Henny Penny OE-301 Parts List
Henny Penny Model OE/OG 301/302/303
SECTION 7. PARTS INFORMATION
7-1. INTRODUCTION This section identifies and lists the replaceable parts of the Henny
Penny 3-Well Open Fryer.
7-2. GENUINE PARTS Use only genuine Henny Penny parts in your unit. Using a part of
lesser quality or substitute design may result in unit damage or
personal injury.
7-3. WHEN ORDERING PARTS Once the part you want to order has been found in the Part List,
write down the following information:
1. From the exploded drawing and Parts List (Sample)
Item Number 8
Part Number 43768
Description On/Off Switch
2. From the data plate (Sample)
Product Number 01400
Serial Number 00100
Voltage 208
7-4. PRICES Your distributor has a price parts list and will be glad to inform you
of the cost of yours parts order.
7-5. DELIVERY Commonly replaced items are stocked by your independent Henny
Penny distributor and will be sent out when your order is received.
Other parts will be ordered by the distributor from Henny Penny
Corporation. Normally, these will be sent to your distributor within
three working days.
7-6. WARRANTY All replacement parts (except lamps and fuses) are covered under
warranty for 90 days against manufacturing defects and workmanship. If damage occurs during shipping, notify the carrier at once so
that a claim may be properly filed. Refer to the warranty in this
manual for other rights and limitations.
7-7. RECOMMENDED
SPARE PARTS FOR
DISTRIBUTORS
Recommended replacement parts, stocked by your distributor, are
indicated with
√ √
√ in the parts lists. Please use care when ordering
√ √
recommended parts, because all voltages and variations are
marked. Distributors should order parts based upon common
voltages and equipment sold in their territory.
206 7-1
uaQti~ per unit
34429 Menu Card - Wendy's 6 4 2
56088 Menu Card - Blank 6 4 2
56089 Menu Card - GM 6 4 2
√√√√√√√
√ recommended parts
302
33309
33308
44784
43768
40500
30978
28979
Control Panel Assembly Complete
(Gas Models) - 120V
Control Panel Assembly Complete
(Electric Models) - 208/24OV
Control Panel Assembly Complete
(Gas Models) - 240V
Power (ON/OFF) Switch
Replaceable Beeper
Transformer - 12OV-12V (Gas)
Transformer - 208/24OV- 12V (Electric)
2
2
2
2
2
2
2
.
.
Electrical Components (Electric Models)
√
√√√
√
√
√
√√√√√
√ recommended parts
Thermal Sensor (Probe)
High Temperature Limit Control
Thermocouple Pot Fitting
Fuse Holder Assy. (5 amp)
Fuse Holder Assy. (15 amp)
Fuse Holder Assy. - CE
Contactor - Mercury
8
9
30094
19682
10 19405
11
12
17216
33376*
Compression Fitting
Contactor Bracket
Contactor
High Limit Bracket
Insulation-Pot Front
13 29901* Cap.-Resistor Assy.-Primary Contactor
14
15
16
51065”
33498” Cap.-Resistor A&Y.-Heat Contactor
36012*
EMC Filter Board Assy. (CE)
Cap.-Resistor Assy.-Pump Motor
*not shown
3 2
3 2
3 2
3 2
3 2
3 2
1 1
3 2
1 1
1
1
1
1
1
1
1
1
1
Limit control.
Henny Penny Model OE/OG 301/302/303
Thermal Sensor and High Temperature Limit Control (Gas Models)
Item Part Quantity per unit
No. Number Description 303 302 301
7- 3 Thermal Sensor and High Temperature Limit
Control (Gas Models)
√√
√ l 16738 High Temperature Limit Control 3 2 1
√√
√√
√ 1 14267 High Temp. Limit Control Kit- CE - Electronic 3 2 1
√√
√√
√ 1 14282 High Temp. Limit Control Kit - CE - Electro-mech. 3 2 1
√√
2 33068 Terminal Block 3 2 1
3 SC02-018 Screw, Thread Forming #8 6 4 2
4 NS02-001 Nut, #10-32 Hex Keps 3 2 1
6 33132 Control Shroud Access Plate 3 2 1
7 FP01-024 Bushing - 3/8-1/8” 3 2 1
8 FP01-099 Pipe Plug 3 2 1
9 33094 Compression Fitting 3 2 1
5 17216 High Limit Control Bracket 3 2 1
√√
√ 10 55168 Thermal Sensor - 6” 3 2 1
√√
√√
√ 10 55167 Thermal Sensor - 3” 3 2 1
√√
√√
√ 10 34822 Thermal Sensor - 6” - CE 3 2 1
√√
11 51071 Thermocouple Pot Fitting 3 2 1
12 34813 Capillary Bulb Mounting Assy. 3 2 1
12 50698 Clamp-Rear, Capillary Bulb - CE (not shown) 3 2 1
12 50699 Clamp-Front, Capillary Bulb - CE (not shown) 3 2 1
13 44371 Seal Weld Assy. (not shown) 2 2 2
√√
√ 14 36012 Capacitor - Resistor Assy. (not shown) 7 5 3
√√
15 33304 Insulation - Front Cover 1 1 1
√ √
√ recommended parts
√ √
206 7-7
Figure 7-4. Firebox and Flue Assembly (Gas Model)
Part
Number
33166
16406
33164
33162
55328
Description
Firebox and Flue Assembly (Gas Models)
Firebox Front Cover Assy.
Heat Shield
Outer Firebox Weld Assy.
Flue Assy.
Firebox Assv.
- CE - 06-301
Quantity per unit
303
302
301
re 7-5.
1
Outer Front Firebox Assy. (Gas Model)
Outer Front Weld Assy.
Insulation-Front Firebox
Insulation-Top Front
w
Y
Part
Number
33348
33046
55327
16503
16502
33346
33456
55326
Description
Firebox Insulation Assembly (Gas Model)
Insulation-Top/Sides
Insulation-Firebox Sides
Insulation-Firebox sides - CE - OG-301
Insulation-Bottom Panel
Insulation-Back Panel
Insulation- 1 in.-Top/Rear
Insulation-3/4 in.-Top/Rear
Insulation-Firebox to Frame - CE (not shown)
Quantity per unit
302 301
Loading...