP200733-0001
ZD501 1 DIODE ZENR 5.6-5.9V 0.5W RAZ005006-0020
D603 D800 D801 3 CHIP DIODE LL4148 TELEFUNKEN RCD104148-0010
CN100 1 CONNECTOR 4 PIN PITCH=2.0mm CCN200000-0104
CN505 1 CONNECTOR 2 PIN LEOCO 3951 CCN396020-0102
CN503 1 CONNECTOR 4 PIN CL3962WVO CCN396020-0104
CN501 1 CONNECTOR 6 PIN CL3962WVO CCN396020-0106
CN601 1 CONNECTOR 11 PIN PITCH=2.0mm CCN200000-0111
CN102 1 CONNECTOR B3B-XH-A 3 PIN CCN250000-0103
CN505 1 WIRE TERM 2P 340mm 1015#18 A=3.96VH VWT503221-0340
L701 1 RF COIL 1 uH MDEC T40818-08 SIL001003-1090
C336 C337 C338 C339 C403 C404 24 CHIP CAP 0.1 uF 50V 5% PYL456370-1040
C530 C531 C532 C533 C606 C637 C638
C605 C340 C342 C341 C343 C405 C406
C607 C608 C609 C610
C652 C714 C651 C334 C335 C402 c604 11 CHIP CAP 220 pF 50V 5% PYL410370-2210
C416 C507 C508 C603
C633 C634 C642 C644 C723 C724 C418A 10 CHIP CAP 0.1 uF 50V 5% PYL456370-1040
C419A C803 C804
C623 C624 2 CHIP CAP 0.0022 uF 50V 5% PYL456370-2220
C719 C507A C508A C416A C651A C652A 6 CHIP CAP 47 pF 50V 5% PYL410370-4700
C726 1 CHIP CAP 0.022 uF 50V 5% PYL456370-2230
C413 C501 C502 C352 C354 C353 C355 13 CHIP CAP 0.0022 uF 50V 5% PYL456370-2220
C411 C412 C620 C622 C619 C621
C722 1 CHIP CAP 0.027 uF 50V 5% PYL456370-2730
R713 R538 R436 R539 R663 R664 C401 J1 34 CHIP RES. 0 OHM JUMP WIRE QCF015020-0000
J2 J3 J4 J5 J6 J7 R536 R537 R530 R545
R351 R352 R613 R614
R407 R353 R354 R408
R615 R616 C601 C602 C332 C333 J8 J9
R631 R632 R711 R701 10 CHIP RES. 1K OHM 1/10W 5% QCF015020-1020
R416 R501 R502 R729 R02 R03
R635 R636 R637 R709 R710 R638 R524 32 CHIP RES. 10K OHM 1/10W 5% QCF015020-1030
R339 R340 R345 R346
R401 R535 R418 R419
R505 R506 R507 R508
R601 R602 R607 R608 R730 R06 R12
R07 R08 R10 R541 R633A R634
R404 R704 R706 R517 R518 5 CHIP RES. 15K OHM 1/10W 5% QCF015020-1530
R633 R634 R708 R420 8 CHIP RES. 100K OHM 1/10W 5% QCF015020-1040
R417 R503 R520 R504
R09 R660 2 CHIP RES. 1M OHM 1/10W 5% QCF015020-1050
R365 R366 R414 R627 R628 R05 6 CHIP RES. 2.2K OHM 1/10W 5% QCF015020-2220
R01 R04 R732 R525 R610 R609 R348 R347 9 CHIP RES. 22K OHM 1/10W 5% QCF015020-2230
R406
R341 R402 R342 R603 R604 5 CHIP RES. 27K OHM 1/10W 5% QCF015020-2730
R726 1 CHIP RES 3.6K OHM 1/10W 5% QCF015020-3620
R733 1 CHIP RES. 36K OHM 1/10W 5% QCF015020-3630
R737 R725 2 CHIP RES. 4.7K OHM 1/10W 5% QCF015020-4720
R11 1 CHIP RES. 470K OHM 1/10W 5% QCF015020-4740
R639 R434 R509 R510 R640 5 CHIP RES. 560 OHM 1/10W 5% QCF015020-5610
R343 R344 R605 R606 9 CHIP RES. 5.6K OHM 1/10W 5% QCF015020-5620
R367 R368 R629 R630 R403
R703 R705 R349 R350 R405 R611 R612 7 CHIP RES. 6.8K OHM 1/10W 5% QCF015020-6820
R727 1 CHIP RES. 68K OHM 1/10W 5% QCF015020-6830
R724 R731 2 CHIP RES. 220K OHM 1/10W 5% QCF015020-2240
R427 1 CHIP RES. 56K OHM 1/10W 5% QCF015020-5630
R543 1 CHIP RES. 2.7K OHM 1/10W 5% QCF015020-2720
R519 R540 R544 3 CHIP RES. 47K OHM 1/10W 5% QCF015020-4730
R702 1 CHIP RES. 12K OHM 1/10W 5% QCF015020-1230
R362 R364 R361 R363 R412 R413 R624 10 CHIP RES. 150K OHM 1/10W 5% QCF015020-1540
R626 R623 R625
R415 R734 2 CHIP RES. 1.2K OHM 1/10W 5% QCF015020-1220
C725 1 CHIP CAP 0.068 uF 50V 10% PYL456470-6830
C720 C721 2 CHIP CAP 0.018 uF 50V 10% PYL456470-1830
R717 1 RESISTOR 4.7 OHM 1/2W 5% CF QAF025000-4790
R641 R642 R435 R511 R512 5 RESISTOR 18K OHM 1/6W 5% CF QAF065000-1830
R712 1 RESISTOR 24K OHM 1/6W 5% CF QAF065000-2430
R428 R429 2 RESISTOR 10 OHM 1/4W 5% CF QAF045000-1000
C717 1 COND MYLAR 0.1 uF 100V 5% PRM0373A0-1040
C707 1 COND ELECT 10 uF 50V 20% PRE039570-1000
C708 1 COND ELECT 33uF 16V 20% PRE039540-3300
C715 C716 C515 C516 4 COND ELECT 100uF 50V 20% PRE039570-1010
C625 C626 C414 C503 C504 5 COND ELECT 1uF 50V 20% PRE039570-1090
C418 C419 2 COND ELECT 220uF 25V 20% PRE039550-2210
C801 1 COND ELECT 4.7 uF 50V 20% PRE039570-4790
C800 1 COND ELECT 10uF 50V 20.% PRE339570-1000
C711 C712 C713 3 COND DISC 0.1 uF 50V +80-20% PRD339670-1040
RB101 1 CON/WIRE 3P 130mm 1007#26 FLAT VWA010090-0001
RB905 1 CON/WIRE 5P 270mm 1007#18 A=3.96VH VWA310006-0011
RB904 1 CON/WIRE 4P 180mm 1007#18 AWG A=3.96VH VWA310006-0009
2 PCB BKT Z SECC T=1.0mm GSE200012-0001
49 WIRE BARE 22 GA TINNED JP300 - JP348 XJP220000-0001
2 BRACKET SECC T=0.8mm GSE100054-0001
DC PCB
Installation Point Qty. Description Material No.
1 DC PCB ASSY HI APE200063-4001
1 PWR TRANS EI-96 230V TTK223001-0001
IC904 1 IC 3 PIN AN7806 MATSUSHITA RHI007806-0001
Loading...