Material name: Safetec® Burn Spray
2115 Version #: 01 Issue date: 01-30-2015
SDS US
1 / 6
SAFETY DATA SHEET
1. Identification
Product identifier Safetec® Burn Spray
Other means of identification
Recommended use
Recommended restrictions
Manufacturer/Importer/Supplier/Distributor information
Manufacturer
Manufacturer:
Company Telephone:
E-mail Address:
Emergency Telephone:
Supplier
2. Hazard(s) identification
Physical hazards
Health hazards
Environmental hazards
OSHA defined hazards
Label elements
Hazard symbol
Signal word
Hazard statement
Precautionary statement
Prevention
Response
Storage
Disposal
Hazard(s) not otherwise
classified (HNOC)
Supplemental information
3. Composition/information on ingredients
Mixtures
Chemical name Common name and synonyms
Propylene Glycol Propane-1,2-diol
2-Hydroxypropanol
Lidocaine 6108-05-0
4. First-aid measures
Inhalation
Skin contact
Eye contact
Ingestion
Not available.
Not available.
None known.
Safetec of America, Inc.
887 Kensington Avenue
Buffalo, NY 14215
1-716-895-1822
www.safetec.com
1-800-255-3924
Refer to Manufacturer
This mixture does not meet the classification criteria according to OSHA HazCom 2012.
This mixture does not meet the classification criteria according to OSHA HazCom 2012.
This mixture does not meet the classification criteria according to OSHA HazCom 2012.
This mixture does not meet the classification criteria according to OSHA HazCom 2012.
None.
None.
The mixture does not meet the criteria for classification.
None required according to OSHA Hazcom 2012.
None required according to OSHA Hazcom 2012.
None required according to OSHA Hazcom 2012.
None required according to OSHA Hazcom 2012.
None known.
None.
CAS number %
57-55-6
If symptoms develop move victim to fresh air. Get medical attention if symptoms persist.
Wash off with warm water and soap. Get medical attention if symptoms occur.
Any material that contacts the eye should be washed out immediately with water. If easy to do,
remove contact lenses. Get medical attention if symptoms persist.
Seek medical advice.
3
2
Material name: Safetec® Burn Spray
2115 Version #: 01 Issue date: 01-30-2015
SDS US
2 / 6
Most important
symptoms/effects, acute and
delayed
Indication of immediate
Direct contact with eyes may cause temporary irritation.
Treat symptomatically.
medical attention and special
treatment needed
5. Fire-fighting measures
Suitable extinguishing media
Unsuitable extinguishing
media
Specific hazards arising from
the chemical
Special protective equipment
and precautions for firefighters
Fire fighting
equipment/instructions
General fire hazards
Hazardous combustion
products
Water. Water Spray or Fog. Dry chemicals. Foam. Carbon dioxide (CO2).
Do not use water jet as an extinguisher, as this will spread the fire.
Thermal decomposition or combustion may liberate toxic gases or fumes.
None known.
Self-contained breathing apparatus and full protective clothing must be worn in case of fire.
No unusual fire or explosion hazards noted.
Carbon oxides. Nitrogen oxides (NOx). Halogenated compounds.
6. Accidental release measures
Personal precautions,
protective equipment and
emergency procedures
Methods and materials for
containment and cleaning up
Environmental precautions
Keep unnecessary personnel away. Wear appropriate personal protective equipment. Do not
touch damaged containers or spilled material unless wearing appropriate protective clothing. For
personal protection, see section 8 of the SDS.
Absorb spill with vermiculite or other inert material, then place in a sealed container for chemical
waste.
Large Spills: Flush with plenty of water. Prevent entry into waterways, sewer, basements or
confined areas. Dike for later disposal.
Small Spills: Wipe up with absorbent material (e.g. cloth, fleece). Clean surface thoroughly to
remove residual contamination.
Avoid discharge into drains, water courses or onto the ground.
7. Handling and storage
Precautions for safe handling
Conditions for safe storage,
including any incompatibilities
When using, do not eat, drink or smoke. Wear appropriate personal protective equipment. Use
only with adequate ventilation. Wash thoroughly after handling.
Keep container tightly closed. Keep cool. Store away from incompatible materials.
8. Exposure controls/personal protection
Occupational exposure limits
US. Workplace Environmental Exposure Level (WEEL) Guides
Components Type Value
Propylene Glycol (CAS
57-55-6)
Biological limit values
Appropriate engineering
No biological exposure limits noted for the ingredient(s).
Ensure adequate ventilation, especially in confined areas.
controls
Individual protection measures, such as personal protective equipment
Eye/face protection
Wear safety glasses with side shields (or goggles).
Skin protection
Hand protection
Other
Chemical resistant gloves recommended.
Wear chemical-resistant gloves, footwear, and protective clothing appropriate for the risk of
exposure. Contact health or safety professional or manufacturer for specific information.
TWA 10 mg/m3 Aerosol.
Form
Material name: Safetec® Burn Spray
2115 Version #: 01 Issue date: 01-30-2015
SDS US
3 / 6
Respiratory protection
If engineering controls do not maintain airborne concentrations below recommended exposure
limits (where applicable) or to an acceptable level (in countries where exposure limits have not
been established), an approved respirator must be worn. Contact health and safety professional or
manufacturer for specific information.
Thermal hazards
General hygiene
considerations
Not available.
Always observe good personal hygiene measures, such as washing after handling the material
and before eating, drinking, and/or smoking. Routinely wash work clothing and protective
equipment to remove contaminants.
9. Physical and chemical properties
Appearance
Physical state
Form
Color
Odor
Odor threshold
6.5
pH
Melting point/freezing point
Initial boiling point and boiling
range
Flash point
Evaporation rate
Flammability (solid, gas)
Upper/lower flammability or explosive limits
Flammability limit - lower
(%)
Flammability limit - upper
(%)
Explosive limit - lower (%)
Explosive limit - upper (%)
Vapor pressure
Vapor density
Relative density
Solubility(ies)
Solubility (water)
Partition coefficient
(n-octanol/water)
Auto-ignition temperature
Decomposition temperature
Viscosity
Other information
Specific gravity
0.99
Liquid.
Liquid.
Liquid.
Colorless.
Not available.
Not available.
Not available.
Not available.
Not available.
Not available.
Not applicable.
Not available.
Not available.
Not available.
Not available.
Not available.
Not available.
Not available.
Complete.
Not available.
Not available.
Not available.
Not available.
10. Stability and reactivity
Reactivity
Chemical stability
Possibility of hazardous
reactions
Conditions to avoid
Incompatible materials
Hazardous decomposition
products
The product is stable and non-reactive under normal conditions of use, storage and transport.
Stable at normal conditions.
Hazardous polymerization does not occur.
High temperatures.
Strong oxidizing agents. Acids.
Carbon oxides. Nitrogen oxides (NOx). Halogenated compounds.
Material name: Safetec® Burn Spray
2115 Version #: 01 Issue date: 01-30-2015
SDS US
4 / 6
11. Toxicological information
Information on likely routes of exposure
Inhalation
Skin contact
Eye contact
Ingestion
Most important
symptoms/effects, acute and
delayed
Information on toxicological effects
Acute toxicity
Components Species
Lidocaine (CAS 6108-05-0)
Acute
Oral
Skin corrosion/irritation
Serious eye damage/eye
irritation
Respiratory or skin sensitization
Skin sensitizer
Germ cell mutagenicity
Carcinogenicity
Reproductive toxicity
Specific target organ toxicity -
single exposure
Specific target organ toxicity -
repeated exposure
Aspiration toxicity
LD50 Mouse
Respiratory sensitization
OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050)
Not listed.
Under normal conditions of intended use, this material is not expected to be an inhalation hazard.
No adverse effects due to skin contact are expected.
Direct contact with eyes may cause temporary irritation.
No harmful effects expected in amounts likely to be ingested by accident.
Direct contact with eyes may cause temporary irritation.
No adverse effects are expected.
This product is not classified as a skin corrosive or irritant.
Direct contact with eyes may cause temporary irritation.
This product is not expected to cause respiratory sensitization.
This product is not expected to cause skin sensitization.
No data available to indicate product or any components present at greater than 0.1% are
mutagenic or genotoxic.
This product is not considered to be a carcinogen by IARC, ACGIH, NTP, or OSHA.
This product is not expected to cause reproductive effects.
Not classified as a specific target organ toxicity -single exposure.
Not classified as a specific target organ toxicity -repeated exposure.
Not expected to be an aspiration hazard.
12. Ecological information
Ecotoxicity
Persistence and degradability
Bioaccumulative potential
Mobility in soil
Other adverse effects
Not expected to be harmful to aquatic organisms.
Not available.
Not available.
Not available.
No other adverse environmental effects (e.g. ozone depletion, photochemical ozone creation
potential, endocrine disruption, global warming potential) are expected from this component.
13. Disposal considerations
Disposal instructions
Local disposal regulations
Hazardous waste code
Waste from residues / unused
products
Contaminated packaging
Collect and reclaim or dispose in sealed containers at licensed waste disposal site.
Dispose in accordance with all applicable regulations.
The waste code should be assigned in discussion between the user, the producer and the waste
disposal company.
Dispose of in accordance with local regulations. Empty containers or liners may retain some
product residues. This material and its container must be disposed of in a safe manner (see:
Disposal instructions).
Empty containers should be taken to an approved waste handling site for recycling or disposal.
Since emptied containers may retain product residue, follow label warnings even after container is
emptied.
Test Results
292 mg/kg
Material name: Safetec® Burn Spray
2115 Version #: 01 Issue date: 01-30-2015
SDS US
5 / 6
14. Transport information
DOT
Not regulated as dangerous goods.
IATA
Not regulated as dangerous goods.
IMDG
Not regulated as dangerous goods.
Transport in bulk according to
Not available.
Annex II of MARPOL 73/78 and
the IBC Code
15. Regulatory information
US federal regulations
TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D)
Not regulated.
CERCLA Hazardous Substance List (40 CFR 302.4)
Not listed.
SARA 304 Emergency release notification
Not regulated.
OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050)
Not listed.
Superfund Amendments and Reauthorization Act of 1986 (SARA)
Hazard categories
SARA 302 Extremely hazardous substance
Not listed.
SARA 311/312 Hazardous
chemical
SARA 313 (TRI reporting)
Not regulated.
Other federal regulations
Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List
Not regulated.
Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130)
Not regulated.
Safe Drinking Water Act
(SDWA)
US state regulations
US. California Controlled Substances. CA Department of Justice (California Health and Safety Code Section 11100)
Not listed.
US. Massachusetts RTK - Substance List
Not regulated.
US. New Jersey Worker and Community Right-to-Know Act
Propylene Glycol (CAS 57-55-6)
US. Pennsylvania Worker and Community Right-to-Know Law
Propylene Glycol (CAS 57-55-6)
US. Rhode Island RTK
Not regulated.
US. California Proposition 65
California Safe Drinking Water and Toxic Enforcement Act of 1986 (Proposition 65): This material is not known to contain
any chemicals currently listed as carcinogens or reproductive toxins.
This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication
Standard, 29 CFR 1910.1200.
Immediate Hazard - Yes
Delayed Hazard - No
Fire Hazard - No
Pressure Hazard - No
Reactivity Hazard - No
Yes
Not regulated.
Material name: Safetec® Burn Spray
2115 Version #: 01 Issue date: 01-30-2015
SDS US
6 / 6
International Inventories
Country(s) or region Inventory name On inventory (yes/no)*
Australia Australian Inventory of Chemical Substances (AICS)
Canada Domestic Substances List (DSL)
Canada Non-Domestic Substances List (NDSL)
China Inventory of Existing Chemical Substances in China (IECSC)
Europe European Inventory of Existing Commercial Chemical
Substances (EINECS)
Europe European List of Notified Chemical Substances (ELINCS)
Japan Inventory of Existing and New Chemical Substances (ENCS)
Korea Existing Chemicals List (ECL)
New Zealand New Zealand Inventory
Philippines Philippine Inventory of Chemicals and Chemical Substances
(PICCS)
United States & Puerto Rico Toxic Substances Control Act (TSCA) Inventory
*A "Yes" indicates that all components of this product comply with the inventory requirements administered by the governing country(s)
A "No" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing
country(s).
16. Other information, including date of preparation or last revision
Issue date
Version #
Disclaimer
Bibliography
01
01-30-2015
Prepared by: ICC The Compliance Center Inc. 1-888-442-9628
http://www.thecompliancecenter.com
Disclaimer
This Safety Data Sheet was prepared by ICC The Compliance Center Inc. using information
provided by / obtained from and CCOHS’ Web Information Service. The information in the Safety
Data Sheet is offered for your consideration and guidance when exposed to this product. ICC The
Compliance Center Inc. and expressly disclaim all expressed or implied warranties and assume
no responsibilities for the accuracy or completeness of the data contained herein. The data in this
SDS does not apply to use with any other product or in any other process.
This Safety Data Sheet may not be changed, or altered in any way without the expressed
knowledge and permission of ICC The Compliance Center Inc. and
ACGIH Documentation of the Threshold Limit Values and Biological Exposure Indices (2014)
Canadian Centre for Occupational Health and Safety, CCInfoWeb Databases, 2014
(Chempendium, RTECs, HSDB, INCHEM)
European Chemicals Bureau, Existing Chemicals Work Area, EINECS Information System, 2014.
Material Safety Data Sheet from manufacturer.
OECD - The Global Portal to Information on Chemical Substances - eChemPortal, 2014.
No
No
No
No
No
No
No
No
Yes
No
No
Loading...