CMA Dish Machines EST Parts List
MODELS
EST-FL
PARTS MANUAL
Rev 1.00A
CMA DISHMACHINES
12700 KNOTT STREET
GARDEN GROVE, CALIFORNIA 92841
800-854-6417
FAX 714-895-2141
www.cmadishmachines.com
Buy Parts
TABLE OF CONTENTS
MODEL EST
1. PARTS MANUAL .......................................................................................... 3
1.1. INITIAL PARTS KIT (P/N 01100.84) ................................................................................................. 3
1.2. OPTIONAL SANI ALARM .................................................................................................................. 4
1.3. EXPLODED VIEW DRAWINGS ........................................................................................................... 5
1.3.1. Cabinet Assembly ................................................................................................................... 5
1.3.1. Door Assembly ........................................................................................................................ 6
1.3.2. Control Box Assembly ............................................................................................................ 7
1.3.3. Pump Assembly ....................................................................................................................... 8
1.3.4. Plumbing System Assembly ..................................................................................................... 9
1.3.5. Spray System Assembly ........................................................................................................... 9
1.3.6. Power Drain Assembly ......................................................................................................... 11
1.3.7. Power Drain Retrofit Kit p/n 00104.95 ................................................................................ 12
1.3.8. Peristaltic Pump Assembly ................................................................................................... 13
1.3.9. Sustainer Heater (Optional) ................................................................................................. 14
www.cmadishmachines.com
Buy Parts
1. Parts Manual
1.1. Initial Parts Kit (P/N 01100.84)
P/N DESCRIPTION Qty
00104.50 Drain Motor, 120V 60Hz 1
00108.83 Drain Actuator Arm (V) 1
00109.60 Drain Actuator Shaft (V) 1
00115.87 Drain Screen 1
00120.02 Thermometer 1
00121.60 Drain Diaphragm 1
00200.10 Pump Assembly, 110/220V 60Hz 1
00206.30 Pump Seal Kit 1
00304.06 Spray Arm 1
00308.50 Spray Arm End Plug, SS 1
00341.00 Spray Arm Bearing 1
00406.00 Control Box Light, .5” Diameter, Red 1
00407.83 Timer, 90 Sec, 8 Cam 1
00416.00 Peristaltic Pump Assembly, 120V/60Hz 1
00425.51 Chemical Tubing Blue 1
00425.53 Chemical Tubing Red 1
00425.54 Chemical Tubing White 1
00470.10 Toggle Switch Rubber Boot 3
00471.10 Toggle Switch, Off/On, 20-Amp 1
00475.70 Toggle Switch, DPDT, 15-Amp, Delimer 1
00631.00 Ice Cube Relay, 120V 1
00707.00 1/2" Water Solenoid Repair Kit, JE 1
00738.10 Solenoid Coil, JE, 120V ( ¾” & ½” ) 1
00938.82 1/2” Drain Bushing, Brass (V) 2
00966.10 10-32X1/4 Hexhead SS Bolt 1
02257. 00 Squeeze Tube Norprene 1
03415.45 Flex-Tight Fitting 1
03470.00 Toggle Switch, Momentary, Screw Terminals 1
03623.00 1/2” Vacuum Breaker Repair Kit, Watts 1
04103.14 Drain Valve Spring 1
Parts Manual
MODEL EST-FL PARTS MANUAL Rev. 1.00A Page
Buy Parts
3
1.2. Optional Sani Alarm
Part Number 12508.00
Parts Manual
Exploded View
ITEM
NO.
NO.
REQ’D
1 3 00400.00 Conduit, 3/8” Sealtite 8 5 00931.00 Wire Tie, Small
2 1 00401.00 S.T. 3/8” Straight Connector 9 1 12510.00 Sanitizer Alarm Box Assembly
3 1 00402.00 S.T. 90 Degree 3/8” Connector 10 1 12511.50 Sanitizer Low Level Vacuum Switch
4 1 00406.00 Control Box Light, .5” Diameter, Red 11 1 12512.00 Sanitizer Alarm Buzzer, 120 Volts
5 1 00435.00 Squeeze Tube, 8” 12 4 40126.10 #10 x 3/4" Sheet metal Screw
6 1 00521.00 Wire, 18 Gauge, Orange, 6 ft. 13 4 40127.00 Wall Anchors
7 1 00531.00 Wire, 18 Gauge, White, 6 ft. 14 1 00426.00 Y Hose Connector, 3/16”
P/N DESCRIPTI
MODEL EST-FL PARTS MANUAL Rev. 1.00A Page
ON
ITEM
NO.
NO.
REQ’D
Buy Parts
P/N
DESCRIPTION
4
1.3. Exploded View Drawings
1.3.1. Cabinet Assembly
Parts Manual
ITEM
NO.
NO.
REQ’D
1 1
2 1
3 1 00115.87 Drain Screen 14 1 1502.90 EST Pan
4 18 00906.00 1/4-20 x 1/2" Hex head Bolt 15 1 01579.50 EVA Splash Card
5 1 01505.51 EST Front Loader LH Tray Track
6 1 01505.50 EST Front Loader RH Tray Track 17 1 01502.95 EST Stand
7 6 00940.50 10-32 x 3/8" Truss Head Screw 18 4 01310.00 Bullet Foot
8 1 00120.40 EVA Power Drain Cover 19 1 00120.02 Thermometer (Bi Metal)
9 4 01145.00 Leg Ass'y 10" w\Adjustable Socket
10 4 00914.00 1/4-20 x 3/4" Hex Head Bolt 21 1
11 1 01577.21 S/S Scrap Trap Drawer
MODEL EST-FL PARTS MANUAL Rev. 1.00A Page
P/N DESCRIPTI
01512.10 EST Front Loader Wrapper Panel 12 1 01573.30 Sani Mount/Drain Lid
01512.00 EST Front Loader Wrapper 13 1 01577.10 Scrap Trap Body
ON
ITEM
NO.
16
20 1
22 2
23 1
NO.
REQ’D
4 01572.10 SS Leg
DESCRIPTION
P/N
0556.10 Reed Switch - ISI
14558.30 EST Front Loader Body Magnet Holder
00557.80 Door Magnet (L-1X/CMA-180UC/GL-X)
14506.30 EST Front Loader Gasket Bracket
Buy Parts
5
Loading...