Honeywell RLV210A Owner's Manual

Line Voltage Electric Baseboard Heat

RLV210A

Thermostat

Owner’s Manual

Read and save these instructions.

For help please visit yourhome.honeywell.com

Application

This thermostat is designed to control an electric heating system such as a baseboard heater, a convector or a fan-forced heater.

The thermostat CANNOT be used with:

• a resistive load under 1.25 A

• a resistive load over 12.5 A (120/208/240V)

• a system driven by a contactor or a relay (inductive load)

• a central heating system

Supplied Parts

• One (1) thermostat

• Two (2) screws

• Two (2) solderless connectors for copper wires

CAUTION Fire Hazard.

Special CO/ALR solderless connectors must be used if the thermostat will be connected to aluminum wires.

ATTENTION: MERCURY RECYCLING NOTICE

NO MERCURY

This product does not contain mercury. However, this product may replace a product that contains

mercury. Mercury and products containing mercury should not be discarded in household trash.

For more information on how and where to properly recycle a thermostat containing mercury in the United States, please refer to the Thermostat Recycling Corporation at www.thermostat-recycle.org.

For mercury thermostat recycling in Canada, please refer to Switch the Stat at www.switchthestat.ca

Specifications

Temperature Setting Range: 5°C to 27°C (41°F to 80°F) Operating Temperature: 0°C to 50°C (32°F to 120°F) non-condensing Storage Temperature: -20°C to 50°C (-4°F to 120°F) Supply: 120 VAC, 50/60Hz; 208 VAC, 50/60Hz; 240 VAC, 50/60Hz Minimum Load: 1.25 A (150 W); 1.25 A (300 W) Maximum Load: 12.5 A (1500 W); 12.5 A (3000 W)

Installation

WARNING Electrical Shock Hazard.

This thermostat is a line voltage control (120–240 Volts). Do not install it if you are not completely familiar with house wiring. If handled improperly, there is risk of electric shock hazard, which may cause serious injury or death.

1. Connect the thermostat as shown on page 3.

2. Remove the thermostat faceplate cover by prying it from the top or bottom with your fingers.

3. Install the thermostat onto the electrical box using supplied screws.

4. Place the faceplate cover back.

5. Apply power to the heating system.

TWO-WIRE INSTALLATION

FOUR-WIRE INSTALLATION

M35696

Fig. 1 Thermostat wiring diagram.

FACEPLATE COVER ON

M35694

FACEPLATE COVER OFF

MOUNTING SCREW OPENINGS

M35695

TEMPERATURE SETTING KNO

Fig. 2 Faceplate cover on.

Fig. 3 Faceplate cover off.

33-00148EFS-01

1-year limited warranty

Honeywell warrants this product, excluding battery, to be free from defects in the workmanship or materials, under normal use and service, for a period of one (1) year from the date of purchase by the consumer. If at any time during the warranty period the product is determined to be defective or malfunctions, Honeywell shall repair or replace it (at Honeywell’s option).

If the product is defective, (i) return it, with a bill of sale or other dated proof of purchase, to the place from which you purchased it; or (ii) call Honeywell Customer Care at 1-800-468-1502. Customer Care will make the determination whether the product

should be returned to the following address: Honeywell Return Goods, Dock 4 MN10-3860, 1885 Douglas Dr. N., Golden Valley, MN 55422, or whether a replacement product can be sent to you.

This warranty does not cover removal or reinstallation costs. This warranty shall not apply if it is shown by Honeywell that the defect or malfunction was caused by damage which occurred while the product was in the possession of a consumer.

Honeywell’s sole responsibility shall be to repair or replace the product within the terms stated above. HONEYWELL SHALL NOT BE LIABLE FOR ANY LOSS OR DAMAGE OF ANY KIND, INCLUDING ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES RESULTING, DIRECTLY OR INDIRECTLY, FROM ANY BREACH OF ANY WARRANTY, EXPRESS OR IMPLIED, OR ANY OTHER FAILURE OF THIS PRODUCT. Some states do not allow the exclusion or limitation of incidental or consequential damages, so this limitation may not apply to you.

THIS WARRANTY IS THE ONLY EXPRESS WARRANTY HONEYWELL MAKES ON THIS PRODUCT. THE DURATION OF ANY IMPLIED WARRANTIES, INCLUDING THE WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, IS HEREBY LIMITED TO THE ONE-YEAR DURATION OF THIS WARRANTY.

Some states do not allow limitations on how long an implied warranty lasts, so the above limitation may not apply to you. This warranty gives you specific legal rights, and you may have other rights which vary from state to state.

If you have any questions concerning this warranty, please write Honeywell Customer Relations, 1985 Douglas Dr, Golden Valley, MN 55422 or call 1-800-468-1502.

The product is certiﬁed by CSA under the following standards:

• CAN/CSA-C22.2 No. 24 Temperature-Indicating and Regulating Equipment.

• UL 873 Temperature-Indicating and Regulating Equipment.

• CSA C828-06, section 4.3 Performance requirements for thermostats used

with individual room electric space heating devices.

Automation and Control Solutions

Honeywell International Inc. 1985 Douglas Drive North Golden Valley, MN 55422 yourhome.honeywell.com

+ 8 hidden pages