Grundig MF 55-2401/7 Top Service Manual

TV Service Manual

Chassis 16.1

ARCANCE 55 Flat
MF 55-2401/5 Top

GBB4600

ARCANCE 55 Flat
MF 55-2401/7 Top

GBB6500

Vorabinformation

Preliminary Information

ARCANCE 55 Flat
MF 55-2401 IT/Top

GBB5600

ARCANCE 55 Flat
MF 55-2401 FR/Top

GBB4700

Zusätzlich erforderliche Unterlagen für den Komplettservice
Additionally required Service Documents for the Complete Service

Service
Manual

Sicherheit

Safety

Materialnr./Part No.

720108000001

Materialnummer/Part Number 720100490000
Änderungen vorbehalten/Subject to alteration
H-S43 0304 • Printed in Germany
http://www.grundig.com

GRUNDIG Service Chassis 16.1

Es gelten die Vorschriften und Sicherheitshinweise
gemäß dem Service Manual "Sicherheit", Material­nummer 720108000001, sowie zusätzlich die eventu­ell abweichenden, landesspezifischen Vorschriften!

D

Inhaltsverzeichnis

The regulations and safety instructions shall be valid
as provided by the "Safety" Service Manual, part
number 720108000001, as well as the respective
national deviations.

GB

Table of Contents

Allgemeiner Teil

Allgemeine Hinweise

Vor dem Öffnen des Gehäuses zuerst den Netzstecker ziehen!

Achtung: ESD-Vorschriften beachten
Leitungsverlegung

Bevor Sie die Leitungen und insbesondere die Masseleitungen lösen,
muss die Leitungsverlegung zu den einzelnen Baugruppen wie z.B.
Chassis, Netzschalterplatte, Bedieneinheit, Bildrohrplatte, Ablenk­einheit, Lautsprecher usw. beachtet werden.
Nach erfolgter Reparatur ist es notwendig, die Leitungsführung wieder
in den werkseitigen Zustand zu versetzen um evtl. spätere Ausfälle
oder Störungen zu vermeiden.

General Section

General Notes

Before opening the cabinet disconnect the mains plug!

Attention: Observe the ESD safety regulations
Wiring

Before disconnecting any leads and especially the earth connecting
leads observe the way they are routed to the individual assemblies like
the chassis, mains switch panel, keyboard control panel, picture tube
panel, deflection unit, loudspeaker and so on.
On completion of the repairs the leads must be laid out as originally
fitted at the factory to avoid later failures or disturbances.

1 - 2

GRUNDIG Service Chassis 16.1

Sicherheits-Hinweise

Die in den Fernsehgeräten auftretende Röntgenstrahlung entspricht
den Bestimmungen der Physikalisch-Technischen Bundesanstalt vom

8. Januar 1987.
Die Hochspannung für die Bildröhre und die damit auftretende
Röntgenstrahlung ist abhängig von der exakten Einstellung der Netzt­eilspannung +B.
Nach jeder Reparatur im Netzteil oder in der Horizontalablenkung ist
die Hochspannung zu messen und gegebenenfalls einzustellen.
Schutzschaltungen im Gerät dürfen nur kurzzeitig außer Betrieb ge­setzt werden, um Folgeschäden am Chassis oder an der Bildröhre zu
vermeiden.
Beim Austausch der Bildröhre dürfen nur die in den Ersatzteillisten
vorgeschriebenen Typen verwendet werden.

D

Service-Hinweise

Chassisausbau

Bevor Sie die Chassis-Verbindungsleitungen lösen, muss die Leitungs­verlegung zu den einzelnen Baugruppen wie Netzschalterplatte, Bedien­einheit, Bildrohrplatte, Ablenkeinheit oder Lautsprecher beachtet wer­den.
Nach erfolgter Reparatur ist es notwendig, die Leitungsführung wieder
in den werkseitigen Zustand zu versetzen, um eventuell spätere
Ausfälle oder Störungen zu vermeiden.

Safety Advices

The X-radiation developing in the sets conforms to the X-radiation
Regulations (January 8, 1987), issued by the Physikalisch-Techni­sche Bundesanstalt (federal physiotechnical institution).
The high tension for the picture tube and thus the developing X­radiation depends on the precise adjustment of the +B power supply.
After every repair of the power supply unit or the horizontal deflection
stage it is imperative that the EHT for the picture tube is checked and
re-adjusted if necessary.
To avoid consequential damages to the chassis or the picture tube
the integrated protective circuits are allowed to be put out of operation
only for a short time.
When replacing the picture tube use only the types specified in the
spare parts lists.

Cable dereseau

Ces appareils ne peuvent être utilisés qu ' avec un cable de connecion
original de réseau avec bobine antiparasite intégré dans la fiche de
secteur. Ce câble de réseau empêche des perturbations de réseau et
est partie de l'autorisation d'appareil. Si nécessaire commandez
uniquement le cable de réseau selon la liste de pièces détachées.

Netzkabel

Diese Geräte dürfen nur mit dem Original-Netzanschlusskabel mit
integrierter Entstördrossel betrieben werden. Dieses Netzkabel ver­hindert Störungen aus dem Netz und ist Bestandteil der Geräte­zulassung. Im Ersatzfall bestellen Sie bitte ausschließlich das Netz­kabel laut Ersatzteilliste.

GB

Service Notes

Disassembly of the chassis

Before disconnecting the chassis connecting leads observe the way
they are routed to the individual assemblies like the mains switch
panel, keyboard control panel, picture tube panel, deflection unit or
loudspeaker.
On completion of the repairs the leads must be laid out as originally
fitted at the factory to avoid later failures or disturbances.

Mains cable

The TV receiver must only be operated with an original mains connecting
cable with an interference suppressor choke integrated in the mains
plug.This mains cable prevents interference from the mains supply and
is part of the product approval. For replacement please order exclusively
the mains connecting cable specified in the spare parts list.

F

Information pour la maintenance

Dèmontage de chassis

Avant de défaire les connecteurs du châssis princip, il y a lieu de
repérer auparavant les liaisons correspondant à chaque platine comme
par exemple le C.I. Inter secteur, le C.I. Commande, le C.I. Tube, le
bloc déviation ou les haut-parleurs.
A la fin de l'intervention, les connexions doivent être remises dans leur
position d'origine afin d'éviter par après d'éventuelles défaillances ou
perturbations.

I

Nota di servizio

Smontaggio del telaio

Prima di sfilare i cavi di collegamneto col telaio è necessario osservare
la disposizione originaria degli stessi verso le singole parti come la
piastra alimentazione, l'unità comandi, la piastra cinescopio, il giogo o
l'altoparlante.
Dopo la riparazione è necessario che gli ancoraggi e le guide
garantiscano la disposizione dei cavi analogamente a quella data in
fabrica e ciò per evitare disturbi o danni nel tempo.

Cavo rete

Gli apperechi devono essere messi in funzioni solo con il cavo originale
il colle gamento di rete e la sua spina di rete deve essere munita di una
bombina d´induttanza. In causa di sostituzione ordinate solo il cavo di
alimentatore che corrésponde alla lista degli accessori.

E

Nota de servicio

Desmontaje del chassis

Antes de desconectar las conecciones del Chassis hay que observar
la dirección de dichas conecciones a los distintos grupos de construcción
como la placa de conmutación de red, unidad de control, placa del
zócalo del tubo de imagen, unidad de deflección o altavoces.
Después de haber realizado la reparación y para evitar fallos o
pertubaciones posteriores es necesario reponer las conecciones tal
como fueron instaladas originalmente en fabrica.

Cable de red

El aparato solo se puede usar con el cable de red original con choque
antiparásito integrado en el enchufe de red. Este cable de red evita
perturbaciones de la red y es parte de la autorización del aparato. En
caso necesario puede pedir el cable de red según lista de piezas de
repuestos.

1 - 3

Technische Daten / Technical Data

Chassis 16.1GRUNDIG Service

CHASSIS CODE
Order Number
EAN
Color
Destination
User manual languages
CHASSIS TYPE
SOUND
REMOTE CONTROL

PICTURE

Picture tube
Picture tube Manufacturer
100 Hz Digital
Flicker free scanning

(full frame memory)
Digital CTI
Digital Combfilter
Digital Luminance Transition

Improvement (DLTI)
Picture Noise reduction
SVM (Scan Velocity Modulation)
Dynamic Focus
Preset picture modes

(soft, natural, rich, user)
Picture Formats
Tilt (rotation)
PIP (2 Tuner)
Multifold Tuner scan

(Mosaic Picture)
PAT: Split screen

(PICTURE + TXT)
PAP: Double window

(PICTURE + PICTURE)
P2AT: Double window + TXT
Picture freezing
POP: PICTURE on PICTURE
Zoom with point function
Auto 16:9 selection via scart
Sharpness Control
Blue Back

SOUND

Mono/A2Stereo/NICAM
AV Stereo
Dolby Virtual
Subwoofer (20W max.)
Dynamic Bass
DSP (Digital Sound Processor)
Balance Adjustment
Automatic Volume Leveling (AVL)
PIP listening via HP-jack
5 Band Graphic Equalizer
Space Sound Effect
Preset Sound Modes

(cinema, music, sport, speech, user)
Sound output (RMS)

ARCANCE 55 Flat
MF 55-2401/5 TOP

16,1 SX

GBB4600

40 13833-59248 8

procon silver

D,A,CH,NL,E,P,S,N,DK

D,NL,DK,N,S,E,P

50 Hz / 90°

STEREO

Tele Pilot 160C Tele Pilot 160C

"21" PF

Philips, Panasonic

\

\

\
\

\

\
\
\

[

16:9 / 4:3

\
\

\

\

\

\
\
\
\
[
[
[

[/[/[[/[/[

[
\
\
\
[
[
[
\
[
[

[

2 x 7 W

ARCANCE 55 Flat

MF 55-2401 IT/ TOP

16,1 SX

GBB5600

40 13833-59278 5

procon silver

50 Hz / 90°

STEREO

"21" PF

Philips, Panasonic

16:9 / 4:3

2 x 7 W

ARCANCE 55 Flat
MF 55-2401/7 TOP

16,1 SX

GBB6500

40 13833-59295 2

procon silver
I
I

\

\

\
\

\

\
\
\

[

\
\

\

\

\

\
\
\
\
[
[
[

[
\
\
\
[
[
[
\
[
[

[

CZ,H,PL,GR,FIN

CZ,H,PL,GR,FIN,GB

50 Hz / 90°

STEREO

Tele Pilot 160C Tele Pilot 160C

"21" PF

Philips, Panasonic

\

\

\
\

\

\
\
\

[

16:9 / 4:3

\
\

\

\

\

\
\
\
\
[
[
[

[/[/[[/[/[

[
\
\
\
[
[
[
\
[
[

[

2 x 7 W

ARCANCE 55 Flat

MF 55-2401 FR/TOP

16,1 SX

GBB 4700

40 13833-59255 6

procon silver

F, CH

F

50 Hz / 90°

STEREO

"21" PF

Philips, Panasonic

\

\

\
\

\

\
\
\

[

16:9 / 4:3

\
\

\

\

\

\
\
\
\
[
[
[

[
\
\
\
[
[
[
\
[
[

[

2 x 7 W

1 - 4

Chassis 16.1GRUNDIG Service

TUNING

PLL Frequncy Synthesize
Automatic Tuning System

with country selection
Frequency Based Auto Search
Automatic Micro-search
Automatic Programming
Manual fine tuning
Direct channel selection
Standard
NTSC Playback via scart

(3,58/4,43)
PAL M/N NTSC M
Cabel TV / Hyperband (S1-S41)

CONNECTIONS

Euro Scart socket 1
(CVBS + RGB)

Euro Scart socket 2
(CVBS + S-VHS)

Euro Scart socket 3
Audio / Video in (Front or Side)
S-VHS cinch (Front or Side)
Audio Back out (Line out)
Headphone jack menu with

full sound adjustments
Aerial Input
S-VHS via Scart
Display of other inputs

while copy function

ELECTRONIC

µ-Processor

Manual & automatic labelling
of prog. (5 characters)

Programmable off timer
Programmable on timer
Intelligent Channel search

(Zapping function)

Programme Edit
Intelegent Programme Switch
Auto switch off
Programme memory TV/AV (opt.)

Teletext/Fastext/Toptext

Childlock

Menu languages OSD

Zapp (Recall function)
Service mode
Game
Hotel mode

POWER SUPPLY / CABINET

Voltage / frequency
Power consumption

(IEC 62087-2002)
Power consumption

Standby

Cabinet (WxHxD) / Weight

ARCANCE 55 Flat
MF 55-2401/5 TOP

[[

[

\
[
\
[
[

PAL /BG

[

\
[

[[

[

\
[
\
\

[

[
[

\\

STM ST92195C7

64kB ROM

[

[
\

\

[
\
[

100/AV

10/7/5 pages

Level 1.5

[

D-DK-E-I-N-NL-P-S

[
[
\
\

230/50Hz 230/50Hz

50 W

4 W

59,4 x 45,1 x 48,1 cm /

59,4 x 45,1 x 48,1 cm /

approx. 22,5 kg

ARCANCE 55 Flat

MF 55-2401 IT/ TOP

[

\
[
\
[
[

PAL /BG

[

\
[

[

\
[
\
\

[

[
[

STM ST92195C7

64kB ROM

[

[
\

\

[
\
[

100/AV

10/7/5 pages

Level 1.5

[

D-DK-E-I-N-NL-P-S

[
[
\
\

50 W

4 W

approx. 22,5 kg

ARCANCE 55 Flat
MF 55-2401/7 TOP

ARCANCE 55 Flat

MF 55-2401 FR/TOP

[[

[

\
[
\
[
[

[

\
[
\
[
[

PAL/SECAM/BG/DK[PAL/SECAM/BG/L´/L

[

\
[

\
[

[[

[

\
[
\
\

[

[
[

[

\
[
\
\

[

[
[

\\

STM ST92195C7

64kB ROM

[

[
\

\

[
\
[

100/AV

10/7/5 pages

Level 1.5

[

CZ-GB-GR-H-PL-CIS-

RO-TR

[
[
\
\

STM ST92195C7

64kB ROM

[

[
\

\

[
\
[

100/AV

10/7/5 pages

Level 1.5

[

D-E-F-GB-GR-I-NL-P

[
[
\
\

230/50Hz 230/50Hz

50 W

4 W

59,4 x 45,1 x 48,1 cm /

approx. 22,5 kg

59,4 x 45,1 x 48,1 cm /

50 W

4 W

approx. 22,5 kg

1 - 5

Bedienhinweise Dieses Kapitel enthält Auszüge aus der Bedienungsanleitung.

Weitergehende Informationen entnehmen Sie bitte der gerätespezifischen Bedienungsanleitung, deren Materialnummer Sie in der entsprechenden Ersatzteilliste finden.

1 - 6

Chassis 16.1GRUNDIG Service

Operating Hints This chapter contains excerpts from the operating instructions.

For further particulars please refer to the appropriate user instructions the part number of which is indicated in the relevant spare parts list.

1 - 7

Chassis 16.1GRUNDIG Service

Subject to change without notice

2

6

10

14

9

13

1

5

TR901

C913
2n2

R915

22K

C914
2n2

R918
33K

R917

6.8K

P901
5K

C923
56pF

R916

15K

C920

2n2 400V

R920

4M7 0.5W

63V

C912

2.2uF

63V

16V

25V

TDA16847

2

11

4

7916

3

14

8

13

10

12

5

IC901

C908
47uF/16V

D906

1N4148

R906

15R

T901
SPP03N65

G

250Vac

250Vac

250Vac

(2SK2545)

R569

4R7

D905
RGP10J

R903
68K

C906

33nF

C905

68uF

2W

630V

400V

D904

RF2007

D902
RF2007

D903

RF2007

D901

RF2007

C917

1n 1KV

C918

1n 1KV

C903

1n 1KV

C904

1n 1KV

C922

xx pF

R908
820K

R901
5R1 NTC

L901

LINE FILTER

C902
100nF

C901

220nF

S901

2.5 A

431

2

SW901

POWER SWITCH

1

2

X901

2 WAY PLUG

R902

PTC

C915

100nF

1

2

X902

2 WAY PLUG

25V

S

D

D950

RGP10J

D951

RGP50D

C950

220pF 1KV

C961
47nF

C951

47uF 160V

C953

33uF / 160V

L950

50uH Choke

ZD570
33V

R950

39K 0.5W

R956

5R6

OUT

IN

GND

IC953
78L05

C954
1000uF

C965

22uF / 16V

C962
47nF

C955
47nF

C964
47nF

R954
1K3 %1

R953
240R %1

T950
BC337

R957

100R

R919

3K9

C966
10uF

C967
47nF

ZD952

5.6V

T906
BC848B

C956

4.7uF

C963
47nF

C957

10uF

C958
47nF

16V

16V

16V

P2.0-IRin

1

RESET

2

P0.7

3

P0.6

4

P0.5

5

P0.4

6

P0.3

7

P0.2

8

P0.1

9

P0.0

10

P3.7

11

P3.6

12

P3.5

13

P3.4

14

P3.3-B

15

P3.2-G

16

P3.1-R

17

P3.0-FB

18

P5.1-SDA

19

P5.B-SCL

20

VCC

21

TEST

22

WSCF

23

WSCR

24

AVDD3

25

TEST1

26

MCFM

27

TEST228TXCF

29

TEST3

30

AVDD2

31

TEST4

32

CVBS2

33

CVBS1

34

GND

35

GND0

36

TEST5

37

PXFM

38

AVDD

39

HSYNC

40

VSYNC

41

P4.0

42

P4.1

43

P4.2

44

P4.3

45

P4.4

46

P4.5

47

ST-BY SPKR

48

MUTE

49

OSC out

50

OSC in

51

P2.5 VS

52

P2.4

53

P2.3

54

P2.2

55

P2.1

56

IC402

ST92195

R434
4K7

R435

8K2

R431
XX R

Q401
4MHz

C413

39pF

C412
39pF

R405
2K7

R433

2K7

C410
2u2 / 16V

C437
560pF

C456
10uF / 16V

C416
10uF / 16V

C420

47nF

C409

4n7

C424
22pF

R416

5K6

R419

2R2

R412

15K

R418
2R2

C421
470nF

C414
82pF

C402
47nF

L403
18uH

R420

2R2

C401

47nF

C419

22p

C415
2n2

R415

5K6

C408
4n7

C418

10uF / 16V

R421

2R2

C407

1nF

L404

18uH

IR_IN

R448

100R
R447

100R

R408
4K7

R407
4K7

SW404

SW403

SW402

R406

4K7

R403
2K2

R402
4K7

P3

P2

P1

S401

TSOP1738

R417
330R

R401
10K

C411
22uF / 16V

C434
22uF / 16V

L402

18uH

R456
8k2

R457
10K

T408

BC848B

ZD407

5.1V

T406
BC848B

R411
470R

R425
680R

R450
2K2

R429

4K7

D418
LED

E0

1

E1

2

E2

3

GND4SDA

5

SCL

6

MODE_WC

7

VCC

8

IC401

24C08

C404
47nF

1

2

3

4

5

X402

SERVICE_PLUG

R440

4K7

SIFIN1

1

SIFIN2

2

AGCSIFCAP

3

IFVREF

4

AGCPIFCAP

5

PIFIN1

6

PIFIN2

7

AGC

8

IFPLL

9

GNDIF

10

QSS

11

VCCIF

12

INTCVBSO

13

EXTAUDIN

14

PIFLC1

15

PIFLC2

16

VCC2

17

CVBSIN1

18

GND2

19

CVBSIN2

20

BS

21

Y_CVBSIN3

22

CHR

23

APR

24

B_EXT

25

G_EXT

26

R_EXT

27

FB_EXT28NC

29

B_OUT

30

G_OUT

31

R_OUT

32

ICATH

33

BOSD

34

GOSD

35

ROSD

36

FBOSD

37

XTAL3

38

XTAL2

39

XTAL1

40

CLPF

41

VAMP

42

GND1

43

CVBSO1

44

VCC1

45

BCLSAF

46

VERT

47

HOUT

48

LBF_SSC

49

SLPF

50

SCL

51

SDA

52

VCCD

53

GND0

54

AUDIOOUT

55

FMCAP

56

IC101

STV2246

C105
10uF / 16V

C101
1uF / 16V

C108
22nF

1

2

3

4

5

SAW01
TABLE

L104
1uH

C110
1nF

C109

330nF

R102

150R

R142

220R

L101 10uH

C114
47nF

C113

47uF

LC100

TOKO

C134

10uF / 16V

C136

1uF / 16V

C139

1uF / 16V

C138

1uF / 16V

C137

1uF / 16V

C120

100nF

C122

100nF

C121

100nF

C123
47nF

R131 330K

1

2

3

4

5

6

X101

CRT_RGB_OUT

R137

270R
R136

270R
R135

270R

R112

1K

R138
47K

R111

470R

R144
1K

R110

470R

R145
1K

R109

470R

R146
1K

C117
47nF

C118

47nF

C116

47nF

R115

5K6

R123
5K6

C119

100nF

Q102

3.58MHz

Q101

4.43MHz

C129
4n7

R101
27K

C124
100nF

C135
220uF

C130
2u2

C127

100uF / 16V

C142
10uF / 16V

C126
22uF / 16V

C115

47nF

R133
2K2

R132

2K2

R134
8K2

R118

100R
R119

100R

R116

470R

R130

56K
C128
4n7

R122

8K2

L102

10uH

16V

D107

1N4148

16V

C143

1uF / 16V

R139
3K3

R120

1K

R107
47R

R129
220R

R108
47R

R126
180R

R104
TABLE

R124
150R

R114

100R

R105

TABLE

R125
180R

R106
47R

T103

BC848B

T102

BC848B

T101

BC848B

L105

TABLE

L103

1uH

L106

1uH

L107

TABLE

C140

10n

C111

10uF

C112
820p

C132
3n9

C131
820p

F101
TABLE

C141

1uF / 16V

C107

10uF

C102

10nF

R117
1K

25V

C106

10uF

16V

63V

R436

4K7
R437
39K

R442

220R

R441

220R

C430

47uF

C432
47pF

C429
560pF

C435
10nF

L401

18uH

AGC

1

2

3

SCL4SDA5+5V6+5V7NC

8

+33V9IF110IF2

11

GND4

15

GND3

14

GND2

13

GND1

12

TU100
TUNER

16V

C187

1nF

R192
3K3

R194

100R

R191
10K

R190
3K3

R193
2K2

C185

220nF

C186

220nF

1

2

3

4

5

SAW02
TABLE

T105
BC848B

T108
BC848B

R195
0R

D181

BA682

D180

BA682

1

2

3

4

5

6

7

8

9

10

11

12

X102

STEREO_1_OUT

C148

220p

R152

75R

R153

68R

R154
75R

R166
75R

R164
75R

R163
75R

R159

330R

R160

100R

C150
1nF

C151
1nF

R161

330R

R162

100R

C152

1nF

C153
1nF

R165

1K

C154
220p

C155
470p

R167

1K

C156
220p

C157

470p

INV9BUFFER8RAMP7GND6VREF_DEC5H_ADJ4TRIG3OUT2PWR

1

VCC10FLYBACK

11

IC501

TDA8174AW

R501

2R2 0.5W

R502
470R

R503

22R

R508
1K8

R516

1K6

R509

TABLE

R519
1K

R506
150K

R504

1K

R513

10K

R527
TABLE

R505
150K

R511

2K7

R512

1K8

R510
TABLE

R524
3K9

R520
1K

R521
100K

R522

8K2

R523
2K2

C506

10uF

C505

1uF

C510
100uF

C503
1000uF / 35V

C504

220uF / 25V

C512

1uF

C511

1uF / 16V

T501
BC848B

T502
BC848B

D502
RF2007

C501
220nF

1

2

X501

VER_DEFL

R518

82K

C509

470pF

C508
15nF

C513
100nF

C508A
33nF

0.5W

0.5W

16V

TABLE

16V

16V

50V

D503

EHT - 29KV

600M

FOCUS

UG2

3

1052

6

7

9

11

1

TR552

DST 12.3

C554
390nF

C566
560pF

C555

6.8nF

C556
330nF

C561

1n 1kV

C563
100nF

C553

1uF / 160V

C552

10uF

C560

10uF

C557
470uF

C564
TABLE

R558

10K

R557
470R

R555
47R

R551
33R

R554

82R 3W

R553

330R

R559

3.3R

D552
BA157

D556

BA157

D553

RGP10J

D560

RGP10J

D559

D557
1N4148

D558

R552
1K

R565

10K

R526

22K

T551

STX112

T552

BU808DFI

L551

LIN.HOR.

L502

6.8uH

1

2

3

4

5

X551

HOR_DEFL

R560

TABLE

50V

TABLE

0.5W

0.5W

250V

2W

250V

0.5W

R568
680R

C558
10nF

C562
100nF

C570

10nF

U CRT

Uv.bes

Uv.ref

BCL

GND2

Text

Text

R562
10K

R563
TABLE

R564

680R

1

2

3

4

X552

CRT_HT_OUT

250V

50V

16V

LINK

C166

22nF

C438

560pF

C405
10nF

R404

10K

R414
10K

16V

C125
1uF / 16V

1

2

3

4

5

6

7

8

9

X103

STEREO_2_IN

R186

10K

R185
100R

T109

BC848B

C184
68pF

F102
T40.4

R128
1K2

R187

330K

R188
330K

D103

1

2

3

X104
SVHS

500V

R914
820R

C911
120pF

R913

2M2 1W

D908 1N4148

R912

220K

D907

1N4148

R907
820K

C916
3n9

R921

47R

R910

33K

R905
10K

D909

1N4148

ZD901

5.1V 1/4W

C919

330nF

R911
560K %1

C921

680pF

R909
3K3

C909

10nF

63V

C910

47nF 63V

R904
39K

HEATER

R923

2R2

R922
560K %1

DEGAUSS

OUT

IN

ADJ

IC951

LM317T

T902

BC327

R184

100R

R183

100R

R182

100R

R189

100R

1

2

3

4

5

X401

C169
1n

C188
10n

C571
47u/16v

C149
220p

R157

68R

R158
75R

R174

75R

R168

330R

R169

100R

C158
1nF

C159
1nF

R171

100R

C160
1nF

C161
1nF

R172

1K

C162
220p

C163
470p

R173

1K

C164

220p

C165
470p

R121

100R

R127
1K

T104

BC848B

C104
10nF

R113

47R

C144
10uF/63V

OPTION

R438S

8K2
R432
4K7

OPTIONEL

R422

4K7

R423

10K

T402

BC848

OPTIONEL

C565

xx

R451

100R

C439
47u/16V

C179
22n

C145

47u/16V

C175
100p

C176
100p

C177
100p

C180

27p

R958

22R 0.5W

Y1

1

Y0

2

Z1

3

ZOUT

4

Z0

5

EN

6

VEE

7

VSS

8

VDD

16

YOUT

15

XOUT

14

X1

13

X0

12

CONT_X

11

CONT_Y

10

CONT_Z

9

IC102

MC14053BD

R179

47K
R180

47K

R177

47K

R178

47K

R176
4K7

R175
4K7

R206

0R

R207

0R

R2050RR181

0R

C170

10uF

C174

2.2uF

C173

2.2uF

C168

100nF

C167

100nF

C172

22nF

C192

10nF

C171

22nF

16V

16V

16V

R202

0R

R203
0R

R208

330R

R201

0R

R209

0R

R140

1K

C178
560p

C191

10n

C194
10n

C195

10n

C196

10n

C200

68p

R196

0R

R200
0R

L-L'

L-L'

L-L'

OPT. 2 . SCART

OPTION 2SC+FAV

C440
100p

C441

100p

C442

100p

R961

470K

R452
0R

R453

4k7

C941
1nF

R940
option

R941
100R

C450

33pF

C431
47pF

C551

2n2

L104A
1uH

C103

1uF / 16V

OPTIONEL

C183

10u/50V

C190

2.2uF/16V

R198

47K

R199
10K

R150
470K

R149

100K

R151
100K

T110

BC848

T111
BC848

SCART

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

161820

21 19 17

SCART

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

161820

21 19 17

out

in

SK101

C380

1.5n

C379

1.5n

C388

220n

C376

100n

C377

220n

C378

100n

R354

2k2

R355

2k2

R356

4k7

R357
4k7

C381

3.3n

C387

3.3n

C385
100n

C384
1000u/16V

11

10

12

9

6

8

3

16

1

4

14

17

2

15

Out1-

Out1+

Out2-

Out2+

Vcc

In1-

In1+

In2-

In2+

Mode

Svr

Gnd

IC317

TDA8944J

C383
100n

C382
100n

R359

4R7/0.5W

R358

4R7/0.5W

C425

1u/16V

R443
4k7

R426

4k7

T404

BC848

T403
BC848

R430
2k7

R428
2k7

R439
2k7

R427
2k7

R444
10k

R445
10k

C444
47pF

C445
47pF

C197

47pF

C198

47pF

C199

47pF

C201

47pF

C907
470pF 2KV

1

2

3

4

X320

C386
10u/16V

S902

FUSE¤
T4A

Non L-L'

Non L-L'

T\U+2584PLER
20"SS
20"EK
20"TH
21"SS
21"NO
21"TH
21"LG-PH
21"PH
21"TH/PF

U1
118V
119V
118V
115V
117V
112V
118V
117V
125V

C557
470uF 220uF

470uF

C504 C450

33pF1000uF

470uF

-

C554

9.1nF

220nF-

8.2nF

5.6nF

6.2nF

7.5nF

*6.8nF

8.2nF

7.5nF

C555

390nF

8.2nF

D950

RGP10J

RGP15J

L551
70uH

*55uH
120uH
*55uH
*55uH
70uH
100uH

470uF
470uF
470uF
470uF
470uF

470uF

470uF
470uF

470uF
470uF
470uF

390nF
390nF
390nF

390nF
390nF
390nF
390nF

220uF
220uF

-

-

-

-

-

-

RGP10J
RGP10J
RGP10J
RGP10J

RGP10J
RGP10J
RGP10J

70uH
70uH

R509 R510 R520 R527 R560 R563 R563 R568

R706\R707

R917

R923\R924

1.5R

1.5R

1.5R

1.2R

1.5R

1.2R

1.2R

1.2R

1.2R

100R
100R
100R

*47R

*100R

100R

100R
100R
100R

1K
100K
1K
*1K
1K
100K
100K
1K

2.7K

680K
680K
680K
680K
680K

*680K
470K
680K

*680K

0.47R

0.68R

0.68R

*0.22R

1R

0.22R
*1.5R

1.8R

0.68R

8.2K

6.8K

8.2K

6.8K

6.8K

6.8K

6.8K

8.2K

7.5K

9.1K

9.1K

9.1K

7.5K

7.5K

7.5K

7.5K

9.1K

7.5K

1K
1K
1K
*1K
1K
*470R
470R
470R
680R

-

-

-

-

141222/220R

-

-

-

-

6.8K

6.8K

6.8K

6.8K

6.8K

8.2K

6.8K

6.8K

4.7K

1.5R

1.5R

1.5R

-

-

-

-

-

-

C564
470uF
470uF
470uF
220uF
220uF
220uF
220uF
220uF
220uF

C565
330pF

-

1.5nF
*1.5nF

­*1nF
330pF

-

-

+5V_AL

+5V_AL

+5V_AL

+5V_AL

+5V A

+5V A

+5V A

+5V A

+5V A

+5V A

+5V A

+5V A

+5V B

+5V B

+5V B

+5V B

+5V B

+5V B

+5V B

+8V

+8V

+8V

+8V

+8V

+8V

+8V

+8V

+8V

+8V

+8V

+13VA

+13V

+13V

+13V

+13V

+33V

+33V

STAT1

SC2 CVBS

SC2 CHR

B_SCRT

G_SCRT

R_SCRT

F_BLSC

B_SCRT

G_SCRT

R_SCRT
F_BLSC

STAT1

CVBS_OUT_SC2

CVBS1

CVBS1

CVBS_OUT_SC1

CVBS_OUT_SC1

STAT2

STAT2

SC2 CHR

CVBS_OUT_SC2

SC2 CVBS

SDA

SCL

SCL

SDA

SDA

SCL

INTRC/QSS

INTRC/QSS

CVBS_TXT

CVBS_TXT

BOSD

GOSD

ROSD

FBOSD

CVBS_TXT/U

IF2

IF1

IF2

IF1

IF2

AGC

AGC

SDA

SCL

MSP_RES

MSP_RES

SDA

SCL

AV3 SVHS

AV3 SVHS

V_AMP

FLAYBACK

FLAYBACK

VSYNC

HSYNC

VSYNC

HSYNC

V_AMP

V_OUT

BCL

BCL

SDA
SCL

H_OUT

H_OUT

LFB

LFB

V_LIN

V_LIN

L_L'

L_L'

CVBS_TXT/U

OFF (ST-BY)

OFF (ST-BY)

U1

U1

FBOSD

ROSD

GOSD

BOSD

V_OUT

NOT: * ile isaretlenen degerler tip veya DST versiyonuna göre degisebilir.

The values marked with asterisk may change with the CRT or DST version.

100p

CHR

VIDEO

C433
1nF

1

2

HS301
SES SOGUTCUSU

Right

Left

Right

Left

R

R

L

L

R446

100K

R449

220R
C447
220pF

C133

22pF

AUD_CLO

1

NC1

2

NC2

3

DCTROUT1

4

DCTRO0

5

ADR_SEL

6

STBYQ

7

NC3

8

SCL

9

SDA

10

I2S_CL

11

I2S_WS

12

I2SDAOUT

13

I2SDAIN1

14

ADR_DA

15

ADR_WS

16

ADR_CL

17

DVSUP

18

DVSS

19

I2SDAIN2

20

NC4

21

NC5

22

NC6

23

RESETQ

24

DACA_R

25

DACA_L

26

VREF2

27

DACM_R

28

DACM_L

29

DAC_C

30

DAC_SUB

31

DAC_S32SC2_O_R

33

SC2_O_L

34

VREF1

35

SC1_O_R

36

SC1_O_L

37

CAPL_A

38

AHVSUP

39

CAPL_M

40

AHVSS

41

AGNDC

42

SC4_I_L

43

SC4_I_R

44

ASG4

45

SC3_I_L

46

SC3_I_R

47

ASG2

48

SC2_I_L

49

SC2_I_R

50

ASG1

51

SC1_I_L

52

SC1_I_R

53

VREFTOP

54

MONO_IN

55

AVSS

56

AVSUP

57

ANA_IN1+

58

ANA_IN-

59

ANA_IN2+

60

TESTEN

61

XTAL_IN

62

XTAL_OUT

63

NC7

64

IC316

MSP34XX

C342

2.2nF

C343

2.2nF

C348

100nF

C334
1nF

C335
1nF

C332

1nF

C354

10nF

C355

10nF

C357
100pF

C333
1nF

C349

100nF

C352

1.5pF

C353

1.5pF

C324
1nF

C325
1nF

C347
100nF

OUT

IN

GND

IC315
78L05

C344

47uF

C317

47nF

C323

1nF

C345

47uF

C356
33nF

R321

100R

R322 100R

MSP_RES

R323

220R

R324

1K

C330

1nF

C331
1nF

R327

1K

C328

1nF

C329
1nF

R326

1K

C326

1nF

C327
1nF

R325

1K

T318
BC858B

T319
BC858B

R318

3.3K

R315
330R

R319

3.3K

R316
330R

C338

100uF / 16V

C339

100uF / 16V

C319
1nF

C320
1nF

1

2

3

X316

HEADPHONE

C315

100uF

C316

47nF

C318

1nF

INTRC/QSS

RIGHT

+8V A

+8V A

LEFT

+8V C

T317
BC858B

R317

3.3K

T320
BC858B

R320

3.3K

C322

1nF

C321
1nF

C371

47uF / 16V

C370

47uF / 16V

C369

47uF / 16V

C368

47uF / 16V

C367

10uF / 63V

C366

10uF / 63V

C365

3.3uF

C362

330nF

C363

330nF

C364

1nF

R328

470R

C361

4.7uF / 16V

C360

4.7uF / 16V

C359

4.7uF / 16V

C358

4.7uF / 16V

C372

10uF

1

2

3

X318

CINCH

1

2

3

4

5

6

7

8

9

10

11

12

X317

MSP_RES

SCL

SDA

+8V A

C340

330nF

C341

330nF

Q315

18.432MHz

INTRC/QSS

16V

MONOIN

63V

50V
T316
BC558

T315

BC558

16V

16V

+8V C

STEREO MODUL

RIGHT

LEFT

R

L

R335

0R

R345

470R

1

2

3

4

5

6

7

8

9

X315

STEREO_2_IN

R338
0R

R337

0R

Optional

C373
33nF

C336

47pF

C337

47pF

4

5

6

78

9

10

11

12

n.c.

G1

GREEN

G2

RED

HT

HT

BLUE

GND

GND

X703

CRT SOKET

1

3
4
5
6

2

X701
RGB

crt

R702
220R

C701

47p

T701

BF422

R710

15k

155V

R711
390R

crt

C703
390p

R712
100R

crt

R713

2.7k

8V_

D702
1N4148

C705

470p

T702

BF421

R714
1k

R703

220R

C706

47p

T703

BF422

R715
15k

155V

R716
390R

crt

C707

390p

R717
100R

crt

R718

2.7k

8V_

D703
1N4148

C708

470p

T704
BF421

R719
1k

R704

220R

C709

47p

T705

BF422

R720
15k

155V

R721

390R

crt

C710
390p

R722
100R

crt

R723

2.7k

8V_

D704
1N4148

C711

470p

T706
BF421

R724
1k

8V_

R725

1.5K

R726

1.5K

R727

1.5K

C712

2.2n

C713

100n/250V

crt

155V

1

2

3

X702

CRT

G2

AQUA SMPS

R701

100R

R706

220R

R707
220R

R709
220R

C702

10u/250V

D701
1N4007

155V

Blue

Green

Red

Icatch

R728

100k 1/2W

CRT BOARD

RIGHT

LEFT

C346

220pF

C375

220nF

C374
100nF

0PAD

KABLO2

KABLO5A

KABLO5B

+13VA

+13VA

C443
100p

C446

C453
100p

100p

C452

100n

C451

100n

C448

100n

C449

C189
100p

C193
100p

T407
BC848B

R458

68k

R459
1k5

+13V

R455

100R

R454

100R

C455
100u / 16V

C454
100u / 16V

L701

10uF

S./P. 3-3

S./P. 3-4

S./P.
3-6

S./P. 3-7

S./P. 3-4

S./P.
3-5

S./P. 3-2

S./P. 3-8

S./P. 3-15

S./P. 3-13

S./P. 3-2

S./P. 3-5

3 - 1

Platinenabbildungen und Schaltpläne / Layout of PCBs and Circuit Diagrams

GRUNDIG Service Chassis 16.1

Übersicht /Overview

Netzteil / Mains Unit

2

6

10

14

9

13

1

5

TR901

C913

2n2

R915

22K

C914

2n2

R918
33K

R917

6.8K

P901
5K

C923
56pF

R916

15K

C920

2n2 400V

R920

4M7 0.5W

63V

C912

2.2uF

63V

16V

25V

TDA16847

2

11

4

7

91

6

3

14

8

13

10

12

5

IC901

C908
47uF/16V

D906

1N4148

R906

15R

T901
SPP03N65

G

250Vac

250Vac

250Vac

(2SK2545)

D905

RGP10J

R903

68K

C906

33nF

C905

68uF

2W

630V

400V

D904

RF2007

D902

RF2007

D903

RF2007

D901

RF2007

C917

1n 1KV

C918

1n 1KV

C903

1n 1KV

C904
1n 1KV

C922

xx pF

R908
820K

R901

5R1 NTC

L901

LINE FILTER

C902
100nF

C901

220nF

S901

2.5 A

4

3

1

2

SW901

POWER SWITCH

1

2

X901

2 WAY PLUG

R902

PTC

C915

100nF

1

2

X902

2 WAY PLUG

25V

S

D

D950

RGP10J

D951

RGP50D

C950

220pF 1KV

C961
47nF

C951

47uF 160V

C953

33uF / 160V

L950

50uH Choke

ZD570

33V

R950

39K 0.5W

R956

5R6

OUT

IN

GND

IC953
78L05

C954

1000uF

C965

22uF / 16V

C962

47nF

C955

47nF

C964

47nF

R954
1K3 %1

R953
240R %1

T950
BC337

R957
100R

R919

3K9

C966

10uF

C967
47nF

ZD952

5.6V

T906
BC848B

C956

4.7uF

C963

47nF

C957

10uF

C958
47nF

16V

16V

16V

R914
820R

C911

120pF

R913

2M2 1W

D908 1N4148

R912

220K

D907

1N4148

R907
820K

C916

3n9

R921

47R

R910

33K

R905

10K

D909

1N4148

ZD901

5.1V 1/4W

C919

330nF

R911
560K %1

C921
680pF

R909
3K3

C909

10nF

63V

C910

47nF 63V

R904
39K

R923

2R2

R922
560K %1

DEGAUSS

OUT

IN

ADJ

IC951

LM317T

T902

BC327

R958

22R 0.5W

R961
470K

C941
1nF

R940
option

R941

100R

C907
470pF 2KV

S902

FUSE
T4A

+5V A

+5V B

+8V

+13VA

+13V

+33V

OFF (ST-BY)

U1

0PAD

KABLO2

BUS B BUS B

BUS A BUS A

Components designated by the safety symbol should only be replac ed by original parts produced and proofed by the manufacturer

.
Sicherheitsbautelle im Sinn der sicherheitsbestimmung. Diese Teile durfen nur durch Originalteile ersetzt werden.
Contrassegno di sicurezza. I componenti devono, corrispondere a ricambi originali e devono essere montati a regola d’arte.

T\U+2584PLER
20"SS
20"EK
20"TH
21"SS
21"NO
21"TH
21"LG-PH
21"PH
21"TH/PF

U1
118V
119V
118V
115V
117V
112V
118V
117V
125V

C557
470uF 220uF

470uF

C504 C450

33pF1000uF

470uF

-

C554

9.1nF

220nF-

8.2nF

5.6nF

6.2nF

7.5nF

*6.8nF

8.2nF

7.5nF

C555

390nF

8.2nF

D950

RGP10J

RGP15J

L551
70uH

*55uH
120uH
*55uH
*55uH
70uH
100uH

470uF
470uF
470uF
470uF
470uF

470uF

470uF
470uF

470uF
470uF
470uF

390nF
390nF
390nF

390nF
390nF
390nF
390nF

220uF
220uF

-

-

-

-

-

-

RGP10J
RGP10J
RGP10J
RGP10J

RGP10J
RGP10J
RGP10J

70uH
70uH

R509 R510 R520 R527 R560 R563 R563 R568

R706\R707

R917

R923\R924

1.5R

1.5R

1.5R

1.2R

1.5R

1.2R

1.2R

1.2R

1.2R

100R
100R
100R
*47R

*100R

100R

100R
100R
100R

1K
100K
1K
*1K
1K
100K
100K
1K

2.7K

680K
680K
680K
680K
680K

*680K
470K
680K

*680K

0.47R

0.68R

0.68R

*0.22R

1R

0.22R
*1.5R

1.8R

0.68R

8.2K

6.8K

8.2K

6.8K

6.8K

6.8K

6.8K

8.2K

7.5K

9.1K

9.1K

9.1K

7.5K

7.5K

7.5K

7.5K

9.1K

7.5K

1K
1K
1K
*1K
1K
*470R
470R
470R
680R

-

-

-

-

141222/220R

-

-

-

-

6.8K

6.8K

6.8K

6.8K

6.8K

8.2K

6.8K

6.8K

4.7K

1.5R

1.5R

1.5R

-

-

-

-

-

-

C564
470uF
470uF
470uF
220uF
220uF
220uF
220uF
220uF
220uF

C565
330pF

-

1.5nF
*1.5nF

­*1nF
330pF

-

-

*Value may change with the CRT or DST version.

*

Wert ist abhänging von der Bildröhre oder dem Zeilentrafo

3 - 2

Variantenbestückung / Variant Components

GRUNDIG Service Chassis 16.1

GRUNDIG Service Chassis 16.1

Chassis IC401 / Chassis IC 401

BUS B

R417
330R

S401

TSOP1738

IR_IN

+5V_AL

IC401

1

E0

2

E1

3

E2

GND4SDA

24C08

SDA

SCL

BOSD
GOSD
ROSD

FBOSD

SDA

SCL

CVBS_TXT/U

+5V_AL

P3

P1

P2

VCC

MODE_WC

SCL

1

2

3

4

5

+5V A

X401

L402

18uH

R401
10K

C411

22uF / 16V

8

7

6

5

SCL

SDA

R406

4K7

47nF

C404

+5V A

R403
2K2

R402

4K7

+5V A

R407

4K7

+5V A

C434
22uF / 16V

C439

47u/16V

R451

100R

+5V_AL

L404

18uH

C408

4n7

R449

220R
C447
220pF

SW402

SW403

SW404

X402

1

2

3

4

5

R408

4K7

C418

10uF / 16V

R457

10K

R456
8k2

T407
BC848B

C456
10uF / 16V

R453

4k7

R452

0R

C451
100n

R446

100K

C440
100p

C452
100p

R440

4K7

SERVICE_PLUG

R448

100R
R447

100R

R421

2R2

C407

1nF

C401

47nF

R420

2R2
R415

5K6

C419

22p

T408
BC848B

1

2

C448

100n

100n

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

3

4
C449

5

R458

68k

+13V

ZD407

5.1V

R459
1k5

P2.0-IRin

RESET

P0.7

P0.6

P0.5

P0.4

P0.3

P0.2

P0.1

P0.0

P3.7

P3.6

P3.5

P3.4

P3.3-B

P3.2-G

P3.1-R

P3.0-FB

P5.1-SDA

P5.B-SCL

VCC

TEST

WSCF

WSCR

AVDD3

TEST1

MCFM

TEST2

IC402

ST-BY SPKR

ST92195

+5V_AL

P2.1

P2.2

P2.3

P2.4

P2.5 VS

OSC in

OSC out

MUTE

P4.5

P4.4

P4.3

P4.2

P4.1

P4.0

VSYNC

HSYNC

AVDD

PXFM

TEST5

GND0

GND

CVBS1

CVBS2

TEST4

AVDD2

TEST3

TXCF

R411
470R

R425
680R

D418
LED

56

55

54

53

52

51

50

49

48

47

46

45

44

43

42

41

40

39

38

37

36

35

34

33

32

31

30

29

T406
BC848B

C445

47pF

C442

100p

C441
100p

C453
100p

C424

22pF

R412

15K

C421
470nF

C414
82pF

C402

47nF

C444
47pF

Q401
4MHz

R404

R419

2R2

R429

4K7

10K

C437

560pF

C450

33pF

C443
100p

R416

5K6

R434
4K7

R432
4K7

R431
XX R

+5V A

C415

2n2

R455

100R

R414
10K

L403
18uH

C416

10uF / 16V

R450
2K2

R438S

39pF

C412
39pF

C420
47nF

C409
4n7

R435

8K2

8K2

C413

R422

4K7

R405
2K7

R433

2K7

BC848

OPTIONEL

C446

100p

T402

R418
2R2

C405
10nF

C410

2u2 / 16V

+5V B

R423

10K

VSYNC

HSYNC

R454

100R

+8V

OPTIONEL

C455
100u / 16V

BUS B

STAT1

STAT2

OFF (ST-BY)

MUTE

ST-BY SPKR

V_LIN

L_L'

AV3 SVHS

MSP_RES

BUS A

BUS A

3 - 3

GRUNDIG Service Chassis 16.1

Tuner

AGC

SDA

SCL

R437
39K

C432
47pF

TU100
TUNER

R442

220R

C431
47pF

C433

1nF

1

AGC

R436

4K7

2

R441

220R

SCL4SDA5+5V6+5V7NC8+33V9IF110IF2

3

C435

10nF

BUS B

C438

560pF

C430

47uF

16V

+33V

C429

560pF

L401

18uH

GND4
GND3
GND2
GND1

11

+5V B

IF1

15
14
13
12

IF1

IF2

IF2

NF-Teil / AF Part

BUS B BUS B

SCL

SDA

X103

INTRC/QSS

BUS A BUS A

MSP_RES

1

2

3

4

5

6

Right

7

Left

8

9

STEREO_2_IN

C454

MUTE

ST-BY SPKR

R426

4k7

R427

2k7

+5V A

100u /
16V

R428
2k7

+8V

R443

4k7

R439
2k7

R430
2k7

T403

BC848

R354

2k2

C381

3.3n

C387

3.3n
R355

2k2

+13VA

R444

10k

R445
10k

BC848

R356

4k7

T404

R357
4k7

1u/16V

C425

C388
220n

C376

100n

C377
220n

C378
100n

In1-

C380

1.5n
In1+

In2-

C379

1.5n
In2+

Mode

Svr

8

6

9

12

10

11

C386

10u/16V

+13VA

Vcc

3

IC317

TDA8944J

2

Gnd

C384

C385

1000u/16V

100n

16

Out1+

4

R

Out1-

1

R

Out2+

17

L

Out2-

14

L

15

KABLO5B

C383
100n

R359

4R7/0.5W

C382

100n

R358

4R7/0.5W

X320

HS301
SES SOGUTCUSU

1

2

4

3

2

1

Right

Left

3 - 4

GRUNDIG Service Chassis 16.1

AV-Buchsen / AV Sockets

R154
75R

R174

75R

SCART

in

SCART

SK101

out

4

6

10

12

14

161820

R159

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

161820

R164

75R

R163
75R

R166
75R

21 19 17

330R

R161

330R

R160

100R
C150

1nF

R162

100R
C152

1nF

R165

1K
C154

220p

R167

1K

C151
1nF

C153
1nF

C155
470p

C157

470p

X102

12

11

10

9

8

7

R209

0R

R202

0R

6

5

4

3

2

1

STEREO_1_OUT

KABLO5A

1

2

3

R168

330R

5

7

8

9

R203
0R

11

R201

13

15

R208

330R

0R

21 19 17

R169

100R
C158

1nF

R171

100R
C160

1nF

R172

1K
C162

220p

R173

1K

C159
1nF

C161
1nF

C163
470p

C165
470p

BUS B

B_SCRT
STAT1

G_SCRT

R_SCRT
F_BLSC

R152

75R

CVBS_OUT_SC1
CVBS1

STAT2

CVBS_OUT_SC2

SC2 CVBS

C148
220p

C156

220p

R157

68R

R158
75R

220p

C149
220p

R153

68R

C164

BUS A

OPTION 2SC+FAV

SC2 CHR

OPTION

BUS B

OPTION 2SC+FAV

1

2

3

C193
100p

VIDEO

CHR

X104
SVHS

C189

100p

C194

10n

R177

47K

R178

47K

C167

100nF

R179

47K
R180

47K

C173

2.2uF
16V

C171

22nF

C195

BUS A

+8V

R176

R175
4K7

C172

22nF

1

2

3

4

5

6

7

C174

2.2uF
16V

8

10n

4K7

IC102

Y1

Y0

Z1

Z0

EN

VEE

VSS

MC14053BD

R181
0R

C170

10uF
16V

CONT_X

CONT_Y

CONT_Z

VDD

YOUT

XOUT

X1

X0

R205
0R

C168

100nF

C192

10nF

R206

0R

R207

0R

16

15

14

13

12

11

10

9

BUS A

ZOUT

SC2 CHR

3 - 5

SC2 CVBS

AV3 SVHS

YOUT

GRUNDIG Service Chassis 16.1

8

6
F

0

1

Chassis IC101 Teil 1 / Chassis IC 101 Part 1

BUS B

IF2

IF2

IF1

AGC

INTRC/QSS

CVBS_TXT

C188

10n

T109

BC848B

R185
100R

OPT. 2 . SCART

C187

10uF

R113

47R

1nF

R194

100R

C106

16V

R117

1K

R121

100R

C184
68pF

F102
T40.4

R195
0R

R193
2K2

R200
0R

R106

47R

BC848B

R196

C102

10nF

T101

BC848B

R127

1K

R186

10K

0R

D180

BA682

D181

BA682

+8V

C104
10nF

T104

C107

10uF

63V

R114

100R

R192

3K3

3K3

T105
BC848B

R107

47R

T102

R125

180R

R129
220R

10uF/63V

R190

BC848B

TABLE

C144

+5V B

C185

220nF

R105

C186

220nF

R191
10K

T108
BC848B

L103

1uH

C132
3n9

L106

Non L-L'

L105

TABLE

L107

TABLE

F101
TABLE

Non L-L'

CVBS_OUT_SC1

L_L'

CVBS_OUT_SC2

1uH

1

2

SAW02
TABLE

L104A

1uH

C131

820p

C112
820p

R104

TABLE

C169

1n

R124
150R

ZOUT

YOUT

3

CVBS1

B_SCRT

G_SCRT

R_SCRT

F_BLSC

1

L104
1uH

2

C140

10n

R131 330K

SAW01
TABLE

C111

10uF

25V

4

5

+5V B

R108

47R

1uF / 16V

3

+8V

C180

T103

R126

180R

C141

1uF / 16V

C137

C108

22nF

4

C109

330nF

L-L'

R142

220R

L101 10uH

27p

BC848B

10uF / 16V

5

C134

C191

10n

R102

150R

C113

47uF
16V

R120

1K

TOKO

+8V

C196

10n

C136

1uF / 16V

1uF / 16V

R183

100R

C1

47u/

C13

C16

22n

R1

10

BUS A

3 - 6

GRUNDIG Service Chassis 16.1

Chassis IC101 Teil 2 / Chassis IC 101 Part 2

BUS B

IC101

47u/16V

R102

150R

C113

47uF

16V

20

K

TOKO

C136

V

C138

F / 16V

C166

22nF

183

00R

C145

R184

100R

L-L'

C105
10uF / 16V

LC100

C176
100p

1uF / 16V

R189

100R

C122

100nF

C121

100nF
R182

100R

C143

C110

1nF

C114

47nF

R139
3K3

C123

47nF

C120

100nF

1uF / 16V

C101
1uF / 16V

C179

22n

10

11

12

13

14

15

16

17

18

C175
100p

19

20

C139

21

22

C177
100p

23

C200

68p
24

25

26

27

28

1

2

3

4

5

6

7

8

9

SIFIN1

SIFIN2

AGCSIFCAP

IFVREF

AGCPIFCAP

PIFIN1

PIFIN2

AGC

IFPLL

GNDIF

QSS

VCCIF

INTCVBSO

EXTAUDIN

PIFLC1

PIFLC2

VCC2

CVBSIN1

GND2

CVBSIN2

BS

Y_CVBSIN3

CHR

APR

B_EXT

G_EXT

R_EXT

FB_EXT

STV2246

FMCAP

AUDIOOUT

LBF_SSC

HOUT

BCLSAF

CVBSO1

VAMP

XTAL1

XTAL2

XTAL3

FBOSD

ICATH

R_OUT

G_OUT

B_OUT

GND0

VCCD

SDA

SCL

SLPF

VERT

VCC1

GND1

CLPF

ROSD

GOSD

BOSD

NC

56

55

54

53

52

51

50

C178

560p

49

48

47

46

45

44

43

42

41

40

39

38

37

36

35

34

33

32

31

30

29

C115

47nF

R118

100R
R119

100R

R137

270R
R136

270R
R135

270R

C128

4n7

Q101

4.43MHz

Q102

3.58MHz

C116

47nF

R138
47K

R122

8K2

C124

100nF

C117
47nF

C103

1uF / 16V

+8V

C129
4n7

C119

100nF

C118

47nF

R112

1K

+8V

C127

100uF / 16V

C130
2u2
16V

C135
220uF

16V

R140

1K

1

2

3

4

5

6

L102

10uH

C133

22pF

R133
2K2

R132

2K2

R116

470R

R128

1K2

D103

R101

27K

C125
1uF / 16V

X101

CRT_RGB_OUT

+5V B

R134
8K2

C126

22uF / 16V

R188
330K

R123
5K6

R146
1K

R145
1K

R144
1K

R187

330K

R115

5K6

R109

470R

R110

470R

R111

470R

R130

56K

1N4148

D107

+5V B

47pF

47pF

47pF

47pF

SDA
SCL

+8V

C142
10uF / 16V

LFB

H_OUT

V_OUT

BCL

FLAYBACK

CVBS_TXT

CVBS_TXT/U

V_AMP

FBOSD

C197

ROSD

C198

GOSD

C199

BOSD

C201

BUS A

3 - 7

Ablenkung / Deflection

R569

4R7

INV

9

BUFFER

8

RAMP

7

GND

6

VREF_DEC

5

H_ADJ

4

TRIG

3

OUT

2

PWR

1

VCC10FLYBACK

11

IC501

TDA8174AW

R501

2R2 0.5W

R502
470R

R503

22R

R508

1K8

R516

1K6

R509

TABLE

R519
1K

R506
150K

R504

1K

R513

10K

R527
TABLE

R505
150K

R511

2K7

R512

1K8

R510
TABLE

R524
3K9

R520
1K

R521
100K

R522

8K2

R523
2K2

C506

10uF

C505

1uF

C510

100uF

C503
1000uF / 35V

C504

220uF / 25V

C512

1uF

C511

1uF / 16V

T501
BC848B

T502
BC848B

D502
RF2007

C501
220nF

1

2

X501

VER_DEFL

R518

82K

C509

470pF

C508

15nF

C513
100nF

C508A

33nF

0.5W

0.5W

16V

TABLE

16V

16V

50V

D503

EHT - 29KV

600M

FOCUS

UG2

3

10

5

2

6 7

9

11

1

TR552

DST 12.3

C554

390nF

C566
560pF

C555

6.8nF

C556
330nF

C561

1n 1kV

C563
100nF

C553

1uF / 160V

C552

10uF

C560

10uF

C557

470uF

C564
TABLE

R558

10K

R557
470R

R555
47R

R551
33R

R554

82R 3W

R553

330R

R559

3.3R

D552

BA157

D556

BA157

D553

RGP10J

D560

RGP10J

D559

D557
1N4148

D558

R552
1K

R565

10K

R526

22K

T551

STX112

T552

BU808DFI

L551

LIN.HOR.

L502

6.8uH

1

2

3

4

5

X551

HOR_DEFL

R560

TABLE

50V

TABLE

0.5W

0.5W

250V

2W

250V

0.5W

R568
680R

C558
10nF

C562

100nF

C570

10nF

U CRT

Uv.bes

Uv.ref

BCL

GND2

Text

Text

R562

10K

R563
TABLE

R564

680R

1

2

3

4

X552

CRT_HT_OUT

250V

50V

16V

LINK

500V

HEATER

C571
47u/16v

C565

xx

C551

2n2

OPTIONAL

C183

10u/50V

C190

2.2uF/16V

R198

47K

R199

10K

R150
470K

R149

100K

R151
100K

T110

BC848

T111

BC848

+5V A

+8V

+13V

+13V

+13V

FLAYBACK

FLAYBACK

HSYNC

VSYNC

V_AMP

BCL

H_OUT

LFB

V_LIN

BUS B

U1

V_OUT

BUS B

BUS A

BUS A

Components designated by the safety symbol should only be replac ed by original parts produced and proofed by the manufacturer

.
Sicherheitsbautelle im Sinn der sicherheitsbestimmung. Diese Teile durfen nur durch Originalteile ersetzt werden.
Contrassegno di sicurezza. I componenti devono, corrispondere a ricambi originali e devono essere montati a regola d

’arte.

GRUNDIG Service Chassis 16.1

3 - 8

GRUNDIG Service Chassis 16.1

Chassis Ansicht auf die Bestückungsseite / View on component side

3 - 9

GRUNDIG Service Chassis 16.1

Chassis Ansicht auf die Bestückungsseite / View on component side

3 - 10

GRUNDIG Service Chassis 16.1

Chassis Ansicht auf die Lötseite / View on solder side

3 - 11

GRUNDIG Service Chassis 16.1

Chassis Ansicht auf die Lötseite / View on solder side

3 - 12

Bildrohrplatte / CRT Panel

4

5

6

78

9

10

11

12

n.c.

G1

GREEN

G2

RED

HT

HT

BLUE

GND

GND

X703

CRT SOKET

1

3
4
5
6

2

X701
RGB

crt

R702

220R

C701

47p

T701

BF422

R710
15k

155V

R711
390R

crt

C703
390p

R712
100R

crt

R713

2.7k

8V_

D702
1N4148

C705

470p

T702

BF421

R714
1k

R703

220R

C706

47p

T703

BF422

R715
15k

155V

R716

390R

crt

C707
390p

R717
100R

crt

R718

2.7k

8V_

D703
1N4148

C708
470p

T704
BF421

R719
1k

R704
220R

C709

47p

T705

BF422

R720

15k

155V

R721
390R

crt

C710

390p

R722
100R

crt

R723

2.7k

8V_

D704
1N4148

C711

470p

T706
BF421

R724

1k

8V_

R725

1.5K

R726

1.5K

R727

1.5K

C712

2.2n

C713

100n/250V

crt

155V

1

2

3

X702

CRT

G2

AQUA

SMPS

R701

100R

R706

220R

R707
220R

R709
220R

C702
10u/250V

D701
1N4007

155V

Blue

Green

Red

Icatch

R728

100k 1/2W

CRT BOARD

L701

10uF

GRUNDIG Service Chassis 16.1

3 - 13

GRUNDIG Service Chassis 16.1

AV-Modul (Option) / AV Module (Option)

AV-MODUL (OPTIONAL)

3 - 14

Stereo Modul / Stereo Module

AUD_CLO

1

NC1

2

NC2

3

DCTROUT1

4

DCTRO0

5

ADR_SEL

6

STBYQ

7

NC3

8

SCL

9

SDA

10

I2S_CL

11

I2S_WS

12

I2SDAOUT

13

I2SDAIN1

14

ADR_DA

15

ADR_WS

16

ADR_CL

17

DVSUP

18

DVSS

19

I2SDAIN2

20

NC4

21

NC5

22

NC6

23

RESETQ

24

DACA_R

25

DACA_L

26

VREF2

27

DACM_R

28

DACM_L

29

DAC_C

30

DAC_SUB

31

DAC_S32SC2_O_R

33

SC2_O_L

34

VREF1

35

SC1_O_R

36

SC1_O_L

37

CAPL_A

38

AHVSUP

39

CAPL_M

40

AHVSS

41

AGNDC

42

SC4_I_L

43

SC4_I_R

44

ASG4

45

SC3_I_L

46

SC3_I_R

47

ASG2

48

SC2_I_L

49

SC2_I_R

50

ASG1

51

SC1_I_L

52

SC1_I_R

53

VREFTOP

54

MONO_IN

55

AVSS

56

AVSUP

57

ANA_IN1+

58

ANA_IN-

59

ANA_IN2+

60

TESTEN

61

XTAL_IN

62

XTAL_OUT

63

NC7

64

IC316

MSP34XX

C342

2.2nF

C343

2.2nF

C348

100nF

C334

1nF

C335

1nF

C332

1nF

C354

10nF

C355

10nF

C357

100pF

C333
1nF

C349

100nF

C352

1.5pF

C353

1.5pF

C324

1nF

C325

1nF

C347

100nF

OUT

IN

GND

IC315
78L05

C344

47uF

C317

47nF

C323

1nF

C345

47uF

C356
33nF

R321

100R

R322 100R

MSP_RES

R323

220R

R324

1K

C330

1nF

C331

1nF

R327

1K

C328

1nF

C329

1nF

R326

1K

C326

1nF

C327

1nF

R325

1K

T318
BC858B

T319
BC858B

R318

3.3K

R315
330R

R319

3.3K

R316
330R

C338

100uF / 16V

C339

100uF / 16V

C319
1nF

C320
1nF

1

2

3

X316

HEADPHONE

C315

100uF

C316

47nF

C318

1nF

INTRC/QSS

RIGHT

+8V A

+8V A

LEFT

+8V C

T317
BC858B

R317

3.3K

T320
BC858B

R320

3.3K

C322

1nF

C321

1nF

C371

47uF / 16V

C370

47uF / 16V

C369

47uF / 16V

C368

47uF / 16V

C367

10uF / 63V

C366

10uF / 63V

C365

3.3uF

C362

330nF

C363

330nF

C364

1nF

R328

470R

C361

4.7uF / 16V

C360

4.7uF / 16V

C359

4.7uF / 16V

C358

4.7uF / 16V

C372

10uF

1

2

3

X318

CINCH

1

2

3

4

5

6

7

8

9

10

11

12

X317

MSP_RES

SCL

SDA

+8V A

C340

330nF

C341

330nF

Q315

18.432MHz

INTRC/QSS

16V

MONOIN

63V

50V
T316
BC558

T315

BC558

16V

16V

+8V C

RIGHT

LEFT

R

L

R335

0R

R345

470R

1

2

3

4

5

6

7

8

9

X315

STEREO_2_IN

R338
0R

R337

0R

Optional

C373
33nF

C336

47pF

C337

47pF

RIGHT

LEFT

C346

220pF

C375
220nF

C374
100nF

3 - 15

GRUNDIG Service Chassis 16.1

GRUNDIG Service Chassis 16.1

Stereo Modul / Stereo Module

3 - 16

ǵ

GRUNDIG Service Chassis 16.1

ǵ

4 - 1

Ersatzteilliste
Spare Parts List

1 / 2004

POS. NR. ABB. MATERIAL-NR. ANZ. BEZEICHNUNG DESCRIPTION
POS. NO. FIG. PART NUMBER QTY.

720126003000 ARCANCE 55 FLAT MF 55-2401/IT ARCANCE 55 FLAT MF 55-2401/IT

0001.000 759550947800 GEHAEUSEVORDERTEIL SILBER FRONT CABINET SILVER

0003.000 759550948900 RUECKWAND SILBER BACK COVER SILVER

0004.000 759550938300 KNOPF NETZ KNOB POWER

0006.000 759550938900 BUCHSENABDECKUNG JACK COVER

0007.000 759550949100 KNOPF VOLUMEN KNOB VOLUME

0010.000 759550950500 LAUTSPRECHER 8 OHM 7/10 W SPEAKER 8 OHM 7/10 W

0012.000 759550949000 KNOPF PROGRAMM KNOB PROGRAM

0013.000 759550456500 SPULE ENTMAGNETISIERUNG 21" COIL DEGAUSSING 21"

0014.000 S 759550450200 NETZKABEL POWER CABLE

0015.000 S 759550920200 NETZSCHALTER 4 A 100-250V POWER SWITCH 4 A 100-250V

0020.000 759550947700 GRUNDIG LOGO GRUNDIG LOGO

0025.000 759550947900 BILDROEHRE VC A51ELD032X001 PICTURE TUBE VC A51ELD32X001

0027.000 720117132900 FERNBEDIENUNG TP160 REMOTE CONTROL TP160

0028.000 S 275990121100 X LP-CHASSISMODUL CHASSISBOARD

0040.000 275990061900 LP-NICAM MODUL NICAM BOARD

0070.000 275990033500 LP-BEDIENMODUL CONTROLBOARD

0090.000 275990121400 LP-AV3/KLK MODUL AV3/KLK BOARD

720117020500 BEDIENUNGSANLEITUNG I INSTRUCTION MANUAL I
720100490000 SERVICE MANUAL D/GB SERVICE MANUAL D/GB

ARCANCE 55 FLAT MF 55-2401/IT

MATERIAL-NR. / PART NO.: 720126003000
BESTELL-NR. / ORDER NO.: GBB5600 SILBER/SILVER

d©

SILBER SILVER
KEIN E-TEIL NO SPARE PART

KEIN E-TEIL NO SPARE PART

X = SIEHE GESONDERTE E-LISTE X = SEE SEPARATE PARTS LIST

TV

Ersatzteilliste
Spare Parts List

1 / 2004

POS. NR. ABB. MATERIAL-NR. ANZ. BEZEICHNUNG DESCRIPTION
POS. NO. FIG. PART NUMBER QTY.

720126003100 ARCANCE 55 FLAT MF 55-2401/5 TOP ARCANCE 55 FLAT MF 55-2401/5 TOP

0001.000 759550950200 GEHAEUSEVORDERTEIL SILBER FRONT CABINET SILVER

0003.000 759550948900 RUECKWAND SILBER BACK COVER SILVER

0004.000 759550950600 KNOPF NETZ KNOB POWER

0005.000 759550938900 BUCHSENABDECKUNG JACK COVER

0006.000 759550950500 LAUTSPRECHER 8 OHM 7/10 W SPEAKER 8 OHM 7/10 W W

0011.000 759550950400 KNOPF VOLUMEN KNOB VOLUME

0012.000 759550950300 KNOPF PROGRAMM KNOB PROGRAM

0013.000 759550456500 SPULE ENTMAGNETISIERUNG 21" COIL DEGAUSSING 21"

0014.000 S 759550450200 NETZKABEL POWER CABLE

0015.000 S 759550920200 NETZSCHALTER 4 A 100-250V POWER SWITCH 4 A 100-250V

0020.000 759550947700 GRUNDIG LOGO GRUNDIG LOGOR

0021.000 759550925300 FEDER KNOPF NETZ SPRING KNOB POWER

0025.000 759550947900 BILDROEHRE VC A51ELD032X001 PICTURE TUBE VC A51ELD32X001

0027.000 720117132900 FERNBEDIENUNG TP160 REMOTE CONTROL TP160

0028.000 S 275990121100 X LP-CHASSISMODUL CHASSISBOARD

0040.000 275990061900 LP-NICAM MODUL NICAM BOARD

0070.000 275990033600 LP-BEDIENMODUL CONTROLBOARD

0090.000 275990121400 LP-AV3/KLK MODUL AV3/KLK BOARD

720117018500 BEDIENUNGSANLEITUNG D/GB/NL/DK INSTRUCTION MANUAL D/GB/NL/DK
720117018600 BEDIENUNGSANLEITUNG N/S/E/P INSTRUCTION MANUAL N/S/E/P
720100490000 SERVICE MANUAL D/GB SERVICE MANUAL D/GB

d©

KEIN E-TEIL NO SPARE PART

KEIN E-TEIL NO SPARE PART

X = SIEHE GESONDERTE E-LISTE X = SEE SEPARATE PARTS LIST

ARCANCE 55 FLAT MF 55-2401/5 TOP

MATERIAL-NR. / PART NO.: 720126003100
BESTELL-NR. / ORDER NO.: GBB4600 SILBER/SILVER

TV

Es gelten die Vorschriften und Sicherheitshinweise
gemäß dem Service Manual "Sicherheit", Mat.-Num­mer 720108000000, sowie zusätzlich die eventuell ab­weichenden, landesspezifischen Vorschriften!

The regulations and safety instructions shall be valid

!

as provided by the "Safety" Service Manual, part
number 720108000000, as well as the respective

( ! )

national deviations.

ÄNDERUNGEN VORBEHALTEN / SUBJECT TO ALTERATION

Es gelten die Vorschriften und Sicherheitshinweise
gemäß dem Service Manual "Sicherheit", Mat.-Num­mer 720108000000, sowie zusätzlich die eventuell ab­weichenden, landesspezifischen Vorschriften!

The regulations and safety instructions shall be valid

!

as provided by the "Safety" Service Manual, part
number 720108000000, as well as the respective

( ! )

national deviations.

ÄNDERUNGEN VORBEHALTEN / SUBJECT TO ALTERATION

Ersatzteilliste
Spare Parts List

GRUNDIG Service Chassis 16.1

ǵ

TV

4 - 2

1 / 2004

POS. NR. ABB. MATERIAL-NR. ANZ. BEZEICHNUNG DESCRIPTION
POS. NO. FIG. PART NUMBER QTY.

720126002900 ARCANCE 55 FLAT MF 55-2401/7 TOP ARCANCE 55 FLAT MF 55-2401/7 TOP

0001.000 759550943400 GEHAEUSEVORDERTEIL FRONT CABINET

0003.000 759550948900 RUECKWAND SILBER BACK COVER SILVER

0004.000 759550950600 KNOPF NETZ KNOB POWER

0006.000 759550938900 BUCHSENABDECKUNG JACK COVER

0007.000 759550950300 KNOPF PROGRAMM KNOB PROGRAM

0008.000 759550950400 KNOPF VOLUMEN KNOB VOLUME

0010.000 759550950500 LAUTSPRECHER 8 OHM 7 W SPEAKER 8 OHM 7 W

0013.000 759550456500 SPULE ENTMAGNETISIERUNG 21" COIL DEGAUSSING 21"

0014.000 S 759550450200 NETZKABEL POWER CABLE

0015.000 S 759550920200 NETZSCHALTER 4 A 100-250V POWER SWITCH 4 A 100-250V

0020.000 759550947700 GRUNDIG LOGO GRUNDIG LOGO

0025.000 759550947900 BILDROEHRE VC A51ELD032X001 PICTURE TUBE VC A51ELD32X001

0027.000 720117132900 FERNBEDIENUNG TP160 REMOTE CONTROL TP160

0028.000 S 275990120800 X LP-CHASSISMODUL CHASSISBOARD

0040.000 275990061900 LP-NICAM MODUL NICAM BOARD

0070.000 275990033600 LP-BEDIENMODUL CONTROLBOARD

0090.000 275990121400 LP-AV3/KLK MODUL AV3/KLK BOARD

720117020000 BEDIENUNGSANLEITUNG INSTRUCTION MANUAL

720100490000 SERVICE MANUAL D/GB SERVICE MANUAL D/GB

d©

SILBER SILVER
KEIN E-TEIL NO SPARE PART

KEIN E-TEIL NO SPARE PART

GB/FIN/GR/PL/CZ/H GB/FIN/GR/PL/CZ/H

X = SIEHE GESONDERTE E-LISTE X = SEE SEPARATE PARTS LIST

ARCANCE 55 FLAT MF 55-2401/7 TOP

MATERIAL-NR. / PART NO.: 720126002900
BESTELL-NR. / ORDER NO.: GBB6500 SILBER/SILVER

Es gelten die Vorschriften und Sicherheitshinweise
gemäß dem Service Manual "Sicherheit", Mat.-Num­mer 720108000000, sowie zusätzlich die eventuell ab­weichenden, landesspezifischen Vorschriften!

The regulations and safety instructions shall be valid

!

as provided by the "Safety" Service Manual, part
number 720108000000, as well as the respective

( ! )

national deviations.

ÄNDERUNGEN VORBEHALTEN / SUBJECT TO ALTERATION

4 - 3

ǵ

Ersatzteilliste
Spare Parts List

1 / 2004

POS. NR. ABB. MATERIAL-NR. ANZ. BEZEICHNUNG DESCRIPTION
POS. NO. FIG. PART NUMBER QTY.

275990120800 LP-CHASSISMODUL CHASSISBOARD

POS. NR. MATERIAL-NR. BEZEICHNUNG
POS. NO. PART NUMBER DESCRIPTION

C 901 S 759550949200 ELKO 10 UF/16V
C 902 S 759550949300 KONDES. 220 NF/275 V AC
C 915 S 759550949500 KONDENS 100NF/250 V
C 920 S 759550949700 KONDENS 1 NF / 50 V

D 103 833021514800 MELF DIODE 1N4148
D 107 830953414900 MELF-DIODE LL 4148 TFK/ITT
D 502 725511823600 DIODE RF2007 I0
D 503 833021514800 MELF DIODE 1N4148
D 552 830920100500 DIODE BA157 AV619 -AMMO
D 553 S 830956550700 DIODE RGP10J/1N4937 MOT/GP
D 553 830956550700 DIODE RGP10J/1N4937 MOT/GP
D 556 830920100500 DIODE BA157 AV619 -AMMO
D 557 830953414900 MELF-DIODE LL 4148 TFK/ITT

D 558 833021514800 MELF DIODE 1N4148
D 559 833021514800 MELF DIODE 1N4148
D 560 830920100500 DIODE BA157 AV619 -AMMO
D 701 830921512700 DIODE 1 N 4007 -GA
D 702 833021514800 MELF DIODE 1N4148
D 703 833021514800 MELF DIODE 1N4148
D 704 833021514800 MELF DIODE 1N4148
D 901 725511823600 DIODE RF2007
D 902 725511823600 DIODE RF2007
D 903 725511823600 DIODE RF2007
D 904 725511823600 DIODE RF2007
D 905 830956550700 DIODE RGP10J/1N4937 MOT/GP
D 906 833021514800 MELF DIODE 1N4148
D 907 833021514800 MELF DIODE 1N4148
D 908 833021514800 MELF DIODE 1N4148
D 909 833021514800 MELF DIODE 1N4148
D 950 759880511100 DIODE RGP15J
D 951 759550944700 DIODE RGP 50D

F 101 759550951800 FILTER TPT02B

IC 101 759550951900 IC STV2249C
IC 102 759550951600 IC MC14053BD
IC 315 759550945000 IC L78L05 ACZ
IC 316 759550939600 IC MSP3410G B8 V3
IC 317 759550951400 IC TDA 8944J
IC 402 759550951500 IC ST92T195D7B1
IC 501 830533817500 IC TDA8174AW
IC 901 759550951200 IC TDA 16847
IC 951 759550924900 IC KA 317 TU
IC 953 759550945000 IC L78L05 ACZ

d©

KEIN E-TEIL NO SPARE PART

POS. NR. MATERIAL-NR. BEZEICHNUNG
POS. NO. PART NUMBER DESCRIPTION

L 101 759862006100 DR 0309 10UH 4-253T-15020
L 102 759862006100 DR 0309 10UH 4-253T-15020
L 103 759550541900 SMD SPULE 1UH K0805
L 104 759550541900 SMD SPULE 1UH K0805
L 105 759550952100 SPULE 5.6 UH K
L 106 759550541900 SMD SPULE 1UH K0805
L 403 759550541800 SMD SPULE 22UH 20% 0805
L 404 759550451700 SMD SPULE 18UH K/12
L 502 S 759550949800 SPULE 6.8 UH
L 551 759550950800 SPULE 120 UH
L 701 759550451500 SPULE 10UH R0814
L 901 S 759550947200 FILTER 18 MH
L 950 759550922600 SPULE 50UH

LC 100 759550952000 SPULE 38.9 HEX

P 901 759550951100 ESTR 5K

Q 101 759880768100 QUARZ 4.433619MHZ
Q 102 759813163400 QUARZ 3,579545 MHZ HC 18
Q 315 759550923000 QUARZ 18.432MHZ
Q 401 759550921200 QUARZ 4 MHZ

R 559 S 759550949900 WIDERST 3.3 OHM 2 W
R 901 S 759550453200 NTC WIDERST 5,1OHM
R 902 S 759550457500 PTC 9OHM 2PIN (R607)
R 920 S 759550949600 WIDERST 75 OHM / 1/4 W

S 901 S 831562150300 SI 5X20 T2,5A H 250V
S 902 S 727006351900 SICHERUNG SI 5X20 T4A

SAW 1 759550951700 FILTER OFW K2966M

SK 102 759550926000 EURO AV BUCHSE

T 100 759550950700 TUNER ENV57D60G ASIMETRIK

T 101 830100484800 SMD TRANS BC848B/ BC847B P
T 102 830100484700 SMD TRANS BC847B
T 103 830100484700 SMD TRANS BC847B
T 315 830320555700 TRANS.BC 557 B GEG.AMMO-PAC
T 316 830320555700 TRANS.BC 557 B GEG.AMMO-PAC
T 317 830320555700 TRANS.BC 557 B GEG.AMMO-PAC
T 318 830320555700 TRANS.BC 557 B GEG.AMMO-PAC
T 319 830320555700 TRANS.BC 557 B GEG.AMMO-PAC
T 320 830320555700 TRANS.BC 557 B GEG.AMMO-PAC
T 402 830100484800 SMD TRANS BC848B/ BC847B P
T 403 830100484800 SMD TRANS BC848B/ BC847B P

ÄNDERUNGEN VORBEHALTEN / SUBJECT TO ALTERATION

LP-CHASSISMODUL

MATERIAL-NR. / PART NO.: 275990120800

TV

CHASSISBOARD

POS. NR. MATERIAL-NR. BEZEICHNUNG
POS. NO. PART NUMBER DESCRIPTION

T 404 830100484800 SMD TRANS BC848B/ BC847B P
T 406 830100484800 SMD TRANS BC848B/ BC847B P
T 407 830100484800 SMD TRANS BC848B/ BC847B P
T 408 830100484800 SMD TRANS BC848B/ BC847B P
T 501 830100484800 SMD TRANS BC848B/ BC847B P
T 502 830100484800 SMD TRANS BC848B/ BC847B P
T 551 759550951000 TRANS STX112
T 552 759550453900 TRANS BU808DFI
T 701 759880586100 TRANS. 2 SC 2482 C
T 702 830340142100 TRANS BF421 PHI/MOT/TOS
T 703 759880586100 TRANS. 2 SC 2482 C
T 704 830340142100 TRANS BF421 PHI/MOT/TOS
T 705 759880586100 TRANS. 2 SC 2482 C
T 706 830340142100 TRANS BF421 PHI/MOT/TOS
T 901 759550951300 TRANS TRN STP4NK60ZFP
T 902 830327332700 TRANS BC327-25 AV330 ­T 906 830100484800 SMD TRANS BC848B/ BC847B P
T 950 830220018800 TRANS BC337-25 SIE/PHI/TFK/

TR 552 S 759550950000 TRAFO FBT 21PF
TR 901 S 759550949400 TRAFO SMT 21PFF

ZD 407 759550580900 SMD Z-DIODE MM5,1V
ZD 570 759550453400 Z- DIODE UZT33V
ZD 901 759550923500 DIODE ZPD5.1
ZD 952 759540423100 DIODE EL-8L,INFRARED EMIT

Es gelten die Vorschriften und Sicherheitshinweise
gemäß dem Service Manual "Sicherheit", Mat.-Num­mer 720108000000, sowie zusätzlich die eventuell ab­weichenden, landesspezifischen Vorschriften!

POS. NR. MATERIAL-NR. BEZEICHNUNG
POS. NO. PART NUMBER DESCRIPTION

The regulations and safety instructions shall be valid

!

as provided by the "Safety" Service Manual, part
number 720108000000, as well as the respective

( ! )

national deviations.

ÄNDERUNGEN VORBEHALTEN / SUBJECT TO ALTERATION

GRUNDIG Service Chassis 16.1

Ersatzteilliste
Spare Parts List

GRUNDIG Service Chassis 16.1

ǵ

TV

4 - 4

1 / 2004

POS. NR. ABB. MATERIAL-NR. ANZ. BEZEICHNUNG DESCRIPTION
POS. NO. FIG. PART NUMBER QTY.

275990121100 LP-CHASSISMODUL CHASSISBOARD

POS. NR. MATERIAL-NR. BEZEICHNUNG
POS. NO. PART NUMBER DESCRIPTION

C 901 S 759550949200 ELKO 10 UF/16V
C 902 S 759550949300 KONDES. 220 NF/275 V AC
C 915 S 759550949500 KONDENS 100NF/250 V
C 920 S 759550949700 KONDENS 1 NF / 50 V

D 107 830953414900 MELF-DIODE LL 4148 TFK/ITT
D 502 725511823600 DIODE RF2007 I0
D 503 833021514800 MELF DIODE 1N4148
D 552 830920100500 DIODE BA157 AV619 -AMMO
D 553 S 830956550700 DIODE RGP10J/1N4937 MOT/GP
D 556 830920100500 DIODE BA157 AV619 -AMMO
D 558 833021514800 MELF DIODE 1N4148
D 559 833021514800 MELF DIODE 1N4148
D 560 830920100500 DIODE BA157 AV619 -AMMO
D 701 830921512700 DIODE 1 N 4007 -GA
D 901 725511823600 DIODE RF2007
D 902 725511823600 DIODE RF2007
D 903 725511823600 DIODE RF2007
D 904 725511823600 DIODE RF2007
D 905 830956550700 DIODE RGP10J/1N4937 MOT/GP
D 907 833021514800 DIODE 1N4148
D 908 833021514800 DIODE 1N4148
D 909 833021514800 DIODE 1N4148
D 951 759550944700 DIODE RGP 50D

ZD 901 759550923500 DIODE ZPD 5.1 V
ZD 952 7595404232000 DIODE MTZJ5.6B

F 101 759550948800 FILTER TPSRD5M50W00
F 102 759550950100 FILTER MKT40.4MA110P-TF01

IC 101 830512524600 IC STV2246 STM
IC 315 759550945000 IC L78L05 ACZ
IC 316 759550939600 IC MSP3410G B8 V3
IC 501 830533817500 IC TDA8174AW
IC 901 759550947300 IC TDA 16847
IC 951 759550924900 IC KA 317 TU
IC 953 759550945000 IC L78L05ACZ

L 104 759550541900 SPULE 1 UH K
L 401 759550451700 SPULE 18 UH K
L 402 759550451700 SPULE 18 UH K
L 403 759550541800 SPULE 22 UH 20 %
L 404 759550451700 SPULE 18
L 502 S 759550949800 SPULE 6.8 UH
L 551 759550950800 SPULE 120 UH
L 701 759550451500 SPULE 10UH R0814
L 901 S 759550947200 FILTER 18 MH

Es gelten die Vorschriften und Sicherheitshinweise
gemäß dem Service Manual "Sicherheit", Mat.-Num­mer 720108000000, sowie zusätzlich die eventuell ab­weichenden, landesspezifischen Vorschriften!

d©

KEIN E-TEIL NO SPARE PART

POS. NR. MATERIAL-NR. BEZEICHNUNG
POS. NO. PART NUMBER DESCRIPTION

L 950 759550922600 SPULE 50UH

P 901 759550951100 ESTR. 5 K

Q 315 759550926200 QUARZ 18.432 MHZ
Q 401 759550921200 QUARZ 4 MHZ

R 559 S 759550949900 WIDERST 3.3 OHM 2 W
R 901 S 759550453200 NTC WIDERST 5,1OHM
R 902 S 759550457500 PTC 9OHM 2PIN (R607)
R 920 S 759550949600 WIDERST 75 OHM / 1/4 W

S 901 S 831562150300 SI 5X20 T2,5A H 250V
S 902 S 727006351900 SICHERUNG SI 5X20 T4A

SK 102 759550926700 EURO AV-BUCHSE

T 100 759550950700 TUNER ENV57D60G3 ASIMETRIK
T 101 830100484800 SMD TRANS BC848B/ BC847B P
T 102 830100484700 SMD TRANS BC847B
T 103 830100484700 SMD TRANS BC847B
T 104 830100484800 SMD TRANS BC848B/ BC847B P
T 315 830320555700 TRANS.BC 557 B GEG.AMMO-PAC
T 316 830320555700 TRANS.BC 557 B GEG.AMMO-PAC
T 317 830100685700 SMD-TRANS.BC 857 C
T 318 830100685700 SMD-TRANS.BC 857 C
T 319 830100685700 SMD-TRANS.BC 857 C
T 320 830100685700 SMD-TRANS.BC 857 C
T 402 830100484800 SMD TRANS BC848B/ BC847B P
T 501 830100484800 SMD TRANS BC848B/ BC847B P
T 502 830100484800 SMD TRANS BC848B/ BC847B P
T 551 759550951000 TRANS STX112
T 552 759550453900 TRANS BU808DFI
T 701 759880586100 TRANS. 2 SC 2482 C
T 702 830222042100 TRANS.BF 421 SIE E6323/VAL/
T 703 759880586100 TRANS. 2 SC 2482 C
T 704 830222042100 TRANS.BF 421 SIE E6323/VAL/
T 705 759880586100 TRANS. 2 SC 2482 C
T 706 830222042100 TRANS.BF 421 SIE E6323/VAL/
T 902 830327332700 TRN BC327-25
T 950 830327332700 TRN BC327-25
T 906 830100484800 SMD TRANS BC848B/ BC847B P

TR 552 S 759550950000 TRAFO FBT 21PF
TR 901 S 759550949400 TRAFO SMT 21PFF

ZD 407 759550580900 SMD Z-DIODE MM5,1V
ZD 570 759550453400 Z- DIODE UZT33V

The regulations and safety instructions shall be valid

!

as provided by the "Safety" Service Manual, part
number 720108000000, as well as the respective

( ! )

national deviations.

ÄNDERUNGEN VORBEHALTEN / SUBJECT TO ALTERATION

LP-CHASSISMODUL

MATERIAL-NR. / PART NO.: 275990121100

CHASSISBOARD