CMA Dish Machines EVA PARTS LIST
MODEL EVA
PARTS MANUAL
Rev.1.03
CMA DISHMACHINES
12700 KNOTT AVENUE
GARDEN GROVE, CALIFORNIA 92841
800-854-6417
FAX 714-895-2141
www.cmadishmachines.com
TABLE OF CONTENTS
MODEL EVA
1. PARTS MANUAL ..........................................................................................3
1.1. INITIAL PARTS KIT (P/N 01100.84)................................................................................................. 3
1.2. OPTIONAL SANI ALARM .................................................................................................................. 4
1.3. EXPLODED VIEW DRAWINGS........................................................................................................... 5
1.3.1. Cabinet Assembly ................................................................................................................... 5
1.3.2. Cabinet Assembly for Corner EVA......................................................................................... 6
1.3.3. Control Box Assembly ............................................................................................................ 7
1.3.4. Door Actuator Assembly......................................................................................................... 8
1.3.5. Door Actuator Assembly for Corner EVA .............................................................................. 9
1.3.6. Pump Assembly..................................................................................................................... 10
1.3.7. Plumbing System Assembly................................................................................................... 11
1.3.8. Spray System Assembly......................................................................................................... 12
1.3.9. Power Drain Assembly......................................................................................................... 13
1.3.10. Peristaltic Pump Assembly................................................................................................... 14
www.cmadishmachines.com
1. Parts Manual
1.1. Initial Parts Kit (P/N 01100.84)
P/N DESCRIPTION Qty
00104.82 50 RPM Drain Motor, 117V 60Hz 1
00105.82 Drain Spring (V) 1
00108.82 Drain Actuator Arm (V) 1
00109.82 Drain Actuator Shaft (V) 1
00115.85 Drain Screen 1
00121.60 Drain Diaphragm 1
00200.10 Pump Assembly, 110/220V 60Hz 1
00206.00 Pump Seal Kit 1
00308.20 Spray Arm End Plug, E-VA 1
00341.20 Spray Arm Bearing 1
00406.00 Control Box Light, .5” Diameter, Red 1
00407.83 Timer, 90 Sec, 8 Cam 1
00416.00 Peristaltic Pump Assembly, 120V/60Hz 1
00435.00 Squeeze Tube, 8”, Silicon 1
00470.10 Toggle Switch Rubber Boot 3
00471.10 Toggle Switch, Off/On, 20-Amp 1
00475.00 Toggle Switch, DPDT, 15-Amp, Delimer 1
00562.00 Door Limit Switch, Roller Action 1
00602.00 Door Spring 1
00631.00 Ice Cube Relay, 120V 1
00707.00 1/2" Water Solenoid Repair Kit, JE 1
00738.10 Solenoid Coil, JE, 120V ( ¾” & ½” ) 1
00935.00 1/4-20 x 1/4" Allen Screw 2
00938.82 1/2” Drain Bushing, Brass (V) 2
03202.00 Thermometer 1
03415.50 Flex-Tight Fitting 1
03470.00 Toggle Switch, Momentary, Screw Terminals 1
03623.00 1/2” Vacuum Breaker Repair Kit, Watts 1
00425.51 Chemical Tubing, Blue 50 ft
00425.53 Chemical Tubing, Red 50 ft
00425.54 Chemical Tubing, White 50 ft
Parts Manual
MODEL EVA PARTS MANUAL Rev. 1.03 Page
3
1.2. Optional Sani Alarm
Parts Manual
Part Number 12508.00
Exploded View
ITEM
NO.
NO.
REQ’D
1 3 00400.00 Conduit, 3/8” Sealtite 8 5 00931.00 Wire Tie, Small
2 1 00401.00 S.T. 3/8” Straight Connector 9 1 12510.00 Sanitizer Alarm Box Assembly
3 1 00402.00 S.T. 90 Degree 3/8” Connector 10 1 12511.00 Sanitizer Low Level Vacuum Switch
4 1 00406.00 Control Box Light, .5” Diameter, Red 11 1 12512.00 Sanitizer Alarm Buzzer, 120 Volts
5 1 00435.00 Squeeze Tube, 8” 12 4 40126.10 #10 x 3/4" Sheet metal Screw
6 1 00521.00 Wire, 18 Gauge, Orange, 6 ft. 13 4 40127.00 Wall Anchors
7 1 00531.00 Wire, 18 Gauge, White, 6 ft.
P/N DESCRIPTION
MODEL EVA PARTS MANUAL Rev. 1.03 Page
ITEM
NO.
NO.
REQ’D
14 1 00426.00 Y Hose Connector, 3/16”
DESCRIPTION
P/N
4
1.3. Exploded View Drawings
1.3.1. Cabinet Assembly
Parts Manual
ITEM
NO.
NO.
REQ’D
1 2 01506.30 Door 11 1 01577.20 Scrap Trap Drawer
2 1 01530.30 Wrapper 12 1 01573.30 Sani Mount/Drain Lid
3 1 00115.85 Drain Screen 13 1 01577.10 Scrap Trap Body
4 18 00906.00 1/4-20 x 1/2" Hex head Bolt 14 2 01505.32 Tray Track, Inline
5 60 00924.00 1/4" SS Washer 15 4 01577.25 Scrap Trap Lid
6 40 00912.00 1/4-20 Nylon Lock Nut 16 4 00636.10 EZ Glide Door Guide, Plastic
7 6 00940.50 10-32 x 3/8" Truss Head Screw 17 1 01502.30 Pan / Stand
8 1 00120.50 Power Drain Cover 18 16 00905.00 1/4-20 x 1/2" Truss Head Bolt
9 4 01310.00 Bullet Foot
10 4 01554.30 Door Guide, SS
MODEL EVA PARTS MANUAL Rev. 1.03 Page
P/N DESCRIPTION
ITEM
NO.
NO.
REQ’D
DESCRIPTION
P/N
5
Loading...