Cretors APT14C Service Manual

PT14-M-A/E-S
PROFITEER POPCORN MACHINE
SERVICE MANUAL
120 Volt,
Single Phase, 60 Hz
230 Volt,
Single Phase, 50 Hz
Included in this manual: *One Pop Option *Salt/Sugar Option
READ and UNDERSTAND these servicing, and safety
instructions before servicing this popcorn machine
April 2004
1
BEGIN SERIAL NO. 0404000
PT14-M-A/E-S
TABLE OF CONTENTS
I. Safety Alert Symbol……………………………………………………………………….6
II. Safety First…………………………………………………………………………………6
III. Introduction………………………………………………………………………………..6
IV. Specifications………………………………………………………………………………7
V. Purpose of Manual………………………………………………………………………..7
VI. Installation Instructions…………………………………………………………………..8
VII. Service Instructions……………………………………………………………………….8
VIII. Troubleshooting…………………………………………………………………………..12
April 2004
2
BEGIN SERIAL NO. 0404000
PT14-M-A/E-S
Part Number Configuration: Profiteer Antique Profiteer
PT 14 A 1 X - A X 3 X
Model PT - Profiteer XX - No Kettle
Kettle 14 - 14 Oz. Kettle
Voltage 60 Hz. (North America) A - 120/1/60 V 50 Hz. E - 230/1/50 V Japan F - 100/1/50 V
Corn X - Not Apply 1 - Salted Corn 2 - Sugar Corn 3 - Salt or Sugar Corn
Control X - Standard Control 1 - One Pop 2 - One Pop with Counter
Cabinet X - Stainless Steel Cabinet A - Red Antique Style Cabinet C - Custom Color Cabinet
Customer Doors X - No Customer Access 1- Wing Doors Customer Side
Base X - No Base 3- Matching Wagon Base
Features C - Custom Features CE - CE Mark ON 230/50 V S - Stainless Steel Z - Other
April 2004
3
BEGIN SERIAL NO. 0404000
PT14-M-A/E-S
I. SAFETY ALERT SYMBOL
The symbol shown below is used to call your attention to instructions concerning your personal safety and the safety of others. Watch for this symbol. It points out important safety precautions. It means ATTENTION! Become Alert! Your personal safety is at risk! Read the message that follows and be alert to the risk of personal injury or death.
II. SAFETY FIRST
The information in this manual is essential for the safe installation and service of your Cretors popcorn machine. The manual must be read and understood before installing and maintaining this equipment, or equivalent training must be provided.
"The employer shall instruct each employee in the recognition and avoidance of unsafe conditions and the regulations applicable to his work environment, to control and eliminate any hazards, or other exposure to illness or injury". Ref.: 29 CFR
1926.20 (b)(4)(a)(2)
It is understood that safety rules within individual companies vary. If a conflict exists between the safety procedures contained in this manual and the rules of a using company, the more stringent rule should take precedence.
III. INTRODUCTION
This manual is filled with time-saving and money-saving information regarding your Cretors popcorn machine. There is nothing, however, more important than the safety aids and warnings that are found throughout this document. The Safety Alert Symbol is used to identify topics of primary safety concern wherever they appear. A separate section has been included which deals exclusively with service and accident prevention.
If, after reviewing this manual, anything is unclear or technical problems are encountered, contact the distributor from whom you purchased your machine. For assistance and if there are any additional questions, feel free to contact our Customer Service Department at the address and/or phone number listed on the last page of this manual. Always have the model and serial number of your machine available to assist in obtaining the correct information.
April 2004
4
BEGIN SERIAL NO. 0404000
PT14-M-A/E-S
IV. SPECIFICATIONS
A. ELECTRICAL SPECIFICATIONS:
Profiteer Popcorn Machines are available in any of the following electrical configurations:
120 Volt, Single Phase, 60 Hz 230 Volt, Single Phase, 50 Hz
B. SIZE SPECIFICATIONS:
MODEL PT14C PROFITEER 14 OZ. ELECTRIC COUNTER MODEL Capacity: 14 oz. All-Steel Kettle, 280 one-ounce servings per hour Electrical: 1850 watts Dimensions: 22"D x 28"W x 34-1/2" H - 55.8 cm D x 71.2 cm W x 87.6 cm H Net Weight:
MODEL APT14C Capacity: Electrical: Dimensions: Net Weight:
MODEL APT14WB Capacity: Electrical: Dimensions: Net Weight:
MODEL APT14WBP
Capacity: Electrical: Dimensions: Net Weight:
MODEL MRDB
Dimensions: Net Weight:
MODEL MREB
Dimensions: Net Weight:
V. PURPOSE OF MANUAL
This instruction manual is intended to familiarize owners with the servicing and safety procedures associated with your Cretors popcorn machine.
85lbs. (35.6 kg.)
ANTIQUE PROFITEER 14 OZ ELECTRIC COUNER MODEL 14 oz. All-Steel Kettle, 280 one-ounce servings per hour 1850 watts 23-1/2"D x 29-1/2"W x 42-1/4" H - 59.7 cm D x 74.2 cm W x 07.3 cm H 92lbs. (41.4 kg.)
ANTIQUE PROFITEER 14 OZ. ELECTRIC MODELON WAGON BASE 14 oz. All-Steel Kettle, 280 one-ounce servings per hour 1850 watts 27-3/4"D x 41-3/4"W x 71-3/4" H - 70.5 cm D x 102.8 cm W x 181.6 cm H 142lbs. (63.9 kg.)
ANTIQUE PROFITEER 14 OZ. ELECTRIC MODEL ON WAGON BASE WITH PUMP 14 oz. All-Steel Kettle, 280 one-ounce servings per hour 2550 watts 27-3/4"D x 41-3/4"W x 71-3/4" H - 70.5 cm D x 102.8 cm W x 181.6 cm H 160lbs. (72.5 kg.)
MERCHANT DELUXE BASE Will accommodate both Merchants and Profiteers 22"D x 28"W x 29" H - - - - 55.8 cm D x 71.1 cm W x 73.6 cm H 93lbs. (41.8 kg.)
MERCHANT ECONOMY BASE Will accommodate both Merchant and Profiteers 22"D x 28"W x 29" H - - - - 55.8 cm D x 71.1 cm W x 73.6 cm H 57lbs. (25.6 kg.)
April 2004
5
BEGIN SERIAL NO. 0404000
+ 9 hidden pages