Gaggenau VL200120 Use & Care Guide
*DJJHQDX
Use and care manual 2
Notice d’utilisation 19
Manual de instrucciones 37
VL 200 120
Downdraft ventilation
Aérateur de plan de cuisson
Extractor de superficie
en-us
Table of Contents
Use and care manual
9 Safety Definitions 3
Faults – What to Do? 17
IMPORTANT SAFETY INSTRUCTIONS 4
General notes 4
Fire Safety 4
Burn Prevention 6
Child Safety 6
Cleaning Safety 7
Safe use 7
Proper Installation and Maintenance 8
Proposition 65 Warning: 10
Causes of damage 11
Protecting the environment 11
Operating modes 11
Air extraction 11
Recirculation 11
Getting to know your appliance 12
Downdraft ventilation 12
Control knob 12
Display on the illuminated ring 12
Customer service 18
Additional information on products, accessories,
replacement parts and services can be found at
www.gaggenau.com and in the online shop
www.gaggenau.com/zz/store
Before using the appliance for the first time 13
Operating the appliance 13
Turning on 13
Turning off 13
Intensive mode 13
Intermittent ventilation 14
Automatic operation 14
Saturation notification 14
Ventilation molding 14
Cleaning and maintenance 15
Cleaning the appliance 15
Removing and installing the metal grease filter 16
Cleaning the metal grease filter 16
Changing the activated charcoal filter
(only in circulating-air mode) 16
Resetting the saturation indicator 16
2
9 Safety Definitions
Safety Definitions
9 WARNING
This indicates that death or serious injuries may
occur as a result of non-observance of this
warning.
9 CAUTION
This indicates that minor or moderate injuries may
occur as a result of non-observance of this
warning.
NOTICE
This indicates that damage to the appliance or property
may occur as a result of non-compliance with this
advisory.
Safety Definitions en-us
Note: This alerts you to important information and/or tips.
3
9 IMPORTANT SAFETY INSTRUCTIONS
READ AND SAVE THESE INSTRUCTIONS
IMPORTANT SAFETY INSTRUCTIONS
READ AND SAVE THESE INSTRUCTIONS
9 WARNING
9 WARNING
When properly cared for, your new
appliance has been designed to be
safe and reliable. Read all
instructions carefully before use.
These precautions will reduce the
risk of burns, electric shock, fire,
and injury to persons. When using
kitchen appliances, basic safety
precautions must be followed,
including those in the following
pages.
General notes
This appliance is not intended for operation with an external clock timer or a remote control.
Make sure that no small parts or liquids penetrate into the appliance.
Check device for visible damage after unpacking it. Don't plug in device in the event of transport damage.
Adults and children must never operate
the appliance without supervision if they
are either physically or mentally incapable
or if they lack the necessary knowledge
and experience to operate the appliance
correctly and safely. Don't let children
play with the appliance or packaging
material.
Fire Safety
Risk of fire!
If the downdraft ventilator is installed
next to a gas appliance, an air baffle
must be used (available as
accessory). This prevents the flame
from being drawn into the fan. Thus,
a filter soaked in grease cannot be
ignited by the gas flame.
9 WARNING
TO REDUCE THE RISK OF A
RANGE TOP GREASE FIRE:
1. Never leave surface units
unattended at high settings.
Boilovers cause smoking and
greasy spillovers that may ignite.
Heat oils slowly on low or medium
settings.
2. Always turn hood ON when
cooking at high heat.
3. Clean ventilating fans frequently.
Grease should not be allowed to
accumulate on fan or filter.
4. Use proper pan size. Always use
cookware appropriate for the size
of the surface element.
Do not flambé under the extractor
hood or work with a naked flame.
When switched on, the extractor
hood draws flames into the filter.
There is a risk of fire due to deposits
on the grease filter!
Always have a working smoke detector near the kitchen.
4
9 IMPORTANT SAFETY INSTRUCTIONS
READ AND SAVE THESE INSTRUCTIONS
9 CAUTION
For general ventilating use only. Do
not use to exhaust hazardous or
explosive materials and vapors.
Do not operate any fan with a damaged cord or plug. Discard fan or return to an authorized service facility for examination and/or repair.
Do not run cord under carpeting. Do not cover cord with throw rugs, runners, or similar coverings. Do not route cord under furniture or appliances. Arrange cord away from traffic area and where it will not be tripped over.
In the event that personal clothing or hair catches fire, drop and roll immediately to extinguish flames.
Smother flames from food fires other than grease fires with baking soda. Never use water on cooking fires.
9 WARNING
TO REDUCE THE RISK OF INJURY
TO PERSONS IN THE EVENT OF A
RANGE TOP GREASE FIRE,
OBSERVE THE FOLLOWING:
▯ SMOTHER FLAMES with a close-
fitting lid, cookie sheet, or metal
tray, then turn off the burner. BE
CAREFUL TO PREVENT BURNS.
If the flames do not go out
immediately, EVACUATE AND
CALL THE FIRE DEPARTMENT.
▯ NEVER PICK UP A FLAMING PAN
– You may be burned.
▯ DO NOT USE WATER, including
wet dishcloths or towels – a
violent steam explosion will result.
▯ Use an extinguisher ONLY if:
– You know you have a Class ABC
extinguisher, and you already know
how to operate it.
– The fire is small and contained in
the area where it started.
– The fire department is being called.
– You can fight the fire with your back
to an exit.
Have an appropriate fire extinguisher available, nearby, highly visible and easily accessible near the appliance.
Whenever possible, do not operate the ventilation system during a cooktop fire. However, do not reach through fire to turn it off.
5
9 IMPORTANT SAFETY INSTRUCTIONS
READ AND SAVE THESE INSTRUCTIONS
9 WARNING
Risk of fire!
Grease deposits in the grease filter
can ignite.
Clean the grease filter at least every
two months.
Never operate the appliance without
the grease filter.
9 WARNING
Risk of fire!
Grease deposits in the grease filter
can catch fire. Never work with a
naked flame near the appliance (e.g.
flambéing). Install the unit near a
heat-producing appliance for solid
fuels (e.g. wood or coal) only if there
is a closed, non-detachable cover.
There must be no flying sparks.
9 WARNING
Risk of fire!
Hot oil and fat catch fire fast. Never
leave hot oil and fat unsupervised.
Never extinguish a fire with water.
Switch off the cooking position.
Suffocate flames carefully with a lid,
a fire blanket or similar.
Burn Prevention
9 WARNING
Risk of burns!
The accessible parts get hot during
operation. Never touch hot parts.
Keep children away.
Child Safety
9 WARNING
Risk of fire!
When gas burners are in operation
without any cookware placed on
them, they can build up a lot of heat.
A ventilation appliance installed
above the cooker may become
damaged or catch fire. Only operate
the gas burners with cookware on
them.
When children become old enough to use the appliance, it is the responsibility of the parents or legal guardians to ensure that they are instructed in safe practices by qualified persons.
Remove all tape and packaging before using the appliance. Destroy the packaging after unpacking the appliance. Never allow children to play with packaging material.
Do not allow anyone to climb, stand, lean, sit, or hang on any part of an appliance, especially a door, warming drawer, or storage drawer. This can damage the appliance, and the unit may tip over, potentially causing severe injury.
6
9 IMPORTANT SAFETY INSTRUCTIONS
READ AND SAVE THESE INSTRUCTIONS
Do not allow children to use this
appliance unless closely supervised by
an adult. Children and pets should not be
left alone or unattended in the area where
the appliance is in use. They should never
be allowed to play in its vicinity, whether
or not the appliance is in use.
9 CAUTION
Items of interest to children should
not be stored in an appliance, in
cabinets above an appliance or on
the backsplash. Children climbing
on an appliance to reach items could
be seriously injured.
Cleaning Safety
9 CAUTION
Damage to appliance
Do not remove control knobs for
cleaning.
Safe use
9 WARNING
Do not repair, replace or remove any
part of the appliance unless
specifically recommended in the
manuals. Improper installation,
service or maintenance can cause
injury or property damage. Refer to
this manual for guidance. All other
servicing should be done by an
authorized servicer.
9 WARNING
Be sure the entire appliance
(including the grease filters and light
bulbs, if applicable) has cooled and
grease has solified before
attempting to clean any part of the
appliance.
9 WARNING
Risk of burns, electrical shock!
by appliance. Always let appliance
cool down prior to cleaning or
maintenance. Turn off fuse or unplug
power plug.
Do not use steam cleaners to clean the appliance.
9 WARNING
Risk of burns!
by hot appliance when used with
cooking appliances. Keep children
away and ensure proper use.
9 WARNING
Risk of injury, damage!
through objects set down on the
appliance. Never place objects on
the appliance.
7
9 IMPORTANT SAFETY INSTRUCTIONS
READ AND SAVE THESE INSTRUCTIONS
9 WARNING
Risk of short circuit!
The cable insulation of electrical
appliances can melt. Never place
connection cable on the hot cooking
zones.
9 WARNING
Risk of fire!
Overly greasy filters pose a risk of
catching fire! Never deep-fry or grill
next to the appliance without paying
careful attention. Clean grease
filters regularly.
Proper Installation and Maintenance
Have the installer show you the location of the circuit breaker or fuse. Mark it for easy reference.
This appliance must be properly installed and grounded by a qualified technician. Connect only to properly grounded outlet. Refer to Installation Instructions for details.
Do not store or use corrosive chemicals,
vapors, flammables or nonfood products
in or near this appliance. It is specifically
designed for use when heating or
cooking food. The use of corrosive
chemicals in heating or cleaning will
damage the appliance and could result in
injury.
Do not operate this appliance if it is not working properly, or if it has been damaged. Contact an authorized servicer.
Do not repair or replace any part of the appliance unless specifically recommended in this manual. Refer all servicing to a factory authorized service center.
9 CAUTION
Grease left on filters can remelt and
move into the vent.
Hidden surfaces may have sharp
edges. Use caution when
reaching behind or under
appliance.
This appliance is intended for normal family household use only. It is not approved for outdoor use. See the Statement of Limited Product Warranty. If you have any questions, contact the manufacturer.
8
9 IMPORTANT SAFETY INSTRUCTIONS
READ AND SAVE THESE INSTRUCTIONS
9 WARNING
When the hood is operated in
exhaust-air mode simultaneously with
a different burner which also makes
use of the same chimney (such as
gas, oil or coal-fired heaters,
continuous-flow heaters, hot-water
boilers) care must be taken to
ensure that there is an adequate
supply of fresh air which will be
needed by the burner for
combustion.
Safe operation is possible provided
that the under pressure in the room
where the burner is installed does
not exceed 4 Pa (0.04 mbar).
This can be achieved if combustion
air can flow through non-lockable
openings, e.g. in doors, windows
and via the air-intake/exhaust-air wall
box or by other technical measures,
such as reciprocal interlocking, etc.
9 WARNING
Avoid carbon monoxide poisoning –
Provide adequate air intake so
combustion gases are not drawn
back into the room.
An air-intake/exhaust-air wall box by
itself is no guarantee that the limiting
value will not be exceeded.
Note: When assessing the overall requirement, the combined ventilation system for the entire household must be taken into consideration. This rule does not apply to the use of cooking appliances, such as cooktops and ovens.
9 WARNING
Mortal danger, risk of poisoning!
through back-suctioned combustion
gases. Never operate appliance in
exhaust air mode simultaneously with
a fire-powered appliance that relies
on ambient air if sufficient air supply
has not been provided for.
Fire-powered appliances that rely on
ambient air (e.g. gas, oil, wood or coalpowered heaters, flow heaters, water
heaters) draw on combustion air from the
room where they're installed and direct
the exhaust fumes through an exhaust
system (e.g. chimney), out of the building.
9
9 IMPORTANT SAFETY INSTRUCTIONS
READ AND SAVE THESE INSTRUCTIONS
In combination with an activated range hood, ambient air is drawn from the kitchen and neighboring rooms— insufficient supply air may cause low pressure. Poisonous gases from the chimney or exhaust shaft may be suctioned back into the living space.
▯ That's why sufficient supply air must
always be provided for.
▯ An air supply / exhaust wall duct alone
doesn't ensure adherence to the limit
value.
9 WARNING
Risk of electrical shock!
through damaged connection cable.
Don't bend or pinch connection
cable during installation.
Proposition 65 Warning:
This product may contain a chemical known to the State of California, which can cause cancer or reproductive harm. Therefore, the packaging of your product may bear the following label as required by California:
67$7(2)&$/,)251,$352326,7,21:$51,1*
:$51,1*
&DQFHUDQG5HSURGXFWLYH+DUPZZZ3:DUQLQJVFDJRY
9 WARNING
Risk of burns, injury!
through damaged connection cable.
Damaged connection cable must be
replaced by an licensed specialist
(electrician).
9 WARNING
Risk of injury!
From sharp edges during
installation. Always wear protective
gloves while installing the appliance.
10
Causes of damage en-us
Causes of damage
Causes of damage
Risk of damage due to ingress of humidity into the electronic circuitry. Never clean operator controls with a wet cloth.
Surface damage due to strong or abrasive cleaning agents. Never use strong and abrasive cleaning agents.
Protecting the environment
Unpack the appliance and dispose of the packaging in an environmentally friendly manner.
Operating modes
Operating modes
This appliance can be used in air extraction or air recirculation mode depending on the remote fan unit connected.
Air extraction
The air sucked in is cleaned by the
grease filters and is routed outdoors
through a pipe system.
Note: The extracted air must neither be discharged into an operating smoke or waste gas chimney nor into a shaft that serves to ventilate rooms where heat-producing appliances are installed.
▯ The local chimney sweep's consent must be obtained
if the exhaust air is to be routed to a smoke or waste
gas chimney that is not in operation.
▯ A telescopic wall duct should be used if the exhaust
air is routed through the outside wall.
Recirculation
The aspirated air is cleaned by the grease
filters and an activated charcoal filter and
is returned to the kitchen.
Note: You must install an activated charcoal filter to bind odors in the recirculation mode. Refer to the manual or ask your specialist dealer for details of the various options for operating the appliance in the recirculation mode. You can obtain the necessary accessories from specialist dealers, from our after-sales service or in the online shop.
11
en-us Getting to know your appliance
Getting to know your appliance
Getting to know your appliance
Downdraft ventilation
Display on the illuminated ring
The control knob is encircled by an illuminated ring that indicates a number of statuses and functions.
Display Meaning
Û Off Appliance OFF
Ú Lights up: Orange Appliance ON
ˆ Switch off appliance,
flashes slowly: White,
3 times
ˆ Switch off appliance,
flashes rapidly: White,
6 times
ˆ Flashing: Orange Appliance fault
Metal grease filter saturation indicator
Activated charcoal filter
saturation indicator
Please contact customer
service.
( Filter cover
0 Metal grease filter
8 Control knobs
Control knob
Symbol Explanation
0 Switches off the appliance
< Switches on automatic mode
1 Switches on fan level 1
2 Switches on fan level 2
3 Switches on fan level 3
Ž Switches on intensive mode
μ Switches on intermittent ventilation
œ Resets the saturation indicator
12
Before using the appliance for the first time en-us
Before using the appliance for the first time
Before using the appliance for the first ti me
Before using the appliance and accessory parts for the
first time, clean them thoroughly.
Operating the appliance
Operating the appliance
Turning on
Automatic mode, three fan settings, intensive mode Ž
and the intermittent ventilation system μ are available for
extraction.
Push in the control knob and turn it clockwise to the fan setting you require.
The illuminated ring behind the control knob lights up.
Turning off
Turn the control knob anti-clockwise to position 0.
Intensive mode
Activate intensive mode if strong odors or large amounts of steam are produced. In this mode, the appliance operates at its maximum fan setting for a short time. After approx. six minutes, the appliance automatically switches back to fan setting 3.
Switching on
Push in the control knob and turn it clockwise to the Ž position.
The intensive mode is activated. The illuminated ring behind the control knob goes out briefly and then lights up orange. A signal tone sounds.
Note: The run time of the intensive mode is six minutes. Once this time has elapsed, the appliance switches back to fan setting 3. A signal tone sounds. The control knob remains in the Ž position. The illuminated ring behind the control knob goes out briefly and then lights up orange.
Switching off
Turn the control knob anti-clockwise to position 0.
13
en-us Operating the appliance
Intermittent ventilation
With intermittent ventilation, the fan automatically switches to fan setting 1 for six minutes every hour.
Switching on
Push in the control knob and turn it clockwise to the
μ position.
Intermittent ventilation is activated. The illuminated ring behind the control knob lights up orange while the ventilation system is switched on.
Switching off
Turn the control knob anti-clockwise to position 0.
Automatic operation
In automatic mode, a sensor in the appliance detects the intensity of the cooking and roasting fumes. The appliance selects the appropriate fan setting automatically.
Switching on
Saturation notification
When the metal grease filter or the activated charcoal filter (only in air recirculation mode) are saturated, a signal sounds after the appliance has been switched off and the illuminated ring on the control knob flashes:
▯ Metal grease filter: Three times white, slow flashing
▯ Activated charcoal filter: Six times white, rapid flashing
Do not wait any longer to clean the metal grease filters or replace or regenerate the activated charcoal filters.~ "Cleaning and maintenance" on page 15
Ventilation molding
If the hob extractor system is operating beside a gas appliance, a ventilation molding (LS 041 001) must be placed on the gas unit.
The ventilation molding improves the extraction behavior of gas appliances and prevents small flames from being blown out by the draught.
Push in the control knob and turn it clockwise to the < position.
Automatic mode is activated.
The optimum fan setting 1, 2 or 3 is set automatically using a sensor. The illuminated ring behind the control knob lights up orange while the ventilation system is switched on.
The run time of the automatic mode is eight hours at most.
Switching off
Turn the control knob anti-clockwise to position 0.
14
Cleaning and maintenance en-us
Cleaning and maintenance
Cleaning and maintenance
9 WARNING
Risk of burns!
The appliance grows hot during operation. Let
appliance cool down prior to cleaning.
9 WARNING
Risk of electrical shock!
Moisture entering the appliance can cause an
electrical shock. Don't use a high-pressure cleaner
or steam cleaner.
9 WARNING
Risk of injury!
Components inside the appliance may have sharp
edges. Wear protective gloves.
NOTICE
Surface damage
Do not use these cleaning agents
▯ Caustic or corrosive cleaners
▯ Oven cleaners
▯ Cleaners that are caustic, contain chlorine or are
aggressive
▯ Cleaners containing large proportions of alcohol
Cleaning the appliance
Note: Before cleaning, remove any jewelry from your
arms and hands.
In order to ensure the grease absorption level, the grease filter must be cleaned regularly.
Clean the appliance after each use once it has cooled down. Remove spilt liquids immediately and do not allow any food remains to dry on it.
Also clean the inside of the downdraft ventilation regularly with a damp cloth.
Appliance part/surface
Appliance
frame
Ventilation
grille
Control panel Soapy water – the cloth must not be
Control knobs Soapy water – the cloth must not be
Recommended cleaning
Soapy water – dry with a soft cloth.
Use a minimal amount of water when
cleaning to prevent water from penetrating the appliance.
Soak dried-on food remains with a
small amount of soapy water; do not
scour.
Carefully remove for cleaning. Soapy
water – dry with a soft cloth.
You can also clean the ventilation
grille in the dishwasher. This may
cause the ventilation grille to discolor,
making it lighter. This does not affect
its usability.
too wet. Dry with a soft cloth.
If acidic substances (e.g. vinegar,
ketchup, mustard, marinades, lemon
juice) are spilled on the control panel,
remove them immediately.
too wet. Dry with a soft cloth.
▯ Hard, scratchy dish-washing sponges, brushes or
scourers
If such an agent comes into contact with the appliance,
wipe it off immediately with water.
Thoroughly wash out new sponge cloths before using
them.
Note: Only use a minimal amount of water when cleaning so that no water enters the appliance.
9 CAUTION
Damage to the appliance
Do not detach the control knobs
to clean them.
15
en-us Cleaning and maintenance
Removing and installing the metal grease filter
1. Remove the filter cover.
2. Pull the metal grease filter up and out of the
appliance.
Cleaning in the dishwasher
Note: Slight discoloration may occur if cleaning in the
dishwasher. This has no effect on the performance of the
metal grease filter.
1. Place the metal grease filters loosely in the
dishwasher with the opening facing down. Do not jam
in the metal grease filters.
2. Do not clean heavily soiled metal grease filters
together with tableware.
Cleaning by hand
1. Soak the metal grease filter in hot soapy water.
2. Clean with a brush and then rinse thoroughly.
3. Allow the metal grease filter to dry before inserting.
Note: You can use a special degreaser to remove stubborn dirt. It can be ordered via the online shop.
Changing the activated charcoal filter (only in circulating-air mode)
3. Clean the metal grease filter and filter cover.
4. Clean the interior of the downdraft ventilation.
5. Insert the metal mesh grease filter.
6. Put the filter cover on.
Cleaning the metal grease filter
9 WARNING
Risk of fire!
Grease deposits in the grease filter can ignite.
Clean the grease filter at least every two months.
Never operate the appliance without the grease
filter.
Activated charcoal filters trap the odor-causing compounds from cooking smells. They are only used for air-recirculation mode.
The activated charcoal filter of the remote fan unit must be replaced at regular intervals. The saturation indicator on your appliance tells you how frequently this needs to be done.
Resetting the saturation indicator
If the saturation indicator for the metal grease filter or activated charcoal filter has flashed, you must reset the saturation indicator after cleaning or changing the filter.
1. Push in the control knob and turn it clockwise to the
œ position.
The saturation indicator is reset. The illuminated ring
behind the control knob flashes three times. A signal
tone sounds.
2. Turn the control knob back to position 0.
The metal grease filter can be cleaned in the dishwasher or by hand.
16
Faults – What to Do?
Faults – What to Do? en-us
Faults – What to Do?
9 WARNING
Risk of electric shock!
Incorrect repairs are dangerous. Repairs may only
be carried out by an authorized servicer. If the
appliance is not functioning properly, unplug the
power cord or switch off the fuse in the fuse box.
Contact Customer Support.
Disruption Possible cause Solution
The appliance does not work No connection to the remote fan
unit.
Power failure Check whether other kitchen appliances
Faulty fuse Check in the fuse box to make sure that the
After the appliance has been
switched off, the illuminated ring
slowly flashes white three times and
an audible signal sounds.
After the appliance has been
switched off, the illuminated ring
rapidly flashes white six times and
an audible signal sounds.
The appliance switches itself off
while in use; the illuminated ring
flashes orange and white alternately
Appliance runs in automatic mode,
illuminated ring flashes orange
--------
The metal grease filter is saturated. Clean the metal grease filter.
The activated charcoal filter in the
remote fan unit is saturated.
Safety switch off:
The controls on the appliance have
not been used for a long time
The appliance remains off after a
power failure
Automatic sensor is faulty Turn the control knob to 0, then switch it
Faults often have simple explanations. Please read the notes in the table before calling customer service.
Check whether the plugs of the connection
cable are properly inserted.
are working.
fuse for the appliance is in working order.
~ "Cleaning and maintenance"
on page 15
Change the activated charcoal filter in the
remote fan unit. ~ "Cleaning and main-
tenance" on page 15
Turn the control knob to 0, then switch it
back on (if you wish to continue using the
appliance)
Turn the control knob to 0, then switch it
back on (if you wish to continue using the
appliance)
back on
If the illuminated ring continues flashing
after you have switched the appliance back
on, contact the after-sales service
17
Loading...