Henny Penny HCN-5 Operation Manual
Henny Penny
Heated Holding Cabinet
Model HCN-5
Model HHC-136
OPERATOR’S MANUAL
REGISTER W ARRANTY ONLINE AT WWW .HENNYPENNY.COM
Model HHC-136/Model HCN-5
LIMITED WARRANTY FOR HENNY PENNY
MODEL HHC-136
Subject to the following conditions, Henny Penny Corporation makes the following limited warranties to the original
purchaser only for Henny Penny appliances and replacement parts:
NEW EQUIPMENT: Any part of a new appliance, except baskets, lamps, and fuses, which proves to be defective in
material or workmanship within two (2) years from date of original installation, will be repaired or replaced without
charge F .O.B. factory , Eaton, Ohio, or F .O.B. authorized distributor . Baskets will be repaired or replaced for ninety (90)
days from date of original installation. Lamps and fuses are not covered under this Limited W arranty. To validate this
warranty, the registration card for the appliance must be mailed to Henny Penny within ten (10) days after installation.
FILTER SYSTEM: Failure of any parts within a fryer filter system caused by the use of the non-OEM filters or
other unapproved filters is not covered under this Limited Warranty.
REPLACEMENT PARTS: Any appliance replacement part, except lamps and fuses, which proves to be defective in
material or workmanship within ninety (90) days from date of original installation will be repaired or replaced without
charge F .O.B. factory , Eaton, Ohio, or F .O.B. authorized distributor .
The warranty for new equipment covers the repair or replacement of the defective part and includes labor charges and
maximum mileage charges of 200 miles round trip for a period of one (1) year from the date of original installation.
The warranty for replacement parts covers only the repair or replacement of the defective part and does not include any
labor charges for the removal and installation of any parts, travel, or other expenses incidental to the repair or replacement of
a part.
EXTENDED FRYPOT WARRANTY: Henny Penny will replace any frypot that fails due to manufacturing or workmanship
issues for a period of up to seven (7) years from date of manufacture. This warranty shall not cover any frypot that fails due to
any misuse or abuse, such as heating of the frypot without shortening.
0 TO 3 YEARS: During this time, any frypot that fails due to manufacturing or workmanship issues will
be replaced at no charge for parts, labor, or freight. Henny Penny will either install a new frypot at no cost or
provide a new or reconditioned replacement fryer at no cost.
3 TO 7 YEARS: During this time, any frypot that fails due to manufacturing or workmanship issues will
be replaced at no charge for the frypot only . Any freight charges and labor costs to install the new frypot as
well as the cost of any other parts replaced, such as insulation, thermal sensors, high limits, fittings, and
hardware, will be the responsibility of the owner.
Any claim must be presented to either Henny Penny or the distributor from whom the appliance was purchased. No
allowance will be granted for repairs made by anyone else without Henny Penny’s written consent. If damage occurs during
shipping, notify the sender at once so that a claim may be filed.
THE ABOVE LIMITED WARRANTY SETS FOR TH THE SOLE REMEDY AGAINST HENNY PENNY FOR ANY BREACH
OF W ARRANTY OR OTHER TERM. BUYER AGREES THA T NO OTHER REMEDY (INCLUDING CLAIMS FOR ANY INCIDENT AL OR CONSEQUENTIAL DAMAGES) SHALL BE AV AILABLE.
The above limited warranty does not apply (a) to damage resulting from accident, alteration, misuse, or abuse; (b) if the
equipment’s serial number is removed or defaced; or (c) for lamps and fuses. THE ABOVE LIMITED W ARRANTY IS EXPRESSL Y IN LIEU OF ALL OTHER W ARRANTIES, EXPRESS OR IMPLIED, INCLUDING MERCHANT ABILITY AND FITNESS, AND ALL OTHER W ARRANTIES ARE EXCLUDED. HENNY PENNY NEITHER ASSUMES NOR AUTHORIZES ANY
PERSON TO ASSUME FOR IT ANY OTHER OBLIGA TION OR LIABILITY.
Revised 01/01/07
FM05-040-D
Revised 3-4-11
Model HHC-136/Model HCN-5
LIMITED WARRANTY FOR HENNY PENNY
MODEL HCN-5
Subject to the following conditions, Henny Penny Corporation makes the following limited warranties to the original purchaser only for Henny Penny appliances and replacement parts:
NEW EQUIPMENT: Any part of a new appliance, except baskets, lamps, and fuses, which proves to be
defective in material or workmanship within one (1) year from date of original installation, will be repaired or
replaced without charge F .O.B. factory , Eaton, Ohio, or F.O.B. authorized distributor. Baskets will be
repaired or replaced for ninety (90) days from date of original installation. Lamps and fuses are not covered
under this Limited Warranty. To validate this warranty , the registration card for the appliance must be
mailed to Henny Penny within ten (10) days after installation.
REPLACEMENT PARTS: Any appliance replacement part, except lamps and fuses, which proves to be
defective in material or workmanship within ninety (90) days from date of original installation will be
repaired or replaced without charge F .O.B. factory , Eaton, Ohio, or F .O.B. authorized distributor .
The warranty for new equipment covers the repair or replacement of the defective part and includes labor charges and
maximum mileage charges of 200 miles round trip for a period of one (90) days from the date of original installation.
The warranty for replacement parts covers only the repair or replacement of the defective part and does not include
any labor charges for the removal and installation of any parts, travel, or other expenses incidental to the repair or replacement of a part.
Any claim must be presented to either Henny Penny or the distributor from whom the appliance was purchased. No
allowance will be granted for repairs made by anyone else without Henny Penny’s written consent. If damage occurs during
shipping, notify the sender at once so that a claim may be filed.
THE ABOVE LIMITED W ARRANTY SETS FOR TH THE SOLE REMEDY AGAINST HENNY PENNY FOR ANY
BREACH OF W ARRANTY OR OTHER TERM. BUYER AGREES THA T NO OTHER REMEDY (INCLUDING CLAIMS FOR
ANY INCIDENT AL OR CONSEQUENTIAL DAMAGES) SHALL BE A VAILABLE.
The above limited warranty does not apply (a) to damage resulting from accident, alteration, misuse, or abuse; (b) if
the equipment’s serial number is removed or defaced; or (c) for lamps and fuses. THE ABOVE LIMITED WARRANTY IS
EXPRESSL Y IN LIEU OF ALL OTHER WARRANTIES, EXPRESS OR IMPLIED, INCLUDING MERCHANT ABILITY AND
FITNESS, AND ALL OTHER WARRANTIES ARE EXCLUDED. HENNY PENNY NEITHER ASSUMES NOR AUTHORIZES
ANY PERSON T O ASSUME FOR IT ANY OTHER OBLIGATION OR LIABILITY .
Revised 5/13/10
Model HHC-136/Model HCN-5
TABLE OF CONTENTS
Section Page
Section 1. INTRODUCTION .................................................................................................... 1-1
1-1. Heated Holding Cabinet.................................................................................... 1-1
1-2. Features ........................................................................................................... 1-1
1-3. Proper Care ..................................................................................................... 1-2
1-4. Assistance ........................................................................................................ 1-2
1-5. Safety............................................................................................................... 1-2
Section 2. INST ALLATION....................................................................................................... 2-1
2-1. Introduction ...................................................................................................... 2-1
2-2. Unpacking ........................................................................................................ 2-1
2-3. Location ........................................................................................................... 2-2
2-4. Electrical Connection ........................................................................................ 2-2
2-5. Cabinet Dimensions .......................................................................................... 2-3
Section 3. OPERA TION ............................................................................................................ 3-1
3-1. Introduction ...................................................................................................... 3-1
3-2. Operating Controls and Components ................................................................ 3-1
3-3. Start-Up........................................................................................................... 3-3
3-4. Operation with Product..................................................................................... 3-4
3-5. Cleaning Procedures ......................................................................................... 3-4
Section 4. TROUBLESHOOTING ............................................................................................ 4-1
4-1. Troubleshooting Guide ...................................................................................... 4-1
GLOSSARY.............................................................................................................. G-1
Distributor List
i 506
SECTION 1. INTRODUCTION
Model HHC-136/Model HCN-5
1-1. HEA TED HOLDING
CABINET
1-2. FEA TURES
The Henny Penny Heated Holding Cabinet is a basic unit of food
processing equipment designed to hold hot foods at proper
temperature in commercial food operations. This cabinet keeps
hot foods humid while maintaining temperature.
As of August 16, 2005, the W aste Electrical and Electronic Equipment
directive went into effect for the European Union. Our products have
been evaluated to the WEEE directive. W e have also reviewed our
products to determine if they comply with the Restriction of Hazardous
Substances directive (RoHS) and have redesigned our products as
needed in order to comply . T o continue compliance with these directives, this unit must not be disposed as unsorted municipal waste. For
proper disposal, please contact your nearest Henny Penny distributor.
• Easily cleaned
• Adjustable, thermostatically controlled heat
• Lift-off doors
• Easy access to electrical components
• Moist heat
• Stainless steel construction
• Full perimeter magnetic door seals
• Lift out tray racks
• Glass door on one side and flip-up doors on control side
207 1-1
Loading...