Duracraft DCM-200 Series Owner's Manual
OWNER’S MANUAL
2.0 GALLON (7.6 LITERS)
OUTPUT PER DAY*
NATURAL COOL MOISTURE
™
HUMIDIFIER
*Output dependent on room temperature and humidity.
Model DCM-200 Series
035-00326-004_R1 DCM-200 OM 5/11/04 10:51 AM Page 1
High
ff
O
L
o
w
When using electrical appliances, basic precautions
should always be followed to reduce the risk of fire,
electric shock, and injury to persons, including the
following:
1. Always place this humidifier on a firm, flat and level surface. This humidifier may not
work properly on an uneven surface.
2. Place this humidifier in an area where it is not accessible to children.
3. Do not place the humidifier near any heat sources such as stoves, radiators, and heaters.
4. Before using the humidifier, check the power cord for any signs of damage. If the cord is
found to be damaged, DO NOT USE and return the humidifier to the manufacturer
under the warranty agreement for repair.
5. This appliance has a polarized plug (one blade is wider than the other). To reduce the
risk of shock, this plug is intended to fit only one way in a polarized outlet. If the plug
does not fit securely in the outlet, reverse the plug. If it still does not fit, contact a
qualified electrician. DO NOT attempt to defeat this safety feature.
6. To disconnect the humidifier, first turn controls to the OFF position, then grip the plug and
pull it from the wall outlet. Never pull by the cord.
7. A loose fit between the AC outlet (receptacle) and plug may cause overheating and a
distortion of the plug. Contact a qualified electrician to replace loose or worn outlet.
8. The humidifier should always be unplugged and emptied when not in operation or while
being serviced or cleaned.
9. Never tilt or attempt to move the humidifier while it is operating or filled with water.
UNPLUG the humidifier before moving.
10. This humidifier requires regular cleaning. Refer to the CLEANING instructions provided.
Never clean the humidifier in any manner other than as instructed in this manual.
11. Turn the humidifier OFF if you notice moisture on the inside of your windows. For proper
humidity reading use a hygrometer, which is available in many hardware and
department stores.
12. When a humidifier is used in a closed room or small rooms, check periodically for
proper ventilation, as excessive humidity can cause condensation stains on walls.
13. Do not direct moisture flow directly at individuals, walls or furniture.
IMPORTANT SAFETY
INSTRUCTIONS
READ AND SAVE THESE SAFETY
INSTRUCTIONS BEFORE USING
THIS HUMIDIFIER
035-00326-004_R1 DCM-200 OM 5/11/04 10:51 AM Page 2
HOW DOES IT WORK?
Natural Cool Moisture™ System
The fan pulls dry air through a wet filter and releases invisible moisture into the air. When the
unit is running you will not see or feel a “mist”. You will know your humidifier is putting
moisture into the air as you watch the water level in your tank decrease throughout the day.
MODEL DCM-200
Your humidifier is made up of the following parts:
INTRODUCTION
NATURAL COOL
MOISTURE
™
FILTER
DISHWASHER-SAFE BASE
FILL CAP
WATER TANK
High
L
o
w
O
f
f
MOTOR HOUSING
035-00326-004_R1 DCM-200 OM 5/11/04 10:51 AM Page 3
NOTE: We recommend that the humidifier be disinfected prior to first use.
Please see CLEANING instructions.
• Select a firm, level, flat location — at least six inches (15 cm) from any wall for proper
air flow (Fig. 1).
• Place the humidifier on a water-resistant surface, as water can damage furniture and some
flooring.
Kaz will not accept responsibility for property damage caused by water spillage.
• Remove the water tank by grasping the handle and pulling straight up (Fig. 1).
• Lift up on the Motor Housing to remove and set aside (Fig. 2). Remove the Natural Cool
Moisture™ filter from the base before filling the unit with water. Soak in a sink full of cool
water to help reduce mineral build up and place back in the humidifier while wet. DO
NOT SQUEEZE OR WRING OUT THE NATURAL COOL MOISTURE™ FILTER. To help
extend the life of your filter repeat this step each time you fill your humidifier.
• Turn the water tank upside down so that the fill cap is facing up; unscrew the fill cap by
turning it counter-clockwise and set aside.
• Fill the water tank with COOL tap water (Fig. 3). Distilled water is not necessary as the
water is filtered by the Natural Cool Moisture™ filter.
DO NOT USE HOT WATER. Doing so may damage the humidifier.
• Replace the fill cap by turning it clockwise . DO NOT OVER TIGHTEN.
Turn the water tank right-side up.
Fig. 1
Wall
6”
Lift
Fig. 2 Fig. 3
SET UP
FILLING
035-00326-004_R1 DCM-200 OM 5/11/04 10:51 AM Page 4
NOTE: WHEN CARRYING THE FILLED WATER TANK, PLEASE USE THE HANDLE AND PLACE
YOUR OTHER HAND UNDER THE TANK FOR ADDITIONAL SUPPORT.
• Place the Motor Housing back onto Base.
• Once the filled tank has been positioned, do not attempt to move the humidifier. If it has
to be moved, unplug the humidifier and remove the water tank first.
NOTE: DO NOT POUR WATER INTO THE GRILL ON THE TOP OF THE MOTOR HOUSING.
DOING SO MAY DAMAGE THE HUMIDIFIER OR CAUSE PERSONAL INJURY.
CAUTION: DO NOT PLUG IN THE HUMIDIFIER WITH WET HANDS AS AN
ELECTRIC SHOCK COULD OCCUR.
POWER
• With the power switch in the OFF position, plug the filled humidifier into a polarized
120V outlet. DO NOT FORCE THE POLARIZED PLUG INTO THE OUTLET; it will only fit one
way.
HUMIDITY CONTROL
1. Set the fan speed control to the desired position (Fig. 4).
HIGH: For fast humidifying
LOW: For quieter operation
NOTE: The length of time your humidifier runs will vary
depending on the quality of construction and insulation of your
room and house, as well as the fan speed.
2. Turn the humidifier OFF if the humidity level feels too moist or
you notice condensation forming on the walls and/or windows.
ALWAYS be sure to empty any unused water in the Base and/or Water Tank each time you
refill the water tank or finish using the humidifier.
Fig. 4
FILLING CONTINUED
OPERATION
035-00326-004_R1 DCM-200 OM 5/11/04 10:51 AM Page 5
High
Low
ff
O
We recommend cleaning the humidifier once a week, more often if you have hard water or
notice a build up of impurities or detect unpleasant odors.
NOTE: THE USE OF OTHER WATER TREATMENT PRODUCTS MAY DAMAGE THE
FILTER OR HUMIDIFIER.
Cleaning involves two steps SCALE REMOVAL and DISINFECTING. Be sure to perform these
in the proper order to avoid harmful chemical interactions.
• First, turn off and unplug the humidifier.
• Remove the Water Tank and Motor Housing.
• Remove the Natural Cool Moisture™ filter from the Base.
• Discard any residual water from the Base.
• Clean all outside surfaces with a dry, soft cloth. DO NOT USE WATER.
THIS MAY DAMAGE THE HUMIDIFIER OR CAUSE ELECTRIC SHOCK.
STEP ONE:
SCALE REMOVAL
DISHWASHER-SAFE BASE
1. Fill the Base with either:
• one cup (8 ozs, 250 ml) of undiluted
white vinegar
OR
• Honeywell
®
humidifier cleaner, part no.
HAC-101, following bottle instructions
2. Let solution stand for 20 minutes
3. With the vinegar or Honeywell
®
humidifier
cleaner in the Base, clean all interior
surfaces with a soft cloth or brush to help
remove scales.
4. Rinse the Base thoroughly with water to
remove scale and cleaning solution.
STEP TWO:
DISINFECTING
WATER TANK
1. Fill the water tank with:
• 1 teaspoon of household bleach
• 1 gallon (4 L) of water.
Pour some of this solution into the Base.
2. Let solution stand for 20 minutes.
3. Rinse with water until the odor of bleach is
gone.
NOTE: Remove filter before cleaning
Failure to remove the filter during cleaning will destroy the filter
WEEKLY CLEANING
The Honeywell trademark is used by Kaz, Inc. under license from Honeywell Intellectual Properties, Inc.
Dishwasher Cleaning: Your base can be cleaned in your dishwasher. If you choose to
use your dishwasher, it's important to follow these instructions:
• Place base ONLY IN TOP RACK of your dishwasher.
• Dishwasher MUST only be operated on COOL CYCLE - NO HEA
T.
(Note: Using your heat cycle can result in damage to your base).
Note: Kaz will not accept responsibility for any damage caused to your dishwasher or your
humidifier due to improper cleaning of your humidifier base.
035-00326-004_R1 DCM-200 OM 5/11/04 10:51 AM Page 6
NOTE: DO NOT ATTEMPT TO CLEAN THE NATURAL COOL MOISTURE™ FILTER WITH
ANY CHEMICAL SOLUTIONS, DOING SO WILL DAMAGE THE FILTER.
If the Natural Cool Moisture™ filter appears to be clogged by hard water or mineral
deposits, soak it in a sink full of cool water for 10 minutes. DO NOT SQUEEZE OR WRING
OUT THE NATURAL COOL MOISTURE™ FILTER. Always place it back in the humidifier wet.
There are many steps you can take each time you fill your humidifier to make sure you get
the most life out of our Natural Cool Moisture™ filter.
1. To prevent mineral deposits, use Honeywell
®
humidifier water softener, part no. HAC-102,
each time the Water Tank is refilled.
2. Treat the Natural Cool Moisture™ filter with care. DO NOT squeeze or wring it out, DO
NOT clean the filter using any chemical solution.
3. Always purchase Honeywell
®
Brand Natural Cool Moisture™ filters (HC-888) as the fan
motor of this humidifier and the Natural Cool Moisture™ filter are designed to function
efficiently as a set. Using any other filter could damage the motor or impair the
humidifier’s performance.
4. Be sure to empty water from the Water Tank and Base when not in use.
PROLONGING THE LIFE OF THE FILTER AND
MAINTAINING A CLEAN HUMIDIFIER
• Follow weekly CLEANING instructions when the humidifier will not be used for at least one
week or more, or at the end of the season.
• At the end of the season, remove and throw away the filter; do not store with a used filter.
• Dry the humidifier completely before storing. DO NOT store with water inside the Base or
Water Tank.
• Pack the unit in its original carton and store in a cool, dry location.
• Before next use, remember to install a new filter and clean the humidifier.
END-OF-THE-SEASON CARE AND STORAGE
035-00326-004_R1 DCM-200 OM 5/11/04 10:51 AM Page 7
Q: I hear the fan turning, but I don’t see any mist. Is my humidifier operating properly?
A: Dry air is pulled through the Cool Moisture system and a fan disperses invisible, moisture
balanced air. There is no “mist” emitted. When operating normally you will feel only cool
air coming from the unit. Monitor the water level in your tank/base. If you notice a
decrease in the water tank over 24 hours then the unit is operating normally.
Q: My unit has been running for several hours. I hear the fan spinning, but I do not notice
the water level in the tank decreasing.
A: First, check the moisture pad to be sure it is wet. If the pad appears dry, remove it from
the base and gently rinse under cool water. Reposition wet filter in the base. You may also
want to check the current moisture level in your home. If the humidity level is over 60%,
the unit will not put out much moisture as your air is already saturated.
TROUBLE SHOOTING
This product is rated at 0.6 amps, 120V, 60 Hz.
NOTE: IF YOU EXPERIENCE A PROBLEM WITH YOUR HUMIDIFIER PLEASE SEE THE
WARRANTY INSTRUCTIONS. PLEASE DO NOT ATTEMPT TO OPEN OR REPAIR THE
HUMIDIFIER YOURSELF. DOING SO WILL VOID THE WARRANTY AND COULD CAUSE
DAMAGE TO THE UNIT OR PERSONAL INJURY. IF THE PROBLEM PERSISTS PLEASE
CONTACT THE CONSUMER RELATIONS DEPARTMENT.
ELECTRICAL RATINGS
CONSUMER RELATIONS
Mail questions or comments to:
Kaz, Inc.
Consumer Relations Dept.
250 Turnpike Road
Southborough, MA 01772 USA
Please be sure to specify model number.
Toll-free: 1-800-332-1110
E-mail: consumerrelations@kaz.com
Visit our website at: www
.kaz.com
035-00326-004_R1 DCM-200 OM 5/11/04 10:51 AM Page 8
©2004 Kaz, Inc. All Rights Reserved.
P/N: 035-00326-004, Rev. 1
A/W: 043-50055-004
You should first read all instructions
before attempting to use this
product.
A. This 1 year limited warranty applies to repair
or replacement of product found to be
defective in material or workmanship. This
warranty does not apply to damage resulting
from commercial, abusive, unreasonable use
or supplemental damage. Defects that are the
result of normal wear and tear will not be
considered manufacturing defects under this
warranty.
KAZ IS NOT LIABLE FOR INCIDENTAL
OR CONSEQUENTIAL DAMAGES OF
ANY NATURE. ANY IMPLIED
WARRANTY, INCLUDING
MERCHANTABILITY AND FITNESS
FOR A PARTICULAR PURPOSE, ON
THIS PRODUCT IS LIMITED IN
DURATION TO THE DURATION OF
THIS WARRANTY.
Some jurisdictions do not allow the exclusion
or limitation of incidental or consequential
damages, or limitations on how long an
implied warranty lasts, so the above
limitations or exclusions may not apply to
you. This warranty gives you specific legal
rights, and you also may have other rights
which vary from jurisdiction to jurisdiction.
This warranty applies only to the original
purchaser of this product from the original
date of purchase.
B. At its option, Kaz will repair or replace this
product if it is found defective in material or
workmanship. Defective product should be
returned directly to Kaz.
C. This warranty does not cover damage
resulting from any unauthorized attempts to
repair or from any use not in accordance
with this manual.
NOTE: THIS WARRANTY DOES NOT
COVER THE NATURAL COOL
MOISTURE™ FILTER, WHOSE
PERFORMANCE WILL DEPEND UPON
THE CONDITION OF THE WATER USED
IN THE HUMIDIFIER.
D. Return defective product to the place of
purchase in accordance with store policy or
to the following address with a brief
description of the problem. Include proof of
purchase and a U.S. $10.00/$15.50 CAN
check or money order for handling, return
packing and shipping charges. Please
include your name, address and a daytime
phone number. You must prepay shipping
charges. Mark carton “Attention Returns
Department.” Ship to:
In US:
Kaz, Inc.
Attn: Returns Department
4755 Southpoint Drive
Memphis, TN 38118
U.S.A.
In Canada:
Kaz, Inc.
Attn: Returns Department
510 Bronte Street South
Milton, ON L9T 2X6
Canada
1 YEAR LIMITED WARRANTY
035-00326-004_R1 DCM-200 OM 5/11/04 10:51 AM Page 9
Loading...