Extech PH7-P Data sheet

Material Safety Data Sheet

Product: PH7-P Buffer Solution 7.00 pH
Date of Preparation: 10/04

Section 1 - Chemical Product and Company Identification

Product/Chemical Name: PH7-P Buffer Solution 7.00 pH
Chemical Formula: Analytical Testing Reagent for Laboratory or Field Use
Emergency Telephone: [phone] (ChemTel)
Manufacturer: Extech Instruments Corporation
285 Bear Hill Road
Waltham, MA. 02451-1064

Wood Dale, IL 60191

Section 2 - Composition/Information on Ingredients

Ingredient Name CAS Number % wt or % vol OSHA PEL ACGIH TLV

TWA STEL TWA STEL Other

Potassium Phosphate 7778770 0-3 None Est.
Monobasic

Non-Hazardous 0-97
Total 100

Section 3 - Hazards Identification

+ + + + Emergency Overview + + + +

HMIS
H= 1
F= 0

Potential Health Effects

Primary Entry Routes: Eye and Skin Contact.
Acute Effects: Irritation to eyes and skin.
Inhalation: High mist concentrations can cause irritation of eyes, nose, throat and lungs.
Eye: Irritation and/or burning sensation to eyes.

Skin: Prolonged or repeated contact may cause skin irritation.
Ingestion: Material is possibly harmful if swallowed.

Carcinogenity: IARC, NTP, and OSHA do not list this product or it=s components as a carcinogen.

Medical Conditions Aggravated by Long-Term Exposure: No specific information provided on compounds at date of issue.
Chronic Effects: No studies have been conducted for this product

R= 0
PPE C

+Sec.8

Section 4 - First Aid Measures

Inhalation: Remove to fresh air. Call a physician if any difficulties persist.
Eye Contact: Flush eyes with a large amount of water for 15 minutes. Seek medical attention immediately if any irritation persists.

After first aid, get appropriate in-plant, paramedic or community medical support.
Skin Contact: Wash affected areas thoroughly with soap and water for at least 15 minutes. Seek medical attention if any irritation
persists.
Ingestion: If swallowed, give 2 glasses of water to drink. DO NOT induce vomiting. After first aid, seek appropriate in-plant,
paramedic, or community medical support. Never give anything by mouth to an unconscious person.

After first aid, get appropriate in-plant, paramedic, or community medical support.

Product: PH7-P Buffer Solution 7.00 pH

Section 5 - Fire-Fighting Measures

Flash Point: Non-Flammable
Flash Point Method: Not applicable
Burning Rate: Not applicable
Autoignition Temperature: Does not burn.
LEL:
UEL:
Flammability Classification: Non Flammable
Extinguishing Media: Water fog, Alcohol foam, Carbon Dioxide, Dry Chemical
Unusual Fire or Explosion Hazards: None known other than material can splatter above 100oC/212oF.
Hazardous Combustion Products: Unknown but carbon monoxide may be released on burning.
Fire-Fighting Instructions: Do not release runoff from fire control methods to sewers or waterways.
Fire-Fighting Equipment: Because fire may produce toxic thermal decomposition products, wear a self-

contained breathing apparatus (SCBA) with a full face piece operated in pressure-demand or positive-pressure mode.

Section 6 - Accidental Release Measures

Spill/Leak Procedures:
Small Spills: Absorb spill with paper towel or similar absorbent; or flush to sewer or ground with large amounts of water.
Large Spills:

Containment: For large spills, dike far ahead of liquid spill for later disposal. Do not release into sewers or
waterways. Absorb spill with vermiculite, oil dry or similar non-reactant absorbent.
Cleanup: Accumulate the absorbed materials and dispose of according to federal, state and local regulations.
Regulatory Requirements: Follow applicable OSHA regulations (29 CFR 1910.120)

Page 2

Section 7 - Handling and Storage

Handling Precautions: Use the recommended safety controls and personal protective equipment as outlined. Fully review all data

before handling of the material itself. Avoid contact with skin or eyes. Avoid breathing dust or mist. Keep from contact with clothing
and other combustible materials. Observe good personal hygiene and housekeeping practices.
Storage Requirements: Do not store this material near any strong acids, bases, oxidizers, flammables or any other type of reactive
material. Do not expose the material to temperature extremes.
Regulatory Requirements: Store materials according to all local, state and federal guidelines which are established for non­regulated chemical products.

Section 8 - Exposure Controls/Personal Protection

Engineering Controls:
Ventilation: Provide general or local exhaust ventilation systems to maintain airborne concentrations below OSHA PELs (Sec. 2).

Local exhaust ventilation is preferred because it prevents contaminant dispersion into the work area by controlling it at its source.

Administrative Controls:
Respiratory Protection: Seek professional advice prior to respirator selection and use. Follow OSHA respirator regulations (29

CFR 1910.134) and, if necessary, wear a MSHA/NIOSH-approved respirator. Select respirator based on its suitability to provide
adequate worker protection for given working conditions, level of airborne contamination, and presence of sufficient oxygen. For
emergency or nonroutine operations (cleaning spills, reactor vessel, or storage tanks), wear an SCBA. Warning! Air-purifying
respirators do not protect workers in oxygen-deficient atmospheres. If respirators are used, OSHA requires a written respiratory
protection program that includes at least: medical certification, training, fit-testing, periodic environmental monitoring, maintenance,
inspection, cleaning, and convenient, sanitary storage areas.
Protective Clothing/Equipment: Wear chemically protective gloves, boots, aprons, and gauntlets to prevent prolonged or repeated
skin contact. Wear protective eyeglasses or chemical safety goggles, per OSHA eye-and face-protection regulations (29 CFR

1910.133). Contact lenses are not eye protective devices. Appropriate eye protection must be worn instead of, or in conjunction with
contact lenses.

Safety Stations: Make emergency eyewash stations, safety/quick-drench showers, and washing facilities available in work area.
Contaminated Equipment: Separate contaminated work clothes from street clothes. Launder before reuse. Remove this material

from your shoes and clean personal protective equipment.
Comments: Never eat, drink, or smoke in work areas. Practice good personal hygiene after using this material, especially before
eating,drinking, smoking, using the toilet, or applying cosmetics.