Dacor EWD27SCH, EWD30SCH, EWD36SCH, MRWD27S, MRWD30B Installation Guide

Installation Instructions

Warming

Models:

Drawer

DWD30, ERWD27, ERWD30, EWD24, EWD27,
EWD30, EWD36, IWD24, IWD27, IWD30, MRWD27,

MRWD30, MWDH27, MWDH30, MWDV27,
MWDV30, OWD24, RWDV30

Pa_ No. 102345 Rev. T

All specifications are subject to change without notice. Dacor ®assumes no liability for changes to specifications.

© 2007 Dacor, all rights reserved.

Before You Begin .............................................................. 1

Important Safety Instructions .......................................... 1

General Safety Precautions ............................................. 2

Installation Specifications ................................................ 3

Verifying the Package Contents ....................................... 3

Installation Planning ......................................................... 3

Install Support Platform in Cabinet .................................. 6

Electrical and Environmental Specifications .................... 6

Installation Instructions .................................................... 7

Remove the Drawer ........................................................ 7

Installing the Chassis ....................................................... 7

Re-installing the Drawer ................................................... 8

Towel Rack Installation ................................................... 8

Verify Warming Drawer Operation ................................... 9

Installation Checklist ........................................................ 9

Important:

InstalJer: In the interest of safety and to minimize problems, read these installation instructions completely and carefully
before you begin the installation process. Leave these installation instructions with the customer.

Customer: Keep these installation instructions for future reference and the local electrical inspector's use.
If you have questions or problems with installation, contact

your Dacor dealer or the Dacor Customer Service Team.

For repairs to Dacor appliances under warranty call the
Dacor Distinctive Service line. Whenever you call, have

the complete model and serial number for your appliance

available. The numbers are found on the product data label
located on back of the drawer front.

The data label also contains the product electrical

requirements.
Dacor Customer Service

Phone: [phone] ex. 2813 (U.S.A. and Canada)
Monday -- Friday 6:00 A.H. to 5:00 P.H.Pacific Time

Web site: www.dacor.com

Dacor Distinctive Service (repairs under warranty only)
Phone: [phone] ex. 2822 (U.S.A. and Canada)

Monday -- Friday 6:00 A.H. to 5:00 P.H.Pacific Time

Important Information About

Safety Instructions

The Important Safety Instructions and warnings in
these instructions are not meant to cover all possible

problems and conditions that can occur. Use common
sense and caution when installing, maintaining or

operating this or any other appliance.

• Always contact the Dacor Customer Service Team
about problems and conditions that you don't

understand,

Product data label
on back for drawer

front

Safety Symbols and Labels

DANGER

Immediate hazards that WILL result in seVere Personal

njury 0r death:

WARNING

HaZards 0i unsafe practices that COULD result in Severe

perSonal injury or death:

[ __CAUTION i

HaZards 0i uasafe practiceS that COULD resut nor
personal injury or property damage_ J

_8_D_ f

General Safety Precautions

To reduce risk of fire, electric shock, serious injury or death when using your appliance, follow basic precautions, including
the following:

WARNING

o

Use this appliance only for its intended use as
described in this manual. Use it only to warm food
and heat plates and utensils. It is not designed for
commercial, industrial or laboratory use.

Only model OWD24 is approved for use in outdoor
installations and near water (bathrooms). Do not
use, store or install warming drawer models other

than OWD24 near water, for example, near sinks,

swimming pools or in a wet basement.
Model OWD24, when installed as a towel warmer,

must be installed indoors and have the supplied wire
rack installed in the drawer bottom according to these

instructions.

• Do not install or operate a product that is
damaged, has a damaged power cord or plug, or is
malfunctioning in any manner. Return the appliance to

the nearest authorized service facility for examination,

repair or adjustment.

• Make sure that the appliance has been properly
installed and grounded by a qualified installer

according to the accompanying installation
instructions. Have the installer show you the location
of the electrical outlet so that you know where to
disconnect power to the appliance.

• Do not repair or replace any part of the warming
drawer unless specifically recommended in the
literature accompanying it. All other service should be
done by a qualified technician.

Use of accessory attachments not recommended by

the appliance manufacturer may cause injuries.

Before cleaning or performing any type of service,
make sure that the power plug is disconnected from

the electrical outlet and that the unit is cool.

DO NOT TOUCH ANY HOT SURFACES IN OR
ON THE WARMING DRAWER DURING OR
IMMEDIATELY AFTER USE. Use the handle instead.

After use, make sure these surfaces have had

sufficient time to cool before touching them. Heating
elements may be hot, even though they are dark in

color.

To avoid the possibility of fire or burns, do not allow

clothing, potholders, towels or rags to come into
contact with any part of the warming drawer during
and immediately after use. Do not wear loose or
hanging apparel while using the appliance.

WARNING

o

Clean the warming drawer thoroughly before
operating it for the first time.

To reduce the risk of fire in the warming drawer, do

not overcook food. Do not leave it unattended with
paper, plastic or other combustible materials inside.

if matenals inside the warming drawer should ignite,
keep the drawer closed and shut off the power at the

circuit breaker panel or fuse box.

• Exercise caution when opening the warming drawer.
Let hot air or steam escape before looking or reaching
into the warming drawer.

- Use only dry pot holders when removing food and

cookware from the warming drawer. Wet pot holders
can cause steam burns.

Do not put items like whole eggs, sealed containers

or closed glass jars in the drawer. They may explode
when heated, causing injury.

When the warming drawer is on in continuous mode

(_), it will remain on until turned off manually. Exercise

caution when operating the unit in continuous mode.

a

Do not place more than 50 pounds in the drawer.

e

Properly clean and maintain the unit regularly as
instructed in the use and care manual. Clean only

those parts listed, in the manner specified.

Do not use abrasive scrubbers or abrasive/caustic

cleaners or detergents on this appliance. They may

permanently damage the finishes. Do not use aerosol

cleaners, because they may be flammable or cause
corrosion of metal parts.

Make sure the warming drawer is used only by those
individuals who are able to operate it properly.

Do not tamper with the controls.

o

Never allow anyone, including children to sit, stand

or climb on any part of the appliance, including the
drawer. Doing so may cause tipping, damage, serious

injury or death.
Do not leave children unattended in the area around

the appliance. Do not allow children to operate it, play
with the controls, pull on the handle or touch other

parts. Do not store items of interest to children above

the warming drawer. Children could be burned or

injured while climbing on the appliance.