Heatmaster H-SS-24NG, HM2-SS-24NG, DG-SS-18NG, DG-SS-24NG, DG-SS-30NG Installation Instructions Manual
...
IM-117 Outdoor Burner/Hearth Kits • 12/08
1
Models:
DG-SS-18/24/30NG
AGL-SS-18/24 NG
H-SS-24NG
HM2-SS-24NG
Installation
Instructions
Check with your local building code agency before you begin installation to ensure compliance with local codes, including
the need for permits and follow-up inspections. If you encounter any problems regarding code approvals, or if you need clarification of any of the instructions contained here, contact the Technical Services Dept., 919.331.0078 or 919.331.0079.
DO NOT DISCARD THIS MANUAL
CAUTION
• Im porta nt operating
a n d m a i n t e n a n c e
instructions included.
•
Leave this manual with
party responsible for
use and operation.
•
Rea d , understa n d
an d fo ll ow th es e
instructions for safe
i ns ta ll at io n a n d
operation.
D
O
N
OT
D
I
S
C
A
R
D
If the information in these instructions is not followed exactly, a
fire may result causing property
damage, personal injury, or death.
• Do not store or use gasoline or other flammable vapors and liquids in the vicinity of
this or any other appliance.
• What to do if you smell gas:
- Do not try to light any appliance.
- Do not touch any electrical switch. Do not
use any phone in your building.
- Immediately call your gas supplier from
a neighbor’s phone. Follow the gas
supplier’s instructions.
- If you cannot reach your gas supplier, call
the fire department.
• Installation and service must be performed
by a qualified installer, service agency, or
the gas supplier.
WARNING
HOT! DO NOT TOUCH.
SEVERE BURNS MAY RESULT.
CLOTHING IGNITION MAY RESULT.
WARNING
• Keep children away.
• CAREFULLY SUPERVISE children in same room as
appliance.
• Alert chil d r e n and adult s to haza r d s of hi gh
temperatures.
• Keep cl o t h i n g , fu r n i t u r e , dr a p e r i es an d other
combustibles away.
Glass and other surfaces are hot during
operation and cool down.
Installation and service of this
appliance should be performed by
qualified personnel.It is suggested
NFI certified or factory-trained
professionals, or techni c i a n s
supervised by an
NFI certified professional.
In the Commonwealth of Massachusetts:
• This appliance must be installed by a licensed plumber
or gas fitter.
• The chimney flue damper, when used with gas logs, will
be welded open or completely removed.
• A CO detector shall be installed in the room where the
appliance is installed.
HEATMASTER, LLC
AMERICAN GAS LOG
Outdoor Burner/Hearth Kits
For use use with Natural gas only
IM-117 Outdoor Burner/Hearth Kits • 12/08
2
Read this manual before installing or operating this appliance.
Please retain this owner’s manual for future reference.
Congratulations on selecting a Heatmaster/American Gas
Log,LLC.,outdoor gas burner system—an elegant and clean
alternative to burning wood. The gas log set you have selected is designed to provide the utmost in safety, reliability,
and efficiency.
As the owner of this new gas log set, you’ll want to read
and carefully follow all of the instructions contained in this
owner’s manual. Pay special attention to all cautions and
warnings.
This owner’s manual should be retained for future reference.
We suggest you keep it with your other important documents
and product manuals.
The information contained in this owner’s manual, unless
noted otherwise, applies to all models and gas control systems.
Your new gas log set will give you years of durable use and
trouble-free enjoyment.
Listing Label Information/Location
The model information regarding your specific gas log set can be found on the rating plate.
Congratulations
Homeowner Reference Information
Model Name: Date purchased/installed:
Serial Number: Location on appliance:
Dealership purchased from: Dealer phone:
Notes:
We recommend that you record the following pertinent
information about your gas log set:
Heatmaster/American Gas Log
IM-117 Outdoor Burner/Hearth Kits • 12/08
3
1
Listing and Code Approvals
A. Appliance Certification
The Gas Log Hearth Kits have been tested and listed for
outdoor use in the U.S. in accordance with ANSI Z21.84-2003
(Gas Log Set). They have been listed by OMNI Test Labs for
installation and operation in the United States and Canada
as described in these Installation and Operating Instructions.
All components are UL, OMNI or CSA safety certified.
Check with your local building code agency prior to installing
this appliance to ensure compliance with local codes,
including the need for permits and follow-up inspections. In
the absence of local codes, comply with the National Fuel
Gas Code, ANSI Z223.1-Latest Edition in the U.S. If any
assistance is required during installation, please contact
your local dealer or Technicial Services Department at
919.331.0078 or 919.331.0079.
B. Table 1
Improper installation, adjustment, alteration, service
or maintenance can cause injury or property damage.
Refer to the owner’s information manual provided with
this appliance. For assistance or additional information
consult a qualified installer, service agency or the gas
supplier.
WARNING
Fire Risk
Exhaust Fumes Risk
• Do NOT use this appliance as a “vent-free
heater.
The flue must be permanently open. Refer
to Table 1.
WARNING
Product DG-SS-18
DG-SS
AGLSS
H-SS
24
DG-SS-30 HM2-SS 24
Inlet BTU
Nat. 62,000 69,000 83,000 34,500
Max. Inlet Pressure
IN. WC / KPa
Nat. 10.0 10.0
10.0
10.0
Min. Inlet Pressure IN.
WC / KPa
Nat. 3.5 3.5
3.5
3.5
Orifice Size
In. / mm
Nat. (#26) (#26) (#16) (#41)
Minimum Fireplace
Opening Size
In. / cm
Front 28 34 40 25
Rear 16 18 24
Depth 14 16 16 14
Height 16 18 20 15
IM-117 Outdoor Burner/Hearth Kits • 12/08
4
2
Getting Started
A. Size of Firebox
See Table 1 in Section 1.B.
Asphyxiation Risk
This appliance produces carbon monoxide
(CO).
• The free opening areas (in square inches)
of the chimney damper as shown in the
tables must be met.
• User must make sure damper is locked
open.
• The installer is responsible to ensure
proper ventilation of flue gases before
appliance is used.
Fire needs to draft properly fo r sa f e
operation.
WARNING
B. Tools and Supplies Needed
Tools and supplies normally required for installation:
Pliers
Phillips screwdriver
Tape measure
Crescent wrenches
Gas shutoff valve
Non-corrosive leak check solution
3/4 in. wrench, 7/16 in. wrench
Sharp Edges
• Wear protective gloves
and safety glasses during
installation.
CAUTION
C. Inspect the Appliance and Components
• Remove the contents from the carton. Attached to the
burner are tags identifying the manufacturer name, serial
number, model number (including gas log size), BTU
ratings, gas type, etc.
• Review the attached tags before proceeding. Ensure
that all minimum fireplace dimension requirements are
achieved using Table 1 in Section 1.B. See Figure 2.1.
Ensure the gas type provided in the fireplace coincide
with the gas type marked on the tag.
Figure 2.1 Measure Firebox
Heatmas t e r /Ame r i c a n Gas Lo g, LLC
disclaims any responsibility for, and the
warranty will be voided by, the following
• Installation and use of any damaged appliance or
vent system component.
• Modification of the appliance or vent system.
• Installation other than as instructed by Heatmaster/
American Gas Log, LLC.
• Improper positioning of the gas logs or the glass
door.
• Installation and/or use of any component part not
approved by Heatmaster/American Gas Log, LLC.
Any such action may cause a fire hazard.
WARNING
IM-117 Outdoor Burner/Hearth Kits • 12/08
5
D. Components of the Gas Hearth Kit
The Burner/Hearth Kit consists of the following:
• Burner/Pan Assembly
• Grate Assembly
• Lava Rock
• Damper Stop
• Aluminum Tubing Assembly
• Brass Elbow Connector
• Brass Orifice & Cap
• Log Set (Logs may be sold separately)
Keep appliance dry.
• Mold or r u s t may cau s e
odors.
• Water may damage controls.
WARNING
Do NOT use this appliance if any part has been under
water. Immediately call a qualified service technician
to inspect the appliance and to replace any part of the
control system and any gas control which has been
under water.
WARNING
Inspect appliance and components for
damage. Damaged parts may impair safe
operation.
• Do NOT install damaged components.
• Do NOT install incomplete components.
• Do NOT install substitute components.
Report damaged parts to dealer.
WARNING
Shock Risk
Fire Risk
Use ONLY optional accessories approved
for this appliance.
• Using non-listed accessories voids
warranty.
• Using non-listed accessories may result
in a safety hazard.
• Only Heatmaster/American Gas Log,
LLC approved accessories may be used
safely.
WARNING
Loading...