Page 1
107408, 120650, 197007
Heat Conductive Compound
MATERIAL SAFETY DA TA SHEET (MSDS)
FOR HEAT-CONDUCTIVE COMPOUND
T
R
A
D
E
L
I
N
E
1
0
7
4
0
8
H
e
a
t
C
o
n
d
e
u
v
i
c
t
C
o
m
p
o
u
n
d
D
i
r
e
c
t
i
o
n
s
C
o
m
p
l
e
t
e
l
y
w
i
t
h
l
i
b
e
r
a
l
i
n
t
o
w
e
l
l
.
S
W
A
R
N
I
N
G
D
o
n
o
t
u
s
e
H
o
m
e
a
n
d
B
u
9
3
-
3
1
2
A
-
0
0
1
-
O
b
l
u
b
g
n
i
s
n
c
e
o
s
a
e
t
r
t
e
u
t
m
a
r
p
e
g
n
i
t
r
e
s
n
i
e
r
o
f
f
i
l
m
e
b
o
d
f
n
c
u
o
o
m
p
.
y
l
e
t
e
e
l
a
p
t
m
b
o
u
c
l
b
l
l
i
e
n
w
!
a
b
o
v
e
.
F
3
°
0
0
.
c
n
I
l
l
e
w
y
e
n
o
H
i
l
d
i
n
g
C
o
n
t
r
o
l
,
s
i
l
o
p
a
e
n
n
i
M
0
0
/
©
1
-
9
5
2
2
4
5
5
a
t
o
s
e
n
n
i
M
d
n
u
o
p
m
Co
e
0
v
i
t
5
c
u
6
d
0
n
o
2
C
t
1
a
e
6
8
5
7
2
4
6
3
7
0
0
H
M7700
SERVICE DATA
Copyright © 1999 Honeywell Inc. • All Rights Reserved
69-0955-1
Page 2
107408, 120650, 197007 HEAT CONDUCTIVE COMPOUND
MATERIAL SAFETY DA TA SHEET (MSDS)
————————————————————————————————————————————————————————————————————————–
————————————————————————————————————————————————————————————————————————–
PRODUCT NAME: Heat Conductive Compound
Synonyms: MS1699
PRODUCT USE: Heat conductive material used to enhance contact and heat
transfer in temperature sensor applications.
MANUFACTURER: Honeywell Inc., 1985 Douglas Drive North, Minneapolis, MN
55422
DATE RELEASED: April 16, 1999
MSDS ID: MBH039
NFPA Ratings:
Health 0
Flammability 1
Reactivity 0
Personal Protection B
————————————————————————————————————————————————————————————————————————–
————————————————————————————————————————————————————————————————————————–
Ingredients CAS No. Percent PEL TLV
No. 2 Lithium Complex Grease (70%):
Mineral Oil 64742-65-0 35-50 5 mg/m3 5 mg/m3
Mineral Oil 64742-62-7 20-25 5 mg/m3 5 mg/m3
Lithium Hydrostearate/Sebacate Complex
Zinc Alkyldithiophosphate
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
SECTION 2. COMPOSITION, INFORMATION ON INGREDIENTS
68815-49-6 4-9 — —
68649-42-3 0-2 — —
Aluminum Paste (30%):
Aluminum, as Al 7429-90-5 20-25 15 mg/m3 10 mg/m3
Aliphatic Petroleum
Distillates 8052-41-3 10-15 2900 mg/m3 525 mg/m3
Stearic Acid 57-11-4 1-2 — —
Aromatic Petroleum
Distillates 64742-95-6 1-2 5 mg/m3 5 mg/m3
Additional Information: Part No. 120650 (0.5 oz tube); Part No. 107408 (4
oz can); Part No. 197007 (5 gal container). May also contain minute
amounts of lithium and molybdenum lubricant compounds.
————————————————————————————————————————————————————————————————————————–
SECTION 3. HAZARD IDENTIFICATION
————————————————————————————————————————————————————————————————————————–
ACUTE HEALTH EFFECTS:
Skin: Excessive contact may cause skin irritation and dermatitis.
Eye: Direct contact with eye will cause irritation.
Inhalation: No adverse effects are expected.
Ingestion: Ingestion of product may cause nausea, vomiting and diarrhea.
CHRONIC HEALTH EFFECTS: Existing skin rash or dermatitis may be aggravated
by repeated contact.
69-0955—1
2
Page 3
107408, 120650, 197007 HEAT CONDUCTIVE COMPOUND
OSHA HAZARD CLASSIFICATIONS: None.
CARCINOGENICITY: Not considered to be a carcinogen by either OSHA, NTP,
IARC, or ACGIH.
TARGET ORGANS: None known.
————————————————————————————————————————————————————————————————————————–
SECTION 4. FIRST AID MEASURES
————————————————————————————————————————————————————————————————————————–
EYE CONTACT: Flush eyes with water for 15 minutes. Remove any contact
lenses and continue to flush. Obtain medical attention if irritation
develops and persists.
SKIN CONTACT: Remove excess with cloth or paper. Wash thoroughly with mild
soap and water. Obtain medical attention if irritation develops and persists.
INGESTION: Contact physician or local poison control center immediately.
INHALATION: Remove patient to fresh air and obtain medical attention if
symptoms develop.
————————————————————————————————————————————————————————————————————————–
SECTION 5. FIRE FIGHTING MEASURES
————————————————————————————————————————————————————————————————————————–
FLASH POINT: >383 F (COC) Will burn if exposed to flame.
EXTINGUISHING MEDIA: Carbon dioxide, dry chemical or foam.
SPECIAL FIRE FIGHTING PROCEDURES: None.
EXPLOSION HAZARDS: None. Aluminum powder can react with water to release
flammable hydrogen gas. In the form of this product, this reaction is not
expected.
————————————————————————————————————————————————————————————————————————–
SECTION 6. ACCIDENTAL RELEASE MEASURES
————————————————————————————————————————————————————————————————————————–
Scrape up and dispose as solid waste in accordance with state and federal
regulations.
————————————————————————————————————————————————————————————————————————–
SECTION 7. HANDLING AND STORAGE
————————————————————————————————————————————————————————————————————————–
Store in dry place. Keep container closed when not in use.
————————————————————————————————————————————————————————————————————————–
SECTION 8. EXPOSURE CONTROLS AND PERSONAL PROTECTION
————————————————————————————————————————————————————————————————————————–
VENTILATION: No special ventilation is required when working with this
product.
RESPIRATORY PROTECTION: None.
EYE PROTECTION: Not normally required. However, use chemical safety
goggles or faceshield if potential for eye contact exists, especially if
material is heated.
HAND/CLOTHING PROTECTION: Not normally required. Protective gloves and
clothing are recommended, as material is difficult to remove from skin and
clothing.
OTHER PROTECTIVE EQUIPMENT: None.
————————————————————————————————————————————————————————————————————————–
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
————————————————————————————————————————————————————————————————————————–
APPEARANCE/ODOR: Aluminum color, semi-solid material, pleasant odor.
SOLUBLE IN WATER: Negligible.
SPECIFIC GRAVITY: 0.86.
3
69-0955—1
Page 4
107408, 120650, 197007 HEAT CONDUCTIVE COMPOUND
—————————————————————————————————————————————————————————————————————————
SECTION 10. STABILITY AND REACTIVITY
————————————————————————————————————————————————————————————————————————–
STABILITY: Stable.
REACTIVITY: Hazardous polymerization will not occur.
INCOMPATIBILITIES: Strong oxidizing agents and halogens.
HAZARDOUS DECOMPOSITION PRODUCTS: Carbon dioxide, carbon monoxide.
————————————————————————————————————————————————————————————————————————–
SECTION 11. TOXICOLOGY INFORMATION
————————————————————————————————————————————————————————————————————————–
No data available.
————————————————————————————————————————————————————————————————————————–
SECTION 12. ECOLOGICAL INFORMATION
————————————————————————————————————————————————————————————————————————–
CHEMICAL FATE INFORMATION: Hydrocarbon components will biodegrade in soil;
relatively persistent in water.
————————————————————————————————————————————————————————————————————————–
SECTION 13. DISPOSAL CONSIDERATION
————————————————————————————————————————————————————————————————————————–
Dispose of as solid waste in accordance with Local, State and Federal
regulations.
————————————————————————————————————————————————————————————————————————–
SECTION 14. TRANSPORTATION INFORMATION
————————————————————————————————————————————————————————————————————————–
DOT CLASSIFICATION: Not classified as hazardous.
————————————————————————————————————————————————————————————————————————–
SECTION 15. REGULATORY INFORMATION
————————————————————————————————————————————————————————————————————————–
SARA TITLE III SUPPLIER NOTIFICATION: Include in Section 311/312 inventory
reports if amounts exceed 10,000 pounds. Aluminum compounds are subject
to the reporting requirements under Section 313 of Emergency Planning and
Community Right-to-Know Act of 1986 (40 CFR 372). Ingredients listed in
TSCA Inventory.
————————————————————————————————————————————————————————————————————————–
SECTION 16. OTHER INFORMATION
————————————————————————————————————————————————————————————————————————–
This information is furnished without warranty, expressed or implied,
except that it is accurate to the best of our knowledge.
PREPARED BY: PROSAR, 1295 Bandana Blvd, Suite 335, St Paul, MN 55108
(651-917-6100)
Home and Building Control
Honeywell Inc.
Honeywell Plaza
P.O. Box 524
Minneapolis, MN 55408-0524
69-0955—1
69-0955—1 J.S. Rev. 5-99
Home and Building Control
Honeywell Limited-Honeywell Limitée
155 Gordon Baker Road
North York, Ontario
M2H 3N7
Printed in U.S.A. on recycled
paper containing at least 10%
post-consumer paper fibers.
4
www.honeywell.com
Loading...