Ford F-650 2013, F-750 2013 Owner's Manual

fordowner.com ford.c a

2013 F-650/750 Owner’s Manual

Table of Contents 1

Introduction 7

Vehicle Inspection Guide 14

Child Safety 26

Child seats...........................................28

Child seat positioning ...................................28

Booster seats .........................................30

Installing child safety seats ...............................33

Child safety locks ......................................40

Safety Belts 41

Fastening the safety belts ................................42

Safety belt height adjustment .............................47

Safetybeltwarninglightandindicatorchime..................48

Safety belt-minder .....................................49

Child restraint and safety belt maintenance ...................51

Keys and Remote Control 52

Keys ...............................................52

Locks 53

Locking and unlocking ..................................53

Steering Wheel 54

Adjusting the steering wheel ..............................54

Steering wheel controls .................................54

Wipers and Washers 55

Windshield wipers .....................................55

Windshield washers ....................................55

Lighting 56

Lighting control .......................................56

Instrument lighting dimmer...............................57

Daytime running lamps ..................................57

Turn signal control .....................................58

Interior lamps ........................................58

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

2 Table of Contents

Windows and Mirrors 59

Power windows .......................................59

Exteriormirrors.......................................60

Instrument Cluster 64

Gauges .............................................64

Warning lamps and indicators .............................68

Audible warnings and indicators ...........................73

Information Displays 74

Message center .......................................74

Information messages ...................................76

Audio System 77

AM/FMstereo ........................................79

AM/FM/CD with SYNC ..................................80

Auxiliary input jack ....................................82

USB port ............................................84

Satellite radio information................................84

Climate Control 88

Manual heating and air conditioning ........................88

Seats 91

Sitting in the correct position .............................91

Head restraints........................................92

Manual seats .........................................94

Power seats ..........................................96

Rear seats ...........................................98

Heated seats .........................................99

Auxiliary Power Points 101

Starting and Stopping the Engine 102

Ignition switch .......................................103

Engine block heater ...................................111

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

Table of Contents 3

Fuel and Refueling 113

Fuel quality .........................................114

Running out of fuel....................................116

Refueling...........................................117

Fuel consumption .....................................118

Diesel Exhaust Fluid (DEF) .............................120

Transmission 132

Transmission operation .................................136

Brakes 147

Brakes .............................................147

Hints on driving with anti-lock brakes ......................151

Traction Control 164

TractionControl™....................................164

Cruise Control 166

Using cruise control ...................................166

Driving Aids 168

Steering ............................................170

Air suspension .......................................171

Upfitter controls ......................................172

Load Carrying 173

Vehicle loading .......................................174

Towing 175

Trailertowing........................................175

Wrecker towing ......................................179

Driving Hints 182

Economical driving ....................................182

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

4 Table of Contents

Roadside Emergencies 184

Getting roadside assistance ..............................184

Hazard flasher control..................................185

Jump-starting the vehicle ...............................185

Customer Assistance 189

Getting assistance outside the U.S. and Canada ...............191

Reporting safety defects (U.S. only) .......................193

Reporting safety defects (Canada only) .....................193

Fuses 194

Changing a fuse ......................................194

Fuse specification chart ................................195

Fuses and relays......................................203

Maintenance 204

General information ...................................204

Opening and closing the hood ............................215

Engine oil dipstick ....................................217

Engine oil check......................................218

Engine coolant check ..................................219

Automatic transmission fluid check ........................223

Brake fluid check .....................................229

Power steering fluid check ..............................231

Fuel filter...........................................232

Washer fluid check ....................................232

Changing the vehicle battery .............................233

Checking the wiper blades ..............................235

Changing the wiper blades ..............................236

Air filter(s) .........................................236

Adjusting the headlamps ................................239

Changing a bulb ......................................239

Bulb specification chart.................................241

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

Table of Contents 5

Vehicle Care 242

Cleaning products.....................................242

Cleaning the exterior ..................................242

Waxing.............................................244

Repairing minor paint damage ............................245

Cleaning the engine ...................................245

Cleaning the windows and wiper blades .....................245

Cleaning the interior ...................................246

Cleaning the instrument panel and instrument cluster lens .......247

Cleaning leather seats ..................................248

Cleaning the alloy wheels ...............................248

Vehiclestorage.......................................249

Wheels and Tires 252

Tire information ......................................252

Wheel lug nut torque ..................................262

Capacities and Specifications 263

Engine drivebelt ......................................263

Lubricant specifications.................................264

Refill capacities ......................................277

Part numbers ........................................280

Vehicle identification number ............................281

Vehicle certification label ...............................281

Scheduled Maintenance 283

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

6 Table of Contents

SYNC® 319

Pairing your phone for the first time .......................324

911 Assist™ .........................................338

Vehicle Health Report ..................................341

Appendices 364

Index 372

The information contained in this publication was correct at the time of going to print. In the interest of continuous development, we reserve the right to change specifications, design or equipment at any time without notice or obligation. No part of this publication may be reproduced, transmitted, stored in a retrieval system or translated into any language in any form by any means without our written permission. Errors and omissions excepted.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

Introduction 7

ABOUT THIS MANUAL

Thank you for choosing Ford. We recommend that you take some time to get to know your vehicle by reading this manual. The more that you know about it, the greater the safety and pleasure you will get from driving it.

WARNING: Always drive with due care and attention when using and operating the controls and features on your vehicle.

Note: This manual describes a range of product features and options, sometimes before they are generally available. Therefore, you may find options in this manual that are not found on your vehicle.

Note: Some of the illustrations in this manual may be used for different models, so they may appear different than your vehicle. However, the essential information in the illustrations is always correct.

Note: Always use and operate your vehicle in line with all applicable laws and regulations.

Note: Pass on this manual when selling your vehicle. It is an integral part of the vehicle.

This manual may qualify the location of a component as left-hand side or right-hand side. The side is determined when facing forward in the seat.

A. Right-hand side B. Left-hand side

Protecting the Environment

You must play your part in protecting the environment. Correct vehicle usage and the authorized disposal of waste, cleaning and lubrication materials are significant steps toward this aim.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

8 Introduction

SYMBOL GLOSSARY

WARNING: You risk death or serious injury to yourself and others if you do not follow the instruction highlighted by the

warning symbol.

These are some of the symbols you may see on your vehicle.

Symbol Description Symbol Description Symbol Description

Safety alert See Owner’s

Manual

Avoid smoking, flames, or sparks

Brake fluid – non petroleum base

Check fuel cap

Child seat tether anchor

Battery Battery acid

Brake system Cabin air

Child Safety Door Lock and Unlock

Cruise control

Anti-lock braking system

filter

Child seat lower anchor

Do not open when hot

Engine air filter

Engine oil Explosive gas Fan warning

Fasten safety belt

Engine coolant

Front airbag Front fog

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

Engine coolant temperature

lamps

Introduction 9

Symbol Description Symbol Description Symbol Description

Fuel pump reset

Heated rear window

Lighting control

Panic alarm Parking aid

Fuse compartment

Interior luggage compartment release

Low tire pressure warning

system

Hazard warning flasher

Jack

Maintain correct fluid level

Parking brake system

Power steering fluid

Service engine soon

Windshield defrost and demist

Power windows front and rear

Side airbag Stability

Windshield washer and wiper

Power window lockout

control

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

10 Introduction

DATA RECORDING

Service Data Recording

Service data recorders in your vehicle are capable of collecting and storing diagnostic information about your vehicle. This potentially includes information about the performance or status of various systems and modules in the vehicle, such as engine, throttle, steering or brake systems. In order to properly diagnose and service your vehicle, Ford Motor Company, Ford of Canada, and service and repair facilities may access or share among them vehicle diagnostic information received through a direct connection to your vehicle when diagnosing or servicing your vehicle. Additionally, when your vehicle is in for service or repair, Ford Motor Company, Ford of Canada, and service and repair facilities may access or share among them data for vehicle improvement purposes. For U.S. only (if equipped), if you choose to use the SYNC® Vehicle Health Report, you consent that certain diagnostic information may also be accessed electronically by Ford Motor Company and Ford authorized service facilities, and that the diagnostic information may be used for any purpose. See the SYNC® chapter for more information.

CALIFORNIA PROPOSITION 65

WARNING: Some constituents of engine exhaust, certain vehicle

components, certain fluids contained in vehicles and certain products of component wear contain or emit chemicals known to the State of California to cause cancer and birth defects or other reproductive harm.

PERCHLORATE MATERIAL

Note: Certain components in your vehicle, such as airbag modules, safety belt pretensioners, and remote control batteries, may contain perchlorate material. Special handling may apply for service or vehicle end of life disposal. See www.dtsc.ca.gov/hazardouswaste/perchlorate for more information.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

Introduction 11

FORD CREDIT (U.S. ONLY)

Ford Credit offers a full range of financing and lease plans to help you acquire your vehicle. If you have financed or leased your vehicle through Ford Credit, thank you for your business.

For your convenience, we offer a number of ways to contact us, as well as help manage your account.

Phone: 1-800-727-7000 For more information regarding Ford Credit, as well as access to

Account Manager, please go to www.fordcredit.com.

REPLACEMENT PARTS RECOMMENDATION

Your vehicle has been built to the highest standards using quality parts. We recommend that you demand the use of genuine Ford and Motorcraft parts whenever your vehicle requires scheduled maintenance or repair. You can clearly identify genuine Ford and Motorcraft parts by looking for the Ford, FoMoCo or Motorcraft branding on the parts or their packaging.

Scheduled Maintenance and Mechanical Repairs

One of the best ways for you to make sure that your vehicle provides years of service is to have it maintained in line with our recommendations using parts that conform to the specifications detailed in this owner’s manual. Genuine Ford and Motorcraft parts meet or exceed these specifications.

Collision Repairs

We hope that you never experience a collision, but accidents do happen. Genuine Ford replacement collision parts meet our stringent requirements for fit, finish, structural integrity, corrosion protection and dent resistance. During vehicle development, we validate that these parts deliver the intended level of protection as a whole system. A great way to know for sure you are getting this level of protection is to use genuine Ford replacement collision parts.

Warranty on Replacement Parts

Genuine Ford and Motorcraft replacement parts are the only replacement parts that benefit from a Ford Warranty. Damage caused to your vehicle as a result of the failure of non-Ford parts may not be covered by the Ford Warranty. For additional information, see the terms and conditions of the Ford Warranty.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

12 Introduction

SPECIAL NOTICES

New Vehicle Limited Warranty

For a detailed description of what is covered and what is not covered by your vehicle’s New Vehicle Limited Warranty, see the warranty information that is provided to you along with your owner’s manual.

Special Instructions

For your added safety, your vehicle is fitted with sophisticated electronic controls.

MOBILE COMMUNICATIONS EQUIPMENT

Using mobile communications equipment is becoming increasingly important in the conduct of business and personal affairs. However, you must not compromise your own or others’ safety when using such equipment. Mobile communications can enhance personal safety and security when appropriately used, particularly in emergency situations. Safety must be paramount when using mobile communications equipment to avoid negating these benefits.

Mobile communication equipment includes, but is not limited to, cellular phones, pagers, portable email devices, text messaging devices and portable two-way radios.

WARNING: Driving while distracted can result in loss of vehicle

control, crash and injury. We strongly recommend that you use extreme caution when using any device that may take your focus off the road. Your primary responsibility is the safe operation of your vehicle. We recommend against the use of any handheld device while driving and encourage the use of voice-operated systems when possible. Make sure you are aware of all applicable local laws that may affect the use of electronic devices while driving.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

Introduction 13

FEDERAL HIGHWAY ADMINISTRATION REGULATION

Regulations such as those issued by the Federal Highway Administration or issued pursuant to the Occupational Safety and Health Act (OSHA), and state and local laws and regulations may require additional equipment for the way you intend to use the vehicle. It is the responsibility of the registered owner to determine the applicability of such laws and regulations to your intended use for the vehicle, and to arrange for the installation of required equipment. Your dealer has information about the availability of equipment which may be ordered for your vehicle.

ENTERING, EXITING OR CLIMBING ON THIS VEHICLE

WARNING: Do not carry items while entering, exiting or

climbing. Make sure you keep a firm grip. Always FACE the VEHICLE STEP and HANDLE SYSTEM while climbing up and down. Do not climb behind the cab unless you have three point contact with a step and handle system at all times.

You must be careful and deliberate to minimize the possibility of personal injury from a slip and fall when entering, exiting or climbing on this vehicle. Always use the steps and assist handles before climbing. Do not skip any steps or assist handles. Use three point contact at all times with at least two feet and one hand or two hands and one foot firmly placed during all phases of entering, exiting or climbing. Always keep your shoe soles and hands clean. Keep the steps and assist handles free of snow, ice, oil, grease, substances or debris. Be sure to use extra care in bad weather. Avoid wearing thick gloves. Always perform trailer hook-up while standing on the ground.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

14 Vehicle Inspection Guide

VEHICLE INSPECTION INFORMATION

To be sure your vehicle is ready to operate, conduct a pre-trip inspection at the beginning of each work period. Follow the steps listed in this section to ensure a proper vehicle inspection procedure. The pages in this section may be produced locally and used on a regular basis.

WARNING: Exercise great caution when working on a vehicle

equipped with an automatic fan clutch. The fan starts in motion only after the engine coolant reaches a predetermined temperature or the refrigerant pressure (if equipped with air conditioning) reaches a predetermined setting. The fan starts at this point with no advance warning. Never reach near, or permit objects to protrude into, the fan blade radius while the engine is running as this could result in vehicle damage, personal injury or death.

WARNING: Do not operate the vehicle if any suspension

conditions listed in the following charts are evident. Loss of steering or suspension could result in property damage, personal injury or death.

WARNING: If a wheel must be changed, obtain expert tire

service help. Mounting and un-mounting of tires should only be performed by a qualified technician using necessary safety procedures and equipment, otherwise the result could be property damage, personal injury or death.

Note: Always make sure the parking brake is applied before starting the engine.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

Vehicle Inspection Guide 15

Engine Compartment (with Engine Stopped)

Engine Oil Use the dipstick to verify the oil level is in the

proper operating range. See Engine oil check in the Maintenance chapter.

Engine Coolant Look through the plastic reservoir or the clear

sight glass on the reservoir (depending upon vehicle equipment) and verify the coolant level is within the proper operating range. Do not

remove the pressure cap until the coolant has cooled. See Engine coolant check in the

Maintenance chapter.

Power Steering Fluid

Brake Fluid Remove the master cylinder caps and inspect the

Clutch Fluid Remove the cap and inspect the fluid level. See

Belts (Fan, Alternator, Water Pump and A/C Compressor)

Fluid Leaks Inspect for signs of fluid puddles or dripping fluid

HVAC Air Inlet Inspect for debris that may have collected on the

Verify that the fluid level is in the proper operating range. See Power steering fluid check in the Maintenance chapter.

fluid level. See Brake fluid check in the

Maintenance chapter.

Clutch fluid and linkage in the Maintenance

chapter. Inspect for glazing, fraying or cracking. There

should be no more than 5-7 cracks per rib, per inch (2.5 cm).

on the ground under the engine, or the underside of the engine.

HVAC air inlet grille or inside the exterior module as this may reduce system performance.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

16 Vehicle Inspection Guide

Engine Starting (Parking Brake Applied)

Safety and Emergency Equipment

Starting the Engine

Engine Oil Pressure

Air Chime (If Equipped with an Air Compressor)

Accelerator Press the accelerator and verify that it operates

• Before entering the cab, verify that the vehicle is equipped with spare electrical fuses (if used), three red reflective triangles, a properly charged and rated fire extinguisher and wheel chocks.

• Walk around the vehicle and verify all steps and grab handles, inside and out (as well as behind), are tight and clean. Use extreme caution and a three-point stance at all times.

• Inspect door latches for proper closing, latching and locking.

Set the parking brake. If starting a vehicle with a manual transmission, press the clutch and verify the transmission is in neutral. If starting a vehicle with an automatic transmission, make sure the gearshift lever is in position N or P (if equipped with a park position). Diesel engine: Turn the key to the on position. Turn the key to start when the wait to start indicator light in the instrument cluster turns off. Gasoline engine: Turn the key to start, then release it as soon as the engine starts.

Verify pressure builds to normal operating range.

The low air pressure warning chime should sound immediately after the engine starts but before the compressor has built-up pressure. The chime should stop when the air pressure reaches 70 psi (483 kPa) (or more). Let the air pressure build to governed cut-out pressure, which should occur between 115–130 psi (793–896 kPa).

smoothly, without any binding or irregular feel. Release the pedal and verify the engine returns to idle speed immediately.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

Vehicle Inspection Guide 17

Engine Starting (Parking Brake Applied)

Voltmeter Check the gauge (diesel engine) or indicator light

(gasoline engine) to verify the alternator is charging.

Steering Linkage Free Play

Full Power Hydraulic Brake Inspection

Parking Brake Verify the parking brake holds the vehicle by

Inspect for excessive free play in the steering linkages. The steering wheel should have less than 2 in. (5 cm) of free play at its rim.

Pump the brake pedal several times with the ignition in the off or run position. The motor/pumps can be heard momentarily replenishing the accumulators.

gently trying to pull forward with the parking brake applied.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

18 Vehicle Inspection Guide

Engine Starting (Parking Brake Applied)

Air Brakes Verify operation using the following procedure.

Chock the wheels, if necessary. Push in the parking brake and, on tractors, push in the tractor parking brake knob:

1. Verify the air compressor or governor cut-out pressure is approximately 120 psi (827 kPa).

2. Turn off the engine, then turn the key back to the on position (without starting the engine).

3. Without the brake pedal applied, note the air pressure drop for one minute. It should be less than 2 psi (14 kPa) for single vehicles and 3 psi (21 kPa) for combination vehicles.

4. Press and hold the brake pedal with 90 psi (621 kPa) or more. Make sure there is no more than a 3 psi (21 kPa) per minute leak for single vehicles and a 4 psi (28 kPa) per minute leak for combination vehicles.

5. Pump the brake pedal to deplete the system of air pressure. The warning light and chime should activate at 57 psi (393 kPa).

6. Pump the brake pedal and make sure the parking brake and trailer parking brake knobs pop out at 20 psi (138 kPa) or higher.

Automatic Transmission Fluid

Verify that the fluid level is in the proper operating range. See Transmission fluid check in the Maintenance chapter.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

Vehicle Inspection Guide 19

Front of Vehicle

Lights Verify:

• all exterior lights illuminate and are clean

• headlights function on high and low beam

• reflectors are clean, unbroken and of proper

color (red on rear, amber elsewhere)

• running lights are clean and unbroken.

Steering Gear Inspect for:

• missing or loose fasteners

• power steering fluid leaks

• damage to power steering hoses.

Steering Linkage Verify:

• connecting links, arms and rods are not worn or cracked

• joints, sockets and boot seals are not worn or loose

• cotter keys, nuts and bolts are not loose or missing.

Tow Hooks Inspect front and rear tow hooks for damage or

loose mounting. This is particularly important on vehicles when they are used frequently.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

20 Vehicle Inspection Guide

Front Suspension

Springs Inspect for leaves that may be:

• missing

• broken

• shifted

• in contact with (or nearly contacting) a tire,

rim, brake drum, frame or body component.

Note: Never apply grease to spring pads.

Spring Mounts Inspect the following for cracks, breaks, wear,

damage and tightness:

• spring hangers

• bolts

• bushings

• axle mounting bolts

• nuts.

Shock Absorbers Inspect for:

• cracks

• leaks

• missing or broken bolts or bushings.

Front Brakes

Hoses • Inspect for cracked, worn or frayed hoses.

• Verify all couplings are secured.

Brake Chambers Verify:

• there are no cracks or dents

• they are securely mounted.

Slack Adjusters Inspect for broken, loose or missing parts.

Note: The angle between the push rod and

adjuster arm should be approximately 90° when the brakes are applied. When pulled by hand, the push rod should not move more than approximately one inch (2.5 cm).

Drums Verify:

• there are no cracks, dents, holes, and no loose or missing bolts

• the brake linings are not worn, dangerously thin or contaminated by lubricant.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

Vehicle Inspection Guide 21

Front Wheels

Rims Inspect for damaged or bent rims. They should

not have welding repairs, and there should be no rust trails that indicate it is loose on the wheel.

Lug Nuts Verify all lug nuts are present and not loose (look

for rust trails around the lug nuts). There should be no cracks radiating from the lug bolt holes or distortion of the bolt holes.

Hub Oil Seals Inspect wheel hub oil seal for leaks and, if sight

glass if present, verify the oil level is adequate.

Oil-lubricated Front Wheel Bearings

Fuel Tank(s) Verify:

Leaks Inspect for leaks from the tank(s).

DEF Tanks Verify:

Leaks Inspect for leaks from the tanks.

Inspect for proper lubrication level if the hubcap has a transparent window. If the hubcap does not have a transparent window, remove the rubber fill-plug and inspect for proper level.

Fuel Area

• tank(s) and cap(s) are secure

• there is no damage to the tank(s).

Diesel Exhaust Fluid (DEF) Area

• tanks and caps are secure

• there is no damage to the tanks.

Underbody

Driveshaft Verify:

• the driveshaft is not bent or cracked

• all driveshaft couplings are secure.

Exhaust System Verify:

• the visible outside parts are securely mounted

• there are no cracks, holes or severe dents.

Frame • Inspect for cracks or bends in longitudinal

frame members.

• Verify there are no loose, cracked, bent, broken or missing crossmembers or crossmember fasteners.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

22 Vehicle Inspection Guide

Rear of Vehicle

Air Hoses and Electrical Lines

Deck Plate Verify deck plate is clean, securely bolted to the

Turns Signals, Brake Lights and Flashers

Lights and Reflectors

• Verify air hoses and electrical line insulation are not cut, cracked, chafed or worn. Listen for audible air leaks.

• Verify air and electrical lines are not tangled, crimped or pinched or being dragged against any truck parts. None of the air or electrical line should be spliced or taped.

• Inspect for corrosion on pins and in electrical sockets to ensure continuity and reduced heat build-up potential.

frame and clear of loose objects. Verify:

• both brake lights illuminate when the pedal is applied

• each signal flashes

• four-way flashers work properly.

Verify:

• all exterior lights illuminate and are clean

• reflectors are clean, unbroken and of proper

color (red on rear, amber elsewhere)

• running lights are clean and unbroken. Note: Rear running lights must be inspected separately from signal, flasher and brake lights.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

Vehicle Inspection Guide 23

Tractor-Coupling System

Mounting Bolts Inspect for loose or missing mounting brackets,

clamps, bolts or nuts. Both fifth-wheel and slide mounting must be solidly attached.

Platform Inspect for cracks or breaks in the platform

structure.

Safety Latch Verify safety latch is engaged. Release Arm Verify:

• the safety latch is in the engaged position

• any safety latch is in place.

Kingpin and Apron

Springs • Inspect for broken or shifted leaves or leaves

Spring Mounts Inspect for:

Torsion Arm and Shock Absorbers

Verify:

• the kingpin is not bent or worn

• the apron lies flat on the fifth-wheel skid plate

• the visible part of the apron is not bent, worn,

cracked or broken.

Rear Suspension

that are in contact with (or nearly contacting) a tire, rim, brake drum, frame or body component.

• Inspect for missing or broken leaves in the leaf spring.

• cracked or broken spring hangers

• broken, missing or loose bolts

• missing or damaged bushings

• broken, loose or missing axle mounting parts.

• Verify torsion arm is not cracked, broken or

missing.

• Inspect the shock absorber for cracks or leaks. There should be no missing or broken mounting bolts or worn bushings.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

24 Vehicle Inspection Guide

Rear Brakes

Hoses • Inspect for cracked, worn or frayed hoses.

• Verify all couplings are secured.

Brake Chambers Verify:

• there are no cracks or dents

• they are securely mounted.

Slack Adjuster Inspect for broken, loose or missing parts.

Note: The angle between the push rod and

adjuster arm should be approximately 90° when the brakes are applied. When pulled by hand, the push rod should not move more than approximately one inch (2.5 cm).

Drum Verify:

• there are no cracks, dents, holes and no loose or missing bolts

• the brake linings are not worn, dangerously thin or contaminated by lubricant.

Rear Wheels

Spacers Verify:

• dual wheels are evenly separated

• the tires are not touching one another.

Rims Inspect for damaged or bent rims. Rims should

not have welding repairs, and no rust trails that indicate it is loose on the wheel.

Lug Nuts Verify all lug nuts are present and not loose (look

for rust trails around the lug nuts). There should be no cracks radiating from the lug bolt holes or distortion of the bolt holes.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

Vehicle Inspection Guide 25

Trailer

If you are pulling a trailer, an inspection of the trailer similar to that of the tractor should be done. The inspection should follow trailer manufacturer recommendations and should include at a minimum: general condition, landing gear, doors, sides, lights, reflectors, suspension, brakes, tires, wheels, cargo placement, stability and tie-downs.

Transmission

WARNING: If the unit starts in gear and/or the neutral start switch is not functioning correctly, the vehicle may inadvertently

move which could result in property damage, personal injury or death.

If your vehicle is equipped with an automatic transmission, regularly inspect the transmission’s neutral start switch. The engine should only start in position N or P.

Inspect the transmission fluid level and shift linkage for proper operation.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

26 Child Safety

GENERAL INFORMATION

See the following sections for directions on how to properly use safety restraints for children.

WARNING: Always make sure your child is secured properly in a

device that is appropriate for their height, age and weight. Child safety restraints must be bought separately from your vehicle. Failure to follow these instructions and guidelines may result in an increased risk of serious injury or death to your child.

WARNING: All children are shaped differently. The

recommendations for safety restraints are based on probable child height, age and weight thresholds from NHTSA and other safety organizations, or are the minimum requirements of law. Ford recommends checking with a NHTSA Certified Child Passenger Safety Technician (CPST) and consulting your pediatrician to make sure your child seat is appropriate for your child, and is compatible with and properly installed in your vehicle. To locate a child seat fitting station and CPST, contact the NHTSA toll free at 1-888-327-4236 or on the internet at http://www.nhtsa.dot.gov. In Canada, check with your local St. John Ambulance office for referral to a CPST or for further information, contact your provincial ministry of transportation, or locate your local St. John Ambulance office by searching for St. John Ambulance on the internet, or Transport Canada at 1–800–333–0371 (http://www.tc.gc.ca). Failure to properly restrain children in safety seats made especially for their height, age, and weight may result in an increased risk of serious injury or death to your child.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

Child Safety 27

Recommendations for Safety Restraints for Children

Child size, height, weight, or age

Infants or toddlers

Small children

Larger children

• You are required by law to properly use safety seats for infants and toddlers in the United States and Canada.

• Many states and provinces require that small children use approved booster seats until they reach age eight, a height of 4 feet 9 inches (1.45 meters) tall, or 80 pounds (36 kilograms). Check your local and state or provincial laws for specific requirements about the safety of children in your vehicle.

• When possible, always properly restrain children twelve (12) years of age and under in a rear seating position of your vehicle. Accident statistics suggest that children are safer when properly restrained in the rear seating positions than in a front seating position. See Front Passenger Sensing System in the Supplementary Restraints System chapter for more information.

Children weighing 40 lb (18 kg) or less (generally age four or younger).

Children who have outgrown or no longer properly fit in a child safety seat (generally children who are less than 4 ft. 9 in. (1.45 m) tall, are greater than age four (4) and less than age twelve (12), and between 40 lb (18 kg) and 80 lb (36 kg) and upward to 100 lb (45 kg) if recommended by your child restraint manufacturer).

Children who have outgrown or no longer properly fit in a belt-positioning booster seat (generally children who are at least 4 ft. 9 in. (1.45 m) tall or greater than 80 lb (36 kg) or 100 lb (45 kg) if recommended by child restraint manufacturer).

Recommended restraint type

Use a child safety seat (sometimes called an infant carrier, convertible seat, or toddler seat).

Use a belt-positioning booster seat.

Use a vehicle safety belt having the lap belt snug and low across the hips, shoulder belt centered across the shoulder and chest, and seat back upright.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

28 Child Safety

CHILD SEATS

Use a child safety seat (sometimes called an infant carrier, convertible seat, or toddler seat) for infants, toddlers or children weighing 40 pounds (18 kilograms) or less (generally age four or younger).

CHILD SEAT POSITIONING

WARNING: Airbags can kill or injure a child in a child seat.

Never place a rear-facing child seat in front of an active airbag. If you must use a forward-facing child seat in the front seat, move the vehicle seat upon which the child seat is installed all the way back. When possible, all children age 12 and under should be properly restrained in a rear seating position. If all children cannot be seated and restrained properly in a rear seating position, properly restrain the largest child in the front seat.

WARNING: Always carefully follow the instructions and

warnings provided by the manufacturer of any child restraint to determine if the restraint device is appropriate for your child’s size, height, weight, or age. Follow the child restraint manufacturer’s instructions and warnings provided for installation and use in conjunction with the instructions and warnings provided by your vehicle manufacturer. A safety seat that is improperly installed or utilized, is inappropriate for your child’s height, age, or weight or does not properly fit the child may increase the risk of serious injury or death.

WARNING: Never let a passenger hold a child on his or her lap

while your vehicle is moving. The passenger cannot protect the child from injury in a crash, which may result in serious injury or death.

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

Child Safety 29

WARNING: Never use pillows, books, or towels to boost a child. They can slide around and increase the likelihood of injury or

death in a crash.

WARNING: Always restrain an unoccupied child seat or booster seat. These objects may become projectiles in a crash or sudden

stop, which may increase the risk of serious injury.

WARNING: Never place, or allow a child to place, the shoulder

belt under a child’s arm or behind the back because it reduces the protection for the upper part of the body and may increase the risk of injury or death in a crash.

WARNING: To avoid risk of injury, do not leave children or pets

unattended in your vehicle.

Use any attachment method as indicated

below by “X”

Restraint Type

Rear facing child seat

Forward facing child seat

Child

Weight

Up to 48 lb (21 kg)

Over 48 lb (21 kg)

LATCH (lower anchors and top tether anchor)

LATCH (lower anchors only)

Safety belt and top tether anchor

Safety belt and LATCH (lower anchors and top tether anchor)

Safety belt only

2013 F-650/750 (f67) Owners Guide gf, 2nd Printing, March 2013 USA (fus)

+ 348 hidden pages