Harbor Freight Tools 9583 Owner's Manual

WARNING SYMBOLS AND DEFINITIONS

This is the safety alert symbol. It is used to alert you to potential

personal injury hazards. Obey all safety messages that

follow this symbol to avoid possible injury or death.

Indicates a hazardous situation which, if not avoided,

will result in death or serious injury.

Indicates a hazardous situation which, if not avoided,

could result in death or serious injury.

Indicates a hazardous situation which, if not avoided,

could result in minor or moderate injury.

Addresses practices not related to personal injury.

IMPORTANT SAFETY INFORMATION

Read all safety warnings and instructions.

Failure to follow the warnings and instructions may result in serious injury.

Work Area

1. Keep your work area clean and well lit.
Cluttered dark areas invite accidents.

2. The work area should have adequate
drainage to reduce the possibility of
a fall due to slippery surfaces.

3. Keep bystanders, children, and visitors

away while operating the Sprayer.

Distractions can cause you to lose control.

Electrical Safety

1. Connect to breaker/fuse protected,
switch-controlled circuit if permanently
installing pump. Do not use with longer
or thinner wires than those provided.

2. Do not connect when wet or while
standing on damp/wet ground.

3. Make sure the Harness is disconnected
from the Pump Wiring before connecting
to the 12VDC power supply.

4. Connect to 12VDC power supply only.
Different voltage may cause motor/wiring
damage, fire, or electric shock.

Page 2 For technical questions, please call 1-800-444-3353. Item 9583

Personal Safety

1. Follow all guidelines regarding

chemicals sprayed, including MSDS
instructions and EPA regulations.

2. If battery acid contacts skin or clothing,

wash immediately with soap and water. If
acid enters eye, immediately flood eye with
running cold water for a minimum of 10 minutes
and get medical attention immediately.

3. Stay alert. Watch what you are doing and use

common sense when operating the Sprayer.
Do not use the Sprayer while tired or under
the influence of drugs, alcohol, or medication.

A moment of inattention while operating the
Sprayer may result in serious personal injury.

Use

1. Use only for water or water-based fertilizers,

herbicides, pesticides and sealers. Do not use
to spray combustible or corrosive chemicals.

2. Do not point the Sprayer at yourself,
other people or animals.

3. Industrial applications must follow
OSHA requirements.

4. Make sure the liquid used in the
Sprayer is not dirty or sandy.

5. This product is not a toy. Do not allow
children to play with or near this item.

6. Use as intended only.

7. Inspect before every use; do not use
if parts are loose or damaged.

4. Dress properly. Do not wear loose
clothing or jewelry. Contain long hair.

5. Do not overreach. Keep proper

footing and balance at all times.

Proper footing and balance enable better
control of the tool in unexpected situations.

6. Always wear eye protection.

Wear ANSI-approved safety goggles while
connecting battery and during operation.

8. Maintain product labels and nameplates.
These carry important safety information.
If unreadable or missing, contact
Harbor Freight Tools for a replacement.

9. WARNING: The brass components of this
product contain lead, a chemical known to
the State of California to cause birth defects
(or other reproductive harm). (California
Health & Safety code § 25249.5, et seq.)

10. The warnings and cautions discussed in this
manual cannot cover all possible conditions
and situations that may occur. The operator
must understand that common sense and
caution are factors that cannot be built into this
product, but must be supplied by the operator.

Service

1. Have your Sprayer serviced by a qualified repair
person using only identical replacement parts.

This will ensure that the safety of
the tool is maintained.

2. Store idle tools and equipment out of
reach of children and other untrained
people. Tools and equipment are dangerous
in the hands of untrained users.

SAVE THESE INSTRUCTIONS.

3. Maintain the Sprayer with care. Keep this product
clean. A properly maintained Sprayer is easier to
control.

Page 3For technical questions, please call 1-800-444-3353.Item 9583

Specifications

Pump 12VDC / 3.5A Diaphragm

Maximum Spray Output 1 GPM @ 40 PSI

Tank Capacity 15 gallons

Hose Length 15'

Maximum Weight 160 lb.

Mounting Hardware 4x Ø5/16" x 1/2" bolts and 5/16" washers (not included)

Components and Controls

Note: For additional information regarding the parts listed in the following pages, refer to the Assembly Diagram near

the end of this manual.

Tank

Drain

Cap

Tank Lid

Battery
Clamps

Figure A

Pump

Trigger

Lock

Wand

Clips

Trigger

Hose

Wand

Nozzle

Page 4 For technical questions, please call 1-800-444-3353. Item 9583