Inter-m Q-4300, Q-3300 Service Manual

Download

Page 1

SERVICE

MANUAL

Q-3300/4300

moc.m

-retni.ww

EROK NI EDAM

PROFESSIONAL POWER

AMPLIFIER

Page 2

ELECTRICAL ADJUSTMENT PROCEDURE

 REQUIRED TEST EQUIPMENT

1. Oscilloscope

2. 1kHz audio sine wave generator

3. Digital multimeter

4. 8ohm resistive load (rated for at least 750W)

 IDLE CURRENT (Q-3300/4300)

1. Setting Set the master volume controls minimum.

2. Connection

3. Adjustment a. Measure the DC voltage across the resistor R155 and R272. adjust VR101 and VR201. b. Adjust VR101 until the DC voltage is within the range as below table. c. Repeat the adjustment(a,b) for the other channel.

;ΠΕΖΝ ͵ʹΧΠΝΥΒΘΖΣΒΟΘΖ ͲΕΛΦΤΥ

΂ Ξ·ρΞ·

΂ Ξ·ρΞ·

ʹΙΒΟΟΖΝ͵ʹΧΠΝΥΒΘΖΒΔΣΠΤΤ΃ԽΒΕΛΦΤΥ·΃ ʹΙΒΟΟΖΝ͵ʹΧΠΝΥΒΘΖΒΔΣΠΤΤ΃ԽΒΕΛΦΤΥ·΃

Electrical Adjustment Procedure Specifications Electrical Parts List Top and Bottom View of P.C.Board Wiring Diagram Block Diagram Schematic Diagram Exploded View of Cabinet & Chassis / Mechanical Parts list

1 2 3~8 9~14 15 16 17~36 37~38

· · · · · · · · · · · · · · · · · · · · · · · ·

· · · · · · · · · · · · · · · · · · · · · · · · · · · · · ·

· · · · · · · · · · · · · · · · · · · · · · · · · · · · · · ·

· · · · · · · · · · · · · · · · · · · · · · · · · · · · · ·

· · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · ·

· · · · · · · · · · · · · · · · · · · · · ·

· · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · ·

· · · · · · · · · · · · · · · · · · ·

CONTENTS

Page 3

SPECIFICATIONSSPECIFICATIONS

ELECTRICAL PARTS LISTELECTRICAL PARTS LIST

Rated Output Power STEREO

BRIDGED

Input Sensitivity Rated Power @4Ω Gain SW : 1V 32dB 26dB Rated Power @8Ω Gain SW : 1V 32dB 26dB Voltage Gain @4Ω Gain SW 1V Frequency Response 1W@8Ω

Damping Factor 10Hz~1KHz @8Ω T.H.D (20Hz~20KHz, 1/10 Power STEREO 4Ω, 8Ω & BRIDGED 8Ω) Channel Seperation 1KHz, Half Power @8Ω Residual Noise Signal to Noise Ratio Output Circuitry Input Impedance High Pass Filter (30Hz/50Hz) Indicators Protection Circuitry

Cooling Connectors

Operating Temperature. Power Source Power Consumption 1/8 Power @4Ω. Weight Dimensions

8Ω (1kHz, THD 0.1%) 4Ω (1kHz, THD 0.1%) 2Ω (1kHz, THD 0.5%) 8Ω (1kHz, THD 0.1%) 4Ω (1kHz, THD 0.5%)

230 VAC

550W 1000W 1650W 2000W 3300W

120 VAC

550 W 1000 W 1600 W 2000 W 3200 W

120 VAC

750W 1300W 2000W 2600W 4000W

230 VAC

750W 1300W 2100W 2600W 4200W

0.94 V

1.63 V

3.25 V 1 V

1.74 V

3.47 V

1.04 V

1.81 V

3.61 V

1.14 V

1.94 V

3.88 V

36.8 dB

20 Hz~20 kHz : +0,-0.2 dB

10 Hz~100 kHz : +0,-3 dB

> 400

< 0.05%

> -70 dB

-73dBu

> -105 dB > -106 dB

2 Step Class H

12 kΩ Balanced, 12 kΩ Unbalanced

12dB/OCT

Active, Signal, Prot/Clip

Full Short Circuit, Thermal Protection

Power ON/OFF Muting, DC Output Protection

2 Variable Speed Fans, Front to Rear Air Flow Input : Combination Jack (XLR Female or 1/4” TRS) Link : XLR Male, Output : Speakon™ & Binding Post

-10°C +40°C

120VAC/60Hz230VAC/50Hz120VAC/60Hz230VAC/50Hz

12A 6A 14A 7A

11.7 kg/25.8lb

482(W) x 88(H) x 407(D)mm/19(W) x 4.6(H) x 16.2(D)in

Q-3300 Q-4300

0dBu=0.775Vrms

Ref. Part No. Description Value Ref. Part No. Description Value

J19 4355795704 CON ASS'Y,DS,1P,250T08,P2.6,110MM ASS'Y

J20 4355833204 CON ASS'Y,DS,1P,250T08,P2.6,110MM ASS'Y E4-5 1508400501 JUMP WIRE(0.5/52M/M) JUMPER CN1 4428592513 CON WAFER,BOX(M),14P,2/ST PC1635-14P Q305 2028106960 TR,PW,PNP,3A,100V,TIP32C TIP32C CN2 4428592516 CON WAFER,BOX(M),16P,2/ST PC1635-16P Q115-118 2028107118 TR,PW,PNP,15A,230V,2SA1943,TO-3P(L) 2SA1943 CN301-302 4428595003 CON WAFER,BOX(M),3P,ST LW5267-03P Q219-222 CN3-4 4465998210 TERMINAL(250)PCB TAB 250T Q114 Q218 2028107995 TR,PW,PNP,8A,250V,MJE15033,TO-220 MJE15033 RL1 5528009851 RELAY AZ2151-1C-24DE ZETTLER DC 24V Q125 Q229 2028110941 TR,PW,PNP,1A,230V,2SA1837 2SA1837 HS301 7505299310 HEAT SINK(30MM) REG TR Heat sink Q130-133 2028407122 TR,PW,NPN,15A,230V,2SC5200,TO-3P(L) 2SC5200 LIM101 LIM201 8545993380 LED LIMITER LED LIMITER Q234-237 Q124 Q228 2008005998-T TR,SG,PNP,200MA,40V,2N3906 2N3906 Q129 Q233 2028407995 TR,PW,NPN,8A,250V,MJE15032,TO-220 MJE15032 Q121 Q225 2008405998-T TR,SW,NPN,200MA,40V,2N3904 2N3904 Q120 Q224 2028410884 TR,PW,NPN,1A,230V,2SC4793,TO-220IS 2SC4793 R113 R216 3022165455-T RES,MF,16.5K,1W,1%,RA A,TA 16.5K 1W 1% Q1-2 2028900101 TR,IGBT,JF N,27A,600V,IRG4PC50 IR G4PC50W R3-4 3029303575-T RES,MF,30K,2W,5%,RA A,TA 30K 2W Q110 Q137 Q214 2048247900 TR,PW,MF N,60A,60V,NTP60N06G,TO-220 NTP60N06 R158 R160-162 3039150575-T RES,MF,15,2W,5%,RA R,TA 15 2W Q241 R274 R276-278 D114 D119 D215 2058100106 DIODE,RE,3A,400V,1N5404,DO-201A 1N5404 R353 3039151575-T RES,MF,150,2W,5%,RA R,TA 150 2W D219 R348 3039159575-T RES,MF,1.5,2W,5%,RA R,TA 1.5 2W BD1 2058199100 DIODE,BR,50A,600V,RBV5006,RBV25 RBV5006 R6-8 R157 3039569575-T RES,MF,5.6,2W,5%,RA R,TA 5.6 2W D20-23 2058300995 DIODE,RE,15A,400V,MUR1540,TO-2 MUR 1540 R159 R200 R275 D113 D230 D214 2058300996 DIODE,RE,15A,200V,MUR1520,TO-220AC MUR 1520 VR101 VR201 3248550120-T RES SEMI FT-63 TP(500) 500 D220 C24 3409210039-T CAP,EC,SM,WB,10UF,16V,M,5X11,T 100/16 D18-29 D24-25 2058499700 DIODE,SW,30A,400V,DSEP30-04A,TO-247AD DSEP30-04A C30 C43 C111 3409210062-T CAP,E,SM,SS,85C,10UF,35V,M 10/35 D2-3 2058499800

DIODE,SW,4A,400V,MUR440,DO-201AD

MUR440 C212 C312 D105 D206 2058502039 DIODE,ZN,500MW,BM,3.9V,DO-35,T 3.9BM C40-42 C69 3409210140-T CAP,EC,SM,WB,100UF,25V,M 100/25 D313 2058502240 DIODE,ZN,500MW,BM,24V,DO-35,TA 24BM C71 C73 D307-310 2058510150 DIODE,ZN,1W,BM,15V,DO-41,TA 15BM C108 C113 C208 3409210141-T CAP,E,SM,SG,85C,100UF,25V,M 100/25 D311 2058512150 DIODE,ZN,1W,BM,12V,DO-41,TA 12V 1W C213 C316-318 D106 D207 2058512190 DIODE,ZN,1W,BM,10V,DO-41,TA 10V 1W C321 U101 U201 2118013377 IC,OP AMP,NE5532P,DIP8 5532N C103 C206 C310 3409210971-T CAP,E,SM,SG,85C,1UF,50V,M 1/50 U2 2118031800 IC,PWM CONT,SG3525AN,DIP16 SG3525AN C114 C123 C214 3409222033-T CAP,E,SM,SE,85C,22UF,16V,M 22/16 U1 2128220089 IC,DRIVER,IR2110,DIP14P,IR IR2110 C223 U5 2128660000 IC,PWM SW,TOP210,DIP08P TOP210 C46 3409233147-T CAP,E,SM,SD,85C,330uF,25V,M 330/25 PC1-2 2408000980 PHOTO COUPLER,1U,CNY17F-1,ON S CNY17F-1 C314 3409247071-T CAP,E,SM,SG,85C,47UF,50V,M 47/50 TH1 2438200960 THERMIST,NTC,20A,10OHM,85C,HJ NTC-10 C301-306 3409247147-T CAP,E,SM,SD,85C,470UF,25V,M 470/25 TH101 TH201 2438200970 KCL103F414FL,NTC,10K KCL103F C32 3409710070-T CAP,E,NP,NP,85C,10UF,50V,M 10/50 NP L101 L201 2648099800 COIL,AIR,2.2UH 2.2 uH C102 C202 C308 3409847041-T CAP,E,NP,NP,85C,47UF,25V,M 47/25 NP L3-8 2648609800 COIL,FER,RADIAL,6UH 6uH C106 C204 3529150210-T CAP,CE,TEMP,NPO,15PF,50V,J,RA 15P L9 2648699510 COIL,FER,TOROID,1.9UH,20A 1.9UH C120 C220 3609223120-T CAP,FILM,POLYESTR,0.022UF,100V 0.022/100(M) L1-2 2648699520 COIL,FER,TOROID,2.2MH,20A 2mH C15 3609332120-T CAP,FILM,POLYESTR,0.0033UF,100V 0.0033/100(M) T2 2828053800 TRANS,PW,SMPS,Q-3300 TRANS TP101 TP201 4225000810-T TERMINAL,PIN,TEST,1P,TA TP T1 2828053900 TRANS,PW,SMPS,EE,Q-3300/4300 TRANS Q123 Q227 S20110402001 TR,SG,PNP,500MA,300V,KST92,SOT KST92 R1-2 3027503660 RES,MF,750K,1/2W,5%,AX M 750K 1/2W Q122 Q226 S20160402009 TR,SG,NPN,500MA,300V,KST42MTF, KST42MTF R142 R171 R258 3029150572 RES,MF,15,2W,5%,AX M 15 2W Q3-4 Q7 S20510405004 TR,SG,PNP,200MA,40V,2N3906S,SOT-23,TA 2N3906S R288 R50 Q101 Q104 Q106 R153 R182 R269 3029159572 RES,MF,1.5,2W,5%,AX M 1.5 2W Q109 Q111-112 R299 Q128 Q136 R143-150 3029478572 RES,MF,0.47,2W,5%,AX M 0.47 2W Q202-205 R172-179 Q208 Q210 Q213 R259-266 Q215-216 Q232 R289-296 Q240 Q301-302 R341-342 3032701960 RES,MO,2.7K,3W,5%,AX P 2.7K 3W Q5-6 Q8 S20560448002 TR,SG,NPN,200MA,40V,MMBT3904,SOT-23,TA 2N3904 R340 3039331673 RES,MO,330,3W,5%,AX N 330 3W Q102-103 Q105 R354-355 3039471674 RES,MO,470,3W,5%,AX P 470 3W Q107-108 Q113 R5 3039560673 RES,MO,56,3W,5%,AX N 56 3W Q126-127 Q135 R349-350 3039681674 RES,MO,680,3W,5%,AX P 680 3W Q201 Q206-207 R351 3039821674 RES,MO,820,3W,5%,AX N 820 3W Q209 Q211-212 R352 Q217 Q230-231 R132-133 3039822674 RES,MO,8.2K,3W,5%,AX N 8.2K 3W Q239 Q303-304 R248-249 R347 U4 S21101142601 IC,OP AMP,LM339,SOP14 LM339MX C49-53 3409247189 CAP,E,SM,WB,470UF,63V,M,16X20 470/63 U102 S21101167701 IC,OP AMP,NJM13600M,DMP16 NJM13600M C64-68 U301 S21102084801 IC,COMP,LM393,SOP08 LM393D C54-63 3409247199 CAP,EC,SM,WB,470UF,100V,M,18X40 470/100 U103-104 S21102087701 IC,COMP,LM311,DMP8 LM311D C7-10 3419033205 CAP,EC,LA,LS,3300UF,200V,M,35X70 3300/200 U202-203 C2-3 C13 3549222091 CAP,CE,AC,Y2/X1,2200PF,250VAC 2200P250 U3 S21283142601 IC,TIMER,LM556CM,SOP14 LM556CM C39 C74 D1 D4 D5 D7 S22400500001 DIODE,SW,0.2A,200V,BAS21,SOT-23 BAS21 C70 C72 C116 3630104500 CAP,FILM,M-POLYESTR,0.1UF,250V 0.1/250(M) D11-13 D15-17 C121 C125 C216 D10 D101-104 C221 C225 C315 D107-112 C320 D115-118 C16 C31 C319 3639104600 CAP,FILM,M-POLYESTR,0.1UF,400V,K 0.1/400(M) D121 D201-205 C6 3649104251 CAP,FILM,AC,X2,0.1UF,250VAC,K 0.1/250 D208-213 C47 3659101179 CAP,FILM,MICA,100PF,500V,J 100P500 D216-218 C17 3659331179 CAP,FILM,MICA,330PF,63V,J 330P500 D221-222 C18 D301-305 D312 C1 C4 3669105208 CAP,FILM,M-POLYPRPN,1UF,275V 1/275(M) D6 D8 D30 S22501048001 DIODE MURS160T3 MOTOROLA MUR160T3 C5 3669474208 CAP,FILM,M-POLYPRPN, 0.47UF,275V 0.47/275(M) D9 D26-29 S22501448001 DIODE,SW,1A,600V,MURS120TS,DO-214AA,TA MURS120T3 C14 3670474600 CAP,FILM,M-POLYPRPN,0.47UF,400V,J 0.47/400(M) D306 S22620620010 DIODE,ZN,350MW,BM,6.2V,BZX84C6 6.2V AN11,AN12 4355428921 CON ASS'Y,DS,2P,P2.6,P2.6,510MM D14 S22621100010 DIODE,ZN,350MW,BM,10V,BZX84C10 10V AN1 4355429300 CON ASS'Y,DS,1P,P2.6,P2.6,40MM R97-98 R163 S30101017231 RES,TF,100,1/10W,5%,2012 100 AN5 4355429303 CON ASS'Y,DS,1P,P2.6,P2.6,100MM R193 R220-221 AN9,AN10 4355716121 CON ASS'Y,DS,2P,P2.6,P2.6,510MM R270 R279 AN2 4355791712 CON ASS'Y,DS,1P,P2.6,P2.6,250MM R108 R204-205 S30101027340 RES,TF,1K,1/8W,5%,3216 1K

AMP B'D (40 051 765 00 ) Q -3 300

Page 4

4 5

Ref. Pa rt No. Description Value Ref. Part No. Description Value

R229 R320 R324 R34 R51 R311 S30153925441 RES,TF,39.2,1/4W,1%,3216 39.2 1% R106 R206 R228 S30101047231 RES,TF,100K,1/10W,5%,2012 100K R312 R314-315 R335 S30101237231 RES,TF,12K,1/10W,5%,2012 12K R131 R192 R247 S30154755230 RES,TF,47.5,1/10W,1%,2012 47.5 1% R102-105 R112 S30101527231 RES,TF,1.5K,1/10W,5%,2012 1.5K R310 R118-119 R213 R9-10 R35 S30301005440 RES,MF,10,1/4W,1%,3216,TA 10 1% R224-227 R16 S30337875330 RES MF 7.87K F 2012 7.87K R232-233 R137 R167 R253 S30342745330 RES,MF,274,1/8W,1%,2012,TA 274 1% R338-339 R283 R120 R235 S30101537231 RES,TF, 15K,1/10W,5%,2012 15K C107 C203 S35101004330 CAP,CE,MONO,COG,10PF,50V,J,2012 10P R45 R47 R123 S30101547340 RES,TF,150K,1/8W,5%,3216 150K C101 C109 C201 S35101014331 CAP,CE,MONO,COG,100PF,50V,J,2012 100P R19-20 R43 C209 R125 R184-185 C29 C45 C309 S35101024344 CAP,CE,MONO,X7R,1000PF,50V,5% 1000pF R239 R241 R302 C311 C313 R304 C19-23 C26 S35101044344 CAP,CE,MONO,X7R,0.1UF,50V,K,3216 0.1U R141 R170 R257 S30102017231 RES,TF,200,1/10W,5%,2012 200 C38 C44 C104 R287 C117 C122 C127 R122 R238 R333 S30102027231 RES,TF,2K,1/10W,5%,2012 2K C207 C217 C222 R99 S30102037231 RES,TF,20K,1/10W,5%,2012 20K C227 C307 R222 R318 R321 C33-35 S35102725434 CAP,CE,MONO,X7R,2700PF,100V 2700P R327-328 R332 C110 C115 C124 R52 S30102737231 RES,TF,27K,1/10W,5%,2012 27K C210 C215 C224 R155-156 S30107507231 RES,TF,75,1/10W,5%,2012 75 C112 C126 C128 S35104704331 CAP,CE,MONO,COG,47PF,50V,J,2012 47P R272-273 C211 C226 C228 R111 R207-209 S30107527230 RES TF 7.5K J 1/10W 2012 7.5K C25 C27-28 S35104714344 CAP,CE,MONO,COG,470PF,50V,J,3216 470P R217 C36-37 C48 R136 S30111045440 RES,TF,100K,1/4W,1%,3216 100K C105 C119 C205 R36 R37 R139 S30111045440 RES,TF,100K,1/4W,1%,3216 100K 1% C219 R164 R195 R250 C118 C218 S35106815331 CAP,CE,MONO,COG,680PF,50V,J,2012 680P R255 R280 R285 R337 R30 R100 R127 S30113925331 R ES,TF,392K,1/8W,1%,2012 392K 1% C601-602 3630104500 CAP,FILM,M-POLYESTR,0.1UF,250V 0.1/250(M) R187 R223 R243 JK601 4438189810 JACK,BINDING POST,4U,4P,2/AN,C BINDING04P R307 R336 R345 JK602-603 4438189710 JACK,SPEA KON,1U,4P,AN SPEAKON4P R23-24 R27-28 S30114875441 RES,TF,487K,1/4W,1%,3216 487K 1% R14-15 R31-32 S30121005230 RES,TF,10K,1/10W,1%,2012 10K 1% R42 R46 AN501 4355429008 CON ASS'Y,RB,14P,IDC2.54,DIP2.54,170MM ASS'Y-14P R22 R44 R92 S30121275230 RES,TF,12.7K,1/10W,1%,2012 12.7K 1% JK402 JK404 4438086010 JACK,XLR(M),1U,7P,ST XLR/M R93 R95 R107 JK401 JK403 4438086210 JACK,COMBO,1U,7P,ST COMBO07P R116 R121 R130 SW501-503 4618499310 SW SLIDE SS84017-0403-5.3T-FN SS84017 R154 R201-202 SW506 R211-212 R234 SW504-505 4628991710 SW,PUSH,VER ,DPDT,NS,1U,L12.5 SPEC122SC011 R237 R246 R271 BK501 6505955520 PCB BKT MX-400 BRACKET R322-323 R344 C521 C522 3409210071-T CAP,E,SM,SG,85C,10UF,50V,M 10/50 R12 S30121505230 RES TF 15K F 1/10W 2012 15K 1% C503 C508 C511 3409847041-T CAP,E,NP,NP,85C,47UF,25V,M 47/25 NP R41 S30122005230 RES,TF,20K,1/10W,1%,2012 20K 1% C516 R26 S30122495331 RES,TF,24.9K,1/8W,1%,2012 24.9K 1% C505 C513 3609683120-T CAP,FILM,POLYESTR,0.068UF,100V 0.068/100 R183 R194 S30123325441 RES,TF, 33.2K,1/4W,1%,3216 33.2K 1% C507 C515 3639224188-T CAP,FILM,M-POLYESTR,0.22UF,63V 0.22/63(M) R300-301 C506 C514 3639473188-T CAP,FILM,M-POLYESTR, 0.047UF,63V 0.047/63(M) R25 R29 R96 S30123925331 RES,TF,39.2K,1/8W,1%,2012 39.2K 1% U501-504 S21101087701 IC,OP AMP,NE5532A,SOP8 NE5532A R135 R140 R165 D501-504 S22400500001 DIODE,SW,0.2A,200V,BAS21,SOT-23 BAS21 R169 R218 R252 R505 R518 S30101037231 RES,TF, 10K,1/10W,5%,2012 10K R256 R281 R286 R506 R519 S30101047231 RES,TF, 100K,1/10W,5%,2012 100K R319 R346 R512 R525 S30102037231 RES,TF,20K,1/10W,5%,2012 20K R186 R306 S30124755331 RES,TF, 47.5K,1/8W,1%,2012 47.5K 1% R527-530 S30107507231 RES,TF,75,1/10W,5%,2012 75 R39 S30131005230 RES,TF,1K,1/10W,1%,2012 1K 1% R507 R513 R520 S30107527230 RES TF 7.5K J 1/10W 2012 7.5K R334 S30131745331 RES,TF,1.74K,1/8W,1%,2012 1.74K 1% R526 R48-49 R94 S30132215331 RES, TF,2.21K,1/8W,1%,2012 2.21K 1% R508 R521 S30121375230 RES, TF,13.7K,1/10W,1%,2012 13.7K 1% R110 R129 R138 R511 R524 S30124755331 RES,TF, 47.5K,1/8W,1%,2012 47.5K 1% R168 R191 R210 R509 R522 S30133655230 RES,TF, 3.65K,1/10W,1%,2012 3.65K 1% R231 R245 R254 R510 R523 S30134755331 RES,TF, 4.75K,1/8W,1%,2012 4.75K 1% R284 R309 R317 R501-504 S30135605230 RES,TF,5.6K,1/10W,1%,2012 5.6K 1% R329-331 R514-517 R864 C501-502 S35101014331 CAP,CE,MONO,COG,100PF,50V,J,2012 100P R13 R21 R40 S30134755331 RES,TF,4.75K,1/8W,1%,2012 4.75K 1% C509-510 R91 C523-524 S35101045331 CAP,CE,MONO,X7R,0.1UF,50V,Z,2012 0.1U R124 R126 R134 C504 C512 S35102204339 CAP,CE,MONO,COG,22PF,50V,J,2012 22P R166 R188-189 C517-520 S35104714330 CAP,CE,MONO,COG,470PF,50V,J,2012 470P R203 R240 R242 R251 R282 R303 R305 ZD401-402 2058502024 DIODE,ZN,500MW,BM,2.4V,DO-35,T 2.4BM R115 R128 R190 S30135905230 RES,TF,5.9K,1/10W,1%,2012 5.9K 1% LD401 LD407 2300030100 LED,RND 3.1MM,RED,DIF,1U,ST2.5 LTL-1CHE R215 R244 R308 LD402-406 2300032100 LED,RND 3.1MM,GRN,DIF,1U,ST2.5 LTL-1CHG R343 S30139095331 RES,TF,9.09K,1/8W,1%,2012 9.09K 1% LD408 R11 R18 S30141005230 RES,TF,100,1/10W,1%,2012 100 1% VR401-402 3228065800 VR,ROT,VER,1U,BUSH,L15,10K,B,21D 10KB R109 R230 R313 S30143835331 RES,TF,383,1/8W,1%,2012 383 1% AN402 4355429120 CON ASS'Y,RB,16P,IDC2.54,DIP2.54,480MM ASS'Y-16P R316 LIM1-8 8545993340 LED LIMITER LED LIMITER R101 R117 R219 S30144755230 RES,TF,475,1/10W,1%,2012 475 1% C402 C404 3409210023-T CAP,E,SM,SE,85C,10UF,50V,M 10/50 R236 Q401-402 S20510405004 TR,SG,PNP,200MA,40V,2N3906S,SOT-23,TA 2N3906S R17 R33 R114 S30145365331 RES,TF,536,1/8W,1%,2012 536 1% Q404-405 R214 Q407-408 R325 S30146345440 RES TF 634F 1/4W 3216 634 1% Q403 Q406 S20560448002 TR,SG,NPN,200MA,40V,MMBT3904,SOT-23,TA 2N3904 R38 S30151005230 RES,TF,10,1/10W,1%,2012 10 1% D401-404 S22400500001 DIODE,SW,0.2A,200V,BAS21,SOT-23 BAS21

O UTPUT B'D (4 005 176 51 0) Q - 330 0

INPU T B'D (400 517 640 0) Q -33 00

LED B'D (40 051 764 10 ) Q -3 300

Ref. Pa rt No. Description Value

R402 R405 S30101027340 RE S,TF,1K,1/8W,5%,3216 1K R401 R403-404 S30134755331 RES,TF,4.75K,1/8W,1%,2012 4.75K 1% R406 C401 C403 S35104714344 CAP,CE,MONO,COG,470PF,50V,J,3216 470P

AC CORD 4308997410 AC POWER CORD (16A/250V) 230VAC AC CORD 4308997610 AC POWER CORD (15A/125V) 120VAC AC INLET 4448597210 AC INLET 3P 2.0T 16A/20A 4793 CONNECTOR 4355429504 CON ASS'Y,DS,1P,R5.3,250T08,110MM CONNECTOR 4355429510 CON ASS'Y,DS,1P,R5.3,250T08,210MM CONNECTOR 4355810803 CON ASS'Y,DS,1P,250T08,ST4.2,100MM FAN 1,2 7308997510 DC FAN(3110KL-05W-B70-F04) SW 4648099810 SW,POWER,18A,250V,AJ1-B0-44-618-5C2-D 230VAC SW 4648099920 SW POWER AJ1-B0-44-635-5C2-C 120VAC

ASS'Y Q - 330 0

Page 5

6 7

Ref. Pa rt No. Description Value Ref. Part No. Description Value

CN2 4428592516 CON WAFER,BOX(M),16P,2/ST PC1635-16P

CN301-302 4428595003 CON WAFER,BOX(M),3P,ST LW5267-03P E4-5 1508400501 JUMP WIRE(0.5/52M/M) JUMPER CN3-4 4465998210 TERMINAL(250)PCB TAB 250T Q305 2028106960 TR,PW,PNP,3A,100V,TIP32C TIP32C RL1 5528009851 RELAY AZ2151-1C-24DE ZETTLER DC 24V Q115-119 2028107118 TR,PW,PNP,15A,230V,2SA1943,TO-3P(L) 2SA1943 HS301 7505299310 HEAT SINK(30MM) REG TR Heat sink Q219-223 LIM101 LIM201 8545993380 LED LIMITER LED LIMITER Q114 Q218 2028107995 TR,PW,PNP,8A,250V,MJE15033,TO-220 MJE15033 Q124 Q228 2008005998-T TR,SG,PNP,200MA,40V,2N3906 2N3906 Q125 Q229 2028110941 TR,PW,PNP,1A,230V,2SA1837 2SA1837 Q121 Q225 2008405998-T TR,S W,NPN,200MA,40V,2N3904 2N3904 Q130-134 2028407122 TR,PW,NPN,15A,230V,2SC5200,TO-3P(L) 2SC5200 R113 R216 3022165455-T RES,MF,16.5K,1W,1%,RA A,TA 16.5K 1W 1% Q234-238 R3-4 3029303575-T RES,MF,30K,2W,5%,RA A,TA 30K 2W Q129 Q233 2028407995 TR,PW,NPN,8A,250V,MJE15032,TO-220 MJE15032 R158 R160-162 3039150575-T RES,MF,15,2W,5%,RA R,TA 15 2W Q120 Q224 2028410884 TR,PW,NPN,1A,230V,2SC4793,TO-220IS 2SC4793 R274 R276-278 Q1-2 2028900101 TR,IGBT,JF N,27A,600V,IRG4PC50 IRG4PC50W R353 3039151575-T RES,MF,150,2W,5%,RA R,TA 150 2W Q110 Q137 Q214 2048247900 TR,PW,MF N,60A,60V,NTP60N06G,TO-220 NTP60N06 R348 3039159575-T RES,MF,1.5,2W,5%,RA R,TA 1.5 2W Q241 R6-8 R157 3039569575-T RES,MF,5.6,2W,5%,RA R,TA 5.6 2W D114 D119 D215 2058100106 DIODE,RE,3A,400V,1N5404,DO-201A 1N5404 R159 R200 R275 D219 VR101 VR201 3248550120-T RES SEMI FT-63 TP(500) 500 BD1 2058199100 DIODE,BR,50A,600V,RBV5006,RBV25 RBV5006 C24 3409210039-T CAP,EC,SM,WB,10UF,16V,M,5X11,T 100/16 D20-23 2058300995 DIODE,RE,15A,400V,MUR1540,TO-2 MUR 1540 C30 C43 C111 3409210062-T CAP,E,SM,SS,85C,10UF,35V,M 10/35 D113 D120 D214 2058300996 DIODE,RE,15A,200V,MUR1520,TO-220AC MUR 1520 C212 C312 D220 C40-42 C69 3409210140-T CAP,EC,SM,WB,100UF,25V,M 100/25 D18-19 D24-25 2058499700 DIODE,SW,30A,400V,DSEP30-04A,TO-247AD DSEP30-04A C71 C73 D2-3 2058499800

MUR440 C108 C113 C208 3409210141-T CAP,E,SM,SG,85C,100UF,25V,M 100/25 D105 D206 2058502039 DIODE,ZN,500MW,BM,3.9V,DO-35,T 3.9BM C213 C316-318 D313 2058502240 DIODE,ZN,500MW,BM,24V,DO-35,TA 24BM C321 D307-310 2058510150 DIODE,ZN,1W,BM,15V,DO-41,TA 15BM C103 C206 C310 3409210971-T CAP,E,SM,SG,85C,1UF,50V,M 1/50 D311 2058512150 DIODE,ZN,1W,BM,12V,DO-41,TA 12V 1W C114 C123 C214 3409222033-T CAP,E,SM,SE,85C,22UF,16V,M 22/16 D106 D207 2058512190 DIODE,ZN,1W,BM,10V,DO-41,TA 10V 1W C223 U101 U201 2118013377 IC,OP AMP,NE5532P,DIP8 5532N C314 3409247071-T CAP,E,SM,SG,85C,47UF,50V,M 47/50 U2 2118031800 IC,PWM CONT,SG3525AN,DIP16 SG3525AN C46 C301-306 3409247147-T CAP,E,SM,SD,85C,470UF,25V,M 470/25 U1 2128220089 IC,DRIVER,IR2110,DIP14P,IR IR2110 C32 3409710070-T CAP,E,NP,NP,85C,10UF,50V,M 10/50 NP U5 2128660000 IC,PWM SW,TOP210,DIP08P TOP210 C102 C202 C308 3409847041-T CAP,E,NP,NP,85C,47UF,25V,M 47/25 NP PC1-2 2408000980 PHOTO COUPLER,1U,CNY17F-1,ON S CNY17F-1 C106 C204 3529150210-T CAP,CE,TEMP,NPO,15PF,50V,J,RA 15P TH1 2438200960 THERMIST,NTC,20A,10OHM,85C,HJ NTC-10 C120 C220 3609223120-T CAP,FILM,POLYESTR,0.022UF,100V 0.022/100(M) TH101 TH201 2438200970 KCL103F414FL,NTC,10K KCL103F C15 3609332120-T CAP,FILM,POLYESTR,0.0033UF,100V 0.0033/100(M) L101 L201 2648099800 COIL,AIR,2.2UH 2.2 uH TP101 TP201 4225000810-T TERMINAL,PIN,TEST,1P,TA TP L3-8 2648609800 COIL,FER,RADIAL,6UH 6uH Q123 Q227 S20110402001 TR,SG,PNP,500MA,300V,KST92,SOT KST92 L9 2648699510 COIL,FER,TOROID,1.9UH,20A 1.9UH Q122 Q226 S20160402009 TR,SG,NPN,500MA,300V,KST42MTF, KST42MTF L1-2 2648699520 COIL,FER,TO ROID,2.2MH,20A 2mH Q3-4 Q7 Q101 S20510405004 TR,SG,PNP,200MA,40V,2N3906S,SOT-23,TA 2N3906S T2 2828053700 TRANS,PW,SMPS,Q-4300 TRA NS Q104 Q106 Q109 T1 2828053900 TRANS,PW,SMPS,EE,Q-3300/4300 TRANS Q111-112 Q128 R1-2 3027503660 RES,MF,750K,1/2W,5%,AX M 750K 1/2W Q136 Q202-205 R50 R142 R171 3029150572 RES,MF,15,2W,5%,AX M 15 2W Q208 Q210 Q213 R258 R288 Q215-216 Q232 R153 R182 R269 3029159572 RES,MF,1.5,2W,5%,AX M 1.5 2W Q240 Q301-302 R299 Q5-6 Q8 S20560448002 TR,SG,NPN,200MA,40V,MMBT3904,SOT-23,TA 2N3904 R143-152 3029478572 RES,MF,0.47,2W,5%,AX M 0.47 2W Q102-103 Q105 R172-181 Q107-108 Q113 R259-268 Q126-127 Q135 R289-298 Q201 Q206-207 R341-342 3032701960 RES,MO,2.7K,3W,5%,AX P 2.7K 3W Q209 Q211-212 R340 3039331673 RES,MO,330,3W,5%,AX N 330 3W Q217 Q230-231 R354-355 3039471674 RES,MO,470,3W,5%,AX P 470 3W Q239 Q303-304 R5 3039560673 RES,MO,56,3W,5%,AX N 56 3W U4 S21101142601 IC,OP AMP,LM339,SOP14 LM339MX R349-350 3039681674 RES,MO,680,3W,5%,AX P 680 3W U102 S21101167701 IC,OP AMP,NJM13600M,DMP16 NJM13600M R351-352 3039821674 RES,MO,820,3W,5%,AX N 820 3W U301 S21102084801 IC,COMP,LM393,SOP08 LM393D R132-133 3039822674 RES,MO,8.2K,3W,5%,AX N 8.2K 3W U103-104 S21102087701 IC,COMP,LM311,DMP8 LM311D R248-249 R347 U202-203 C49-53 C64-68 3409247189 CAP,E,SM,WB,470UF,63V,M,16X20 470/63 U3 S21283142601 IC,TIMER,LM556CM,SOP14 LM556CM C54-63 3409247199 CAP,EC,SM,WB,470UF,100V,M,18X40 470/100 D1 D4-5 D7 S22400500001 DIODE,SW,0.2A,200V,BAS21,SOT-23 BAS21 C7-12 3419027205 CAP,EC,LA,LS,2700UF,200V,M,35X70 2700/200 D10-13 D15-17 C2-3 C13 3549222091 CAP,CE,AC,Y2/X1,2200PF,250VAC 2200P250 D101-104 C39 C74 D107-112 C70 C72 C116 3630104500 CAP,FILM,M-POLYESTR,0.1UF,250V 0.1/250(M) D115-118 D121 C121 C125 C216 D201-205 C221 C225 C315 D208-213 C320 D216-218 C16 C31 C319 3639104600 CAP,FILM,M-POLYESTR,0.1UF,400V,K 0.1/400(M) D221-222 C6 3649104251 CAP,FILM,AC,X2,0.1UF,250VAC,K 0.1/250 D301-305 D312 C47 3659101179 CAP,FILM,MICA,100PF,500V,J 100P500 D6 D8 D30 S22501048001 DIODE MURS160T3 MOTOROLA MUR160T3 C17-18 3659331179 CAP,FILM,MICA,330PF,63V,J 330P500 D9 D26-29 S22501448001 DIODE,SW,1A,600V,MURS120TS,DO-214AA,TA MURS120T3 C1 C4 3669105208 CAP, FILM,M-POLYPRPN,1UF,275V 1/275(M) D306 S22620620010 DIODE,ZN,350MW,BM,6.2V,BZX84C6 6.2V C5 3669474208 CAP,FILM,M-POLYPRPN,0.47UF,275V 0.47/275(M) D14 S22621100010 DIODE,ZN,350MW,BM,10V,BZX84C10 10V C14 3670474600 CAP,FILM,M-POLYPRPN,0.47UF,400V,J 0.47/400(M) R97-98 R163 S30101017231 RES,TF,100,1/10W,5%,2012 100 AN11,AN12 4355428921 CON ASS'Y,DS,2P,P2.6,P2.6,510MM ASS'Y R193 R220-221 AN1 4355429300 CON ASS'Y,DS,1P,P2.6,P2.6,40MM ASS'Y R270 R279 AN5 4355429303 CON ASS'Y,DS,1P,P2.6,P2.6,100MM ASS'Y R108 R204-205 S30101027340 RES,TF,1K,1/8W,5%,3216 1K AN9,AN10 4355716121 CON ASS'Y ,DS,2P,P2.6,P2.6,510MM ASS'Y R229 R320 R324 AN2 4355791712 CON ASS'Y,DS,1P,P2.6,P2.6,250MM ASS'Y R326 J19 4355795704 CON ASS'Y,DS,1P,250T08,P2.6,110MM ASS'Y R106 R206 R228 S30101047231 RES,TF,100K,1/10W,5%,2012 100K J20 4355833204 CON ASS'Y,DS,1P,250T08,P2.6,110MM ASS'Y R335 S30101237231 RES,TF,12K,1/10W,5%,2012 12K CN1 4428592513 CON WAFER,BOX(M),14P,2/ST 14P R102-105 S30101527231 RES,TF,1.5K,1/10W,5%,2012 1.5K

AMP B'D (40 051 765 00 ) Q -4 300

Ref. Pa rt No. Description Value Ref. Part No. Description Value

R112 R118-119 R310 R213 R224-227 R9-10 R35 S30301005440 RES,MF,10,1/4W,1%,3216,TA 10 1% R232-233 R16 S30337875330 RES MF 7.87K F 2012 7.87K R338-339 R137 R167 R253 S30342745330 RES,MF,274,1/8W,1%,2012,TA 274 1% R120 R235 S30101537231 RES,TF,15K,1/10W,5%,2012 15K R283 R19-20 R43 S30101547340 RES,TF, 150K,1/8W,5%,3216 150K C107 C203 S35101004330 CAP,CE,MONO,COG,10PF,50V,J,2012 10P R45 R47 R123 C101 C109 C201 S35101014331 CAP,CE,MONO,COG,100PF,50V,J,2012 100P R125 R136 R164 C209 R184-185 R239 C29 C45 C309 S35101024344 CAP,CE,MONO,X7R,1000PF,50V,5% 1000pF R241 R250 R280 C311 C313 R302 R304 C19-23 C26 S35101044344 CAP,CE,MONO,X7R,0.1UF,50V,K,3216 0.1U R141 R170 R257 S30102017231 RES,TF,200,1/10W,5%,2012 200 C38 C44 R287 C104 C117 C122 R122 R238 R333 S30102027231 RES,TF,2K,1/10W,5%,2012 2K C127 C207 C217 R222 R318 R321 S30102037231 RES,TF,20K,1/10W,5%,2012 20K C222 C227 C307 R327-328 R332 C33-35 C110 S35102725434 CAP,CE,MONO,X7R,2700PF,100V 2700P R99 C115 C124 C210 R155-156 S30107507231 RES,TF,75,1/10W,5%,2012 75 C215 C224 R272-273 C112 C126 C128 S35104704331 CAP,CE,MONO,COG,47PF,50V,J,2012 47P R111 R207-209 S30107527230 RES TF 7.5K J 1/10W 2012 7.5K C211 C226 C228 R217 C25 C27-28 S35104714344 CAP, CE,MONO,COG,470PF,50V,J,3216 470P R195 R255 R285 S30111045440 RES,TF,100K,1/4W,1%,3216 100K 1% C36-37 C48 R36-37 R139 C105 C119 C205 R337 C219 R30 R100 R127 S30113925331 RE S,TF,392K,1/8W,1%,2012 392K 1% C118 C218 S35106815331 CAP,CE,MONO,COG,680PF,50V,J,2012 680P R187 R223 R243 R307 R336 R345 R23-24 R27-28 S30114875441 RES,TF,487K,1/4W,1%,3216 487K 1% C601-602 3630104500 CAP,FILM,M-POLYESTR,0.1UF,250V 0.1/250(M) R14-15 R31-32 S30121005230 RES,TF,10K,1/10W,1%,2012 10K 1% JK601 4438189810 JACK,BINDING POST,4U,4P,2/AN,C BINDING04P R42 R46 JK602-603 4438189710 JACK,SPEAKON,1U,4P,AN SPEAKON4P R22 R44 S30121275230 RES,TF,12.7K,1/10W,1%,2012 12.7K 1% R92-93 R95 R107 R116 R121 AN501 4355429008 CON ASS'Y,RB,14P,IDC2.54,DIP2.54,170MM ASS'Y-14P R130 R140 R154 JK402 JK404 4438086010 JACK,XLR(M),1U,7P,ST XLR/M R169 R201-202 JK401 JK403 4438086210 JACK,COMBO,1U,7P,ST COMBO07P R211-212 R234 SW501-503 4618499310 SW SLIDE SS84017-0403-5.3T-FN SS84017 R237 R246 R256 SW506 R271 R286 SW504-505 4628991710 SW,PUSH,VER,DPDT,NS,1U,L12.5 SPEC122SC011 R322-323 R344 BK501 6505955520 PCB BKT MX-400 BRACKET R12 S30121505230 RES TF 15K F 1/10W 2012 15K 1% C521-522 3409210071-T CAP,E,SM,SG,85C,10UF,50V,M 10/50 R41 R52 S30122005230 RES,TF,20K,1/10W,1%,2012 20K 1% C503 C508 C511 3409847041-T CAP,E,NP,NP,85C,47UF,25V,M 47/25 NP R26 S30122495331 RES,TF,24.9K,1/8W,1%,2012 24.9K 1% C516 R183 R194 S30123325441 RES,TF,33.2K,1/4W,1%,3216 33.2K 1% C505 C513 3609683120-T CAP,FILM,POLYESTR ,0.068UF,100V 0.068/100 R300-301 C507 C515 3639224188-T CAP,FILM,M-POLYESTR,0.22UF,63V 0.22/63(M) R25 R29 R96 S30123925331 RES,TF,39.2K,1/8W,1%,2012 39.2K 1% C506 C514 3639473188-T CAP,FILM,M-POLYESTR,0.047UF,63V 0.047/63(M) R135 R165 R218 U501-504 S21101087701 IC,OP AMP,NE5532A,SOP8 NE5532A R252 R281 R319 D501-504 S22400500001 DIODE,SW,0.2A,200V,BAS21,SOT-23 BAS21 R346 R505 R518 S30101037231 RES,TF,10K,1/10W,5%,2012 10K R186 R306 S30124755331 RES,TF,47.5K,1/8W,1%,2012 47.5K 1% R506 R519 S30101047231 RES,TF,100K,1/10W,5%,2012 100K R39 S30131005230 RES,TF,1K,1/10W,1%,2012 1K 1% R512 R525 S30102037231 RES,TF,20K,1/10W,5%,2012 20K R138 R168 R254 S30131625331 RES,TF,1.62K,1/8W,1%,2012 1.62K 1% R527-530 S30107507231 RES,TF,75,1/10W,5%,2012 75 R284 R507 R513 R520 S30107527230 RES TF 7.5K J 1/10W 2012 7.5K R334 S30131745331 RES,TF,1.74K,1/8W,1%,2012 1.74K 1% R526 R191 R210 R231 S30132215331 RES,TF,2.21K,1/8W,1%,2012 2.21K 1% R508 R521 S30121375230 RES,TF,13.7K,1/10W,1%,2012 13.7K 1% R309 R317 R511 R524 S30124755331 RES,TF,47.5K,1/8W,1%,2012 47.5K 1% R329-331 R509 R522 S30133655230 RES,TF,3.65K,1/10W,1%,2012 3.65K 1% R48-49 R110 R510 R523 S30134755331 RES,TF,4.75K,1/8W,1%,2012 4.75K 1% R94 R129 R245 S30133015230 RES,TF,3.01K,1/10W,1%,2012 3.01K 1% R501-504 S30135605230 RES,TF,5.6K,1/10W,1%,2012 5.6K 1% R864 R514-517 R134 R166 R251 S30134325230 RES,TF,4.32K,1/10W,1%,2012 4.32K 1% C501-502 S35101014331 CAP,CE,MONO,COG,100PF,50V,J,2012 100P R282 C509-510 R13 R21 R40 S30134755331 RES,TF,4.75K,1/8W,1%,2012 4.75K 1% C523-524 S35101045331 CAP,CE,MONO,X7R,0.1UF,50V,Z,2012 0.1U R91 R124 R126 C504 C512 S35102204339 CAP,CE,MONO,COG,22PF,50V,J,2012 22P R188-189 R203 C517-520 S35104714330 CAP,CE,MONO,COG,470PF,50V,J,2012 470P R240 R242 R303 R305 R115 R128 R190 S30135905230 RES,TF,5.9K,1/10W,1%,2012 5.9K 1% ZD401-402 2058502024 DIODE,ZN,500MW,BM,2.4V,DO-35,T 2.4BM R215 R244 R308 LD401 LD407 2300030100 LE D,RND 3.1MM,RED,DIF,1U,ST2.5 LTL-1CHE R343 S30139095331 RES,TF,9.09K,1/8W,1%,2012 9.09K 1% LD402-406 2300032100 LED,RND 3.1MM,GRN,DIF,1U,ST2.5 LT L-1CHG R11 R18 S30141005230 RES,TF,100,1/10W,1%,2012 100 1% LD408 R109 R230 R313 S30143835331 RES,TF,383,1/8W,1%,2012 383 1% VR401-402 3228065800 VR,ROT,VER,1U,BUSH,L15,10K,B,21D 10KB R316 AN402 4355429120 CON ASS'Y,RB,16P,IDC2.54,DIP2.54,480MM ASS'Y-16P R101 R117 R219 S30144755230 RES,TF,475,1/10W,1%,2012 475 1% LIM1-8 8545993340 LED LIMITER LED LIMITER R236 C402 C404 3409210023-T CAP,E,SM,SE,85C,10UF,50V,M 10/50 R17 R33 R114 S30145365331 RES,TF,536,1/8W,1%,2012 536 1% Q401-402 S20510405004 TR,SG,PNP,200MA,40V,2N3906S,SOT-23,TA 2N3906S R214 Q404-405 R325 S30146345440 RES TF 634F 1/4W 3216 634 1% Q407-408 R38 S30151005230 RES,TF,10,1/10W,1%,2012 10 1% Q403 Q406 S20560448002 TR,SG,NPN,200MA,40V,MMBT3904,SOT-23,TA 2N3904 R34 R51 S30153925441 RES,TF,39.2,1/4W,1%,3216 39.2 1% D401-404 S22400500001 DIODE,SW,0.2A,200V,BAS21,SOT-23 BAS21 R311-312 R402 R405 S30101027340 RES,TF,1K,1/8W,5%,3216 1K R314-315 R401 R403-404 S30134755331 RES,TF,4.75K,1/8W,1%,2012 4.75K 1% R131 R192 R247 S30154755230 RES,TF,47.5,1/10W,1%,2012 47.5 1% R406

LED B'D (40 051 764 10 ) Q -4 300

O UTPUT B'D (4 005 176 51 0) Q - 430 0

INPU T B'D (400 517 640 0) Q -43 00

Page 6