EVO 10-0051 Installation Manual

OWNER & INSTALLATION MANUAL

the natural way to cook

®

®

Affinity 30Ge

Cooktop

Evo Affi nity 30Ge

Electronically-Controlled Gas Cooktop

For Indoor Use Only

This appliance and its individual shutoff valve must be
disconnected from the gas supply piping system during
any pressure testing of system at test pressures in
excess of 1/2 PSI (3.5kPa).

This appliance, when installed, must be electrically grounded in accordance with local codes,

or in the absence of local codes, with the National Electrical Code, ANSI/NFPA70,

or the Canadian Electrical Code, CSA C22.2, as applicable.

This appliance must be isolated from the gas supply
piping system by closing its individual manual shutoff
valve during any pressures testing of the gas supply
system at test pressures equal to or less than 1/2 PSI
(3.5kPa).

Cleaning Instructions

Certifi cation: ANSI Z83.11b-2009/CSA 1.8B-2009. OMNI Report # 0141GM004S
Part #: Commercial models: 10-0050-NG | 10-0050-LP
Residential models: 10-0051-NG | 10-0051-LP
Doc: OM-C&R-30Ge 01/2016
Copyright © 2016

Phone [phone] | Fax [phone] | www.evoamerica.com | [e-mail]

Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA

evoamerica.com

Warnings

INSTALLATION INSTRUCTIONS

Affinity 30Ge

FOR YOUR SAFETY

1. Do not store or use gasoline or other
fl ammable vapors and liquids under
this appliance or in the vicinity of this
or any other appliance.

2. An LP Tank not connected for use shall
not be stored in the vicinity of this or
any other appliance.

If You Smell Gas:

1. Shut off gas to appliance.

2. Extinguish any open fl ame.

3. Remove grill cooking surface.

4. If odor continues, immediately call your
gas supplier or your fi re department.

5. Evacuate all personnel from the area.

FOR YOUR SAFETY

POST THIS WARNING MESSAGE IN A PROMINENT LOCATION

If you suspect a natural gas leak or other gas emergency and are unsure of its severity or what
to do, evacuate the area immediately and call 911 from a safe location.

WARNING

Improper installation, adjustment, alteration, service or maintenance can cause property damage,
injury or death. Read the installation, operating and maintenance instructions thoroughly before
installing or servicing this equipment.

Grill is for indoor use only . Grill should be operated in a well-ventilated space. Never operate near
fl ammable liquids or vapors. Do not install or use grill within 36” of combustible materials from back and
sides of grill. Grill shall not be located under unprotected overhead made of combustible construction.

WARNING

WARNING

Do not block or obstruct air ventilation for combustion.

Do not attempt to light appliance during a power outage.

WARNING

It is the responsibility of the assembler/owner to
assemble, install and maintain gas grill. Do not
let children operate or play near your grill. Failure
to follow these instructions could result in serious
personal injury and / or property damage.

Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA

Phone [phone] | Fax [phone] | www.evoamerica.com | [e-mail]

WARNING

This symbol identifi es the most important
safety messaging in this manual. When you
see this symbol, be alert to the possibility of
serious bodily injury if the instructions are not
followed. Be sure to read and carefully follow
all of the messages.

1

INSTALLATION INSTRUCTIONS

Affinity 30Ge

THIS MANUAL MUST BE RETAINED FOR FUTURE REFERENCE. READ, UNDERSTAND,

AND FOLLOW THE INSTRUCTIONS AND WARNINGS CONTAINED IN THIS MANUAL.

DANGER

WARNING

CAUTION

CAUTION

POTENTIALLY HAZARDOUS SITUATION WHICH, IF NOT
AVOIDED, COULD RESULT IN DEATH

POTENTIALL Y HAZARDOUS SITUA TION WHICH, IF NOT A VOIDED,
COULD RESULT IN DEATH OR SERIOUS INJURY

POTENTIALL Y HAZARDOUS SITUA TION WHICH, IF NOT A VOIDED,
MAY RESULT IN MINOR OR MODERATE INJURY.

Helpful tips and technique instructions are shown.

HIGH

VOLTAGE

Notes

The installation of this cooking equipment must conform with local codes, or in the

absence of local codes, with the National Fuel Gas Code, ANSI Z223.1/NFPA 54, or the

Natural Gas and Propane Installation Code, CSA B149.1, as applicable.

To Installer or Person Uncrating Grill:

Leave these instructions with purchaser.

To Purchaser:

Keep these instructions for future reference.

Complete Now For Future Reference

Model #_______________________________ Serial # _________________________________
Date Purchased ________________________ Location Purchased _______________________
Date Installed __________________________ Location Installed _________________________

2

Phone [phone] | Fax [phone] | www.evoamerica.com | [e-mail]

Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA

INSTALLATION INSTRUCTIONS

Affinity 30Ge

READ FIRST

IMPORTANT PRODUCT AND SAFETY INFORMATION

WARNING INSTALLATION OF THIS UNIT MUST BE DONE BY A QUALIFIED PLUMBER

AND ELECTRICIAN. INCORRECT INSTALLATION CAN CAUSE INJURY
TO PERSONNEL AND/OR DAMAGE TO EQUIPMENT. THIS UNIT MUST BE
INSTALLED IN ACCORDANCE WITH ALL LOCAL AND UNIFORM BUILDING/

CONSTRUCTION CODES.

WARNING DO NOT INSTALL THIS UNIT TO COMBUSTIBLE SURFACES, AND DO

NOT USE COMBUSTIBLE MATERIALS IN THE CONSTRUCTION OF ANY
COUNTER, STAND, OR OTHER DEVICE.

WARNING THIS UNIT IS EQUIPPED WITH A THREE-PRONG (GROUNDING) PLUG FOR

YOUR PROTECTION AGAINST SHOCK HAZARD AND MUST BE PLUGGED
INTO GROUNDED RECEPTACLE. DO NOT MODIFY, CUT, OR REMOVE THE
GROUNDING PRONG FROM THIS PLUG.

WARNING IMMEDIATELY AFTER CONNECTING GAS SUPPLY LINE AND BEFORE

FIRST IGNITION, CHECK ALL GAS CONNECTIONS WITH SOAPY WATER
TO TEST FOR LEAKS.

WARNING KEEP WATER AND ALL COOKING SPILL OVERS AWAY FROM FRONT

CONTROL PANEL AND ALL OPEN SERVICE AREAS. NEVER HOSE UNIT,
OR SPRAY UNIT WITH CLEANING SOLUTIONS.

CAUTION CAREFULLY FOLLOW ALL INSTALLATION INSTRUCTIONS AND

CONSTRUCT ALL COUNTER SPACE, STANDS, OR OTHER SURFACES TO
THE RECOMMENDED INSTALLATION SPECIFICATIONS AS OUTLINED IN

THIS MANUAL.

CAUTION THIS UNIT IS HEAVY AND SHOULD BE INSTALLED BY TWO PEOPLE.

USE NECESSARY BLOCKING FOR LOCATING COOK SURFACE AND
CONNECTING TEMPERATURE SENSORS TO THE UNDERSIDE OF COOK

SURFACE.

CAUTION ALWAYS KEEP ANY AND ALL FLAMMABLE LIQUIDS AND COMBUSTIBLE

MATERIALS AWAY FROM UNIT. DO NOT STORE TOWELS OR UTENSILS,
OR ANY OTHER ITEMS ON UNIT’S DRIP PAN.

CAUTION DO NOT CLEAN THE COOK SURFACE WITH GRILL BRICKS OR CLEANING

SOLUTIONS. USE ONLY GRILL SCREENS AND GRILL PADS AND FOLLOW
THE PRESCRIBED METHOD OF CLEANING AS OUTLINED IN THIS
MANUAL.

NOTICE THE SERIAL NUMBER AND MODEL INFORMATION LABEL PLATE IS

LOCATED UNDERNEATH THE CONTROL PANEL.

NOTICE INSTALLATION OF ANY VENT HOODS OR FIRE EXTINGUISHER SYSTEMS

MUST CONFORM TO THE NATIONAL, STATE, AND LOCAL BUILDING AND
ALL APPLICABLE UNIFORM CONSTRUCTION CODES.

NOTICE DURING THE FIRST FEW HOURS OF OPERATION IT IS NORMAL FOR OILS

USED IN THE MANUFACTURING PROCESS TO BURN OFF AND GIVE AN
ODOR OR PETROLEUM SMOKE.

3

Phone [phone] | Fax [phone] | www.evoamerica.com | [e-mail]

Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA

INSTALLATION INSTRUCTIONS

Affinity 30Ge

EVO RESIDENTIAL LIMITED WARRANTY TERMS

Evo, Incorporated warrants to the original residential consumer-purchaser that the Evo grill shall be free from rust-through on all
metal surfaces and shall be free from defects in materials and workmanship under normal and reasonable use from the original
date of purchase. Evo promises to replace, at its determination, any product or component that is defective and covered under
this warranty for as long as you, the registered original consumer-purchaser, owns the grill. This is your sole and exclusive
remedy. This warranty is for the benefi t of the original consumer-purchaser and is non-transferable. This warranty is subject to the
limitations, exclusions and other provisions listed below.

Limitations Involving Materials and Components:

Warranty does not apply to normal wear and tear, which are expected over the course of ownership. The materials and
components listed below are covered according to the following schedule from the original date of purchase:

• One Year – electrical and electronic components [including, but not limited to, electronic displays, overlay and membrane
switches, temperature sensors (RTD and K-Value Thermal Couple), hot surface igniters, computers, transformers,
heater elements, relays, igniters, ignition controllers, wiring, switches, encoders, outlets and plugs

• One Year – gas components [including, but not limited to, gas regulator, gas hoses, manifold assemblies]

• One Year – accessories and repair parts

The Warranty Registration Card (or online warranty registration form available at www.evoamerica.com/content/
residential-warranty-registration) must be completed and returned/submitted to Evo, Incorporated within 30 days from the
date of purchase. The original purchase invoice or payment record must be retained and produced upon request if claims
are made under this warranty. To receive a replacement Warranty Registration Card, write or call the address listed at the
bottom of this page. Warranties are void if the original serial numbers have been removed, altered, or cannot be readily
determined.

THIS WARRANTY APPLIES ONLY TO PRODUCTS PURCHASED AND LOCATED WITHIN THE UNITED STATES
OR CANADA.

WHAT IS NOT COVERED BY THIS WARRANTY

1. Conditions and damages resulting from any of the following:

a. Improper or inadequate installation, delivery, use, storage or maintenance
b. Any repair not authorized in writing by Evo, Inc., any modifi cations, misapplications, or unreasonable use
c. Improper setting of any control
d. Harsh environmental conditions, including, but not limited to, continual seawater spray, high pressure water, and direct contact
with corrosive chemicals and materials
e. Excessive or inadequate electrical, or gas supply
f. Accidents, natural disasters, acts of God
g. Conditions covered by the purchaser’s insurance
h. Cleaning supplies and fi lters

2. Products purchased or utilized for commercial use without the express authorization of Evo, Incorporated for such use

3. Labor not pre-authorized by Evo, Incorporated, and labor not performed by an authorized Evo service agency or representative

4. Pre-authorized warranty labor performed outside of normal business hours, and at overtime and premium rates

5. The cost of service or a service call to:

a. Identify or correct installation errors
b. Transport the product or component for service to/from the manufacturer or service center
c. Instruct the user of the proper use of the product

6. The cost for any inconvenience, personal injury or property damage due to failure of the product, and cost of damage arising out

of the transportation of the product which is covered under different terms with the carrier

7. Natural variations in color and fi nishes that are inherent to the material and unavoidable (and therefore not defects)

ALL IMPLIED WARRANTIES, INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY, SUITABILITY,
QUALITY AND/OR FITNESS FOR A PARTICULAR PURPOSE, ARE LIMITED IN DURATION TO THE EXPRESS
WARRANTY PERIODS SPECIFIED ABOVE FOR THE PARTS DESCRIBED THEREIN. EVO, INCORPORATED
MAKES NO OTHER WARRANTY AND WILL NOT BE LIABLE FOR ANY DIRECT OR INDIRECT, CONSEQUENTIAL
OR INCIDENTAL DAMAGES. Some states do not allow limitations on how long an implied warranty lasts, so the above

limitation may not apply to you. Neither Evo manufacturer representatives and dealers, nor the retail establishment selling this
product has any authority to make any warranties or to promise remedies in addition to or inconsistent with those stated above.
The maximum liability to Evo, Incorporated in any event, shall not exceed the purchase price of the product paid by the original
consumer-purchaser. Some states do not allow the exclusion or limitation of incidental or consequential damages, so the above
limitations or exclusions may not apply to you. This warranty gives you specifi c legal rights, and you may also have other rights
which vary from state to state.

Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA

Phone [phone] | Fax [phone] | www.evoamerica.com | [e-mail]

4

SAFETY LABEL

INSTALLATION INSTRUCTIONS

Affinity 30Ge

Evo Affinity 30Ge Cooktop

FOR INDOOR USE ONLY

POUR UNE UTILISATION À L'INTÉRIEUR UNIQUEMENT

Report No. /Rapport n° 0141GM004S

THIS APPLIANCE EQUIPPED FOR USE ONLY WITH :

CET APPAREIL EST CONÇU UNIQUEMENT POUR ÊTRE UTILISÉ AVEC DU :

LP Propane Manifold Gas Pressure = 10” W.C
NG Natural Gas Manifold Gas Pressure = 4” W.C

CLEARANCE TO COMBUSTIBLE SURFACE FROM COOKING SURFACE

Min 3” clearance below unit venting to 22 sq/in of combustible air. For installation under

ventilation hood only. / Minimum 76mm de dégagement ci-dessous ventilation unité à

Evo is protected under U.S Patents 6,189,530 and 6,488,022 and U.S. Patents Pending.

Evo est protégé par des brevets É-U 6,189,530 et 6,488,022 et brevets É-U en instance.

BTU Input Rate Max / Débit calorifique max. en BTU :

Drill Size Orifice No. / Dimensions de l'orifice n° : Outer Ring :

CLEARANCE TO COMBUSTIBLE CONSTRUCTION FROM CHASSIS

DÉGAGEMENT D'UNE CONSTRUCTION COMBUSTIBLE PARTIR D'UN CHÂSSIS

Back

Sides

Bottom

DÉGAGEMENT AUX SURFACE COMBUSTIBLE DE LA SURFACE DE CUISSON

142 cm² dans l'air. Installer en dessous d’une hotte de ventilation seulement.

retour
côtés

bas

* 3/8” cement board / 9.53mm panneau de ciment

Top

Sides

haut

côtés

Anneau extérieur :

Combustible

Combustible

3/8”

*

3/8”

*

3”

Anneau intérieur :

9.53mm

9.53mm
76mm

Inner Ring :

36”
12”

C

LP

GPL

48,000

#52

1.61mm

#55

1.32mm

Non-combustible

Incombustible

0”
0“
3”

91cm
30cm

NG

0mm
0mm

76mm

Commercial Model #

Modèle commercial n°

Residential Model #

Modèle residential n°

GN

46,000

#41

2.44mm

#48

1.93mm

ANSI Z83.11b-2009/CSA 1.8b-2009

ELECTRICAL VOLTAGE

1-Phase, Max: 7 AMPS /

Evo, Inc., 8140 Nimbus Ave., Bldg 5

10-0050

10-0051

SERIAL NUMBER

N° SÉRIE

MANUFACTURE DATE

DATE DU CONSTRUCTEUR

Tested To / Testé pour:

FOOD SERVICE EQUIPMENT

ÉLECTRIQUE Le VOLTAGE

120V or/ou 220V / 50-60Hz

Manufactured By construit pres:

Beaverton, Oregon 97008 USA

Fabriqué aux É.-U. Made in USA.

AMPÈRES

09-12-/2014

5

Phone [phone] | Fax [phone] | www.evoamerica.com | [e-mail]

Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA

INSTALLATION INSTRUCTIONS

Affinity 30Ge

EVO COMMERCIAL LIMITED WARRANTY TERMS

Evo, Incorporated warrants to the original commercial foodservice purchaser that the Evo cooking, refrigeration and ventilation
equipment shall be free from rust through on all metal surfaces and shall be free from defects in materials and workmanship under
normal and reasonable use for One Year from the original date of purchase from Evo, Inc. This warranty is for the benefi t of the
original use purchaser and is non-transferable. Evo promises to replace, at its determination, any product or component that is
defective during this initial one year period. Or as a resolution, Evo may at its option repurchase the product at its original purchase
price. This is your sole and exclusive remedy. This warranty is subject to the limitations, exclusions and other provisions listed
below.

Limitations Involving Materials and Components:

Warranty does not apply to normal wear and tear, which are expected over the course of ownership. The materials and
components listed below are covered according to the following schedule from the original date of purchase from Evo:

• One Year – electrical and electronic components [including, but not limited to, electronic displays, overlay and membrane
switches, temperature sensors (RTD and K-Value Thermal Couple), hot surface igniters, computers, transformers,
heater elements, relays, igniters, ignition controllers, wiring, switches, encoders, outlets and plugs

• One Year – gas components [including, but not limited to, gas regulator, gas hoses, manifold assemblies]

• One Year – accessories and repair parts

• Ninety (90) Days - refrigeration components [including, but not limited to, compressor, evaporator, pressure control units]

The Warranty Registration Card (or online warranty registration form available at www.evoamerica.com/content/
commercial-warranty-registration) must be completed and returned/submitted to Evo, Incorporated within 30 days from
the date of purchase. The original purchase invoice or payment record must be retained and produced upon request if
claims are made under this warranty. To receive a replacement Warranty Registration Card, write or call the address listed
at the bottom of this page. Warranties are void if the original serial numbers have been removed, altered, or cannot be
readily determined.
THIS WARRANTY APPLIES ONLY TO PRODUCTS PURCHASED AND LOCATED WITHIN THE USA OR CANADA.

What is NOT COVERED by this warranty:

1. Conditions and damages resulting from any of the following:

a. Improper or inadequate installation, delivery, use, storage or maintenance
b. Any repair not authorized in writing by Evo, Inc., any modifi cations, misapplications, or unreasonable use
c. Improper setting of any control
d. Harsh environmental conditions, including, but not limited to, continual seawater spray, high pressure water, and direct contact
with corrosive chemicals and materials
e. Excessive or inadequate electrical, gas, or refrigeration supply
f. Accidents, natural disasters, acts of God
g. Conditions covered by the purchaser’s insurance
h. Cleaning supplies and fi lters

2. Labor not pre-authorized by Evo, Incorporated, and labor not performed by an authorized Evo service agency or

representative

3. Pre-authorized warranty labor performed outside of normal business hours, and at overtime and premium rates

4. The cost of service or a service call to:

a. Identify or correct installation errors
b. Transport the product or component for service to/from the manufacturer or service center
c. Instruct the user of the proper use of the product

5. The cost for any inconvenience, personal injury or property damage due to failure of the product, and cost of

damage arising out of the transportation of the product which is covered under different terms with the carrier

6. Natural variations in color and fi nishes that are inherent to the material and unavoidable (and therefore not defects)

ALL IMPLIED WARRANTIES, INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY, SUITABILITY, QUALITY
AND/OR FITNESS FOR A PARTICULAR PURPOSE, ARE LIMITED IN DURATION TO THE EXPRESS WARRANTY PERIODS
SPECIFIED ABOVE FOR THE PARTS DESCRIBED THEREIN. EVO, INCORPORATED MAKES NO OTHER WARRANTY AND
WILL NOT BE LIABLE FOR ANY DIRECT OR INDIRECT, CONSEQUENTIAL OR INCIDENTAL DAMAGES. Some states do not
allow limitations on how long an implied warranty lasts, so the above limitation may not apply to you. Neither Evo manufacturer
representatives and dealers, nor the commercial establishment selling this product has any authority to make any warranties
or to promise remedies in addition to or inconsistent with those stated above. The maximum liability to Evo, Incorporated in any
event, shall not exceed the purchase price of the product paid by the original commercial-purchaser. Some states do not allow the
exclusion or limitation of incidental or consequential damages, so the above limitations or exclusions may not apply to you. This
warranty gives you specifi c legal rights, and you may also have other rights which vary from state to state.

6

Phone [phone] | Fax [phone] | www.evoamerica.com | [e-mail]

Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA

INSTALLATION INSTRUCTIONS

Affinity 30Ge

INSTALLATION CHECKLIST

PAGE #

UNPACK COOKTOP COMPONENTS 8

CLEARANCE DIMENSIONS 9

PREPARE COUNTER TOP FOR INSTALLATION 10 - 13

INSERT CHASSIS IN COUNTER TOP 14

INSTALL DRIP PAN AND DRIP PAN GASKET 15 - 16

ASSEMBLING COOK SURFACE RETAINING FASTENERS 17

CONNECTING TEMPERATURE SENSOR WIRE TO 18
COOKING SURFACE

POSITIONING TEMPERATURE SENSORS AND 19
LOWERING COOKING SURFACE

RETAINING COOKING SURFACE 20

CONNECT ELECTRICAL AND GAS LINES 21

DISPLAY PANEL AND TEMPERATURE CONTROL 22 - 23

SPILLOVER TRAY REMOVAL AND CLEANING 24

COOKING SURFACE MAINTENANCE 25

APPENDIX - CONTROL COMPONENTS 26 - 27

Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA

Phone [phone] | Fax [phone] | www.evoamerica.com | [e-mail]

7

Cook Surface: Lift and separate cook surface from unit and place next to installation area.

Drip Pan

Unlatch pan
from circular
skirt, then
carefully lift and
separate drip
pan from unit
and place next
to installation
area. Take care

not to scratch
drip pan during
installation.

Remove Tie
Down Bolts
and Tabs

holding chassis
to packing crate
base using 7/16”
wrench.

INSTALLATION INSTRUCTIONS

Affinity 30Ge

UNPACKING COOKTOP COMPONENTS

Use caution when lifting. The cook surface is heavy.

Drip Pan Gasket:

Gasket is secured

to top of drip tray.

Remove gasket

from drip tray

and set aside

for reinstallation.

Chassis:

Lift chassis

from crating box

and place on

its side next to

installation area.

Use caution

since ignition

components

are exposed.

3-wire service line: Black, white
and green

Metal Right Angle Brackets: Unscrew from unit
and keep screws and brackets handy for fi rst
installation step.

STEP 1: As you are unpacking the crate, make sure you locate all components before
installation.

Ignition components are exposed during uncrating and installation.
Use caution and do not alter factory set positions.

8

Phone [phone] | Fax [phone] | www.evoamerica.com | [e-mail]

Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA