Duke FlexBake 5 IVS-208-FB5, FlexBake 5 IVS-CE-FB5 Installation And Operation Manual
FlexBake 5™ Integrated
Ventilation System
Model#
IVS-208-FB5
IVS-CE-FB5
Installation and
Operation Manual
CAUTION:
This manual is Copyright © 2019 Duke Manufacturing Co. All rights reserved.
Reproduction without written permission is prohibited. Duke is a registered
Please read this manual completely before attempting
to install, operate or service this equipment
trademark of the Duke Manufacturing Co.
P/N 514109
REV B 05/07/2019
Installation and Operation of: FlexBake 5™ Integrated Ventilation System
CAUTION
CAUTION
TABLE OF CONTENTS
Important Safety Instructions ............................................................................................................................ 2
Specications ........................................................................................................................................................... 4
Wire Schematic........................................................................................................................................................ 5
Unpacking Instructions ........................................................................................................................................ 6
Removal of Old Facade ......................................................................................................................................... 6
Installation of New IVS Hood ............................................................................................................................ 8
Congure IVS Hood to FlexBake
Oven Start Up ........................................................................................................................................................ 12
Care and Cleaning ................................................................................................................................................ 12
Troubleshooting ...................................................................................................................................................12
Throughout this manual, you will nd the following safety words and symbols that signify
important safety risks with regards to operating or maintaining the equipment.
Indicates a hazardous situation which, if not avoided, could
result in death or serious injury.
Indicates a hazardous situation which, if not avoided, could
result in minor or moderate injury.
TM
................................................................................................................. 11
IMPORTANT SAFETY INSTRUCTIONS
Indicates electrical shock hazard which, if not avoided, could
Indicates hot surface which, if not avoided, could result in
Indicates hot surface which, if not avoided, could result in
Indicates rotating fan blade hazard which, if not avoided,
2
Indicates Important Information
result in death or serious injury and/or equipment damage.
minor or moderate injury.
minor or moderate injury. Specically, risk of burn from
heating elements.
could result in minor or moderate injury.
Installation and Operation of: FlexBake 5™ Integrated Ventilation System
In addition to the warnings and cautions in this manual, use the following guidelines for
safe operation of the unit.
• Read all instructions before using equipment.
• For your safety, the equipment is furnished with a properly grounded cord connector. Do
not attempt to remove or disconnect the grounded connector.
• Install or locate the equipment only for its intended use as described in this manual.
• Do not use corrosive chemicals on this equipment.
• Do not operate this equipment if it has a damaged cord or plug, if it is not working
properly, or if it has been damaged or dropped.
• This equipment should be serviced by qualied personnel only. Contact the nearest
Duke authorized service facility for adjustment or repair.
• Do not block or cover any openings on the unit.
• Do not immerse cord or plug in water.
• Keep cord away from heated surfaces.
• Do not allow cord to hang over edge of table or counter.
• A minimum clearance of 6” (152,4 mm) from the top of the unit to the ceiling must be
provided.
The following warnings and cautions appear throughout this manual and should be
carefully observed.
• Turn the unit o, disconnect the power source and allow unit to cool down before
performing any service or maintenance on the unit.
• The procedures in this manual may include the use of chemical products. You must read
the Material Safety Data Sheets before using any of these products.
• The unit should be grounded according to local electrical codes to prevent the
possibility of electrical shock. It requires a grounded receptacle with dedicated electrical
lines, protected by fuses or circuit breaker of the proper rating, in accordance with all
applicable regulations.
• Disposal of the unit must be in accordance with local environmental codes and/or any
other applicable codes.
• This appliance is not intended for use by persons (including children) with reduced
physical, sensory or mental capabilities, or lack of experience and knowledge, unless
they have been given supervision or instruction concerning use of the appliance
by a person responsible for their safety.
3
Installation and Operation of: FlexBake 5™ Integrated Ventilation System
SPECIFICATIONS
946mm
37.2in
336mm
13.2in
334mm
13.2in
282mm
11.1in
879mm
34.6in
BLOWER SPECIFICATION:
Static Pressure Flow-rate
(Inches of Water) Pa CFM mm3/min
0 0 346 9.8
0.3 75 305 8.64
0.6 150 241 6.82
0.8 200 105 2.97
Commercial
Cooking
Appliance
509L
ANSI/NSF4
ELECTRICAL SPECIFICATIONS:
Model
IVS-208-FB5
IVS-CE-FB5
208V a.c. / 60Hz, 0.49A
230V a.c. / 60Hz, 0.43A
230VAC /50-60Hz, 0.39-0.43A
296mm
Motor
11.7in
DIMENSIONS:
IVS-208-FB5
IVS-CE-FB5
4
Model
Freight Class: 100
Height Width Depth
in. cm in. cm in. cm lbs. kg Carton Crate
78.5 199.5 37.2 94.6 34.6 87.9 164 61.2 Inches - 40.5X37.1X14.2
78.5 199.5 37.2 94.6 34.6 87.9 164 61.2 Inches - 40.5X37.1X14.2
Crated Ship
Weight
Shipping Dimensions
CM - 102.9X94.2X36.1
CM - 102.9X94.2X36.1
Inches - 45.5X42.3X21.5
CM - 115.6X107.4X54.6
Inches - 45.5X42.3X21.5
CM - 115.6X107.4X54.6
Loading...