Earthquake 29702, 33970 Owner’s Manual

Owner’s Manual

GAS/OIL

RATIO

50:1

VICTORY

Rear-Tine Tiller

Model #’s: 29702 / 33970

ENGLISH

SERIAL NO.

DATE OF PURCHASE:

THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT SAFETY INFORMATION. PLEASE READ AND KEEP FOR FUTURE REFERENCE.

Get parts or technical assistance online at

www.GetEarthquake.com or call (800) 345-6007

P/N: 32440

REV 3: 10/14/2019

Owner’s Manual

VICTORY REAR-TINE TILLER

STOP! ACTIVATE YOUR WARRANTY BEFORE USE

All products must be registered within 30 days from the date of purchase in order to be covered under warranty. For more information regarding Warranty and Registration please review the Warranty and Registration terms and conditions expressed in the warranty insert.

INTRODUCTION

Thank you for purchasing your product from Earthquake®. We have worked to ensure that this product meets the highest standards for usability and durability. With proper care, your purchase will provide many years of service.

Please read this entire manual before installation and use. Earthquake® reserves the right to change, alter or improve the product and this document at any time without prior notice. Due to continuous product improvements, product images may not be exact. Some assembly may be required.

Read and keep this manual for future reference. This manual contains important information regarding safety, assembly, operation and maintenance. The owner must be certain that all the product information is included with the unit. This information includes the manual, the replacement parts and the warranties. This information must be included to make sure state laws and other laws are followed. All persons to whom rent/loan this unit must have access to and understand this information. This manual should remain with the product even if it is resold.

CONTENTS

Introduction/Contents ..................................................................................................................................................................................................................2

Bolt Identication Chart ................................................................................................................................................................................................................3

Warnings and Safety Precautions ..........................................................................................................................................................................................4-8

Features ..............................................................................................................................................................................................................................................9

Assembly ................................................................................................................................................................................................................................... 10-12

Operation .................................................................................................................................................................................................................................. 12-16

Maintenance and Storage ................................................................................................................................................................................................... 16-19

Troubleshooting and Repair ......................................................................................................................................................................................................20

REGISTRATION AND SERVICE

Record the product model number and serial number in the space provided for easy reference when ordering parts or requesting technical support. Excluding emissions-related warranty items, the warranty is valid only if the completed registration is received by Ardisam within 30 days of purchase. You can register your warranty online by visiting www. GetEarthquake.com, or by mailing it to: Ardisam, 1160 8th Avenue, Cumberland, WI 54829. You may also call our Customer Service department at (800) 345-6007 Mondays through Fridays from 8 a.m. to 5 p.m. CST.

Serial Number

Location

Get parts online at www.GetEarthquake.com or Call 800-345-6007 M-F 8-5 CST

BOLT IDENTIFICATION CHART

Bolts shown are for size reference only. Extra hardware may be included in the parts bag.

(A) M10 x 45 MM Bolt Qty 4

(B) M10 x 25 MM Bolt Qty 2

(F) M6 x 12 MM Bolt Qty 6

Owner’s Manual

VICTORY REAR-TINE TILLER

(I) Lock Pin Qty 1

(H) M6 X 18.8 MM Washer Qty 12

(G) M6 Nut Qty 6

(D) M10 X 20 MM Washer Qty 6

(K) Lock Pin Qty 2

Get parts online at www.GetEarthquake.com or Call 800-345-6007 M-F 8-5 CST

Owner’s Manual

VICTORY REAR-TINE TILLER

WARNINGS AND SAFETY PRECAUTIONS

OWNER’S RESPONSIBILITY

Accurate assembly and safe and eective use of the machine is the owner’s responsibility.

• Read and follow all safety instructions.

• Carefully follow all assembly instructions.

• Maintain the machine according to directions and schedule included in this Earthquake® operator’s manual.

• Ensure that anyone who uses the machine is familiar with all controls and safety precautions.

SPECIAL MESSAGES

Your manual contains special messages to bring attention to potential safety concerns, machine damage as well as helpful operating and servicing information. Please read all the information carefully to avoid injury and machine damage.

NOTE: General information is given throughout the manual that may help the operator in the operation or service of the machine.

This symbol points out important safety instructions which if not followed could endanger your personal safety. Read and follow all instructions in this manual before attempting to operate this equipment.

BEFORE OPERATING EQUIPMENT:

Please read this section carefully. Read entire operating and

maintenance instructions for this product. Failure to follow instructions could result in serious injury or death. Operate the machine according to the safety instructions outlined here and inserted throughout the text. Anyone who uses this machine must read the instructions and be familiar with the controls.

INTENDED USE / FORESEEABLE MISUSE

NOTICE

NOTICE INDICATES YOUR EQUIPMENT CAN BE DAMAGED IF THE SAFETY INSTRUCTIONS THAT FOLLOW THIS SIGNAL WORD ARE NOT OBEYED.

IMPORTANT

IMPORTANT INDICATES HELPFUL INFORMATION FOR PROPER ASSEMBLY, OPERATION OR MAINTENANCE OF YOUR EQUIPMENT.

CAUTION

CAUTION INDICATES A HAZARD WHICH, IF NOT AVOIDED, COULD RESULT IN PERSONAL INJURY AND/OR PROPERTY DAMAGE.

WARNING

WARNING INDICATES A HAZARD WHICH, IF NOT AVOIDED, COULD RESULT IN DEATH OR SERIOUS INJURY AND/OR PROPERTY DAMAGE.

DANGER

DANGER INDICATES A HAZARD WHICH, IF NOT AVOIDED, CERTAINLY WILL RESULT IN DEATH OR SERIOUS INJURY AND/OR PROPERTY DAMAGE.

WARNING

YOU MUST READ, UNDERSTAND AND COMPLY WITH ALL SAFETY AND OPERATING INSTRUCTIONS IN THIS MANUAL BEFORE ATTEMPTING TO SETUP AND OPERATE YOUR MACHINE.

IMPORTANT: This is a motorized rotary tiller that works the soil by means of rotating tines. It is pedestrian-controlled, with a gasoline-fueled internal combustion engine to power the tines. It shall not be used for any other purpose.

DANGER

Keep away from rotating tines.

Rotating tines will cause injury.

Get parts online at www.GetEarthquake.com or Call 800-345-6007 M-F 8-5 CST

FAILURE TO COMPLY WITH ALL SAFETY AND OPERATING INSTRUCTIONS CAN RESULT IN LOSS OF MACHINE CONTROL, SERIOUS PERSONAL INJURY TO YOU AND/OR BYSTANDERS, AND RISK OF EQUIPMENT AND PROPERTY DAMAGE. THE TRIANGLE IN THE TEXT SIGNIFIES IMPORTANT CAUTIONS OR WARNINGS WHICH MUST BE FOLLOWED.

Owner’s Manual

VICTORY REAR-TINE TILLER

GENERAL SAFETY RULES

• Read, understand, and follow all instructions on the machine and in the manual(s). Be thoroughly familiar with the controls and the proper use of the machine before starting. Know how to stop the machine and disengage the controls quickly.

• Use this equipment for its intended purpose only.

• Familiarize yourself with all of the safety and operating decals on this equipment and on any of its attachments or accessories.

• Do not put hands or feet near or under rotating parts.

• Only allow responsible individuals who are familiar with the instructions to operate the machine. Never allow children to operate this machine. Never allow adults to operate the machine without proper instruction.

• Thoroughly inspect the area where the machine is to be used and remove all foreign objects. Your equipment can propel small objects at high speed causing personal injury or property damage. Stay away from breakable objects, such as house windows, automobiles, greenhouses, etc.

• Keep the area of operation clear of all persons, particularly small children and pets.

• Do not operate in shorts or open toed shoes. Wear proper Personal Protective Equipment (PPE) at all times, such as gloves, proper footwear, and eye protection.

• Do not wear loose clothing or jewelry. They can get caught in moving parts. Always keep hands, feet, hair and loose clothing away from any moving parts on engine and machine.

• Always wear safety goggles or safety glasses with side shields when operating the machine to protect your eyes from foreign objects which can be thrown from the unit. Always wear a protective hearing device.

• Always wear work gloves and sturdy footwear. Wear footwear that will improve footing on slippery surfaces. Leather work shoes or short boots work well for most people. These will protect the operator’s ankles and shins from small sticks, splinters, and other debris.

• It is advisable to wear protective headgear to prevent the possibility of being struck by small ying particles, or being struck by low hanging branches, twigs, or other objects which may be unnoticed by the operator.

• Do not operate product when fatigued or under the inuence of alcohol, drugs or other medication which can cause drowsiness or aect your ability to operate this machine safely.

• Never operate machine in wet grass. Always be sure of your footing; keep a rm hold on the handle and walk; never run.

• Watch for trac when operating machine near, or when crossing roads.

• Temperature of muer and nearby areas may exceed 150° F (65° C). Allow muer and engine areas to cool before touching. Never pick up or carry the machine while the engine is running.

• Prolonged exposure to noise and vibration from gasoline engine-powered equipment should be avoided. Take intermittent breaks and/or wear ear protection from engine noise as well as heavy work gloves to reduce vibration in the hands.

• When moving the packaged machine, always do so with a partner.

• Check local regulations for age restrictions on use of this machine.

• Never attempt to make any adjustment while the engine (motor) is running (except where specically recommended by the manufacturer).

• The tines of the tiller should not rotate when the drive control lever is released into the neutral position. If it does rotate when in neutral, contact Earthquake® Customer Service for instruction.

ENGINE SAFETY PRECAUTIONS

If your product comes with a separate engine manual, be sure to read and follow all safety and warning precautions outlined there, in addition to any in this manual.

PREVENTING CARBON MONOXIDE POISONING

• Always start and run engine outdoors. Do not start or run engine in an enclosed area, even if doors or windows are open.

• Never try to ventilate engine exhaust indoors. Carbon monoxide can reach dangerous levels very quickly.

• Never run engine outdoors where exhaust fumes may be pulled into a building.

• Never run engine outdoors in a poorly ventilated area

Get parts online at www.GetEarthquake.com or Call 800-345-6007 M-F 8-5 CST

WARNING

ENGINES GIVE OFF CARBON MONOXIDE, AN ODORLESS,

COLORLESS, POISONOUS GAS. CARBON MONOXIDE MAY BE PRESENT EVEN IF YOU DO NOT SMELL OR SEE ANY ENGINE EXHAUST. BREATHING CARBON MONOXIDE CAN CAUSE NAUSEA, FAINTING OR DEATH, IN ADDITION TO DROWSINESS, DIZZINESS AND CONFUSION.

IF YOU EXPERIENCE ANY OF THESE SYMPTOMS, SEEK

FRESH AIR AND MEDICAL ATTENTION IMMEDIATELY.

HOT GASES ARE A NORMAL BY-PRODUCT OF A FUNCTIONING INTERNAL COMBUSTION ENGINE. FOLLOW ALL SAFETY INSTRUCTIONS TO PREVENT BURNS AND FIRES.

DO NOT ALTER/MODIFY ENGINE:

• NEVER ALTER OR MODIFY THE ENGINE FROM THE

FACTORY. SERIOUS INJURY OR DEATH MAY OCCUR IF ENGINE IS MODIFIED OR ALTERED.

• WHEN WORKING ON OR REPLACING PARTS FOR THE

ENGINE OR PRODUCT, YOU MUST ALWAYS PUT THE ON/ OFF SWITCH TO THE OFF POSITION.

where the exhaust fumes may be trapped and not easily taken away. (Examples include: in a large hole or areas where hills surround your working area.)

• Never run engine in an enclosed or partially enclosed area. (Examples include: buildings that are enclosed on one or more sides, under tents, car ports or basements.)

• Always run the engine with the exhaust and muer pointed in the direction away from the operator.

Owner’s Manual

VICTORY REAR-TINE TILLER

• Carefully inspect the area to be tilled and remove all foreign objects. Do not till above underground water lines, gas lines, electric cables, or pipes. Do not operate the tiller in soil with large rocks and foreign objects which can damage the equipment.

• Disengage all clutches and leave control lever in the neutral position before starting the engine (motor).

SAFE HANDLING OF GASOLINE

Use extra care in handling gasoline and other fuels. They are extremely ammable and vapors are explosive.

• Extinguish all cigarettes, cigars, pipes and other sources of ignition.

• Never remove gas cap or add fuel with the engine running.

• Allow engine to cool before refueling.

• Never store the machine or fuel container where there is an open ame, spark, or pilot light such as on a water heater or on other appliances.

• Never ll containers inside a vehicle or on a truck or trailer bed with a plastic liner. Always place containers on the ground away from your vehicle before lling.

• Remove gas powered equipment from the truck or trailer and refuel it on the ground. If this is not possible, then refuel such equipment with a portable container, rather than from a gasoline dispenser nozzle.

• Keep the nozzle in contact with the rim of the fuel tank or container opening at all times until fueling is complete. Do not use a nozzle lock open device.

• Never point the exhaust muer towards anyone. People should always be many feet away from the operation of the engine and its attachments.

• Do not change the engine governor settings or overspeed the engine.

PREPARATION

• Dress appropriately when operating the tiller. Always wear sturdy footwear. Never wear sandals, sneakers or open shoes, and never operate the tiller with bare feet. Do not wear loose clothing that might get caught in moving parts. Wear proper Personal Protective Equipment (PPE) at all times, such as gloves, proper footwear, and eye protection.

Get parts online at www.GetEarthquake.com or Call 800-345-6007 M-F 8-5 CST

• If fuel is spilled on clothing, change clothing immediately.

• Never overll fuel tank. Replace gas cap and tighten securely.

• If fuel is spilled do not attempt to start the engine but move the machine away from the area of spillage and avoid creating any source of ignition until fuel vapors have dissipated.

• Prevent re and explosion caused by static electric discharge. Use only nonmetal, portable fuel containers approved by the Underwriter’s Laboratory (U.L.) or the American Society for Testing & Materials (ASTM).

• Always ll fuel tank outside in a well ventilated area. Never ll your fuel tank with fuel indoors. (Examples include: basement, garage, barn, shed, house, porch, etc.).

Owner’s Manual

VICTORY REAR-TINE TILLER

• Test the fuel cap for proper installation before starting and using engine.

• Always run the engine with fuel cap properly installed on the engine.

NOTICE

THE RIGHT AND LEFT SIDES OF YOUR ROTOTILLER ARE DETERMINED FROM THE OPERATING POSITION AS YOU FACE THE DIRECTION OF FORWARD TRAVEL.

ENGINE IS SHIPPED FROM FACTORY WITHOUT OIL. YOU MUST ADD ENGINE OIL BEFORE STARTING ENGINE.

OPERATION

• Do not allow hands, feet, or other body parts, or clothing near the rotating tines or any other moving part. The tines begin to rotate once the engine/motor is started and the activating device is engaged. The tines may momentarily rotate after the activating device is released.

• Exercise extreme caution when crossing gravel surfaces. Stay alert for hidden hazards or trac.

• If an object becomes lodged in the tines, ip the ON/OFF switch to the OFF position, allow to cool before attempting to remove the foreign object.

• After striking a foreign object, stop the engine (motor), remove the wire from the spark plug (or disconnect the cord for electric products), thoroughly inspect the machine for any damage, and repair the damage before restarting and operating the machine.

• Exercise caution to avoid slipping or falling.

• If the machine should start to vibrate abnormally, stop the engine (motor) and check immediately for the cause. Vibration is generally a warning sign of trouble.

• Stop the engine (motor) when leaving the operating position, before unclogging the tines, and when making any repairs, adjustments and inspections.

from the plug to prevent accidental starting. Disconnect the cord on electric motors.

• Do not operate tiller under the inuence of alcohol or drugs.

• Never operate tiller without guards, covers, and hoods in place.

• Do not overload the machine capacity by attempting to till or cultivate too deep at too fast a rate.

• Never operate the machine at high transport speeds on hard or slippery surfaces.

• Never allow bystanders near the machine, especially small children.

• Use only attachments and accessories approved by the manufacturer of the machine (such as wheel weights, counterweights, and the like).

• Never operate the tiller without good visibility or light.

• Be careful when tilling in hard ground. The tines may catch in the ground and propel the tiller forward. If this occurs, let go of the handlebars and do not restrain the machine.

• Use extreme caution when reversing or pulling the machine towards you. To avoid getting pinned against a structure, ensure adequate distance before reversing near a wall or fence.

• Do not change the engine governor settings or over speed the engine.

• Start the engine or switch on the motor carefully according to instructions and with feet away from th tines.

• Never pick up or carry a machine while the engine (motor) is running.

• Do not operate the tiller while under the inuence of alcohol or drugs.

• Powered walk-behind tiller work is strenuous. You must be in good physical condition and mentally alert. If you have any condition that might be aggravated by strenuous work, check with your doctor before operating a powered walk-behind tiller.

• Stop the engine (motor) when leaving the machine unattended.

• Before cleaning, repairing or inspecting, shut o the engine and make certain all moving parts have stopped. Disconnect the spark plug wire, and keep the wire away

Get parts online at www.GetEarthquake.com or Call 800-345-6007 M-F 8-5 CST

Owner’s Manual

VICTORY REAR-TINE TILLER

MAINTENANCE AND STORAGE

• Keep machine, attachments and accessories in safe working condition.

• Check shear bolts, engine mounting bolts and other bolts at frequent intervals for proper tightness to be sure the equipment is in safe working condition.

• To prevent accidental starting, always disconnect and secure the spark plug wire from the spark plug before performing tiller maintenance.

• Pulleys and belts should be kept free of oil or other moisture for ecient operation.

• Never store equipment with gasoline in the tank inside a closed building where ignition sources are present, such as hot water and space heaters, clothes dryers and the like. Allow engine to cool before storing in any enclosure.

• Always refer to the operator’s guide instructions for important details if the tiller is to be stored for an extended period.

• If the fuel tank has to be drained, do this outdoors.

• Follow manufacturer’s recommendations for safe loading, unloading, transport and storage of machine.

E: Dangerous Moving Parts.

F: Be Aware of Moving and Rotating Parts.

G: Wear Ear and Eye Protection At All Times.

H: Do Not Service or Adjust Moving Parts Unless Engine is

Stopped and Spark Plug Wire is Disconnected.

I: Dress Appropriately And Wear Sturdy Footwear.

J: Toxic Fumes —Do Not Operate in Unventilated Areas.

K: Hot Surfaces.

L: Fire Hazards.

M. Do Not Use In Thunderstorms--For severe weather,

stop operation of this machine and seek shelter.

N. Team Lift--For your safety, always have at least two

people when lifting this machine.

O. Do Not Till Above Underground Utility Lines And

Pipes.

P. Do Not Operate When Children Or Others Are Around.

A B

SAFETY DECALS

This rototiller unit has been designed and manufactured to provide you with the safety and reliability you would expect from an industry leader in outdoor power equipment manufacturing.

Although reading this manual and the safety instructions it contains will provide you with the necessary basic knowledge to operate this equipment safely and eectively, we have placed several safety labels on the tiller to remind you of this important information while you are operating the unit.

Please review these decals now, and if you have any questions regarding its meaning or how to comply with these instructions, reread the complete safety instruction text in this manual. For additional questions call Earthquake®Customer Service.

HAZARD SYMBOLS AND MEANINGS

A: Warning!

B: Avoid Injury From Rotating Tines.

C: Read Owner’s Manual Before Operating Machine.

D: Remove Objects that Could Be Thrown By This

Machine.

Get parts online at www.GetEarthquake.com or Call 800-345-6007 M-F 8-5 CST

+ 16 hidden pages