Greenlee 690-22, 690 User Manual
INSTRUCTION MANUAL
690 and 690-22
Power Fishing Systems
Includes Serial Number AAR 3800 and higher (120 volt model)
Includes Serial Number AAT 00500 and higher (220 volt model)
Read and understand all of the instructions and
safety information in this manual before operating
or servicing this tool.
Register this product at www.greenlee.com
99900530 © 2010 Greenlee Textron Inc. IM 1283 REV 5 1/10
690 and 690-22 Power Fishing Systems
Table of Contents
Description .................................................................... 2
Safety ............................................................................ 2
Purpose of this Manual ................................................. 2
Important Safety Information .....................................3–4
Grounding Instructions .................................................. 4
Identication .................................................................. 5
Specications ................................................................ 5
Setup ............................................................................. 6
Operation ....................................................................6–8
Maintenance .................................................................. 8
Troubleshooting ............................................................. 9
Illustrations and Parts Lists ....................................10–13
Wiring Diagram ............................................................ 14
Description
The Greenlee 690 and 690-22 Power Fishing Systems
are intended to “sh,” or route, nylon shing line through
1/2" to 4" conduit. Optional accessories are also
available for shing through 5" and 6" conduit, and for
clean-up vacuuming.
This tool is intended for commercial use.
Safety
Safety is essential in the use and maintenance of
Greenlee tools and equipment. This instruction manual
and any markings on the tool provide information for
avoiding hazards and unsafe practices related to the
use of this tool. Observe all of the safety information
provided.
Purpose of this Manual
This manual is intended to familiarize personnel with the
safe operation and maintenance procedures for the following Greenlee products:
• 690 Serial Number AAR 001 and higher
(120 volt model)
• 690-22 Serial Number AAT 001 and higher
(220 volt model)
Keep this manual available to all personnel.
Replacement manuals are available upon request at no
charge at www.greenlee.com.
Do not discard this product or throw away!
For recycling information, go to www.greenlee.com.
All specications are nominal and may change as design
improvements occur. Greenlee Textron Inc. shall not be liable for
damages resulting from misapplication or misuse of its products.
Mighty Mouse is a registered trademark of Greenlee Textron Inc.
KEEP THIS MANUAL
Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070
2
690 and 690-22 Power Fishing Systems
IMPORTANT SAFETY INFORMATION
SAFETY
ALERT
SYMBOL
This symbol is used to call your attention to hazards
or unsafe practices which could result in an injury or
property damage. The signal word, dened below,
indicates the severity of the hazard. The message
after the signal word provides information for preventing or avoiding the hazard.
Immediate hazards which, if not avoided, WILL result
in severe injury or death.
Do not allow to be used as a toy. Close attention is •
necessary when used by or near children.
Use only as described in this manual. Use only •
manufacturer’s recommended attachments.
Do not put any object into openings. Do not use •
with any opening blocked; keep free of dust and
debris that may reduce air ow.
Turn power OFF before unplugging.•
Use extra care when cleaning on stairs.•
Keep loose clothing and all parts of the body away •
from openings and moving parts.
Failure to observe these warnings could result in
severe injury or death.
Hazards which, if not avoided, COULD result in
severe injury or death.
Hazards or unsafe practices which, if not avoided,
MAY result in injury or property damage.
Read and understand all of the
instructions and safety information
in this manual before operating or
servicing this tool.
Failure to observe this warning will
result in severe injury or death.
Do not use this tool in a hazard-
ous environment, or use this tool
to vacuum up anything hazardous.
Hazards include ammable liquids,
gases, or other materials. Such use
can result in a re or explosion.
Failure to observe this warning will
result in severe injury or death.
Electric shock hazard:
Do not leave unit unattended when •
plugged in. Unplug from recep-
tacle when not in use and before
servicing.
Do not expose to rain. Store •
indoors.
Do not handle plug or vacuum/•
blower unit with wet hands.
Do not use with a damaged cord or •
plug. If the vacuum/blower is not
working as it should, if it has been
dropped, damaged, left outdoors
or dropped into water, send it to an
authorized Greenlee service center.
Do not pull or carry by cord, use •
the cord as a handle, close a door
on the cord, run over the cord, or
pull the cord around sharp edges or
corners. Keep the cord away from
heated surfaces.
Do not unplug by pulling on the •
cord. To unplug, grasp and pull the
plug — not the cord.
Connect to a properly grounded •
receptacle only. Refer to
“Grounding Instructions.”
Disconnect from power before •
servicing.
Failure to observe these warnings
could result in severe injury or death.
Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070
3
690 and 690-22 Power Fishing Systems
ReceptaclePlug
ReceptaclePlug
IMPORTANT SAFETY INFORMATION
Do not vacuum or blow burning or
toxic materials such as carcinogens,
asbestos, pesticides or heavy metals.
Wear eye protection and a dust •
mask when operating or servicing
this tool.
Piston and debris will exit the •
conduit at high speed. Attach the
warning tag at the exit end of the
conduit before blowing a piston
through the conduit.
Failure to wear eye protection could
result in serious eye injury from ying
debris.
Do not use without a clean lter in place. Using •
the vacuum/blower with a clogged, damaged or
missing lter will cause damage to the motor.
Do not vacuum up anything that is burning or •
smoking, such as cigarettes, matches or hot ashes.
Failure to observe these warnings may result in
severe injury or death.
Note: Keep all decals clean and legible, and replace
when necessary.
Grounding Instructions
Electric shock hazard:
Do not modify the plug provided •
with the tool.
Connect this tool to a grounded •
receptacle on a 15-amp GFCI-
protected circuit.
Failure to observe these warnings
could result in severe injury or death.
This tool must be grounded. In the event of a malfunc-
tion or breakdown, an electrical ground provides a path
of least resistance for the electric current. This path of
least resistance is intended to reduce the risk of electric
shock.
This tool’s electric cord has a grounding conductor and
a grounding plug as shown. Do not modify the plug.
Connect the plug to a corresponding GFCI-protected
receptacle that is properly installed and grounded in
accordance with all national and local codes and
ordinances.
Do not use an adapter.
NEMA 5-15 (for Model 690)
NEMA 6-15 (for Model 690-22)
Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070
4
Identification
Intake Port
(for vacuuming)
Exhaust Port
(for blowing)
690 and 690-22 Power Fishing Systems
Specifications
Motor
Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070
Model 690 ......................................................................12 amps / 120 VAC / 60 Hz
Model 690-22 ...................................................................6 amps / 220 VAC / 50 Hz
Pressure
Blower ..............................................................................................0.275 bar (4 psi)
Vacuum
Column of Water ................................................................................ 2.8 m (110")
Column of Mercury ............................................................................203 mm (8")
Air Flow .....................................................................................3.4 m3/min (120 ft3/min)
Piston Speed in 1/2" Conduit .................................................... 145 m/min (475 ft/min)
Tank Capacity
Liquid ............................................................................................41 L (11 U.S. gal)
Dry ...................................................................................................30 L (8 U.S. gal)
Mass / Weight ..........................................................................................22.7 kg (51 lb)
5
Loading...