Parts Catalog
Issued: Aug 8, 2007
Lynx L-3X
Scooter Series
Yes, you can. ™
Throughout this catalog you will notice letters to draw your attention to specific footnotes which are located at the
bottom of the page or below specified charts.
Parts Catalog Usage Guide
To order call toll free 1-800-333-6900, or www.invacare.com
The information contained in this document is subject to change without notice. This catalog contains
service parts for Form No. 07-080. If you have any questions regarding this catalog, please contact one
of our Customer Service Representatives.
For Customer Service Support Call:
1-800-333-6900
For Faxed In Orders Call:
1-800-678-4682 or
1-440-366-0709
For Technical Service Call:
1-800-832-4707
Literature Can Be Found at:
www.invacare.com or
1-800-828-6272
SYMBOL DEFINITION
Examples:
A,B,C etc.
NOTE:
NLA
= Special Comments
= General information pertaining to that specific page
= No Longer Available
HARDWARE MEASUREMENTS
The measurements for the hardware will be listed as follows:
Screws, Bolts
Washers
Spacers
For your convenience, we have supplied an area for you to list your Invacare Representatives.
©2007 Invacare Corporation. Elyria, Ohio. Invacare, the Medallion Design and Yes, you can. are registered trademarks and Lynx is a trademark of Invacare
Diameter X Thread Count/Pitch X Length
Inside Diameter X Outside Diameter X Thickness
Inside Diameter X Outside Diameter X Length
Name Phone Numbers
Corporation.
Form No.
07-080
1
TABLE of CONTENTS
To order call toll free 1-800-333-6900, or www.invacare.com
Form No.
07-080
Description
Chargers, Controller & Cable Cover ......................................................................................... 14
Floor Mats, Main and Rear Shrouds ........................................................................................ 5
Lower Tiller Assembly .............................................................................................................. 10
Motor, Transaxle & Rear Wheel ............................................................................................... 16
Seat and Arms .......................................................................................................................... 3
Tiller Maintenance .................................................................................................................... 7
Wire Harnesses & Battery Straps ............................................................................................. 12
2
Seat and Arms
Form No.
07-080
3
To order call toll free 1-800-333-6900, or www.invacare.com
Seat and Arms
Item
Number
Part Number
Description Note
Quantity Per
Package Assembly
1148842 Seat without Arms 1 1 1
1148843 Arm with Pad - Right 1 1 2
1148844 Arm with Pad - Left 1 1 3
1148847 Cover, Seat 1 1 4
1148848 Cover, Backrest 1 1 5
1148845 Kit, Seat Slide 1 1 6
1148850 Seat Post Hardware
Includes:
(1) ea. Nylon Nut,
(1) ea. Bolt, &
(2) ea. Washers.
1 1 7
1148852 Liner, Shroud/Guide Seat 1 1 8
1148849 Kit, Plugs and Knobs
Includes:
(2) ea. Screws &
(2) ea. Plugs.
1 1 9
1148846 Seat Bracket Assembly 1 1 10
1144812 Spring, Seat Lever 1 1 11
Form No.
07-080
To order call toll free 1-800-333-6900, or www.invacare.com
4
Floor Mats, Main and Rear Shrouds
Form No.
07-080
5
To order call toll free 1-800-333-6900, or www.invacare.com
Floor Mats, Main and Rear Shrouds
Item
Number
Part Number
Description Note
Quantity Per
Package Assembly
1148851 Kit, Floor Mat w/ Hardware
Includes:
(1) ea. Rubber Pad and
(6) ea. Push Rivets.
1 1 1
1144816 Pkg, Push Rivets (Pkg of 25) 25 1 A
1148855 Kit, Floor Shroud - Red
Includes:
(1) ea. 3-D Invacare Logo,
(1) ea. Front Shroud - Red,
(4) ea. Shield Bolts,
(1) ea. Front Bumper Cover,
(2) ea. Bolt,
(1) ea. Hook & Loop,
(1) ea. Weight Capacity Decal, and
(1) ea. Warning Label.
1 1 2
1148856 Kit, Floor Shroud - Blue
Includes:
(1) ea. 3-D Invacare Logo,
(1) ea. Front Shroud - Blue,
(4) ea. Shield Bolts,
(1) ea. Front Bumper Cover,
(2) ea. Bolt,
(1) ea. Hook & Loop,
(1) ea. Weight Capacity Decal, and
(1) ea. Warning Label.
1 1 2
1148857 Kit, Rear Shroud - Red
Includes:
(1) ea. Drive/Push Decal,
(1) ea. Rear Shroud - Red,
(1) ea. Hook & Loop, and
(2) ea. Lynx Side Logo Decals.
1 1 3
1148858 Kit, Rear Shroud - Blue
Includes:
(1) ea. Drive/Push Decal,
(1) ea. Rear Shroud - Blue,
(1) ea. Hook & Loop, and
(2) ea. Lynx Side Logo Decals.
1 1 3
1148853 Cover, Shroud Tail w/ Decal - Red 1 1 4
1148854 Cover, Shroud Tail w/ Decal - Blue 1 1 4
A - Not Shown
NOTE:
Form No.
07-080
To order call toll free 1-800-333-6900, or www.invacare.com
6
Tiller Maintenance
Form No.
07-080
7
To order call toll free 1-800-333-6900, or www.invacare.com
Tiller Maintenance
Item
Number
Part Number
Description Note
Quantity Per
Package Assembly
1148838 Kit, Tiller Cover - Red
Includes:
(1) ea. Upper Steering Cover,
(1) ea. Front Steering Cover - Red,
(1) ea. Rear Steering Cover - Red,
(1) ea. Faceplate Decal,
(1) ea. Reflector,
(6) ea. Tapping Screws,
(1) ea. Volt Meter,
(2) ea. Screw,
(1) ea. Speed Pot,
(1) ea. Speed Control Knob,
(1) ea. Ignition Switch w/ Key,
(1) ea. Horn speaker,
(2) ea. Screw,
(1) ea. 2-Pole Switch Complete,
(1) ea. Splash Cap Complete,
(1) ea. Meter PC Board, and
(2) ea. Screws.
1 1 1
1148839 Kit, Tiller Cover - Blue
Includes:
(1) ea. Upper Steering Cover,
(1) ea. Front Steering Cover - Blue,
(1) ea. Rear Steering Cover - Blue,
(1) ea. Faceplate Decal,
(1) ea. Reflector,
(6) ea. Tapping Screws,
(1) ea. Volt Meter,
(2) ea. Screw,
(1) ea. Speed Pot,
(1) ea. Speed Control Knob,
(1) ea. Ignition Switch w/ Key,
(1) ea. Horn speaker,
(2) ea. Screw,
(1) ea. 2-Pole Switch Complete,
(1) ea. Splash Cap Complete,
(1) ea. Meter PC Board, and
(2) ea. Screws.
1 1 1
1148841 Kit, Steering Bar
Includes:
(1) ea. Steering bar,
(2) ea. Hand Grips,
(1) ea. Plain Washer,
(2) ea. Nylon Washer, and
(1) ea. Bolt.
1 1 2
1148861 Basket 1 1 3
1144791 Kit, Speed Pot
Includes:
(1) ea. Speed Control Knob and
(1) ea. Speed Pot - 30 K Ohms
1 1 4
1144792 Pkg, Speed Control Knobs (Pkg of 10) 10 1 5
Form No.
07-080
To order call toll free 1-800-333-6900, or www.invacare.com
8
Tiller Maintenance
Item
Number
Part Number
Description Note
Quantity Per
Package Assembly
1144793 Ignition Switch w/Key 1 1 6
1144794 Pkg, Ignition Keys (Pkg of 10) 10 1 7
1144795 Throttle Pot & Lever Assembly 1 1 8
1144796 Throttle Lever w/Hardware 1 1 9
Form No.
07-080
9
To order call toll free 1-800-333-6900, or www.invacare.com
Lower Tiller Assembly
Form No.
07-080
10
To order call toll free 1-800-333-6900, or www.invacare.com
Lower Tiller Assembly
Item
Number
Part Number
Description Note
Quantity Per
Package Assembly
1148840 Kit, Fork w/ Hardware
Includes:
(1) ea. Fork,
(1) ea. Padlock,
(1) ea. Steering Nut,
(1) ea. Plain Washer,
(1) ea. Tooth Washer,
(1) ea. Steering Race, and
(2) ea. Set Bearing.
1 1 1
1148836 Kit, Frame Connection
Included:
(1) ea. Frame Hook,
(1) ea. Hook Pin,
(1) ea. C-Ring,
(1) ea. Spring,
(1) ea. Lever, &
(1) ea. Lever Cap.
1 1 2
1148837 Kit, Lower Steering Hardware
Includes:
(1) ea. Steering Adj.,
(1) ea. Plain Washer,
(2) ea. Nylon Nut,
(1) ea. Bolt,
(1) ea. Joint Bolt,
(1) ea. Washer, &
(1) ea. Guide Complete.
1 1 3
1148859 Kit, Front Wheel Assembly
Includes:
(2) ea. Nylon Nuts,
(1) ea. Front Wheel Assembly,
(1) ea. Plain Washer,
(1) ea. Bolt, &
(2) ea. Spacers.
1 1 4
Form No.
07-080
To order call toll free 1-800-333-6900, or www.invacare.com
11
Wire Harnesses & Battery Straps
Form No.
07-080
12
To order call toll free 1-800-333-6900, or www.invacare.com
Wire Harnesses & Battery Straps
Item
Number
Part Number
Description Note
Quantity Per
Package Assembly
1148831 Harness, Front Wiring 1 1 1
1148832 Kit, Rear Wiring Harness 1 1 2
1148834 Battery Straps 1 1 3
1148833 Kit, Battery Wiring 1 1 4
1144798 Cable, Charger 1 1 5
1144835 Fuse, 3 AMP 1 1 A
1144836 Fuse, 5 AMP 1 1 A
A - Not shown
NOTE:
Form No.
07-080
13
To order call toll free 1-800-333-6900, or www.invacare.com
Chargers, Controller & Cable Cover
Form No.
07-080
14
To order call toll free 1-800-333-6900, or www.invacare.com
Chargers, Controller & Cable Cover
Item
Number
Part Number
Description Note
Quantity Per
Package Assembly
1144573 Controller R-Series (DR-90) 1 1 1 A
1148830 Charger, 5 AMP Off-Board 24 DC 1 1 2
1148829 Cover, Plastic Cable 1 1 3
1148828 Kit, Controller R-Series (DR-90) w/ Hardware
Includes:
(1) ea. Controller and
(2) ea. Bolt.
1 1 4
A - The controller may or may not reflect the true look of the controller supplied.
NOTE:
Form No.
07-080
To order call toll free 1-800-333-6900, or www.invacare.com
15
Motor, Transaxle & Rear Wheel
Form No.
07-080
16
To order call toll free 1-800-333-6900, or www.invacare.com
Motor, Transaxle & Rear Wheel
Motor, Transaxle & Rear Wheel
Item
Number
Part Number
Description Note
Quantity Per
Package Assembly
1148824 Kit, Transaxle
Includes:
(1) ea. Differential,
(2) ea. Keys,
(2) ea. Bolts,
(1) ea. Guide, and
(1) ea. Decal, Inspection.
1 1 1
1148825 Kit, Motor with Brake
Includes:
(1) ea. Motor Assembly,
(1) ea. Guide, and
(2) ea. Keys.
1 1 2
1148827 Kit, Brake with Hardware
Includes:
(1) ea. Brake and
(4) ea. Screw M4 x 8L.
1 1 3
1148835 Kit, Transaxle Hardware
Includes
(2) ea. Holder, Differential,
(4) ea. Bolt M6 x 12L,
(1) ea. Bolt M8 x 25L, and
(1) ea. Nut.
1 1 4
1148860 Kit, Rear Wheel
Includes:
(2) ea. Spacers.
(1) ea. Rear Wheel,
(1) ea. Plain Washer,
(1) ea. Nylon Nut, and
(1) ea. Cap Washer.
1 1 5
Form No.
07-080
To order call toll free 1-800-333-6900, or www.invacare.com
17
Invacare Corporation
07-080
©2007 Invacare Corporation. Elyria, Ohio.
All rights reserved. Trademarks are
identified by the symbols ™ and ®. All
trademarks are owned by or licensed to
Invacare Corporation unless otherwise
noted. (Rev. 8/8/07)
www.invacare.com
Yes, you can. ™
One Invacare Way
Elyria, Oh USA
44036-2125
800-333-6900
Technical Support
800-832-4707
Florida Technical Support
407-321-5630
Customer Service
800-333-6900
Form No.