GE AHD40 Use and Care Guide

Page 1
Use
&Care
Dehumidifier
Guide
Safe~
Instructions . . . . . . . . . . . . . . . . . . . . . . . .
Operating
Auto Defrost..
Control Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
How the Dehumidifier Works ......................3
Humidity Control ............................................4
Care and
Adapter Plug
Condenser Coils ..............................................5
Grille and Cabinet ...........................................5
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
CIeaning............................5
....................................................5
3
4
.
❑ ❑
Problem solver . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
More
questions...call
GE Answer Center” 800.626.2000
Installation
Electrical Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Extension Cord . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Grounding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
o
Consumer Services
Appliance Registration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Consumer Services . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Model and Serial Numbers . . . . . . . . . . . . . . . . . . . . . . . . . 2
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . back cover
Models:
AHD25
AHD40
6
.
5
GE
Oualiw
Product
Page 2
~LP
US
~LP
YOU
Before using your dehumidifier, read this book carefully.
It is intended to help you operate and maintain your new dehumidifier properly.
Keep it handy for answers to your questions.
If you don’t understand something or need more help, write (include your phone number):
Consumer Affairs GE Appliances Appliance Park Louisville, KY 40225
Write down the model and serial numbers.
You’ll find them on a label behind the bucket at the back
of the dehumidifier. These numbers are also on the
Consumer Product Ownership Registration Card that came with your dehumidifier. Before sending in this card, please write these numbers here:
Model Number
Serial Number
Use these model and serial numbers in any correspondence or service calls concerning your dehumidifier.
~
YOU NEED SERVICE
If you received a damaged dehumidifier...
Immediately contact the dealer (or builder) that sold you the dehumidifier.
Save time and money. Before you request service...
Check the Problem Solver in the back of this book. It lists causes of
minor operating problems that you can correct yourself.
To obtain service, see the Consumer Services page in the
back of this book. We’re proud of our service and
want you to be pleased. If for some reason you are not happy with the service you receive, here are three steps to
follow
for further help.
FIRST, contact the people who serviced your appliance. Explain why you are not pleased. In most
cases this will solve the problem. NEXT, if you are still not pleased,
write all the details—including your phone number—to:
Manager, Consumer Relations GE Appliances Appliance Park Louisville, KY 40225
FINALLY, if your problem is not resolved, write:
Major Appliance Consumer
Action Panel 20 North Chicago, IL 60606
Wacker
Drive
still
.—
2
Page 3
When using this appliance, always exercise basic safety precautions, including the following:
This dehumidifier must be properly
‘Q~:$
. installed and located in accordance
. .
.
o
with the Installation Instructions before it is used.
Use this appliance only for its intended purpose
as described in this Use and Care Guide.
This dehumidifier must be properly grounded
before it is used. See
grounding instructions in
the Installation section.
Never operate this appliance in an area that is
likely to accumulate standing water,
If this condition develops, for your safety disconnect the power supply before stepping into the water,
Never unplug your dehumidifier by
P“lling on the
power
cord. Always gfip
plug firmly and pull straight out from the receptacle.
Repair or replace immediately all electric
service cords that have become frayed or otherwise damaged.
Do not use a cord that
shows cracks or abrasion damage along its
length or at either the plug or connector end.
SAVE THESE INSTRUCTIONS
How it works
Moist, humid air is drawn over a cold, refrigerated dehumidifying coil. Moisture in the air condenses on this coil and then drains into a bucket (or through a hose into a drain). Dry, clean air is then drawn over the condenser where it is actually heated several degrees and discharged out the front normal warmer as the dehumidifier operates. This warming effect further reduces the relative humidity of the surrounding air.
When locating the dehumidifier, be sure to place it where there is no restriction to the air flow either into the coil at the rear or from the front grille. Good air circulation through the appliance is essential to efficient operation.
for
the surrounding air to become slightly
grille
into the room. It is
Dehumidifying Coil
\
Humid “
Air In
*
Drain —
Bucket
r
~
—-
———
o-
r
Appearance may vary
Condenser
Air
/ :::ulating
% \
Dry Air out
b
% %
Sealed
Refrigeration
Unit
(c(]ntinued
next page)
3
Page 4
OPEMT~G
YOUR
(continued)
Humidity Control
A Humidity Control, built into your dehumidifier, automatically maintains a selected humidity level. It starts the dehumidifier when the humidity is high and shuts it off when the humidity is
low.
For maximum dehumidification
The Humidity Control has settings from “1“ to “ 10.” Turning the control knob to “ 10” provides the greatest amount of dehumidification, turning it to “1“ provides the least.
Even when the Humidity Control is set at “ 10,” the dehumidifier will run continuously during particularly humid periods due to seepage of humid air into the room through the walls, around doors and windows and through the use of clothes dryers and similar equipment that add moisture to the air. The continuous operation of the dehumidifier during such humid periods is normal and necessary to maintain desired conditions.
The first 3 or 4 days that you have your dehumidifier, run it at “10” to allow it to remove
large amounts of accumulated moisture from the room. When the room has reached the desired humidity level, the amount of moisture removed from the air will be considerably less. Rotate the Humidity Control knob toward “1“ until the dehumidifier shuts off. The Humidity Control will automatically maintain the desired dryness in the room.
DEH~~~ER
Hum;di~ Control
first
When the dehumidifier is
dehumidifying coil is dry, a light coating of frost will appear. This is normal. The frost will usually disappear in 30 to 45 minutes.
If room temperature goes below
accumulate on the dehumidifying coil, reducing the unit’s operating efficiency. The Auto Defrost control will shut the compressor off automatically until the coil reaches the correct operating temperature. The fan will continue to run to aid in the defrosting.
The Auto Defrost feature is also designed to prevent excessive on-off cycling, and under certain conditions may allow the frost to remain on the coil for some time before the compressor shuts off and the frost is cleared. This is not unusual.
turned on and the
65°F.,
frost may
To remove collected water
Your dehumidifier has a plastic bucket that catches the water that is removed from the air, an automatic water overflow control, and a signal light that glows when the bucket is full.
Before removing the bucket to empty it, turn the
Humidity Control knob to “OFF.” This will prevent the dehumidifier from operating when the bucket is not in
place.
On some models, after emptying the bucket, push it all the way back into place and on other models hang it on the bucket supports on each side.
4
-——
Appearance may vary
After replacing the bucket, be sure to turn the Humidity Control knob back to the desired setting.
For continuous drain-off of water, attach a standard garden hose (not supplied). A male thread is provided on the drain or water bucket.
Page 5
Unplug dehumidifier before cleaning.
Occasionally the dehumidifier will require cleaning. Use a vacuum cleaner attachment or brush to front grille. The best way to clean the dehumidifying coil is by the use of a soft brush when the soil is soft and wet. (If allowed to dry and harden, it will be difficult to remove and must be soaked and softened.)
clean
the
Do not allow a lot of water to enter the electrical/machine compartment through the circular opening behind the coil. Use a squirt bottle or syringe so you can control the water.
Filter Screen
(on some models)
How to connect electricity
For personal safety, this appliance must
be properly grounded.
The power cord of this appliance is equipped with a
three-prong (grounding) plug which mates with a
standard three-prong (grounding) wall outlet (Fig. 1) to minimize the possibility of electric shock hazard from this appliance.
The filter pulls out from the bottom and down from the top.
The filter should be cleaned at least every 30 days or as often as needed. To clean the filter, vacuum it on the dusty side to remove light dust. Wash the filter, cleaner side up, under gently flowing water to wash out accumulated dust and lint. If the filter is very dirty, use a mild household detergent in wash water. Let the filter dry thoroughly before replacing it.
DO NOT, UNDER ANY CIRCUMSTANCES,
CUT OR REMOVE THE THIRD (GROUND)
PRONG FROM
T~
POWER CORD.
Use of extension cords not recommended
Because of potential safety hazards under certain conditions, we strongly recommend against the use of an extension cord. However, if you still elect to use an extension cord, it is absolutely necessary that it be a
UL
listed 3-wire grounding type appliance extension cord having a grounding type plug and outlet and that the electrical rating of the cord be 15 amperes (minimum) and 120 volts.
Have the wall outlet and circuit checked by a I-, electrician to make sure the outlet is properly grounded.
Where a standard two-prong encountered, it is your personal responsibility and obligation to have it replaced with a properly grounded three-prong wall outlet.
wall
outlet is
ualified
(c{)ntinued
next page)
5
Page 6
~STALLATION
REQUIREMENTS
(continued)
Use of Adapter Plug
(llS-VOlt
units)
Because of potential safety hazards under certain conditions, we strongly recommend against use of an adapter plug. However, if you
still
elect to use an adapter, where local codes permit, a TEMPORARY CONNECTION may be made to a properly grounded two-prong wall outlet by use of a UL listed adapter (Fig. 2) available at most local hardware stores.
TEMPORARY METHOD
(ADAPTER PLUGS NOT
PERMl~ED
IN CANADA)
ALIGN LARGE PRONGS/SLOTS
<;.
4
T
Q’
w-’
INSURE PROPER GROUND AND FIRM CONNECTION
BEFORE USE
/
Q
~
QUESTIONS?
USE THIS PROBLEM SOLVER
The larger slot in the adapter must be aligned with the larger slot in the wall outlet to provide proper polarity in the connection of the power cord.
CAUTION:
Attaching an adapter ground terminal to wall outlet cover screw does not ground appliance unless cover screw is metal, and not insulated, and wall outlet is grounded through house wiring. You should have circuit checked by a qualified electrician to make sure the outlet is properly grounded.
When disconnecting the power cord from the adapter,
is not done, the adapter ground terminal is very
always hold the adapter with one hand. If this
likely
to
break with repeated use.
Should the adapter ground terminal break, DO NOT USE the appliance until a proper ground has again been established.
PROBLEM
DEHUMIDIFIER DOES NOT OPERATE
DEHUMIDIMER
“DOES NOT DRY THE
AIR AS IT SHOULD”
POSSIBLE CAUSE
Not plugged in. Plug may have been bumped loose.
If plugged in, fuse could have blown or circuit breaker may have tripped.
Bucket may not be pushed all the way into the dehumidifier.
When the dehumidifier was first installed, not enough time was allowed for it to
remove the large amount of moisture that had accumulated in the room. As long
as three or four days, with the Humidity Control knob set at “10,” may be
required to achieve and maintain the desired dryness.
Objects blocking front
reduce efficiency.
Humidity Control may be set too low. Turn control knob to a higher setting.
Doors
Clothes dryer may be blowing moisture-laden air into the room.
WATER ON FLOOR
Connection may be loose if hose is attached to dehumidifier for continuous
drain-off.
Bucket may not be pushed all the way into the dehumidifier.
Bucket not hung properly from bucket supports (on models with
bucket supports).
If you need more help...call, toll free: GE Answer
Center@
800.626.2000 consumer information service
andor
back of dehumidifier will restrict air flow and
an~or
windows may not be tightly closed.
6
——.. .——
.-
Page 7
We’ll Be There
With the purchase
information or assistance from GE,
h-Home Repair Service
8DMEXARES(80M32-2737)
A GE
consumer service professional will provide expert repair service, scheduled company-operated locations convenience Our factory-trained technicians know your appliance inside and
repairs can be handled in just one visit.
at a time that’s convenient for you. Many GE
(7:00
GEAnswer Cente~
8086262000
Whatever your question about any GE major appliance, GE Answer Genter@ information service is available to help. Your call—and your question-will be answered promptly and courteously. And you
Center@ service is open 24 hours a clay, 7 days a week.
ofyour
a.m. to
new GE appliance, receive the assurance that if you ever need
off’er
you service today or tomorrow, or at. your
7:00
p.m. weekdays,
wdll be there. All you have to do is call—toll-free!
(;onsumer
9:00
a.m. to
can call any time.
Service
2:00
p.m. Saturdays).
out–so
C~E
Answer
most
kr
Customers With Special Needs...
80~6262000
Gonsurners with impaired hearing or speech who have
access to a TDD or a conventional teletypewriter may
call
800-TDD-GEAC (800-833-4322) to request
information or service.
CL- M”””... ,W,,
..
...-,. .,-..
SEHIONA.A
W,..... ---
.”...
-..s.
Upon request, GE will provide Braille controls for a variety of’ appliances, and a brochure assist in planning a barrier-free kitchen mobility. To obtain these items,
-...
,.,
free of charge, call 800.626.2000.
fi~r
persons with limited
GE
to
Service Contracts
80M2&2224
You can have the secure feeling that GE Consumer Service will still be there after your warranty expires. Purchase a in effect and you’ll receive a substantial discount. With a multiple-year contract,
you’re assured of
fLlture
service at today’s prices.
GE
contract while your warranty is still
Pads andAccessories
80M2&2002
Individuals qualified to service their own appliances
can have needed parts or accessories their home. The 47,000 parts... and all GE C,enuine Renewal Parts are
fully warranted. VISA, Master[;ard and Discover cards are
accepted.
C,E p:~rts system
sent
directly to
provides access to over
User maintenance instructions contained in this booklet cover procedures intended to be performed by any user.
O*er
servicing genertiy shotid be referred to
service
personnel. Caution must be exercised, since
improper servicing may cause unsafe operation.
quafified
Page 8
YOUR GE DEHUMIDIFIER
WARRANTY
Save proof of original purchase date such as your sales slip or
cancelled
check to establish warranty period.
WHAT IS COVERED
LIMITED ONE-YEAR WARRANTY
For one year from date of original purchase, we will provide, free of
charge, parts and service labor to
any
pati
of
repair or replace
the
dehumid~fierthat fails because of
a manufacturing defect.
LIMITED ADDITIONAL FOUR-YEAR WARRANTY
For the second through fifth year from date of original purchase, we will provide, free of charge, and service labor to repair or replace
system
any
pati
of
the
(the compressor,
pafls
sealed
condenser, dehumidifying coil and all connecting tubing) that fails because of a manufacturing defect.
For
each of the above
warranties:
You must take the dehumidifier to a General Electric Factory Service Center or a General Electric Customer Care” Servicer and pick it up following service. In-home
sewice is also available, but you
must pay for the sewice technician’s
travel costs to your home.
This warranty is extended to the original purchaser and any succeeding owner for products purchased for use in the 48 mainland states, Alaska, Hawaii and Washington,
D.C.
All warranty service will be provided by our
Facto~ Sewice
Centers or by our authorized Customer Care” servicers during normal working hours.
Should your appliance need
service, during warranty period or beyond, call 800-GE-CARES (800-432-2737).
WHAT IS NOT COVERED
Service trips to your home to teach
you how to use the product.
Read your Use and Care material.
If you then have any questions about operating the product, please contact your dealer or our Consumer Affairs office at the address below, or call, toll free:
GE Answer
800.626.2000 consumer information service
Some
may not apply to you.
To know what your legal rights are in
Pub
No.
1 1
11-92
49-7280
CG
CenteF
states
do not allow the
This warranty gives you specific legal rights, and you may also have other rights which
Manager—Consumer Affairs, GE Appliances, Louisville, KY 40225
c
Improper installation. Failure of the product if it is used
If you have an installation problem, contact your dealer or installer. You are responsible for providing adequate electrical, plumbing and other connecting facilities.
Replacement of house fuses or WARRANTOR IS NOT
resetting of circuit breakers.
for other than its intended purpose or used commercially.
Damage to product caused
by accident, fire, floods or acts of God.
RESPONSIBLE FOR CONSEQUENTIAL DAMAGES.
exclusion or limitation of incidental or consequential damages, so the above limitation or
your state, consult your local or state consumer affairs office or your state’s Attorney General.
vay
from state to state.
exclusion
Warrantor: General Electric Company
If further help is needed concerning this warranty, write:
AHD2. AHD40
Loading...