Delfield ASM-60 Installation Manual
ASM Series
Original Instructions
Installation, Operation and Maintenance Manual
This manual is updated as new information and models are released. Visit our website for the latest manual.
Part Number: 9291463 10/17
Safety Notices
Warning
n
Read this manual thoroughly before operating, installing
or performing maintenance on the equipment. Failure
to follow instructions in this manual can cause property
damage, injury or death.
DANGER
Do not lift the condensing unit by the refrigerant tubing
or other components. These features will not support
the condensing unit weight. Injury and unit damage
may occur!
DANGER
Do not install or operate equipment that has been
misused, abused, neglected, damaged, or altered/
modified from that of original manufactured
specifications.
Warning
n
This product contains chemicals known to the State
of California to cause cancer and/or birth defects or
other reproductive harm. Operation, installation, and
servicing of this product could expose you to airborne
particles of glasswool or ceramic fibers, crystalline
silica, and/or carbon monoxide. Inhalation of airborne
particles of glasswool or ceramic fibers is known to the
State of California to cause cancer. Inhalation of carbon
monoxide is known to the State of California to cause
birth defects or other reproductive harm.
Warning
n
Do not use electrical appliances or accessories other
than those supplied by the manufacturer.
Warning
n
Use caution when handling metal surface edges of all
equipment.
DANGER
All utility connections and fixtures must be maintained
in accordance with Local and national codes.
DANGER
Keep power cord AWAY from HEATED surfaces. DO NOT
immerse power cord or plug in water. DO NOT let power
cord hang over edge of table or counter.
Warning
n
Authorized Service Representatives are obligated to
follow industry standard safety procedures, including,
but not limited to, local/national regulations for
disconnection / lock out / tag out procedures for all
utilities including electric, gas, water and steam.
Warning
n
This appliance is not intended for use by persons
(including children) with reduced physical, sensory
or mental capabilities, or lack of experience and
knowledge, unless they have been given supervision
concerning use of the appliance by a person responsible
for their safety. Do not allow children to play with this
appliance.
Warning
n
DO NOT touch refrigeration lines inside units; some may
exceed temperatures of 200°F (93.3°C).
Note
Proper installation, care and maintenance are
essential for maximum performance and trouble-free
operation of your equipment. Visit our website www.
mtwkitchencare.com for manual updates, translations,
or contact information for service agents in your area.
Warning
n
Do not store or use gasoline or other flammable vapors
or liquids in the vicinity of this or any other appliance.
Never use flammable oil soaked cloths or combustible
cleaning solutions, for cleaning.
Section 1
General Information
Section 2
Installation
Section 3
Operation
Table of Contents
Model Numbers .................................................................................................................. 4
Serial Number Location ..................................................................................................... 4
Warranty Information ........................................................................................................ 4
Regulatory Certifications ..................................................................................................4
Dimensioned Drawings .....................................................................................................5
Location ..............................................................................................................................6
Weight of Equipment .........................................................................................................7
Clearance Requirements ....................................................................................................7
Dimensions ......................................................................................................................... 7
Electrical Service ................................................................................................................ 8
Voltage .......................................................................................................................................................8
Fuse/Circuit Breaker ..............................................................................................................................8
Ground Fault Circuit Interrupter .......................................................................................................8
Rated Amperages, Horsepower, Voltage & Power Cord Chart ...............................................8
Installation Instructions ....................................................................................................9
Prepare the Cabinet ...............................................................................................................................9
Lower in the ASM ................................................................................................................................10
Construct an Air Duct ........................................................................................................................ 10
Plumbing...........................................................................................................................11
Leveling .............................................................................................................................11
Sliding Door Removal And Reinstall ...............................................................................11
Night & Security Cover Operations .................................................................................11
Shelf Adjustments ...........................................................................................................11
Operation ..........................................................................................................................12
Temperature Control Settings .........................................................................................13
Change Coil Temperature ................................................................................................................. 13
Change Other Parameter Values ....................................................................................................13
Section 4
Maintenance
Cleaning and Sanitizing Procedures ...............................................................................14
General ....................................................................................................................................................14
Interior Cleaning .................................................................................................................................. 14
Exterior Cleaning ................................................................................................................................. 15
Plexiglas, Including Baffles ...............................................................................................................15
Sliding Doors ......................................................................................................................................... 15
Drain .........................................................................................................................................................15
Cleaning the Condenser Coil .......................................................................................................... 15
Part Number: 9291463 10/17 3
Section 1
General Information
Model Numbers
This manual covers standard units only.
NOTE: For custom units, consult Manitowoc KitchenCare at
1-844-724-CARE.
Drop-In Air Screen Merchandisers
ASM-36
ASM-48
Serial Number Location
The serial number on all self-contained Drop-In Air Screen
Merchandisers is located on the mechanical section wall.
Always have the serial number of your unit available when
calling for parts or service.
Warranty Information
• Register your product for warranty.
• Verify warranty information.
• View and download a copy of your warranty.
At www.delfield.com/warranty
Regulatory Certifications
All models are certified by:
•
•
•
National Sanitation Foundation (NSF)
Underwriters Laboratories (UL)
Underwriters Laboratories of Canada (cUL)
4 Part Number: 9291463 10/17
Section 1 General Information
Dimensioned Drawings
25.93”
66cm
63.48”
161cm
36.25”
92cm
48.25”
123cm
25.93”
66cm
Plan View, ASM-36 Plan View, ASM-48
63.48”
161cm
34.50” 88cm
Elevation View, ASM-36
46.50” 118cm
Elevation View, ASM-48
38.65”
98cm
24.83”
63cm
Left Section View,
ASM-36, ASM-48
12.50”
32cm
12.50”
32cm
12.50”
32cm
24.87”
63cm
Right Side View,
ASM-36, ASM-48
Part Number: 9291463 10/17 5
Loading...