Hoshizaki KD-90D User Manual
INSTRUCTION MANUAL
ISSUED: OCT. 11, 2005
REVISED: JAN. 1, 2007
HOSHIZAKI
REFRIGERATED GLASS
MERCHANDISE
R
MODEL KD-90D
IMPORTANT
1. This booklet is an integral and essential part of the product and should be
handed
over to the user. Read the warnings contained in this booklet carefully
as
they give important indications regarding the safety of the installation, use
and
maintenance. Please preserve this booklet for any further consultation
that
may be necessary.
2.
This is a refrigerated glass merchandiser and should be destined only to the
use
for which it has been expressly conceived. Any other use should be
considered
improper and therefore dangerous. The manufacturer cannot be
held
responsible for eventual damage caused by improper, incorrect and
unreasonable
use.
CONTENTS PAGE
I.
GENERAL INFORMATION -------------------------------------------------------------------------- 1
1. CONSTRUCTION ---------------------------------------------------------------------------------- 1
2. FOR SAFETY AND BEST OPERATING RESULTS --------------------------------------- 2
3.
TEMPERATURE CONTROL -------------------------------------------------------------------- 2
II.
INSTALLATION AND OPERATING INSTRUCTIONS ------------------------------------------ 3
1.
UNPACKING ---------------------------------------------------------------------------------------- 3
2.
LOCATION------------------------------------------------------------------------------------------- 3
3.
ELECTRICAL CONNECTIONS ----------------------------------------------------------------- 4
4.
DRAIN CONNECTIONS -------------------------------------------------------------------------- 4
5. FINAL CHECK LIST ------------------------------------------------------------------------------- 5
6.
START UP ------------------------------------------------------------------------------------------- 5
7. SHUT DOWN --------------------------------------------------------------------------------------- 6
III.
MAINTENANCE AND CLEANING INSTRUCTIONS ------------------------------------------ 7
1. INTERIOR/EXTERIOR ---------------------------------------------------------------------------- 7
2. GROUND FAULT CIRCUIT INTERRUPTER (GFCI)---------------------------------------- 7
3. DRAIN TANK ---------------------------------------------------------------------------------------- 7
4.
DRIP PAN-------------------------------------------------------------------------------------------- 7
5.
AIR FILTER ------------------------------------------------------------------------------------------ 7
1
I. GENERAL INFORMATION
1. CONSTRUCTION
Fastener
Glass Shelf
Angle
Fr
ont Glass
Left
Side Glass
Fluorescent Lamp
Evapor
ator
Bra
cket
Drain
Hose
Sheet
Thermometer
Drip Pan
Air Filter
Rear Cover
Ground Fault Circuit
Interrupter (GFCI)
Fluorescent Lamp Switch
Thermo
stat
Pilaster
Sliding Door
Po
wer Cord
3-Prong Plug
Right Side Glass
2
2. FOR SAFETY AND BEST OPERATING RESULTS
IMPOR
TANT
Hoshizaki refrigerated glass merchandiser is not designed as a refrigerator.
Use
this merchandiser only as a display case. The following are
recommendations
for proper use.
* Select a proper installation site (see “II. INSTALLATION AND OPERATING INSTRUCTIONS”).
* Do not store foods in the merchandiser for a long period.
* Pre-cooling is required for canned or warm foods.
* Do not store raw foods when ambient temperature is above 79°F (26°C) to prevent damage
or
spoiling.
* Do not pack foods closely.
* Always wrap foods with plastic films or equivalent to prevent drying up.
* Do not open the Sliding Doors too frequently or leave them open.
* Be careful not to damage the glass. Even a small scratch can lead to a crack after a few
days
.
3. TEMPERATURE CONTROL
A ON-OFF Thermostat is equipped in the merchandiser. The inside temperature is adjustable
by setting the Thermostat to cooler or warmer position (see “II. INSTALLATION AND
OPERATING INSTRUCTIONS”). The Temperature Control Thermostat will shut off the
Condensing
Unit (Compressor and Fan Motor) when the inside temperature reaches the set
temperature, and resume operation automatically when the temperature rises.
Loading...