Operations Manual
Edge Plus - 25”x40” Tortilla Warmer Grill
Model #: TW2540
WWW.PROLUXE.COM
Version: 51719
CLEANING
Use only cleaners which are safe for ALUMINUM. DO NOT use caustic cleaners, ice or cold water to clean the grill. Turn grill down or OFF during idle periods to prevent carbon buildup.
1.Turn power off and unplug, allow grill to cool.
2.Remove particles by using a spatula with rounded corners.
3.Wipe down all surfaces using a warm damp cloth and mild detergent.
CARBON CLEANING
When carbon buildup occurs, use a carbon removal agent which is safe for aluminum, follow the instructions provided with the product. When this process is complete, you must re-season your grill.
INITIAL START UP
Before using the unit for the first time, wipe down the exterior and platen area with a damp cloth.
Heat for approximately 30 minutes. The warmer may emit a small amount of smoke as the cooking surface reaches its operating temperature. This is normal, as the smoke is caused by oils associated with the manufacturing process and will stop when the burn off is complete. Brush off any debris from the warming surface.
SEASONING THE TORTILLA GRILL HEATING SURFACE FIRST TIME SEASONING
Follow your company/corporate guidelines for seasoning cooking surfaces or perform the following:
1.Bring the grill to 300°F (148°C) and leave it on while performing the next three steps.
2.Brush the cooking surfaces with a release agent. If using an aerosol agent, first apply into a cup and then brush onto cooking surface.
3.Let sit for 20 minutes.
4.Wipe the cooking surface clean, using a warm damp cloth.
*Warning*
DO NOT SUBMERGE IN WATER OR ALLOW WATER TO SPILL INTO THE ELECTRICAL HOUSING. AS THIS WILL VOID WARRANTY AND DAMAGE THE UNIT.
*Caution - To reduce the risk of fire, the appliance is to be installed in non-combustible surroundings only, with no combustible material within 18 inches of the sides, front, or rear of the appliance or within 40 inches above the appliance. The appliance is to be mounted on floors of noncombustible construction with noncombustible flooring and surface finish and with no combustible material against the underside, or on noncombustible slabs or arches have no combustible material against the underside. Such construction shall in all cases extend not less than 12 inches beyond the equipment on all sides.
20281 Harvill Ave
Perris, CA 92570
Tel: (800) 624-6717
Fax: (951) 657-4594
TW2023&TW2540 Recommended Cleaning Procedures
DO NOT use ice or cold water to cool unit down. This causes the platens to warp.
TOOLS REQUIRED: 1. Spatula w/ rounded corners 2. Damp Washcloth 3. Griddle cleaner
1.Turn off grill and allow to cool down.
2.Apply small amount of cleaner to grill surface
3. Use spatula w/ round edges |
4. Use warm damp cloth to |
to remove particles |
wipe grill surface. |
Loading...